Mercury 225 (3.0L EFI) (0T409000 THRU 0T800999) Outboard Motor Parts Diagram & Catalog – Free PDF Download

by JLM Marine 30 Apr 2025 0 Comments

Mercury 225 (3.0L EFI) Outboard Motor Parts Diagram & Catalog – Free PDF Download

ACCESSORIES

Below is the parts list for Mercury 225 (3.0L EFI) ACCESSORIES:

Part Name	OEM Number	Supersedes
FLUSH COUPLING	22-852400	56-820386A55
DECK FILL KIT, Oil	15969A3
DIODE ASSEMBLY (DUAL ENGINE)	812497A2
FLUSHING ATTACHMENT	44357Q2
HOSE ASSEMBLY, Fuel (9 FT.)	32-858610A31	32-858610A10, 32-16789A18
HOSE ASSEMBLY, Fuel (12 Feet) Comment: (NO FITTINGS)	32-877683Q12	32-858623Q12, 32-858623A12, 32-822379A12, 32-819380A12, FA599752, FS409752, 32-819380A 3, F216752, FA409752, F289752, FA178752, FA216752, FA284752, FA289752, FS409952 (NO FITTINGS)
SWITCH/LANYARD KIT	87-19674Q2
MERCATHODE KIT	88334A2
HOSE EXTENSION KIT	41729A3
NOT SOLD SEPARATE, Rigging Hose Kit Comment: (SEE PARTS BULLETIN 99-4)	NSS
RESERVOIR KIT, Oil	15943A1
TRIM REDUCER KIT	858915A1

ATTENUATOR/FLYWHEEL COVER

Below is the parts list for Mercury 225 (3.0L EFI) ATTENUATOR/FLYWHEEL COVER:

Position No.	Part Name	OEM Number	Supersedes
1	COVER	892854T01	880009T02, 880009T 1
2	GROMMET, (.88 Inside Diameter)	25-13467
3	GROMMET	25-8M0153609
4	ATTENUATOR	881909T3
5	BUSHING	23-856954
6	GROMMET	25-8M0190980
7	SEAL	882767
8	GROMMET	25-20116
9	CLIP	54-23567
10	WASHER, (.265 x .750 x .048) Stainless Steel	12-65567
11	SCREW, (M6 x 25)	10-82130025
12	DECAL, Caution-Start in Gear	37-881865	37-825064
13	SCREW, (#10-16 x .750)	10-69570

BOTTOM COWL

Below is the parts list for Mercury 225 (3.0L EFI) BOTTOM COWL:

Position No.	Part Name	OEM Number	Supersedes
1	BOTTOM COWL, Port	113-850302A1
2	PLUG	854367001	854367
3	BOTTOM COWL, Starboard	113-850301A1
4	SEAL, (44.00 Inches)	8M0109218
5	SCREW, (M6 x 40)	10-82130040
6	SCREW, (M6 x 75)	10-824868
7	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
8	FRONT HANDLE	8M0053903	850684F 1
9	BUSHING	23-335891
10	O-RING, (.614 x .070)	25-48462
11	PAWL	8219423
12	WASHER, (.281 x .734 x .063)	12-69057
13	NUT, (M6) Stainless Steel	11-401366
14	SCREW, (#10-16 x .625)	10-8214281
15	CLIP	54-822873
16	SWITCH, Trim	87-8M0235191
17	RIGGING KIT (UPPER)	8M8027677	54-859359A 2
18	NOT SOLD SEPARATE, Clamp (LOWER)	NSS
19	SCREW, (M6 x 12)	10-82130012
20	NOT SOLD SEPARATE, Strap	NSS
21	FOAM	859343
22	TIE STRAP, (11.750 Inches)	54-850181
23	HANDLE, Cowl	852361T1
24	WAVE WASHER	13-29402

COIL PLATE

Below is the parts list for Mercury 225 (3.0L EFI) COIL PLATE:

Position No.	Part Name	OEM Number	Supersedes
1	PLATE, Coil Mounting	850295T2
2	COIL KIT	300-8M0077471	300-879984T01, 339-879984A 1, 339-879984T00
3	SCREW, (M6 x 30)	10-82129130
4	CABLE SET	84-881908T	84-821945T74, 84-821945T65
5	CLIP	54-828991T	54-828991
6	SPARK PLUG	33-941
7	HARNESS ASSEMBLY, Coil	84-882757T1
-	HARNESS ASSEMBLY, 5 Pin	879346A51	84-854839T02
8	CABLE ASSEMBLY, Braided	84-858414A1
9	SCREW, (M6 x 10)	10-82129110
10	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
11	GROMMET	25-833155
12	WASHER	12-4002318
13	BUSHING	23-8502341
14	SCREW, (M8 x 35)	10-81893435
15	SENSOR KIT, (0-50 PSI)	71-8M0157742
16	FITTING	22-8M0207782
17	CLIP, (.865)	54-883066
18	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
19	TUBING, (44.00 Inches Bulk) (Cut to 18 Inches)	32-85978571
20	WASHER	12-36001

CRANKSHAFT, PISTONS AND CONNECTING RODS

Below is the parts list for Mercury 225 (3.0L EFI) CRANKSHAFT, PISTONS AND CONNECTING RODS:

Position No.	Part Name	OEM Number	Supersedes
1	CRANKSHAFT ASSEMBLY	482-9784A11
2	NOT SOLD SEPARATE, Wear Sleeve	NSS
3	BEARING, Ball (LOWER)	30-67923T
4	RING	53-67446
5	RING	39-843198T01	39-843198001, 39-816106
6	KEY, Woodruff	28-91800
7	O-RING, (.859 x .139)	25-35126
8	RACE ASSEMBLY	31-88270A02
9	NOT SOLD SEPARATE, Needle Roller Bearing	NSS
10	PISTON Comment: (STBD-STANDARD)	700-858295T14	700-858295T 1 (STBD-STANDARD)
10	PISTON Comment: (PORT-STANDARD)	700-858294T14	700-858294T 1 (PORT-STANDARD)
10	PISTON ASSEMBLY Comment: (STARBOARD - .015 O/S)	700-878572A2
10	PISTON ASSEMBLY Comment: (PORT - .015 O/S)	700-878571A2
10	PISTON ASSEMBLY Comment: (STARBOARD - .030 O/S)	700-878574A2
10	PISTON ASSEMBLY Comment: (PORT - .030 O/S)	700-878573A2
11	RING	40-841202
12	RING SET, Piston Comment: (STANDARD)	39-858772A12
12	RING SET, Piston Comment: (.015 O/S)	39-875252A12	39-856939A12, 39-826293A12 (.015 O/S)
12	RING SET, Piston Comment: (.030 O/S)	39-875257A12	39-826297A12, 39-856940A12 (.030 O/S)
13	NOT SOLD SEPARATE, Piston Ring (LOWER)	NSS
14	CONNECTING ROD ASSEMBLY	600-8M0125869
15	SCREW, (.375-24 x 1.250)	10-94320
16	BEARING/CAGE KIT	31-844338A01	31-43012A04
17	NOT SOLD SEPARATE, Needle Roller Bearing	NSS
18	THRUST WASHER	12-88263
19	NEEDLE, Roller Bearing	29-8M0204715
20	BEARING ASSEMBLY (UPPER)	31-816773A2
21	SEAL	26-859093	26-815449
22	O-RING, (1.989 x .070)	25-823683	25-64067
-	GASKET SET, Powerhead	27-832934A00
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T598999 & Below	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T598999 & Below	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T599000 & Up	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T598999 & Below	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T599000 & Up	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (200)	891823A07	891823A04, 891823B04 (200)

CYLINDER BLOCK AND END CAP

Below is the parts list for Mercury 225 (3.0L EFI) CYLINDER BLOCK AND END CAP:

Position No.	Part Name	OEM Number	Supersedes
1	CYLINDER BLOCK Comment: (225) SN# 0T598999 & Below	885-9811A82
1	CYLINDER BLOCK ASSEMBLY Comment: (225) SN# 0T599000 & Up	885-899162A06	885-9811T92 (225) SN# 0T599000 & Up
1	CYLINDER BLOCK Comment: (3L Work) SN# 0T598999 & Below	885-9811A81
1	CYLINDER BLOCK Comment: (200/3L Work) SN# 0T599000 & Up	885-899162A05	885-9811T91 (200/3L Work) SN# 0T599000 & Up
1	CYLINDER BLOCK Comment: (250) SN# 0T598999 & Below	885-899162A07	885-9811T93 (250) SN# 0T598999 & Below
1	CYLINDER BLOCK Comment: (250) SN# 0T599000 & Up	885-899162A07	885-9811T93 (250) SN# 0T599000 & Up
2	SCREW, (M8 x 40)	10-81893440
3	BRACKET	8M0111325
4	STUD, (M10 x 1.5 x 64)	16-903509
5	STUD, (M10 x 1.5 x 155)	16-8154431
6	DEFLECTOR	8248577
7	CHECK VALVE	21-8781051
8	PIN	17-8M0036405	17-67296
9	PIN, Dowel - Without Hole (.375 x .625)	17-43044
10	PLUG	19-850309001	19-850309
11	SCREW, (M8 x 35)	10-81893435
12	SCREW, (M10 x 80)	10-82446180
13	FITTING, Elbow 45 Degree (1.25)	22-782792
14	SENSOR ASSEMBLY, Temperature	13536A13
15	PIN	17-8405101
16	RETAINER	8588641
17	WASHER, (.406 x .750 x .105) Stainless Steel	12-8M0214963
18	NUT, (M10) Stainless Steel	11-4013610
19	SENSOR	8M0082988	8M0030022, 828358 2
20	SCREW, (M5 x 16) Stainless Steel	10-40011107
21	END CAP ASSEMBLY	1171-9787A4
22	O-RING, (3.237 x .103)	25-62700
23	SEAL	26-8308981
24	SCREW, (M6 x 20)	10-82130020
25	PLATE ASSEMBLY	857186T02	857186A 1
26	MOUNT	23-855729
27	SCREW, (M10 x 45)	10-82130145
28	SCREW, (M6 x 12)	10-82130012
29	GROMMET	25-19565002
30	WASHER	12-855725
31	RETAINER	137151
32	J CLIP	54-858951
33	SCREW, (M6 x 12)	10-82130012
34	SEAL	818574
35	CYLINDER HEAD Comment: (225/250) SN# 0T598999 & Below	812851A27	812851A22, 812851A19 (225/250) SN# 0T598999 & Below
35	CYLINDER HEAD Comment: (200/225/250) SN# 0T599000 & Up	812851A27	812851A22, 812851A19 (200/225/250) SN# 0T599000 & Up
35	CYLINDER HEAD Comment: (3L Work) SN# 0T598999 & Below	812851A26	812851A21, 812851A18 (3L Work) SN# 0T598999 & Below
35	CYLINDER HEAD Comment: (3L Work) SN# 0T599000 & Up	812851A26	812851A21, 812851A18 (3L Work) SN# 0T599000 & Up
36	SEAL Comment: SN# 0T599000 & Up	884391
36	SEAL Comment: SN# 0T598999 & Below	878453
37	THERMOSTAT, 54Â°C (130Â°F) Comment: SN# 0T599000 & Up	8M0057307	885599004, 885599003, 885599 1 SN# 0T599000 & Up
38	GASKET	27-8503181
39	COVER, Thermostat Comment: SN# 0T598999 & Below	8503173
39	COVER, Thermostat Comment: SN# 0T599000 & Up	8M0039357	887926 SN# 0T599000 & Up
40	SCREW, (M6 x 25)	10-82130025
41	SCREW, (M8 x 50)	10-8M0045380	10-891570050, 10-859096, 10-824460 50, 10-891570
42	SENSOR ASSEMBLY, Temperature	8M0214984
43	O-RING, (.301 x .070)	25-627021
44	SCREW, (M8 x 14)	10-81893414
45	PLUG, Pipe (.125-27) Brass	22-328022
46	CLAMP	8266241
47	SCREW, (M6 x 12)	10-82130012
48	LEVER, TPI	8583561
49	SCREW, (M6 x 25)	10-82130025
50	BUSHING	23-856954
51	GROMMET	25-8M0190980
52	WASHER, (.265 x .750 x .048) Stainless Steel	12-65567
53	SCREW, (M5 x 45) Stainless Steel	10-40011113
54	INDICATOR, Throttle Position	8M6005165
55	LINK	8M0084743
56	CLIP	54-858932
57	COVER	8582261
58	BRACKET	8544862
59	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
60	FITTING	22-8533394
61	HOSE (STARBOARD)	32-8404461
62	HOSE (PORT)	32-8404462
63	SCREW, (M8 x 20)	10-81893420
64	CLAMP	54-858902
65	SENSOR ASSEMBLY, Knock Comment: (200/3.0L WORK)	8M6003194	878187 (200/3.0L WORK)
66	STUD Comment: (200/3.0L WORK)	16-882781
67	NUT, (M10) Brass/Nickel Plated Comment: (200/3.0L WORK)	11-826292
68	No Longer Available, Thermostat (120 Degrees) Comment: (Refer to Service Bulletin 2002-08) SN# 0T598999 & Below	NLA
69	SEAL Comment: SN# 0T598999 & Below	26-854639001	26-854639 SN# 0T598999 & Below
-	GASKET SET, Powerhead	27-832934A00
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T598999 & Below	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY, Mechanical Oil Pump Comment: (225) SN# 0T599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY, Electric Oil Pump Comment: (225) SN# OT599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# OT599000 & Up
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T598999 & Below	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T599000 & Up	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T598999 & Below	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T599000 & Up	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (200)	891823A07	891823A04, 891823B04 (200)

DRIVESHAFT HOUSING & EXHAUST TUBE

Below is the parts list for Mercury 225 (3.0L EFI) DRIVESHAFT HOUSING & EXHAUST TUBE:

Position No.	Part Name	OEM Number	Supersedes
1	HOUSING ASSEMBLY, Driveshaft Comment: (LONG)	3518-832937A06	3518-832937A05, 3518-832937A 3, 3518-832937A 4 (LONG)
1	HOUSING ASSEMBLY, Driveshaft Comment: (X/XX-LONG)	3519-832938A06	3519-832938A 5 (X/XX-LONG)
2	STUD, (M12 x 52) Comment: (LONG/X-LONG)	16-8M0008031	16-856983, 16-822257 (LONG/X-LONG)
3	SCREW, (M12 x 35 MM) Comment: (LONG/X-LONG)	10-8M0102995	10-8M0071178, 10-885528 35 (LONG/X-LONG)
4	GROMMET	25-8331231
5	WASHER, (.500 x .810 x .090) Stainless Steel	12-856982
6	NUT, (M12 x 1.75)	11-896895	11-857008
7	PLUG	19-64649
8	SCREW, (M14 x 178)	10-898834	10-815431002, 10-815431
9	CABLE ASSEMBLY, Ground	88238A10
10	WASHER, (.562 x 2.00 x .125)	12-815432
11	WASHER, (1.25 x 2.00 x .19)	12-8154331
12	MOUNT	8137711
13	WASHER	12-825190
14	NUT	11-896602	11-815434, 11-815434002
15	CLAMP	8186442
16	SCREW, (M8 x 35)	10-81893435
17	LOCKWASHER, Internal Tooth	13-72521
18	COVER, Black	8M0001136	818645F 1
19	SCREW, (#10-16 x .440)	10-69079
20	SEAL	8329321
21	TUBE ASSEMBLY, Exhaust	833116A4
22	NOT SOLD SEPARATE, Strainer	NSS
23	SCREW, (M8 x 35)	10-81893435
24	TUBE, Water Comment: (LONG)	32-8M0042785	32-832941 7 (LONG)
24	TUBE, Water Comment: (X-LONG)	32-8M0042786	32-832941 8 (X-LONG)
24	TUBE, Water Comment: (XX-LONG)	32-8M0042787	32-832941 9 (XX-LONG)
25	SEAL	832940001	832940
26	CLAMP	8329391
27	SCREW, (.250-20 x .500) Stainless Steel	10-41508
28	SPACER Comment: (XX-LONG)	8M0105088	8M0071622, 880647T04, 823979T 1, 880647T02, 880647T (XX-LONG)
29	PIN, Dowel - Without Hole (.375 x .625) Comment: (XX-LONG)	17-43044
30	STUD, (M12 x 179) Comment: (XX-LONG)	16-8M0008047	16-857009, 16-824117 (XX-LONG)
31	SCREW, (M12 x 160) Comment: (XX-LONG)	10-857137
32	SCREW, (M8 x 35)	10-81893435

Dual Engine Tie Bar Kit

Below is the parts list for Mercury 225 (3.0L EFI) Dual Engine Tie Bar Kit:

Position No.	Part Name	OEM Number	Supersedes
-	EXTENSION KIT, Dual Engine	92876A9
1	TUBE ASSEMBLY	71565A2
2	O-RING, (.614 x .070)	25-48462
3	MOUNT	41055
4	TAB WASHER	14-42100
5	NUT, (.875-14)	11-8M0041651	11-37984
6	TAB WASHER	88404
7	SCREW, (.250-28 x 1.250)	10-38601
8	BRACKET	17729A1
9	SCREW, (.312-24 x 1.250)	10-62055
10	TAB WASHER	17728
11	SCREW, (.375-24 x 1.38)	10-140001
12	NUT, (.375-24) Stainless Steel	11-8M0204726
13	STEERING EYE	8M0026167	8M0005848, 97933 1
14	SLEEVE, (1.625)	23-23651
15	TUBING, (4.00 Inches)	97931
16	COUPLER, (15.00 Inches)	8M0026098	814951 3
17	NUT, (.562-18)	11-42099
18	COUPLING	22-821169
19	WASHER, (.406 x .734 x .063) Stainless Steel Comment: (.734 Outside Diameter)	12-34931
19	WASHER, (.390 x .625 x .062) Stainless Steel Comment: (.625 Outside Diameter)	12-37828
20	SCREW, (.375-24 x 1.5)	10-94319

EXHAUST PLATE

Below is the parts list for Mercury 225 (3.0L EFI) EXHAUST PLATE:

Position No.	Part Name	OEM Number	Supersedes
1	PLATE ASSEMBLY, Exhaust Comment: SN# 0T598999 & Below	832935A17	832935A16, 832935A15, 832935A14 SN# 0T598999 & Below
1	PLATE ASSEMBLY, Exhaust Comment: SN# 0T599000 & Up	832935A17	832935A16, 832935A15, 832935A14 SN# 0T599000 & Up
2	GASKET	27-8329335
3	GASKET (LOWER)	27-8329344
4	SEAL	8M0043157	823805 1
5	FITTING, Check Valve	22-8320761
6	PLUG, Pipe (.375-18) Brass	22-8M0180565
7	CHECK VALVE ASSEMBLY, Drain	21-817519A1
8	PIN, Dowel - Without Hole (.375 x .625)	17-43044
9	GROMMET Comment: SN# 0T599000 & Up	25-822002
10	PLUG Comment: SN# 0T599000 & Up	19-48323
11	COVER ASSEMBLY	65663A2
12	SCREW, (M8 x 35)	10-81893435
13	CARRIER	814190
14	GROMMET	25-814191
15	POPPET	814189
16	SPRING, (Black)	24-64878
17	PLATE ASSEMBLY	65664A1
18	GASKET	27-88907003
19	DIAPHRAGM	648771
20	WASHER	12-76451
21	SCREW, (#10-16 x .750)	10-69570
22	SCREW, (M8 x 35)	10-81893435
23	BOOT, Idle Exhaust	850306A04	850306 1
24	CLAMP, (28.6)	54-850896
25	FITTING, Tell-Tale	22-8M0077650	821904
26	PLUG	19-821908
27	WASHER	12-821915
28	FITTING	22-8596001
29	CHECK VALVE	8219631
30	O-RING, (.299 x .103)	25-30641
31	NUT, (M6) Stainless Steel	11-401386
32	SHIFT LINK	883142A03	883142A 2
33	SLIDE	8539683
34	NUT, (M6) Stainless Steel	11-401386
35	BUSHING	23-42994
36	SHIFT SHAFT, Upper Comment: (LONG)	8M0036408	896669001, 824070 1 (LONG)
36	SHIFT SHAFT, Upper Comment: (X-LONG)	8M0187153
36	SHIFT SHAFT, Upper Comment: (XX-LONG)	8240703
37	BUSHING	23-48237
38	COUPLING	43585
39	FLUSH HOSE KIT (INLET)	32-859626A1
40	GROMMET	25-12602002
41	WASHER	12-35459
42	HOSE, (57.00 Inches Bulk) (Cut to 3 Inches)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
43	FITTING	22-8M0214961
-	GASKET SET, Powerhead	27-832934A00
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T598999 & Below	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T598999 & Below	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T599000 & Up	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T598999 & Below	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T599000 & Up	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (200)	891823A07	891823A04, 891823B04 (200)

FLYWHEEL/ALTERNATOR

Below is the parts list for Mercury 225 (3.0L EFI) FLYWHEEL/ALTERNATOR:

Position No.	Part Name	OEM Number	Supersedes
1	ALTERNATOR Comment: SN# 0T598999 & Below	8M6013461
1	ALTERNATOR Comment: SN# 0T599000 & Up	8M6013461
2	SPRING	24-8523742
3	ARM TENSIONER ASSEMBLY Comment: SN# 0T599000 & Up	856815T2
4	WASHER Comment: SN# 0T599000 & Up	12-4002320
5	BUSHING Comment: SN# 0T599000 & Up	23-8568941
6	STUD, (M10 x 85) Comment: SN# 0T599000 & Up	16-8M0034457	16-856900 SN# 0T599000 & Up
7	NUT, (M10) Brass/Nickel Plated Comment: SN# 0T599000 & Up	11-826292
8	PULLEY ASSEMBLY	8M6005030
9	SCREW, (M10 x 35) Hex Flange - Stainless Steel	10-4010835
10	BELT	57-828507Q11	57-828507 11
11	FLYWHEEL Comment: (225) SN# 0T467442 & Up	283-859619T1
11	FLYWHEEL Comment: (250) SN# 0T467335 & Up	283-859619T1
11	FLYWHEEL Comment: (225) SN# 0T467441 & Below	283-859619T3
11	FLYWHEEL Comment: (250) SN# 0T467334 & Below	283-859619T3
12	NUT, (M16)	11-42979
13	WASHER, (.641 x 1.250 x .190)	12-33001
14	PLUG, Yellow	19-45907
15	NUT, (M6) Stainless Steel	11-401386
16	CABLE ASSEMBLY Comment: (7-1/4)	84-856583A4
16	CABLE ASSEMBLY Comment: (6-1/4)	84-856583A5
17	WASHER	12-4002319
18	SCREW, (M10 x 50)	10-82130150
19	SCREW, (M6 x 12)	10-82130012
20	BELT TENSIONER Comment: SN# 0T598999 & Below	850291T3
21	BUSHING Comment: SN# 0T598999 & Below	23-42139
22	BUSHING Comment: SN# 0T598999 & Below	23-8525622
23	SCREW, (M10 x 45) Comment: SN# 0T598999 & Below	10-4007180

FUEL MANAGEMENT

Below is the parts list for Mercury 225 (3.0L EFI) FUEL MANAGEMENT:

Position No.	Part Name	OEM Number	Supersedes
-	MANAGEMENT ASSEMBLY, Fuel	880004T05	880004T 2
1	ADAPTOR PLATE	883951T1
2	GASKET	27-804680
3	REED BLOCK	828623T4
4	SCREW, (M6)	10-8555252
5	BUSHING	23-855364
6	GROMMET	25-855362001	25-855362
7	SCREW, (M8 x 35)	10-81893435
8	WASHER, (.344 x 1.00 x .063) Stainless Steel	12-817274	12-817274 1
9	SCREW, (M8 x 30)	10-81893430
10	PLENUM KIT, Air	883950T1
11	GASKET	27-804679004	27-804679 3
12	SCREW, (M6 x 16)	10-1993716
13	BRACKET, MAP Sensor	884522	804873, 841095
14	SENSOR, MAP	854445
15	SENSOR ASSEMBLY, Temperature	8M0214984
16	O-RING, (.301 x .070)	25-627021
17	THROTTLE BODY KIT	883949T1
18	SCREW, (M6 x 40)	10-82130040
19	O-RING	25-855426
20	LEVER ASSEMBLY, Throttle	8588511
21	ROLLER	677483
22	RING, Retaining	53-8237951
23	SCREW, Special	10-889354
24	WASHER, Cupped	12-881991
25	WASHER, Spool	12-881992
26	LOCKWASHER, External	10,13-69432
27	CAM ASSEMBLY	858353A08	858353A 3
28	BALL, Threaded	8235694
29	BUSHING	23-8M0215006
30	BUSHING	23-8807371
31	SCREW, (M8 x 55) Stainless Steel	10-40011155
32	FITTING	22-993211
33	PUMP ASSEMBLY, Oil	8M0185615
34	BRACKET	883926
35	SCREW, (M4 x 16)	10-883942
36	SCREW, (M6 x 25)	10-82130025
37	WASHER	12-8M0214930
38	GROMMET	25-8M0190980
39	BUSHING	23-822003
40	FUEL RAIL	883952T1
41	RETAINER	8833821
42	SCREW, (#8-32 x .380)	10-840118
43	INJECTOR, Fuel	840481T01	840481001, 840481, 883381
44	NOT SOLD SEPARATE, O-Ring	NSS
45	TUBE	8832151
46	O-RING	25-883355
47	FITTING	22-883940
48	SCREW, (#10-24 x .375)	10-883376
49	RETAINER	883382
50	O-RING, (.239 x .070)	25-20385
51	HARNESS ASSEMBLY, Fuel Rail	84-880745T1
52	WASHER, (.330 x .750 x .060) Stainless Steel	12-56720
53	J CLIP	54-8M0024808
54	SCREW, (M6 x 40)	10-82130040
-	GASKET SET, Powerhead	27-832934A00
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T598999 & Below	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T598999 & Below	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T599000 & Up	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T598999 & Below	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T599000 & Up	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (200)	891823A07	891823A04, 891823B04 (200)

FUEL PUMP

Below is the parts list for Mercury 225 (3.0L EFI) FUEL PUMP:

Position No.	Part Name	OEM Number	Supersedes
-	PUMP KIT, Fuel	14360A78
1	NOT SOLD SEPARATE, Fuel Pump	NSS
-	DIAPHRAGM KIT	21-857005A1
2	NOT SOLD SEPARATE, Disc Check Valve	NSS
3	NOT SOLD SEPARATE, Diaphragm	NSS
4	NOT SOLD SEPARATE, Retainer	NSS
5	NOT SOLD SEPARATE, Spring	NSS
6	NOT SOLD SEPARATE, Cap	NSS
7	NOT SOLD SEPARATE, Spring	NSS
8	NOT SOLD SEPARATE, Cap	NSS
9	NOT SOLD SEPARATE, Diahpragm	NSS
10	NOT SOLD SEPARATE, Gasket-Boost	NSS
11	NOT SOLD SEPARATE, Gasket-Pulse	NSS
12	GASKET	27-8M0204705
13	PLATE	987752
14	FITTING, Straight (.125-27)	22-16604
15	SCREW, (M5 x 40)	10-82104540
16	SCREW, (M6 x 50)	10-82130050
17	BASE	144303
18	ELBOW	22-856842
19	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
20	HOSE, Pulse Line	32-8M0064783	32-858800
21	CONNECTOR	22-822769
22	HOSE	32-8M0064778	32-856817 2
23	NOT SOLD SEPARATE, Cap	NSS
24	HOSE/SLEEVE	32-8M0064780	32-856818A 1
25	HOSE, (57.00 Inches Bulk) (Cut to 16 Inches)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
26	CONNECTOR	22-858955
27	CLAMP, Hose (15.3)	54-8M0214964
28	HOSE	32-8839461
29	TUBING, (33.00 Inches Bulk) (Cut to 15 Inches)	32-85583464
30	TUBING, (33.00 Inches Bulk) (Cut to 28 Inches)	32-85583464
31	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
32	CONDUIT	32-883965
-	GASKET SET, Powerhead	27-832934A00
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T598999 & Below	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T598999 & Below	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T599000 & Up	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T598999 & Below	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T599000 & Up	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (200)	891823A07	891823A04, 891823B04 (200)

GEAR HOUSING(DRIVESHAFT)(STANDARD/COUNTER ROTATION)

Below is the parts list for Mercury 225 (3.0L EFI) GEAR HOUSING(DRIVESHAFT)(STANDARD/COUNTER ROTATION):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (STANDARD)(LONG)	1623-859399T13	1623-859399R13 (STANDARD)(LONG)
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (STANDARD)(X-LONG)	1623-859399T14	1623-859399R14 (STANDARD)(X-LONG)
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (STANDARD)(XX-LONG)	1623-859399T15	1623-859399R15 (STANDARD)(XX-LONG)
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (COUNTER ROTATION)(X-LONG)	1623-859399T16	1623-859399R16 (COUNTER ROTATION)(X-LONG)
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (COUNTER ROTATION)(XX-LONG)	1623-859399T17	1623-859399R17 (COUNTER ROTATION)(XX-LONG)
1	GEAR HOUSING ASSEMBLY, Basic	1623-859399T18	1623-857113T 3
2	PIN	17-379721
3	FILLER BLOCK	821526001	821526
4	PITOT TUBE	859402
5	ANODE	97-826134Q	826134, 826134A 1
6	SCREW, (M6 x 40)	10-4000333
7	NUT, (M6) Stainless Steel	11-401386
8	BEARING ASSEMBLY, Roller	31-42647A1
9	PIN, Dowel - Without Hole (.375 x .625)	17-43044
10	SCREW KIT, (.375-16 x .250) Drain	10-79953Q04
11	WASHER	12-191833
12	TUBING, (72.00 Inches Bulk) Comment: (LONG - 7 IN)	32-85944975
12	TUBING, (72.00 Inches Bulk) Comment: (X-LONG - 12 IN)	32-85944975
12	TUBING, (72.00 Inches Bulk) Comment: (XX-LONG - 17 IN)	32-85944975
13	FITTING	22-881866	22-859432
14	COVER	858934
15	GASKET	27-858935
16	NOT SOLD SEPARATE, Pinion Gear Comment: (1.75:1 - 12/21)(Part of 43-859321A3)	NSS
17	WASHER	12-92721
18	NUT, (.625-18)	11-35921
19	SEAL, Oil	26-8M0204708
20	O-RING, (.799)	25-8M0214927
21	SCREW, (M6 x 16)	10-1993716
22	WASHER	12-77674
23	SHIFT SHAFT (LOWER)	824145
24	DRIVESHAFT Comment: (LONG)	45-881938	45-858711 (LONG)
24	DRIVESHAFT Comment: (X-LONG)	45-881942	45-858712 (X-LONG)
24	DRIVESHAFT Comment: (XX-LONG)	45-881943	45-858713 (XX-LONG)
25	SHIM ASSEMBLY	15-8M0063268
26	BEARING, Tapered Roller	31-8M0146553
27	NOT SOLD SEPARATE, Cup	NSS
28	KEY	28-8M0204723
29	SHIM SET	15-42637A1
30	BEARING, Roller	31-8M0146566
31	NOT SOLD SEPARATE, Cup	NSS
32	RETAINER	8245191
33	CARRIER ASSEMBLY	8M0214948
34	O-RING, (2.175 x .175)	25-8M0142854
35	SEAL, Oil	26-8M0214939
36	SEAL, Oil	26-8M0214939
37	HOUSING KIT, Upper Water Pump	817275A2
38	SEAL KIT	26-816575A2
39	GASKET	27-430331
40	GASKET	27-8172771
41	FACEPLATE	8M0204709
42	IMPELLER	47-43026T2
43	SCREW, (M6 x 16)	10-1993716
44	COUPLING ASSEMBLY	832942A1
45	O-RING, (.796 x .139)	25-8M0204645
46	O-RING, (1.046)	25-8M0204654
-	SEAL KIT, Gear Housing	26-816575A4
-	REBUILD KIT, Water Pump	817275A5
-	REPAIR KIT, Water Pump Impeller	47-8M0100526	47-43026Q06

GEAR HOUSING(PROP SHAFT)(COUNTER ROTATION)

Below is the parts list for Mercury 225 (3.0L EFI) GEAR HOUSING(PROP SHAFT)(COUNTER ROTATION):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (X-LONG)	1623-859399T16	1623-859399R16 (X-LONG)
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (XX-LONG)	1623-859399T17	1623-859399R17 (XX-LONG)
1	GEAR HOUSING ASSEMBLY, Basic	1623-859399T18	1623-857113T 3
2	PLUG	22-859403
3	SHIFT CRANK	8M0226861
4	SPOOL ASSEMBLY	8M0235940
5	NOT SOLD SEPARATE, Spool	NSS
6	NOT SOLD SEPARATE, Sleeve	NSS
7	COTTER PIN	18-469501
8	SHIM SET	15-44491A1
9	ADAPTOR ASSEMBLY, Bearing	828830A2
10	BEARING ASSEMBLY, Needle Rollers	31-814653T	31-814653, 31-814653001
11	THRUST WASHER	12-815481
12	BEARING, Thrust	31-815480
13	GEAR, Reverse (12/21) Comment: (1.75:1)	43-828696T2
14	BEARING ASSEMBLY, Roller	31-15844
15	SPRING	24-30893
16	CLUTCH	52-859340T	52-854735T, 52-828288
17	PIN, Cross	17-8M0100263	17-8M0084681, 17-8M0020941, 17-30632
18	PIN, Detent	17-828356
19	PROPELLER SHAFT	44-8M0140448
20	GEAR SET, Forward/Pinion (12/21) Comment: (1.75:1)	43-828695A1
21	SPACER SHIM , (.206)	23-1761514
21	SPACER SHIM , (.208)	23-1761515
21	SPACER SHIM, (.210)	23-1761516
21	SPACER SHIM, (.212)	23-1761517
21	SPACER SHIM, (.214)	23-1761518
21	SPACER SHIM, (.216)	23-1761519
21	SPACER SHIM, (.218)	23-1761520
21	SPACER SHIM, (.220)	23-1761521
21	SPACER SHIM, (.222)	23-1761522
21	SPACER SHIM, (.224)	23-1761523
21	SPACER SHIM, (.226)	23-1761524
21	SPACER SHIM, (.228)	23-1761525
21	SPACER SHIM, (.230)	23-1761526
22	BEARING, Thrust	31-815480
23	THRUST WASHER	12-815481
24	ADAPTOR ASSEMBLY, Bearing	828831A3
25	BEARING ASSEMBLY, Needle Rollers	31-814653T	31-814653, 31-814653001
26	THRUST WASHER	12-18448
27	BEARING, Thrust	31-15842
28	RACE, Thrust	8182911
29	KEEPER	814605
30	O-RING	25-8M0214920
31	CARRIER ASSEMBLY, Bearing	818290T8
32	BEARING, Needle	31-30956T
33	SEAL, Oil (INSIDE)	26-14077
34	SEAL (OUTSIDE)	26-8M0204670
35	TAB WASHER	14-18323
36	RETAINER	8M2011027	79448
37	ANODE KIT	97-76214Q5
38	SCREW, (.437-14 x 1.750)	10-8M0204686
39	NOT SOLD SEPARATE, Decal-Counter Rotation	NSS
-	SEAL KIT, Gear Housing	26-816575A4

GEAR HOUSING(PROP SHAFT)(STANDARD ROTATION)

Below is the parts list for Mercury 225 (3.0L EFI) GEAR HOUSING(PROP SHAFT)(STANDARD ROTATION):

Position No.	Part Name	OEM Number	Supersedes
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (LONG)	1623-859399T13	1623-859399R13 (LONG)
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (X-LONG)	1623-859399T14	1623-859399R14 (X-LONG)
-	GEAR HOUSING ASSEMBLY, Complete (4.75 Inch/120.65 mm Torpedo Diameter) Comment: (XX-LONG)	1623-859399T15	1623-859399R15 (XX-LONG)
1	GEAR HOUSING ASSEMBLY, Basic	1623-859399T18	1623-857113T 3
2	PLUG	22-859403
3	SHIFT CRANK	8M0226861
4	SPOOL ASSEMBLY	8M0235940
5	NOT SOLD SEPARATE, Shift Spool	NSS
6	COTTER PIN	18-469501
7	NOT SOLD SEPARATE, Sleeve	NSS
8	GEAR SET, Forward/Pinion (12/21) Comment: (1.75:1)	43-859321A3
9	SHIM SET	15-44491A1
10	BEARING SET, Cup And Cone	31-30894A1
11	NOT SOLD SEPARATE, Cup	NSS
12	RING, Retaining	53-856823
13	BEARING, Needle	31-30895T
14	SPRING	24-30893
15	CLUTCH	52-859340T	52-854735T, 52-828288
16	PIN, Detent	17-828356
17	PIN, Cross	17-8M0100263	17-8M0084681, 17-8M0020941, 17-30632
18	PROPELLER SHAFT	44-8M0140440
19	GEAR, Reverse (12/21) Comment: (1.75:1)	43-859322A1
20	SPACER	23-824108
21	RING, Thrust	681001
22	BEARING, Ball	30-88957T
23	O-RING	25-8M0214920
24	CARRIER ASSEMBLY, Bearing	818763T11	818763A11
25	BEARING, Needle	31-30956T
26	SEAL, Oil (INSIDE)	26-14077
27	SEAL (OUTSIDE)	26-8M0204670
28	TAB WASHER	14-18323
29	RETAINER	8M2011027	79448
30	ANODE KIT	97-76214Q5
31	SCREW, (.437-14 x 1.750)	10-8M0204686
-	SEAL KIT, Gear Housing	26-816575A4

OIL INJECTION COMPONENTS

Below is the parts list for Mercury 225 (3.0L EFI) OIL INJECTION COMPONENTS:

Position No.	Part Name	OEM Number	Supersedes
1	TANK ASSEMBLY	1200-8M0119508	1200-8M0064073, 1270-830889A10, 1270-830889A 4
2	NOT SOLD SEPARATE, Decal-Reservoir	NSS
3	SCREW, (.164-18 x .375)	10-58376
4	WASHER, (.203 x .562 x .060) Stainless Steel	12-72761
5	CAP ASSEMBLY	36-814449A3
6	GASKET	27-42999T
7	SWITCH ASSEMBLY	87-856156T02	87-856156A 2
8	SCREW, (M8 x 35)	10-81893435
9	WASHER	12-4002318
10	GROMMET	25-855362001	25-855362
11	BUSHING	23-855364
12	HOSE, (57.00 Inches Bulk) (Cut to 7 Inches)	32-8M0108355	32-8M0047428, 32-830756109, 32-99127109, 32-877821
13	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
14	FITTING	22-8M0207780
15	HOSE, (2.00 Inches)	32-875283
16	FILTER, In Line	35-875284T01	35-875284001, 35-875284
17	HOSE	32-875289
18	CONNECTOR	22-858955
19	NOT SOLD SEPARATE, Plug	NSS
20	TUBING, (25.00 Inches Bulk) (Cut to 24 Inches)	32-82381455

PORT BLEED SYSTEM

Below is the parts list for Mercury 225 (3.0L EFI) PORT BLEED SYSTEM:

Position No.	Part Name	OEM Number	Supersedes
1	CHECK VALVE	21-8282182
2	PIPE PLUG	22-8272011
3	TUBING, (36.00 Inches Bulk) (Cut to 20.5 Inches)	32-8M0054152	32-856060 65
4	CHECK VALVE	21-8159234
5	CHECK VALVE, 90 Degree (.0625-27)	21-8592352
6	TUBING, (36.00 Inches Bulk) (Cut to 13 Inches)	32-8M0054152	32-856060 65
7	CHECK VALVE	21-426585
8	PIPE PLUG	22-8272011
9	CLIP	54-23567
10	SCREW, (#10-16 x .500)	10-48408
11	TUBING, (36.00 Inches Bulk) (Cut to 11 Inches)	32-8M0054152	32-856060 65
12	TUBING, (20.00 Feet Bulk) (Cut to 22.5 Inches)	32-892024122	32-99130122
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T598999 & Below	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T598999 & Below	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T599000 & Up	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T598999 & Below	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T599000 & Up	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (200)	891823A07	891823A04, 891823B04 (200)

POWER TRIM COMPONENTS

Below is the parts list for Mercury 225 (3.0L EFI) POWER TRIM COMPONENTS:

Position No.	Part Name	OEM Number	Supersedes
-	POWER TRIM, Complete	855998A11	855998A08, 855998A07, 855998A10, 855998A09, 855998A05, 855998A 3
1	TRIM MOTOR	878265A4
2	NOT SOLD SEPARATE, Armature	NSS
3	NOT SOLD SEPARATE, End Frame	NSS
4	SCREW, (M6 x 30)	10-82494830
5	LOCKWASHER, (M6)	13-400256
6	COUPLING	8782451
7	PO CHECK KIT	878410A1
8	MANUAL RELEASE ASSEMBLY Comment: (Incls. Ref. #26)	893929A01	813442A 2 (Incls. Ref. #26)
9	SHAFT KIT	8M0142997
10	PIN	17-878267	17-44431
11	TILT CYLINDER ASSEMBLY	878235A03	878235A02, 878235A 1
12	GUIDE KIT Comment: (Incls. Ref. #26)	878239A02	878239A 1 (Incls. Ref. #26)
13	O-RING KIT Comment: (Incls. Ref. #26)	8M0142999
14	SHOCK ROD KIT Comment: (Incls. Ref. #26)	8M0168219
15	PISTON ASSEMBLY, Memory	8M0143000
16	REPAIR KIT, Check Valve Comment: (Incls. Ref. #26)	878406A02	878406A 1 (Incls. Ref. #26)
17	PISTON ASSEMBLY	878414T01	878414A 1
18	PISTON ASSEMBLY	878413A1
19	GUIDE ASSEMBLY	1100-8M0021648	878243A 1
20	RESERVOIR KIT	878264A1
21	PLUG ASSEMBLY	19-811613
22	SCREW, (M6 x 14)	10-4000327
23	WASHER	12-4002315
24	PUMP KIT	892251A01	878411A 1
25	REPAIR KIT, Power Trim	878408A1
26	PIN, Trilobe	17-821539	17-13794, 17-19603
27	SCREW, (M10 x 30)	10-858771
28	WASHER	12-4002319
29	ANODE KIT	97-818298Q1
30	SCREW, (M6 x 25)	10-8M0204707
31	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
32	SHAFT	99625002
33	C WASHER	8M0084613	69205
34	CLAMP	54-26550
35	SCREW, (#10-16 x .600)	10-878609	10-812832 1
36	CONDUIT, (.350 Inside Diameter x 3.00 Feet Bulk) (Cut to 2 Inches)	32-828547353
37	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275

SERVICE/SUPPORT MATERIAL

Below is the parts list for Mercury 225 (3.0L EFI) SERVICE/SUPPORT MATERIAL:

Part Name	OEM Number	Supersedes
PARTS MANUAL, 200/225/250 (3.0L) SeaPro/Marathon EFI	90-80319902
SERVICE MANUAL	90-884294R01	90-884294
OWNERS MANUAL	90-10128030
DECAL, EPA Label Information Comment: (2002)	37-804670A02
DECAL, EPA Label Information Comment: (2003)	37-804670A03
TOOL KIT Comment: (SEAPRO/MARATHON)	91-826798A1
DECAL SET Comment: (200)	37-891822A03
DECAL SET Comment: (3L SEAPRO)	37-883285A02
DECAL SET Comment: (MERC 225 EFI-LONG)	37-824105A02
DECAL SET Comment: (MERC 225 EFI XL/XXL)(BLUE)(2002)	37-809693A03	37-809693A02 (MERC 225 EFI XL/XXL)(BLUE)(2002)
DECAL SET Comment: (MERC 225 EFI XL/XXL)(BLUE)(2003)	37-809693A03	37-809693A02 (MERC 225 EFI XL/XXL)(BLUE)(2003)
DECAL SET Comment: (MERC 250)(2002)	37-809167A03	37-809167A02 (MERC 250)(2002)
DECAL SET Comment: (MERC 250)(2003)	37-809167A03	37-809167A02 (MERC 250)(2003)
DECAL SET Comment: (3L MARATHON)	37-883286A02
DECAL SET Comment: (MARINER 225 LONG)(2002)	37-827438A03	37-827438A02 (MARINER 225 LONG)(2002)
DECAL SET Comment: (MARINER 225 LONG)(2003)	37-827438A03	37-827438A02 (MARINER 225 LONG)(2003)
DECAL SET Comment: (MARINER 225 XL)(2002)	37-883284A03	37-883284A02 (MARINER 225 XL)(2002)
DECAL SET Comment: (MARINER 225 XL)(2003)	37-883284A03	37-883284A02 (MARINER 225 XL)(2003)
DECAL SET Comment: (MARINER 250)(2002)	37-809168A03	37-809168A02 (MARINER 250)(2002)
DECAL SET Comment: (MARINER 250)(2003)	37-809168A03	37-809168A02 (MARINER 250)(2003)
DECAL SET Comment: (TRACKER 225)	37-809848A02

SOLENOID PLATE

Below is the parts list for Mercury 225 (3.0L EFI) SOLENOID PLATE:

Position No.	Part Name	OEM Number	Supersedes
1	PLATE	858366T2
2	SOLENOID ASSEMBLY, (#10-32 / .3125-18 Terminals)	89-817109A2
3	GROMMET	25-822179
4	SCREW, (M6 x 25 MM)	10-82129125
5	BUSHING	23-8M0214955
6	RELAY ASSEMBLY	8M0207773
7	NOT SOLD SEPARATE, Decal	NSS
8	BRACKET	828102
9	BUSHING	23-8M0214955
10	GROMMET	25-818967
11	HARNESS ASSEMBLY, Engine Wiring Comment: SN# 0T598999 & Below	84-880005T1
11	HARNESS ASSEMBLY, Engine Wiring Comment: SN# 0T599000 & Up	84-880005T2
12	FUSE, Mini - Yellow - 20 Ampere	88-832969T20	88-832969 20
12	FUSE, Mini - Tan - 5 Ampere	88-832969T05	88-832969 5
13	COVER, Fuse	858754
-	HARNESS ASSEMBLY (TPS)	879346A41	84-878073A 2
-	HARNESS ASSEMBLY, Encoder, Crank Position Sensor	84-879964A2
-	HARNESS ASSEMBLY, Alternator, Alternator	84-881262A2
14	SCREW, (M6 x 14)	10-82129114
15	J CLIP	54-8M0024808
16	CABLE ASSEMBLY Comment: (225) SN# 0T467442 & Up	84-882830A1
16	CABLE ASSEMBLY Comment: (250) SN# 0T467335 & Up	84-882830A1
17	SCREW, (M6 x 12)	10-82130012
18	HARNESS ASSEMBLY, Trim Comment: SN# 0T598999 & Below	84-819514T16
18	HARNESS ASSEMBLY, Trim Comment: SN# 0T599000 & Up	84-819514T18
19	HARNESS ASSEMBLY, Digital Adaptor Comment: (225) SN# 0T467442 & Up	84-859244T1
19	HARNESS ASSEMBLY, Digital Adaptor Comment: (250) SN# 0T467335 & Up	84-859244T1
20	HARNESS ASSEMBLY, Fuse - 100 Ampere Comment: SN# 0T599000 & Up	84-878231A6
21	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
22	CAP NUT,	10-32,11-813938
23	NUT, (.312-18)	11-8M0204668
24	NUT, Brass (BRASS)	10-32,11-45076
25	LOCKWASHER, (.312)	13-53166
26	CLIP, (1.00)	54-858755
27	CLIP	54-828991T	54-828991
28	PCM, Propulsion Control Module Comment: (200)	89790644T	88555741T, 88555741S, 88555729S, 88555721S (200)
28	PCM, Propulsion Control Module Comment: (225)	8M0086577	859610R47, 85961047S, 859610 47, 85961087S (225)
28	PCM, Propulsion Control Module Comment: (3L WORK)	8M0086574	859610R17, 85961017S, 859610 17, 85961086S (3L WORK)
28	PCM, Propulsion Control Module Comment: (250)	8M0086578	859610R48, 85961048S, 859610 48, 85961088S (250)
29	SCREW, (M6 x 25)	10-82130025
30	BUSHING	23-856954
31	GROMMET	25-8M0190980
32	WASHER, (.265 x .750 x .048) Stainless Steel	12-65567
33	CLIP	8590881
34	SCREW, (M6 x 10)	10-82129110
35	SENSOR, (0 - 100 PSI)	881879T11	881879011, 881879A 6
36	FITTING	22-8M0207782
37	CLIP, (.865)	54-883066
38	BRACKET	859313
39	GROMMET	25-818967
40	BUSHING	23-8M0214955
41	SCREW, (M6 x 25)	10-82130025
42	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
43	CABLE ASSEMBLY, (4.00 Inches) Black	84-88807A16
44	SCREW, (M8 x 20)	10-81893420
45	CABLE ASSEMBLY, Battery - Negative	84-88439A26
45	CABLE ASSEMBLY, Battery - Positive	84-88439A25
46	CONNECTOR ASSEMBLY	832948A1
47	CONNECTOR, 6 Pin Plug	881065A1
48	HARNESS ASSEMBLY Comment: (200/3.0L WORK)	84-882815A1
49	BOOT, Insulator - Red	85-8500671
50	CABLE ASSEMBLY, Yellow/Black Comment: (Use where Applicable)	84-93388A14
51	PLUG, Male Comment: (Use where Applicable)	13541
52	CAP ASSEMBLY, 3 Position-Female Connector (FEMALE) Comment: (COUNTER ROTATION)	881175A1
53	CAP ASSEMBLY, 3 Position-Male Connector (MALE) Comment: (COUNTER ROTATION)	881176A1
-	CAP, Female	13540

SPEEDOMETER/BLOCK PRESSURE SYSTEM

Below is the parts list for Mercury 225 (3.0L EFI) SPEEDOMETER/BLOCK PRESSURE SYSTEM:

Position No.	Part Name	OEM Number	Supersedes
1	FITTING	22-881866	22-859432
2	TUBING, (44.00 Inches Bulk) (GRAY)	32-85978571
3	COUPLER	22-8M0214971
4	PLUG	22-859732
5	FITTING, Adapter	22-8M0214970
6	TUBING, (44.00 Inches Bulk) (Cut to 5 Inches)	32-85978571
7	TEE, Fitting	22-875207
8	FITTING	22-859448T	22-859448
9	GROMMET	25-8M0153609
10	TIE STRAP, (11.750 Inches)	54-850181
11	TUBING, (72.00 Inches Bulk) (Cut to 46 Inches)	32-85944975

STARBOARD BLEED SYSTEM

Below is the parts list for Mercury 225 (3.0L EFI) STARBOARD BLEED SYSTEM:

Position No.	Part Name	OEM Number	Supersedes
1	TUBING, (36.00 Inches Bulk) (Cut to 15.t Inches)	32-8M0054152	32-856060 65
2	CHECK VALVE, 90 Degree (.0625-27)	21-8592352
3	TUBING, (36.00 Inches Bulk) (Cut to 16.5 Inches)	32-8M0054152	32-856060 65
4	TUBING, (36.00 Inches Bulk) (Cut to 15 Inches)	32-8M0054152	32-856060 65
5	CLIP	54-23567
6	SCREW, (#10-16 x .500)	10-48408
7	CHECK VALVE	21-8282182
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T598999 & Below	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (225) SN# 0T599000 & Up	883892A07	883892A04, 883892A03, 883892A02 (225) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T598999 & Below	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (3L Work) SN# 0T599000 & Up	883893A07	883893A04, 883893A03, 883893A02 (3L Work) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T598999 & Below	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T598999 & Below
-	POWERHEAD ASSEMBLY Comment: (250) SN# 0T599000 & Up	883894A07	883894A04, 883894A03, 883894A02 (250) SN# 0T599000 & Up
-	POWERHEAD ASSEMBLY Comment: (200)	891823A07	891823A04, 891823B04 (200)

STARTER MOTOR(225-S/N-0T467441/250-S/N-0T467334 &BELOW)

Below is the parts list for Mercury 225 (3.0L EFI) STARTER MOTOR(225-S/N-0T467441/250-S/N-0T467334 &BELOW):

Position No.	Part Name	OEM Number	Supersedes
1	STARTER MOTOR ASSEMBLY	50-898265013	50-856996T
2	PLATE	75660
3	THRU BOLT	10-749681
4	DRIVE KIT	8236401
5	PINION	898265015	86177 1
6	ARMATURE	8236381
7	BRUSH/SPRING KIT	898265016	75384, 75384 1
8	HOLDER	898265014	61787
9	END CAP	15386001
10	SCREW	F15158
11	LOCKWASHER, (.250) Stainless Steel	13-26992
12	NUT, (.250-20)	11-64015
13	LOCKWASHER, (.250) Stainless Steel	13-26992
14	NUT, (.250-20)	11-20890
15	DECAL, Warning, High Voltage	37-8272822
16	BOOT, Insulator - Yellow	85-8500673
17	COLLAR	23-8M0034918	23-8M0001391, 56703
18	STOP, Rubber	8M0043376	68042
19	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel	10-69035
20	CABLE ASSEMBLY, (6.00 Inches) Black	84-93388A1

STARTER MOTOR(225-S/N-0T467442/250-S/N-0T467335 & UP)

Below is the parts list for Mercury 225 (3.0L EFI) STARTER MOTOR(225-S/N-0T467442/250-S/N-0T467335 & UP):

Position No.	Part Name	OEM Number	Supersedes
1	STARTER MOTOR ASSEMBLY	50-892339T01	50-892339T, 50-853329T
2	THRU BOLT	10-803005
3	GEAR KIT	43-880805A1
4	SOLENOID KIT	809463A1
5	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel	10-69035
6	CABLE ASSEMBLY, (6.00 Inches) Black	84-93388A1
7	DECAL, Warning, High Voltage	37-8272822
8	LOCKWASHER, (M5)	13-400255
9	NUT, (M5) Stainless Steel	11-400211
10	LOCKWASHER, (.312)	13-8M0204647
11	NUT, (M8) Stainless Steel	11-400213
12	COLLAR	23-8M0034918	23-8M0001391, 56703
13	STOP	8M0043276	879845

SWIVEL BRACKET AND STEERING ARM

Below is the parts list for Mercury 225 (3.0L EFI) SWIVEL BRACKET AND STEERING ARM:

Position No.	Part Name	OEM Number	Supersedes
1	SWIVEL BRACKET ASSEMBLY, Black	1499-8M0102865	1499-8710T20
2	O-RING	25-8M0214926
3	BUSHING	23-818764	23-67669
4	SPACER	23-816039
5	SEAL, Oil (LOWER)	26-87735
6	FITTING, Grease	22-8M0169589
7	BUSHING	23-821207	23-99608
8	THRUST WASHER	12-816432
9	YOKE, Bottom Comment: (LONG - CARBON STEEL)	814084F1
9	YOKE, Bottom Comment: (XL-STAINLESS STEEL)	826364T	826364F 1 (XL-STAINLESS STEEL)
10	RING, Retaining	53-67684
11	STRIKER PLATE	8M0045383	99630 1
12	LOCKWASHER, (.375)	13-58643
13	NUT, (.375-24)	11-46335
14	SCREW, (.250-28 x .500)	10-64014
15	NOT SOLD SEPARATE, Decal-Serial Overlaminate	NSS
16	SENDER ASSEMBLY, Trim	8M0074846	821180A 6
17	SCREW, (#10-24 x .750)	10-852368	10-56682
18	LOCKWASHER, Stainless Steel	10,13-26996
19	WASHER, (.203 x .406 x .040)	12-89302
20	SWIVEL PIN ASSEMBLY, Steering Arm Comment: (LONG - CARBON STEEL)	17-67706A55
20	SWIVEL PIN ASSEMBLY, Steering Arm - Stainless Steel Comment: (XL-STAINLESS STEEL)	17-8M0132731
21	SCREW, (M12 x 190)	10-8M0141069
22	BUMPER	824998001	824998
23	MOUNT, Upper	8163851
24	WASHER	12-8154371
25	WASHER	12-815436
26	NUT, (M12)	11-896963	11-859129, 11-90099
27	CLAMP	8M0036783	813769
28	SCREW, (M8 x 35)	10-81893435
29	LINK ROD ASSEMBLY	92876A12
30	SCREW, (.375-24 x 1.250)	10-849838	10-14000
31	NUT, (.375-24) Stainless Steel	11-8M0204726
32	WASHER, (.390 x .625 x .062) Stainless Steel	12-37828

THROTTLE LINKAGE

Below is the parts list for Mercury 225 (3.0L EFI) THROTTLE LINKAGE:

Position No.	Part Name	OEM Number	Supersedes
1	LEVER, Throttle Control	8M0040987	825268 2
2	SCREW, (M8 x 35)	10-81893435
3	WASHER	12-36042
4	BUSHING	23-821113
5	SCREW, (M6 x 55)	10-40124
6	NUT, (M6) Stainless Steel	11-400212
7	CAP	42942
8	INSERT	42927
9	NUT, (M6) Stainless Steel	11-401366
10	BUSHING	23-8M0215006
11	LINK	8583541
12	BRACKET	824010T05	824010 2
13	LATCH	824016
14	DRIVE SCREW	10-42975
15	CUP, Barrel Retainer	824015
16	SCREW, (M8 x 25 MM) Stainless Steel	10-82155025
17	CLAMP	54-859172
18	SCREW, (M8 x 25 MM) Stainless Steel	10-82155025
19	GUIDE, Roller	8M0039052	896662, 854653 1
20	SWITCH Comment: (DESIGN II)	87-8M0207794
21	TIE STRAP, (8.00 Inches)	54-816311T	54-816311, 54-90077, 54-826785, F1877, F717046-1, F717046, MAF03001, 833188E, 54-F9301, 54-816311100, 54-898101111, 54-898101275
22	SCREW, (M3.5 x 20)	10-82470620
23	WASHER	12-43430
24	WASHER	12-35459
25	WASHER	12-36001
26	SWITCH Comment: (DESIGN I)	87-8M0052931	87-814281A 2 (DESIGN I)

TOOLS

Below is the parts list for Mercury 225 (3.0L EFI) TOOLS:

Part Name	OEM Number	Supersedes
CARTRIDGE	91-880118A04	91-880118A03, 91-880118A 2
DIAL INDICATOR TOOL	91-58222A1
HARNESS ASSEMBLY, DDT Adaptor Comment: (ELECTRICAL/IGNITION)	84-822560A5
HOLDER TOOL	91-52344
STAND TOOL, Powerhead	91-827001A1
CABLE ASSEMBLY, DDT Comment: (ELECTRICAL/IGNITION)	84-825003A1
DIGITAL DIAGNOSTIC TESTER Comment: (ELECTRICAL/IGNITION)	91-823686A2
TACH MULTI METER, DMT 2000 Digital Comment: (ELECTRICAL/IGNITION)	91-854009A3
CAP TOOL, Flywheel Puller	91-24161
SWITCH ASSEMBLY Comment: (ELECTRICAL/IGNITION)	91-52024A1
TESTER, Eight Chamber Comment: (ELECTRICAL/IGNITION)	91-850439T1
GAP TOOL, Single Chamber Comment: (ELECTRICAL/IGNITION)	91-63998A1
TIMING LIGHT Comment: (ELECTRICAL/IGNITION)	91-99379
GAUGE TOOL Comment: (POWERHEAD)	91-29287
SLEEVE Comment: (POWERHEAD)	91-55919
LIFTING EYE Comment: (POWERHEAD)	91-904551
INSTALLATION TOOL, Lock Ring Comment: (POWERHEAD)	91-93004A2
REMOVAL TOOL, Piston Pin Lock Ring Comment: (POWERHEAD)	91-52952T1
MANDREL TOOL, Piston Pin Comment: (POWERHEAD)	91-92973A1
EXPANDER TOOL, Piston Ring Comment: (POWERHEAD)	91-24697
STAND, Powerhead Comment: (POWERHEAD)	91-812549T	91-812549 (POWERHEAD)
COMPRESSOR TOOL, Ring Comment: (POWERHEAD)	91-823237T	91-823237 (POWERHEAD)
TORQUE WRENCH, (0-150 lb-in)	91-66274
PULLER PLATE	91-37241
ALIGNMENT TOOL Comment: (TRIM/TILT SYSTEM)	91-112301
SPANNER WRENCH Comment: (TRIM/TILT SYSTEM)	91-74951
HEAT LAMP Comment: (TRIM/TILT SYSTEM)	91-63209
ROD TOOL, Backlash Indicator Flag Comment: (GEAR HOUSING)	91-53459
INDICATOR TOOL, Backlash Comment: (GEAR HOUSING)	91-8M0053505	91-78473 (GEAR HOUSING)
DRIVER TOOL, Bearing Comment: (GEAR HOUSING)	91-816244
REMOVAL TOOL, Bearing Comment: (GEAR HOUSING)	91-816245
MANDREL, Bearing Driver Cup Comment: (GEAR HOUSING)	91-31106T
DRIVER TOOL, Bearing Cup Comment: (GEAR HOUSING)	91-87120T
PRE LOAD TOOL, Bearing Comment: (GEAR HOUSING)	91-14311A04
PULLER KIT, Bearing Comment: (GEAR HOUSING)	91-31229A7
MANDREL Comment: (GEAR HOUSING)	91-15755T
DRIVE HEAD TOOL Comment: (GEAR HOUSING)	91-36569T
DRIVER ROD TOOL, Needle Bearings Comment: (GEAR HOUSING)	91-37323
WRENCH TOOL, Driveshaft Bearing Comment: (GEAR HOUSING)	91-36571T
INSTALLER TOOL, Bearing Comment: (GEAR HOUSING)	91-38628T
NUT, (.625-18) Comment: (GEAR HOUSING)	11-24156
PLATE Comment: (GEAR HOUSING)	91-29310
WASHER Comment: (GEAR HOUSING)	12-34961
RETAINING TOOL, Bearing Comment: (GEAR HOUSING)	91-43506T
WASHER Comment: (GEAR HOUSING)	12-54048
INSTALL TOOL, Cross Pin Comment: (GEAR HOUSING)	91-86642
ADAPTER KIT, Dial Indicator Comment: (GEAR HOUSING)	91-83155
HOLDING TOOL, Dial Indicator Comment: (GEAR HOUSING)	91-89897
DRIVER CUP Comment: (GEAR HOUSING)	91-36577T
ADAPTOR TOOL, Driveshaft Comment: (GEAR HOUSING)	91-61077T
HOLDING TOOL, Driveshaft Comment: (GEAR HOUSING)	91-56775T
DRIVER CUP Comment: (GEAR HOUSING)	91-36577T
ADAPTOR TOOL, Driveshaft Comment: (GEAR HOUSING)	91-61077T
HOLDING TOOL, Driveshaft Comment: (GEAR HOUSING)	91-56775T
FOWARD GEAR INSTALLATION TOOL Comment: (GEAR HOUSING)	91-815850
INSTALLER TOOL, Needle Bearing - Forward Gear Comment: (GEAR HOUSING)	91-86943T
NUT TOOL, Gear Housing Cover Comment: (GEAR HOUSING)	91-61069T
GUIDE PLATE Comment: (GEAR HOUSING)	91-816243
PULLER JAWS Comment: (GEAR HOUSING)	91-816242
MANDREL Comment: (GEAR HOUSING)	91-92788T
DRIVER Comment: (GEAR HOUSING)	91-33491
DRIVER, Oil Seal Comment: (GEAR HOUSING)	91-31108T
DRIVER TOOL, Oil Seal Comment: (GEAR HOUSING)	91-817569T	91-817569 (GEAR HOUSING)
LOCATION TOOL, Pinion Comment: (GEAR HOUSING)	91-12349A05
SHIMMING TOOL, Pinion Gear Comment: (GEAR HOUSING)	91-56048001
ADAPTOR TOOL, Pinion Nut Comment: (GEAR HOUSING)	91-61067A04
PROPELLER SHAFT Comment: (GEAR HOUSING)	44-93003
PULLER TOOL Comment: (GEAR HOUSING)	91-85716
PULLER JAW ASSEMBLY Comment: (GEAR HOUSING)	91-46086A1
INSTALLATION TOOL, Bearing Adaptor Comment: (GEAR HOUSING)	91-18605A2
PULLER ASSEMBLY, Slide Hammer Comment: (GEAR HOUSING)	91-34569A1
GUIDE TOOL, Water Pump Alignment Pins Comment: (GEAR HOUSING)	91-821571A1
CLAMP KIT Comment: (FUEL SYSTEM)	91-803146A04	91-803146A 2 (FUEL SYSTEM)
GAUGE, Air/Fuel Pressure Comment: (FUEL SYSTEM)	91-881833A03	91-881833A 2 (FUEL SYSTEM)
SEAL KIT, Wire Harness Comment: (ELECTRICAL)	91-881814A1

TOP COWL

Below is the parts list for Mercury 225 (3.0L EFI) TOP COWL:

Position No.	Part Name	OEM Number	Supersedes
1	TOP COWL ASSEMBLY Comment: (BLACK)	4001-880012T1
1	TOP COWL ASSEMBLY Comment: (SILVER)	4001-880012T36	4001-880012T 2 (SILVER)
2	SCREW, (M6 x 30)	10-82130030
3	SOUND BLANKET KIT	880014A02	880014A 1
4	NOT SOLD SEPARATE, Sound Blanket-Top	NSS
5	NOT SOLD SEPARATE, Sound Blanket (PORT)	NSS
6	WASHER, (.250 External Star)	13-93702
7	COVER	826639T
8	HOOK ASSEMBLY, Rear Latch	850682T4
9	NOT SOLD SEPARATE, Pin	NSS
10	RING, Retaining	53-8237951
11	ROLLER	8M0207770
12	GROMMET	25-850685T02	850685002, 25-850685 1
13	BRACKET, Front	8M0036792	821249M 2
14	SCREW, (M6 x 20)	10-82130020
15	BUMPER, Latch	815477
16	PIN, Roll	8155381
17	NUT, (M6) Stainless Steel	11-401366
18	WASHER, (.281 x .500 x .060) Stainless Steel	12-8M0204649
19	RING, Retaining	53-8237951
20	ROLLER	8M0207770
21	WASHER	12-87161
22	NOT SOLD SEPARATE, Decal-Break-In	NSS
23	NOT SOLD SEPARATE, Decal-Counter Rotation	NSS

Transom Brackets

Below is the parts list for Mercury 225 (3.0L EFI) Transom Brackets:

Position No.	Part Name	OEM Number	Supersedes
1	BRACKET ASSEMBLY, Transom-Starboard	3426-828334T03
2	BRACKET ASSEMBLY, Transom-Port	3425-828333T08
3	FITTING, Grease (PORT)	22-8M0169588
4	TILT TUBE	826125A1
5	NUT, (1.00-14) Nylon Insert	11-826135
6	O-RING, (.612 x .103)	25-45711
7	WASHER	13-88750
8	NUT, (.875-14)	11-826164
9	SCREW, (.500-20 x 4.500)	10-8M0149747
10	WASHER, (.530 x .870 x .105) Stainless Steel	12-8M0204665
11	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel	12-8M0204648
12	NUT, (.500-20)	11-82671117
13	LEVER ASSEMBLY, Tilt Lock	8M0115104	8M0115103, 99629T 2
14	SPRING, Tension	24-830899
15	NYLINER	23-65830
16	SPRING, Compression	24-830900
17	KNOB	99633
18	PIN, Groove	17-99615
19	PIN	17-893709	17-99617

VAPOR SEPARATOR COMPONENTS

Below is the parts list for Mercury 225 (3.0L EFI) VAPOR SEPARATOR COMPONENTS:

Position No.	Part Name	OEM Number	Supersedes
1	COVER KIT	883245T04	883245T 2
2	FITTING, Straight	22-881740
3	FITTING	22-883249
4	NOT SOLD SEPARATE, Elbow	NSS
5	FITTING KIT, Pump Outlet Comment: (Use Without Filter)	22-855437A2
5	FITTING KIT Comment: (Use with Filter)	22-885186A1
6	O-RING Comment: (Use Without Filter)	25-8M0062785	25-883209 (Use Without Filter)
6	O-RING, (.468 x .078) Comment: (Use with Filter)	25-831985	25-885187 (Use with Filter)
7	FILTER	35-885188	35-823501
8	VALVE	883219
9	CAP	22-15026
10	CAP	883220
11	PLUG	19-883208	19-881830
12	SEAL	26-883248
13	GASKET	27-883252
14	REGULATOR	883257T1
15	O-RING KIT	25-883593A1
16	WASHER	12-883258
17	SCREW, (M5 x .8)	10-883261
18	SCREW, (M5 x .8)	10-883261
19	WIRE ASSEMBLY	84-881831
20	SCREW AND WASHER, (#8-32 x .750)	1395-808612	1399-5132
21	FLOAT KIT	883253A1
22	SHAFT	F10064
23	VALVE/SEAT KIT, Inlet	883247A1
24	SCREW, (M6 x 16)	10-883223
25	FILTER KIT	35-18458Q4
26	PROBE	8M0204710
27	BAFFLE	889318002	883260
28	SCREW, (M6 x 16)	10-883223
29	PUMP KIT	881705T1
30	SLEEVE	8M6000589	23-855428
31	BOWL KIT	883256T1
32	SEAL	26-883248
33	PLUG KIT	19-855435A1
34	O-RING	25-8M0062785	25-883209
35	SCREW, (M6 x 8)	10-16955

Download this page as PDF: Click here

For Mercury Owners:

To assist you in maintaining and repairing your marine engines, we hope the following resources may be of use:

Mercury / Mercruiser / Mariner Parts from JLM Marine

About JLM Marine

Founded in 2002, JLM Marine has established itself as a dedicated manufacturer of high-quality marine parts, based in China. Our commitment to excellence in manufacturing has earned us the trust of top marine brands globally.

As a direct supplier, we bypass intermediaries, which allows us to offer competitive prices without compromising on quality. This approach not only supports cost-efficiency but also ensures that our customers receive the best value directly from the source.

We are excited to expand our reach through retail channels, bringing our expertise and commitment to quality directly to boat owners and enthusiasts worldwide.