Mercury 25 (4-STROKE) (0G590000 THRU 0G760299) Outboard Motor Parts Diagram & Catalog – Free PDF Download

by JLM Marine 30 Apr 2025 0 Comments

Mercury 25 (4-STROKE) Outboard Motor Parts Diagram & Catalog – Free PDF Download

Accessories

Below is the parts list for Mercury 25 (4-STROKE) Accessories:

Position No.	Part Name	OEM Number	Supersedes
-	OIL (CASE)	92-828000A12
-	SENDER KIT, Oil Pressure	8M0068785	828019A 1
-	SENDER KIT, Power Trim Gauge	822573A12	822573A11
-	POWER TRIM KIT	822344A13	822344A 8
-	MANUAL TILT ASSIST KIT	828533A2
-	BRACKET ASSEMBLY, Steering (W/O CARRYING HANDLE)	816667A2
-	EXTENSION KIT, (22.5) Comment: (BLACK)	824072A5
-	EXTENSION KIT, (22.5) Comment: (GRAY)	824072A6
-	TILLER HANDLE KIT Comment: (BLACK)	821455A20	821455A 6 (BLACK)
-	TILLER HANDLE KIT Comment: (GRAY)	821455A7
-	LINE ASSEMBLY, Fuel (8 Feet) Comment: WITH QUICK DISCONNECT	32-877680Q8
-	LINE ASSEMBLY, Fuel (12 Feet) Comment: WITH QUICK DISCONNECT	32-877680Q12	32-858620Q12, 32-858620A12, 32-827927A12 WITH QUICK DISCONNECT
-	LINE ASSEMBLY, Fuel (8 Feet) Comment: WITH QUICK DISCONNECT ENGINE END ONLY	32-877681Q8
-	LINE ASSEMBLY, Fuel (12 Feet) Comment: WITH QUICK DISCONNECT ENGINE END ONLY	32-877681Q12	32-804792Q12, 32-804792Q, 32-858621Q12, 32-858621A12, 32-17146A12 WITH QUICK DISCONNECT ENGINE END ONLY
-	LINE ASSEMBLY, Fuel (12 Feet) Comment: NO FIITINGS	32-877683Q12	32-858623Q12, 32-858623A12, 32-822379A12, 32-819380A12, FA599752, FS409752, 32-819380A 3, F216752, FA409752, F289752, FA178752, FA216752, FA284752, FA289752, FS409952 NO FIITINGS

Adaptor Plate

Below is the parts list for Mercury 25 (4-STROKE) Adaptor Plate:

Position No.	Part Name	OEM Number	Supersedes
1	DIPSTICK	8M0162935
2	DIPSTICK TUBE	825989003	825989 2
3	SEAL, Lower Cowl	8238052
4	HEAT SHIELD	8289151
5	PIN, Dowel	17-23784
6	FITTING, Elbow - 90 Degree (.125-27)	22-629101
7	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
8	SEAL, Oil	26-828932	26-821756
9	PLUG, Pipe	22-384073
10	GROMMET	25-822408001	25-822408
11	ADAPTOR PLATE	825228A25	825228 5
12	GASKET	27-8M0213113
13	O-RING	25-845746
14	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
15	DEFLECTOR, Oil	856592
16	BODY, Oil Pressure Relief	8M0210772
17	COTTER PIN	18-45882
18	PLUNGER	8252151
19	SPRING	24-825216
20	PLATE, Oil Pickup-Top	893765	854789
21	HOSE, Oil Pickup	32-854793
22	BAFFLE	893700	854791 1
23	CLAMP	54-855228	54-888988014

Bottom Cowl

Below is the parts list for Mercury 25 (4-STROKE) Bottom Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	BOTTOM COWL Comment: (BLACK) SHORT-PORT	4020-852554T1
1	BOTTOM COWL Comment: (GRAY) SHORT-PORT	4020-852554T2
1	BOTTOM COWL Comment: (BLACK) LONG-PORT	4020-826277T1
1	BOTTOM COWL Comment: (GRAY) LONG-PORT	4020-826277T2
2	BOTTOM COWL Comment: (BLACK) SHORT-STBD.	4020-852555T5
2	BOTTOM COWL Comment: (GRAY) SHORT-STBD.	4020-852555T2
2	BOTTOM COWL Comment: (BLACK) LONG-STBD.	4020-826278T7
2	BOTTOM COWL Comment: (GRAY) LONG-STBD.	4020-826278T4
3	SCREW, (M6 x 30)	10-82684430
4	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
5	SEAL	825238002	825238 1
6	WASHER	12-855576
7	GASKET	27-855627
8	SCREW, (M6 x 60)	10-82684460
9	FITTING	22-827948
10	BOOT	826273001	826273
11	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
12	LEVER, Cowl Latch Comment: (BLACK)	825782F1
12	LEVER, Cowl Latch Comment: (GRAY)	825782F2
13	BUSHING	23-812707	23-71984, 23-F286818, 23-F286828, F480818
14	WASHER, Wave	13-12134
15	LATCH HOOK	893766	825783
16	SCREW, (M6 x 16)	10-4006731
17	GROMMET Comment: (NON POWER TRIM)	25-8M0179867
17	GROMMET Comment: (SPLIT - POWER TRIM)	25-19565002
18	PLUG Comment: (NON POWER TRIM)	812830T01	812830 1 (NON POWER TRIM)
19	RETAINER Comment: (NON POWER TRIM)	8M0032848	812443 1 (NON POWER TRIM)
20	SWITCH Comment: (POWER TRIM)	87-8M0042301	87-896620, 87-856990, 87-850691, 87-18286A40 (POWER TRIM)

Camshaft/Oil Pump

Below is the parts list for Mercury 25 (4-STROKE) Camshaft/Oil Pump:

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M10 x 40)	10-82761140
2	WASHER	12-4002319
3	BELT	8M0151040
4	GEAR, Driven	8331043
5	PIN, Dowel	17-825956
6	CAMSHAFT Comment: (ELECTRIC)	2419-830275T1
6	CAMSHAFT Comment: (MANUAL)	406-853894A2
7	PIN	17-826149	17-893566
8	PUMP ASSEMBLY, Oil	852388T1
9	O-RING	25-826152
10	O-RING	25-826154
11	O-RING	25-826153
12	SCREW, (M6 x 35)	10-8M0205943
-	GASKET SET	27-830270A02	27-830270A98
-	CYLINDER HEAD Comment: (ELECTRIC)	830271T3
-	CYLINDER HEAD Comment: (MANUAL)	830271T4

Carburetor

Below is the parts list for Mercury 25 (4-STROKE) Carburetor:

Position No.	Part Name	OEM Number	Supersedes
1	CARBURETOR	3329-883314T03	3329-830276T 7, 3329-883314T 1
2	SCREW	10-854246
3	PLATE	854245
4	NOT SOLD SEPARATE, Gasket	NSS
5	ENRICHENER	854254T	803918T, 854254
6	NOT SOLD SEPARATE, O-Ring	NSS
7	PLATE	854255
8	SCREW	10-8542461
9	SPRING	24-854249
10	JET, Pilot	50,855406
11	PLUG, Rubber	19-854248
12	JET, Main	110,8554061
13	VALVE, Float	854247
14	FLOAT	854253
15	NOT SOLD SEPARATE, Float Pin	NSS
16	NOT SOLD SEPARATE, Gasket	NSS
17	FLOAT BOWL	854252
18	SCREW	10-8542463
19	SCREW, Drain	10-8542462
20	NOT SOLD SEPARATE, Washer	NSS
21	NOT SOLD SEPARATE, Spring	NSS
22	PLUNGER	854251
23	NOT SOLD SEPARATE, Cap-Rubber	NSS
24	COLLAR	23-854244
25	MAIN NOZZLE	854250
26	JET (PO)	8554062
27	NOT SOLD SEPARATE, O-Ring	NSS
-	REPAIR KIT, Carburetor	854256

Clamp Bracket

Below is the parts list for Mercury 25 (4-STROKE) Clamp Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	CLAMP BRACKET Comment: (BLACK) PORT	3411-821773T1
1	CLAMP BRACKET Comment: (GRAY) PORT	3411-821773A2
2	CLAMP BRACKET Comment: (BLACK) STARBOARD	3412-821774T8
2	CLAMP BRACKET Comment: (GRAY) STARBOARD	3412-821774T9
3	THUMB SCREW ASSEMBLY Comment: MANUAL	10-818883A1
4	NOT SOLD SEPARATE, Handle Comment: MANUAL	NSS
5	NOT SOLD SEPARATE, Rivet Comment: MANUAL	NSS
6	WASHER Comment: MANUAL	12-818884
7	SHOULDER SCREW, Hex Comment: MANUAL	10-768042
8	CAP	822401
9	PIN, (.125 x 0.75 Inches)	17-25319
10	PIN	17-8224001
11	BUSHING	23-823589
12	ANODE	97-8252711
13	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
14	SCREW, (M6 x 25)	10-8M0204707
15	NUT, (.500-20)	11-91962
16	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel	12-8M0204648
17	SCREW, (.500-20 x 4.00)	10-814259
18	DECAL, Tilt Lock	37-830253	37-814743 3, 37-826546
19	TRIM, HYDRAULIC ASSIST Comment: GAS ASSIST TRIM	828533A1
20	CABLE ASSEMBLY Comment: GAS ASSIST TRIM	88238A11
21	LEVER, Tilt Comment: GAS ASSIST TRIM	828924
22	TILT KNOB Comment: GAS ASSIST TRIM	8M0007469	19621 GAS ASSIST TRIM
23	ARM, Lever Comment: GAS ASSIST TRIM	828930
24	WAVE WASHER Comment: GAS ASSIST TRIM	13-31030
25	PIN, (.125 x 0.75 Inches) Comment: GAS ASSIST TRIM	17-25319
26	LINK Comment: GAS ASSIST TRIM	8289961
27	NUT, Comment: GAS ASSIST TRIM	10-32,11-8M0204718
28	PIN, Anchor (14 mm) Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	17-822481001	17-822481 GAS ASSIST TRIM & POWER TRIM MOUNTING
29	BUSHING Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	23-822482
30	BUSHING Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	23-822484
31	WASHER Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	12-825190
32	NUT, (M14) Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	11-826712	11-40134 14 GAS ASSIST TRIM & POWER TRIM MOUNTING
33	SCREW, (M10 x 40) Stainless Steel Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	10-4009040
34	WASHER Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	12-4002319
35	NUT, (M10) Comment: GAS ASSIST TRIM & POWER TRIM MOUNTING	11-40140
36	PIN Comment: HANDLE-NON POWER TRIM	17-853923A1
37	SPRING Comment: HANDLE-NON POWER TRIM	24-821461
38	NOT SOLD SEPARATE, Decal-Warning	NSS

Clamp Bracket, Remote Control

Below is the parts list for Mercury 25 (4-STROKE) Clamp Bracket, Remote Control:

Position No.	Part Name	OEM Number	Supersedes
1	CLAMP BRACKET Comment: (BLACK) PORT	3411-821773T1
1	CLAMP BRACKET Comment: (GRAY) PORT	3411-821773A2
2	CLAMP BRACKET Comment: (BLACK) STARBOARD	3412-821774T8
2	CLAMP BRACKET Comment: (GRAY) STARBOARD	3412-821774T9
3	CAP	822401
4	PIN, (.125 x 0.75 Inches)	17-25319
5	BUSHING	23-823589
6	PIN	17-8224001
7	NOT SOLD SEPARATE, Decal-Shallow Water	NSS
8	DECAL, Tilt Lock	37-830253	37-814743 3, 37-826546
9	NUT, (M10)	11-40140
10	WASHER	12-4002319
11	ANODE	97-8252711
12	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
13	SCREW, (M6 x 25)	10-8M0204707
14	STUD, (M10 x 277)	16-8M0034459	16-823656
15	SPACER	23-824952
16	NUT, (.500-20)	11-91962
17	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel	12-8M0204648
18	SCREW, (.500-20 x 4.00)	10-814259
19	NUT, (M10)	11-40140
20	WASHER	12-4002319
21	PIN ASSEMBLY, Tilt Lock	17-8M0026103	17-821457A 1
22	SPRING	24-821461
23	LEVER	822409
24	PIN, (.125 x 0.75 Inches)	17-25319
25	BUSHING (PLASTIC)	23-824858
26	ROD, Shallow Water Drive	878580	822414 1
27	BUSHING (PLASTIC)	23-824858
28	BUSHING	23-823812
29	ARM	822411
30	LINK ROD	878563	822412 2
31	SPRING	24-832085A1

Crankshaft, Pistons and Connecting Rods

Below is the parts list for Mercury 25 (4-STROKE) Crankshaft, Pistons and Connecting Rods:

Position No.	Part Name	OEM Number	Supersedes
1	CRANKSHAFT	2400-8M0084517
2	KEY	28-893761
3	KEY, Woodruff	28-91800
4	SEAL	8M0151047
5	SEAL	8M0151048
6	CONNECTING ROD	600-893530T01	662-856065T 1
7	BOLT	10-8M0049884
8	BEARING, Brown	23-893630	23-825021
8	BEARING, Black	23-893630001	23-825021 1
8	BEARING, Blue	23-893630002	23-825021 2
9	PISTON Comment: (STANDARD)	700-893524T08	700-893524T07, 713-856064A 1 (STANDARD)
9	PISTON Comment: (.25 O/S) PISTON ONLY	700-893524T01	713-856064 2 (.25 O/S) PISTON ONLY
9	PISTON Comment: (.50 O/S) PISTON ONLY	700-893524T02	713-856064 3 (.50 O/S) PISTON ONLY
10	RING SET, Piston (TOP) Comment: (STANDARD)	39-893525A01	39-833099A 1 (STANDARD)
10	RING, Piston (TOP) Comment: (.25MM O/S)	39-893525A02	39-833100T 2 (.25MM O/S)
10	RING, Piston (TOP) Comment: (.50MM O/S)	39-893525A03	39-833100T 3 (.50MM O/S)
11	NOT SOLD SEPARATE, Piston Ring-Second Comment: (STANDARD)	NSS
11	RING, Piston (2 ND.) Comment: (.25MM O/S)	39-893525A02	39-833100T 2 (.25MM O/S)
11	RING, Piston (2 ND.) Comment: (.50MM O/S)	39-893525A03	39-833100T 3 (.50MM O/S)
12	RING, Oil	39-893950	39-893527, 39-833101 1
13	PIN, Piston	41-893863	41-825016
14	RETAINER	40-825017	40-825017F
15	BALANCE ROD	652-831876A1
16	PISTON	701-831875T2
17	NUT	11-893789	11-81773M
18	GEAR, Drive	833102T	833102
-	POWERHEAD ASSEMBLY	61-854236T00	61-854236T98, 61-854236A98
-	GASKET SET	27-830270A02	27-830270A98

Cylinder Block

Below is the parts list for Mercury 25 (4-STROKE) Cylinder Block:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER BLOCK	2806-830267T3
2	PIN, Dowel	17-825010
3	PLUG	22-479452
4	PLUG, Pipe (1/2-14)	22-384073
5	PIPE PLUG (3/4-14)	22-416223
6	BEARING, Brown	23-893631	23-825024
6	BEARING, Black	23-893631001	23-825024 1
6	BEARING, Blue	23-893631002	23-825024 2
7	NIPPLE, (M20)	822625
8	SCREW, (M8 x 82)	10-82506182
9	SCREW, (M6 x 35)	10-8M0205943
10	GASKET	27-8M0069692	27-825231 2
11	FILTER, Oil	35-8M0162830
12	GASKET	27-830298
13	COVER, Exhaust	830299T2
14	DECAL, EPA Label Information Comment: (1998)	37-855577A24	37-855577 24 (1998)
15	PLUG	22-479452
16	THERMOSTAT	855676003	825212001, 825212, 855676
17	GASKET	27-8M0177107
18	COVER	8M0188835
19	SCREW, (M6 x 35)	10-8M0205943
20	ELBOW	22-996642
21	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
22	TUBING, (28.00 Inches Bulk)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80
23	LIFTING EYE	893697	852560 1
24	SCREW, (M8 x 35)	10-82127335
25	FILTER, Breather	35-8548091
26	NOT SOLD SEPARATE, Plug-Serial Number	NSS
27	GASKET, Breather Cover	27-854780
28	BREATHER COVER	832734A2
29	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
30	HOSE	32-77653A6
31	O-RING	25-854722
32	COVER	8556692
33	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
34	J CLIP	54-8M0024808
-	POWERHEAD ASSEMBLY	61-854236T00	61-854236T98, 61-854236A98
-	GASKET SET	27-830270A02	27-830270A98

Cylinder Head

Below is the parts list for Mercury 25 (4-STROKE) Cylinder Head:

Position No.	Part Name	OEM Number	Supersedes
-	CYLINDER HEAD Comment: (ELECTRIC)	830271T3
-	CYLINDER HEAD Comment: (MANUAL)	830271T4
1	CYLINDER HEAD	830271T2
2	GUIDE	8M0054272	825037001, 825037
3	CIRCLIP	53-825038	825722
4	ANODE	826887M
5	GROMMET	25-825040
6	COVER	826888M
7	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
8	BOLT	10-827607
9	GASKET	27-827610
10	SEAL, Oil	26-825048
11	O-RING	25-833103
12	COVER	830272A1
13	NOT SOLD SEPARATE, Decal-Servicing Referral	NSS
14	NOT SOLD SEPARATE, Decal-Engine Oil/Valve Clearance	NSS
15	GASKET	27-8M0049885	27-830270
16	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
17	SCREW, (M6 x 25)	10-893745025
18	SCREW, (M9 x 95)	10-82503395
19	PIN, Dowel	17-825010
20	PLUG	859578A1
21	O-RING	25-8M0052669	25-825492
-	POWERHEAD ASSEMBLY	61-854236T00	61-854236T98, 61-854236A98
-	GASKET SET	27-830270A02	27-830270A98

Driveshaft Housing

Below is the parts list for Mercury 25 (4-STROKE) Driveshaft Housing:

Position No.	Part Name	OEM Number	Supersedes
1	SEAL, Water Tube	42941001
2	HOUSING ASSEMBLY, Driveshaft Comment: (BLACK) SHORT	1501-850168T3
2	HOUSING ASSEMBLY, Driveshaft Comment: (GRAY) SHORT	1501-850168T4
2	HOUSING ASSEMBLY, Driveshaft Comment: (BLACK) LONG	3532-825218T5
2	HOUSING ASSEMBLY, Driveshaft Comment: (GRAY) LONG	3532-825218T6
3	NOT SOLD SEPARATE, Exhaust Pipe	NSS
4	SCREW, (M8 x 110) Stainless Steel	10-824459110
5	SCREW, (M8 x 45)	10-88960845
6	PLUG, Drain	8288181
7	GASKET	27-8M0204692
8	BUMPER	826276
9	GROMMET Comment: (LONG)	8M0151042
10	STUD, (M10 x 50)	16-823984
11	WASHER, (.406 x .750 x .104)	12-8M0214963
12	NUT, (M10)	11-40140
13	TUBE, Water Comment: (SHORT)	32-897970A01	32-850169002, 32-850169 (SHORT)
13	TUBE, Water Comment: (LONG)	32-897971A01	32-888591001, 32-888591, 32-825250 1 (LONG)
14	GUIDE	54-828529
15	BUMPER (USE WHERE APPLICABLE) Comment: (LONG)	8M0043364	828706 (LONG)
-	GASKET SET	27-830270A02	27-830270A98

Electrical Components

Below is the parts list for Mercury 25 (4-STROKE) Electrical Components:

Position No.	Part Name	OEM Number	Supersedes
1	SOLENOID ASSEMBLY	89-8M0185146
2	BUSHING	23-8M0214955
3	GROMMET	25-818967
4	NUT, Brass Comment: (ELECTRIC)	8-32,11-26419
5	NUT, (.250-20) Brass	11-94330
6	CABLE ASSEMBLY, Battery - Positive	84-88439A9
7	BOOT, Insulator - Black	85-79695T
8	CABLE ASSEMBLY	84-93388A14
9	CABLE ASSEMBLY, Battery - Negative	84-88439A4
10	STARTER MOTOR ASSEMBLY	50-893886T	50-888151T, 50-859169T, 50-830308T, 50-830308
11	SCREW, (M8 x 45) Stainless Steel Comment: (ELECTRIC)	10-40011153
11	SCREW, (M8 x 25) Stainless Steel Comment: (MANUAL)	10-40011149
12	SCREW, (M6 x 25) Comment: (ELECTRIC)	10-82684425
12	SCREW, (M6 x 16) Comment: (MANUAL)	10-8248324
13	J CLIP	54-54457
14	PRESSURE SWITCH	87-8M0098207	87-8M0070107, 87-828040 1
15	SENSOR	8M0082988	8M0030022, 828358 2
16	SCREW, (M5 x 16) Stainless Steel	10-40011107
17	BRACKET Comment: (ELECTRIC - DESIGN II)	856040
18	MOUNT Comment: (ELECTRIC - DESIGN II)	856836001	856836, 856039 (ELECTRIC - DESIGN II)
19	RETAINER Comment: (ELECTRIC - DESIGN II)	92753
20	SCREW, (M6 x 25)	10-82129125
21	PLATE	855670
22	BUSHING	23-822003
23	GROMMET	25-8M0190980
24	ECM, Engine Control Module	87843304S	878433A 4
25	NOT SOLD SEPARATE, Decal-Caution-Start in Gear	NSS
26	BUSHING	23-8539201
27	SCREW, (M6 x 45)	10-82129145
28	SPARK PLUG, NGK-DPR6EA-9	33-827858Q	33-827858
29	NOT SOLD SEPARATE, Decal-Coil Identification	NSS
30	COIL ASSEMBLY, Ignition Comment: (Includes Leads and Boots)	339-859738T1
31	GROMMET	25-82069M
32	HIGH TENSION LEAD	84-825102A1
33	SCREW, (M6 x 30)	10-82684430
34	J CLIP	54-8M0024808
35	HARNESS ASSEMBLY, Engine Wiring Comment: (MANUAL)	84-850167A2
35	HARNESS ASSEMBLY, Engine Wiring Comment: (ELECTRIC)	84-830279A4
36	FUSE, Yellow - 20 Ampere	88-812619	88-860608
37	HARNESS ASSEMBLY, Auxiliary	84-855225A2
38	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
39	TIE STRAP, (4.00 Inches) Comment: (MANUAL)	56762
40	HORN DRIVER ASSEMBLY Comment: (MANUAL)	17461A7
41	REGULATOR ASSEMBLY, Voltage Comment: ELECTRIC	883071A1
42	SCREW, (M6 x 40) Comment: ELECTRIC	10-8248329
43	SENSOR ASSEMBLY, Temperature	13536A12
44	RETAINER	8533071
45	SCREW, (M6 x 13) Stainless Steel	10-40011126
46	J CLIP	54-8M0024808
47	CLAMP, Connector Comment: (ELECTRIC - DESIGN I)	8261151
-	POWERHEAD ASSEMBLY	61-854236T00	61-854236T98, 61-854236A98

Flywheel

Below is the parts list for Mercury 25 (4-STROKE) Flywheel:

Position No.	Part Name	OEM Number	Supersedes
1	FLYWHEEL COVER Comment: ELECTRIC	859284T2
2	SCREW, (M6 x 25) Comment: ELECTRIC	10-8248326
3	FLYWHEEL Comment: ELECTRIC	284-832010T32	284-832010T31, 284-832010T26, 284-832010T14, 284-832010A 8 ELECTRIC
4	FLYWHEEL Comment: MANUAL	284-832010T27	284-832010T16, 284-832010A 4 MANUAL
5	NOT SOLD SEPARATE, Decal-Warning-Spinning Flywheel	NSS
6	NOT SOLD SEPARATE, Decal-Timing Marks	NSS
7	NOT SOLD SEPARATE, Decal-Warning-Neutral	NSS
8	NUT	11-893789	11-81773M
9	WASHER	12-893762	12-84436M
10	SCREW, (M5 x 25) Comment: MANUAL	10-4007325
11	STATOR Comment: MANUAL	398-852386T8
10	SCREW, (M5 x 30) Comment: ELECTRIC	10-4013930
11	STATOR Comment: ELECTRIC	398-852387T9
12	LOAD RING	834838

Fuel Pump

Below is the parts list for Mercury 25 (4-STROKE) Fuel Pump:

Position No.	Part Name	OEM Number	Supersedes
1	FILTER, Fuel	35-816296Q03	35-816296Q, 35-816296, 35-16494
2	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
3	HOSE, (57.00 Inches Bulk) (16 IN.)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
4	HOSE, (57.00 Inches Bulk) (19 IN.)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
5	CONNECTOR ASSEMBLY, Fuel	22-8M0148585
-	O-RING, Fuel Connector	25-16524
6	PUMP ASSEMBLY, Fuel	826398T3
7	SCREW, (M5 x 35)	10-809564
8	COVER	809565
9	DIAPHRAGM	8095611
10	SCREW, (M3 x 5)	10-41889M
11	NUT	11-82537M
12	CHECK VALVE	21-41888M
13	DIAPHRAGM	8095612
14	PIN	17-8095661
15	SPRING	24-809562
16	NUT, (M5)	11-82388M
17	SPRING	24-8095621
18	PLUNGER	8095631
19	O-RING	25-8M0052669	25-825492
20	SCREW, (M6 x 30)	10-82684430
21	PLUG	19-854310	806899
22	HOSE	32-854304
23	CONDUIT, (.500 Inside Diameter x 3.00 Feet Bulk) Comment: (ELECTRIC)	32-828547T1
-	GASKET SET	27-830270A02	27-830270A98

Gear Housing, Driveshaft - 2.41:1 Gear Ratio

Below is the parts list for Mercury 25 (4-STROKE) Gear Housing, Driveshaft - 2.41:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY Comment: (BLACK) SHORT	1682-821306T30	1682-821306A30 (BLACK) SHORT
-	GEAR HOUSING ASSEMBLY Comment: (GRAY) SHORT	1682-821306T31	1682-821306A31 (GRAY) SHORT
-	GEAR HOUSING ASSEMBLY Comment: (BLACK) LONG	1682-821306T32	1682-821306A32, 1682-821306T33, 1682-821306A33 (BLACK) LONG
-	GEAR HOUSING ASSEMBLY Comment: (GRAY) LONG	1682-821306T32	1682-821306A32, 1682-821306T33, 1682-821306A33 (GRAY) LONG
1	GEAR HOUSING ASSEMBLY Comment: (BLACK) BASIC	1682-821306T12	1682-821306A12 (BLACK) BASIC
1	GEAR HOUSING ASSEMBLY Comment: (GRAY) BASIC	1682-821306T13	1682-821306A13 (GRAY) BASIC
2	SEAL/PLATE KIT	818226A1
3	NOT SOLD SEPARATE, Plate	NSS
4	SCREW KIT, (.375-16 x .250)	10-79953Q04
5	WASHER, Fiber	12-191833
6	FITTING KIT, Magnetic, Plug Fill/Drain	22-8M0058389	22-67892A06
7	WASHER, Fiber	12-191833
8	NUT	11-828490
9	NOT SOLD SEPARATE, Pinion Gear (Part of 43-833000A2)(12 Teeth)	NSS
10	BEARING ASSEMBLY	31-821321A2
11	NOT SOLD SEPARATE, Cup	NSS
12	SCREW, (M6 x 16)	10-8248324
13	HOUSING ASSEMBLY, Water Pump Upper	46-821351A3
14	SEAL Comment: (SHORT - 1-3/4)	8M0204658
14	SEAL Comment: (LONG - 2-1/4)	8235471
15	WASHER	12-866451
16	KEY	28-8M0214993
17	WASHER	12-866451
18	GASKET, Upper Water Pump	27-822189
19	GASKET, Lower Water Pump	27-8M0214956
20	FACE PLATE	8213542
21	IMPELLER	47-8M0204712
22	BASE ASSEMBLY, Water Pump	46-821307A2
23	SEAL	26-821309
24	SEAL	26-821310
25	O-RING, (1.421 x .139)	25-821308
26	DRIVESHAFT Comment: (SHORT)	45-850177A1
26	DRIVESHAFT Comment: (LONG)	45-832987A1
27	BEARING, Ball	30-821311
28	TIE STRAP	823548T	823548, 54-856608
29	BOOT	822158
30	RETAINER	821827
31	O-RING, (1.609 x .139)	25-26855
32	O-RING, (.239 x .174)	25-85594
33	WASHER	12-814803	12-93853
34	SHIFT SHAFT Comment: (SHORT)	827865A2
34	SHIFT SHAFT Comment: (LONG)	827865A1
35	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
36	PIN, (.078 x .437)	17-85593
37	CAM, Shift	8213161
38	PIN, (.125 x .625)	17-822369
-	REPAIR KIT, Water Pump	821354A2
-	SEAL KIT	823547A2

Gear Housing, Propeller Shaft - 2.41:1 Gear Ratio

Below is the parts list for Mercury 25 (4-STROKE) Gear Housing, Propeller Shaft - 2.41:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY Comment: (BLACK) SHORT	1682-821306T30	1682-821306A30 (BLACK) SHORT
-	GEAR HOUSING ASSEMBLY Comment: (GRAY) SHORT	1682-821306T31	1682-821306A31 (GRAY) SHORT
-	GEAR HOUSING ASSEMBLY Comment: (BLACK) LONG	1682-821306T32	1682-821306A32, 1682-821306T33, 1682-821306A33 (BLACK) LONG
-	GEAR HOUSING ASSEMBLY Comment: (GRAY) LONG	1682-821306T32	1682-821306A32, 1682-821306T33, 1682-821306A33 (GRAY) LONG
1	GEAR HOUSING ASSEMBLY Comment: (BLACK) BASIC	1682-821306T12	1682-821306A12 (BLACK) BASIC
1	GEAR HOUSING ASSEMBLY Comment: (GRAY) BASIC	1682-821306T13	1682-821306A13 (GRAY) BASIC
39	PIN, Dowel	17-821327
40	GASKET	27-823942
41	TUBE	32-8M0026108	32-821828
42	PLUG, Rubber	19-824928001	19-824928, 19-32297
43	SCREEN	821829
44	TRIM TAB	822157T2
45	SCREW, (M8 x 20)	10-82497020
46	WASHER	12-72397
47	GEAR ASSEMBLY, Forward (29 TEETH)	43-833000A2
48	BEARING ASSEMBLY, Roller	31-8M0103470	31-99328A 1
49	NOT SOLD SEPARATE, Cup	NSS
50	BEARING, Roller	31-41326
51	FOLLOWER, Cam	821578
52	SPRING	24-8261991
53	PIN	17-8M0020999	17-85093
54	CLUTCH	52-821314T	52-821314
55	SPRING	24-38114
56	PROPELLER SHAFT	44-8M0140441
57	GEAR, Reverse (29 TEETH)	43-833001T	43-833001
58	BEARING, Ball	30-20839T
59	CARRIER ASSEMBLY, Bearing	8M0168900
60	O-RING	25-815460
61	BEARING, Needle	31-21700
62	SEAL, Oil	26-8M0205511
63	SEAL, Oil	26-8M0203757
64	TAB WASHER	14-826613
64	WASHER Comment: (USE W/THREADED INSERT)	12-855941
65	SCREW, (M8 x 25) Comment: (USE W/TAB WASHER)	10-4000353
65	SCREW, (M8 x 30) Comment: (USE W/THREADED INSERT)	10-85594030
66	INSERT, Threaded	8227731
67	NOT SOLD SEPARATE, Decal (2.42:1)	NSS
68	THRUST HUB Comment: THESE REPLACEMENT PARTS ARE NOT INCLUDED WITH COMPLETE GEAR HOUSING REPLACEMENT	73345A1
69	PROP NUT KIT Comment: THESE REPLACEMENT PARTS ARE NOT INCLUDED WITH COMPLETE GEAR HOUSING REPLACEMENT	11-69578Q1
70	TAB WASHER Comment: THESE REPLACEMENT PARTS ARE NOT INCLUDED WITH COMPLETE GEAR HOUSING REPLACEMENT	14-8M0214942
71	SCREW, (M10 x 45) Comment: THESE REPLACEMENT PARTS ARE NOT INCLUDED WITH COMPLETE GEAR HOUSING REPLACEMENT	10-4000380
72	WASHER, (.453 x .812 x .105) Stainless Steel Comment: THESE REPLACEMENT PARTS ARE NOT INCLUDED WITH COMPLETE GEAR HOUSING REPLACEMENT	12-45176
73	PLUG Comment: THESE REPLACEMENT PARTS ARE NOT INCLUDED WITH COMPLETE GEAR HOUSING REPLACEMENT	19-95925
-	SEAL KIT	823547A2

Intake

Below is the parts list for Mercury 25 (4-STROKE) Intake:

Position No.	Part Name	OEM Number	Supersedes
1	CARBURETOR (SEE BREAKDOWN ON CARBURETOR PAGE)	3329-883314T03	3329-830276T 7, 3329-883314T 1
2	O-RING	25-33466
3	ISOLATOR, Carburetor	8536451
4	DIFFUSER	830277F01	830277F
5	BUMPER	8M0043364	828706
6	INSERT	855219
7	O-RING, (1.984 x .139)	25-8M0214923
8	SCREW, (M6 x 25)	10-8248326
9	SCREW, M6 x 100	10-821704100
10	CLAMP	855838
11	HOSE ASSEMBLY, Breather	32-854787A1
12	SEAL	855837	855837 1
13	INTAKE ASSEMBLY, Air	832011A2
-	GASKET SET	27-830270A02	27-830270A98

Intake/Exhaust Valves

Below is the parts list for Mercury 25 (4-STROKE) Intake/Exhaust Valves:

Position No.	Part Name	OEM Number	Supersedes
1	VALVE, Exhaust	8M0119204
2	VALVE, Intake	832990T1
3	WASHER, Valve Spring	12-825044
4	SEAL, Valve Stem	26-822647
5	SPRING, Valve Outer	24-823678
6	RETAINER	822650
7	KEY	28-893554	28-822651
8	ROCKER ARM	898821A01
9	SCREW	10-825046
10	NUT	11-826150	11-858274
11	SHAFT, Rocker	8M0011790
12	NOT SOLD SEPARATE, Plug	NSS
13	BRACKET	825050
14	SPRING	24-825052
15	SCREW, (M8 x 30)	10-82641030
-	GASKET SET	27-830270A02	27-830270A98
-	CYLINDER HEAD Comment: (ELECTRIC)	830271T3
-	CYLINDER HEAD Comment: (MANUAL)	830271T4

Linkage

Below is the parts list for Mercury 25 (4-STROKE) Linkage:

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 70) Stainless Steel Comment: ELECTRIC NON HANDLE	10-40011158
2	SCREW, Adjusting (M6 x 55) Comment: ELECTRIC NON HANDLE	10-814776	10-42978 ELECTRIC NON HANDLE
3	NUT, (M6) Comment: ELECTRIC NON HANDLE	11-401196
4	CAP Comment: ELECTRIC NON HANDLE	42942
5	LEVER, Throttle Comment: ELECTRIC NON HANDLE	822682A4
6	RETAINER Comment: ELECTRIC NON HANDLE	826587	826587 1 ELECTRIC NON HANDLE
7	BUSHING Comment: ELECTRIC NON HANDLE	23-825078
8	RETAINER Comment: ELECTRIC NON HANDLE	822459
9	LEVER, Shift Comment: ELECTRIC NON HANDLE	8259571
10	SHIFT ROD Comment: ELECTRIC NON HANDLE	882820	826271 ELECTRIC NON HANDLE
11	ROD, Throttle Comment: ELECTRIC NON HANDLE	830307
12	BUSHING Comment: ELECTRIC NON HANDLE	23-8M0215006
13	BRACKET Comment: ELECTRIC NON HANDLE	827706A4
14	LATCH Comment: ELECTRIC NON HANDLE	98889
15	SCREW, (M6 x 16) Comment: ELECTRIC NON HANDLE	10-8248324
16	SLEEVE Comment: ELECTRIC NON HANDLE	23-15885
17	WASHER Comment: ELECTRIC NON HANDLE	12-8M0214930
18	COTTER PIN Comment: ELECTRIC NON HANDLE	18-210711
19	CAM, Throttle	830305
20	BUSHING	23-822389
21	WASHER, (.265 x .750 x .048) Stainless Steel	12-65567
22	SCREW, (M6 x 35) Stainless Steel	10-40011131
23	SHIFT SHAFT ASSEMBLY, Horizontal	826588A4
24	RETAINER	8277071
25	SPRING, Detent	24-826077
26	SPRING, Backing	24-824993
27	SPRING, Plate	824994
28	SCREW, (M5 x 16) Stainless Steel	10-40011107
29	SWITCH Comment: ELECTRIC HANDLE MODELS	87-8M0052927	87-813960A 3 ELECTRIC HANDLE MODELS
30	SCREW, (M3.5 x 20) Stainless Steel Comment: ELECTRIC HANDLE MODELS	10-88075020
31	PLATE Comment: ELECTRIC HANDLE MODELS	824923
32	BRACKET Comment: HANDLE MODELS	8214943
33	SCREW, (M6 x 16) Comment: HANDLE MODELS	10-8248324

Power Trim

Below is the parts list for Mercury 25 (4-STROKE) Power Trim:

Position No.	Part Name	OEM Number	Supersedes
1	POWER TRIM	822344T14	822344T10, 822344T 5
-	O-RING KIT	25-827668A1
2	SHOCK ROD ASSEMBLY	893931A01	827670A 2
3	PILOT CHECK ASSEMBLY	827671A1
4	TILT RELIEF VALVE ASSEMBLY	827672A1
5	SEAT ASSEMBLY, Suction	827673A1
6	PUMP ASSEMBLY	827674A1
7	NOT SOLD SEPARATE, Spring/down Relief Ball	NSS
8	NOT SOLD SEPARATE, Screw (10-32 x 1-1/4 Inches)	NSS
9	NOT SOLD SEPARATE, Filter	NSS
10	NOT SOLD SEPARATE, Seal Ring	NSS
11	MOTOR ASSEMBLY	827675A1
12	NOT SOLD SEPARATE, Screw (1/4-28 x 5/8 Inches)	NSS
13	CABLE ASSEMBLY	88238A15
14	NOT SOLD SEPARATE, Lockwasher	NSS
15	NOT SOLD SEPARATE, O-Ring	NSS
16	NOT SOLD SEPARATE, Coupler	NSS
17	PISTON, Memory	827676
18	MANUAL RELEASE ASSEMBLY	893929A01	813442A 2
19	PLUG ASSEMBLY	19-811613
-	HARNESS/RELAY ASSEMBLY, Trim	84-826802A14
20	HARNESS ASSEMBLY, Trim	84-826802A9
21	RELAY ASSEMBLY	8M0207773
22	BRACKET	828102
23	GROMMET	25-818967
24	BUSHING	23-8M0214955
25	NOT SOLD SEPARATE, Decal-Trim Relay	NSS
26	SCREW, (M6 x 25)	10-8248326

Power Trim Mounting

Below is the parts list for Mercury 25 (4-STROKE) Power Trim Mounting:

Position No.	Part Name	OEM Number	Supersedes
1	PIN, Anchor (14 mm)	17-822481001	17-822481
2	BUSHING	23-822482
3	BUSHING	23-822484
4	WASHER	12-825190
5	NUT, (M14)	11-826712	11-40134 14
6	SCREW, (M10 x 40) Stainless Steel	10-4009040
7	WASHER	12-4002319
8	NUT, (M10)	11-40140
9	SCREW, (#10-16 x .600)	10-878609	10-812832 1
10	C WASHER	8M0084613	69205
11	CLIP	54-22740
12	PIN, Trilobe	17-821539	17-13794, 17-19603
13	PIN, Pivot	17-822480
14	BUSHING	23-823507

Recoil Starter

Below is the parts list for Mercury 25 (4-STROKE) Recoil Starter:

Position No.	Part Name	OEM Number	Supersedes
-	STARTER ASSEMBLY, Recoil	835253A13	835253T 6
1	HOUSING, Recoil	835253A12	835253A 8
2	CAM	816712T01	816712 1
3	SPRING	24-826791	24-816718 1
4	SEAL	8M0026455	835255 2
5	ROLLER	835256T	835256
6	BUSHING	23-852987T	23-852987
7	WASHER	826414T	12-826414
8	SCREW, (M6 x 30)	10-82684430
9	LOCKWASHER	13-826229
10	SPRING	24-86857T01
11	SHEAVE ASSEMBLY, Starter	50-854317T5
12	CAM	868501
13	SPRING	24-86851T02
14	RING, Retaining	53-86849T01
15	SPRING	24-868523
16	CAM	86853T01
17	SCREW, (.250-20 x .625)	10-826253	10-97516, 10-818838
18	ROPE	50-12066Q10
19	LEVER, Interlock	856073	852449
20	RETAINER	856072T	856072
21	SPRING	24-856138T03	24-856138 3
22	BUSHING	854779T	854779
23	SCREW, (#10-16 x 1.00)	10-8182491
24	HANDLE ASSEMBLY	85174A1
25	NOT SOLD SEPARATE, Retainer	NSS
26	SCREW, (M6 x 25)	10-8248326
27	CABLE, Interlock	856754	816748 6
28	SCREW, (#10-16 x .625)	10-8214281
29	WASHER, (.220 x .500 x .030) Stainless Steel	12-73288
30	COTTER PIN	18-26811
31	SCREW, (M5 x 16) Stainless Steel	10-40011107
32	J CLIP	54-54457
33	SCREW, (M6 x 16)	10-8248324

Service/Support Material

Below is the parts list for Mercury 25 (4-STROKE) Service/Support Material:

Part Name	OEM Number	Supersedes
PARTS MANUAL, 25 (4- Stroke)	90-85553598
SERVICE MANUAL	90-854785R2
OWNERS MANUAL	90-10183981
DECAL SET Comment: (MERCURY)	37-854693A00	37-854693A98 (MERCURY)
DECAL SET Comment: (MARINER)	37-854692A03	37-854692A01, 37-854692A98 (MARINER)
DECAL SET Comment: (TRACKER)	37-856144A98
DECAL, EPA Label Information Comment: (1998)	37-855577A24	37-855577 24 (1998)
PROPELLER	48-85632A45
TANK ASSEMBLY, Fuel	1265-859065A3

Starter Motor

Below is the parts list for Mercury 25 (4-STROKE) Starter Motor:

Position No.	Part Name	OEM Number	Supersedes
1	STARTER MOTOR ASSEMBLY	50-893886T	50-888151T, 50-859169T, 50-830308T, 50-830308
2	THRU BOLT	10-965662
3	DRIVE KIT	906432
4	PINION	685752
5	DRIVE CAP	8236392
6	ARMATURE	8236383
7	CAP, Commutator	8119011
8	BRUSH/SPRING KIT	898265016	75384, 75384 1
9	HOLDER	898265014	61787
10	SCREW	F15158
11	DECAL, Warning, High Voltage	37-8272822

Steering Arm

Below is the parts list for Mercury 25 (4-STROKE) Steering Arm:

Position No.	Part Name	OEM Number	Supersedes
1	NUT, (M12)	11-896963	11-859129, 11-90099
2	STRAP	893773002	827923 2, 893773001, 827923 1
3	MOUNT	826267T3
4	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
5	BUMPER	8M0156878
6	RING, Retaining	53-89531
7	ARM, Steering Comment: (BLACK)	8M0118183
7	ARM, Steering Comment: (GRAY)	8M0118183
8	BOLT, (M12 x 154)	10-898835001	10-42973
9	SPACER Comment: (SHORT)	23-8279973
9	SPACER Comment: (LONG)	23-8279971
10	SWIVEL TUBE Comment: (SHORT)	850175A1
10	SWIVEL TUBE Comment: (LONG)	826233T3
11	CABLE ASSEMBLY	84-88238T01
12	CABLE ASSEMBLY, Ground	8M0207768
13	SCREW, (M10 x 105) Hex Flange - Stainless Steel	10-823567105	10-817430105
14	BRACKET	893703	828985
15	SCREW, (#10-16 x .380)	10-878607	10-817626
16	NUT, (M10)	11-40140
17	NUT, (.375-24) Comment: HANDLE	11-8M0204726
18	LEVER Comment: HANDLE	823792
19	WASHER Comment: HANDLE	12-29330
20	ROD (THREADED) Comment: HANDLE	821961
21	BRAKE PLATE Comment: HANDLE	821957
22	DISC Comment: HANDLE	8165621
23	PLATE Comment: HANDLE	8M0007471	823791 HANDLE
24	DISC Comment: HANDLE	8165621
25	SHOULDER SCREW, Hex Comment: HANDLE	10-768042
26	BRACKET Comment: ELECTRIC	8M0184092
27	TAB WASHER Comment: ELECTRIC	14-8M0009820	14-816669F 1 ELECTRIC
28	SCREW, (M10 x 30) Comment: ELECTRIC	10-4000377

Swivel Bracket

Below is the parts list for Mercury 25 (4-STROKE) Swivel Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	LINK ROD Comment: NON HANDLE	19608A14
2	SCREW, (.375-24 x 1.500) Comment: NON HANDLE	10-823919
3	WASHER, (.390 x .546 x .12) Comment: NON HANDLE	12-8M0109680
4	WASHER, (.390 x .625 x .062) Stainless Steel Comment: NON HANDLE	12-37828
5	NUT, (.375-24) Comment: NON HANDLE	11-8M0204726
6	PUCK Comment: (ELECTRIC)	822397
7	SWIVEL BRACKET ASSEMBLY Comment: (BLACK)	3410-827402T5
7	SWIVEL BRACKET ASSEMBLY Comment: (GRAY)	3410-827402T6
8	BUSHING	23-8217711
9	BUSHING (LOWER)	23-821777
10	SEAL	26-8M0205512
11	FITTING, Grease	22-8M0169589
12	FITTING, Grease Comment: (HANDLE)	22-8M0169589
13	SEAL KIT Comment: NON HANDLE	19624A1
14	O-RING, (.583 x .103) Comment: NON HANDLE	25-29619
15	SPACER Comment: NON HANDLE	23-78861
16	WASHER	12-19619
17	NUT, (.875-14)	11-826164
18	NOT SOLD SEPARATE, Decal-Serial Overlaminate	NSS
19	SCREW, (M8 x 10) Stainless Steel Comment: MANUAL HANDLE	10-4008910
19	SCREW, (M8 x 25) Stainless Steel Comment: ELECTRIC	10-40011149
20	SEAL Comment: ELECTRIC	8282451
21	WASHER	12-19619
22	TILT TUBE	8M0041938	8M0035070, 19614 1
23	NUT, (.875-14)	11-826164
24	PIN, Trilobe	17-821539	17-13794, 17-19603
25	BUSHING	23-823507
26	PIN, Pivot (UPPER)	17-822480
27	DECAL, Co-Pilot	37-8237011

Swivel Bracket, Remote Control

Below is the parts list for Mercury 25 (4-STROKE) Swivel Bracket, Remote Control:

Position No.	Part Name	OEM Number	Supersedes
1	LINK ROD	19608A14
2	SCREW, (.375-24 x 1.500)	10-823919
3	WASHER, (.390 x .546 x .12)	12-8M0109680
4	WASHER, (.390 x .625 x .062) Stainless Steel	12-37828
5	NUT, (.375-24)	11-8M0204726
6	PUCK	822397
7	SWIVEL BRACKET ASSEMBLY Comment: (BLACK)	3410-827402T5
7	SWIVEL BRACKET ASSEMBLY Comment: (GRAY)	3410-827402T6
8	BUSHING (UPPER)	23-8217711
9	FITTING, Grease	22-8M0169589
10	BUSHING (LOWER)	23-821777
11	SEAL	26-8M0205512
12	WASHER	12-19619
13	NUT, (.875-14)	11-826164
14	COTTER PIN	18-26811
15	PIN, Pivot	821799002	821799 1
16	NOT SOLD SEPARATE, Decal-Serial Overlaminate	NSS
17	SCREW, (M8 x 25) Stainless Steel	10-40011149
18	SEAL	8282451
19	WASHER	12-19619
20	TILT TUBE	8M0041938	8M0035070, 19614 1
21	NUT, (.875-14)	11-826164
22	PIN, Trilobe	17-821539	17-13794, 17-19603
23	BUSHING	23-823507
24	PIN, Pivot (UPPER)	17-822480
25	STRAP	8217751
26	LINK (UPPER)	821800
27	LEVER	8217981
28	NUT,	6-32,11-8M0207777
29	PIN	826578	F366886, F366866
30	SPRING	24-F366300
31	LINK	8M0026107	821805 2
32	WASHER	12-71055
33	ARM	825181003	825181 1
34	LOCK, Reverse	8289861
35	NUT,	10-32,11-8M0204718
36	SEAL KIT	19624A1
37	O-RING, (.583 x .103)	25-29619
38	SPACER	23-78861

Tiller Handle

Below is the parts list for Mercury 25 (4-STROKE) Tiller Handle:

Position No.	Part Name	OEM Number	Supersedes
1	COVER KIT	822148A8
2	PULLEY	822150
3	NOT SOLD SEPARATE, Case	NSS
4	SCREW, (#10-16 x .500)	10-878608	10-812832
5	CABLE ASSEMBLY, Throttle (26.50 Inches)	4324214
6	CABLE ASSEMBLY, Throttle (27.50 Inches)	4324215
7	SLEEVE, (12.00 Inches)	85-960099
8	SCREW, (M8 x 25)	10-82526225
9	COVER Comment: (BLACK)	8M0072298	822407F 1 (BLACK)
9	COVER Comment: (GRAY)	822407F2
10	BUSHING	23-821477
11	ARM, Steering Handle Comment: (BLACK)	822325T1
11	ARM, Steering Handle Comment: (GRAY)	822325T2
12	RETAINER	822441
13	SCREW, (M5 x 16) Stainless Steel	10-40011107
14	SCREW, (M6 x 25)	10-8M0204707
15	LOCK, Throttle	892995	821971
16	SPRING	24-96203
17	KNOB, Throttle	821972T	821972
18	CLIP Comment: (ELECTRIC)	824918
19	SWITCH ASSEMBLY Comment: (ELECTRIC)	87-823609A12
20	HOUSING Comment: (ELECTRIC)	889734	823917 2 (ELECTRIC)
21	TILLER TUBE	821463T01	821463A 1
22	DECAL	37-8242004
23	HANDLE, Throttle	821465
24	GRIP	8M0221732
25	SWITCH, Stop	87-8M0104611	87-823609A 2
26	SCREW, (M5 x 12)	10-82239312
27	WASHER	12-8M0214930
28	ALARM ASSEMBLY	84-8M0088388	816492A 8
29	CLIP	823687
30	SWITCH, Stop	87-11083A31
31	RETAINER, Brass	8M0032846	12044 1
32	BRACKET, Tiller Comment: (BLACK)	821455A4
32	BRACKET, Tiller Comment: (GRAY)	821455A5
33	WAVE WASHER	13-826792	13-34678 1, 13-822144
34	BUSHING	23-821477
35	WASHER	12-827314
36	CONDUIT, (.620 Inside Diameter x 3.00 Feet Bulk)	32-828547633
37	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
38	NOT SOLD SEPARATE, Decal-Shift (F-N-R)	NSS
39	NOT SOLD SEPARATE, Decal-Start Comment: (ELECTRIC)	NSS
40	TAB WASHER	14-8M0009820	14-816669F 1
41	SCREW, (M10 x 90)	10-82484890
42	LANYARD ASSEMBLY	15920Q54
43	SCREW, (M8 x 35) Stainless Steel	10-40011151
44	HANDLE	830180A01	830180
45	BUSHING	23-830181
46	SHIFT ROD	8301821

Tools, Special

Below is the parts list for Mercury 25 (4-STROKE) Tools, Special:

Position No.	Part Name	OEM Number	Supersedes
-	HOLDER TOOL, Flywheel Comment: ELECTRICAL/IGNITION	91-8M0161873
-	TESTER, Eight Chamber Comment: ELECTRICAL/IGNITION	91-850439T1
-	GAP TOOL, Single Chamber Comment: ELECTRICAL/IGNITION	91-63998A1
-	NOT SOLD SEPARATE, Collet (SNAP-ON - CG41-14) Comment: TRIM/TILT SYSTEM	NSS
-	NOT SOLD SEPARATE, Rod-Expanding (SNAP-ON - CG41-11) Comment: TRIM/TILT SYSTEM	NSS
-	DOWN PRESSURE KIT Comment: TRIM/TILT SYSTEM	91-822778A3
-	SPANNER WRENCH Comment: TRIM/TILT SYSTEM	91-74951
-	HEAT LAMP Comment: TRIM/TILT SYSTEM	91-63209
-	GAUGE TOOL Comment: POWERHEAD	91-29287
-	HOLDER TOOL, Flywheel Comment: POWERHEAD	91-8M0161873
-	FLYWHEEL PULLER Comment: POWERHEAD	91-83164M
-	EXPANDER TOOL, Piston Ring Comment: POWERHEAD	91-24697
-	STAND TOOL, Powerhead Comment: POWERHEAD	91-827001A1
-	COMPRESSOR TOOL, Piston Ring Comment: POWERHEAD	FT2997	FJ7081, FJ8785, FJ8786, FJ8787, FJ8788, FJ8789 POWERHEAD
-	TORQUE WRENCH, (0-150 lb-in) Comment: POWERHEAD	91-66274
-	INSTALLER TOOL, Valve Guide Bushing Comment: POWERHEAD	91-809496A1
-	REAMER TOOL, Valve Guide Comment: POWERHEAD	91-809497A1
-	REMOVER TOOL, Valve Guide Comment: POWERHEAD	91-809495001	91-809495A 1 POWERHEAD
-	BEARING, Thrust Comment: GEAR HOUSING	31-85560
-	INSTALLER TOOL, Bearing Carrier Seal Comment: GEAR HOUSING	91-817007T	91-817007 GEAR HOUSING
-	PILOT Comment: GEAR HOUSING	91-825199
-	PULLER KIT, Bearing Comment: GEAR HOUSING	91-31229A7
-	NUT, (.625-18) Comment: GEAR HOUSING	11-24156
-	PLATE Comment: GEAR HOUSING	91-29310
-	WASHER Comment: GEAR HOUSING	12-34961
-	PILOT WASHER Comment: GEAR HOUSING	91-36571T
-	DRIVER HEAD TOOL Comment: GEAR HOUSING	91-37312T
-	DRIVER ROD TOOL, Needle Bearings Comment: GEAR HOUSING	91-37323
-	HOOK TOOL, Spring Comment: GEAR HOUSING	91-825200A1
-	REMOVER TOOL, Bearing Comment: GEAR HOUSING	91-13779
-	HOLDING TOOL, Driveshaft Comment: GEAR HOUSING	91-83180M
-	INSTALLER TOOL, Bearing Comment: GEAR HOUSING	91-826872
-	INSTALLER TOOL, Needle Bearing Comment: GEAR HOUSING	91-817011T	91-817011 GEAR HOUSING
-	MANDREL Comment: GEAR HOUSING	91-825197T	91-825197 GEAR HOUSING
-	MANDREL Comment: GEAR HOUSING	91-825198
-	PULLER, WATER PUMP Comment: GEAR HOUSING	91-27780
-	PULLER PLATE Comment: GEAR HOUSING	91-37241
-	TORQUE WRENCH, (0-150 lb-in) Comment: GEAR HOUSING	91-66274
-	GAUGE TOOL, Carburetor	91-36392

Top Cowl

Below is the parts list for Mercury 25 (4-STROKE) Top Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	TOP COWL ASSEMBLY Comment: (BLACK) MANUAL	4027-830562T5
1	TOP COWL ASSEMBLY Comment: (SILVER) MANUAL	4027-830562T6
2	TOP COWL ASSEMBLY Comment: (BLACK) ELECTRIC	4027-830562T7
2	TOP COWL ASSEMBLY Comment: (SILVER) ELECTRIC	4027-830562T8
3	NOT SOLD SEPARATE, Induction Insert	NSS
4	NOT SOLD SEPARATE, Cowl Insert Comment: (MANUAL)	NSS
5	LATCH Comment: (BLACK)	826291F1
5	LATCH Comment: (SILVER)	826291F1
6	SCREW, (M4 x 14.5)	10-8231871
7	LOCKWASHER, Stainless Steel	8,13-26995
8	NUT, (M4)	11-8237515
9	SEAL	8M0153618
10	SOUND BLANKET KIT	852556A02	855334A 1
11	NOT SOLD SEPARATE, Sound Blanket-Top Comment: (ELECTRIC)	NSS
12	NOT SOLD SEPARATE, Sound Blanket-Top Comment: (MANUAL)	NSS
13	BRACKET ASSEMBLY, Latch Roller	893763	18173
14	SCREW, (M6 x 16)	10-4006731
15	BRACKET	8M0038412	822426 1
16	SCREW, (M4 x 14.5)	10-8231871
17	LOCKWASHER, Stainless Steel	8,13-26995
18	NUT, (M4)	11-8237515
19	ROPE AND HANDLE KIT	47341A11

Download this page as PDF: Click here

For Mercury Owners:

To assist you in maintaining and repairing your marine engines, we hope the following resources may be of use:

Mercury / Mercruiser / Mariner Parts from JLM Marine

About JLM Marine

Founded in 2002, JLM Marine has established itself as a dedicated manufacturer of high-quality marine parts, based in China. Our commitment to excellence in manufacturing has earned us the trust of top marine brands globally.

As a direct supplier, we bypass intermediaries, which allows us to offer competitive prices without compromising on quality. This approach not only supports cost-efficiency but also ensures that our customers receive the best value directly from the source.

We are excited to expand our reach through retail channels, bringing our expertise and commitment to quality directly to boat owners and enthusiasts worldwide.