Mercury 15 (4-STROKE) (0G760300 THRU 1B226999) Outboard Motor Parts Diagram & Catalog – Free PDF Download

by JLM Marine 30 Apr 2025 0 Comments

Mercury 15 (4-STROKE) Outboard Motor Parts Diagram & Catalog – Free PDF Download

Accessories

Below is the parts list for Mercury 15 (4-STROKE) Accessories:

Part Name	OEM Number	Supersedes
CHARGING KIT, 10 Ampere	856557A1
CHARGING KIT, Battery	856558A2
STARTER MOTOR KIT, Electric	50-856555A1
HOSE ASSEMBLY, Fuel Comment: (Original Equipment)	32-858610A38	32-858610A19, 32-858697A 2 (Original Equipment)
HOSE ASSEMBLY, Fuel (8 Feet) Comment: (With Quick Disconnect)	32-877680Q8
HOSE ASSEMBLY, Fuel (12 Feet) Comment: (With Quick Disconnect)	32-877680Q12	32-858620Q12, 32-858620A12, 32-827927A12 (With Quick Disconnect)
HOSE ASSEMBLY, Fuel (8 Feet) Comment: ((With Quick Disconnect Engine End Only)	32-877681Q8
HOSE ASSEMBLY, Fuel (12 Feet) Comment: (With Quick Disconnect Engine End Only)	32-877681Q12	32-804792Q12, 32-804792Q, 32-858621Q12, 32-858621A12, 32-17146A12 (With Quick Disconnect Engine End Only)
HOSE ASSEMBLY, Fuel (12 Feet) Comment: (No Fittings)	32-877683Q12	32-858623Q12, 32-858623A12, 32-822379A12, 32-819380A12, FA599752, FS409752, 32-819380A 3, F216752, FA409752, F289752, FA178752, FA216752, FA284752, FA289752, FS409952 (No Fittings)
ATTACHING KIT, Remote Control	856553A2
HARNESS KIT, Remote Control	84-856554A1
TILLER HANDLE KIT Comment: (Black)	856537A5
SWITCH KIT, Tiller Handle Start Button	856556A2

Bottom Cowl

Below is the parts list for Mercury 15 (4-STROKE) Bottom Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	BOTTOM COWL Comment: (Black)	4000-835416A1
2	COVER	25-857002	25-826808
3	LATCH HOOK	852480
4	SCREW, (M6 x 16)	10-4006731
5	WASHER	12-8M0214930
6	BUSHING	23-826618
7	GROMMET	25-828129
8	WASHER, (.281 x .734 x .063)	12-69057
9	GROMMET	25-855289T	25-855289
10	LEVER, Cowl Latch Comment: (Black)	825782F1
11	SCREW, (M6 x 35 MM)	10-1993735
12	BUSHING	23-812707	23-71984, 23-F286818, 23-F286828, F480818
13	WASHER, Wave	13-12134
14	CONNECTOR, Fuel - Brass	22-8M0182334
15	SCREW, (M6 x 25) Stainless Steel	10-40011129
16	GROMMET, Fuel Connector	25-18202
17	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
18	TUBING, (13.00 Inches) Comment: SN# 0T003862 & Up	32-85682931
18	HOSE, (.187) (26.00 Inches Bulk) Comment: (Cut to 21 Inch Length) SN# 0T003861 & Below	32-9912878
19	PLUG	826037
20	FITTING	22-813613
21	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
22	NOT SOLD SEPARATE, Decal Unleaded Fuel Comment: (Bodensee)	NSS
23	SHIFT DECAL Comment: (Handle) (Use Where Applicable)	37-111851

Carburetor

Below is the parts list for Mercury 15 (4-STROKE) Carburetor:

Position No.	Part Name	OEM Number	Supersedes
1	CARBURETOR Comment: (9.9)	3323-856919T2
1	CARBURETOR Comment: (8/9.9 Bodensee)	3323-835382A2
1	CARBURETOR Comment: (15 Bodensee)	3323-856918A1
1	CARBURETOR Comment: (13.5/15) (Without Tamper Cap)	3323-835382T04	3323-835382T 3 (13.5/15) (Without Tamper Cap)
1	CARBURETOR Comment: (13.5/15) (With Tamper Cap)	3323-835382T04	3323-835382T 3 (13.5/15) (With Tamper Cap)
-	CAP, Tamper	19-854248002
2	SCREW, (M4 x 10)	10-809571
3	COVER	8095721
4	GASKET	809573
5	SCREW, Throttle	10-8095781
6	SPRING	24-8095791
7	SCREW, (M4 x 5)	10-811248M	10-852787 3
8	COVER	802705
9	SCREW, (M3 x 5)	10-8026921
10	PILOT JET,	45,8027011
11	PLUG	19-802702
12	MAIN NOZZLE Comment: (13.5/15)	802700
12	MAIN NOZZLE Comment: (15 Bodensee)	8027001
12	MAIN NOZZLE Comment: (8/9.9)	8027002
13	O-RING	25-11802M
14	JET, Main Comment: (13.5/15)	104,802701
14	JET, Main Comment: (15 BODENSEE)	103,8027012
14	JET, Main Comment: (8/9.9)	68,8027013
15	SCREW, (M4 x 5)	10-8095711
16	VALVE, Needle	8095701
17	FLOAT	809569
18	PIN	17-11794M
19	GASKET	27-802699	27-802699 1
20	FILTER	35-802704
21	FLOAT BOWL ASSEMBLY Comment: (13.5/15) SN# USA-0T800999/BEL-0P267999 & Below	802690T3
21	FLOAT BOWL ASSEMBLY Comment: (13.5/15) SN# USA-0T801000/BEL-0P268000 & Up	802690T3
21	FLOAT BOWL ASSEMBLY Comment: (8/9.9)	802690T2
22	RING, Retaining Comment: (13.5/15)	53-802693
23	CAP Comment: (13.5/15)	802698
24	SEAL Comment: (13.5/15)	802697
25	DIAPHRAGM Comment: (13.5/15)	802695
26	SPRING Comment: (13.5/15)	24-802696
27	PLATE Comment: (13.5/15)	802694
28	SCREW, (M4 x 8) Comment: (13.5/15)	10-802692
29	PLUG, Drain (M4 x 5) Comment: (13.5/15)	22-14183M
30	GASKET Comment: (13.5/15)	27-8026911
31	SCREW, Drain (M5 x 6) Comment: (Not Included With 8/9.9 Bowl)	10-8095783
32	GASKET Comment: (Not Included With 8/9.9 Bowl)	27-802691
33	SCREW, (M4 x 12)	10-81758M
34	CHECK VALVE Comment: (13.5/15)	21-802703
35	NOT SOLD SEPARATE, Spring-Air Adjusting	NSS
36	NOT SOLD SEPARATE, O-Ring	NSS
37	NOT SOLD SEPARATE, Screw-Air Adjusting	NSS
38	PLUG	19-855237	19-802702003, 19-809583
39	SEAL, Rubber Comment: (Bodensee)	26-827737
40	STOP, Throttle Comment: (8 Bodensee)	859200
41	PUSH NUT Comment: (8 Bodensee)	11-821285
-	REPAIR KIT, Carburetor	802706A1

Clamp Bracket

Below is the parts list for Mercury 15 (4-STROKE) Clamp Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	BRACKET ASSEMBLY, Transom Comment: (Starboard) (Black)	1497-8796A7
2	BRACKET ASSEMBLY, Transom Comment: (Port) (Black)	1497-8794A9
3	THUMB SCREW ASSEMBLY Comment: (2.68) (Not included With Clamp Bracket Replacement)	10-92767A6
3	THUMB SCREW ASSEMBLY, (16 mm) Comment: (3.68)	10-92767A3
4	NOT SOLD SEPARATE, Rivet	NSS
5	NOT SOLD SEPARATE, Handle	NSS
6	SHOULDER SCREW, Hex	10-768042
7	WASHER, Thumb Screw	12-73719
8	NUT, (.250-28) Stainless Steel	11-826709109	11-33825, 11-35045
9	NUT, (.875)	11-93164
10	SCREW, (M6 x 40)	10-4000333
11	HANDLE, Carrying	41042
12	SPACER	23-818538
13	WASHER, Nylon, Tilt Tube	12-71421
14	TILT TUBE	8M0035075	883068, 41171
15	WASHER, Nylon, Tilt Tube	12-71421
16	DECAL, Co-Pilot Comment: (Handle Models)	37-8237011
17	PIN ASSEMBLY, Tilt	17-56373A2
18	SPRING	24-92995
19	SCREW, (M6 x 40)	10-4000333
20	NUT, (.875)	11-93164
21	CLIP, Safety	54-8M0085928	54-30954
22	SCREW, (.312-18 x 3.500) Stainless Steel	10-814945	F1417
23	WASHER	12-67981
24	NUT, (.312)	11-815848
25	NUT, (.250-28) Stainless Steel	11-826709109	11-33825, 11-35045
26	SCREW, (.250-28 x 1.00)	10-41523
27	LEVER, Tilt Stop-Starboard Side	96965
28	NUT, (.250-28) Stainless Steel	11-826709109	11-33825, 11-35045
29	SPRING, Tilt Stop Lever Screw	24-44581
30	SCREW, (.250-28 x 1.75)	10-41524
31	SCREW, (.250-28 x 1.75)	10-41524
32	WAVE WASHER, Tilt Stop Strap Screw	13-31030
33	NUT, (.250-28) Stainless Steel	11-826709109	11-33825, 11-35045
34	STRAP, Tilt Stop-Port Side	90901
35	SCREW, (.250-28 x 1.00)	10-41523

Crankshaft, Pistons, And Connecting Rods

Below is the parts list for Mercury 15 (4-STROKE) Crankshaft, Pistons, And Connecting Rods:

Position No.	Part Name	OEM Number	Supersedes
1	CRANKSHAFT	400-834957
2	SEAL, Oil	26-855680
3	SEAL, Oil	26-855681
4	BEARING Comment: (Brown)	31-834960
4	BEARING Comment: (Black)	31-83496010
4	BEARING Comment: (Blue)	31-83496020
5	CONNECTING ROD	600-834961T1
6	BOLT, (M7 x 38)	10-850844
7	WASHER	12-855682
8	PISTON	700-834963T	700-834963
9	RING, Piston	39-850846
10	RING, Piston	39-850847
11	RING, Oil	39-825839
12	PIN, Piston	41-825713
13	CLIP	53-82343M
14	KEY Comment: SN# USA-0T800999/BEL-0P267999 & Below	28-8M0057164	28-81914M SN# USA-0T800999/BEL-0P267999 & Below
14	KEY Comment: SN# USA-0T801000/BEL-0P268000 & Up	28-8M0057164	28-81914M SN# USA-0T801000/BEL-0P268000 & Up
15	KEY	28-8M0084803	28-84403M
-	POWERHEAD ASSEMBLY Comment: (Electric)	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178499 & Below	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178500/BEL-0P094500 & Up	879783A01
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Cylinder Block and Covers

Below is the parts list for Mercury 15 (4-STROKE) Cylinder Block and Covers:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER BLOCK	900-8M0055024	900-835407A02, 900-835407A 1
2	PIN, Dowel	17-825689
3	BOLT, (M8 x 55)	10-8M0101617
4	BOLT, (M6 x 14)	10-43092M
5	PIPE PLUG	22-822644
6	GASKET	27-834952002	27-834952
7	COVER, Exhaust	834953T02	834953T, 834953
8	FITTING	22-83326M
9	THERMOSTAT, (60C/140F) Comment: SN# USA-0T979999/BEL-0P325499 & Below	855676003	825212001, 825212, 855676 SN# USA-0T979999/BEL-0P325499 & Below
9	THERMOSTAT, (60C/140F) Comment: SN# USA-0T980000/BEL-0P325500 & Up	855676A1
10	COVER, Thermostat	8M0188835
11	GASKET	27-8M0177107
12	BOLT, (M6 x 30)	10-82500930
13	HOSE	8M0060022	32-855694
14	CLAMP Comment: SN# USA-0T800999/BEL-0P267999 & Below	54-888441	54-884385 SN# USA-0T800999/BEL-0P267999 & Below
14	CLAMP, Oetiker (12.8 mm) Comment: SN# USA-0T801000/BEL-0P268000 & Up	54-888441	54-884385 SN# USA-0T801000/BEL-0P268000 & Up
15	HOSE, (57.00 Inches Bulk), To Telltale Comment: (Cut to 14 Inch Length) SN# USA-0T003862 & Up	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821 (Cut to 14 Inch Length) SN# USA-0T003862 & Up
15	HOSE, (57.00 Inches Bulk), To Telltale Comment: (Cut to 16 Inch Length) SN# USA-0T003861 & Below	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821 (Cut to 16 Inch Length) SN# USA-0T003861 & Below
16	FILTER, Oil Comment: SN# USA-0T800999/BEL-0P267999 & Below	35-8M0162832
16	FILTER ASSEMBLY, Oil Comment: SN# USA-0T801000/BEL-0P268000 & Up	35-8M0162832
17	NIPPLE, (M20)	822625
18	GROMMET	25-855690
19	BREATHER COVER	834974
20	SEAL	26-850850
21	BOLT, (M6 x 20)	10-8257021
22	PLATE, Oil Deflection Comment: SN# USA-0G960500 & Up	855922A2
23	GASKET Comment: SN# USA-0G960500 & Up	27-8354272
24	PLATE, Oil Deflection Comment: SN# USA-0G960499 & Below	855922A2
25	GASKET Comment: SN# USA-0G960500 & Below	27-8354271
26	SCREW, (M8 x 35) Stainless Steel	10-40011151
27	WASHER	12-4002317
28	ANODE	97-8M0099896	97-855678
29	GROMMET	25-825040
30	COVER	855776
31	BOLT, (M5 x 12)	10-855778
32	PLATE	855779
33	BOLT, (M6 x 20)	10-8257021
34	CABLE, Choke Comment: (Handle)	8533442
35	NUT, (.375-24) Comment: (Handle)	11-46335
36	BRACKET Comment: (Handle)	855732
37	RING, Retaining Comment: (Handle)	53-27290
38	SCREW, (M6 x 13) Stainless Steel Comment: (Handle)	10-40011126
39	SOCKET Comment: (Handle)	817428	830875 (Handle)
40	DIPSTICK	19-8354262
41	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
42	PIPE JOINT	22-8830591
43	HOSE Comment: SN# USA-0T979999/BEL-0P325499 & Below	32-896122	32-852485 SN# USA-0T979999/BEL-0P325499 & Below
43	HOSE Comment: SN# USA-0T980000/BEL-0P325500 & Up	32-896122	32-852485 SN# USA-0T980000/BEL-0P325500 & Up
44	SCREEN, Oil	852484
45	CLAMP	54-8556951
46	CLAMP	54-8556961
-	POWERHEAD ASSEMBLY Comment: (Electric)	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178499 & Below	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178500/BEL-0P094500 & Up	879783A01
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Cylinder Head

Below is the parts list for Mercury 15 (4-STROKE) Cylinder Head:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER HEAD ASSEMBLY Comment: (Electric)(Use with 32mm Camshaft)	900-835430A1
1	CYLINDER HEAD ASSEMBLY Comment: (Electric)(Use with 35mm Camshaft)	835430T08
1	CYLINDER HEAD ASSEMBLY Comment: (Manual)(Use with 32mm Camshaft) SN# USA-0T178499 & Below	900-835430A1
1	CYLINDER HEAD ASSEMBLY Comment: (Manual)(Use with 32mm Camshaft) SN# USA-0T178500/BEL-0P094500 & Up	900-835430A2
1	CYLINDER HEAD ASSEMBLY Comment: (Manual)(Use with 35mm Camshaft) SN# USA-0T178500/BEL-0P094500 & Up	835430T08
2	GUIDE, Intake	850835
3	CIRCLIP	53-825038	825722
4	PIPE PLUG	22-822644
5	BOLT, (M8 x 78)	10-855677
6	PIN, Dowel	17-825689
7	SCREW, (M6 x 25)	10-893745025
8	GASKET	27-8M0052705	27-850836
9	COVER	834954
10	SEAL	850837
11	BOLT, (M6 x 20)	10-8257021
12	SPARK PLUG, NGK-DPR6EA-9	33-827858Q	33-827858
13	PLUG ASSEMBLY, Oil	859578A1
14	NOT SOLD SEPARATE, O-Ring	NSS
15	NOT SOLD SEPARATE, Decal-recomm. Eng. Oil/Valve Cle.	NSS
-	POWERHEAD ASSEMBLY Comment: (Electric)	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178499 & Below	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178500/BEL-0P094500 & Up	879783A01
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Driveshaft Housing

Below is the parts list for Mercury 15 (4-STROKE) Driveshaft Housing:

Position No.	Part Name	OEM Number	Supersedes
1	HOUSING, Driveshaft Comment: (Short Non-Bigfoot) (Long Bigfoot)	1505-852995F1
1	HOUSING, Driveshaft Comment: (Long Non-Bigfoot)(X-Long BigfootI)	1506-835409T1
2	MOUNT, Upper Comment: SN# USA-0T800999/BEL-0P267999 & Below	835410T2
2	MOUNT, Upper Comment: SN# USA-0T801000/BEL-0P268000 & Up	835410T2
2	MOUNT, Upper Comment: (Bigfoot)	856157T	856157 (Bigfoot)
3	SCREW, (M8 x .98)	10-8136911
4	BUMPER	826276
5	GASKET	27-8M0204692
6	PLUG, Drain	8288181
7	COVER	853577T
8	GASKET	27-854617
9	SCREW, (M6 x 16)	10-4006731
10	SEAL	26-827947
11	TUBE, Water Comment: (Short)	32-852993
11	TUBE, Water Comment: (Long)	32-855260
11	TUBE, Water Comment: (Long Bigfoot)	32-855252
11	TUBE, Water Comment: (X-Long Bigfoot)	32-855253
12	SEAL	26-8272411
13	SEAL, Oil	26-413651
14	SEAL	852432
15	BRACKET	856179
16	SLEEVE	856196
17	COVER Comment: (Port) (Black)	850862F2
18	COVER Comment: (Starboard) (Black)	850863F2
19	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
20	NUT, (M6) Stainless Steel	11-401386
21	BUMPER	8224211
22	GROMMET	25-855299
23	ADAPTOR Comment: (Black) (Bigfoot)	853963F1
24	BUSHING, (.31 x .45 x .50) Comment: (Bigfoot)	23-12009
25	SCREW, (M8 x 50) Comment: (Bigfoot)	10-82407110
26	SCREW, (M8 x 30) Comment: (Bigfoot)	10-8240717
27	RELIEF VALVE ASSEMBLY	825578A1
28	O-RING	25-825579
29	PIN, Dowel	17-82364M
30	PLUG	22-68307

Electrical Components

Below is the parts list for Mercury 15 (4-STROKE) Electrical Components:

Position No.	Part Name	OEM Number	Supersedes
1	BRACKET Comment: (Electric)	835403T1
1	BRACKET Comment: (Manual)	835403T	835403 (Manual)
2	CLAMP	54-855686
3	BOLT, (M6 x 20)	10-855810
4	SCREW, (M6 x 25 MM)	10-8248326
5	WASHER	12-855811
6	GROMMET	25-97687M
7	COLLAR	23-852473
8	RECTIFIER/REGULATOR Comment: (Electric)	854650T2
9	BOLT, (M6 x 16) Comment: (Electric)	10-811188T	10-811188M, 10-852776 8 (Electric)
10	CAP, Female Comment: (Electric)	13540
10	PLUG, Male Comment: (Electric)	13541
11	CABLE ASSEMBLY, Brown/White Comment: (Electric)	84-11149A43
12	CABLE ASSEMBLY Comment: (Electric)	84-824372A1
13	BRACKET Comment: (Electric)	8M0010250	95643M (Electric)
14	RELAY Comment: (Electric)	825096T01	89-825096T, 89-825096, 89-95642M (Electric)
15	WASHER Comment: (Electric)	12-827205
16	NUT, (M6) Comment: (Electric)	11-827204
17	LOCKWASHER, (M6) Comment: (Electric)	13-400256
18	NUT, (M6) Stainless Steel Comment: (Electric)	11-400212
19	BOOT Comment: (Electric)	85-826574
20	LEAD WIRE Comment: (Electric)	855742
21	NUT, (.250-20) Brass Comment: (Electric)	11-94330
22	HARNESS ASSEMBLY, Engine Wiring Comment: (Electric)	84-859312T1
23	RETAINER Comment: (Electric)	92753
24	CABLE ASSEMBLY, Battery - Positive Comment: (Electric)	84-88439A29
25	CABLE ASSEMBLY, Battery - Negative Comment: (Electric)	84-88439A30
26	HARNESS ASSEMBLY, Fuse Comment: (1 Piece Design)	84-859451A1
27	FUSE, Yellow - 20 Ampere Comment: (1 Piece Design)	88-812619	88-860608 (1 Piece Design)
28	COVER, Fuse Comment: (1 Piece Design)	828054
29	SCREW, (M6 x 12) Comment: (1 Piece Design)	10-82130012
30	WASHER, (.281 x .500 x .060) Stainless Steel Comment: (1 Piece Design)	12-8M0204649
31	CABLE ASSEMBLY, Fuse Comment: (Multi-Piece Design)	84-859451A1
32	FUSE, 20 Ampere Comment: (Multi-Piece Design)	88-8M0207796
33	CABLE ASSEMBLY, Fuse Comment: (Multi-Piece Design)	84-95084A19
34	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
35	CABLE ASSEMBLY Comment: (Handle)	84-824912A6
36	CDI UNIT	835401T1
37	BOLT, (M6 x 20)	10-84058M
38	COIL ASSEMBLY, Ignition - Includes Leads and Boots	855685T	855685
39	HIGH TENSION LEAD	84-825102A1
40	GROMMET	25-82069M
41	SWITCH, Oil Pressure	853524
42	NOT SOLD SEPARATE, Screw	NSS
43	LEAD WIRE	853537
44	RECTIFIER/REGULATOR Comment: (Manual)	835406
45	BOLT, (M6 x 16) Comment: (Manual)	10-811188T	10-811188M, 10-852776 8 (Manual)
46	SOLENOID ASSEMBLY Comment: (Electric Non/Handle)	89-853598T	89-853598 (Electric Non/Handle)
47	BRACKET Comment: (Electric Non/Handle)	853599T	853599 (Electric Non/Handle)
48	HOOK WIRE Comment: (Electric Non/Handle)	853601
49	SCREW, (M5 x 8) Comment: (Electric Non/Handle)	10-855739
50	GROMMET Comment: (Electric Non/Handle)	25-91782M
51	O-RING Comment: (Electric Non/Handle)	25-82258M
52	BOLT, (M6 x 16) Comment: (Electric Non/Handle)	10-811188T	10-811188M, 10-852776 8 (Electric Non/Handle)
-	POWERHEAD ASSEMBLY Comment: (Electric)	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178499 & Below	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178500/BEL-0P094500 & Up	879783A01

Extension Kit-Driveshaft Housing (828032A1/A2)

Below is the parts list for Mercury 15 (4-STROKE) Extension Kit-Driveshaft Housing (828032A1/A2):

Position No.	Part Name	OEM Number
1	EXTENSION KIT Comment: (Black)	828032A1
1	EXTENSION KIT Comment: (Silver)	828032A2
2	BUSHING, (.31 x .45 x .50)	23-12009
3	BUSHING	23-123691
4	HOUSING	123702
5	RETAINER	14107001
6	RING, Snap	53-14094
7	DRIVESHAFT, (X-Long)	45-826745
8	SHIFT SHAFT	826874
9	TUBE, Water (X-Long)	32-827231
10	SCREW, (M8 x 50)	10-82407110
11	SCREW, (M8 x 30)	10-8240717
12	QUAD RING	25-822236
13	GASKET	27-192043
14	GASKET	27-19202001

Flywheel

Below is the parts list for Mercury 15 (4-STROKE) Flywheel:

Position No.	Part Name	OEM Number	Supersedes
1	NUT, (M16)	11-96650M
2	WASHER	12-96651M
3	FLYWHEEL Comment: (Manual)	856031
3	FLYWHEEL Comment: (Electric)	835397
4	COIL, Charging	835399T	835399
5	BOLT, (M6 x 25)	10-853536
6	COIL, Lighting Comment: (Manual)	835387
6	COIL, Lighting Comment: (Electric)	855944
7	BOLT, (M6 x 30) Comment: (Manual)	10-858530	10-879194068 (Manual)
7	BOLT, (M6 x 40) Comment: (Electric)	10-853531
8	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
9	PULSER	835395
10	BOLT, (M6 x 16)	10-811188T	10-811188M, 10-852776 8
11	NOT SOLD SEPARATE, Decal-Warning Neutral	NSS

Fuel Pump

Below is the parts list for Mercury 15 (4-STROKE) Fuel Pump:

Position No.	Part Name	OEM Number	Supersedes
1	PUMP ASSEMBLY, Fuel	835389T02	835389T 1
2	NOT SOLD SEPARATE, Body	NSS
3	CHECK VALVE	21-41888M
4	DIAPHRAGM	8095613
5	SPRING	24-8095622
6	PLUNGER	8095632
7	SPRING	24-8095623
8	SCREW, (M4 x 30)	10-8095641
9	DIAPHRAGM	8095614
10	SCREW, (M3 x 5)	10-41889M
11	NUT, (M4)	11-8237515
12	PIN	17-8095662
13	FILTER, Fuel, To Fuel Connector Comment: SN# 0T003862 & Up	35-816296A3
13	FILTER, To Fuel Connector Comment: SN# 0T003861 & Below	35-80365M
14	TIE STRAP, (8.00 Inches) Comment: SN# 0T003862 & Up	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275 SN# 0T003862 & Up
14	CLAMP Comment: SN# 0T003861 & Below	54-82047M
15	HOSE, Molded Comment: SN# 0T003862 & Up	32-896273
15	HOSE (2.44 Inches) Comment: SN# 0T003861 & Below	32-8M0060021	32-852469 SN# 0T003861 & Below
16	SCREW, (M6 x 25)	10-855683
17	O-RING	25-825478
18	CLAMP	54-82047M
19	HOSE, To Carb	32-8M0053527	32-855985
20	CLAMP	54-83577M
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Fuel Tank

Below is the parts list for Mercury 15 (4-STROKE) Fuel Tank:

Position No.	Part Name	OEM Number	Supersedes
1	TANK ASSEMBLY, Fuel	1260-859060A2
2	CAP ASSEMBLY, Fuel	36-816976Q1
3	GASKET, Fuel Cap	27-8169771
4	CONNECTOR KIT, Fuel	22-8M0175544
5	NOT SOLD SEPARATE, Connector	NSS
6	O-RING	25-823533	25-18471
7	NOT SOLD SEPARATE, Tube	NSS
8	SCREEN	35-823534	35-18029

Gear Housing(Driveshaft)(2.00:1 Gear Ratio)

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing(Driveshaft)(2.00:1 Gear Ratio):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete (2.60 Inch/102 mm Torpedo Diameter) Comment: (Short - Black)	1666-8833T33
-	GEAR HOUSING ASSEMBLY, Complete (2.60 Inch/102 mm Torpedo Diameter) Comment: (Long - Black)	1666-8833T35
1	GEAR HOUSING ASSEMBLY, Basic-Black Comment: (Basic - Black)	1600-8M0083312	1666-8833A17 (Basic - Black)
2	BUSHING, (.31 x .45 x .50)	23-12009
3	SCREW KIT, (.375-16 x .250) Drain	10-79953Q04
3	FITTING KIT, Magnetic, Plug Fill/Drain Comment: SN# USA-0T979999/BEL-0P325499 & Below	22-8M0058389	22-67892A06 SN# USA-0T979999/BEL-0P325499 & Below
3	PLUG KIT, Drain (Magnetic) Comment: SN# USA-0T980000/BEL-0P325500 & Up	22-8M0058389	22-67892A06 SN# USA-0T980000/BEL-0P325500 & Up
4	SEAL	12-191833
5	SLEEVE ASSEMBLY	822244A1
6	SLEEVE	23-823944
7	BUSHING	23-823943
8	SCREW KIT, (.375-16 x .250) Drain	10-79953Q04
9	SEAL	12-191833
10	SCREEN	35-421991
11	SCREW, (.250-14 x .88)	10-13954
12	ANODE ASSEMBLY	97-42121Q02
13	SCREW, (.250-14 x .88)	10-13954
14	SEAL	26-42133
15	GEAR, Pinion - 13-26	43-8219251
16	WASHER, Thrust	12-41369
17	BEARING, Roller	31-22756
18	BASE ASSEMBLY, Water Pump	46-42040T5
19	GASKET	27-192043
20	SEAL	26-33613
21	RETAINER	42375
22	SCREW, (#10-16 x .500)	10-48408
23	QUAD RING	25-822236
24	SEAL, Oil	26-413651
25	GASKET, Water Pump Plate Comment: SN# USA-0T979999/BEL-0P325499 & Below	27-19202001
25	GASKET Comment: SN# USA-0T980000/BEL-0P325500 & Up	27-19202001
26	TUBE ASSEMBLY, Water	32-42185A1
27	FACE PLATE	42200
28	COVER ASSEMBLY	46-42089A2
29	NOT SOLD SEPARATE, Insert	NSS
30	SEAL	26-421021
31	IMPELLER Comment: SN# USA-0T800999/BEL-0P267999 & Below	47-42038Q02
31	IMPELLER Comment: SN# USA-0T801000/BEL-0P268000 & Up	47-42038Q02
32	KEY ASSEMBLY	28-8M0173458
33	NOT SOLD SEPARATE, Washer	NSS
34	GUIDE	444671
35	SCREW, (M6 x 30)	10-82684430
36	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
37	CAM	42039
38	SHIFT SHAFT Comment: (Short)	855280
38	SHIFT SHAFT Comment: (Long)	855281
39	NUT, (M6) Stainless Steel	11-400212
40	COUPLER	822419
41	SHIFT SHAFT (Upper)	8529941
42	E RING	53-42389
43	DRIVESHAFT Comment: (Short)	45-825537
43	DRIVESHAFT Comment: (Long)	45-825843
44	THRUST WASHER	12-822248
-	SEAL KIT	26-41365A3
-	PUMP KIT, Water	46-42089A5

Gear Housing(Driveshaft)(2.42:1 Gear Ratio)

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing(Driveshaft)(2.42:1 Gear Ratio):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete (3.30 Inch/130 mm Torpedo Diameter) Comment: (Long - Black)	1665-8669T33
-	GEAR HOUSING ASSEMBLY, Complete (3.30 Inch/130 mm Torpedo Diameter) Comment: (X-Long - Black)	1600-8M0084519	1665-8669A46 (X-Long - Black)
1	GEAR HOUSING ASSEMBLY, Basic-Black Comment: (Basic - Black)	1600-8M0083538	1665-8669A21 (Basic - Black)
2	NOT SOLD SEPARATE, Sleeve	NSS
3	SEAL	26-99325
4	BEARING, Roller	31-41326
5	PIN, Dowel (.187 x .530)	17-8M0084726	17-85500
6	SCREW KIT, (.375-16 x .250) Drain	10-79953Q04
7	SEAL	12-191833
8	SCREEN, Water Inlet Port	35-41133
9	SCREW, (M5 x 40)	10-40031112
10	SCREW KIT, (.375-16 x .250) Drain	10-79953Q04
10	FITTING KIT, Magnetic, Plug Fill/Drain Comment: SN# USA-0T979999/BEL-0P325499 & Below	22-8M0058389	22-67892A06 SN# USA-0T979999/BEL-0P325499 & Below
10	PLUG KIT, Drain (Magnetic) Comment: SN# USA-0T980000/BEL-0P325500 & Up	22-8M0058389	22-67892A06 SN# USA-0T980000/BEL-0P325500 & Up
11	SEAL	12-191833
12	SCREEN	35-41134
13	NUT, (M5) Stainless Steel	11-401365
14	BEARING ASSEMBLY, Roller	31-98294A1
15	NOT SOLD SEPARATE, Cup	NSS
16	GEAR, Pinion - 12-29	43-854498
17	NUT	11-828490
18	GASKET	27-993261
19	FACE PLATE	85083
20	WASHER	12-866451
21	KEY	28-8M0214993
22	IMPELLER	47-8M0204712
23	WASHER	12-866451
24	O-RING	25-69202
25	PUMP ASSEMBLY, Water Comment: SN# USA-0T800999/BEL-0P267999 & Below	46-99157A02
25	PUMP ASSEMBLY, Water Comment: SN# USA-0T801000/BEL-0P268000 & Up	46-99157A02
26	NOT SOLD SEPARATE, Insert	NSS
27	SEAL Comment: SN# USA-0T979999/BEL-0P325499 & Below	26-85090001
27	SEAL Comment: SN# USA-0T980000/BEL-0P325500 & Up	26-85090001
28	O-RING	25-86203
29	SCREW, (M6 x 16)	10-8248324
30	SHIFT SHAFT Comment: (Long)	854503
30	SHIFT SHAFT Comment: (X-Long)	854504
31	NUT, (M6) Stainless Steel	11-400212
32	COUPLER	822419
33	SHIFT SHAFT, Upper	8529941
34	DRIVESHAFT Comment: (Long)	45-854501
34	DRIVESHAFT Comment: (X-Long)	45-854502
35	BOOT Comment: SN# USA-0T979999/BEL-0P325499 & Below	85552001
35	BOOT Comment: SN# USA-0T980000/BEL-0P325500 & Up	85552001
36	RETAINER	93878
37	O-RING, (.734 x .139)	25-35276
38	O-RING, (.239 x .174)	25-85594
39	WASHER	12-85091
40	SPRING	24-93007
41	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
42	PIN, (.078 x .437)	17-85593
43	SHIFT CAM	85562A2
44	PIN, Drive	17-85096
45	SLEEVE, Water Tube	23-29804T
-	SEAL KIT	26-85090A2
-	PUMP KIT, Water	46-99157T2

Gear Housing, Propeller Shaft - 2.00:1 Gear Ratio

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing, Propeller Shaft - 2.00:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
0	GEAR HOUSING ASSEMBLY, Complete (2.60 Inch/102 mm Torpedo Diameter) Comment: (Short - Black)	1666-8833T33
0	GEAR HOUSING ASSEMBLY, Complete (2.60 Inch/102 mm Torpedo Diameter) Comment: (Long - Black)	1666-8833T35
1	GEAR HOUSING ASSEMBLY, Basic-Black Comment: (Basic - Black)	1600-8M0083312	1666-8833A17 (Basic - Black)
2	BEARING ASSEMBLY, Roller	31-821321A1
3	NOT SOLD SEPARATE, Cup	NSS
4	GEAR ASSEMBLY, Forward (13-26)	43-821924A1
5	BUSHING	23-41367
6	FOLLOWER, Cam	813139	42131
7	CLUTCH ASSEMBLY	52-821930A1
8	PIN, Cross	17-823951
9	SPRING	24-42204
10	PROPELLER SHAFT	44-821929
11	GEAR, Reverse - 13/26	43-821926T1
12	CARRIER, Bearing	42144T3
13	O-RING, (1.984 x .139)	25-8M0214923
14	BUSHING	23-821927
15	SEAL	26-99325
16	SEAL, Oil	26-821928
17	SCREW, (M8 x 50)	10-82407110
18	SCREW, (M8 x 30)	10-8240717
19	PROPELLER, (9.00 x 9.00)	48-828156A12	48-42522A12, 48-828156A45
20	NUT, (M10)	11-40140
21	THRUST HUB	8219321
22	SPACER	23-420911
-	SEAL KIT	26-41365A3

Gear Housing, Propeller Shaft - 2.42:1 Gear Ratio

Below is the parts list for Mercury 15 (4-STROKE) Gear Housing, Propeller Shaft - 2.42:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete (3.30 Inch/130 mm Torpedo Diameter) Comment: (Long - Black)	1665-8669T33
-	GEAR HOUSING ASSEMBLY, Complete (3.30 Inch/130 mm Torpedo Diameter) Comment: (X-Long - Black)	1600-8M0084519	1665-8669A46 (X-Long - Black)
1	GEAR HOUSING ASSEMBLY, Basic-Black Comment: (Basic - Black)	1600-8M0083538	1665-8669A21 (Basic - Black)
45	TRIM TAB	97-98432Q6
46	SCREW, (M8 x 30)	10-4000354
47	WASHER, (.323 x .563 x .063) Stainless Steel	12-8M0042642	12-70132
48	BEARING ASSEMBLY, Roller	31-8M0103470	31-99328A 1
49	NOT SOLD SEPARATE, Cup	NSS
50	GEAR ASSEMBLY, Forward - 12/29	43-854496A1
51	BUSHING	23-85557
52	FOLLOWER, Cam	85094
53	SPRING	24-38114
54	CLUTCH	52-41040T1
55	PIN	17-8M0020999	17-85093
56	SPRING	24-88680
57	PROPELLER SHAFT	44-8166231
58	GEAR, Reverse - 12/29	43-854497T	43-854497
59	CARRIER ASSEMBLY, Bearing	99906T1
60	BEARING, Roller	31-21739
61	SEAL, Oil, Inner	26-41132
62	SEAL, Oil, Outer	26-41131
63	O-RING	25-85549
64	PLATE	87293
65	SCREW, (M5 x 16)	10-90883
66	SCREW, (M10 x 35)	10-87810178
67	WASHER	12-43328
68	THRUST HUB ASSEMBLY	858498	8M0027793, 85128A 1
69	PROPELLER	48-19636A10
70	PROP NUT	11-88228
-	SEAL KIT	26-85090A2

Intake

Below is the parts list for Mercury 15 (4-STROKE) Intake:

Position No.	Part Name	OEM Number	Supersedes
1	MANIFOLD, Intake	835385T	835385
2	GASKET	27-853525
3	PIN, Dowel	17-82364M
4	BOLT, (M6 x 40)	10-853531
5	INSULATOR Comment: (8/9.9/15)	853526
6	GASKET	27-835383
7	O-RING	25-8250572
8	SILENCER	835386T	835386
9	DECAL, Warning Comment: (High Voltage)	37-8272822
10	PLATE	803872	879194062
11	COLLAR	855780
12	BOLT, (M6 x 100)	10-8M0100009	10-855809002, 10-855809
13	HOSE	32-852463
14	PLATE, Restrictor Comment: (13.5)	882759
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Intake/Exhaust Valves

Below is the parts list for Mercury 15 (4-STROKE) Intake/Exhaust Valves:

Position No.	Part Name	OEM Number	Supersedes
1	VALVE, Intake	850838T	850838
2	VALVE, Exhaust	850839T	850839
3	SEAT, Valve Spring	855959
4	SPRING, Valve	24-850840
5	RETAINER	822650
6	KEY	28-893554	28-822651
7	SEAL, Valve Stem	26-822647
8	ROCKER ARM ASSEMBLY	850841A1
9	SCREW	10-825046
10	NUT	11-826150	11-858274
11	SHAFT, Rocker	850842
12	COLLAR Comment: SN# USA-0T178499 & Below	825451
12	COLLAR Comment: SN# USA-0T178500/BEL-0P094500 & Up	825451
13	COLLAR Comment: SN# USA-0T178500/BEL-0P094500 & Up	880135
14	COLLAR Comment: SN# USA-0T178500/BEL-0P094500 & Up	880134
15	SPRING	24-825452
16	SPRING	24-825453
-	POWERHEAD ASSEMBLY Comment: (Electric)	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178499 & Below	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178500/BEL-0P094500 & Up	879783A01
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Oil Pump/Camshaft

Below is the parts list for Mercury 15 (4-STROKE) Oil Pump/Camshaft:

Position No.	Part Name	OEM Number	Supersedes
1	CAMSHAFT Comment: (Electric)(32mm)	834956
1	CAMSHAFT Comment: (Electric)(35mm)	834956004
1	CAMSHAFT Comment: (Manual)(32mm) SN# USA-0T178499/BEL-0P94499 & Below	834956
1	CAMSHAFT Comment: (Manual)(32mm) SN# USA-0T178500/BEL-0P094500 & Up	880136A1
1	CAMSHAFT Comment: (Manual)(35mm) SN# USA-0T178500/BEL-0P094500 & Up	880136A02
2	O-RING	25-825462
3	GASKET	27-853523
4	BOLT, (M6 x 35)	10-850879
5	KEY	28-8M0084803	28-84403M
6	SEAL, Oil	26-825455
7	WASHER	12-82710M
8	GEAR, Driven	43-834973T	43-834973
9	WASHER	12-825498
10	BOLT	10-826957M	10-91725M
11	PUMP ASSEMBLY, Oil Comment: SN# USA-0T178500/BEL-0P094500 & Up	834967T2
11	PUMP ASSEMBLY, Oil Comment: SN# USA-0T178499/BEL-0P094499 & Below	834967A1
12	GEAR, Drive	43-8M0063224	43-834955
13	WASHER	12-850843
14	NUT, (M28)	11-855679
15	TIMING BELT Comment: SN# USA-0T800999/BEL-0P267999 & Below	57-835392Q	835392 SN# USA-0T800999/BEL-0P267999 & Below
15	TIMING BELT Comment: SN# USA-0T801000/BEL-0P268000 & Up	57-835392Q	835392 SN# USA-0T801000/BEL-0P268000 & Up
-	POWERHEAD ASSEMBLY Comment: (Electric)	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178499/BEL-0P094499 & Below	802733A98
-	POWERHEAD ASSEMBLY Comment: (Manual) SN# USA-0T178500/BEL-0P094500 & Up	879783A01
-	GASKET SET, Powerhead	27-835427A00	27-835427A98

Powerhead Gasket Set Components

Below is the parts list for Mercury 15 (4-STROKE) Powerhead Gasket Set Components:

Position No.	Part Name	OEM Number	Supersedes
-	GASKET SET, Powerhead	27-835427A00	27-835427A98
0	O-RING, Fuel Pump	25-825478
0	O-RING, Camshaft	25-825462
0	GASKET, Oil Pump	27-853523
0	SEAL, Oil, Camshaft	26-825455
0	GASKET, Intake Manifold	27-853525
0	GASKET, Isulator	27-835383
0	O-RING, Silencer	25-8250572
0	SEAL, Valve Stem	26-822647
0	GASKET, Exhaust Cover	27-834952002	27-834952
0	GASKET, Thermostat Cover	27-8M0177107
0	SEAL, Breather Cover	26-850850
0	PLATE, Oil Deflection	855922A2
0	GASKET, Oil Deflection Plate	27-8354272
0	GASKET, Cylinder Head	27-8M0052705	27-850836
0	SEAL, Cylinder Head	850837
0	O-RING, Oil Plug Comment: (Not Used For This Application)	25-8M0052669	25-825492 (Not Used For This Application)
0	SEAL, Oil, Crankshaft-Top	26-855680
0	SEAL, Oil, Crankshaft-Bottom	26-855681

Service/Support Material

Below is the parts list for Mercury 15 (4-STROKE) Service/Support Material:

Part Name	OEM Number	Supersedes
PARTS MANUAL, 9.9/13.5/15 (323cc) 8/9.9/15 Bodensee 4-Stroke	90-803183
OWNERS MANUAL Comment: (1999)	90-10185990
OWNERS MANUAL Comment: (2000)	90-10185002
OWNERS MANUAL Comment: (Tracker 2000)	90-10210001
OWNERS MANUAL Comment: (2001)	90-10185010
OWNERS MANUAL Comment: (Tracker 2001)	90-10210010
OWNERS MANUAL Comment: (2002)	90-10185020
OWNERS MANUAL Comment: (Tracker 2002)	90-10210020
OWNERS MANUAL Comment: (2003)	90-10185030
OWNERS MANUAL Comment: (2004)	90-10185040
OWNERS MANUAL Comment: (2005)	90-10185050
SERVICE MANUAL	90-856159R02	90-856159R 1
DECAL SET Comment: (8 Bodensee)	37-809727A00	37-809727A98, 37-809727A96 (8 Bodensee)
DECAL, Bodensee Certification	37-856924
DECAL SET Comment: (15-Black-Non-Bigfoot) (2005)	37-802739A05
DECAL SET Comment: (15-Black-Non-Bigfoot) (2000 Thru 2004)	37-802739A00	37-802739A98 (15-Black-Non-Bigfoot) (2000 Thru 2004)
DECAL SET Comment: (15-Black-Non-Bigfoot) (1998/1999)	37-802739A00	37-802739A98 (15-Black-Non-Bigfoot) (1998/1999)
DECAL SET Comment: (15-Black-Bigfoot) (2005)	37-802741A05
DECAL SET Comment: (15-Black-Bigfoot) (2000 Thru 2004)	37-802741A00	37-802741A98 (15-Black-Bigfoot) (2000 Thru 2004)
DECAL SET Comment: (15-Black-Bigfoot) (1998/1999)	37-802741A00	37-802741A98 (15-Black-Bigfoot) (1998/1999)
DECAL SET Comment: (15 Gray Non-Bigfoot) (1998-2000)	37-802740A03	37-802740A01, 37-802740A98, 37-802742A98 (15 Gray Non-Bigfoot) (1998-2000)
DECAL SET Comment: (15 Gray Bigfoot) (1998-2000)	37-802740A03	37-802740A01, 37-802740A98, 37-802742A98 (15 Gray Bigfoot) (1998-2000)
DECAL SET Comment: (All 15 Gray ) (2001-2002)	37-802740A03	37-802740A01, 37-802740A98, 37-802742A98 (All 15 Gray ) (2001-2002)
DECAL SET Comment: (All 15 Gray) (2003 And Above)	37-802740A03	37-802740A01, 37-802740A98, 37-802742A98 (All 15 Gray) (2003 And Above)
DECAL SET Comment: (9.9-Black-Sailpower And BigfootI) (Tracker 2002 And Above)	37-803158A00	37-803158A99 (9.9-Black-Sailpower And BigfootI) (Tracker 2002 And Above)
DECAL SET Comment: (9.9-Black-Non-Bigfoot) (2000 And Above)	37-826335A00	37-826335A98, 37-826335A96, 37-826335A95 (9.9-Black-Non-Bigfoot) (2000 And Above)
DECAL SET Comment: (9.9-Black-Non-Bigfoot) (1998/1999)	37-826335A00	37-826335A98, 37-826335A96, 37-826335A95 (9.9-Black-Non-Bigfoot) (1998/1999)
DECAL SET Comment: (All 9.9 Gray) (1998-2002)	37-826336A03	37-826336A01, 37-826336A98, 37-826336A97, 37-826336A95 (All 9.9 Gray) (1998-2002)
DECAL SET Comment: (All 9.9 Gray) (2003 And Above)	37-826336A03	37-826336A01, 37-826336A98, 37-826336A97, 37-826336A95 (All 9.9 Gray) (2003 And Above)
DECAL SET Comment: (9.9-Gray-Sailpower) (1999 And Above)	37-803159A99
DECAL SET Comment: (9.9 Tracker) (1997-2001)	37-853556A97
DECAL SET Comment: (13.5-Black) (Export) (2005)	37-881842A05
DECAL SET Comment: (13.5-Black) (Export) (2001-2004)	37-881842A01
DECAL SET Comment: (13.5-Gray) (Export) (2001-2002)	37-881843A03	37-881843A01 (13.5-Gray) (Export) (2001-2002)
DECAL SET Comment: (13.5 Gray) (Export) (2003 And Above)	37-881843A03	37-881843A01 (13.5 Gray) (Export) (2003 And Above)
DECAL, CA Very Low Emission	37-8834338
DECAL, EPA Label Information Comment: (1999)	37-856985A20	37-856985 20 (1999)
DECAL, EPA Label Information Comment: (2000)	37-804652A00
DECAL, EPA Label Information Comment: (2001)	37-804652A01
DECAL, EPA Label Information Comment: (2002)	37-804652A02
DECAL, EPA Label Information Comment: (2003)	37-804652A03
DECAL, EPA Label Information Comment: (2004)	37-804652A04
DECAL, EPA Label Information Comment: 2005	37-804652A05

Starter Assembly

Below is the parts list for Mercury 15 (4-STROKE) Starter Assembly:

Position No.	Part Name	OEM Number	Supersedes
1	HANDLE REST	850865A1
2	SEAL	8M0043417
3	HANDLE ASSEMBLY Comment: (Handle Models)	85174A1
4	NOT SOLD SEPARATE, Retainer	NSS
5	PILOT LAMP Comment: (Handle Models)	8524791
6	NUT Comment: (Handle Models)	11-856949
7	SCREW, (M6 x 16)	10-8147762
-	RECOIL ASSEMBLY	8M0049883	850864
8	HOUSING	853541
9	COLLAR	23-852473
10	SHEAVE, Starter	50-8527732
11	PAWL	852777
12	SPRING, Starter	24-852778
13	DRIVEPLATE ASSEMBLY	852780
14	SPRING, Drive Pawl	24-852778T01	24-852778 1
15	SPRING	24-8527782
16	SPRING, Return	24-8527783
17	CIRCLIP	53-852784
18	BOLT	10-852785
19	GROMMET	25-852786
20	ROPE	50-12066Q10
21	STOPPER	8527881
22	SPRING, Return	24-8560361
23	SPRING	24-856036
24	BOLT, (M6 x 20)	10-84058M
25	BOLT, (M6 x 90)	10-855783
26	WASHER	12-82213M
27	NUT, (M6)	11-82390M
28	PLUG Comment: (Electric Non-Handle)	19-858768	19-855741 (Electric Non-Handle)
29	PLUG Comment: (Electric Non-Handle) SN# USA-0T979999/BEL-0P325499 & Below	19-822513002	19-822513 1 (Electric Non-Handle) SN# USA-0T979999/BEL-0P325499 & Below
29	PLUG Comment: (Electric Non-Handle) SN# USA-0T980000/BEL-0P325500 & Up	19-822513002	19-822513 1 (Electric Non-Handle) SN# USA-0T980000/BEL-0P325500 & Up
30	HOUSING Comment: (Electric)	853541
31	COLLAR Comment: (Electric)	23-852473
32	DECAL, Caution-Start in Gear Comment: (Start In Gear) (Electric)	37-881865	37-825064 (Start In Gear) (Electric)
33	NOT SOLD SEPARATE, Decal Comment: (Emergency Start Procedure)	NSS
34	COVER	855691
35	GROMMET	25-8527681
36	NOT SOLD SEPARATE, Decal Comment: (Servicing Referral)	NSS
37	DECAL, EPA Label Information Comment: (1999)	37-856985A20	37-856985 20 (1999)
37	DECAL, EPA Label Information Comment: (2000)	37-804652A00
37	DECAL, EPA Label Information Comment: (2001)	37-804652A01
37	DECAL, EPA Label Information Comment: (2002)	37-804652A02
37	DECAL, EPA Label Information Comment: (2003)	37-804652A03
37	DECAL, EPA Label Information Comment: (2004)	37-804652A04
37	DECAL, EPA Label Information Comment: 2005	37-804652A05

Starter Motor

Below is the parts list for Mercury 15 (4-STROKE) Starter Motor:

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 45)	10-4000357
2	WASHER Comment: (Bottom)	12-4002317
3	STARTER MOTOR ASSEMBLY Comment: (Nut Design)	50-859168T	50-852570T, 50-852570 (Nut Design)
3	STARTER MOTOR ASSEMBLY Comment: (Retaining Ring Design)	50-859168T	50-852570T, 50-852570 (Retaining Ring Design)
4	THRU BOLT	10-965662
5	DRIVE KIT Comment: (Nut Design)	891752	90643 4 (Nut Design)
6	DRIVE KIT Comment: (Retaining Ring Design)	906432
7	ARMATURE Comment: (Retaining Ring Design)	8236383
7	ARMATURE Comment: (Nut Design)	8236385
8	PINION	68575T2
9	DRIVE CAP	8236391
10	CAP, Commutator	8119012
11	BRUSH/SPRING KIT	898265016	75384, 75384 1
12	HOLDER	898265014	61787
13	SCREW	F15158

Swivel Bracket

Below is the parts list for Mercury 15 (4-STROKE) Swivel Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	SWIVEL BRACKET Comment: (Black)	3415-822237A3
2	FITTING, Grease	22-8M0169589
3	FITTING, Grease	22-8M0169589
4	FITTING, Grease	22-8M0169589
5	BUSHING	23-855628A1
6	NOT SOLD SEPARATE, O-Ring	NSS
7	NOT SOLD SEPARATE, Bushing	NSS
8	NOT SOLD SEPARATE, Bushing	NSS
9	NOT SOLD SEPARATE, Washer	NSS
10	ROD Comment: (Handle)	821961
11	DISC Comment: (Handle)	8165621
12	PLATE KIT Comment: (Handle)	821958A1
13	SCREW, (M6 x 13) Stainless Steel Comment: (Handle)	10-40011126
14	BRAKE PLATE Comment: (Handle)	821957
15	WASHER Comment: (Handle)	12-29330
16	HANDLE Comment: (Handle)	821959
17	NUT, (.375-24) Stainless Steel Comment: (Handle)	11-8M0204726
18	HOOK ASSEMBLY, Reverse Lock	98830A4
19	SPRING	24-96018
20	SPRING Comment: (Non-Handle)	24-97427
20	SPRING Comment: (Handle)	24-879894	24-12755 (Handle)
21	RING, Retaining Comment: (Handle)	53-13194
22	PIN Comment: (Handle)	17-13195
23	BRACKET Comment: (Handle)	12756
24	SPRING Comment: (Handle)	24-12754
25	LEVER Comment: (Handle)	12758
26	RING, Retaining Comment: (Handle)	53-13194
27	SCREW, (.375-24 x 1.25) Comment: (Electric - Non-Handle) SN# USA-0T979999/BEL-0P325499 & Below	10-849838	10-14000 (Electric - Non-Handle) SN# USA-0T979999/BEL-0P325499 & Below
27	SCREW, (.375-24 x 1.250) Comment: SN# USA-0T980000/BEL-0P325500 & Up	10-849838	10-14000 SN# USA-0T980000/BEL-0P325500 & Up
28	ATTACHING KIT, Steering Link Comment: (Electric - Non-Handle)	41323A03
29	WASHER, (.390 x .625 x .062) Stainless Steel Comment: (Electric - Non-Handle)	12-37828
30	NUT, (.375-24) Stainless Steel Comment: (Electric - Non-Handle)	11-8M0204726
31	BRACKET ASSEMBLY Comment: (Black)(Electric - Non-Handle)	96186A2
32	SCREW, (M10 x 25 MM) Comment: (Electric - Non-Handle)	10-1993325
33	LOCKWASHER, (M10) Comment: (Electric - Non-Handle)	13-400248
34	SWIVEL HEAD ASSEMBLY Comment: (Black)	854801T2
35	SHAFT, Reverse Lock	858338A1
36	BUSHING	23-F536813
37	GUIDE	8M0036770	42126
38	SCREW, (M5 x 25) Stainless Steel	10-40011109
39	NUT, (M5) Stainless Steel	11-401385
40	LINK ROD KIT, Reverse Lock Comment: (May Be Used In Place Of Ref. #35)	858338A3
41	BOLT, (M5 x 6) Comment: (May Be Used In Place Of Ref. #35)	10-858407
42	STUD, (M10 x 1.5 x 97)	16-854819
43	WASHER	12-4002320
44	NUT, (M10) Stainless Steel	11-4013610
45	MOUNT	8M0039074	42189 2
46	COVER Comment: (Starboard) (Black)	854729T1
47	COVER Comment: (Port) (Black)	854728T1
48	SCREW, (M8 x 100)	10-19943100
49	SCREW, (M8 x 60)	10-1994360
50	WASHER	12-36001
51	NUT, (M8) Stainless Steel	11-400213
52	NOT SOLD SEPARATE, Decal-Serial Overlaminate	NSS

Throttle/Shift Linkage(Handle Models)

Below is the parts list for Mercury 15 (4-STROKE) Throttle/Shift Linkage(Handle Models):

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M6 x 20)	10-8248291
2	COVER	856905
3	NOT SOLD SEPARATE (Decal-F,N,R)	NSS
4	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
5	BRACKET	856909
6	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
7	WASHER	12-8M0214930
8	PULLEY ASSEMBLY	825787A2
9	BUSHING	23-825788
10	NUT, (M6) Stainless Steel	11-401366
11	LINK, Throttle	882818	850871 1
12	SHIFT PLATFORM KIT Comment: (Design II)	856904A2
13	SHAFT Comment: (Design II)	8569111
14	PLUG Comment: (Design II)	19-48323
15	SHIFT PLATFORM Comment: (Design I)	856904A2
16	SHAFT Comment: (Design I)	856911
17	RING, Retaining Comment: (Design I)	53-95019
18	SEAL	856910
19	RING, Retaining	53-857213
20	WAVE WASHER	13-69150
21	SHIFT HANDLE	856906
22	SHIFT LINK	856908
23	LEVER, Shift	856907
24	SCREW, (M5 x 12)	10-82239312
25	SHIFT SHAFT ASSEMBLY, Horizontal Comment: (Non-Bigfoot)	852494A5
25	SHIFT SHAFT ASSEMBLY, Horizontal Comment: (Bigfoot)	852494A6
26	LEVER, Interlock Comment: (Bigfoot)	855609
26	LEVER, Interlock Comment: (Non-Bigfoot)	826063
27	SCREW, (M5 x 35) Stainless Steel	10-40011111
28	SPRING, Detent	24-824992
29	SPRING, Backing	24-824993
30	SPRING, Plate	824994
31	SCREW, (M5 x 12)	10-82239312
32	STRAP	8280471
33	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
34	SEAL	8354191
35	SWITCH ASSEMBLY	87-11083A30
36	RETAINER, Brass	8M0032846	12044 1
37	LANYARD ASSEMBLY	15920Q54
38	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
39	WIRE	852472
40	BRACKET	855888F
41	SCREW, (M5 x 12)	10-82239312
42	SWITCH ASSEMBLY Comment: (Electric)	87-8M0052929	87-813960A 5 (Electric)
43	PLATE Comment: (Electric)	824923
44	SCREW, (M3.5 x 20) Comment: (Electric)	10-82470620

Throttle/Shift Linkage(Non-Handle Models)

Below is the parts list for Mercury 15 (4-STROKE) Throttle/Shift Linkage(Non-Handle Models):

Position No.	Part Name	OEM Number	Supersedes
1	STRAP	8280471
2	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
3	SCREW, (M5 x 12)	10-82239312
4	SPRING, Plate	824994
5	SPRING, Backing	24-824993
6	SPRING, Detent	24-824992
7	SHIFT SHAFT ASSEMBLY, Horizontal Comment: (Bigfoot)	852494A6
7	SHIFT SHAFT ASSEMBLY, Horizontal Comment: (Non-Bigfoot)	852494A5
8	LEVER, Interlock Comment: (Bigfoot)	855609
8	LEVER, Interlock Comment: (Non-Bigfoot)	826063
9	SCREW, (M5 x 35) Stainless Steel	10-40011111
10	REMOTE CONTROL PLATFORM	835415F
11	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
12	COVER	852498
13	SCREW, (M6 x 20)	10-832047
14	LEVER, Shift Shaft	8524961
15	SCREW, (M5 x 12)	10-82239312
16	SHIFT LINK ASSEMBLY	852497A2
17	SOCKET	817428	830875
18	NUT, Brass	10-32,11-45076
19	RING, Retaining	53-857213
20	SEAL	8354191
21	LEVER, Shift	850856
22	BUSHING	23-91912
23	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
24	RETAINER	822459
25	PUSH NUT	11-825677
26	LEVER, Throttle	850857
27	RETAINER	822459
28	PUSH NUT	11-825677
29	SCREW, (M6 x 45)	10-82129145
30	BUSHING	23-855765
31	SLIDE	828049
32	LINK, Throttle Comment: SN# USA-0T800999/BEL-0P267999 & Below	882817	835420 SN# USA-0T800999/BEL-0P267999 & Below
32	LINK, Throttle Comment: SN# USA-0T801000/BEL-0P268000 & Up	882817	835420 SN# USA-0T801000/BEL-0P268000 & Up
33	RING, Retaining	53-8237951
34	GROMMET	25-828114
35	PLUG	19-855937
36	CLAMP Comment: (Electric)	54-28700
37	SCREW, (M5 x 12) Comment: (Electric)	10-82239312

Tiller Handle

Below is the parts list for Mercury 15 (4-STROKE) Tiller Handle:

Position No.	Part Name	OEM Number	Supersedes
-	TILLER HANDLE ASSEMBLY Comment: (Black)	821468T65	821468T10, 821468A10 (Black)
1	COVER KIT	822148A3
2	PULLEY	822150
3	NOT SOLD SEPARATE, Body	NSS
4	SCREW, (#10-16 x .500)	10-878608	10-812832
5	CABLE, Throttle	43242T09
6	SLEEVE	85-9600910
7	ARM ASSEMBLY, Steering Handle Comment: (Black)	821468A66	821468T 8 (Black)
8	SCREW, (M5 x 16) Stainless Steel	10-40011107
9	SCREW, (M5 x 16) Stainless Steel	10-40011107
10	KNOB, Throttle	821972T	821972
11	SPRING	24-96203
12	LOCK, Throttle	892995	821971
13	SCREW, (M6 x 25)	10-8M0204707
14	TILLER TUBE	821463T01	821463A 1
15	DECAL	37-8242003
16	HANDLE, Throttle	821465
17	GRIP	8M0221732
18	SWITCH ASSEMBLY, Stop	87-8M0104613
19	RETAINER	822441
20	BUSHING	23-823939
21	WASHER	12-822145
22	WAVE WASHER	13-826792	13-34678 1, 13-822144
23	WASHER	12-822146
24	BRACKET, Steering Arm Comment: (Black)	822841F1
25	SCREW, (M10 x 80)	10-4000384
26	PLATE	826648
27	HOUSING Comment: (Electric Handle) SN# USA-0T800999/BEL-0P267999 & Below	889734	823917 2 (Electric Handle) SN# USA-0T800999/BEL-0P267999 & Below
27	HOUSING, Switch Comment: (Electric Handle) SN# USA-0T801000/BEL-0P268000 & Up	889734	823917 2 (Electric Handle) SN# USA-0T801000/BEL-0P268000 & Up
28	CLIP Comment: (Electric Handle)	824918
29	SWITCH ASSEMBLY Comment: (Electric Handle)	87-823609A8
30	DECAL, Start Comment: (Electric Handle)	37-855262

Tools

Below is the parts list for Mercury 15 (4-STROKE) Tools:

Position No.	Part Name	OEM Number	Supersedes
1	NOT SOLD SEPARATE, Oil Filter Wrench (Obtain Locally)	NSS
2	FLYWHEEL PULLER	91-83164M
3	HOLDER TOOL, Flywheel	91-8M0161873
4	COMPRESSOR TOOL, Piston Ring	FT2997	FJ7081, FJ8785, FJ8786, FJ8787, FJ8788, FJ8789
6	COMPRESSOR TOOL, Valve Spring	91-809494A1
7	REMOVER TOOL, Valve Guide	91-809495001	91-809495A 1
8	INSTALLER TOOL, Valve Guide Bushing	91-809496A1
9	REAMER TOOL, Valve Guide	91-809497A1
10	NOT SOLD SEPARATE, Valve Seat Cutter Kit (Obtain Locally)	NSS
11	WRENCH	91-828999
12	PULLER PLATE	91-37241
13	PULLER ASSEMBLY	91-83165T
14	PULLER ASSEMBLY, Slide Hammer	91-34569A1
15	INSTALLER TOOL, Bearing Comment: (Non-Bigfoot)	91-13664
15	INSTALLER TOOL, Bearing Carrier Comment: (Bigfoot)	91-93843T1
16	REMOVAL TOOL, Bearing	91-824788A1
17	INSTALLATION TOOL, Driveshaft Bushing	91-824790A1
18	MANDREL	91-13658T
19	REMOVAL TOOL, Bushing	91-824787
20	INSTALLER TOOL, Bushing And Seal	91-824785T1
21	PLATE	91-29310
22	NOT SOLD SEPARATE, Expanding Rod (Snap-On #CG40-4)	NSS
23	NOT SOLD SEPARATE, Collet (Jaws)(Snap-On #CG40A6)	NSS
24	TESTER KIT	FT8950

Top Cowl

Below is the parts list for Mercury 15 (4-STROKE) Top Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	TOP COWL ASSEMBLY Comment: (Black)	114-852413T3
1	TOP COWL ASSEMBLY Comment: (Silver)	114-852413T4
2	BRACKET	852490F
3	COVER	827702T	827702
4	LATCH	826649
5	SCREW, (M4 x 12)	10-8231872
6	LOCKWASHER, Stainless Steel	8,13-26995
7	NUT, (M4)	11-8237515
8	NOT SOLD SEPARATE, Insert	NSS
9	SCREW, (#10-16 x .50)	10-95700
10	BRACKET ASSEMBLY	852491A1
11	SCREW, (M6 x 13) Stainless Steel	10-40011126
12	ROLLER	18745
13	SEAL, Cowl	8M0043391	828237 1
14	ROPE AND HANDLE KIT, Manual Starting	47341A11
15	NOT SOLD SEPARATE, Starter Rope	NSS

Visual Warning

Below is the parts list for Mercury 15 (4-STROKE) Visual Warning:

Position No.	Part Name	OEM Number	Supersedes
1	PLATE ASSEMBLY, Lamp Mounting	17334A4
2	LAMP	88-17429
3	BRACKET	76424
4	STUD, (#10-32 x 2.00)	16-55422
5	WASHER, (.200 x .440 x .032)	12-24676
6	NUT, Stainless Steel	10-32,11-68219
7	TERMINAL BLOCK	86-45915
8	SCREW, (#8 x .625)	10-16324
9	SCREW, (#10-16 x .375)	10-878607	10-817626
10	CABLE ASSEMBLY	84-11149A3
11	INSULATOR, (2.00 Inch)	85-623594
12	SCREW, (#10-32 x .250)	10-24231
13	NUT AND LOCKWASHER,	10-32,11-27164

Download this page as PDF: Click here

For Mercury Owners:

To assist you in maintaining and repairing your marine engines, we hope the following resources may be of use:

Mercury / Mercruiser / Mariner Parts from JLM Marine

About JLM Marine

Founded in 2002, JLM Marine has established itself as a dedicated manufacturer of high-quality marine parts, based in China. Our commitment to excellence in manufacturing has earned us the trust of top marine brands globally.

As a direct supplier, we bypass intermediaries, which allows us to offer competitive prices without compromising on quality. This approach not only supports cost-efficiency but also ensures that our customers receive the best value directly from the source.

We are excited to expand our reach through retail channels, bringing our expertise and commitment to quality directly to boat owners and enthusiasts worldwide.