Mercury 30 JET (3 CYL.) (0P017000 THRU 0P153499) Outboard Motor Parts Diagram & Catalog – Free PDF Download

by JLM Marine 30 Apr 2025 0 Comments

Mercury 30 JET (3 CYL.) Outboard Motor Parts Diagram & Catalog – Free PDF Download

Accessories

Below is the parts list for Mercury 30 JET (3 CYL.) Accessories:

Position No.	Part Name	OEM Number	Supersedes
-	HOSE ASSEMBLY, Fuel (8 Feet) (With Quick disconnect)	32-877680Q8
-	HOSE ASSEMBLY, Fuel (12 Feet) (With Quick disconnect)	32-877680Q12	32-858620Q12, 32-858620A12, 32-827927A12
-	HOSE ASSEMBLY, Fuel (8 Feet) (With Quick disconnect Engine End Only)	32-877681Q8
-	HOSE ASSEMBLY, Fuel (12 Feet) (With Quick disconnect Engine End Only)	32-877681Q12	32-804792Q12, 32-804792Q, 32-858621Q12, 32-858621A12, 32-17146A12
-	HOSE ASSEMBLY, Fuel (12 Feet) (No Fittings)	32-877683Q12	32-858623Q12, 32-858623A12, 32-822379A12, 32-819380A12, FA599752, FS409752, 32-819380A 3, F216752, FA409752, F289752, FA178752, FA216752, FA284752, FA289752, FS409952
-	LINE ASSEMBLY, Fuel (Original Equipment)	32-877680Q8
-	EXTENSION KIT, (22.5) Comment: (NON-BIGFOOT-Converts 20 In. to 22-1/2 In.)	824072A5
-	HIGH OUTPUT ALTERNATOR KIT	398-852387A11
-	SENDER KIT, Oil Pressure	8M0068785	828019A 1
-	ATTACHING KIT, Remote Control	859185A1
-	POWER TRIM KIT Comment: SN# 0T294064 & Below	8M0055001	830150A 7 SN# 0T294064 & Below
-	POWER TRIM KIT Comment: SN# 0T294065 & Up	8M0055002	830150A 8 SN# 0T294065 & Up
-	POWER TRIM KIT Comment: SN# 0T294064 & Below	8M0055008	855654A 5 SN# 0T294064 & Below
-	POWER TRIM KIT Comment: SN# 0T294065 & Up	855654A6
-	SENDER KIT, Power Trim	821400A2
-	KEY SWITCH KIT, Remote Ignition	15000A7
-	BRACKET ASSEMBLY, Steering (Without Carrying Handle)	816667A2
-	TILLER HANDLE KIT, Electric Start Comment: (NON-BIGFOOT)	821455A22	821455A11 (NON-BIGFOOT)
0	CARRYING HANDLE	43393A1
0	DIODE ASSEMBLY (Dual Engine)	812497A2
0	CONVERSION KIT, Starter Motor	50-822462A06	50-822462A 5
0	FLUSHING ATTACHMENT	44357Q2
0	HOSE ASSEMBLY, Fuel (8 Feet) Comment: (With Quick Disconnect)	32-877680Q8
0	HOSE ASSEMBLY, Fuel (12 Feet) Comment: (With Quick Disconnect)	32-877680Q12	32-858620Q12, 32-858620A12, 32-827927A12 (With Quick Disconnect)
0	HOSE ASSEMBLY, Fuel (8 Feet) Comment: (With Quick Disconnect Engine End Only)	32-877681Q8
0	HOSE ASSEMBLY, Fuel (12 Feet) Comment: (With Quick Disconnect Engine End Only)	32-877681Q12	32-804792Q12, 32-804792Q, 32-858621Q12, 32-858621A12, 32-17146A12 (With Quick Disconnect Engine End Only)
0	HOSE ASSEMBLY, Fuel (12 Feet) Comment: No Fittings	32-877683Q12	32-858623Q12, 32-858623A12, 32-822379A12, 32-819380A12, FA599752, FS409752, 32-819380A 3, F216752, FA409752, F289752, FA178752, FA216752, FA284752, FA289752, FS409952 No Fittings
0	HORSE POWER RESTRICTOR KIT Comment: (Black 50)	815548A8
0	KEY SWITCH KIT, Remote Ignition	15000A7
0	SWITCH/LANYARD KIT	87-19674Q2
0	MERCATHODE KIT	88334A2
0	SWITCH KIT, Trim (10.00 Feet) (With Or Without Tiller)	87-18286A18
0	TILLER HANDLE KIT Comment: (Black)	828813A29	828813A 6 (Black)
0	VISUAL WARNING SYSTEM (Low Oil/Overheat)	17334A2
0	REGULATOR KIT, Voltage	88825A6

Adaptor Plate

Below is the parts list for Mercury 30 JET (3 CYL.) Adaptor Plate:

Position No.	Part Name	OEM Number	Supersedes
1	DIPSTICK	8M0162935
2	DIPSTICK TUBE Comment: SN# 0T178499 & Below	825989003	825989 2 SN# 0T178499 & Below
3	DIPSTICK TUBE Comment: SN# 0T178500 & Up	825989003	825989 2 SN# 0T178500 & Up
4	SEAL	8560552
5	ADAPTOR PLATE Comment: SN# 0T178499 & Below	825228A24	825228 4 SN# 0T178499 & Below
6	PIN, Dowel Comment: SN# 0T178499 & Below	17-23784
7	HEAT SHIELD	8289151
8	ADAPTOR PLATE Comment: SN# 0T178500 & Up	825228A17	825228T 9 SN# 0T178500 & Up
9	PLUG	19-822464
10	SCREW, (M6 x 55) Comment: SN# 0T178500 & Up	10-4007455
11	CLAMP	54-855228	54-888988014
12	PIN, Dowel	17-23784
13	FITTING, Elbow - 90 Degree (.125-27)	22-629101
14	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
15	SEAL, Oil Comment: (NON-BIGFOOT)	26-828932	26-821756 (NON-BIGFOOT)
15	SEAL, Oil Comment: (BIGFOOT)	26-16977
16	BUSHING Comment: (NON-BIGFOOT)	23-856743
17	PLUG, Pipe	22-384073
18	GROMMET Comment: (NON-BIGFOOT)	25-822408001	25-822408 (NON-BIGFOOT)
19	GASKET	27-8M0213113
20	O-RING	25-845746
21	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
22	DEFLECTOR, Oil	856592
23	BODY ASSEMBLY, Oil Pressure Relief	8M0210772
24	COTTER PIN	18-45882
25	PLUNGER	8252151
26	SPRING	24-825216
27	PLATE, Oil Pickup-Top	893765	854789
28	HOSE, Oil Pickup	32-854793
29	BAFFLE	893700	854791 1

Attenuator Plate

Below is the parts list for Mercury 30 JET (3 CYL.) Attenuator Plate:

Position No.	Part Name	OEM Number	Supersedes
1	ATTENUATOR, Sound	828164
2	SCREW, (M6 x 16)	10-40019127
3	WASHER, (.2656 x .625 x .0625) Stainless Steel	12-35462
4	CAP	19-815784	22-14685
5	BRACKET	828928
6	SEAL	26-812889
7	BRACKET	828927
8	SCREW, (M8 x 100)	10-4000363
9	ARM ASSEMBLY	11399A1
10	ROLLER	67748
11	SCREW, (M5 x 6)	10-40056103
12	WASHER, (.203 x .500 x .032)	12-8M0204666
13	HOSE, (.187) (26.00 Inches Bulk) (4-1/4 Inch) Comment: (Manual)	32-9912878
13	HOSE, (.187) (26.00 Inches Bulk) (4-1/4 Inch) Comment: (Electric)	32-9912878
14	HOSE, (.187) (26.00 Inches Bulk) (3 Inch) Comment: (Electric)	32-9912878
15	FITTING TEE Comment: (Electric)	22-830285
16	HOSE, (.187) (26.00 Inches Bulk) (1 Inch) Comment: (Electric)	32-9912878
17	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
18	GASKET, Flange	27-8144461
19	LINK, Throttle	825204T03	825204 3
20	DECAL, Warning, High Voltage Comment: (Manual)	37-8272822
21	NOT SOLD SEPARATE Comment: (Decal-Caution)	NSS
22	NOT SOLD SEPARATE Comment: (Decal-Caution in Gear Idle) (Electric)	NSS
-	POWERHEAD ASSEMBLY	852067T98	852067A98, 852067A97
-	GASKET SET	27-828553A97

Bottom Cowl

Below is the parts list for Mercury 30 JET (3 CYL.) Bottom Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	BOTTOM COWL Comment: (SHORT-PORT)	4020-852554T1
1	BOTTOM COWL Comment: (LONG-PORT)	4020-826277T1
2	BOTTOM COWL Comment: (SHORT-STARBOARD)	4020-852555T5
2	BOTTOM COWL Comment: (LONG-STARBOARD)	4020-826278T7
3	SCREW, (M6 x 30)	10-82684430
4	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
5	SEAL	825238002	825238 1
6	WASHER	12-855576
7	GASKET	27-855627
8	SCREW, (M6 x 60)	10-82684460
9	FITTING	22-827948
10	BOOT	826273001	826273
11	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
12	LEVER, Cowl Latch	825782F1
13	BUSHING	23-812707	23-71984, 23-F286818, 23-F286828, F480818
14	WASHER, Wave	13-12134
15	LATCH HOOK	893766	825783
16	SCREW, (M6 x 16)	10-1993716
17	GROMMET Comment: (NON POWER TRIM)	25-8M0179867
17	GROMMET Comment: (SPLIT - POWER TRIM)	25-19565002
18	PLUG Comment: (NON POWER TRIM)	812830T01	812830 1 (NON POWER TRIM)
19	SWITCH, Trim Comment: (POWER TRIM - DESIGN II)	87-8M0235191
20	SWITCH ASSEMBLY Comment: (POWER TRIM - DESIGN I)	87-8M0042301	87-896620, 87-856990, 87-850691, 87-18286A40 (POWER TRIM - DESIGN I)
21	RETAINER Comment: (NON POWER TRIM)	8M0032848	812443 1 (NON POWER TRIM)
1	SPRING, Detent	24-824992
2	SPRING, Backing	24-824993
3	SPRING, Plate	824994
4	SCREW, (M5 x 14)	10-82191916
5	STRAP	8280471
6	SCREW, (M6 x 16)	10-4006731
7	CLAMP	8M0039049	822008, 822008 1
8	SCREW, (M6 x 30) Stainless Steel	10-40011130
9	SWITCH Comment: (Electric Handle)	87-8M0052927	87-813960A 3 (Electric Handle)
10	SCREW, (M3 x 20) Comment: (Electric Handle)	10-88075020
11	PLATE Comment: (Electric Handle)	824923
12	HARNESS ASSEMBLY Comment: (Electric Handle)	84-824934A3
13	CAP Comment: (Non-Handle)	8M0036802	822469 (Non-Handle)
14	SCREW, (M6 x 16) Comment: (Non-Handle)	10-4006731
15	LEVER Comment: (Non-Handle)	8M0041741	822467 1 (Non-Handle)
16	INSERT Comment: (Non-Handle)	42927
17	PIN Comment: (Non-Handle)	17-8224561
18	BUSHING Comment: (Non-Handle)	23-26954
19	BUSHING Comment: (Non-Handle)	23-48475
20	RETAINER Comment: (Non-Handle)	822459
21	NUT, (M6) Stainless Steel Comment: (Non-Handle)	11-401386
22	WASHER, (.255 x .620 x .030) Stainless Steel Comment: (Non-Handle)	12-69056
23	LINK, Shift Comment: (Non-Handle)	8224701
24	BUSHING Comment: (Non-Handle)	23-48475
25	LATCH Comment: (Non-Handle)	98889
26	CUP Comment: (Non-Handle)	39519
27	SHIFT SHAFT, Horizontal	821483A6
28	LEVER, Interlock Actuating Comment: (Manual)	821487
29	SCREW, (#10-16 x .375)	10-878607	10-817626
30	CABLE ASSEMBLY (Black-7 1/2 Inch)	84-88807A28
31	SHIFT ROD Comment: (Handle)	8M0037997	825175 1 (Handle)
32	COTTER PIN Comment: (Handle)	18-210711
33	PIN Comment: (Handle)	17-8251851
34	LOCKWASHER Comment: (Handle)	13-827418	13-826793 (Handle)
35	LEVER, Shift Comment: (Handle)	822011
36	WAVE WASHER Comment: (Handle)	13-825273
37	SCREW, (M5 x 16) Stainless Steel Comment: (Handle)	10-40011107
38	DRIVE SCREW	10-42975
39	GROMMET	25-828462001	25-828462
40	PLUG	19-17230
41	SEAL Comment: (Handle)	822424001	822424 (Handle)
42	SEAL, Throttle Cable Comment: (Non-Handle)	19-823874001	19-823874 (Non-Handle)
43	BOTTOM COWL Comment: (Black)	4023-828165A1
44	CHECK VALVE ASSEMBLY, Drain	21-817519A1
45	GROMMET Comment: (Split-Power Trim)	25-19565002
45	GROMMET Comment: (Non Power Trim)	25-8M0179867
46	PLUG Comment: (Non-Handle)	19-824076001	19-824076 (Non-Handle)
47	HANDLE Comment: (Manual Handle)	8214901
48	SEAL Comment: (Manual Handle)	823572001	823572 (Manual Handle)
49	ALARM ASSEMBLY, Audio Warning Comment: (Manual Handle)	84-8M0210763
50	WASHER Comment: (Manual Handle)	12-8M0214930
51	SCREW, (M5 x 12) Comment: (Manual Handle)	10-82239312
52	SCREW, (M5 x 16) Stainless Steel Comment: (Manual Handle)	10-40011107
53	SWITCH ASSEMBLY Comment: (Power Trim)	87-8M0042301	87-896620, 87-856990, 87-850691, 87-18286A40 (Power Trim)
54	PLUG, Trim Switch Comment: (Non Power Trim)	812830T01	812830 1 (Non Power Trim)
55	RETAINER	8M0032848	812443 1
56	SCREW, (M6 x 16)	10-1993716
57	CAM, Latch	828464
58	WASHER, Wave	13-12134
59	BUSHING	23-812707	23-71984, 23-F286818, 23-F286828, F480818
60	FITTING	22-813613
61	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
62	HOSE, (15.00 Inches)	32-7568058
63	BUSHING	23-812707	23-71984, 23-F286818, 23-F286828, F480818
64	LEVER, Cowl Latch	823573F1
65	SCREW, (M6 x 25) Stainless Steel	10-40011129
66	BUSHING	23-822003
67	GROMMET	25-822002
68	PLUG, Warning Alarm Comment: (Electric)	19-824473
69	SCREW, (#10-16 x .500)	10-878608	10-812832
70	BUMPER	8M0043169	828465
71	LATCH, Front	828463
72	SCREW, (M4 x 16)	10-4001987
73	GROMMET	25-16226

Camshaft/Oil Pump

Below is the parts list for Mercury 30 JET (3 CYL.) Camshaft/Oil Pump:

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M10 x 40)	10-82761140
2	WASHER	12-4002319
3	BELT	8M0151040
4	GEAR, Driven	833104T6
5	PIN, Dowel	17-825956
6	CAMSHAFT Comment: (MANUAL)	400-8M0183249
7	CAMSHAFT Comment: (ELECTRIC)	402-834781T1
8	PIN	17-826149	17-893566
9	PUMP ASSEMBLY, Oil	825058A1
10	O-RING	25-826152
11	O-RING	25-826154
12	O-RING	25-826153
13	SCREW, (M6 x 40)	10-4000333
-	GASKET SET, Engine	27-825231A99

Carburetor

Below is the parts list for Mercury 30 JET (3 CYL.) Carburetor:

Position No.	Part Name	OEM Number	Supersedes
1	CARBURETOR, (WME 53-1), Top Comment: (Electric 40)	3301-823799T34	3301-823799T 7 (Electric 40)
1	CARBURETOR, (WME 53-2), Center Comment: (Electric 40)	3301-823799T35	3301-823799T 8 (Electric 40)
1	CARBURETOR, (WME 53-3), Bottom Comment: (Electric 40)	3301-823799T36	3301-823799T 9 (Electric 40)
1	CARBURETOR, (WME 92-1), Top Comment: (Electric)	3301-823799T34	3301-823799T 7 (Electric)
1	CARBURETOR, (WME 92-2), Center Comment: (Electric)	3301-823799T35	3301-823799T 8 (Electric)
1	CARBURETOR, (WME 92-3), Bottom Comment: (Electric)	3301-823799T36	3301-823799T 9 (Electric)
1	CARBURETOR, (WME 69-1), Top Comment: (Manual 40)	3301-823799T31	3301-823799T13, 3301-823799A13 (Manual 40)
1	CARBURETOR, (WME 69-2), Center Comment: (Manual 40)	3301-823799T32	3301-823799T14, 3301-823799A14 (Manual 40)
1	CARBURETOR, (WME 69-3), Bottom Comment: (Manual 40)	3301-823799A33	3301-823799T33, 3301-823799T15, 3301-823799A15 (Manual 40)
1	CARBURETOR, (WME 91-1), Top Comment: (Manual)	3301-823799T31	3301-823799T13, 3301-823799A13 (Manual)
1	CARBURETOR, (WME 91-2), Center Comment: (Manual)	3301-823799T32	3301-823799T14, 3301-823799A14 (Manual)
1	CARBURETOR, (WME 91-3), Bottom Comment: (Manual)	3301-823799A33	3301-823799T33, 3301-823799T15, 3301-823799A15 (Manual)
1	CARBURETOR, (WME 68-1), Top Comment: (50)	3301-824902T28	3301-824902T16, 3301-824902A16 (50)
1	CARBURETOR, (WME 68-2), Center Comment: (50)	3301-824902T29	3301-824902T17, 3301-824902A17 (50)
1	CARBURETOR, (WME 68-3), Bottom Comment: (50)	3301-824902T30	3301-824902T18, 3301-824902A18 (50)
1	CARBURETOR, (WME 93-1), Top Comment: (Electric)	3301-824902T28	3301-824902T16, 3301-824902A16 (Electric)
1	CARBURETOR, (WME 93-2), Center Comment: (Electric)	3301-824902T29	3301-824902T17, 3301-824902A17 (Electric)
1	CARBURETOR, (WME 93-3), Bottom Comment: (Electric)	3301-824902T30	3301-824902T18, 3301-824902A18 (Electric)
2	SHAFT, Throttle, Top Comment: (WME-53/68/92/93)	1395-823632
3	SHAFT, Throttle, Center Comment: (WME-53/68/92/93)	1395-823633
4	SHAFT, Throttle, Bottom Comment: (WME-53/68/92/93)	1395-823636
2	SHAFT, Throttle, Top/Bottom Comment: (WME-69/91)	1395-823632
3	SHAFT, Throttle, Center Comment: (WME-69/91)	1395-823633
5	SCREW, Top/Bottom	1395-823634
6	NOT SOLD SEPARATE Comment: (Spring-Throttle Return)	NSS
7	NOT SOLD SEPARATE Comment: (Idle Needle)	NSS
8	NOT SOLD SEPARATE Comment: (Spring-Idle Needle)	NSS
9	NOT SOLD SEPARATE Comment: (Gasket-Cover Plate)	NSS
10	COVER PLATE	1395-811221
11	SCREW, Cover Plate	1395-811220
12	GASKET, Flange	27-8144461
13	LEVER, Oil Pump, Bottom Comment: (WME-53/68/92/93)	1395-8113522
14	SCREW, Lever Retainer, Bottom Comment: (WME-53/68/92/93)	1395-8086121
15	SCREW, Throttle Valve	10-F10155
16	VALVE, Throttle	1395-97245
17	NOT SOLD SEPARATE Comment: (Retaining Ring)	NSS
18	SHAFT	F10064
19	GASKET	1395-808738
20	NOT SOLD SEPARATE Comment: (Gasket-Fuel Bowl)	NSS
21	VALVE, Inlet Needle	10-95951
22	FLOAT	1395-9594
23	SCREW AND WASHER, (#8-32 x .750)	1395-808612	1399-5132
24	BOWL, Fuel Comment: (WME-53/68/92/93)	1395-811693	1395-9590 (WME-53/68/92/93)
24	BOWL, Fuel, Top Comment: (WME-69/91)	1395-811695	1395-811217 (WME-69/91)
24	BOWL, Fuel, Center/Bottom Comment: (WME-69/91)	1395-811693	1395-9590 (WME-69/91)
25	PLUG KIT Comment: (WME-69/91)	1395-811694	1395-9596 1 (WME-69/91)
26	SEAL (Consists of 4 Seals)	1395-802731
27	JET, (.044) Comment: (WME-53/69/91/92)	1395-7394
27	JET, (.052) Comment: (WME-68/93)	1395-6359
-	REPAIR KIT, Carburetor Comment: (1 Per Carburetor)	1395-8236354
-	GASKET SET, Carburetor Comment: (1 Per Carburetor)	1395-8112231
-	GASKET SET	27-828553A97

Carburetor(0T178499 and Below)

Below is the parts list for Mercury 30 JET (3 CYL.) Carburetor(0T178499 and Below):

Position No.	Part Name	OEM Number	Supersedes
1	CARBURETOR Comment: (TOP)	3329-830276T27	3329-830276T10 (TOP)
1	CARBURETOR Comment: (CENTER)	3329-830276T11
1	CARBURETOR Comment: (BOTTOM)	3329-830276T12
2	SCREW	10-854246
3	PLATE	854245
4	NOT SOLD SEPARATE, Gasket	NSS
5	ENRICHENER	854254T	803918T, 854254
6	NOT SOLD SEPARATE, O Ring	NSS
7	PLATE	854255
8	IDLE JET	803919
9	JET	803912	803912 38
10	PLUG, Rubber	19-854248
11	JET	803915
12	VALVE, Float	854247
13	MAIN NOZZLE	803914
14	FLOAT	854253
15	NOT SOLD SEPARATE, Float Pin	NSS
16	NOT SOLD SEPARATE, Gasket	NSS
17	FLOAT BOWL Comment: (TOP)	803916
17	FLOAT BOWL Comment: (CENTER/BOTTOM)	803917
18	SCREW	10-8542463
19	SCREW, Drain	10-8542462
20	NOT SOLD SEPARATE, Washer	NSS
21	SCREW, Synchronization Comment: (TOP/CENTER)	10-803925
21	SCREW Comment: (BOTTOM)	10-803913
22	SPRING Comment: (TOP/CENTER)	24-803923
23	SPRING Comment: (TOP/CENTER)	24-803924
24	SPRING Comment: (BOTTOM)	24-854249
25	NOT SOLD SEPARATE, Spring	NSS
26	PLUNGER	854251
27	NOT SOLD SEPARATE, Rubber Bellows	NSS
28	NOT SOLD SEPARATE, Screw-Plunger Retaining	NSS
29	NOT SOLD SEPARATE, Plunger Rod	NSS
-	REPAIR KIT, Carburetor	854256

Carburetor(0T178500 and Up)

Below is the parts list for Mercury 30 JET (3 CYL.) Carburetor(0T178500 and Up):

Position No.	Part Name	OEM Number
1	CARBURETOR Comment: (Top)	3329-830276T31
1	CARBURETOR Comment: (Center)	3329-830276T32
1	CARBURETOR Comment: (Bottom)	3329-830276T33
2	SCREW	10-854246
3	PLATE	854245
4	GASKET	27-8542572
5	ENRICHENER	854254T2
6	NOT SOLD SEPARATE, O Ring	NSS
7	PLATE	854255
8	CAP	19-880814
9	SCREW, Adjusting	10-880841
10	O-RING	25-880842
11	SPRING	24-880815
12	JET, Pilot	80391242
13	O-RING	25-880843
14	PLUG	19-880844
15	JET, Main	80391595
16	MAIN NOZZLE	8039143
17	VALVE, Float	854247
18	FLOAT	8542531
19	PIN, Float	17-8542581
20	SCREW	10-880845
21	GASKET	27-8542573
22	FLOAT BOWL Comment: (Top)	8039161
22	FLOAT BOWL Comment: (Center/Bottom)	8039171
23	SCREW	10-8542463
24	SCREW, Drain	10-8542464
25	WASHER	12-8542591
26	SCREW, Synchronization Comment: (Top/Center)	10-803925
27	SPRING Comment: (Top/Center)	24-880846
28	SPRING Comment: (Top/Center)	24-803923
29	SCREW Comment: (Bottom)	10-803913
30	SPRING Comment: (Bottom)	24-854249
31	SPRING	24-880847
32	PLUNGER	8542511
33	SCREW	10-880848
34	NOT SOLD SEPARATE, Rubber Bellows	NSS
35	PLUNGER ROD	880849
-	REPAIR KIT, Carburetor	8542561

Clamp Bracket

Below is the parts list for Mercury 30 JET (3 CYL.) Clamp Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	CLAMP BRACKET Comment: (Port) (Black)	3411-821773T1
2	CLAMP BRACKET Comment: (Storboard) (Black)	3412-821774T8
3	THUMB SCREW ASSEMBLY Comment: (Manual)	10-818883A1
4	NOT SOLD SEPARATE Comment: Handle (Manual)	NSS
5	NOT SOLD SEPARATE Comment: Rivet (Manual)	NSS
6	WASHER Comment: (Manual)	12-818884
7	SHOULDER SCREW, Hex Comment: (Manual)	10-768042
8	CAP Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)	8224011
9	PIN Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)	17-25810
10	BEARING Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)	23-86637
11	PIN Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)	17-8224002
12	CAP Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)	822401
13	PIN, (.125 x 0.75 Inches) Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)	17-25319
14	BUSHING Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)	23-823589
15	PIN Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)	17-8224001
16	ANODE	97-8252711
17	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
18	SCREW, (M6 x 25)	10-8M0204707
19	NUT, (.500-20)	11-82671117
20	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel	12-8M0204648
21	SCREW, (.500-20 x 4.00)	10-814259
22	DECAL, Tilt Lock	37-830253	37-814743 3, 37-826546
23	NOT SOLD SEPARATE Comment: (Decal-Warning)	NSS
24	TRIM, Hydraulic Assist Comment: (Gas Assist Trim)	828533T1
25	CABLE ASSEMBLY Comment: (Gas Assist Trim)	88238A11
26	LEVER, Tilt Comment: (Gas Assist Trim)	828924
27	TILT KNOB Comment: (Gas Assist Trim)	8M0007469	19621 (Gas Assist Trim)
28	ARM, Lever Comment: (Gas Assist Trim)	828930
29	WAVE WASHER Comment: (Gas Assist Trim)	13-31030
30	PIN, (.125 x 0.75 Inches) Comment: (Gas Assist Trim)	17-25319
31	LINK Comment: (Gas Assist Trim)	8289961
32	NUT, Comment: (Gas Assist Trim)	10-32,11-8M0204718
33	PIN, Anchor (14 mm) Comment: (Gas Assist/Power Trim)	17-822481001	17-822481 (Gas Assist/Power Trim)
34	BUSHING Comment: (Gas Assist/Power Trim)	23-822482
35	BUSHING Comment: (Gas Assist/Power Trim)	23-822484
36	WASHER Comment: (Gas Assist/Power Trim)	12-825190
37	NUT Comment: (Gas Assist/Power Trim)	11-826712	11-40134 14 (Gas Assist/Power Trim)
38	SCREW, (M10 x 40) Stainless Steel Comment: (Gas Assist/Power Trim)	10-4009040
39	WASHER Comment: (Gas Assist/Power Trim)	12-4002319
40	NUT, (M10) Comment: (Gas Assist/Power Trim)	11-40140
41	PIN Comment: (Non-Power Trim)	17-853923A1
42	SPRING Comment: (Non-Power Trim)	24-821461

Crankshaft, Piston and Connecting Rods

Below is the parts list for Mercury 30 JET (3 CYL.) Crankshaft, Piston and Connecting Rods:

Position No.	Part Name	OEM Number	Supersedes
1	CRANKSHAFT ASSEMBLY	401-834774T1
1	CRANKSHAFT Comment: (BIGFOOT)	401-834774T2
2	KEY	28-893761
3	KEY, Woodruff	28-91800
4	SEAL	8M0151047
5	SEAL	8M0151048
6	CONNECTING ROD	600-893530T01	662-856065T 1
7	BOLT	10-8M0049884
8	BEARING, Brown	23-893630	23-825021
8	BEARING, Black	23-893630001	23-825021 1
8	BEARING, Blue	23-893630002	23-825021 2
9	PISTON ASSEMBLY Comment: (STANDARD)	700-893524T08	700-893524T07, 713-856064A 1 (STANDARD)
9	PISTON Comment: (.25 O/S)(BARE PISTON)	700-893524T01	713-856064 2 (.25 O/S)(BARE PISTON)
9	PISTON Comment: (.50 O/S)(BARE PISTON)	700-893524T02	713-856064 3 (.50 O/S)(BARE PISTON)
10	RING SET, Piston (TOP) Comment: (STANDARD)	39-893525A01	39-833099A 1 (STANDARD)
10	RING, Piston (TOP) Comment: (.25MM O/S)	39-893525A02	39-833100T 2 (.25MM O/S)
10	RING, Piston (TOP) Comment: (.50MM O/S)	39-893525A03	39-833100T 3 (.50MM O/S)
11	NOT SOLD SEPARATE, Piston Ring (Second) Comment: (STANDARD)	NSS
11	NOT SOLD SEPARATE, Piston Ring (Second) Comment: (.25MM O/S)	NSS
11	RING, Piston (Second) Comment: (.50MM O/S)	39-893525A03	39-833100T 3 (.50MM O/S)
12	RING, Oil	39-893950	39-893527, 39-833101 1
13	PIN, Piston	41-893863	41-825016
14	RETAINER	40-825017	40-825017F
15	GEAR, Drive	833102T	833102
-	GASKET SET, Engine	27-825231A99
-	POWERHEAD ASSEMBLY	61-803017T01	61-803017T99
-	POWERHEAD ASSEMBLY Comment: (BIGFOOT)	61-803016T01	61-803016T99 (BIGFOOT)

Crankshaft, Pistons and Connection Rods

Below is the parts list for Mercury 30 JET (3 CYL.) Crankshaft, Pistons and Connection Rods:

Position No.	Part Name	OEM Number	Supersedes
1	CRANKSHAFT ASSEMBLY	2411-827954T3
2	GEAR ASSEMBLY	43-43019A2
3	BEARING, Ball	30-63742T
4	RING, Retaining	53-812877
5	KEY, Woodruff	28-91800
6	BEARING ASSEMBLY, Roller Comment: (Top)	31-818889A1
7	SEAL, Oil	26-8173971
8	BEARING ASSEMBLY	827955A2
9	NOT SOLD SEPARATE Comment: (Roller)	NSS
10	NOT SOLD SEPARATE Comment: (Ring-Seal)	NSS
11	PISTON ASSEMBLY Comment: (Standard)	705-850026T1
11	PISTON Comment: (.015 Over Size)	705-850026T2
12	LOCK RING	53-857196	40-52035
13	RING SET, Piston Comment: (Standard)	39-831255A6
13	RING SET, Piston Comment: (.015 Over Size)	39-821695A6
14	NOT SOLD SEPARATE Comment: Piston Ring (Chrome Face)	NSS
15	CONNECTING ROD ASSEMBLY	640-9612A6
16	WASHER	12-8M0012298	12-812876
17	BEARING	29-8M0214934
18	SCREW, (.250-28 Special)	10-91012
19	BEARING KIT	8M0234886
-	POWERHEAD ASSEMBLY	852067T98	852067A98, 852067A97

Cylinder Block

Below is the parts list for Mercury 30 JET (3 CYL.) Cylinder Block:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER BLOCK	803-850082T34	803-850082T 5
1	CYLINDER BLOCK Comment: (BIGFOOT)	800-893500T02
2	PIN, Dowel	17-825010
3	PLUG	22-479452
4	PLUG, Pipe (1/2-14)	22-384073
5	PIPE PLUG (3/4-14)	22-416223
6	BEARING, Brown Comment: (BROWN)	23-893631	23-825024 (BROWN)
6	BEARING, Black Comment: (BLACK)	23-893631001	23-825024 1 (BLACK)
6	BEARING, Blue Comment: (BLUE)	23-893631002	23-825024 2 (BLUE)
7	NIPPLE, (M20)	822625
8	SCREW, (M8 x 82)	10-82506182
9	SCREW, (M6 x 35)	10-8M0205943
10	GASKET	27-8M0213112
11	FILTER ASSEMBLY, Oil	35-8M0162830
12	GASKET	27-8M4500244	27-834775005, 27-834775004, 27-834775 3
13	COVER, Exhaust	8M0183025
14	PLUG	22-479452
15	THERMOSTAT	855676003	825212001, 825212, 855676
16	GASKET	27-8M0177107
17	COVER	8M0188835
18	SCREW, (M6 x 35)	10-8M0205943
19	FITTING, Elbow 90 Degree (.125-27 x .250) Nylon	22-996642
20	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
21	TUBING, (28.00 Inches Bulk) (Cut to 11 Inches)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80
22	SENSOR ASSEMBLY, Temperature	8M0214984
23	O-RING, (.301 x .070)	25-627021
24	LIFTING EYE	893697	852560 1
25	SCREW, (M8 x 35)	10-857139
26	NOT SOLD SEPARATE, Plug-Serial Number	NSS
27	HOSE, (48.00 Inches Bulk) (Cut to 19 Inches) Comment: SN# 0T178500 & Up	32-77653101
27	HOSE, (48.00 Inches Bulk) (Cut to 18 Inches) Comment: SN# 0T178499 & Below	32-77653101
28	BRACKET, Trim Relay Comment: (Power Trim) SN# 0T294232 & Up	882831
29	SCREW, (M6 x 16) Comment: (Power Trim) SN# 0T294232 & Up	10-8248324
30	SCREW, (M6 x 30) Comment: (Power Trim) SN# 0T294232 & Up	10-82129130
-	GASKET SET, Engine	27-825231A99
-	POWERHEAD ASSEMBLY	61-803017T01	61-803017T99
-	POWERHEAD ASSEMBLY Comment: (BIGFOOT)	61-803016T01	61-803016T99 (BIGFOOT)

Cylinder Block and Crankcase

Below is the parts list for Mercury 30 JET (3 CYL.) Cylinder Block and Crankcase:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER BLOCK	2801-827953T7
2	SCREW, (M8 x 80)	10-81742780
3	SCREW, (M8 x 30)	10-81742730
4	CHECK VALVE	21-426585
5	TUBING, (240.00 Inches Bulk) (Cut to 15.00 Inch Length)	32-892024122	32-99130122
6	CHECK VALVE (Press-In)	21-426232
7	CARRIER ASSEMBLY	812888A2
8	CHECK VALVE	21-42657A4
9	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
10	NUT, (M6) Stainless Steel	11-400212
11	CAP	42942
12	PIN, Dowel - Without Hole (.375 x .625) (Locating)	17-43044
13	PIN (Bearing Race)	17-8M0084653	17-812870 1
14	GASKET	27-827284
15	STUD, (M6 x 44)	16-8161949
16	PLUG, Pipe (.375-18)	22-185981
17	PLUG, Pipe (.125-27) Brass	22-328022
18	ELBOW	22-19725
19	CHECK VALVE	21-426585
20	COVER	827251A1
21	LIFTING EYE Comment: (Manual)	850897
22	SCREW, (M8 x 25) Stainless Steel Comment: (Manual)	10-40011149
23	NOT SOLD SEPARATE Comment: (Decal-Serialization)	NSS
24	SCREW, (M8 x 25) Stainless Steel	10-40011149
25	CARRIER	889735	827365
26	THERMOSTAT, 43Â°C (110Â°F)	850055001	850055
27	SEAL	26-854639001	26-854639
28	SENDER, Temperature	787992
29	RETAINER	889733	44552
30	SCREW, (#10-16 x .600)	10-878609	10-812832 1
31	WASHER, (.203 x .500 x .032)	12-8M0204666
32	FITTING, Elbow 90 Degree (.125-27 x .250) Nylon	22-996642
33	WASHER, (.187 x .500 x .062) Neoprene Comment: (Electric)	12-8M0204663
34	WASHER, (.255 x .620 x .030) Stainless Steel Comment: (Electric)	12-69056
35	WING NUT Comment: (Electric)	11-816872
36	FITTING, Barbed Comment: (Electric)	22-56759
37	COVER Comment: (Manual)	8129962
38	O-RING, (.614 x .070) Comment: (Manual)	25-48462
39	SCREW, (M5 x 20) Stainless Steel Comment: (Manual)	10-40011108
40	TUBING, (20.00 Feet Bulk) (Cut to 5.50 Inch Length)	32-892024122	32-99130122
-	POWERHEAD ASSEMBLY	852067T98	852067A98, 852067A97
-	GASKET SET	27-828553A97

Cylinder Head

Below is the parts list for Mercury 30 JET (3 CYL.) Cylinder Head:

Position No.	Part Name	OEM Number	Supersedes
-	CYLINDER HEAD Comment: (ELECTRIC)	8M0205506
-	CYLINDER HEAD Comment: (MANUAL)	893504T02	877568T 9 (MANUAL)
1	CYLINDER HEAD	834778T2
2	GUIDE	8M0054272	825037001, 825037
3	CIRCLIP	53-825038	825722
4	ANODE	826887M
5	GROMMET	25-825040
6	COVER	826888M
7	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
8	BOLT	10-827607
9	GASKET	27-827610
10	SCREW, (M6 x 10)	10-84088M
11	GASKET	27-827610
12	SEAL, Oil	26-825048
13	PIPE PLUG	22-822644
14	O-RING	25-8M0162934
15	COVER	8M0174399
16	NOT SOLD SEPARATE, Decal-Servicing Referral	NSS
17	NOT SOLD SEPARATE, Decal-Engine Oil/Valve Clearance	NSS
18	GASKET	27-8M0118180
19	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
20	SCREW, (M6 x 25)	10-893745025
21	SCREW, (M9 x 95)	10-82503395
22	PIN, Dowel	17-825010
23	PLUG ASSEMBLY, Oil	859578A1
24	NOT SOLD SEPARATE, O Ring	NSS
25	PLATE, Baffle	855236
26	SCREW, (M4 x 10)	10-4005785
27	FITTING, Elbow - 90 Degree (.125-27)	22-629101
28	BREATHER PIPE	22-825054
29	BRACKET Comment: (HANDLE)	830294T1
30	SCREW, (M6 x 13) Stainless Steel Comment: (HANDLE)	10-40011126
31	J CLIP Comment: (USE WHERE APPLICABLE)	54-8M0024808
-	GASKET SET, Engine	27-825231A99
-	POWERHEAD ASSEMBLY	61-803017T01	61-803017T99
-	POWERHEAD ASSEMBLY Comment: (BIGFOOT)	61-803016T01	61-803016T99 (BIGFOOT)

Driveshaft Housing

Below is the parts list for Mercury 30 JET (3 CYL.) Driveshaft Housing:

Position No.	Part Name	OEM Number	Supersedes
1	SEAL, Water Tube	42941001
2	HOUSING, Driveshaft Comment: (Short) SN# 0T178500 & Up	1501-850168T5
2	HOUSING ASSEMBLY, Driveshaft Comment: (Long) SN# 0T178500 & Up	3532-825218T7
2	HOUSING, Driveshaft Comment: (Short) SN# 0T178499 & Below	1501-850168T3
2	HOUSING ASSEMBLY, Driveshaft Comment: (Long) SN# 0T178499 & Below	3532-825218T5
3	NOT SOLD SEPARATE, Exhaust Pipe Comment: (SHORT)	NSS
3	PIPE, Exhaust Comment: (LONG)	825220T06
4	SCREW, (M8 x 110) Stainless Steel	10-824459110
5	SCREW, (M8 x 45) (M8 X 45)	10-88960845
6	PLUG, Drain	8288181
7	GASKET	27-8M0204692
8	BUMPER	826276
9	GROMMET Comment: (LONG)	8M0151042
10	STUD, (M10 x 50) Comment: (NON-BIGFOOT)	16-823984
10	STUD, (M10 x 100) Comment: (BIGFOOT)	16-903501
11	WASHER, (.406 x .750 x .105) Stainless Steel	12-8M0214963
12	NUT, (M10)	11-40140
13	TUBE, Water Comment: (SHORT)	32-897970A01	32-850169002, 32-850169 (SHORT)
13	TUBE, Water Comment: (LONG)	32-897971A01	32-888591001, 32-888591, 32-825250 1 (LONG)
14	GUIDE	54-828529
15	BUMPER Comment: (LONG)	8M0043364	828706 (LONG)
16	HOUSING, Driveshaft Comment: (Bigfoot) SN# 0T178500 & Up	1503-852421T07	1503-852421T 5 (Bigfoot) SN# 0T178500 & Up
16	HOUSING ASSEMBLY, Driveshaft Comment: (Bigfoot) SN# 0T178499 & Below	1503-852421T3
17	PLATE Comment: (BIGFOOT)	893770	854471 (BIGFOOT)
18	SCREW, (M10 x 25 MM) Comment: (BIGFOOT)	10-1993325
19	SPEEDOMETER PICK UP Comment: (BIGFOOT)	22-85822A7
20	CONNECTOR, Straight Comment: (BIGFOOT)	22-85822T
21	FITTING Comment: (BIGFOOT)	22-8M0181450
22	SPACER Comment: (BIGFOOT)	23-813745	23-43041 (BIGFOOT)
23	COUPLING Comment: (BIGFOOT)	43585
24	BUSHING Comment: (BIGFOOT)	23-855623
25	WASHER, (.453 x .812 x .105) Stainless Steel Comment: (BIGFOOT)	12-45176
26	TIE STRAP, (8.00 Inches) Comment: (BIGFOOT)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275 (BIGFOOT)

Driveshaft Housing/Exhaust Plate

Below is the parts list for Mercury 30 JET (3 CYL.) Driveshaft Housing/Exhaust Plate:

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 55) Stainless Steel	10-40011155
2	GROMMET	25-93221002
3	CLAMP	99019
4	SEAL, Water Tube	42941001
5	TUBE, Water Comment: (Short)	32-8M0042795	32-881200 2 (Short)
5	TUBE, Water Comment: (Long)	32-8M0042794	32-881200 1 (Long)
6	TUBE, Exhaust	87917217T	821440 1
7	SCREW, (M8 x 45) Stainless Steel	10-40011153
8	GASKET, Driveshaft Housing	27-8M0000821	27-821446
9	ADAPTOR PLATE	821439T4
10	PIN, Dowel	17-23784
11	SCREW, (M10 x 75) Hex Flange - Stainless Steel	10-4010875
12	SEAL, Bottom Cowl	8M0043148	821510
13	COUPLER	822419
14	GROMMET	25-822408001	25-822408
15	SHIFT SHAFT (Upper)	880042	822418
16	WASHER, (.203 x .406 x .040)	12-89302
17	PIN	17-822417
18	COTTER PIN	18-210711
19	SCREW, (M12 x 162)	8M0000520	10-822396
20	MOUNT	1400-8M4501487	8M0021334, 881898, 821441
21	SCREW, (M8 x 45) Stainless Steel	10-40011153
22	CABLE ASSEMBLY, Ground	88238A10
23	WASHER, Neoprene	12-32834
24	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel	12-8M0204648
25	NUT, (M12)	11-896963	11-859129, 11-90099
26	TRIM COVER Comment: (Black)	828466A1
27	BUMPER	8M0043155	822421
28	SCREW, (M5 x .8 x 60)	10-826173
29	WASHER, (.220 x .500 x .030) Stainless Steel	12-73288
30	NUT, (M5) Stainless Steel	11-401365
31	BUMPER	8M0043170	8M0036836, 827023 1
32	SEAL	822395001	822395
33	SEAL, Idle Relief	828495001	828495
34	SCREW, (M10 x 110)	10-817430110	10-40096110
35	HOUSING, Driveshaft Comment: (Black) (Long)	3531-821447T10	3531-821447A10, 3531-821447A 7 (Black) (Long)
35	HOUSING, Driveshaft Comment: (Black) (Short) (Jet)	3525-821841T7
36	STUD, (M10 x 50)	16-823984
37	WASHER, (.406 x .750 x .105) Stainless Steel	12-8M0214963
38	NUT, (M10)	11-40140
39	MOUNT (Lower)	8284842
40	COVER, Mount Comment: (Black)	828485F1
41	SCREW, (M8 x 35) Stainless Steel	10-40011151
42	YOKE, Bottom Comment: (Black)	850030F1
43	SCREW, (M8 x 40) Stainless Steel	10-8M0038368	10-824459 40
44	WASHER	12-36001
45	NUT, (M8)	11-401378
46	SCREW, (M12 x 125)	10-828556
47	NUT, (M12)	11-896963	11-859129, 11-90099
48	CABLE ASSEMBLY (A = To Portside of Swivel Bracket)	88238A11
-	GASKET SET	27-828553A97

Electrical Components

Below is the parts list for Mercury 30 JET (3 CYL.) Electrical Components:

Position No.	Part Name	OEM Number	Supersedes
1	PLATE, Electrical	8302351
2	SCREW, (M5 x 12)	10-82239312
3	WASHER, (.203 x .406 x .040)	12-89302
4	TIE STRAP, (4.00 Inches)	56762
5	REV LIMITER Comment: (Manual)	821889A49	821889A41 (Manual)
5	REV LIMITER Comment: (Electric)	821889A50	821889A42 (Electric)
6	CLAMP Comment: (Electric)	8266241
7	SCREW, (M5 x 12) Comment: (Electric)	10-82239312
8	SOLENOID ASSEMBLY Comment: (Electric)	89-8M0185146
9	BUSHING Comment: (Electric)	23-8M0214955
10	GROMMET Comment: (Electric)	25-818967
11	SCREW, (M6 x 25 MM) Comment: (Electric)	10-82129125
12	NUT, (.250-20) Comment: (Electric)	11-64015
13	LOCKWASHER, (.250) Stainless Steel Comment: (Electric)	13-26992
14	CABLE ASSEMBLY Comment: (Electric)	84-88807A33
15	CABLE ASSEMBLY, (4.00 Inches) Black Comment: (Electric)	84-88807A16
16	NUT, Brass Comment: (Electric)	8-32,11-26419
17	REGULATOR, Voltage Comment: (Electric)	8M0084173	883072T, 854515T 1 (Electric)
18	SCREW, (M6 x 40) Comment: (Electric)	10-82129140
19	J CLIP Comment: (Electric)	54-8M0024808
20	BOOT, Insulator - Red Comment: (Electric)	85-830233
21	CABLE ASSEMBLY, Battery - Negative Comment: (Electric)	84-88439A4
22	WASHER, (.281 x .500 x .060) Stainless Steel (Quantity of 3 on Electric)	12-8M0204649
23	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
24	SCREW, (M6 x 25 MM)	10-82129125
25	CABLE ASSEMBLY	84-88807A31
26	SCREW, (M8 x 20) Comment: (Manual)	10-81742720
27	SCREW, (M6 x 16) Comment: (Manual)	10-82129116
28	J CLIP (Quanity of 3 on Electric)	54-54457
29	HARNESS ASSEMBLY, Engine Comment: (Electric)	84-850220A2
30	FUSE, Yellow - 20 Ampere Comment: (Electric)	88-812619	88-860608 (Electric)
31	GROMMET	25-822002
32	BUSHING	23-822003
33	WASHER	12-8M0214930
34	SCREW, (M6 x 25) Stainless Steel	10-40011129
35	HARNESS ASSEMBLY, Ignition	84-850221A2
36	CDM MODULE ASSEMBLY Comment: (5 Inch Leads)	827509T7
36	CDM MODULE ASSEMBLY Comment: (11 Inch Leads)	827509A10	827509A 4 (11 Inch Leads)
37	CABLE ASSEMBLY, Hi-Tension	84-857124A1
38	BOOT/TERMINAL KIT	85-857074A1
39	SPARK PLUG Comment: (NGK# BP8H-N-10)	33-816737Q	33-816737 2 (NGK# BP8H-N-10)
39	SPARK PLUG Comment: (NGK#BPZ-8H-N-10)	33-938
39	SPARK PLUG Comment: (NGK#BUZ8H)	33-896329885
40	SCREW, (M6 x 16)	10-82129116
41	HARNESS ASSEMBLY, Power Comment: (Manual)	84-850052A1
42	HARNESS ASSEMBLY Comment: (Manual)	84-11149T31
43	HARNESS ASSEMBLY Comment: (Manual)	84-852375A2
43	HARNESS ASSEMBLY Comment: (Electric)	84-852375A4

Electrical Components(0G960499 and Below)

Below is the parts list for Mercury 30 JET (3 CYL.) Electrical Components(0G960499 and Below):

Position No.	Part Name	OEM Number	Supersedes
1	SOLENOID ASSEMBLY Comment: (ELECTRIC)	89-8M0185146
2	BUSHING Comment: (ELECTRIC)	23-8M0214955
3	GROMMET Comment: (ELECTRIC)	25-818967
4	NUT, Brass Comment: (ELECTRIC)	8-32,11-26419
5	NUT, (.250-20) Brass Comment: (ELECTRIC)	11-94330
6	CABLE ASSEMBLY, Battery - Positive Comment: (ELECTRIC)	84-88439A9
7	BOOT, Insulator - Black Comment: (ELECTRIC)	85-79695T
8	CABLE ASSEMBLY Comment: (ELECTRIC)	84-93388A13
9	CABLE ASSEMBLY, Battery - Negative Comment: (ELECTRIC)	84-88439A4
10	STARTER MOTOR ASSEMBLY Comment: (ELECTRIC)	50-893887T	50-888160T, 50-884045T, 50-859170T 1 (ELECTRIC)
11	SCREW, (M8 x 45) Stainless Steel Comment: (ELECTRIC)	10-40011153
11	SCREW, (M8 x 25) Stainless Steel Comment: (MANUAL)	10-40011149
12	SCREW, (M6 x 30) Comment: (ELECTRIC)	10-82684430
12	SCREW, (M6 x 16) Comment: (MANUAL)	10-8248324
13	J CLIP Comment: (ELECTRIC)	54-8M0024808
14	PRESSURE SWITCH	87-8M0098207	87-8M0070107, 87-828040 1
15	SENSOR	8M0082988	8M0030022, 828358 2
16	SCREW, (M5 x 16) Stainless Steel	10-40011107
17	SCREW, (M6 x 25)	10-82130025
18	WASHER, (.265 x .750 x .048) Stainless Steel	12-65567
19	PLATE	859224	856604
20	BUSHING	23-822003
21	GROMMET	25-8M0190980
22	ECM, Engine Control Module	87843302S
23	BUSHING	23-8539201
24	SCREW, (M6 x 40)	10-82129140
25	SPARK PLUG, NGK-DPR6EA-9	33-827858Q	33-827858
26	NOT SOLD SEPARATE, Decal-Coil Identification	NSS
27	COIL, Ignition	339-830404T3
28	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
29	HARNESS ASSEMBLY, Engine Wiring Comment: (MANUAL)	84-856158A2
29	HARNESS ASSEMBLY, Engine Wiring Comment: (ELECTRIC)	84-854781A2
30	FUSE, Yellow - 20 Ampere Comment: (ELECTRIC)	88-812619	88-860608 (ELECTRIC)
31	COVER, Fuse Comment: (ELECTRIC)	828054
32	CLAMP, Connector Comment: (ELECTRIC)	8261151
33	SCREW, (M6 x 16) Comment: (ELECTRIC)	10-8248324
34	HARNESS ASSEMBLY, Extension Comment: (ELECTRIC HANDLE)	84-852375A6
35	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
36	J CLIP Comment: (MANUAL)	54-47483
37	REGULATOR, Voltage Comment: (ELECTRIC)	883071T	854514T, 854514, 856747 (ELECTRIC)
38	J CLIP Comment: (ELECTRIC)	54-8M0024808
39	SCREW, (M6 x 40) Comment: (ELECTRIC)	10-8248329
39	SCREW, (M6 x 16) Comment: (MANUAL)	10-8248324
40	SCREW, (M6 x 10) Comment: (ELECTRIC)	10-82129110
41	PLUG, Male Comment: (Quantity of 2 on Manual)	13541
42	SCREW, (M6 x 16)	10-8248324
43	CABLE ASSEMBLY	84-858884A1
-	POWERHEAD ASSEMBLY	61-803017T01	61-803017T99
-	POWERHEAD ASSEMBLY Comment: (BIGFOOT)	61-803016T01	61-803016T99 (BIGFOOT)

Electrical Components(0G960500 and Up)

Below is the parts list for Mercury 30 JET (3 CYL.) Electrical Components(0G960500 and Up):

Position No.	Part Name	OEM Number	Supersedes
1	SOLENOID ASSEMBLY Comment: (ELECTRIC)	89-8M0185146
2	BUSHING Comment: (ELECTRIC)	23-8M0214955
3	GROMMET Comment: (ELECTRIC)	25-818967
4	NUT, Brass Comment: (ELECTRIC)	8-32,11-26419
5	NUT, (.250-20) Brass Comment: (ELECTRIC)	11-94330
6	CABLE ASSEMBLY, Battery - Positive Comment: (ELECTRIC)	84-88439A9
7	BOOT, Insulator - Red Comment: (ELECTRIC)	85-8500671
8	CABLE ASSEMBLY Comment: (ELECTRIC)	84-93388A13
9	CABLE ASSEMBLY, Battery - Negative Comment: (ELECTRIC)	84-88439A4
10	STARTER MOTOR ASSEMBLY Comment: (ELECTRIC)	50-893887T	50-888160T, 50-884045T, 50-859170T 1 (ELECTRIC)
11	SCREW, (M8 x 45) Stainless Steel Comment: (ELECTRIC)	10-40011153
11	SCREW, (M8 x 25) Stainless Steel Comment: (MANUAL)	10-40011149
12	SCREW, (M6 x 30) Comment: (ELECTRIC)	10-82684430
12	SCREW, (M6 x 16) Comment: (MANUAL)	10-8248324
13	PRESSURE SWITCH	87-8M0098207	87-8M0070107, 87-828040 1
14	SENSOR	8M0082988	8M0030022, 828358 2
15	SCREW, (M5 x 16) Stainless Steel	10-40011107
16	SCREW, (M6 x 25)	10-82130025
17	WASHER	12-8M0214930
18	PLATE	859224	856604
19	RETAINER Comment: (ELECTRIC)	856836001	856836, 856039 (ELECTRIC)
20	BRACKET Comment: (ELECTRIC)	856040
21	SCREW, (M6 x 14) Comment: (ELECTRIC)	10-82129114
22	RETAINER Comment: (ELECTRIC)(Quantity of 2 on Handle)	92753
23	BUSHING	23-856954
24	GROMMET	25-8M0190980
25	ECM, Engine Control Module Comment: SN# 0T178500 & Up	87843302S
25	ECM, Engine Control Module Comment: SN# 0T178499 & Below	87843302S
26	BUSHING	23-8539201
27	SCREW, (M6 x 40)	10-82129140
28	SPARK PLUG, NGK-DPR6EA-9	33-827858Q	33-827858
29	COIL ASSEMBLY, Ignition	339-858942T1
30	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
31	HARNESS ASSEMBLY, Engine Wiring Comment: (MANUAL)	84-859196T1
32	HARNESS ASSEMBLY, Engine Wiring Comment: (ELECTRIC) SN# 0T294065 & Up	84-859197T3
32	HARNESS ASSEMBLY, Engine Wiring Comment: (ELECTRIC) SN# 0T178500 THRU 0T294064	84-859197T2
32	HARNESS ASSEMBLY, Engine Wiring Comment: (ELECTRIC) SN# 0T178499 & Below	84-859197T1
33	FUSE, Yellow - 20 Ampere Comment: (ELECTRIC)	88-812619	88-860608 (ELECTRIC)
34	COVER, Fuse Comment: (ELECTRIC)	828054
35	HARNESS ASSEMBLY, Extension Comment: (ELECTRIC HANDLE)	84-852375A6
36	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
37	J CLIP Comment: (MANUAL)	54-8M0024808
38	REGULATOR, Voltage Comment: (ELECTRIC)	883071T1
39	BRACKET Comment: (ELECTRIC)	893771	858413 (ELECTRIC)
40	FOAM PAD Comment: (ELECTRIC)	8308971
41	SCREW, (M6 x 40) Comment: (ELECTRIC)	10-8248329
41	SCREW, (M6 x 16) Comment: (MANUAL)	10-8248324
42	SCREW, (M6 x 10) Comment: (ELECTRIC)	10-82129110
43	PLUG, Male Comment: (MALE)	13541
44	CABLE ASSEMBLY Comment: (Use where Applicable)	84-877860T1
45	SCREW, (M6 x 16)	10-8248324
46	J CLIP Comment: (ELECTRIC-NON POWER TRIM)	54-8M0024808
47	SCREW, (M6 x 16) Comment: (ELECTRIC-NON POWER TRIM)	10-8248324
-	POWERHEAD ASSEMBLY	61-803017T01	61-803017T99
-	POWERHEAD ASSEMBLY Comment: (BIGFOOT)	61-803016T01	61-803016T99 (BIGFOOT)

Flywheel

Below is the parts list for Mercury 30 JET (3 CYL.) Flywheel:

Position No.	Part Name	OEM Number	Supersedes
1	FLYWHEEL COVER Comment: (ELECTRIC)	859284T2
2	SCREW, (M6 x 25 MM) Comment: (ELECTRIC)	10-8248326
3	DECAL, EPA Label Information Comment: (ELECTRIC)(1999)	37-856985A22	37-856985 22 (ELECTRIC)(1999)
3	DECAL, EPA Label Information Comment: (ELECTRIC)(2000)	37-804654A00
3	DECAL, EPA Label Information Comment: (ELECTRIC)(2001)	37-804654A01
4	FLYWHEEL Comment: (ELECTRIC)	284-832010T32	284-832010T31, 284-832010T26, 284-832010T14, 284-832010A 8 (ELECTRIC)
5	FLYWHEEL Comment: (MANUAL)	284-832010T27	284-832010T16, 284-832010A 4 (MANUAL)
6	NOT SOLD SEPARATE, Decal-Warning Spinning Flywheel	NSS
7	NOT SOLD SEPARATE, Decal-Timing Marks	NSS
8	NOT SOLD SEPARATE, Decal-Warning-Neutral	NSS
9	NUT	11-893789	11-81773M
10	WASHER	12-893762	12-84436M
11	SCREW, (M5 x 25) Comment: SN# 0G960499 & Below	10-4007325
11	SCREW, (M5 x 25) Comment: (Manual) SN# 0G960500 & Up	10-4007325
11	SCREW, (M5 x 30) Comment: (Electric) SN# 0G960500 & Up	10-4013930
12	STATOR Comment: (Electric) SN# 0G960500 & Up	398-852387T7
12	STATOR Comment: (Manual) SN# 0G960500 & Up	398-852386T6
12	STATOR Comment: (Electric) SN# 0G960499 & Below	398-852387T9
12	STATOR Comment: (Manual) SN# 0G960499 & Below	398-852386T8
13	LOAD RING	834838

Flywheel and Stator(Electric)

Below is the parts list for Mercury 30 JET (3 CYL.) Flywheel and Stator(Electric):

Position No.	Part Name	OEM Number	Supersedes
1	COVER ASSEMBLY	812777T1
2	NUT, (M16)	11-42979
3	WASHER, (.641 x 1.250 x .190)	12-33001
4	FLYWHEEL	261-859234T24	261-859234T 2
5	IGNITION STATOR KIT	398-832075A21	398-832075A 4
6	SCREW, (M5 x 30)	10-4013930
7	TRIGGER	854512T	834820T
8	SWIVEL BALL	93421
9	SWIVEL BASE	93254
10	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
11	DECAL, EPA Label Information Comment: (1999)	37-856985A7
11	DECAL, EPA Label Information Comment: (2000)	37-804665A00
11	DECAL, EPA Label Information Comment: (2001)	37-804665A01
11	DECAL, EPA Label Information Comment: (2002)	37-804665A02
11	DECAL, EPA Label Information Comment: (2003)	37-804665A03
11	DECAL, EPA Label Information Comment: (2004)	37-804665A04

Flywheel and Stator(Manual)

Below is the parts list for Mercury 30 JET (3 CYL.) Flywheel and Stator(Manual):

Position No.	Part Name	OEM Number	Supersedes
1	FLYWHEEL	261-859234T25	261-859234T 4
2	NUT, (M16)	11-42979
3	WASHER, (.641 x 1.250 x .190)	12-33001
4	STATOR	398-832074A11	398-832074A 5
5	SCREW, (M5 x 30)	10-4013930
6	TRIGGER	854512T	834820T
7	SWIVEL BALL	93421
8	SWIVEL BASE	93254
9	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
10	PLUG, Male	13541

Fuel Lines

Below is the parts list for Mercury 30 JET (3 CYL.) Fuel Lines:

Position No.	Part Name	OEM Number	Supersedes
1	HOSE	32-856607
2	HOSE	32-856609
3	LINKAGE	856610
4	BUSHING	23-803896
5	TIE STRAP	823548T	823548, 54-856608
6	HOSE	32-856613
7	HOSE and SLEEVE	32-856611
8	CONNECTOR	22-822771
9	FITTING, 45 Degree Comment: SN# 0T178500 & Up	22-878404
10	HOSE Comment: SN# 0T178500 & Up	32-878423
11	TUBING, (17.00 Inches Bulk) (Cut to 3-1/2 Inches) Comment: SN# 0T178500 & Up	32-85682239
12	HOSE (90MM) Comment: SN# 0T178500 & Up	32-82381310
13	CLIP Comment: SN# 0T178500 & Up	54-878425
14	TIE STRAP, (4.00 Inches)	56762
15	WASHER	12-8542592
16	COTTER PIN	18-880850
17	Y-CONNECTOR Comment: SN# 0T178500 & Up	22-878593

Fuel Pump

Below is the parts list for Mercury 30 JET (3 CYL.) Fuel Pump:

Position No.	Part Name	OEM Number	Supersedes
1	FILTER, Fuel	35-877565T1
2	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
3	HOSE, (57.00 Inches Bulk) (Cut to 14 Inches)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
4	HOSE, (57.00 Inches Bulk) (Cut to 19 Inches)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
5	CONNECTOR ASSEMBLY, Fuel	22-8M0148585
-	O-RING, Fuel Connector	25-16524
6	PUMP, Fuel	826398T3
7	SCREW, (M5 x 35)	10-809564
8	COVER	809565
9	DIAPHRAGM	8095611
10	SCREW, (M3 x 5)	10-41889M
11	NUT	11-82537M
12	CHECK VALVE	21-41888M
13	DIAPHRAGM	8095612
14	PIN	17-8095661
15	SPRING	24-809562
16	NUT, (M5)	11-82388M
17	SPRING	24-8095621
18	PLUNGER	8095631
19	O-RING	25-8M0052669	25-825492
20	SCREW, (M6 x 30)	10-82684430
21	PLUG	19-854310	806899
22	J CLIP	54-8M0024808
23	DEFLECTOR, Cowl	8M0007776	893698001, 856603 1
-	GASKET SET, Engine	27-825231A99

Fuel Pump(Electric)

Below is the parts list for Mercury 30 JET (3 CYL.) Fuel Pump(Electric):

Position No.	Part Name	OEM Number	Supersedes
-	PUMP ASSEMBLY, Fuel	14360A78
1	NOT SOLD SEPARATE Comment: (Diaphragm Kit)	NSS
2	DIAPHRAGM KIT	21-857005A1
3	NOT SOLD SEPARATE Comment: (Diaphragm)	NSS
4	NOT SOLD SEPARATE Comment: (Retainer)	NSS
5	NOT SOLD SEPARATE Comment: (Spring)	NSS
6	NOT SOLD SEPARATE Comment: (Cap)	NSS
7	NOT SOLD SEPARATE Comment: (Spring)	NSS
8	NOT SOLD SEPARATE Comment: (Cap)	NSS
9	NOT SOLD SEPARATE Comment: (Diaphragm)	NSS
10	GASKET	27-8M0204705
11	NOT SOLD SEPARATE Comment: (Gasket-Boost)	NSS
12	NOT SOLD SEPARATE Comment: (Gasket-Pulse)	NSS
13	PLATE	987752
14	CONNECTOR, (90 Degree) With Vibraseal	22-433351
15	SCREW, (M5 x 40)	10-82104540
15	SCREW, (M6 x 50)	10-82130050
16	BASE	144303
17	HOSE	32-831949
18	FILTER, Fuel	35-816296Q2
19	LINE, Fuel	32-830761	32-19723
20	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
21	TUBING, (.312) (70.00 Inches Bulk) (Cut to 1.50 Inch Length) Comment: (40)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80 (40)
21	TUBING, (.312) (70.00 Inches Bulk) (Cut to 1.25 Inch Length) Comment: (50)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80 (50)
22	TUBING, (.312) (70.00 Inches Bulk) (Cut to 1.50 Inch Length) Comment: (40)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80 (40)
22	TUBING, (.312) (70.00 Inches Bulk) (Cut to 1.25 Inch Length) Comment: (50)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80 (50)
23	CONNECTOR Comment: (40)	22-818992
23	CONNECTOR, Tee Comment: (50)	22-818993
24	TUBING, (15.00 Inches Bulk) (Cut to 2.00 Inch Length) Comment: (40)	32-82381335
24	TUBING, (15.00 Inches Bulk) (Cut to 1.50 Inch Length) Comment: (50)	32-82381335
25	TUBING, (.312) (70.00 Inches Bulk) (Cut to 22.00 Inch Length)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80
26	CHECK VALVE	22-8189941
27	CONNECTOR ASSEMBLY, Fuel	22-816856T01	22-816856A 1
28	SCREW, (M6 x 35)	10-4000332
29	HOSE, (.187) (26.00 Inches Bulk) (Cut to 4.25 Inch Length)	32-9912878
30	CLAMP	54-633003
31	SOLENOID KIT, Enrichner Valve	89-819503A5
32	TUBING, (36.00 Inches Bulk) (Cut to 8.00 Inch Length)	32-9912688
33	TUBING, (36.00 Inches Bulk) (Cut to 4.00 Inch Length)	32-9912688
34	TUBING, (240.00 Inches Bulk) (Cut to 14.00 Inch Length)	32-892024122	32-99130122
35	FITTING, Tee	22-59169003
36	TUBING, (36.00 Inches Bulk) (Cut to 2.00 Inch Length)	32-9912688
37	SCREW, (M6 x 16)	10-4006731
-	POWERHEAD ASSEMBLY	852067T98	852067A98, 852067A97
-	GASKET SET	27-828553A97

Fuel Pump(Manual)

Below is the parts list for Mercury 30 JET (3 CYL.) Fuel Pump(Manual):

Position No.	Part Name	OEM Number	Supersedes
-	PUMP ASSEMBLY, Fuel	14360A78
1	NOT SOLD SEPARATE Comment: (Fuel Pump)	NSS
2	DIAPHRAGM KIT	21-857005A1
3	NOT SOLD SEPARATE Comment: (Diaphragm Kit)	NSS
4	NOT SOLD SEPARATE Comment: (Retainer)	NSS
5	NOT SOLD SEPARATE Comment: (Spring)	NSS
6	NOT SOLD SEPARATE Comment: (Cap)	NSS
7	NOT SOLD SEPARATE Comment: (Diaphragm)	NSS
8	NOT SOLD SEPARATE Comment: (Cap)	NSS
9	NOT SOLD SEPARATE Comment: (Diaphragm)	NSS
10	GASKET	27-8M0204705
11	NOT SOLD SEPARATE Comment: (Gasket-Boost)	NSS
12	NOT SOLD SEPARATE Comment: (Gasket-Pulse)	NSS
13	PLATE	987752
14	CONNECTOR, (90 Degree) With Vibraseal	22-433351
15	SCREW, (M5 x 40)	10-82104540
15	SCREW, (M6 x 50)	10-82130050
16	BASE	144303
17	TUBING, (.312) (70.00 Inches Bulk) (22 Inch)	32-8M0108349	32-8M0047448, 32-830757130, 32-830757 80
18	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
19	LINE, Fuel	32-830761	32-19723
20	HOSE, (.187) (26.00 Inches Bulk) (Cut to 4.25 Inch Length)	32-9912878
21	FILTER, Fuel	35-816296Q2
22	HOSE	32-831949
23	FITTING, Tee	22-59169003
24	TUBING, (20.00 Feet Bulk) (Cut to 9.50 Inch Length)	32-892024122	32-99130122
25	PRIMER BULB	858763	816877 3
26	CONNECTOR ASSEMBLY, Fuel	22-816856T01	22-816856A 1
27	SCREW, (M6 x 35)	10-4000332
28	TUBING, (20.00 Feet Bulk) (Cut to 5.50 Inch Length)5-1/2 Inch)	32-892024122	32-99130122
29	TUBING, (20.00 Feet Bulk) (Cut to 1.50 Inch Length)1-1/2 Inch)	32-892024122	32-99130122
-	POWERHEAD ASSEMBLY	852067T98	852067A98, 852067A97
-	GASKET SET	27-828553A97

Gasket Set Components-Engine Overhaul

Below is the parts list for Mercury 30 JET (3 CYL.) Gasket Set Components-Engine Overhaul:

Position No.	Part Name	OEM Number	Supersedes
-	GASKET SET	27-828553A97
0	O-RING, (.614 x .070)	25-48462
0	GASKET, Cylinder Block to Exhaust Plate	27-8M0000822	27-828553, 27-812865, 27-822420
0	O-RING, (2.175 x .175)	25-8M0142854
0	SEAL, Water Tube, Upper	42941001
0	GASKET, Driveshaft Housing	27-8M0000821	27-821446
0	WASHER	12-866451
0	GASKET, Upper Water Pump, Water Pump	27-822189
0	GASKET, Lower Water Pump, Lower	27-8M0214956
0	O-RING, (1.421 x .139) (1.421 I.D.)	25-821308
0	SEAL	12-191833
0	O-RING, (1.609 x .139)	25-26855
0	GASKET, Induction Manifold	27-812869
0	GASKET, Reed Block	27-812868
0	GASKET, Thermostat Cover	27-827284
0	O-RING, (.239 x .174) (.239 I.D.)	25-85594
0	GASKET , Water Tube	27-823942
0	O-RING, Bearing Carrier	25-815460
0	O-RING (.676 I.D.)	25-36390
0	O-RING (.739 I.D.)	25-8M0204667
0	NOT SOLD SEPARATE (Disc-Check Valve)	NSS
0	NOT SOLD SEPARATE (Diaphragm-Fuel Pump)	NSS
0	GASKET, Fuel Pump	27-8M0204705
0	NOT SOLD SEPARATE (Gasket-Boost Chamber)	NSS
0	NOT SOLD SEPARATE (Gasket-Pulse Chamber)	NSS
0	RETAINER, Check Valve	21-17311
0	NOT SOLD SEPARATE (Spring Compression, Boost)	NSS
0	NOT SOLD SEPARATE (Spring Compression, Main)	NSS
0	NOT SOLD SEPARATE (Cap-Spring End)	NSS
0	NOT SOLD SEPARATE (Cap-Spring End)	NSS
0	GASKET, Flange, Carburetor	27-8144461

Gear Housing(Driveshaft)(1.83:1 Gear Ratio)

Below is the parts list for Mercury 30 JET (3 CYL.) Gear Housing(Driveshaft)(1.83:1 Gear Ratio):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY Comment: (Black)(Short)	1682-821306T26	1682-821306A26 (Black)(Short)
-	GEAR HOUSING ASSEMBLY Comment: (Black)(Long)	1682-821306T28	1682-821306A28 (Black)(Long)
1	GEAR HOUSING ASSEMBLY, Basic Comment: (Basic-Black)	1682-821306T12	1682-821306A12 (Basic-Black)
2	SEAL/PLATE KIT	818226A1
3	NOT SOLD SEPARATE Comment: (Plate)	NSS
4	SCREW KIT, (.375-16 x .250) Drain (.375-16 X .25)	10-79953Q04
5	WASHER	12-191833
6	SCREW KIT, (.375-16 x .250) Drain	10-79953Q04
6	FITTING KIT, Magnetic, Plug Fill/Drain	22-8M0058389	22-67892A06
7	WASHER	12-191833
8	NUT, (.437-20)	11-55910
9	GEAR, Pinion (12 Teeth)	43-822161T2
10	BEARING ASSEMBLY	31-821321A2
11	NOT SOLD SEPARATE Comment: (Cup)	NSS
12	SCREW, (M6 x 16)	10-8248324
13	HOUSING ASSEMBLY, Water Pump Upper	46-821351A3
14	SEAL	8235471
15	WASHER	12-866451
16	KEY	28-8M0214993
17	WASHER	12-866451
18	GASKET, Upper Water Pump	27-822189
19	GASKET, Lower Water Pump (Lower)	27-8M0214956
20	FACE PLATE	8213542
21	IMPELLER	47-8M0204712
22	BASE ASSEMBLY, Water Pump	46-821307A2
23	SEAL	26-821309
24	SEAL	26-821310
25	O-RING, (1.421 x .139)	25-821308
26	DRIVESHAFT Comment: (Short)	45-822466A1
26	DRIVESHAFT Comment: (Long)	45-822159T1
27	BEARING, Ball	30-821311
28	TIE STRAP	823548T	823548, 54-856608
29	BOOT	822158
30	RETAINER	821827
31	O-RING, (1.609 x .139)	25-26855
32	O-RING, (.239 x .174)	25-85594
33	WASHER	12-814803	12-93853
34	SHIFT SHAFT Comment: (Short)	822453A1
34	SHIFT SHAFT Comment: (Long)	821319A1
35	NUT, (M6) Stainless Steel	11-400212
36	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
37	PIN, (.078 x .437)	17-85593
38	CAM, Shift	8213161
39	PIN, (.125 x .625)	17-822369
-	GASKET SET	27-828553A97
-	SEAL KIT	823547A2
-	REPAIR KIT, Water Pump	821354A2

Gear Housing(Driveshaft-2.31:1 Gear Ratio)

Below is the parts list for Mercury 30 JET (3 CYL.) Gear Housing(Driveshaft-2.31:1 Gear Ratio):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete	1667-9011G86
1	GEAR HOUSING ASSEMBLY, Basic	1667-9011G59
2	PIN, Dowel - With Hole (.375 x .625) (FRONT)	17-8M0084244	17-43043
3	TUBE, Oiler	43046
4	SCREW KIT, (.375-16 x .250)	10-79953Q04
4	FITTING KIT, Magnetic, Plug Fill/Drain	22-8M0058389	22-67892A06
5	WASHER, Fiber	12-191833
6	PIN, Dowel - Without Hole (.375 x .625) (REAR)	17-43044
7	TRIM TAB	31640T07
8	SCREW, (.437-14 x 1.250) Stainless Steel	10-825427	10-15942
9	WASHER, (.453 x .812 x .105) Black Oxide	12-451761
10	CARRIER ASSEMBLY	43040T1
11	NOT SOLD SEPARATE, Needle Bearing	NSS
12	ANODE	97-826134Q	826134, 826134A 1
13	NUT, (M6)	11-401386
14	SCREW, (M6 x 40)	10-4000333
15	GEAR, Pinion (13 Teeth)	43-44484T
16	NUT, (.625-18)	11-35921
17	CAM, Shift Control	850307
18	BEARING ASSEMBLY, Tapered Roller	31-42677A1
19	SHIM SET	15-44492A1
20	DRIVESHAFT ASSEMBLY	45-854808A1
21	SLEEVE/RING KIT	42461A1
22	NOT SOLD SEPARATE, Ring Seal	NSS
23	COVER ASSEMBLY, Water Pump	43055A4
24	GASKET	27-430331
25	GASKET	27-8M0214931
26	SEAL, Oil (LOWER)	26-43036
27	SEAL, Oil (UPPER)	26-43035
28	GASKET	27-8172771
29	HOUSING KIT, Upper Water Pump	817275A2
30	FACEPLATE	8M0204709
31	SCREW, (M6 x 30)	10-8M0214957
32	SEAL	8M0204658
33	KEY	28-8M0204723
34	IMPELLER	47-43026T2
35	SCREW, (M6 x 25 MM)	10-8248326
36	SHIFT SHAFT ASSEMBLY	853906A1
37	E RING	53-29641
38	BUSHING ASSEMBLY	23-43052A4
39	O-RING, (1.424 x .103)	25-8M0204681
40	SEAL, Oil	26-8M0204708
41	SCREW, (M6 x 25 MM)	10-8248326
42	FACE SEAL	26-861415	26-816575
-	SEAL KIT, Gear Housing	26-43035A4
-	REPAIR KIT, Water Pump	46-8M0113799
-	REPAIR KIT, Water Pump Impeller	47-8M0100526	47-43026Q06

Gear Housing(Driveshaft-2:1 Gear Ratio)

Below is the parts list for Mercury 30 JET (3 CYL.) Gear Housing(Driveshaft-2:1 Gear Ratio):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, (3.44 Inch/87.37 mm Torpedo Diameter) Complete Comment: (SHORT)	1682-821306T54	1682-821306T38 (SHORT)
-	GEAR HOUSING ASSEMBLY, Complete Comment: (LONG)	1682-821306T17	1682-821306A17 (LONG)
1	GEAR HOUSING ASSEMBLY, Basic Comment: (BASIC)	1682-821306T12	1682-821306A12 (BASIC)
2	SEAL/PLATE KIT	818226A1
3	NOT SOLD SEPARATE, Plate	NSS
4	SCREW KIT, (.375-16 x .250) (.375-16 X .25)	10-79953Q04
5	WASHER, Fiber	12-191833
6	SCREW KIT, (.375-16 x .250)	10-79953Q04
6	FITTING KIT, Magnetic, Plug Fill/Drain Comment: (MAGNETIC)	22-8M0058389	22-67892A06 (MAGNETIC)
7	WASHER, Fiber	12-191833
8	NUT, (.437-20)	11-55910
9	GEAR, Pinion - 13 Teeth	43-821326T1
10	BEARING ASSEMBLY	31-821321A2
11	NOT SOLD SEPARATE, Cup	NSS
12	SCREW, (M6 x 16)	10-8248324
13	HOUSING ASSEMBLY, Water Pump Upper	46-821351A3
14	SEAL Comment: (SHORT - 1-3/4)	8M0204658
14	SEAL Comment: (LONG - 2-1/4)	8235471
15	WASHER	12-866451
16	KEY	28-8M0214993
17	WASHER	12-866451
18	GASKET, Upper Water Pump	27-822189
19	GASKET, Lower Water Pump (LOWER)	27-8M0214956
20	FACE PLATE	8213542
21	IMPELLER	47-8M0204712
22	BASE ASSEMBLY, Water Pump	46-821307A2
23	SEAL	26-821309
24	SEAL	26-821310
25	O-RING, (1.421 x .139)	25-821308
26	DRIVESHAFT Comment: (SHORT)	45-826193T2
26	DRIVESHAFT Comment: (LONG)	45-826194A1
27	BEARING, Ball	30-821311
28	TIE STRAP	823548T	823548, 54-856608
29	BOOT	822158
30	RETAINER	821827
31	O-RING, (1.609 x .139)	25-26855
32	O-RING, (.239 x .174)	25-85594
33	WASHER	12-814803	12-93853
34	SHIFT SHAFT Comment: (SHORT)	827865A2
34	SHIFT SHAFT Comment: (LONG)	827865A1
35	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
36	PIN, (.078 x .437)	17-85593
37	CAM, Shift	8213161
38	PIN, (.125 x .625)	17-822369
-	SEAL KIT	823547A2
-	REPAIR KIT, Water Pump	821354A2

Gear Housing(Prop Shaft - 2.31:1 - S/N-0T625303 and below)

Below is the parts list for Mercury 30 JET (3 CYL.) Gear Housing(Prop Shaft - 2.31:1 - S/N-0T625303 and below):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete	1667-9011G86
1	GEAR HOUSING ASSEMBLY, Basic	1667-9011G59
2	BEARING SET, Cup And Cone	31-30894A1
3	NOT SOLD SEPARATE, Cup	NSS
4	GEAR ASSEMBLY, Forward - 30 Teeth	43-859472A3
5	BEARING, Needle	31-30895T
6	RING, Retaining	53-856823
7	FOLLOWER KIT, Cam	850315A1
8	BALL	30-44530
9	NOT SOLD SEPARATE, Slide	NSS
10	SPRING	24-850327
11	CLUTCH	52-850048T	52-850048
12	PIN, Cross	17-8M0100263	17-8M0084681, 17-8M0020941, 17-30632
13	SPRING	24-30893
14	PROPELLER SHAFT	44-8M0140445
15	GEAR, Reverse (30 Teeth)	43-850034T	43-850034
16	CARRIER ASSEMBLY, Bearing	8M0168901
17	O-RING, (3.609 x .139)	25-8M0214974
18	BEARING, Needle	31-30956T
19	SEAL, Oil (INNER)	26-8M0205728
20	SEAL, Oil (OUTER)	26-8M0205729
21	BEARING, Roller	31-12578T
22	THRUST WASHER	12-12577
23	BEARING, Thrust	31-12576
24	STUD, (M8 x 48)	16-8M0034456	16-42917 2
25	WASHER, (.323 x .590 x .112) Stainless Steel	12-855941
26	NUT, (M8)	11-401378
27	SHIM SET	15-44491A1
28	INSERT, Threaded	8227731
29	NOT SOLD SEPARATE, Decal	NSS
30	NOT SOLD SEPARATE, Decal-Prop Operation	NSS
31	THRUST WASHER	13191Q01
32	PROP NUT KIT, (.750-16)	11-52707Q1
33	TAB WASHER	14-816629Q	14-816629, 14-31210, 14-816629B
34	SCREW, (M10 x 45)	10-4000380
35	WASHER, (.406 x .750 x .105) Stainless Steel	12-8M0214963
-	SEAL KIT, Gear Housing	26-43035A4

Gear Housing, Propeller Shaft - 1.83:1 Gear Ratio

Below is the parts list for Mercury 30 JET (3 CYL.) Gear Housing, Propeller Shaft - 1.83:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY Comment: (Black)(Short)	1682-821306T26	1682-821306A26 (Black)(Short)
-	GEAR HOUSING ASSEMBLY Comment: (Black)(Long)	1682-821306T28	1682-821306A28 (Black)(Long)
1	GEAR HOUSING ASSEMBLY, Basic Comment: (Basic-Black)	1682-821306T12	1682-821306A12 (Basic-Black)
40	PIN, Dowel	17-821327
41	GASKET	27-823942
42	TUBE	32-8M0026108	32-821828
43	PLUG, Rubber	19-824928001	19-824928, 19-32297
44	SCREEN	821829
45	TRIM TAB	822157T2
46	SCREW, (M8 x 20)	10-82497020
47	WASHER	12-72397
48	GEAR, Forward (22 Teeth)	43-822162T2
49	BEARING ASSEMBLY, Roller	31-8M0103470	31-99328A 1
50	NOT SOLD SEPARATE Comment: (Cup)	NSS
51	BEARING, Roller	31-41326
52	FOLLOWER, Cam	821578
53	SPRING	24-8261991
54	PIN	17-8M0020999	17-85093
55	CLUTCH	52-821314T	52-821314
56	SPRING	24-38114
57	PROPELLER SHAFT	44-8M0140441
58	GEAR, Reverse (22 Teeth)	43-822163T1
59	BEARING, Ball	30-20839T
60	CARRIER ASSEMBLY, Bearing	8M0168900
61	O-RING	25-815460
62	BEARING, Needle	31-21700
63	SEAL, Oil	26-8M0205511
64	SEAL, Oil	26-8M0203757
65	WASHER, (.323 x .563 x .063) Stainless Steel	12-8M0042642	12-70132
65	WASHER, (.323 x .590 x .112) Stainless Steel Comment: (Use with Threaded Insert)	12-855941
66	SCREW, (M8 x 25)	10-4000353
66	SCREW, (M8 x 30) Comment: (Use with Threaded Insert)	10-85594030
67	INSERT, Threaded	8227731
68	NOT SOLD SEPARATE (Decal 1.83:1) (12 X 22)	NSS
69	THRUST HUB	73345A1
70	PROP NUT KIT	11-69578Q1
71	TAB WASHER	14-8M0214942
72	SCREW, (M10 x 45)	10-4000380
73	WASHER, (.406 x .750 x .105) Stainless Steel	12-8M0214963
-	GASKET SET	27-828553A97
-	SEAL KIT	823547A2

Gear Housing, Propeller Shaft - 2:1 Gear Ratio

Below is the parts list for Mercury 30 JET (3 CYL.) Gear Housing, Propeller Shaft - 2:1 Gear Ratio:

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, (3.44 Inch/87.37 mm Torpedo Diameter) Complete Comment: (SHORT)	1682-821306T54	1682-821306T38 (SHORT)
-	GEAR HOUSING ASSEMBLY, Complete Comment: (LONG)	1682-821306T17	1682-821306A17 (LONG)
1	GEAR HOUSING ASSEMBLY, Basic Comment: (BASIC)	1682-821306T12	1682-821306A12 (BASIC)
39	PIN, Dowel	17-821327
40	GASKET	27-823942
41	TUBE	32-8M0026108	32-821828
42	PLUG, Rubber	19-824928001	19-824928, 19-32297
43	SCREEN	821829
44	TRIM TAB	822157T2
45	SCREW, (M8 x 20)	10-82497020
46	WASHER	12-72397
47	GEAR ASSEMBLY, Forward - 26 Teeth	43-821315T1
48	BEARING ASSEMBLY, Roller	31-8M0103470	31-99328A 1
49	NOT SOLD SEPARATE, Cup	NSS
50	BEARING, Roller	31-41326
51	FOLLOWER, Cam	821578
52	SPRING	24-8261991
53	PIN	17-8M0020999	17-85093
54	CLUTCH	52-821314T	52-821314
55	SPRING	24-38114
56	PROPELLER SHAFT	44-8M0140441
57	GEAR, Reverse - 26 Teeth	43-821312T1
58	BEARING, Ball	30-20839T
59	CARRIER ASSEMBLY, Bearing	8M0168900
60	O-RING	25-815460
61	BEARING, Needle	31-21700
62	SEAL, Oil	26-8M0205511
63	SEAL, Oil	26-8M0203757
64	WASHER, (.323 x .590 x .112) Stainless Steel	12-855941
65	SCREW, (M8 x 30)	10-85594030
66	INSERT, Threaded	8227731
67	NOT SOLD SEPARATE, Decal (2:1)	NSS
68	THRUST HUB	73345A1
69	PROP NUT KIT	11-69578Q1
70	TAB WASHER	14-8M0214942
71	SCREW, (M10 x 45)	10-4000380
72	WASHER, (.406 x .750 x .105) Stainless Steel	12-8M0214963
73	PLUG	19-95925
-	SEAL KIT	823547A2

Induction Manifold and Reed Block

Below is the parts list for Mercury 30 JET (3 CYL.) Induction Manifold and Reed Block:

Position No.	Part Name	OEM Number	Supersedes
1	GASKET	27-8M0000822	27-828553, 27-812865, 27-822420
2	END CAP ASSEMBLY	1171-9812A8
3	SEAL, Oil	26-828932	26-821756
4	SEAL	26-41953
5	O-RING, (2.175 x .175)	25-8M0142854
6	SCREW, (M8 x 20)	10-81742720
7	BRACKET ASSEMBLY	19077A07
8	STUD, (M6 x 44)	16-8161949
9	WASHER, (.187 x .500 x .062) Neoprene Comment: (Electric)	12-8M0204663
10	WASHER, (.255 x .620 x .030) Stainless Steel Comment: (Electric)	12-69056
11	WING NUT Comment: (Electric)	11-816872
12	SCREW, (M8 x 35 MM)	10-82127335
13	MANIFOLD ASSEMBLY, Induction	827998A1
14	ELBOW Comment: (Electric)	22-19725
15	ELBOW Comment: (Manual)	22-19725
16	CAP Comment: (Manual)	22-15026
17	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
18	GASKET	27-812869
19	SCREW, (M8 x 30)	10-81742730
20	REED BLOCK ASSEMBLY	8M0219197
21	GASKET	27-812868
22	NOT SOLD SEPARATE Comment: (Dowel Pin)	NSS
23	REED ASSEMBLY	34-812880A03	34-812880A 1, 34-812880A 2
24	TAB WASHER	14-429821
25	RETAINER, Reed Comment: (50)	812879002	812879 1 (50)
26	RETAINER, Reed Comment: (40)	825267
27	SCREW, (M6 x 16)	10-88421471
-	POWERHEAD ASSEMBLY	852067T98	852067A98, 852067A97
-	GASKET SET	27-828553A97

Intake

Below is the parts list for Mercury 30 JET (3 CYL.) Intake:

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M6 x 90)	10-82615890
2	INTAKE, Air	856126T
3	O-RING	25-856525
4	PLATE	834783T
5	ISOLATOR Comment: (40)	834784T
5	ISOLATOR Comment: (30)	834784T1
6	PLUG	19-827633
7	ATTENUATOR, Sound	856127A2
8	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
9	BUSHING	23-17044M
10	TIE STRAP, (11.750 Inches)	54-850181
11	SEAL	26-856128001	26-856128
12	O-RING	25-8250572
13	PIN, Dowel	17-23784
14	SCREW, (M6 x 25 MM)	10-8248326
15	BREATHER HOSE	32-8M0182223
16	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
-	GASKET SET, Engine	27-825231A99

Intake/Exhaust Valves

Below is the parts list for Mercury 30 JET (3 CYL.) Intake/Exhaust Valves:

Position No.	Part Name	OEM Number	Supersedes
1	VALVE, Exhaust	8M0119204
2	VALVE, Intake	832990T1
3	WASHER, Valve Spring	12-825044
4	SEAL, Valve Stem	26-822647
5	SPRING, Valve Outer	24-823678
6	RETAINER	822650
7	KEY	28-893554	28-822651
8	ROCKER ARM	898821A01
9	SCREW	10-825046
10	NUT	11-826150	11-858274
11	SHAFT, Rocker	834780T1
12	PLUG	19-825042
13	BRACKET	825050
14	PLATE	825051
15	SPRING	24-825052
16	SPRING	24-854713
17	SCREW, (M8 x 30)	10-82641030
-	GASKET SET, Engine	27-825231A99

Jet Components

Below is the parts list for Mercury 30 JET (3 CYL.) Jet Components:

Position No.	Part Name	OEM Number
1	SCREW, (M6 x 16)	10-8248324
2	HOUSING ASSEMBLY, Water Pump Upper	46-821351A3
3	SEAL	8235471
4	WASHER	12-866451
5	KEY	28-8M0214993
6	WASHER	12-866451
7	GASKET, Upper Water Pump	27-822189
8	GASKET, Lower Water Pump	27-8M0214956
9	FACE PLATE	8213542
10	IMPELLER	47-8M0204712
11	EXTENSION, Water Tube	854491
-	SEAL KIT	823547A2
-	REPAIR KIT, Water Pump	821354A2
-	GASKET SET	27-828553A97

Jet Pump Assembly

Below is the parts list for Mercury 30 JET (3 CYL.) Jet Pump Assembly:

Position No.	Part Name	OEM Number	Supersedes
-	JET PUMP ASSEMBLY Comment: (With Stainless Steel Impeller)	856143A5
1	HOUSING, Pump	801411401
2	HOSE, Lube	32-827490
3	SHIFT LINKAGE KIT	878376
4	CAM	878381
5	GATE, Reverse - With Bumper	878379
6	IMPELLER Comment: (Stainless Steel)	47-855708T40	47-801414 40 (Stainless Steel)
7	HOUSING, Intake	80141240
8	LINER	827188T1
9	DRIVESHAFT	45-801413401
10	THRUST WASHER	12-879652
11	BEARING, Ball	30-879653
12	SLEEVE	23-827189
13	NUT	11-827190
14	KEY, Impeller	28-801405625
15	SHIM, Impeller	15-801404625
16	TAB WASHER	14-801403625
17	SCREW, (.250-20 x .750) Stainless Steel	10-90192
18	SCREW, (.250-20 x .875)	10-19923088
19	WASHER, (.281 x .625 x .065) Stainless Steel	12-35044
20	SCREW, (.250-20 x .625)	10-19923062
21	SCREW, (.312-18 x 1.250)	10-60411
22	BRACKET, Cable Support	801410
23	NUT, (.312-18)	11-82670910
24	PIN, Dowel	17-801406
25	SCREW, (.312-18 x 2.50)	10-19924250
25	SCREW, (.312-18 x 2.75)	10-19924275
26	WASHER	12-8M0207778
27	SCREW, (.375-16 x 1.25)	10-19925125
28	ADAPTOR	853881
29	SCREW, (M10 x 1.5 x 30)	10-1993330
30	WASHER, (.406 x .734 x .063) Stainless Steel	12-34931
31	SCREW, (M10 x 35)	10-87810178
32	PIN, Dowel	17-821327

Linkage(Electric Bigfoot)

Below is the parts list for Mercury 30 JET (3 CYL.) Linkage(Electric Bigfoot):

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 70) Stainless Steel	10-40011158
2	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
3	NUT, (M6)	11-401196
4	CAP	42942
5	LEVER ASSEMBLY, Throttle Comment: (DESIGN II)	822682A4
6	RETAINER Comment: (DESIGN II)	883160
7	BUSHING	23-825078
8	RETAINER	822459
9	LEVER, Shift	8259571
10	BRACKET	827706A4
11	LATCH	98889
12	SCREW, (M6 x 16)	10-8248324
13	SLEEVE	23-15885
14	SHIFT ROD	893777	850162
15	GUIDE, Shift Rod	8501631
16	SHIFT LINK	893769A01	850255A 1
17	BUSHING	23-48475
18	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
19	NUT, (M6)	11-401386
20	COTTER PIN	18-210711
21	LEVER ASSEMBLY, Shift Shaft	850166T2
22	BUSHING	23-850165
23	CAM, Throttle	8535853
24	SPACER	23-309772
25	WASHER	12-4002314
26	SCREW, (M5 x 16)	10-40056107
27	LEVER, Throttle Comment: (DESIGN I)	822682A4
28	RETAINER Comment: (DESIGN I)	826587	826587 1 (DESIGN I)

Linkage(Manual Bigfoot-0G960499 and Below)

Below is the parts list for Mercury 30 JET (3 CYL.) Linkage(Manual Bigfoot-0G960499 and Below):

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 70) Stainless Steel	10-40011158
2	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
3	NUT, (M6)	11-401196
4	CAP	42942
5	RETAINER	826587	826587 1
6	LEVER, Throttle	822682A4
7	BUSHING	23-825078
8	RETAINER	822459
9	LEVER, Shift	8259571
10	BRACKET	827706A4
11	LATCH	98889
12	SCREW, (M6 x 16)	10-8248324
13	SLEEVE	23-15885
14	GUIDE, Shift Rod	8501631
15	SHIFT LINK	893769A01	850255A 1
16	BUSHING	23-48475
17	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
18	NUT, (M6)	11-401386
19	COTTER PIN	18-210711
20	LEVER ASSEMBLY, Shift Shaft	850166T2
21	BUSHING	23-850165
22	CAM, Throttle	8535853
23	SPACER	23-309772
24	WASHER	12-4002314
25	SCREW, (M5 x 16)	10-40056107
26	ROD	854467
27	DETENT/SPRING KIT	12016A2
28	NOT SOLD SEPARATE, Spring	NSS

Linkage(Manual Bigfoot-0G960500 and Up)

Below is the parts list for Mercury 30 JET (3 CYL.) Linkage(Manual Bigfoot-0G960500 and Up):

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 70) Stainless Steel	10-40011158
2	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
3	NUT, (M6)	11-401196
4	CAP	42942
5	LEVER ASSEMBLY, Throttle Comment: (DESIGN II)	822682A4
6	SCREW, (M6 x 25 MM)	10-8248326
7	SHIFT GUIDE	858245
8	SCREW, (M5 x 12)	10-82239312
9	SHIFT SLIDE	858246
10	DETENT/SPRING KIT	12016A2
11	NOT SOLD SEPARATE, Spring	NSS
12	SHIFT ROD	858247
13	COTTER PIN	18-210711
14	NUT, (M6)	11-401386
15	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
16	SHIFT LINK	858248
17	BUSHING	23-48475
18	LEVER ASSEMBLY, Shift Shaft	850166T2
19	BUSHING	23-850165
20	CAM, Throttle	8535853
21	SPACER	23-309772
22	WASHER	12-4002314
23	SCREW, (M5 x 16)	10-40056107
24	LEVER, Throttle Comment: (DESIGN I)	822682A4

Linkage(Non Bigfoot)

Below is the parts list for Mercury 30 JET (3 CYL.) Linkage(Non Bigfoot):

Position No.	Part Name	OEM Number	Supersedes
1	SCREW, (M8 x 70) Stainless Steel	10-40011158
2	SCREW, Adjusting (M6 x 55) Comment: (30 HP)	10-814776	10-42978 (30 HP)
3	NUT, (M6) Comment: (30 HP)	11-401196
4	BUSHING Comment: (30 HP)	23-823807	23-42806 (30 HP)
5	SCREW, Adjusting (M6 x 55) Comment: (40 HP)	10-814776	10-42978 (40 HP)
6	NUT, (M6) Comment: (40 HP)	11-401196
7	CAP Comment: (40 HP)	42942
8	LEVER ASSEMBLY, Throttle Comment: (DESIGN II)	822682A4
9	RETAINER Comment: (ELECTRIC)(DESIGN II)	883160
10	BUSHING	23-825078
11	RETAINER Comment: (NON HANDLE)	822459
12	LEVER, Shift Comment: (NON HANDLE)	8259571
13	BRACKET Comment: (NON HANDLE)	827706A4
14	LATCH Comment: (NON HANDLE)	98889
15	SCREW, (M6 x 16) Comment: (NON HANDLE)	10-8248324
16	SLEEVE Comment: (NON HANDLE)	23-15885
17	SHIFT ROD Comment: (NON HANDLE)	882820	826271 (NON HANDLE)
18	CAM, Throttle	8535853
19	SPACER	23-309772
20	WASHER	12-4002314
21	SCREW, (M5 x 16)	10-40056107
22	SHIFT SHAFT ASSEMBLY, Horizontal	826588A4
23	RETAINER	8277071
24	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
25	COTTER PIN	18-210711
26	SPRING, Detent	24-826077
27	SPRING, Backing	24-824993
28	SPRING, Plate	824994
29	SCREW, (M5 x 16) Stainless Steel	10-40011107
30	SWITCH Comment: (ELECTRIC HANDLE MODELS)	87-8M0052927	87-813960A 3 (ELECTRIC HANDLE MODELS)
31	SCREW, (M3.5 x 20) Stainless Steel Comment: (ELECTRIC HANDLE MODELS)	10-88075020
32	PLATE Comment: (ELECTRIC HANDLE MODELS)	824923
33	LEVER, Throttle Comment: (DESIGN I)	822682A4
34	RETAINER Comment: (DESIGN I)	826587	826587 1 (DESIGN I)

Lube Chart

Below is the parts list for Mercury 30 JET (3 CYL.) Lube Chart:

Position No.	Part Name	OEM Number	Supersedes
	NO PARTS LIST	NOPART

Manual Starter

Below is the parts list for Mercury 30 JET (3 CYL.) Manual Starter:

Position No.	Part Name	OEM Number	Supersedes
-	STARTER ASSEMBLY, Recoil	835253A13	835253T 6
1	HOUSING ASSEMBLY, Recoil	835253A12	835253A 8
2	CAM	8167122
3	SPRING	24-8267911
4	SEAL	8M0026455	835255 2
5	ROLLER	835256T	835256
6	BUSHING	23-852987T	23-852987
7	WASHER	826414T	12-826414
8	SCREW, (M6 x 30)	10-82684430
9	LOCKWASHER	13-826229
10	SPRING	24-86857T01
11	SHEAVE ASSEMBLY, Starter	50-854317T5
12	CAM	868501
13	SPRING	24-86851T02
14	RING, Retaining	53-86849T01
15	SPRING	24-868523
16	CAM	86853T01
17	SCREW, (.250-20 x .625)	10-826253	10-97516, 10-818838
18	ROPE	50-12066Q10
19	LEVER, Interlock	856073	852449
20	RETAINER	856072T	856072
21	SPRING	24-856138T03	24-856138 3
22	BUSHING	854779T	854779
23	SCREW, (#10-16 x 1.00)	10-8182491
24	HANDLE ASSEMBLY	85174A1
25	NOT SOLD SEPARATE	NSS
26	SCREW, (M6 x 25 MM)	10-8248326
27	CABLE, Interlock	856754	816748 6
28	SCREW, (#10-16 x .625)	10-8214281
29	WASHER, (.220 x .500 x .030) Stainless Steel	12-73288
30	COTTER PIN	18-26811
31	SCREW, (M5 x 16) Stainless Steel	10-40011107
32	DECAL, EPA Label Information Comment: (1999)	37-856985A22	37-856985 22 (1999)
32	DECAL, EPA Label Information Comment: (2000)	37-804654A00
32	DECAL, EPA Label Information Comment: (2001)	37-804654A01

Manual Tilt

Below is the parts list for Mercury 30 JET (3 CYL.) Manual Tilt:

Position No.	Part Name	OEM Number	Supersedes
-	MANUAL TRIM ASSEMBLY	8M0118570
1	SHOCK ROD ASSEMBLY	8M0118572
2	PISTON ASSEMBLY, Trim Memory	893903A01
3	O-RING KIT, Cylinder	25-893917A01	25-809872A 1
4	NOT SOLD SEPARATE, O Ring	NSS
5	CYLINDER ASSEMBLY	893918A01	811224A 1
6	SCREW AND SEAL KIT	893919A01	813433A 2
7	ACCUMULATOR ASSEMBLY	893920A01	813454A 2
8	VALVE BODY ASSEMBLY	893921A01	813455T 4
9	CAM KIT	893923A01	813457A 3
10	VALVE KIT, Velocity	893924A01	809881A 1
11	REPAIR KIT	893925A01	809882A 1
12	CABLE ASSEMBLY, Ground	8M0207768
-	O-RING KIT	25-893922A01	25-809880A 2
13	PIN	17-19607
14	PIN, Trilobe	17-821539	17-13794, 17-19603

Oil Injection Components

Below is the parts list for Mercury 30 JET (3 CYL.) Oil Injection Components:

Position No.	Part Name	OEM Number	Supersedes
1	BUSHING	23-822003
2	GROMMET	25-822002
3	SCREW, (M6 x 25) Stainless Steel	10-40011129
4	TANK ASSEMBLY, Oil	1276-828163A2
5	CAP ASSEMBLY	36-828765A2
6	NOT SOLD SEPARATE, Tether	NSS
7	PUSH NUT	11-821285
8	VENT ASSEMBLY	19299A1
9	VALVE	21-64871
10	SEAL	8M0039080	816066 2
11	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
12	GROMMET	25-813644002	25-813644 1
13	SWITCH ASSEMBLY	87-12886A6
14	SCREW, (.164-18 x .375)	10-58376
15	WASHER, (.203 x .562 x .060) Stainless Steel	12-72761
16	SPACER	23-826084
17	TUBING, (15.00 Inches Bulk) (12 Inch)	32-82381335
18	PUMP ASSEMBLY, Oil Injection Comment: (40)	818902A2
19	PUMP ASSEMBLY, Oil Injection Comment: (50)	818902A1
20	O-RING	25-36390
21	O-RING	25-8M0204667
22	SCREW, (M5 x 20) Stainless Steel	10-40011108
23	GEAR, Driven	43-19277
24	BEARING ASSEMBLY	23-19278A2
25	BUSHING (Flanged)	23-17597
26	BUSHING	23-17596
27	LINK	8M0084729	826581A 2
-	GASKET SET	27-828553A97

Power Trim

Below is the parts list for Mercury 30 JET (3 CYL.) Power Trim:

Position No.	Part Name	OEM Number	Supersedes
-	PUMP/MOTOR ASSEMBLY Comment: (NON-BIGFOOT)	8M0055006	893518T01, 830150T10, 830150T 6 (NON-BIGFOOT)
-	PUMP/MOTOR ASSEMBLY Comment: (BIGFOOT)	8M0055011	893517T01, 855654T09, 855654T08, 855654T 4 (BIGFOOT)
1	SHOCK ROD KIT	893943A01	855833A 1
2	PISTON ASSEMBLY, Memory	8M0171822
3	O-RING KIT, Rebuild	25-8M0171819
4	NOT SOLD SEPARATE, O Ring	NSS
5	CYLINDER ASSEMBLY	893904T01	811228A 1
6	VALVE KIT, Trim Limit Comment: (NON-BIGFOOT)	893905A02	809873A 1 (NON-BIGFOOT)
6	VALVE KIT, Trim Limit Comment: (BIGFOOT)	893944A01	809873A 2 (BIGFOOT)
7	PUMP ASSEMBLY	893906A02	809874A 1
8	MOTOR KIT	893907A02	809885A 2
9	PLUG	22-8134351
10	MANUAL RELEASE ASSEMBLY	893929A01	813442A 2
11	MANIFOLD KIT	893909A02	809875A 1
12	SCREW KIT (MOTOR)	10-809876A1
13	DRIVESHAFT/SEAL KIT	809877A1
14	FILTER KIT	35-893912A02	809878A 1
15	POPPET KIT	893913A02	809879A 1
16	CABLE ASSEMBLY	88238A18
-	O-RING KIT (COMPLETE TRIM)	25-893914A02	25-809880A 1
17	PIN, Trilobe	17-821539	17-13794, 17-19603
18	PIN	17-19607
19	PIN	17-822869001	17-822869
-	HARNESS ASSEMBLY, Trim Comment: SN# 0T178500 & Up	84-826802T21
-	HARNESS/RELAY ASSEMBLY Comment: SN# 0T178499 & Below	84-826802A15
20	HARNESS ASSEMBLY, Trim Comment: SN# 0T178500 & Up	84-826802T19
20	HARNESS ASSEMBLY Comment: SN# 0T178499 & Below	84-826802A12
21	RELAY ASSEMBLY	8M0207773
22	BRACKET	828102
23	GROMMET	25-818967
24	BUSHING	23-8M0214955
25	NOT SOLD SEPARATE, Decal-Trim Relay	NSS
26	SCREW, (M6 x 30) Comment: SN# 0T294064 & Below	10-82684430
1	POWER TRIM ASSEMBLY	822344T14	822344T10, 822344T 5
-	O-RING KIT	25-827668A1
2	SHOCK ROD ASSEMBLY	893931A01	827670A 2
3	PILOT CHECK ASSEMBLY	827671A1
4	TILT RELIEF VALVE ASSEMBLY	827672A1
5	SEAT ASSEMBLY, Suction	827673A1
6	PUMP ASSEMBLY	827674A1
7	NOT SOLD SEPARATE Comment: (Ball/Spring)	NSS
8	NOT SOLD SEPARATE Comment: (Screw)	NSS
9	NOT SOLD SEPARATE Comment: (Filter)	NSS
10	NOT SOLD SEPARATE Comment: (O Ring)	NSS
11	MOTOR ASSEMBLY	827675A1
12	NOT SOLD SEPARATE Comment: (Screw)	NSS
13	NOT SOLD SEPARATE Comment: (Washer)	NSS
14	CABLE ASSEMBLY	88238A15
15	NOT SOLD SEPARATE Comment: (O Ring)	NSS
16	NOT SOLD SEPARATE Comment: (Coupler)	NSS
17	PISTON, Memory	827676
18	MANUAL RELEASE ASSEMBLY	893929A01	813442A 2
19	PLUG ASSEMBLY	19-811613
20	BRACKET	831276T
21	HARNESS ASSEMBLY, Trim	84-826802A9
22	SCREW, (M6 x 25 MM)	10-82129125
23	RELAY ASSEMBLY	8M0207773
24	BRACKET	828102
25	GROMMET	25-818967
26	BUSHING	23-8M0214955
27	NOT SOLD SEPARATE Comment: (Decal)	NSS
28	SCREW, (#10-16 x .600)	10-878609	10-812832 1
29	C WASHER	8M0084613	69205
30	CLIP	54-22740

Service and Support Material

Below is the parts list for Mercury 30 JET (3 CYL.) Service and Support Material:

Part Name	OEM Number	Supersedes
PARTS MANUAL, 30/40 Carb 4-Stroke (3 Cylinder)	90-803941
OWNERS MANUAL	90-10212010
OWNERS MANUAL Comment: (TRACKER)	90-10214010
SERVICE MANUAL	90-857046R1
DECAL SET Comment: (BLACK 30)(1999 MODEL YEAR AND ABOVE)	37-803640A00	37-803640A99 (BLACK 30)(1999 MODEL YEAR AND ABOVE)
DECAL SET Comment: (BLACK 40)(2000 MODEL YEAR AND ABOVE)	37-803641A00	37-803641A99 (BLACK 40)(2000 MODEL YEAR AND ABOVE)
DECAL SET Comment: (BLACK 40 BIGFOOT)(2000 MODEL YEAR AND ABOVE)	37-803644A00	37-803644A99 (BLACK 40 BIGFOOT)(2000 MODEL YEAR AND ABOVE)
DECAL SET Comment: (BLACK 40)(1999 MODEL YEAR)	37-803641A00	37-803641A99 (BLACK 40)(1999 MODEL YEAR)
DECAL SET Comment: (BLACK 40 BIGFOOT)(1999 MODEL YEAR)	37-803644A00	37-803644A99 (BLACK 40 BIGFOOT)(1999 MODEL YEAR)
DECAL SET Comment: (GRAY 30)(1999/2000 MODEL YEARS)	37-803642A03	37-803642A01, 37-803642A99 (GRAY 30)(1999/2000 MODEL YEARS)
DECAL SET Comment: (GRAY 40)(1999/2000 MODEL YEARS)	37-803643A03	37-803643A01, 37-803643A99 (GRAY 40)(1999/2000 MODEL YEARS)
DECAL SET Comment: (GRAY 40 BIGFOOT)(1999/2000 MODEL YEARS)	37-803645A01	37-803645A99 (GRAY 40 BIGFOOT)(1999/2000 MODEL YEARS)
DECAL SET Comment: (GRAY 30)(2001 MODEL YEAR)	37-803642A03	37-803642A01, 37-803642A99 (GRAY 30)(2001 MODEL YEAR)
DECAL SET Comment: (GRAY 40)(2001 MODEL YEAR)	37-803643A03	37-803643A01, 37-803643A99 (GRAY 40)(2001 MODEL YEAR)
DECAL SET Comment: (GRAY 40 BIGFOOT)(2001 MODEL YEAR)	37-803645A01	37-803645A99 (GRAY 40 BIGFOOT)(2001 MODEL YEAR)
DECAL SET Comment: (TRACKER 30)	37-803946A99
DECAL SET Comment: (TRACKER 40)	37-803947A99
DECAL, EPA Label Information Comment: (1999)	37-856985A22	37-856985 22 (1999)
DECAL, EPA Label Information Comment: (2000)	37-804654A00
DECAL, EPA Label Information Comment: (2001)	37-804654A01

Service/Support Material

Below is the parts list for Mercury 30 JET (3 CYL.) Service/Support Material:

Part Name	OEM Number	Supersedes
PARTS MANUAL, 40/50 Jet 30 (3 Cylinder) 2-Stroke	90-803026
SERVICE MANUAL	90-8M0110565	90-852572R02, 90-852572R 1
OWNERS MANUAL Comment: (Mercury/Mariner)(USA)	90-10170040
OWNERS MANUAL Comment: (Mercury/Mariner)(Belgium)	90-10170V40
OWNERS MANUAL Comment: (Jet 30)	90-10204010
DECAL SET Comment: (Black 40)(2000 and Above)	37-830163A00
DECAL SET Comment: (Black 50)(1997 and Above)	37-852079A00	37-852079A97 (Black 50)(1997 and Above)
DECAL SET Comment: (Black Jet 30)(2000 - 2001)	37-804687A00
DECAL SET Comment: (Black 40)(1997 Through 1999)	37-830163A97
DECAL SET Comment: (Black Jet 30-also need 37-830163A97)(1997 Through 1999)	37-83016330
DECAL SET Comment: (Black Jet 30-also need 37-830163-30)(1997 Through 1999)	37-830163A97
DECAL SET Comment: (Gray 40)(2001/2002)	37-830164A03	37-830164A01, 37-830164A97 (Gray 40)(2001/2002)
DECAL SET Comment: (Gray 40)(2003)	37-830164A03	37-830164A01, 37-830164A97 (Gray 40)(2003)
DECAL SET Comment: (Gray 50)(2001/2002)	37-852080A03	37-852080A01, 37-852080A97 (Gray 50)(2001/2002)
DECAL SET Comment: (Gray 50)(2003)	37-852080A03	37-852080A01, 37-852080A97 (Gray 50)(2003)
DECAL SET Comment: (Gray Jet 30)(2001 and Above)	37-830162A01	37-830162A98 (Gray Jet 30)(2001 and Above)
DECAL SET Comment: (Gray 40)(1997 Through 2000)	37-830164A03	37-830164A01, 37-830164A97 (Gray 40)(1997 Through 2000)
DECAL SET Comment: (Gray 50)(1997 Through 2000)	37-852080A03	37-852080A01, 37-852080A97 (Gray 50)(1997 Through 2000)
DECAL SET Comment: (Gray Jet 30)(1998 Through 2000)	37-830162A01	37-830162A98 (Gray Jet 30)(1998 Through 2000)
DECAL SET Comment: (Tracker 40)	37-850311A97
DECAL SET Comment: (Tracker 50)	37-803948A99
DECAL, EPA Label Information Comment: (1999)	37-856985A7
DECAL, EPA Label Information Comment: (2000)	37-804665A00
DECAL, EPA Label Information Comment: (2001)	37-804665A01
DECAL, EPA Label Information Comment: (2002)	37-804665A02
DECAL, EPA Label Information Comment: (2003)	37-804665A03
DECAL, EPA Label Information Comment: (2004)	37-804665A04

Starter Assembly(Manual)

Below is the parts list for Mercury 30 JET (3 CYL.) Starter Assembly(Manual):

Position No.	Part Name	OEM Number	Supersedes
1	HANDLE ASSEMBLY	85174A1
2	NOT SOLD SEPARATE Comment: (Retainer)	NSS
-	REST ASSEMBLY, Starter Handle	821788A6
3	NOT SOLD SEPARATE Comment: (Rest)	NSS
4	SEAL	8M0043416	824995 1
5	SCREW, (M6 x 30) Stainless Steel	10-4010630
6	SPACER	23-830190
7	BUSHING	23-816086
8	GROMMET	25-8157951
9	WASHER, (.265 x .750 x .048)	12-858779
10	NUT, (M6)	11-401196
11	CABLE, Interlock	8567541
12	SCREW, (#10-16 x .625)	10-8214281
13	WASHER, (.220 x .500 x .030) Stainless Steel	12-73288
14	COTTER PIN	18-26811
15	SCREW, (#10-16 x .500)	10-878608	10-812832
16	COTTER PIN	18-26811
-	STARTER ASSEMBLY, Recoil	816728T14	816728A14, 816728A12, 816728A11, 816728A10, 816728A 9
17	HOUSING	816728T05	816728 5
18	SPRING	24-826791	24-816718 1
19	LEVER	8166903
20	CAM	816712T01	816712 1
21	RETAINER	816711
22	SCREW, (#10-16 x 1.00)	10-8182491
23	LOCKWASHER, SPRING	13-826229
24	SPRING	24-86857T01
25	SHEAVE, Starter	50-825269T01	50-825269A 1
26	SPRING	24-86851T02
27	CAM	868501
28	RING, Retaining	53-86849T01
29	ROPE	50-12066Q10
30	SPRING	24-868523
31	CAM	86853T01
32	SCREW, (.250-20 x .625)	10-826253	10-97516, 10-818838
33	BUSHING	8M0183792
34	RING, Retaining	53-818853	53-42689
35	NOT SOLD SEPARATE Comment: (Timing Decal)	NSS
36	NOT SOLD SEPARATE Comment: (Decal-Caution in Gear Idle)	NSS
37	DECAL, EPA Label Information Comment: (1999)	37-856985A7
37	DECAL, EPA Label Information Comment: (2000)	37-804665A00
37	DECAL, EPA Label Information Comment: (2001)	37-804665A01
37	DECAL, EPA Label Information Comment: (2002)	37-804665A02
37	DECAL, EPA Label Information Comment: (2003)	37-804665A03
37	DECAL, EPA Label Information Comment: (2004)	37-804665A04

Starter Motor

Below is the parts list for Mercury 30 JET (3 CYL.) Starter Motor:

Position No.	Part Name	OEM Number	Supersedes
1	STARTER MOTOR ASSEMBLY Comment: (NUT DESIGN)	50-893887T	50-888160T, 50-884045T, 50-859170T 1 (NUT DESIGN)
1	STARTER MOTOR ASSEMBLY Comment: (RETAINING RING DESIGN)	50-893887T	50-888160T, 50-884045T, 50-859170T 1 (RETAINING RING DESIGN)
2	THRU BOLT	10-965661
3	DRIVE KIT Comment: (NUT DESIGN)	891752	90643 4 (NUT DESIGN)
4	DRIVE KIT Comment: (RETAINING RING DESIGN)	803945
5	ARMATURE Comment: (RETAINING RING DESIGN)	8236382
5	ARMATURE Comment: (NUT DESIGN)	8236384
6	PINION	68575T2
7	DRIVE CAP	8236392
8	CAP, Commutator	8119011
9	BRUSH/SPRING KIT	898265016	75384, 75384 1
10	HOLDER	898265014	61787
11	SCREW	F15158
12	DECAL, Warning, High Voltage	37-8272822
1	STARTER MOTOR ASSEMBLY	50-893890T	50-822462T 1
2	THRU BOLT	10-965661
3	DRIVE KIT	90643
4	DRIVE ASSEMBLY	685753
5	DRIVE CAP	8236392
6	ARMATURE	965651
7	CAP, Commutator	8119011
8	BRUSH/SPRING KIT	898265016	75384, 75384 1
9	HOLDER	898265014	61787
10	SCREW	F15158
11	LOCKWASHER, (.250) Stainless Steel	13-26992
12	NUT, (.250-20)	11-64015
13	CABLE ASSEMBLY, Battery - Positive	84-88439A9
14	SCREW, (M8 x 45) Stainless Steel	10-40011153
15	NOT SOLD SEPARATE, Decal-Warning	NSS
16	BRACKET, Oil Tank	823989

Steering Arm

Below is the parts list for Mercury 30 JET (3 CYL.) Steering Arm:

Position No.	Part Name	OEM Number	Supersedes
1	NUT, (M12)	11-896963	11-859129, 11-90099
2	STRAP	893773002	827923 2, 893773001, 827923 1
3	MOUNT	8M0224385
4	WASHER, (12.80 mm x 24.0 mm x 2.4 mm) Stainless Steel Comment: (BIGFOOT)	12-4002321
5	SCREW, (M6 x 20) Stainless Steel	10-8M0204741
6	BUMPER	8M0156878
7	BUMPER Comment: (BIGFOOT)	8M0156878
8	RING, Retaining	53-89531
9	ARM, Steering	8M0118183
10	BRACKET Comment: (ELECTRIC)	8M0184092
11	TAB WASHER Comment: (ELECTRIC)	14-8M0009820	14-816669F 1 (ELECTRIC)
12	SCREW, (M10 x 30) Comment: (ELECTRIC)	10-4000377
13	BOLT, (M12 x 154)	10-898835001	10-42973
14	SPACER Comment: (SHORT)	23-8279973
14	SPACER Comment: (LONG)	23-8279971
15	SWIVEL TUBE Comment: (SHORT)	8M0219910
15	SWIVEL TUBE Comment: (LONG)	893590T01	826233T 4 (LONG)
16	CABLE ASSEMBLY	84-88238T01
17	CABLE ASSEMBLY, Ground	8M0207768
18	SCREW, (M10 x 105) Hex Flange - Stainless Steel	10-823567105	10-817430105
19	BRACKET	893703	828985
20	SCREW, (#10-16 x .380)	10-878607	10-817626
21	NUT, (M10)	11-40140
22	NUT, (.375-24) Comment: (HANDLE)	11-8M0204726
23	LEVER Comment: (HANDLE)	823792
24	WASHER Comment: (HANDLE)	12-29330
25	ROD (THREADED) Comment: (HANDLE)	821961
26	BRAKE PLATE Comment: (HANDLE)	821957
27	DISC Comment: (HANDLE)	8165621
28	PLATE Comment: (HANDLE)	8M0007471	823791 (HANDLE)
29	DISC Comment: (HANDLE)	8165621
30	SHOULDER SCREW, Hex Comment: (HANDLE)	10-768042

Swivel Bracket

Below is the parts list for Mercury 30 JET (3 CYL.) Swivel Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	ATTACHING KIT, Engine Steering Comment: (ELECTRIC NON HANDLE)	19608A14
2	SCREW, (.375-24 x 1.500) Comment: (ELECTRIC NON HANDLE)	10-823919
3	WASHER, (.390 x .546 x .12) Comment: (ELECTRIC NON HANDLE)	12-8M0109680
4	WASHER, (.390 x .625 x .062) Stainless Steel Comment: (ELECTRIC NON HANDLE)	12-37828
5	NUT, (.375-24) Stainless Steel Comment: (ELECTRIC NON HANDLE)	11-8M0204726
6	PUCK Comment: (ELECTRIC NON HANDLE)	822397
7	BUSHING	23-8217711
8	SWIVEL BRACKET	1401-850066T01	1401-850066A 1
9	BEARING	23-19606
10	FITTING, Grease Comment: (QTY. OF 3 REQUIRED ON HANDLE VERSIONS)	22-8M0169589
11	DECAL, Co-Pilot	37-8237011
12	NOT SOLD SEPARATE, Decal-Serail Overlaminate	NSS
13	BUSHING (LOWER)	23-821777
14	SEAL	26-8M0205512
15	SCREW, (M8 x 10) Stainless Steel Comment: (HANDLE)	10-4008910
15	SCREW, (M8 x 25) Stainless Steel Comment: (ELECTRIC)	10-40011149
16	SEAL Comment: (ELECTRIC)	8282451
1	ATTACHING KIT, Engine Steering Comment: (Non-Handle)	19608A14
2	SCREW, (.375-24 x 1.500) Comment: (Non-Handle)	10-823919
3	WASHER, (.390 x .546 x .12) Comment: (Non-Handle)	12-8M0109680
4	WASHER, (.390 x .625 x .062) Stainless Steel Comment: (Non-Handle)	12-37828
5	NUT, (.375-24) Stainless Steel Comment: (Non-Handle)	11-8M0204726
6	PUCK Comment: (Non-Handle)	822397
7	SWIVEL BRACKET ASSEMBLY	3410-827402T5
8	BUSHING (Upper)	23-8217711
9	FITTING, Grease Comment: (Quanty of 4 on Handle Version)	22-8M0169589
10	BUSHING (Lower)	23-821777
11	SEAL	26-8M0205512
12	NOT SOLD SEPARATE Comment: (Decal-Serial Overlaminate)	NSS
13	CABLE ASSEMBLY	88238A11
14	WASHER	12-19619
15	SCREW, (M8 x 10) Stainless Steel Comment: (Handle)	10-4008910
15	SCREW, (M8 x 25) Stainless Steel Comment: (Non-Handle)	10-40011149
16	SEAL Comment: (Non-Handle)	8282451
17	SEAL KIT Comment: (Non-Handle)	19624A1
18	O-RING, (.583 x .103) Comment: (NonHandle)	25-29619
19	SPACER Comment: (Non-Handle)	23-78861
20	WASHER	12-19619
21	TILT TUBE	8M0041938	8M0035070, 19614 1
22	NUT, (.875-14)	11-858869	11-30499
23	DECAL, Co-Pilot	37-8237011
24	PIN, Trilobe	17-821539	17-13794, 17-19603
25	BUSHING	23-823507
26	PIN, Pivot (Upper)	17-822480
27	SCREW, (#10-16 x .375)	10-878607	10-817626

Swivel Tube

Below is the parts list for Mercury 30 JET (3 CYL.) Swivel Tube:

Position No.	Part Name	OEM Number	Supersedes
1	SWIVEL TUBE HEAD, Black	821769T1
1	SWIVEL TUBE HEAD, Gray	821769T2
2	BRACKET Comment: (Non-Handle)	8M0184092
3	TAB WASHER Comment: (Non-Handle)	14-8M0009820	14-816669F 1 (Non-Handle)
4	SCREW, (M10 x 30) Comment: (Non-Handle)	10-4000377
5	NUT, (.375-24) Stainless Steel	11-8M0204726
6	LEVER	823792
7	WASHER	12-29330
8	ROD (Threaded)	821961
9	BRAKE PLATE	821957
10	DISC	8165621
11	PLATE	8M0007471	823791
12	DISC	8165621
13	SHOULDER SCREW, Hex	10-768042
14	BUMPER	8M0156878

Throttle Lever and Linkage

Below is the parts list for Mercury 30 JET (3 CYL.) Throttle Lever and Linkage:

Position No.	Part Name	OEM Number	Supersedes
1	LEVER, Throttle	42946T1
2	SCREW, Adjusting (M5 x 35)	10-817582	10-814775, 10-42977
3	NUT, (M5) Stainless Steel	11-400211
4	INSERT	42927
5	WASHER	12-35459
6	NUT, (M6) Stainless Steel	11-401386
7	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
8	NUT, (M6) Stainless Steel	11-400212
9	CAP	42942
10	BUSHING	23-812930A1
11	NOT SOLD SEPARATE Comment: (Insert)	NSS
12	SCREW, (M10 x 45)	10-4007180
13	BUSHING	23-8M0215006
14	SPRING	24-55162
15	WASHER	12-42980
16	LEVER, Spark Advance	19663T02
17	ROD	878172	42918
18	SWIVEL BASE	93254
19	SCREW, Adjusting (M6 x 55)	10-814776	10-42978
20	NUT, (M6) Stainless Steel	11-400212
21	CAP	42942
22	SWIVEL BALL	93421
23	STUD	16-8161949
24	SPRING Comment: (Electric)	24-817702
25	CAM ASSEMBLY, Throttle	828160A2
26	BUSHING	23-8M0215006
27	ROD, Throttle	878174	828159
28	WASHER, (.265 x .750 x .048) Stainless Steel	12-65567
29	NUT, (M6) Stainless Steel	11-401386
30	WASHER Comment: (Electric)	12-828494
31	BRACKET Comment: (Handle Versions)	8214943
32	SCREW, (M6 x 16) Comment: (Handle Versions)	10-4006731

Tiller Handle

Below is the parts list for Mercury 30 JET (3 CYL.) Tiller Handle:

Position No.	Part Name	OEM Number	Supersedes
1	COVER KIT	822148T06	822148A 6
2	PULLEY	822150
3	NOT SOLD SEPARATE, Case	NSS
4	SCREW, (#10-16 x .500)	10-878608	10-812832
5	CABLE ASSEMBLY, Throttle (30.50 Inches)	4324210
6	CABLE ASSEMBLY, Throttle (41.50 Inches)	4324211
7	SLEEVE, (12.00 Inches)	85-960099
8	SCREW, (M8 x 25 MM)	10-82526225
9	COVER	8M0072298	822407F 1
10	BUSHING	23-821477
11	ARM, Steering Handle	828813T1
-	DECAL, Lanyard, Black	37-8M0032728
12	RETAINER	822441
13	SCREW, (M5 x 16) Stainless Steel Comment: (MANUAL)	10-40011107
14	SCREW, (M6 x 25)	10-8M0204707
15	LOCK, Throttle	892995	821971
16	SPRING	24-96203
17	KNOB, Throttle	821972T	821972
18	TILLER TUBE	8M0138696
19	DECAL	37-8242004
20	HANDLE, Throttle	821465
21	GRIP	8M0221732
22	SWITCH, Stop	87-8M0104614	87-823609A14, 87-823609A13
23	SCREW, (M5 x 12) Comment: (MANUAL)	10-82239312
24	WASHER Comment: (MANUAL)	12-8M0214930
25	ALARM Comment: (MANUAL)	84-8M0088388	816492A 8 (MANUAL)
26	CLIP	823687
27	SWITCH, Stop	87-11083A31
28	RETAINER, Brass	8M0032846	12044 1
29	BRACKET, Tiller	821455A4
30	WAVE WASHER	13-826792	13-34678 1, 13-822144
31	BUSHING	23-821477
32	WASHER	12-827314
33	CONDUIT, (.620 Inside Diameter x 3.00 Feet Bulk)	32-828547633
34	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
35	NOT SOLD SEPARATE, Decal-Shift (F-N-R)	NSS
36	LANYARD ASSEMBLY	15920Q54
37	SCREW, (M8 x 35) Stainless Steel	10-40011151
38	HANDLE	830180A01	830180
39	BUSHING	23-830181
40	SHIFT ROD	8301821
41	TAB WASHER	14-8M0009820	14-816669F 1
42	SCREW, (M10 x 90)	10-82484890
1	COVER KIT	822148A7
2	PULLEY	822150
3	NOT SOLD SEPARATE Comment: (Case)	NSS
4	SCREW, (#10-16 x .500)	10-878608	10-812832
5	CABLE ASSEMBLY, Throttle (28.50 Inches)	4324212
6	CABLE ASSEMBLY, Throttle (30.00 Inches)	4324213
7	SLEEVE, (12.00 Inches)	85-960099
8	SCREW, (M8 x 25 MM)	10-82526225
9	COVER Comment: (Black)	8M0072298	822407F 1 (Black)
10	BUSHING	23-821477
11	ARM, Steering Handle Comment: (Black)	828813T1
-	DECAL, Lanyard, Black	37-8M0032728
12	RETAINER	822441
13	SCREW, (M5 x 16) Stainless Steel	10-40011107
14	SCREW, (M6 x 25)	10-8M0204707
15	LOCK, Throttle	892995	821971
16	SPRING	24-96203
17	KNOB, Throttle	821972T	821972
18	TILLER TUBE	8M0138696
19	DECAL Comment: (Turtle/Rabbit)	37-8242004
20	HANDLE, Throttle	821465
21	GRIP	8M0221732
22	SWITCH ASSEMBLY	87-8M0104614	87-823609A14, 87-823609A13
23	SCREW, (M10 x 110)	10-824848110	10-853473
24	TAB WASHER	14-8M0009820	14-816669F 1
25	CLIP	823687
26	SPACER	23-828569	23-8M0010932
27	BRACKET, Tiller Comment: (Black)	821455A4
28	WAVE WASHER	13-826792	13-34678 1, 13-822144
29	BUSHING	23-821477
30	WASHER	12-827314
31	SWITCH	87-11083A31
32	RETAINER, Brass	8M0032846	12044 1
33	LANYARD ASSEMBLY	15920Q54

Tools

Below is the parts list for Mercury 30 JET (3 CYL.) Tools:

Position No.	Part Name	OEM Number	Supersedes
1	FLUSHING ATTACHMENT	44357Q2
2	PUMP ASSEMBLY, Crankcase Oil	802889Q1
3	WRENCH, Oil Filter	91-802653Q02	91-802653Q 1
4	HOLDER TOOL, Flywheel	91-8M0161873
5	FLYWHEEL PULLER	91-83164M
6	TIMING LIGHT	91-99379
7	ADAPTOR TOOL, Direct Voltage	91-890451
8	TACH MULTI METER	91-854009A3
9	DIGITAL DIAGNOSTIC TESTER	91-823686A2
10	CARTRIDGE	91-8226086
11	HARNESS ASSEMBLY, Adaptor	84-822560A7
12	HARNESS ASSEMBLY, Adaptor	84-822560A10
13	GAUGE TOOL, Carburetor	91-36392
14	REMOVER TOOL, Valve Guide	91-809495001	91-809495A 1
15	INSTALLER TOOL, Valve Guide Bushing	91-809496A1
16	REAMER TOOL, Valve Guide	91-809497A1
17	COMPRESSOR TOOL, Valve Spring	91-809494A1
18	NOT SOLD SEPARATE, Valve Seat Cutter Kit Comment: (OBTAIN LOCALLY)	NSS
19	COMPRESSOR TOOL, Piston Ring	FT2997	FJ7081, FJ8785, FJ8786, FJ8787, FJ8788, FJ8789
20	STAND TOOL, Powerhead	91-827001A1
21	EXPANDER TOOL, Piston Ring	91-24697
22	SPANNER WRENCH	91-74951
23	DOWN PRESSURE KIT	91-822778A3
24	HEAT LAMP	91-63209
25	BEARING, Thrust	31-85560
26	REMOVER TOOL, Bearing	91-13779
-	PULLER KIT, Bearing	91-31229A7
27	NOT SOLD SEPARATE, Expanding rod Comment: (P/N-CG-41-11)	NSS
28	NOT SOLD SEPARATE, Collet Comment: (P/N-CG-41-14)	NSS
29	NUT, (.625-18)	11-24156
30	WASHER	12-34961
31	PLATE	91-29310
32	SHAFT	91-31229
33	WRENCH TOOL, Driveshaft Bearing	91-36571T
34	DRIVER ROD TOOL, Needle Bearings	91-37323
35	MANDREL	91-15755T
36	DRIVE HEAD TOOL	91-36569T
37	PULLER	91-27780
38	PULLER PLATE	91-37241
39	DRIVER HEAD TOOL	91-37312T
40	INSTALLER TOOL, Needle Bearing	91-817011T	91-817011
41	HOLDING TOOL, Driveshaft	91-83180M
42	INSTALLER TOOL, Oil Seal	91-825197T	91-825197
43	INSTALLER TOOL, Seal	91-817007T	91-817007
44	MANDREL	91-825198
45	PILOT	91-825199
46	HOOK TOOL, Spring	91-825200A1
47	INSTALLER TOOL, Bearing	91-826872
48	TESTER KIT	FT8950
49	LOCATION TOOL, Pinion	91-12349A05
50	INSTALLATION TOOL, Bearing	91-13945
51	DRIVER TOOL, Oil Seal	91-13949
52	RACE TOOL, Bearing	91-14308T02
53	INSTALLATION TOOL, Bearing	91-14309T02
54	WEAR SLEEVE INSTALLATION TOOL	91-14310T1
55	PRE LOAD TOOL, Bearing	91-14311A04
56	INDICATOR TOOL, Backlash	91-8M0053505	91-78473
57	MANDREL, Bearing Driver Cup	91-31106T
58	DRIVER, Oil Seal	91-31108T
59	PULLER ASSEMBLY, Slide Hammer	91-34569A1
60	PULLER JAW ASSEMBLY	91-46086A1
61	MANDREL	91-37350T
62	HOLDING TOOL, Driveshaft	91-56775T
63	DIAL INDICATOR TOOL	91-58222A1
64	PULLER TOOL	91-85716
65	ADAPTER KIT, Dial Indicator	91-83155
66	PULLER ASSEMBLY	91-83165T
67	INSTALLATION TOOL, Bearing	91-856875A1

Tools, Special

Below is the parts list for Mercury 30 JET (3 CYL.) Tools, Special:

Part Name	OEM Number	Supersedes
GREASE KIT	91-30500A2
GAUGE TOOL, Carburetor	91-36392
ADAPTOR TOOL, Direct Voltage Comment: (Electrical/Ignition)	91-890451
FLYWHEEL HOLDER TOOL, Teeth Type Comment: (Electrical/Ignition)	91-52344
PULLER ASSEMBLY Comment: (Electrical/Ignition)	91-849154T1
MULTI METER Comment: (Electrical/Ignition)	91-99750A1
SWITCH ASSEMBLY Comment: (Electrical/Ignition)	91-52024A1
SERVICE TACHOMETER Comment: (Electrical/Ignition)	91-59339
TESTER, Eight Chamber Comment: (Electrical/Ignition)	91-850439T1
GAP TOOL, Single Chamber Comment: (Electrical/Ignition)	91-63998A1
TESTER, Eight Chamber Comment: (Electrical/Ignition)	91-850439T1
TIMING LIGHT Comment: (Electrical/Ignition)	91-99379
HARNESS ASSEMBLY, TPI/CDM Test Comment: (Electrical/Ignition)	84-825207A1
NOT SOLD SEPARATE (Snap On - CG41-14) Comment: (Trim/Tilt System)	NSS
NOT SOLD SEPARATE (Snap On - CG41-11) Comment: (Trim/Tilt System)	NSS
DOWN PRESSURE KIT Comment: (Trim/Tilt System)	91-822778A3
MULTI METER Comment: (Trim/Tilt System)	91-99750A1
SPANNER WRENCH Comment: (Trim/Tilt System)	91-74951
HEAT LAMP Comment: (Trim/Tilt System)	91-63209
GAUGE TOOL Comment: (Powerhead)	91-29287
SLEEVE Comment: (Powerhead)	91-55919
PULLER ASSEMBLY Comment: (Powerhead)	91-849154T1
LIFTING EYE Comment: (Powerhead)	91-904551
INSTALLER KIT Comment: (Powerhead)	91-77109A3
REMOVAL TOOL, Piston Pin Lock Ring Comment: (Powerhead)	91-52952T1
INSTALLER KIT, Piston Pin Comment: (Powerhead)	91-74607A3
EXPANDER TOOL, Piston Ring Comment: (Powerhead)	91-24697
TORQUE WRENCH, (0-150 lb-in) Comment: (Powerhead)	91-66274
PULLER PLATE, Universal Comment: (Powerhead)	91-37241
PULLER ASSEMBLY, Slide Hammer Comment: (Gear Housing)	91-34569A1
BEARING, Thrust Comment: (Gear Housing)	31-85560
TORQUE WRENCH, (0-150 lb-in) Comment: (Gear Housing)	91-66274
INSTALLER TOOL, Water Pump Base Seal Comment: (Gear Housing)	91-817006
WEAR SLEEVE INSTALLATION TOOL Comment: (Gear Housing)	91-14310T1
INDICATOR TOOL, Backlash Comment: (Gear Housing)	91-8M0053505	91-78473 (Gear Housing)
INDICATOR TOOL, Backlash Comment: (Gear Housing)	91-196601
INSTALLER TOOL, Seal Comment: (Gear Housing)	91-817007T	91-817007 (Gear Housing)
PILOT Comment: (Gear Housing)	91-825199
INSTALLATION TOOL, Bearing Comment: (Gear Housing)	91-13945
INSTALLATION TOOL, Bearing Comment: (Gear Housing)	91-14309T02
PRE LOAD TOOL, Bearing Comment: (Gear Housing)	91-14311A04
PULLER ASSEMBLY Comment: (Gear Housing)	91-83165T
RACE TOOL, Bearing Comment: (Gear Housing)	91-14308T02
PULLER KIT, Bearing Comment: (Gear Housing)	91-31229A7
NUT, (.625-18) Comment: (Gear Housing)	11-24156
MANDREL Comment: (Gear Housing)	91-15755T
DRIVE HEAD TOOL Comment: (Gear Housing)	91-36569T
DRIVER HEAD TOOL Comment: (Gear Housing)	91-37312T
DRIVER ROD TOOL, Needle Bearings Comment: (Gear Housing)	91-37323
WRENCH TOOL, Driveshaft Bearing Comment: (Gear Housing)	91-36571T
MANDREL Comment: (Gear Housing)	91-37350T
PLATE Comment: (Gear Housing)	91-29310
WASHER Comment: (Gear Housing)	12-34961
RETAINING TOOL, Bearing Comment: (Gear Housing)	91-43506T
HOOK TOOL, Spring Comment: (Gear Housing)	91-825200A1
ADAPTER KIT, Dial Indicator Comment: (Gear Housing)	91-83155
DIAL INDICATOR TOOL Comment: (Gear Housing)	91-58222A1
REMOVER TOOL, Bearing Comment: (Gear Housing)	91-13779
DRIVER TOOL, Bearing Cup Comment: (Gear Housing)	91-817009T	91-817009, 91-31361 (Gear Housing)
HOLDING TOOL, Driveshaft Comment: (Gear Housing)	91-817070
HOLDING TOOL, Driveshaft Comment: (Gear Housing)	91-825196
INSTALLER TOOL, Bearing Comment: (Gear Housing)	91-817005
INSTALLER TOOL, Bearing Comment: (Gear Housing)	91-826872
DRIVER TOOL, Bearing Comment: (Gear Housing)	91-817058A1
INSTALLER TOOL, Needle Bearing Comment: (Gear Housing)	91-817011T	91-817011 (Gear Housing)
DRIVER TOOL, Oil Seal Comment: (Gear Housing)	91-13949
DRIVER, Oil Seal Comment: (Gear Housing)	91-31108T
INSTALLER TOOL, Oil Seal Comment: (Gear Housing)	91-825197T	91-825197 (Gear Housing)
MANDREL Comment: (Gear Housing)	91-825198
LOCATION TOOL, Pinion Gear Comment: (Gear Housing)	91-817008A2
LOCATION TOOL, Pinion Comment: (Gear Housing)	91-12349A05
PULLER Comment: (Gear Housing)	91-27780
PULLER BOLT TOOL, Bearing Carrier Comment: (Gear Housing)	91-85716
PULLER JAW ASSEMBLY Comment: (Gear Housing)	91-46086A1
PULLER PLATE, Universal Comment: (Gear Housing)	91-37241

Top Cowl

Below is the parts list for Mercury 30 JET (3 CYL.) Top Cowl:

Position No.	Part Name	OEM Number	Supersedes
1	TOP COWL ASSEMBLY Comment: (MANUAL - BLACK)	102-834785T17	102-834785T 5 (MANUAL - BLACK)
1	TOP COWL ASSEMBLY Comment: (MANUAL - SILVER)	102-834785T6
2	TOP COWL ASSEMBLY Comment: (ELECTRIC - BLACK)	102-834785T22	102-834785T 7 (ELECTRIC - BLACK)
2	TOP COWL ASSEMBLY Comment: (ELECTRIC - SILVER)	102-834785T8
3	NOT SOLD SEPARATE, Induction Insert	NSS
4	LATCH Comment: (BLACK)	826291F1
4	LATCH Comment: (SILVER)	826291F1
5	SCREW, (M4 x 14.5)	10-8231871
6	LOCKWASHER, Stainless Steel	8,13-26995
7	NUT, (M4)	11-8237515
8	SEAL	8M0153618
9	SOUND BLANKET KIT	834786A04	834786A 3
10	NOT SOLD SEPARATE, Sound Blanket-Top Comment: (ELECTRIC)	NSS
11	NOT SOLD SEPARATE, Sound Blanket-Top Comment: (MANUAL)	NSS
12	BRACKET ASSEMBLY, Latch Roller	893763	18173
13	SCREW, (M6 x 16)	10-4006731
14	BRACKET	8M0038412	822426 1
15	SCREW, (M4 x 14.5)	10-8231871
16	LOCKWASHER, Stainless Steel	8,13-26995
17	NUT, (M4)	11-8237515
18	ROPE AND HANDLE KIT, Manual Starting	47341A11
1	TOP COWL ASSEMBLY Comment: (Black)(Electric)	100-8M0107150
1	TOP COWL ASSEMBLY Comment: (Silver)(Electric)	4019-825239T14	4019-825239A14 (Silver)(Electric)
2	TOP COWL ASSEMBLY Comment: (Black)(Manual)	4019-825239T11	4019-825239A11 (Black)(Manual)
2	TOP COWL ASSEMBLY Comment: (Silver)(Manual)	4019-825239T12	4019-825239A12 (Silver)(Manual)
3	BRACKET, Cowl Support Comment: (Rear)	8M0041044	813549F 3 (Rear)
4	SPACER, Bracket	828433T	828433
5	SCREW	10-83208630
6	NUT	11-400632
7	BRACKET ASSEMBLY, Latch Roller	893763	18173
8	SCREW, (M6 x 16)	10-4006731
9	MOUNT	813546003	813546 2
10	ROPE AND HANDLE KIT, Manual Starting	47341A11
11	BRACKET, Cowl Support - Front Comment: (Front)	8M0041646	828468 (Front)
12	LATCH KEEPER	828503
13	SCREW	10-83208616
14	NUT	11-400632
15	DUCT, Air Inlet	8M0038217	892844, 828178
16	NOT SOLD SEPARATE Comment: (Induction Insert)	NSS
17	SCREW, (.250-20 x .875)	10-F2317
18	SEAL	8M0043404	831905
19	GAUGE KIT, Oil Level Comment: (Electric)	813504A1
20	GROMMET Comment: (Electric)	813505
21	RETAINER Comment: (Electric)	113171
22	NUT Comment: (Electric)	11-65110
23	SOUND BLANKET KIT (All)	828180A02	828180A 1
24	NOT SOLD SEPARATE Comment: (Storboard and Rear)	NSS
25	NOT SOLD SEPARATE Comment: (Port and Rear)	NSS
26	NOT SOLD SEPARATE Comment: (Tape)	NSS
27	DECAL, F-N-R Shift	37-82409316

Transom Bracket

Below is the parts list for Mercury 30 JET (3 CYL.) Transom Bracket:

Position No.	Part Name	OEM Number	Supersedes
1	BRACKET ASSEMBLY, Transom Comment: (PORT)	3418-822866T04	3418-822866A 1 (PORT)
1	CLAMP BRACKET ASSEMBLY Comment: (PORT - MANUAL LONG BIGFOOT)	3420-8M0084195	3420-822868A 1 (PORT - MANUAL LONG BIGFOOT)
2	FITTING, Grease	22-8M0169588
3	PIN, Groove	17-99604
4	BRACKET, Transom Comment: (STARBOARD)	3418-822865T05	3418-822865F 2 (STARBOARD)
4	CLAMP BRACKET Comment: (PORT - MANUAL LONG BIGFOOT)	3419-822867F1
5	LEVER ASSEMBLY, Tilt Lock	893704T01	19618A 2
6	SPRING	24-99622
7	NYLINER	23-65830
8	SPRING	24-812708
9	KNOB	812709	812709T, 812709F 1
10	PIN, Groove	17-99615
11	WASHER	12-19619
12	BRACKET, Anchor	18486F5
13	ANODE KIT	97-818298Q1
14	SCREW, (M6 x 25)	10-8M0204707
15	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
16	SCREW, (M8 x 30) Comment: (30 MM)	10-4000354
16	SCREW, (M8 x 35) Comment: (35 MM)	10-4000355
17	LOCKWASHER, (M8)	13-400257
18	NUT, (M8) Stainless Steel	11-401388
19	PIN ASSEMBLY, Tilt Lock Comment: (NON POWER TRIM)	17-8M0026068	17-49930A 1 (NON POWER TRIM)
20	SPRING Comment: (NON POWER TRIM)	24-821461
21	TILT TUBE	8M0041938	8M0035070, 19614 1
22	NUT, (7/8-14)	11-858869	11-30499
23	SEAL KIT Comment: (NON-HANDLE)	19624A1
24	O-RING, (.583 x .103) Comment: (NON-HANDLE)	25-29619
25	SPACER Comment: (NON-HANDLE)	23-78861
26	CLIP Comment: (POWER TRIM)	54-22740
27	C WASHER Comment: (POWER TRIM)	8M0084613	69205 (POWER TRIM)
28	SCREW, (#10-16 x .600) Comment: (POWER TRIM)	10-878609	10-812832 1 (POWER TRIM)
29	SCREW, (.500-20 x 4.00)	10-814259
30	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel	12-8M0204648
31	NUT, (.500-20)	11-82671117
32	LINK Comment: (NON POWER TRIM)	8M0084737
33	LEVER ASSEMBLY, Tilt Comment: (NON POWER TRIM)	19615A05
34	BUSHING Comment: (NON POWER TRIM)	23-812707	23-71984, 23-F286818, 23-F286828, F480818 (NON POWER TRIM)
35	WASHER, (.520 x .850 x .060) Nylon - Black Comment: (NON POWER TRIM)	12-8M0042643	12-19605 (NON POWER TRIM)
36	WAVE WASHER Comment: (NON POWER TRIM)	13-99611
37	TILT KNOB Comment: (NON POWER TRIM)	8M0007469	19621 (NON POWER TRIM)
38	SCREW, (.375-16 x .62) Comment: (NON POWER TRIM)	10-19611
39	SCREW, (M10 x 40) Stainless Steel	10-4009040
40	WASHER	12-4002319
41	NUT, (M10)	11-40140
42	DECAL, Tilt Lock	37-830253	37-814743 3, 37-826546
43	THUMB SCREW ASSEMBLY Comment: (MANUAL BIGFOOT)	10-818883A1
44	WASHER Comment: (MANUAL BIGFOOT)	12-818884
45	SHOULDER SCREW, Hex Comment: (MANUAL BIGFOOT)	10-768042
46	NOT SOLD SEPARATE, Handle Comment: (MANUAL BIGFOOT)	NSS
47	NOT SOLD SEPARATE, Rivet Comment: (MANUAL BIGFOOT)	NSS
48	NOT SOLD SEPARATE, Decal-Warning Comment: (MANUAL BIGFOOT)	NSS

Trim Switch Kit

Below is the parts list for Mercury 30 JET (3 CYL.) Trim Switch Kit:

Position No.	Part Name	OEM Number	Supersedes
-	SWITCH KIT, Trim (10.00 Feet)	87-18286A18
1	RETAINER	18861
2	ADAPTOR	814820	812978
3	NOT SOLD SEPARATE, Switch	NSS
4	FUSE, 20 Ampere	88-8M0207796
5	CABLE ASSEMBLY	84-95084A2
6	CABLE ASSEMBLY, (6.00 Inches)	84-11149A2
7	SCREW, (#10-32 x 2.25)	10-19209
7	SCREW, (#10-16 x 2.25)	10-813523
-	SWITCH KIT, Trim (10.00 Feet)	87-18286A18
1	RETAINER	18861
2	ADAPTOR	814820	812978
3	NOT SOLD SEPARATE Comment: (Switch)	NSS
4	FUSE, 20 Ampere	88-8M0207796
5	CABLE ASSEMBLY	84-95084A2
6	CABLE ASSEMBLY, (6.00 Inches)	84-11149A2
7	SCREW, (#10-32 x 2.25)	10-19209
7	SCREW, (#10-16 x 2.25)	10-813523

Download this page as PDF: Click here

For Mercury Owners:

To assist you in maintaining and repairing your marine engines, we hope the following resources may be of use:

Mercury / Mercruiser / Mariner Parts from JLM Marine

About JLM Marine

Founded in 2002, JLM Marine has established itself as a dedicated manufacturer of high-quality marine parts, based in China. Our commitment to excellence in manufacturing has earned us the trust of top marine brands globally.

As a direct supplier, we bypass intermediaries, which allows us to offer competitive prices without compromising on quality. This approach not only supports cost-efficiency but also ensures that our customers receive the best value directly from the source.

We are excited to expand our reach through retail channels, bringing our expertise and commitment to quality directly to boat owners and enthusiasts worldwide.