Mercury 15 (4-STROKE) (0G590000 THRU 0G760299) Outboard Motor Parts Diagram & Catalog – Free PDF Download

by JLM Marine 30 Apr 2025 0 Comments

Mercury 15 (4-STROKE) Outboard Motor Parts Diagram & Catalog – Free PDF Download

Accessories

Below is the parts list for Mercury 15 (4-STROKE) Accessories:

Part Name	OEM Number	Supersedes
CHARGING KIT, 10 Ampere	856557A1
CHARGING KIT, Battery	856558A2
STARTER MOTOR KIT, Electric	50-856555A1
LINE ASSEMBLY, Fuel (8 Feet) Comment: WITH QUICK DISCONNECT	32-877680Q8
LINE ASSEMBLY, Fuel (12 Feet) Comment: WITH QUICK DISCONNECT	32-877680Q12	32-858620Q12, 32-858620A12, 32-827927A12 WITH QUICK DISCONNECT
LINE ASSEMBLY, Fuel (8 Feet) Comment: WITH QUICK DISCONNECT ENGINE END ONLY	32-877681Q8
LINE ASSEMBLY, Fuel (12 Feet) Comment: WITH QUICK DISCONNECT ENGINE END ONLY	32-877681Q12	32-804792Q12, 32-804792Q, 32-858621Q12, 32-858621A12, 32-17146A12 WITH QUICK DISCONNECT ENGINE END ONLY
LINE ASSEMBLY, Fuel (12 Feet) Comment: NO FITTINGS	32-877683Q12	32-858623Q12, 32-858623A12, 32-822379A12, 32-819380A12, FA599752, FS409752, 32-819380A 3, F216752, FA409752, F289752, FA178752, FA216752, FA284752, FA289752, FS409952 NO FITTINGS
HARNESS KIT, Remote Control	84-856554A1
TILLER HANDLE KIT Comment: (BLACK)	856537A1
TILLER HANDLE KIT Comment: (GRAY)	856537A2
SWITCH KIT	87-856556A1

Bottom Cowl

Below is the parts list for Mercury 15 (4-STROKE) Bottom Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	BOTTOM COWL Comment: (BLACK)	4000-835416A1
1	BOTTOM COWL Comment: (GRAY)	4000-835416A2
2	LATCH HOOK	852480
3	SCREW, (M6 x 16)	10-4006731
4	WASHER	12-8M0214930
5	BUSHING	23-826618
6	GROMMET	25-828129
7	WASHER, (.281 x .734 x .063)	12-69057
8	GROMMET	25-855289T	25-855289
9	GROMMET Comment: (HANDLE)	25-857002	25-826808 (HANDLE)
9	PLUG Comment: (NON-HANDLE)	827403
10	LEVER, Cowl Latch Comment: (BLACK)	825782F1
10	LEVER, Cowl Latch Comment: (GRAY)	825782F2
11	SCREW, (M6 x 35 MM)	10-1993735
12	BUSHING	23-812707	23-71984, 23-F286818, 23-F286828, F480818
13	WASHER, Wave	13-12134
14	CONNECTOR, Fuel - Brass	22-8M0182334
15	SCREW, (M6 x 25) Stainless Steel	10-40011129
16	GROMMET	25-18202
17	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
18	HOSE, (.187) (26.00 Inches Bulk) (Cut to 21 IN.)	32-9912878
19	PLUG	826037
20	FITTING	22-813613
21	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
22	SHIFT DECAL Comment: (HANDLE)	37-111851

Carburetor

Below is the parts list for Mercury 15 (4-STROKE) Carburetor:

Position No.	Part Name	OEM Number	Supersedes
1	CARBURETOR	3323-835382T04	3323-835382T 3
2	SCREW, (M4 x 10)	10-809571
3	COVER	8095721
4	GASKET	809573
5	SCREW, Throttle	10-8095781
6	SPRING	24-8095791
7	SCREW, (M4 x 5)	10-811248M	10-852787 3
8	PLATE	802694
9	SCREW, (M3 x 5)	10-8026921
10	PILOT JET,	45,8027011
11	PLUG	19-802702
12	MAIN NOZZLE	802700
13	O-RING	25-11802M
14	JET, Main	104,802701
15	SCREW, (M4 x 5)	10-8095711
16	VALVE, Needle	8095701
17	FLOAT	809569
18	PIN	17-11794M
19	GASKET	27-802699	27-802699 1
20	FILTER	35-802704
21	FLOAT BOWL ASSEMBLY	802690T3
22	RING, Retaining	53-802693
23	CAP	802698
24	SEAL	802697
25	SCREW, Drain (M5 x 6)	10-8095783
26	GASKET	27-802691
27	DIAPHRAGM	802695
28	SPRING	24-802696
29	COVER	802705
30	SCREW, (M4 x 8)	10-802692
31	PLUG, Drain (M4 x 5)	22-14183M
32	GASKET	27-8026911
33	SCREW, (M4 x 12)	10-81758M
34	CHECK VALVE	21-802703
-	REPAIR KIT, Carburetor	802706A1

Clamp Bracket

Below is the parts list for Mercury 15 (4-STROKE) Clamp Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	BRACKET ASSEMBLY, Transom Comment: (STARBOARD)(BLACK)	1497-8796A7
1	BRACKET ASSEMBLY, Transom Comment: (STARBOARD)(GRAY)	1497-8796A8
2	BRACKET ASSEMBLY, Transom Comment: (PORT)(BLACK)	1497-8794A9
2	BRACKET ASSEMBLY, Transom Comment: (PORT)(GRAY)	1497-8794A10
3	THUMB SCREW ASSEMBLY, (16 mm)	10-92767A3
4	NOT SOLD SEPARATE, Rivet	NSS
5	NOT SOLD SEPARATE, Handle	NSS
6	SHOULDER SCREW, Hex	10-768042
7	WASHER	12-73719
8	NUT, (.250-28)	11-826709109	11-33825, 11-35045
9	NUT, (.875)	11-93164
10	SCREW, (M6 x 40)	10-4000333
11	HANDLE	41042
12	SPACER	23-818538
13	WASHER, Nylon	12-71421
14	TILT TUBE	8M0035075	883068, 41171
15	WASHER, Nylon	12-71421
16	DECAL, Co-Pilot Comment: HANDLE MODELS	37-8237011
17	PIN ASSEMBLY, Tilt	17-56373A2
18	SPRING	24-92995
19	SCREW, (M6 x 40)	10-4000333
20	NUT, (.875)	11-93164
21	CLIP	54-8M0085928	54-30954
22	SCREW, (.312-18 x 3.500) Stainless Steel	10-814945	F1417
23	WASHER	12-67981
24	NUT, (.312)	11-815848
25	NUT, (.250-28)	11-826709109	11-33825, 11-35045
26	SCREW, (.250-28 x 1.00)	10-41523
27	LEVER, STARBOARD SIDE	96965
28	NUT, (.250-28)	11-826709109	11-33825, 11-35045
29	SPRING	24-44581
30	SCREW, (.250-28 x 1.75)	10-41524
31	SCREW, (.250-28 x 1.75)	10-41524
32	WAVE WASHER	13-31030
33	NUT, (.250-28)	11-826709109	11-33825, 11-35045
34	STRAP, PORT SIDE	90901
35	SCREW, (.250-28 x 1.00)	10-41523

Crankshaft, Pistons and Connecting Rods

Below is the parts list for Mercury 15 (4-STROKE) Crankshaft, Pistons and Connecting Rods:

Position No.	Part Name	OEM Number	Supersedes
1	CRANKSHAFT	400-834957
2	SEAL, Oil	26-855680
3	SEAL, Oil	26-855681
4	BEARING Comment: (BROWN)	31-834960
4	BEARING Comment: (BLACK)	31-83496010
4	BEARING Comment: (BLUE)	31-83496020
5	CONNECTING ROD	600-834961T1
6	BOLT, (M7 x 38)	10-850844
7	WASHER	12-855682
8	PISTON	700-834963T	700-834963
9	RING, Piston	39-850846
10	RING, Piston	39-850847
11	RING, Oil	39-825839
12	PIN, Piston	41-825713
13	CLIP	53-82343M
14	KEY	28-8M0057164	28-81914M
15	KEY	28-8M0084803	28-84403M
-	POWERHEAD ASSEMBLY	802733A98
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Cylinder Block

Below is the parts list for Mercury 15 (4-STROKE) Cylinder Block:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER BLOCK	900-8M0055024	900-835407A02, 900-835407A 1
2	PIN, Dowel	17-825689
3	BOLT, (M8 x 55)	10-8M0101617
4	BOLT, (M6 x 14)	10-43092M
5	PIPE PLUG	22-822644
6	GASKET	27-834952002	27-834952
7	COVER, Exhaust	834953T02	834953T, 834953
8	FITTING	22-83326M
9	THERMOSTAT, (60C/140F)	855676003	825212001, 825212, 855676
10	COVER	8M0188835
11	GASKET	27-8M0177107
12	BOLT, (M6 x 30)	10-82500930
13	HOSE	8M0060022	32-855694
14	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
15	HOSE, (57.00 Inches Bulk) (16 IN.)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
16	FILTER ASSEMBLY, Oil	35-8M0162832
17	NIPPLE, (M20)	822625
18	NOT SOLD SEPARATE, Plug-Serial Number	NSS
19	BREATHER COVER	834974
20	SEAL	26-850850
21	BOLT, (M6 x 20)	10-8257021
22	GASKET	27-8354271
23	PLATE, Oil Deflection	855922A2
24	SCREW, (M8 x 35) Stainless Steel	10-40011151
25	ANODE	97-8M0099896	97-855678
26	GROMMET	25-855777
27	COVER	855776
28	BOLT, (M5 x 12)	10-855778
29	PLATE	855779
30	BOLT, (M6 x 20)	10-8257021
31	CABLE Comment: HANDLE	8533442
32	NUT (.375) Comment: HANDLE	11-46335
33	BRACKET Comment: HANDLE	855732
34	RING, Retaining Comment: HANDLE	53-27290
35	SCREW, (M6 x 13) Stainless Steel Comment: HANDLE	10-40011126
36	SOCKET Comment: HANDLE	817428	830875 HANDLE
37	DIPSTICK	19-8354262
38	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
39	PIPE JOINT	22-8830591
40	HOSE	32-896122	32-852485
41	SCREEN, Oil	852484
42	CLAMP Comment: ELECTRIC	54-28700
43	SCREW, (M5 x 12) Comment: ELECTRIC	10-82239312
44	CLAMP	54-8556951
45	CLAMP	54-8556961
46	GROMMET	25-855690
-	POWERHEAD ASSEMBLY	802733A98
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Cyliner Head

Below is the parts list for Mercury 15 (4-STROKE) Cyliner Head:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER HEAD ASSEMBLY	900-835430A1
2	GUIDE, Intake	850835
3	CIRCLIP	53-825038	825722
4	PIPE PLUG	22-822644
5	BOLT, (M8 x 78)	10-855677
6	PIN, Dowel	17-825689
7	SCREW, (M6 x 25)	10-893745025
8	GASKET	27-8M0052705	27-850836
9	COVER	834954
10	SEAL	850837
11	BOLT, (M6 x 20)	10-8257021
12	SPARK PLUG, NGK-DPR6EA-9	33-827858Q	33-827858
13	PLUG	859578A1
14	O-RING	25-8M0052669	25-825492
15	NOT SOLD SEPARATE, Decal-Recomm. Eng. Oil/Valve Cle.	NSS
-	POWERHEAD ASSEMBLY	802733A98
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Driveshaft Housing

Below is the parts list for Mercury 15 (4-STROKE) Driveshaft Housing:

Position No.	Part Name	OEM Number	Supersedes
1	HOUSING, Driveshaft Comment: (SHORT and BIGFOOT)(BLACK)	1505-852995F1
1	HOUSING, Driveshaft Comment: (SHORT and BIGFOOT)(GRAY)	1505-852995T2
1	HOUSING, Driveshaft Comment: (LONG)(BLACK)	1506-835409T1
1	HOUSING, Driveshaft Comment: (LONG)(GRAY)	1506-835409T2
2	MOUNT, Upper	835410T2
2	MOUNT, Upper Comment: (BIGFOOT)	856157T	856157 (BIGFOOT)
3	SCREW, (M8 x .98)	10-8136911
4	BUMPER	826276
5	GASKET	27-8M0204692
6	PLUG, Drain	8288181
7	COVER	853577T
8	GASKET	27-854617
9	SCREW, (M6 x 16)	10-4006731
10	SEAL	26-827947
11	TUBE, Water Comment: (SHORT)	32-852993
11	TUBE, Water Comment: (LONG)	32-855260
11	TUBE, Water Comment: (BIGFOOT)	32-855252
12	SEAL	26-8272411
13	SEAL, Oil	26-413651
14	SEAL	852432
15	BRACKET	856179
16	SLEEVE	856196
17	COVER Comment: (PORT)(BLACK)	850862F2
17	COVER Comment: (PORT)(GRAY)	850862F3
18	COVER Comment: (STARBOARD)(BLACK)	850863F2
18	COVER Comment: (STARBOARD)(GRAY)	850863F3
19	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
20	NUT, (M6)	11-401386
21	BUMPER	8224211
22	GROMMET	25-855299
23	ADAPTOR Comment: (BLACK)	853963F1
23	ADAPTOR Comment: (GRAY)	853963F2
24	BUSHING, (.31 x .45 x .50) Comment: BIGFOOT	23-12009
25	SCREW, (M8 x 50) Comment: BIGFOOT	10-82407110
26	SCREW, (M8 x 30) Comment: BIGFOOT	10-8240717
27	RELIEF VALVE ASSEMBLY	825578A1
28	O-RING	25-825579
29	PIN, Dowel	17-82364M
30	PLUG	22-68307

Electrical Components

Below is the parts list for Mercury 15 (4-STROKE) Electrical Components:

Position No.	Part Name	OEM Number	Supersedes
1	BRACKET Comment: (ELECTRIC)	835403T1
1	BRACKET Comment: (MANUAL)	835403T	835403 (MANUAL)
2	CLAMP	54-855686
3	BOLT, (M6 x 20)	10-855810
4	BOLT, (M6 x 25)	10-8248326
5	WASHER	12-855811
6	GROMMET	25-97687M
7	COLLAR	23-852473
8	RECTIFIER/REGULATOR ASSEMBLY Comment: ELECTRIC	854650T2
9	BOLT, (M6 x 16) Comment: ELECTRIC	10-811188T	10-811188M, 10-852776 8 ELECTRIC
10	CAP, Female Comment: ELECTRIC	13540
11	CABLE ASSEMBLY, Brown/White Comment: ELECTRIC	84-11149A43
12	CABLE ASSEMBLY Comment: ELECTRIC	84-824372A1
13	BRACKET Comment: ELECTRIC	8M0010250	95643M ELECTRIC
14	SOLENOID Comment: ELECTRIC	825096T01	89-825096T, 89-825096, 89-95642M ELECTRIC
15	WASHER Comment: ELECTRIC	12-827205
16	NUT, (M6) Comment: ELECTRIC	11-827204
17	LOCKWASHER, (M6) Comment: ELECTRIC	13-400256
18	NUT, (M6) Stainless Steel Comment: ELECTRIC	11-400212
19	BOOT Comment: ELECTRIC	85-826574
20	LEAD WIRE Comment: ELECTRIC	855742
21	NUT, (.250-20) Brass Comment: ELECTRIC	11-94330
22	CABLE ASSEMBLY, Fuse Comment: ELECTRIC	84-859451A1
23	FUSE, 20 Ampere Comment: ELECTRIC	88-8M0207796
24	CABLE ASSEMBLY, Fuse Comment: ELECTRIC	84-95084A19
25	HARNESS ASSEMBLY, Engine Wiring Comment: ELECTRIC	84-859312T1
26	RETAINER Comment: ELECTRIC	92753
27	CABLE ASSEMBLY, Battery - Positive Comment: ELECTRIC	84-88439A29
28	CABLE ASSEMBLY, Battery - Negative Comment: ELECTRIC	84-88439A30
29	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
30	CABLE ASSEMBLY Comment: (HANDLE)	84-824912A6
31	CDI UNIT	835401T1
32	BOLT, (M6 x 20)	10-84058M
33	COIL ASSEMBLY, Ignition Comment: (Includes Leads and Boots)	855685T	855685 (Includes Leads and Boots)
34	HIGH TENSION LEAD	84-825102A1
35	GROMMET	25-82069M
36	SWITCH, Oil Pressure	853524
37	NOT SOLD SEPARATE, Screw	NSS
38	LEAD WIRE	853537
39	RECTIFIER/REGULATOR Comment: MANUAL	835406
40	BOLT, (M6 x 16) Comment: MANUAL	10-811188T	10-811188M, 10-852776 8 MANUAL
41	SOLENOID ASSEMBLY Comment: ELECTRIC NON/HANDLE	89-853598T	89-853598 ELECTRIC NON/HANDLE
42	BRACKET Comment: ELECTRIC NON/HANDLE	853599T	853599 ELECTRIC NON/HANDLE
43	HOOK WIRE Comment: ELECTRIC NON/HANDLE	853601
44	SCREW, (M5 x 8) Comment: ELECTRIC NON/HANDLE	10-855739
45	GROMMET Comment: ELECTRIC NON/HANDLE	25-91782M
46	O-RING Comment: ELECTRIC NON/HANDLE	25-82258M
47	BOLT, (M6 x 16) Comment: ELECTRIC NON/HANDLE	10-811188T	10-811188M, 10-852776 8 ELECTRIC NON/HANDLE
-	POWERHEAD ASSEMBLY	802733A98

Flywheel

Below is the parts list for Mercury 15 (4-STROKE) Flywheel:

Position No.	Part Name	OEM Number	Supersedes
1	NUT, (M16)	11-96650M
2	WASHER	12-96651M
3	FLYWHEEL Comment: (MANUAL)	856031
3	FLYWHEEL Comment: (ELECTRIC)	835397
4	COIL, Charging	835399T	835399
5	BOLT, (M6 x 25)	10-853536
6	COIL, Lighting Comment: (MANUAL)	835387
6	COIL, Lighting Comment: (ELECTRIC)	855944
7	BOLT (M6 X 30) Comment: (MANUAL)	855782
7	BOLT, (M6 x 40) Comment: (ELECTRIC)	10-853531
8	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
9	PULSER	835395
10	BOLT, (M6 x 16)	10-811188T	10-811188M, 10-852776 8
11	NOT SOLD SEPARATE, Decal-Warning Neutral	NSS

Fuel Pump

Below is the parts list for Mercury 15 (4-STROKE) Fuel Pump:

Position No.	Part Name	OEM Number	Supersedes
1	PUMP ASSEMBLY, Fuel	835389T02	835389T 1
2	NOT SOLD SEPARATE, Body	NSS
3	CHECK VALVE	21-41888M
4	DIAPHRAGM	8095613
5	SPRING	24-8095622
6	PLUNGER	8095632
7	SPRING	24-8095623
8	SCREW, (M4 x 30)	10-8095641
9	DIAPHRAGM	8095614
10	SCREW, (M3 x 5)	10-41889M
11	NUT, (M4)	11-8237515
12	PIN	17-8095662
13	FILTER	35-80365M
14	CLAMP	54-82047M
15	HOSE	32-8M0060021	32-852469
16	SCREW, (M6 x 25)	10-855683
17	O-RING	25-825478
18	CLAMP	54-82047M
19	HOSE	32-8M0053527	32-855985
20	CLAMP	54-83577M
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Gear Housing, Driveshaft - 2.00:1 Gear Ratio

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing, Driveshaft - 2.00:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete-Short-Black	1666-8833T33
-	GEAR HOUSING ASSEMBLY, Complete-Short-Gray	1666-8833T34
-	GEAR HOUSING ASSEMBLY, Complete-Long-Black	1666-8833T35
-	GEAR HOUSING ASSEMBLY, Complete-Long-Gray	1666-8833T36
1	GEAR HOUSING ASSEMBLY, Basic-Black	1600-8M0083312	1666-8833A17
1	GEAR HOUSING ASSEMBLY, Basic-Gray	1666-8833A18
2	BUSHING, (.31 x .45 x .50)	23-12009
3	FITTING KIT, Magnetic, Plug Fill/Drain	22-8M0058389	22-67892A06
4	WASHER, Fiber	12-191833
5	SLEEVE ASSEMBLY	822244A1
6	SLEEVE	23-823944
7	BUSHING	23-823943
8	SCREW KIT, (.375-16 x .250)	10-79953Q04
9	WASHER, Fiber	12-191833
10	SCREEN	35-421991
11	SCREW, (.250-14 x .88)	10-13954
12	ANODE ASSEMBLY	97-42121Q02
13	SCREW, (.250-14 x .88)	10-13954
14	SEAL	26-42133
15	GEAR, Pinion - 13-26	43-8219251
16	WASHER	12-41369
17	BEARING, Roller	31-22756
18	BASE ASSEMBLY, Water Pump	46-42040T5
19	GASKET	27-192043
20	SEAL	26-33613
21	RETAINER	42375
22	SCREW, (#10-16 x .500)	10-48408
23	QUAD RING	25-822236
24	SEAL, Oil	26-413651
25	GASKET, Water Pump Plate	27-19202001
26	TUBE ASSEMBLY, Water	32-42185A1
27	FACE PLATE	42200
28	COVER ASSEMBLY	46-42089A2
29	NOT SOLD SEPARATE, Insert	NSS
30	SEAL	26-421021
31	IMPELLER	47-42038Q02
32	KEY ASSEMBLY	28-8M0173458
33	NOT SOLD SEPARATE, Washer	NSS
34	GUIDE	444671
35	SCREW, (M6 x 30)	10-82684430
36	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
37	CAM	42039
38	SHIFT SHAFT Comment: (SHORT)	855280
38	SHIFT SHAFT Comment: (LONG)	855281
39	NUT, (M6) Stainless Steel	11-400212
40	COUPLER	822419
41	SHIFT SHAFT (UPPER)	8529941
42	E RING	53-42389
43	DRIVESHAFT Comment: (SHORT)	45-825537
43	DRIVESHAFT Comment: (LONG)	45-825843
44	THRUST WASHER	12-822248
-	SEAL KIT	26-41365A3
-	PUMP KIT, Water	46-42089A5

Gear Housing, Driveshaft - 2.42:1 Gear Ratio

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing, Driveshaft - 2.42:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete-Black	1665-8669T33
-	GEAR HOUSING ASSEMBLY, Complete-Gray	1665-8669T33
1	GEAR HOUSING ASSEMBLY, Basic-Black	1600-8M0083538	1665-8669A21
1	GEAR HOUSING ASSEMBLY, Basic-Gray	1665-8669A22
2	NOT SOLD SEPARATE, Sleeve	NSS
3	SEAL	26-99325
4	BEARING, Roller	31-41326
5	PIN, Dowel (.187 x .530)	17-8M0084726	17-85500
6	SCREW KIT, (.375-16 x .250)	10-79953Q04
7	WASHER, Fiber	12-191833
8	SCREEN, Water Inlet Port	35-41133
9	SCREW, (M5 x 40)	10-40031112
10	FITTING KIT, Magnetic, Plug Fill/Drain	22-8M0058389	22-67892A06
11	WASHER, Fiber	12-191833
12	SCREEN	35-41134
13	NUT, (M5)	11-400263
14	BEARING ASSEMBLY, Roller	31-98294A1
15	NOT SOLD SEPARATE, Cup	NSS
16	GEAR, Pinion - 12-29	43-854498
17	NUT	11-828490
18	GASKET	27-993261
19	FACE PLATE	85083
20	WASHER	12-866451
21	KEY	28-8M0214993
22	IMPELLER	47-8M0204712
23	WASHER	12-866451
24	O-RING	25-69202
25	PUMP ASSEMBLY, Water	46-99157A02
26	NOT SOLD SEPARATE, Insert	NSS
27	SEAL	26-85090001
28	O-RING	25-86203
29	SCREW, (M6 x 16)	10-8248324
30	SHIFT SHAFT	854503
31	NUT, (M6) Stainless Steel	11-400212
32	COUPLER	822419
33	SHIFT SHAFT (UPPER)	8529941
34	DRIVESHAFT	45-854501
35	BOOT	85552001
36	RETAINER	93878
37	O-RING, (.734 x .139)	25-35276
38	O-RING, (.239 x .174)	25-85594
39	WASHER	12-85091
40	SPRING	24-93007
41	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
42	PIN, (.078 x .437)	17-85593
43	SHIFT CAM	85562A2
44	PIN, Drive	17-85096
45	SLEEVE	23-29804T
-	SEAL KIT	26-85090A2
-	REPAIR KIT, Water Pump	46-99157T2

Gear Housing, Propeller Shaft - 2.00:1 Gear Ratio

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing, Propeller Shaft - 2.00:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete-Short-Black	1666-8833T33
-	GEAR HOUSING ASSEMBLY, Complete-Short-Gray	1666-8833T34
-	GEAR HOUSING ASSEMBLY, Complete-Long-Black	1666-8833T35
-	GEAR HOUSING ASSEMBLY, Complete-Long-Gray	1666-8833T36
1	GEAR HOUSING ASSEMBLY, Basic-Black	1600-8M0083312	1666-8833A17
1	GEAR HOUSING ASSEMBLY, Basic-Gray	1666-8833A18
2	BEARING ASSEMBLY, Roller	31-821321A1
3	NOT SOLD SEPARATE	NSS
4	GEAR ASSEMBLY, Forward (13-26)	43-821924A1
5	BUSHING	23-41367
6	FOLLOWER, Cam	813139	42131
7	CLUTCH ASSEMBLY	52-821930A1
8	PIN, Cross	17-823951
9	SPRING	24-42204
10	PROPELLER SHAFT	44-821929
11	GEAR, Reverse - 13/26	43-821926T1
12	CARRIER ASSEMBLY, Bearing	42144T3
13	O-RING, (1.984 x .139)	25-8M0214923
14	BUSHING	23-821927
15	SEAL	26-99325
16	SEAL, Oil	26-821928
17	SCREW, (M8 x 50)	10-82407110
18	SCREW, (M8 x 30)	10-8240717
19	PROPELLER, (9.00 x 9.00)	48-828156A12	48-42522A12, 48-828156A45
20	NUT, (M10)	11-40140
21	THRUST HUB	8219321
22	SPACER	23-420911
-	SEAL KIT	26-41365A3

Gear Housing, Propeller Shaft - 2.42:1 Gear Ratio

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing, Propeller Shaft - 2.42:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete-Black	1665-8669T33
-	GEAR HOUSING ASSEMBLY, Complete-Gray	1665-8669T33
1	GEAR HOUSING ASSEMBLY, Basic-Black	1600-8M0083538	1665-8669A21
1	GEAR HOUSING ASSEMBLY, Basic-Gray	1665-8669A22
45	TRIM TAB	97-98432Q6
46	SCREW, (M8 x 30)	10-4000354
47	WASHER, (.323 x .563 x .063) Stainless Steel	12-8M0042642	12-70132
48	BEARING ASSEMBLY, Roller	31-8M0103470	31-99328A 1
49	NOT SOLD SEPARATE, Cup	NSS
50	GEAR ASSEMBLY, Forward - 12/29	43-854496A1
51	BUSHING	23-85557
52	FOLLOWER, Cam	85094
53	SPRING	24-38114
54	CLUTCH	52-41040T1
55	PIN	17-8M0020999	17-85093
56	SPRING	24-88680
57	PROPELLER SHAFT	44-8166231
58	GEAR, Reverse - 12/29	43-854497T	43-854497
59	CARRIER ASSEMBLY, Bearing	99906T1
60	BEARING, Roller	31-21739
61	SEAL, Oil (INNER)	26-41132
62	SEAL, Oil (OUTER)	26-41131
63	O-RING	25-85549
64	PLATE	87293
65	SCREW, (M5 x 16)	10-90883
66	SCREW, (M10 x 35) Stainless Steel	10-87810178
67	WASHER	12-43328
68	THRUST HUB ASSEMBLY	851281
69	PROPELLER	48-19636A10
70	PROP NUT	11-88228
-	SEAL KIT	26-85090A2

Intake

Below is the parts list for Mercury 15 (4-STROKE) Intake:

Position No.	Part Name	OEM Number	Supersedes
1	MANIFOLD, Intake	835385T	835385
2	GASKET	27-853525
3	PIN, Dowel	17-82364M
4	BOLT, (M6 x 40)	10-853531
5	INSULATOR	853526
6	GASKET	27-835383
7	O-RING	25-8250572
8	SILENCER	835386T	835386
9	DECAL, Warning, High Voltage	37-8272822
10	PLATE	855781
11	COLLAR	855780
12	BOLT, (M6 x 100)	10-8M0100009	10-855809002, 10-855809
13	HOSE	32-852463
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Intake/Exhaust Valves

Below is the parts list for Mercury 15 (4-STROKE) Intake/Exhaust Valves:

Position No.	Part Name	OEM Number	Supersedes
1	VALVE, Intake	850838T	850838
2	VALVE, Exhaust	850839T	850839
3	SEAT, Valve Spring	855959
4	SPRING, Valve	24-850840
5	RETAINER	822650
6	KEY	28-893554	28-822651
7	SEAL, Valve Stem	26-822647
8	ROCKER ARM ASSEMBLY	850841A1
9	SCREW	10-825046
10	NUT	11-826150	11-858274
11	SHAFT, Rocker	850842
12	COLLAR	825451
13	SPRING	24-825452
14	SPRING	24-825453
-	POWERHEAD ASSEMBLY	802733A98
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Oil Pump/Camshaft

Below is the parts list for Mercury 15 (4-STROKE) Oil Pump/Camshaft:

Position No.	Part Name	OEM Number	Supersedes
1	CAMSHAFT	834956
2	O-RING	25-825462
3	GASKET	27-853523
4	BOLT, (M6 x 35)	10-850879
5	KEY	28-8M0084803	28-84403M
6	SEAL, Oil	26-825455
7	WASHER	12-82710M
8	GEAR, Driven	43-834973T	43-834973
9	WASHER	12-825498
10	BOLT (M6 X 16)	10-826957M	10-91725M
11	PUMP ASSEMBLY, Oil	834967A1
12	GEAR, Drive	43-8M0063224	43-834955
13	WASHER	12-850843
14	NUT, (M28)	11-855679
15	TIMING BELT	57-835392Q	835392
-	POWERHEAD ASSEMBLY	802733A98
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Recoil Starter

Below is the parts list for Mercury 15 (4-STROKE) Recoil Starter:

Position No.	Part Name	OEM Number	Supersedes
1	HANDLE REST	850865A1
2	SEAL	8M0043417
3	HANDLE ASSEMBLY Comment: HANDLE MODELS	85174A1
4	NOT SOLD SEPARATE, Retainer Comment: HANDLE MODELS	NSS
5	LAMP Comment: HANDLE MODELS	8524791
6	SCREW, (M6 x 16)	10-8147762
-	RECOIL ASSEMBLY Comment: MANUAL	8M0049883	850864 MANUAL
7	HOUSING Comment: MANUAL	853541
8	COLLAR Comment: MANUAL	23-852473
9	SHEAVE, Starter Comment: MANUAL	50-8527732
10	PAWL Comment: MANUAL	852777
11	SPRING, Starter Comment: MANUAL	24-852778
12	DRIVEPLATE ASSEMBLY Comment: MANUAL	852780
13	SPRING, Drive Pawl Comment: MANUAL	24-852778T01	24-852778 1 MANUAL
14	SPRING Comment: MANUAL	24-8527782
15	SPRING, Return Comment: MANUAL	24-8527783
16	CIRCLIP Comment: MANUAL	53-852784
17	BOLT Comment: MANUAL	10-852785
18	GROMMET Comment: MANUAL	25-852786
19	ROPE Comment: MANUAL	50-12066Q10
20	STOPPER Comment: MANUAL	8527881
21	SPRING, Return Comment: MANUAL	24-8560361
22	SPRING Comment: MANUAL	24-856036
23	BOLT, (M6 x 20)	10-84058M
24	BOLT, (M6 x 90)	10-855783
25	WASHER	12-82213M
26	NUT, (M6)	11-82390M
27	PLUG, Warning Light Comment: (ELECTRIC NON-HANDLE)	19-858768	19-855741 (ELECTRIC NON-HANDLE)
28	PLUG Comment: (ELECTRIC NON-HANDLE)	19-822513002	19-822513 1 (ELECTRIC NON-HANDLE)
29	HOUSING Comment: ELECTRIC	853541
30	COLLAR Comment: ELECTRIC	23-852473
31	DECAL, Caution, Start In Gear Comment: ELECTRIC	37-881865	37-825064 ELECTRIC
32	NOT SOLD SEPARATE, Decal-Emergency Start Procedure	NSS
33	COVER	855691
34	GROMMET	25-8527681
35	NOT SOLD SEPARATE, Decal-Servicing Referral	NSS

Service/Support Material

Below is the parts list for Mercury 15 (4-STROKE) Service/Support Material:

Part Name	OEM Number	Supersedes
PARTS MANUAL, 15 (4-Stroke)	90-80273898
OWNERS MANUAL	90-10185980
DECAL SET Comment: (BLACK-NON-BIGFOOT)	37-802739A00	37-802739A98 (BLACK-NON-BIGFOOT)
DECAL SET Comment: (BLACK-BIGFOOT)	37-802741A00	37-802741A98 (BLACK-BIGFOOT)
DECAL SET Comment: (GRAY-NON-BIGFOOT)	37-802740A03	37-802740A01, 37-802740A98, 37-802742A98 (GRAY-NON-BIGFOOT)
DECAL SET Comment: (GRAY-BIGFOOT)	37-802740A03	37-802740A01, 37-802740A98, 37-802742A98 (GRAY-BIGFOOT)

Starter Motor

Below is the parts list for Mercury 15 (4-STROKE) Starter Motor:

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 45)	10-4000357
2	WASHER, Bottom	12-4002317
3	STARTER MOTOR ASSEMBLY	50-859168T	50-852570T, 50-852570
4	THRU BOLT	10-965662
5	DRIVE KIT	906432
6	PINION	685752
7	DRIVE CAP	8236391
8	ARMATURE	8236383
9	CAP, Commutator	8119012
10	BRUSH/SPRING KIT	898265016	75384, 75384 1
11	HOLDER	898265014	61787
12	SCREW	F15158

Swivel Bracket

Below is the parts list for Mercury 15 (4-STROKE) Swivel Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	SWIVEL BRACKET Comment: (BLACK)	3415-822237A3
1	SWIVEL BRACKET Comment: (GRAY)	3415-822237A4
2	FITTING, Grease	22-8M0169589
3	FITTING, Grease	22-8M0169589
4	FITTING, Grease	22-8M0169589
5	BUSHING	23-855628A1
6	NOT SOLD SEPARATE, O-Ring	NSS
7	NOT SOLD SEPARATE, Bushing	NSS
8	NOT SOLD SEPARATE, Bushing	NSS
9	NOT SOLD SEPARATE, Washer	NSS
10	ROD Comment: HANDLE	821961
11	DISC Comment: HANDLE	8165621
12	PLATE KIT Comment: HANDLE	821958A1
13	SCREW, (M6 x 13) Stainless Steel Comment: HANDLE	10-40011126
14	BRAKE PLATE Comment: HANDLE	821957
15	WASHER Comment: HANDLE	12-29330
16	HANDLE Comment: HANDLE	821959
17	NUT, (.375-24) Comment: HANDLE	11-8M0204726
18	HOOK ASSEMBLY, Reverse Lock	98830A4
19	SPRING	24-96018
20	SPRING Comment: NON-HANDLE	24-97427
20	SPRING Comment: HANDLE	24-879894	24-12755 HANDLE
21	RING, Retaining Comment: HANDLE	53-13194
22	PIN Comment: HANDLE	17-13195
23	BRACKET Comment: HANDLE	12756
24	SPRING Comment: HANDLE	24-12754
25	LEVER Comment: HANDLE	12758
26	RING, Retaining Comment: HANDLE	53-13194
27	SCREW, (.375-24 x 1.25) Comment: ELECTRIC - NON-HANDLE	10-849838	10-14000 ELECTRIC - NON-HANDLE
28	LINK ROD ASSEMBLY Comment: ELECTRIC - NON-HANDLE	41323A03
29	WASHER, (.390 x .625 x .062) Stainless Steel Comment: ELECTRIC - NON-HANDLE	12-37828
30	NUT, (.375-24) Comment: ELECTRIC - NON-HANDLE	11-8M0204726
31	BRACKET ASSEMBLY Comment: (BLACK) ELECTRIC - NON-HANDLE	96186A2
31	BRACKET, Ride Guide Comment: (GRAY) ELECTRIC - NON-HANDLE	96186A3
32	SCREW, (M10 x 25 MM) Comment: ELECTRIC - NON-HANDLE	10-1993325
33	LOCKWASHER, (M10) Comment: ELECTRIC - NON-HANDLE	13-400248
34	SWIVEL HEAD ASSEMBLY Comment: (BLACK)	854801T2
34	SWIVEL HEAD ASSEMBLY Comment: (GRAY)	854801T3
35	SHAFT, Reverse Lock	858338A3
36	STUD, (M10 x 1.5 x 97)	16-854819
37	WASHER	12-4002320
38	NUT, (M10)	11-4013610
39	MOUNT	8M0039074	42189 2
40	COVER Comment: (STARBOARD) (BLACK)	854729T1
40	COVER Comment: (STARBOARD) (GRAY)	854729T2
41	COVER Comment: (PORT) (BLACK)	854728T1
41	COVER Comment: (PORT) (GRAY)	854728T2
42	SCREW, (M8 x 100)	10-19943100
43	SCREW, (M8 x 60)	10-1994360
44	WASHER	12-36001
45	NUT, (M8) Stainless Steel	11-400213
46	NOT SOLD SEPARATE, Decal-Serial Overlaminate	NSS

Throttle Linkage, Handle Models

Below is the parts list for Mercury 15 (4-STROKE) Throttle Linkage, Handle Models:

Position No.	Part Name	OEM Number	Supersedes
1	HANDLE	825792
2	GROMMET	25-825781
3	SCREW, (M5 x 12)	10-82239312
4	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
5	WASHER	12-8M0214930
6	PULLEY ASSEMBLY	825787A2
7	BUSHING	23-825788
8	NUT, (M6)	11-401366
9	LINK	882818	850871 1
10	PLATFORM	8257863
11	BUSHING	23-825789
12	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
13	SHIFT SHAFT ASSEMBLY, Horizontal Comment: BIGFOOT	852494A6
13	SHIFT SHAFT ASSEMBLY, Horizontal Comment: NON BIGFOOT	852494A5
14	LEVER, Interlock Comment: BIGFOOT	855609
14	LEVER, Interlock Comment: NON BIGFOOT	826063
15	SCREW, (M5 x 35) Stainless Steel	10-40011111
16	SPRING, Detent	24-824992
17	SPRING, Backing	24-824993
18	SPRING, Plate	824994
19	SCREW, (M5 x 12)	10-82239312
20	STRAP	8280471
21	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
22	COVER Comment: MANUAL	852489
22	COVER Comment: ELECTRIC	855743
23	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
24	SWITCH ASSEMBLY	87-11083A30
25	RETAINER, Brass	8M0032846	12044 1
26	LANYARD ASSEMBLY	15920Q54
27	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
28	WIRE Comment: MANUAL	852472
29	BRACKET	855888F
30	SCREW, (M5 x 12)	10-82239312
31	SWITCH ASSEMBLY Comment: ELECTRIC	87-8M0052929	87-813960A 5 ELECTRIC
32	PLATE Comment: ELECTRIC	824923
33	SCREW, (M3.5 x 20) Comment: ELECTRIC	10-82470620

Throttle Linkage, Non-Handle Models

Below is the parts list for Mercury 15 (4-STROKE) Throttle Linkage, Non-Handle Models:

Position No.	Part Name	OEM Number	Supersedes
1	PLUG	826037
2	STRAP	8280471
3	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
4	SCREW, (M5 x 12)	10-82239312
5	SPRING, Plate	824994
6	SPRING, Backing	24-824993
7	SPRING, Detent	24-824992
8	SHIFT SHAFT ASSEMBLY, Horizontal Comment: BIGFOOT	852494A6
8	SHIFT SHAFT ASSEMBLY, Horizontal Comment: NON BIGFOOT	852494A5
9	LEVER, Interlock Comment: BIGFOOT	855609
9	LEVER, Interlock Comment: NON BIGFOOT	826063
10	SCREW, (M5 x 35) Stainless Steel	10-40011111
11	REMOTE CONTROL PLATFORM	835415F
12	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
13	COVER	852498
14	SCREW, (M6 x 20)	10-832047
15	LEVER, Shift Shaft	8524961
16	SCREW, (M5 x 12)	10-82239312
17	SHIFT LINK ASSEMBLY	852497A2
18	SOCKET	817428	830875
19	NUT, Brass	10-32,11-45076
20	SEAL	8354191
21	LEVER, Shift	850856
22	BUSHING	23-91912
23	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
24	RETAINER	822459
25	PUSH NUT	11-825677
26	LEVER, Throttle	850857
27	RETAINER	822459
28	PUSH NUT	11-825677
29	SCREW, (M6 x 45)	10-82129145
30	BUSHING	23-855765
31	SLIDE	828049
32	LINK, Throttle	882817	835420
33	RING, Retaining	53-8237951
34	GROMMET	25-828114
35	PLUG	19-855937
36	CLAMP Comment: ELECTRIC	54-28700
37	SCREW, (M5 x 12) Comment: ELECTRIC	10-82239312

Tiller Handle

Below is the parts list for Mercury 15 (4-STROKE) Tiller Handle:

Position No.	Part Name	OEM Number	Supersedes
-	TILLER ASSEMBLY Comment: (BLACK)	821468T65	821468T10, 821468A10 (BLACK)
-	TILLER ASSEMBLY Comment: (GRAY)	821468T11	821468A11 (GRAY)
1	COVER	822148A3
2	PULLEY	822150
3	NOT SOLD SEPARATE, Case	NSS
4	SCREW, (#10-16 x .500)	10-878608	10-812832
5	CABLE, Throttle	43242T09
6	SLEEVE	85-9600910
7	ARM ASSEMBLY, Steering Handle Comment: (BLACK)	821468A66	821468T 8 (BLACK)
7	ARM ASSEMBLY, Steering Handle Comment: (GRAY)	821468T9
8	SCREW, (M5 x 16) Stainless Steel	10-40011107
9	SCREW, (M5 x 16) Stainless Steel	10-40011107
10	KNOB, Throttle	821972T	821972
11	SPRING	24-96203
12	LOCK, Throttle	892995	821971
13	SCREW, (M6 x 25)	10-8M0204707
14	TILLER TUBE	821463T01	821463A 1
15	DECAL	37-8242003
16	HANDLE, Throttle	821465
17	GRIP	8M0221732
18	SWITCH ASSEMBLY, Stop	87-8M0104613
19	RETAINER	822441
20	BUSHING	23-823939
21	WASHER	12-822145
22	WAVE WASHER	13-826792	13-34678 1, 13-822144
23	WASHER	12-822146
24	BRACKET Comment: (BLACK)	822841F1
24	BRACKET Comment: (GRAY)	822841F2
25	SCREW, (M10 x 80)	10-4000384
26	PLATE	826648
27	HOUSING Comment: ELECTRIC HANDLE	889734	823917 2 ELECTRIC HANDLE
28	CLIP Comment: ELECTRIC HANDLE	824918
29	SWITCH ASSEMBLY Comment: ELECTRIC HANDLE	87-823609A8
30	DECAL Comment: ELECTRIC HANDLE	37-855262

Tools

Below is the parts list for Mercury 15 (4-STROKE) Tools:

Position No.	Part Name	OEM Number	Supersedes
1	NOT SOLD SEPARATE, Wrench-Oil Filter (Obtain Locally)	NSS
2	HOLDER TOOL, Flywheel	91-8M0161873
3	FLYWHEEL PULLER	91-83164M
4	COMPRESSOR TOOL, Piston Ring	FT2997	FJ7081, FJ8785, FJ8786, FJ8787, FJ8788, FJ8789
5	STAND TOOL, Powerhead	91-83190M
6	COMPRESSOR TOOL, Valve Spring	91-809494A1
7	REMOVER TOOL, Valve Guide	91-809495001	91-809495A 1
8	INSTALLER TOOL, Valve Guide Bushing	91-809496A1
9	REAMER TOOL, Valve Guide	91-809497A1
10	NOT SOLD SEPARATE, jValve Seat Cutter Kit-Obtain Locally	NSS
11	GAUGE TOOL, Carburetor	91-36392
12	PULLER PLATE	91-37241
13	PULLER ASSEMBLY, Bearing	91-83165T
14	PULLER ASSEMBLY, Slide Hammer	91-34569A1
15	INSTALLER TOOL, Bearing	91-13664
16	REMOVAL TOOL, Bearing	91-824788A1
17	INSTALLATION TOOL, Driveshaft Bushing	91-824790A1
18	MANDREL	91-13658T
19	REMOVAL TOOL, Bushing	91-824787
20	INSTALLER TOOL, Bushing And Seal	91-824785T1
21	PLATE	91-29310
22	NOT SOLD SEPARATE, Expanding Rod (SNAP-ON #CG40-4)	NSS
23	NOT SOLD SEPARATE, Collet (Jaws)(SNAP-ON #CG40A6)	NSS
24	TESTER KIT	FT8950

Top Cowl

Below is the parts list for Mercury 15 (4-STROKE) Top Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	TOP COWL ASSEMBLY Comment: (BLACK)	114-852413T3
1	TOP COWL ASSEMBLY Comment: (SILVER)	114-852413T4
2	BRACKET	852490F
3	COVER	827702T	827702
4	LATCH	826649
5	SCREW, (M4 x 12)	10-8231872
6	LOCKWASHER, Stainless Steel	8,13-26995
7	NUT, (M4)	11-8237515
8	NOT SOLD SEPARATE, Insert	NSS
9	NOT SOLD SEPARATE, Screw (#10 X .5)	NSS
10	BRACKET ASSEMBLY	852491A1
11	SCREW, (M6 x 16)	10-4006731
12	ROLLER	18745
13	SEAL, Cowl	8M0043391	828237 1
14	ROPE AND HANDLE KIT, Manual/Emergency Start	47341A11
15	NOT SOLD SEPARATE, Rope	NSS

Visual Warning

Below is the parts list for Mercury 15 (4-STROKE) Visual Warning:

Position No.	Part Name	OEM Number	Supersedes
1	PLATE ASSEMBLY, Lamp Mounting	17334A4
2	LAMP	88-17429
3	BRACKET	76424
4	STUD, (#10-32 x 2.00)	16-55422
5	WASHER, (.200 x .440 x .032)	12-24676
6	NUT, Stainless Steel	10-32,11-68219
7	TERMINAL BLOCK	86-45915
8	SCREW, (#8 x .625)	10-16324
9	SCREW, (#10-16 x .375)	10-878607	10-817626
10	CABLE ASSEMBLY	84-11149A3
11	INSULATOR, (2.00 Inch)	85-623594
12	SCREW, (#10-32 x .250)	10-24231
13	NUT AND LOCKWASHER,	10-32,11-27164

Download this page as PDF: Click here

For Mercury Owners:

To assist you in maintaining and repairing your marine engines, we hope the following resources may be of use:

Mercury / Mercruiser / Mariner Parts from JLM Marine

About JLM Marine

Founded in 2002, JLM Marine has established itself as a dedicated manufacturer of high-quality marine parts, based in China. Our commitment to excellence in manufacturing has earned us the trust of top marine brands globally.

As a direct supplier, we bypass intermediaries, which allows us to offer competitive prices without compromising on quality. This approach not only supports cost-efficiency but also ensures that our customers receive the best value directly from the source.

We are excited to expand our reach through retail channels, bringing our expertise and commitment to quality directly to boat owners and enthusiasts worldwide.