– JLM Marine Boat Parts Limited

Mercury V-200 (5624878 THRU 0C100860) Parts & Diagrams

🔎 Mercury V-200 Reference Library — Exploded parts diagrams (40 diagrams), specifications, common issues, and maintenance checklist.

The Mercury V-200 is a 2-Stroke EFI, V6 60-degree outboard motor. Designed for large center-consoles, offshore sport-fishing boats, and multi-engine configurations.

Quick Reference Specifications

Specification	Value
Engine Type	2-Stroke EFI, V6 60-degree
Horsepower	200 HP
Displacement	2507 cc (2.5L / 153 CID)
Bore x Stroke	89 mm x 67 mm (3.501 in. x 2.650 in.)
Spark Plug (Type & Gap)	NGK BPZ8HS-10
Engine Oil Capacity	—
Recommended Engine Oil	Mercury 2-Stroke Outboard Oil (TCW-3)
Gear Case Oil Capacity	802 mL (27.1 oz)
Idle Speed (in gear)	650–700 RPM (in gear)
Full Throttle RPM Range	5000-5600
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury V-200:

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury V-200.

▶Carburetor (29 parts)

Ref	OEM Part #	Part Name
-	1395-7826	REPAIR PARTS KIT
1	1374-9242T44	CARBURETOR Comment: (BOTTOM)(WH-46)
2	1399-3517	JET, (.084), VENT BOWL
3	NSS	NOT SOLD SEPARATE, Gasket-Cover Plate
4	1395-6032	PLATE
5	1395-9597	SCREW, COVER PLATE
6	1395-7822	FUEL BOWL Comment: (CENTER/BOTTOM)
7	NSS	NOT SOLD SEPARATE, Screw-Fuel Bowl
8	1395-6025	PLUG, MAIN JET
9	NSS	NOT SOLD SEPARATE, Gasket-Main Jet
10	1399-3518	JET, (.082), MAIN FUEL
11	NSS	NOT SOLD SEPARATE, Screw-Float Pin
12	NSS	NOT SOLD SEPARATE, Gasket-Inlet Needle and Seat
13	1395-7824	INLET NEEDLE AND SEAT ASSEMBLY
14	NSS	NOT SOLD SEPARATE, Gasket-Nozzle Boss
15	1395-9267	FLOAT
16	NSS	NOT SOLD SEPARATE, Pin-Float Lever
17	NSS	NOT SOLD SEPARATE, Gasket-Fuel Bowl
18	1395-4541	SCREW, IDLE AIR BLEED JET
19	NSS	NOT SOLD SEPARATE, Gasket-Bleed Jet Plug
20	1399-5213	JET, (.056), IDLE AIR
21	1395-6027	SCREW, THROTTLE LEVER
22	87607	THROTTLE LEVER
23	NSS	NOT SOLD SEPARATE, Spring-Throttle Return
24	1395-6031	SPACER, THROTTLE LEVER
25	1395-6022	SHAFT
26	NSS	NOT SOLD SEPARATE, Ring-Retainer-Throttle Shaft
27	1395-9416	THROTTLE VALVE
28	NSS	NOT SOLD SEPARATE, Screw-Throttle Valve

▶Choke Plate and Choke Linkage(Design I) (35 parts)

Ref	OEM Part #	Part Name
1	54293A10	CHOKE SOLENOID
2	10-39349	SCREW, (.312-18 x .750)
3	13-8M0204647	LOCKWASHER, (.312)
4	56074A11	PLUNGER AND LINK
5	10,13-26996	LOCKWASHER,
6	10-32,11-68219	NUT,
7	67245T	BRACKET
8	25-67272	GROMMET
9	90435	MOUNT
10	12-21249	WASHER
11	11-8267089	NUT, (.250-28)
12	27-672741	GASKET
13	99390A4	CHOKE PLATE
14	10-68000	SCREW, (.24-28 X 1.00)
15	16-33071	STUD (2-9/16")
16	27-672751	GASKET
17	67246T	COVER
18	12-69056	WASHER, (.255 x .625 x .0312)
19	13-26992	LOCKWASHER, (.250)
20	11-26001	NUT
21	89041	RETAINER
22	10-48408	SCREW, (#10-16 x .500)
23	73861A1	CHOKE SHAFT
24	76040	CHOKE SHUTTER
25	10-75898	SCREW
26	90401	CHOKE SHAFT LEVER
27	24-88578	SPRING
28	73860	MANUAL CHOKE ROD
29	25-67273	GROMMET
30	67247	KNOB
31	10-67262	SCREW
32	67249	CHOKE ROD
33	24-88522	SPRING
34	19-90585	PLUG
35	87076A4	IDLE SPEED CONTROL ASSEMBLY

▶Choke Plate and Throttle Levers(Design II) (26 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
1	67245T	BRACKET, COWL MOUNTIN - UPPER
2	25-67272	GROMMET
3	90435	MOUNT
4	12-21249	WASHER
5	11-8267089	NUT, (.250-28)
6	93772A2	STABILIZER
7	27-892211	GASKET
8	88509	SOUND ATTENUATOR PLATE
9	43440T	INLET
10	10-48408	SCREW, (#10-16 x .500)
11	27-877361	GASKET
12	93518A1	COVER
13	10-48408	SCREW, (#10-16 x .500)
14	10-88488	SCREW (3-1/4")
15	10-884891	SCREW, (.250-28 x 2.500)
16	12-35459	WASHER
17	87604	THROTTLE LINK Comment: SN# Merc-6073192/Mariner-6055033 & Up
18	828277A1	THROTTLE LEVER Comment: (OIL INJECTION)
19	10-15124	SCREW (3/4")
20	10,13-26996	LOCKWASHER,
21	12-24676	WASHER, (.200 x .440 x .032)
22	17-67297	CLEVIS PIN
23	12-89302	WASHER
24	18-26953	COTTER PIN
25	67748	ROLLER

▶Cowl Mounting Brackets (48 parts)

Ref	OEM Part #	Part Name
1	76258A3	BRACKET, REAR COWL Comment: (GRAY)
2	22-76256	NOZZLE
3	67984	SEAL
4	67228	SEAL
5	67999	SEAL
6	32-8M0108355	FUEL LINE, (57.00 Inches Bulk), TELL TALE
7	22-90824001	TEE
8	54-816311T	CABLE TIE, (8.00 Inches)
9	86386A1	BRACKET ASSEMBLY
10	10-66687	SCREW, (#10-32 x 1.50)
11	85650	HOUSING Comment: (STARBOARD)
12	10-64278	SCREW, (.250-28 X 1.00)
13	12-20583	WASHER
14	11-35888	NUT, (.250-28)
15	90435	MOUNT
16	12-8M0204649	WASHER, (.281 x .500 x .060)
17	11-35888	NUT, (.250-28)
18	99424	BRACKET Comment: (BRACKET CASTING #99423)
19	99447	RETAINER Comment: (BRACKET CASTING #99423)
20	10-68918	SCREW, (.190-24 x 1.00) Comment: (BRACKET CASTING #99423)
21	67260	SEAL Comment: (BRACKET CASTING #99423)
22	67241	HOUSING
23	10-92051	SCREW, (10-16 x .75)
24	87608	COWL LATCH Comment: (USE W/BRACKET CASTING #99423 OR #87586)
25	24-60295	SPRING Comment: (USE W/BRACKET CASTING #99423 OR #87586)
26	88622	PLATE
27	99391	RETAINER
28	10-69093	SCREW, (.25-20 X 1.50)
29	12-69057	WASHER (SMALL)
30	12-35280	WASHER, (.255 x .620 x .030) (LARGE)
31	23-88180	BUSHING
32	25-88033	GROMMET
33	87587	BRACKET Comment: (BRACKET CASTING #87586)
34	88804	RETAINER Comment: (BRACKET CASTING #87586)
35	10-88865	SCREW, (#10-24 x .750) Comment: (BRACKET CASTING #87586)
36	88508	SEAL Comment: (BRACKET CASTING #87586)
37	88623A1	BRACKET Comment: (CASTING #88624)
38	88621	RETAINER
39	88622	PLATE Comment: (USE W/BRACKET CASTING #88624)
40	10-89900	SCREW, (10-24 X 1.00)
41	25-87743	GROMMET
42	67260	SEAL
43	25-67272	GROMMET Comment: (USE W/CASTING #88624 OR 92008)
44	76264	LATCH Comment: (USE W/CASTING #88624 OR 92008)
45	24-85367	SPRING Comment: (USE W/CASTING #88624 OR 92008)
46	67739	SEAL Comment: (USE W/CASTING #88624)
47	NLA	No Longer Available Comment: (USE W/CASTING #88624)
48	10-69079	SCREW, (#10-16 x .440) Comment: USE W/CASTING #88624

▶Cowls and Front Cover (30 parts)

Ref	OEM Part #	Part Name
1	2151-7523A18	PORT COWL (GRAY) Comment: (USE WITH DESIGN "B" LATCH)
2	67260	SEAL
3	67258	PAD
4	88227	BLANKET
5	879871	BRACKET, UPPER
6	879851	BRACKET, LOWER
7	10-37562	SCREW, (.312-18 x 1.00)
8	68048	SHIELD Comment: (PORT)
9	10-48409	SCREW, (#10-16 x .625)
10	2150-7524A1	STARBOARD COWL Comment: (BLACK)(USE WITH DESIGN "B" LATCH)
11	88227	BLANKET
12	99444	SEAL
13	97461A2	LATCH (PORT/STARBOARD) Comment: (DESIGN "B" LATCH)
14	10-48409	SCREW, (#10-16 x .625) Comment: (DESIGN "B" LATCH)
15	12-72761	WASHER Comment: (DESIGN "B" LATCH)
16	2149-5399A16	FRONT COVER (GRAY) Comment: (DESIGN "A" LATCH)
17	67615	BLANKET Comment: (DESIGN "A" LATCH)
18	61158T	HOOK Comment: (DESIGN "A" LATCH)
19	10-75162	SCREW Comment: (DESIGN "A" LATCH)
20	67261	SHIELD Comment: (DESIGN "A" LATCH)
21	10-35519	SCREW, (#10-16 X .50) Comment: (DESIGN "A" LATCH)
22	62628	BARREL Comment: (DESIGN "A" LATCH)
23	46785A5	COWL LATCH ASSEMBLY Comment: (DESIGN "A" LATCH)
24	10-31312	SCREW, (#10-32 x 0.875) Comment: (DESIGN "A" LATCH)
25	15222	BAR Comment: (DESIGN "A" LATCH)
26	62629	BARREL Comment: (DESIGN "A" LATCH)
27	24-62624	SPRING Comment: (DESIGN "A" LATCH)
28	12-30164	WASHER, (.192 x .375 x .0312) Comment: (DESIGN "A" LATCH)
29	10-32,11-859124	NUT, Comment: (DESIGN "A" LATCH)
30	47341A11	ROPE AND HANDLE KIT (MANUAL STARTING)

▶Crankshaft, Pistons, and Connecting Rods (18 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
1	455-8745T5	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball (LOWER)
3	53-67446	RING
4	43-99727A1	DRIVE GEAR
5	54196A6	CARRIER ASSEMBLY
6	65800	PACKING
7	39-78633	RING, SEALING Comment: (.139 THICK)
8	31-67445	ROLLER BEARING Comment: (2 PIECE)
9	53-67444	RETAINING RING
10	NLA	No Longer Available, Piston Comment: (PORT - .030 O.S.)
11	NLA	No Longer Available, Piston Ring Comment: (.030 O.S.)
12	53-857196	RING, Lock
13	636-8119A6	CONNECTING ROD ASSEMBLY
14	10-76349	SCREW, (.3125-24 X 1.00)
15	12-8M0032839	WASHER
16	8M0234886	BEARING KIT
17	29-67483	NEEDLE BEARING

▶Cylinder Block and End Caps (42 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
--	66517	RESTRICTOR
1	858-8712A59	CYLINDER BLOCK Comment: SN# Merc-6203991/Mariner-6201970 & Up
2	16-76175	STUD (1-718")
3	16-8M0034454	STUD Comment: (6-3/4")
4	17-43044	PIN, Dowel
5	17-8M0036405	PIN (BEARING RACE)
6	27-11338	GASKET
7	8M0088723	COVER, STARTER MOTOR (UPPER)
8	10-73657	SCREW, (.312-18 x 1.50)
9	13-8M0204647	LOCKWASHER, (.312)
10	76867	COVER, STARTER MOTOR (LOWER)
11	10-815549	SCREW, .312-18 x 2.00
11A	23-99448	BUSHING
12	10-74824	SCREW, (.312-18 x 1.250), CRANKCASE TO CYLINDER BLOCK
13	1159-8454T2	END CAP ASSEMBLY (UPPER) Comment: SN# Merc-6073192/Mariner-6055033 & Up
14	25-54029	O-RING Comment: SN# Merc-6073192/Mariner-6055033 & Up
15	31-93496T	ROLLER BEARING Comment: SN# Merc-6073192/Mariner-6055033 & Up
16	26-41953	SEAL Comment: SN# Merc-6073192/Mariner-6055033 & Up
17	10-30225	SCREW WITH LOCKWASHER, (.312-18 x 1.00)
18	10-24220	SCREW, (.190-24 x .19)
19	22-38407	PLUG, (.500-14) (WATER JACKET)
20	16-15094	STUD (1-7/8")
21	16-8M0034435	STUD, (#10-32 x 1.00)
22	23-67269	SPACER
23	12-8M0204663	WASHER
24	12-72761	WASHER
25	11-816874	NUT
26	422482	BRACKET, FLYWHEEL COVER Comment: (CASTING #42114C)
27	10-8M0214943	SCREW, (.250-20 X 1.00)
28	1156-7809T1	END CAP ASSEMBLY (LOWER)
29	25-67207	O-RING Comment: (3-1/2" I.D.)
30	26-41953	SEAL
31	10-28636	SCREW, (.250-20 x .750)
32	13-26992	LOCKWASHER, (.250)
33	10-64022	SCREW, (.250-20 x 2.125)
34	11-64015	NUT, (.250-20)
35	26852	CAP
36	22-8M0180564	PLUG, (.250-18), CRANKCASE Comment: (NON-OIL INJECTION)
37	43453T	PLUG Comment: (NON-OIL INJECTION)
38	25-32509	O-RING, (.489 x .070), CRANKCASE PLUG Comment: (NON-OIL INJECTION)
39	10-41506	SCREW, (#10-32 X .44), PLUG TO CRANKCASE Comment: (NON-OIL INJECTION)

▶Cylinder Head (43 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
1	NLA	No Longer Available, Cylinder Head Comment: (DESIGN I)
2	27-41244T02	GASKET Comment: (DESIGN I)
3	10-668631	SCREW, (.375-16 X 2.5) Comment: (DESIGN I)
4	NLA	No Longer Available, Cover-Cylinder Comment: (DESIGN I)
5	27-65788	GASKET Comment: (DESIGN I)
6	10-74824	SCREW, (.312-18 x 1.250) Comment: (DESIGN I)
7	54-47483	J CLIP Comment: (DESIGN I)
8	75692	THERMOSTAT Comment: (DESIGN I)
9	27-8M0204714	GASKET Comment: (DESIGN I)
10	90390A1	COVER KIT Comment: (DESIGN I)
11	10-35386	SCREW, (.312-18 x 1.00) Comment: (1")(DESIGN I)
12	22-68728	FITTING Comment: (DESIGN I)
13	32-77653101	HOSE, (48.00 Inches Bulk) Comment: (DESIGN I)
14	22-687271	FITTING, (90 Degree) Comment: (DESIGN I)
15	61990	CABLE TIE, (14.00 Inches) Comment: (DESIGN I)
16	78799	TEMPERATURE SENDER, (19.50 Inch) Comment: (DESIGN I)
18	NLA	No Longer Available, Cover Comment: (DESIGN I)
19	86-45915	TERMINAL BLOCK Comment: (DESIGN I)
20	10-69079	SCREW, (#10-16 x .440) Comment: (DESIGN I)
21	15221A5	CYLINDER HEAD Comment: (1 PIECE DESIGN) (DESIGN II)
22	137151	RETAINER Comment: (USE WITH REF.#21) (DESIGN II)
23	10-98257	SCREW, (.312-18 x .500) Comment: (USE WITH REF.#21) (DESIGN II)
24	13536A7	TEMPERATURE SENSOR Comment: (USE WITH REF.#21) (DESIGN II)
25	NLA	No Longer Available, Cylinder Head Comment: (2 PIECE DESIGN) (DESIGN II)
26	27-96278	GASKET Comment: (2 PIECE DESIGN)(DESIGN II)
27	NLA	No Longer Available, Cover-Cylinder Comment: (2 PIECE DESIGN)(DESIGN II)
28	10-74824	SCREW, (.312-18 x 1.250) Comment: (2 PIECE DESIGN)(DESIGN II)
29	27-41247T01	GASKET Comment: (DESIGN II)
30	10-98534	SCREW, (.375-16 X 2.30) Comment: (DESIGN II)
31	12-25909	WASHER, (.406 x .812 x .065) Comment: (DESIGN II)
32	75692	THERMOSTAT Comment: (DESIGN II)
33	27-8M0204714	GASKET Comment: (DESIGN II)
34	90390A1	COVER KIT Comment: (DESIGN II)
35	10-35386	SCREW, (.312-18 x 1.00) Comment: (1" - QTY. OF 4 USED WITH REF. #21)(DESIGN II)
36	22-687271	FITTING, (90 Degree) Comment: (DESIGN II)
37	32-77653101	HOSE, (48.00 Inches Bulk) Comment: (DESIGN II)
38	22-68728	FITTING Comment: (DESIGN II)
39	54-816311T	CABLE TIE, (8.00 Inches) Comment: (DESIGN II)
40	97465	TEMPERATURE SENDER Comment: (DESIGN II)
41	96282	COVER Comment: ( NOT USED WITH REF.#21)(DESIGN II)
42	86-45915	TERMINAL BLOCK Comment: ( NOT USED WITH REF.#21) (DESIGN II)
43	10-69079	SCREW, (#10-16 x .440) Comment: ( NOT USED WITH REF.#21) (DESIGN II)

▶Driveshaft Housing and Exhaust Tube (46 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
--	17-43044	PIN, Dowel (.375 x .625) (Without Hole) Comment: (X-LONG)
1	1590-8343A8	DRIVESHAFT HOUSING ASSEMBLY Comment: (Gray)
2	16-74732	STUD Comment: (X-LONG SHAFT)
3	25067	BUMPER
4	10-898831	SCREW, (.500-20 x 6.00)
5	77327	MOUNT Comment: (HEAVY DUTY)
6	12-49339	WASHER, (.8125)
7	11-25096	NUT
8	88238A10	GROUND WIRE ASSEMBLY
9	54-8M0036782	CLAMP
10	10-66727	SCREW, (.312-18 x 1.250)
11	67077F1	COVER Comment: (GRAY)
12	10-88417	SCREW, (#12-24 x .620)
13	11-35521	NUT
14	67703	STRAP
15	10-67769	SCREW, (.375-24 X 4.00)
16	11-25269	NUT
17	12-73862	WASHER
18	11-29489	NUT
19	12-45176	WASHER, (.453 x .812 x .105)
20	11-8M0204653	NUT, (.437-20)
21	19-64649	PLUG
22	89743	EXHAUST TUBE Comment: SN# Merc-5363918/Mariner-5624878 & Up
23	66350001	SEAL (LOWER)
24	86027	SEAL (UPPER) Comment: SN# Merc-5363918/Mariner-5624878 & Up
25	32-8M0042790	TUBE Comment: (X-LONG SHAFT)
26	27-991734	GASKET
27	41945A6	PLATE ASSEMBLY Comment: SN# Merc-5363918/Mariner-5624878 & Up
28	707482	SEAL
29	68011	BRACKET
30	10-48408	SCREW, (#10-16 x .500)
31	17-43044	PIN, Dowel (.375 x .625) (Without Hole)
32	26-38970	SEAL
33	27-991772	GASKET
34	12-20553	WASHER
35	11-69254	NUT
36	41941T	EXHAUST DIFFUSER
37	27-782461	GASKET
38	16-66021	STUD
39	12-20533	WASHER
40	11-30506	NUT, (.250-28)
41	88238A10	GROUND WIRE ASSEMBLY
42	10-41508	SCREW, (.250-20 x .500)
43	10-90192	SCREW, (.250-20 x .750) Comment: (LATER MODELS)
44	NLA	No Longer Available, Boot Comment: SN# Merc-5363917 & Below

▶Exhaust Manifold and Exhaust Plate (27 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
1	27-904841	GASKET Comment: SN# Merc-53631918/Mariner-5624878 & Up
2	99169A1	PLATE Comment: SN# Merc-53631918/Mariner-5624878 & Up
3	26-814754	SEAL Comment: SN# Merc-53631918/Mariner-5624878 & Up
4	95067	COVER Comment: SN# Merc-53631918/Mariner-5624878 & Up
5	10-74824	SCREW, (.312-18 x 1.250) Comment: SN# Merc-53631918/Mariner-5624878 & Up
6	27-76636	GASKET Comment: SN# Merc-5363917 & Below
7	NLA	No Longer Available, Divider Plate Comment: SN# Merc-5363917 & Below
8	26-814754	SEAL Comment: SN# Merc-5363917 & Below
9	NLA	No Longer Available, Cover Comment: SN# Merc-5363917 & Below
10	10-35386	SCREW, (.312-18 x 1.00) Comment: SN# Merc-5363917 & Below
11	NLA	No Longer Available, Washer Comment: SN# Merc-5363917 & Below
29	27-991764	GASKET Comment: SN# Merc-6435503/Mariner-6435983 & Up
29A	27-8231422	GASKET Comment: SN# Merc-6435502/Mariner-6435982 & Below
30	41944A5	PLATE ASSEMBLY
31	22-996642	ELBOW, (90 Degree)
32	17-43044	PIN, Dowel (.375 x .625) (Without Hole)
33	707482	SEAL
34	680101	BRACKET
35	10-48408	SCREW, (#10-16 x .500)
36	12-20553	WASHER, (.406 x .734 x .063)
37	11-69254	NUT
38	23-27132	BUSHING
39	10-66727	SCREW, (.312-18 x 1.250)
40	10-68783	SCREW, (.312-18 x 2.50)
41	10-898833	SCREW, (.375-16 x 3.50)
42	25-12602002	GROMMET

▶Fittings and Hoses (29 parts)

Ref	OEM Part #	Part Name
1	21-426585	CHECK VALVE Comment: SN# Merc-6073191/Mariner-6055032 & Below
2	32-9938779	HOSE Comment: SN# Merc-6073191/Mariner-6055032 & Below
3	22-15133	FITTING Comment: SN# Merc-6073191/Mariner-6055032 & Below
4	54-23567	CLIP Comment: SN# Merc-6073191/Mariner-6055032 & Below
5	10-62568	SCREW, (#10-16 x .375) Comment: SN# Merc-6073191/Mariner-6055032 & Below
6	8M0084613	C WASHER Comment: SN# Merc-6073191/Mariner-6055032 & Below
7	21-64871A2	CHECK VALVE Comment: SN# Merc-5363918/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
8	22-79790	FITTING Comment: SN# Merc-6073191/Mariner-6055032 & Below
9	NLA	No Longer Available, Washer Comment: SN# Merc-6073191/Mariner-6055032 & Below
10	NLA	No Longer Available, Hose-Reed Block Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
11	32-892024122	TUBING, (20.00 Feet Bulk) Comment: (.092 I.D.) SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
12	32-9072925	HOSE Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
13	22-996642	ELBOW, (90 Degree), REED BLOCK Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
14	22-8585531	CONNECTOR, REED BLOCK Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
15	22-782792	ELBOW FITTING, REED BLOCK (45 DEGREES) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
16	NLA	No Longer Available, Elbow-Reed block (1/16" Barb - 90 Degree) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
17	NLA	No Longer Available, Tee-Reed Block (1/16" Barb) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
18	21-426982	CHECK VALVE Comment: (PRESS-IN - 13/16") SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
19	21-426585	CHECK VALVE (THREADED/STRAIGHT) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
20	22-15133	FITTING, BLEED HOSE PRESS- IN) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
21	22-56759	FITTING, Press-In, BLEED HOSE (PRESS-IN) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
22	22-54090	ELBOW, PULSE HOSE Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
23	22-59169003	FITTING, Tee, BLEED HOSE Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6435502/Mariner-6435982
24	32-892024122	TUBING, (20.00 Feet Bulk) Comment: SN# Merc-6435503/Mariner-6435983 & Up
25	32-9072925	HOSE Comment: SN# Merc-6435503/Mariner-6435983 & Up
26	22-997511	FITTING, PULSE HOSE (90 DEGREES) Comment: SN# Merc-6435503/Mariner-6435983 & Up
27	21-426982	CHECK VALVE Comment: (Press-In 13/16 Inch) SN# Merc-6435503/Mariner-6435983 & Up
28	22-15133	FITTING, BLEED HOSE (PRESS-IN) Comment: SN# Merc-6435503/Mariner-6435983 & Up
29	22-56759	FITTING, Press-In, BLEED HOSE (PRESS-IN) Comment: SN# Merc-6435503/Mariner-6435983 & Up

▶Flywheel, Starter Motor and Ignition Coils (35 parts)

Ref	OEM Part #	Part Name
1	79918A1	COVER KIT
2	79022	MARKER
3	10-37572	SCREW, (.190-32 x .380)
4	12-72761	WASHER
5	19-89219001	PLUG
6	19-45907	PLUG, (Yellow)
7	11-52901	NUT, (.625-18)
8	12-33001	WASHER
9	271-859238A9	FLYWHEEL Comment: (Measure the stator lamination thickness: 5/8 In. Order 257-7555A17)
10	10-32417	SCREW, (.250-28 x .625)
11	10-68997	SCREW, (.3125-24 X .75)
12	398-5454A35	STATOR Comment: (USE W/VOLTAGE REGULATOR-15AMP)(STATOR LAMINATION THICKNESS: 5/8 IN.)
13	10-19926100	SCREW, (#10-24 x 1.00)
14	10,13-26996	LOCKWASHER,
15	96455A9	TRIGGER PLATE ASSEMBLY
16	50-86976	STARTER MOTOR Comment: (9 TOOTH PINION)
17	23-8M0034918	COLLAR
18	8M0043376	STOP
19	13-26992	LOCKWASHER, (.250)
20	11-20890	NUT, (.250-20)
21	84-93389A5	WIRE, (Yellow)(6.50 Inches)
22	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) SS
23	84-93388A1	CABLE ASSEMBLY, Black
24	339-832757A4	IGNITION COIL ASSEMBLY Comment: (NAVY BLUE)
25	67614	COVER
26	10-88447	SCREW, (.190-32 x 1.62) (1-5/8")
27	12-30164	WASHER, (.192 x .375 x .0312)
28	10-32,11-45076	NUT,
29	84-88807A6	WIRE, (3.50 Inches) Black
30	10-68513	SCREW, (#10-32 x .375)
31	84-813715A1	LEAD WIRE
32	85-63709A1	BOOT/TERMINAL KIT
33	33-13686Q	SPARK PLUG Comment: (NGK-BU8H)
34	84-69739A2	HARNESS, COIL TO SWITCH BOX Comment: (#1, 3 & 5)
35	23-56774	SPACER

▶Fuel Pump(Design I) (42 parts)

Ref	OEM Part #	Part Name
-	89031A2	DIAPHRAGM ASSEMBLY
2	1395-6232	FITTING, FUEL INLET - UPPER AND LOWER
3	22-70007	FITTING, FUEL INLET - MIDDLE
4	27-904301	GASKET Comment: SN# Merc-5464486/Mariner 5875389 THRU Merc-6073191/Mariner 6055032
5	11-8M0207775	NUT, CARBURETOR MOUNTING
6	32-8M0108355	FUEL LINE, (57.00 Inches Bulk), CARBURETOR TO FUEL PUMP
7	54-68424	CLAMP, FUEL HOSE
8	13453A1	FUEL PUMP ASSEMBLY Comment: SN# Merc-5363918/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
9	21-30430A8	CHECK VALVE ASSEMBLY
10	89031A2	DIAPHRAGM ASSEMBLY
11	NSS	NOT SOLD SEPARATE, Gasket
12	NSS	NOT SOLD SEPARATE, Gasket
13	NSS	NOT SOLD SEPARATE, Gasket
14	NSS	NOT SOLD SEPARATE, Gasket
15	35-59072	SCREEN
16	25-35480	O-RING, (1.237 x .103)
17	NSS	NOT SOLD SEPARATE, Gasket
18	23004	RETAINER
19	10-43725	SCREW, (#6-32 X .38)
20	67623	BASE
21	86449	CHAMBER Comment: SN# Merc-5363918/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
22	35-91078A1	COVER, FUEL FILTER
23	10-89766	SCREW, (#10-32 x .620)
24	10-88447	SCREW, (.190-32 x 1.62)
25	10,13-26996	LOCKWASHER,
26	22-67620	FITTING, FUEL OUTLET
27	24-86207	SPRING
28	86026	RETAINER
29	86252	CAP
30	54-68424	CLAMP
31	32-8M0108355	FUEL LINE, (57.00 Inches Bulk) Comment: SN# Merc-5875304/Mariner-5875389 THRU Merc-6073191/Mariner-6055032
31A	22-920071	FITTING, (.250-18) (90 DEGREES)
31B	92037	SEAL
31C	10-69224	SCREW (1-1/4")
31D	13-26992	LOCKWASHER, (.250)
32	30186	ADAPTOR Comment: SN# Merc-5875304/Mariner-5875389 THRU Merc-6073191/Mariner-6055032
33	30187	STEM
34	25-16524	O-RING
35	24-30189	SPRING
36	30188	WASHER
47	24-89808	SPRING
48	22-8M0123050	FITTING, (45 Degree Elbow)

▶Fuel Pump(Design II) (59 parts)

Ref	OEM Part #	Part Name
-	89031A4	DIAPHRAGM Comment: SN# Merc-6357230/Mariner-6356980 & Up
1	42859A2	ENRICHNER VALVE
2	54-633003	CLAMP
3	10-73286	SCREW, (.250-20 x .500)
4	1395-7901	ELBOW Comment: (90 DEGREES)
7	27-67751	GASKET
8	11-8M0207775	NUT
9	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
10	54-68424	CLAMP
11	13453A2	FUEL PUMP Comment: SN# Merc-6357230/Mariner-6356980 & Up
12	21-30430A12	CHECK VALVE KIT Comment: SN# Merc-6357230/Mariner-6356980 & Up
12A	17-26618	PIN Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6357229/Mariner-6356979
12B	21-42657A3	CHECK VALVE Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6357229/Mariner-6356979
13	89031A4	DIAPHRAGM Comment: SN# Merc-6357230/Mariner-6356980 & Up
14	NSS	NOT SOLD SEPARATE, Gasket
15	NSS	NOT SOLD SEPARATE, Gasket
16	NSS	NOT SOLD SEPARATE, Gasket
17	NSS	NOT SOLD SEPARATE, Gasket
18	35-59072	SCREEN
19	25-35480	O-RING, (1.237 x .103)
20	NSS	NOT SOLD SEPARATE, GAsket
21	22-70007	FITTING (45 DEGREES)
22	23004	RETAINER
23	10-43723	SCREW, (#6-32 X .50)
24	90728	BASE
25	88848	PULSE CHAMBER
26	35-91078A1	COVER Comment: (1 HOLE)
27	10-89766	SCREW, (#10-32 x .620)
28	10-73013	SCREW, 10-32 x 1.50
29	10,13-26996	LOCKWASHER,
30	22-19688	FITTING
31	24-86207	SPRING
32	86026	RETAINER
33	86252	CAP
34	32-89020	FUEL LINE Comment: (FITTING ON 1 END)
35	22-63187	FITTING, Barb (.250-18) Comment: (STRAIGHT)
36	30186	ADAPTOR
37	30187	STEM
38	25-16524	O-RING
39	24-30189	SPRING
40	30188	WASHER
41	10-76596	SCREW, (.250-20 x 1.250)
42	42859A2	ENRICHNER VALVE Comment: (USE WHERE APPLICABLE)
43	22-90275	CONNECTOR (BOTTOM) Comment: (USE WHERE APPLICABLE)
44	22-67902	CONNECTOR (SIDE) Comment: (USE WHERE APPLICABLE)
45	90345	BRACKET Comment: (USE WHERE APPLICABLE)
46	10-89075	SCREW Comment: (USE WHERE APPLICABLE)
47	10-98253	SCREW, (.250-20 x .500) Comment: (USE WHERE APPLICABLE)
48	13-26992	LOCKWASHER, (.250) Comment: (USE WHERE APPLICABLE)
49	86-45915	TERMINAL BLOCK
50	10-69079	SCREW, (#10-16 x .440)
51	32-9938779	HOSE
52	32-9912688	TUBING, (36.00 Inches Bulk)
53	92037	SEAL
54	35-816296Q03	FILTER, Fuel
55	54-26404	CLAMP
56	8M0084613	C WASHER
57	10,13-26996	LOCKWASHER,
58	10-78291	SCREW, (.190-24 X .50)

▶Fuel Pump(Design III) (Square Fuel Pump) (50 parts)

Ref	OEM Part #	Part Name
-	21-857005A1	DIAPHRAGM KIT
4	22-70007	FITTING (MIDDLE)
5	1395-7900	TEE FITTING (MIDDLE)
6	1395-7901	ELBOW (UPPER/LOWER)
7	27-67751	GASKET
8	11-8M0207775	NUT
9	42859A2	ENRICHNER VALVE
10	54-633001	CLAMP
11	10-73286	SCREW, (.250-20 x .500)
12	86-45915	TERMINAL BLOCK
13	10-35519	SCREW, (#10-16 X .50)
14	32-892024122	TUBING, (20.00 Feet Bulk)
15	32-9912688	TUBING, (36.00 Inches Bulk)
16	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
17	15930A15	FUEL PUMP ASSEMBLY
18	21-857005A1	DIAPHRAGM KIT
19	NSS	NOT SOLD SEPARATE, Check Valve-Rubber
20	NSS	NOT SOLD SEPARATE, Gasket-Boost
21	NSS	NOT SOLD SEPARATE, Diaphragm
22	NSS	NOT SOLD SEPARATE, Gasket-Pulse
23	NSS	NOT SOLD SEPARATE, Spring
24	NSS	NOT SOLD SEPARATE, Cap
25	NSS	NOT SOLD SEPARATE, Check Valve
26	NSS	NOT SOLD SEPARATE, Retainer
27	NSS	NOT SOLD SEPARATE, Spring
28	NSS	NOT SOLD SEPARATE, Cap
29	27-8M0204705	GASKET
30	22-14868	FITTING
31	22-19688	FITTING
32	144303	BASE
33	987752	PLATE
34	22-56800	PLUG, Pipe (.0625-27)
35	22-15979	FITTING
36	10-16452	SCREW, (#12-24 x 2.00)
37	10-4000310	SCREW, (M5 x 40)
38	12-4002314	WASHER
39	32-9072925	HOSE
40	22-997511	FITTING (90 DEGREES)
41	32-8M0108349	TUBING
42	54-816311T	CABLE TIE, (8.00 Inches)
43	22-14866	ELBOW
44	30186	ADAPTOR
45	30187	STEM
46	24-30189	SPRING
47	25-16524	O-RING
48	30188	WASHER
49	10-69067	SCREW, (.25-20 X 1.375)
50	92037	SEAL
51	22-424253	TEE
52	35-816296Q03	FILTER, Fuel

▶Gear Housing(Drive - Without a Driveshaft Nut) (52 parts)

Ref	OEM Part #	Part Name
-	26-55682A1	SEAL KIT, Gear Housing
0	1647-9148T91	GEAR HOUSING Comment: (X-LONG - GRAY)
1	1647-8688T10	GEAR HOUSING Comment: (GRAY-BASIC) (CASTING # 1647-8675C)
2	22-85822A10	CONNECTOR ASSEMLBY
3	66884	INSERT Comment: (PORT)(EARLY MODELS)
4	10-76156	SCREW, (#10-32 x 1.88) Comment: (EARLY MODELS)
5	10-32,11-859124	NUT, Comment: (EARLY MODELS)
6	17-43044	PIN, Dowel
7	16-78639	STUD Comment: (9"-X-LONG)
8	16-74730	STUD Comment: (7-1/16" - X-LONG)
9	16-8M0034463	STUD, (.312 x 3.38)
10	16-306671	STUD, (.250-20/.250-28 x 3.125)
11	31-35934A1	ROLLER BEARING
12	23-98621	SCREW, (.375-16 X .75)
13	45-41509A2	DRIVESHAFT Comment: (X-LONG)
14	24-34576	SPRING
15	17-30545	PIN
16	NSS	NOT SOLD SEPARATE, Pinion Gear Comment: (PART OF 43-43491A1)
17	11-35921	NUT, (.625-18)
18	15-57007A1	SHIM
19	31-53079A1	TAPERED ROLLER BEARING ASSEMBLY
20	27-8M0214962	GASKET
21	25-8M0214923	O-RING, (1.984 x .139)
22	46-96146A6	WATER PUMP BASE
23	26-89238	OIL SEAL
24	26-16977	OIL SEAL
24A	17-35973	PIN, Dowel Comment: (EARLY MODELS)
25	27-8M0090319	GASKET
26	8M0204677	FACE PLATE
27	27-858524	GASKET
28	46-96148T1	WATER PUMP BODY ASSEMBLY
29	48752T	INSERT
30	26-38970	SEAL
31	47-89984T4	IMPELLER
32	28-8M0214992	KEY
33	10-8M0215009	SCREW, (#14-8 x 2.25)
34	12-8M0204649	WASHER, (.281 x .500 x .060)
35	11-35888	NUT, (.250-28)
36	12-36001	WASHER
37	11-826709111	NUT, (.312-24)
38	25-8M0214918	RING
39	23-29804T	SLEEVE
40	789022	SHAFT
41	53-29641	E RING
42	53-78907	RETAINING RING
43	25-25439	O-RING, (.862 x .103)
44	23-77631A2	BUSHING ASSEMBLY
45	26-8M0204708	OIL SEAL
46	12-77674	WASHER
47	10-79953Q04	SCREW, (.375-16 x .250)
48	22-8M0058389	SCREW, Magnetic
49	12-191833	WASHER, Fiber

▶Gear Housing(Driveshaft)(With a Driveshaft Nut) (48 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
0	1647-9148T91	GEAR HOUSING Comment: (X-LONG - GRAY)
1	1647-9148T47	GEAR HOUSING ASSEMBLY Comment: (GRAY)(CASTING #1647-9147C)
2	22-85822A10	CONNECTOR ASSEMLBY
3	17-43044	PIN, Dowel
4	16-78639	STUD Comment: (9"-X-LONG)
5	16-74730	STUD Comment: (7-1/16" - X-LONG)
6	16-8M0034463	STUD, (.312 x 3.38)
7	16-306671	STUD, (.250-20/.250-28 x 3.125)
8	31-42647A1	BEARING ASSEMBLY, Roller
9	23-43998	SLEEVE
11	45-897625T	DRIVESHAFT Comment: (X-LONG)
12	NSS	NOT SOLD SEPARATE, Pinion Gear Comment: (PART OF 43-44104A2)
13	12-92721	WASHER
14	11-35921	NUT, (.625-18)
15	15-42637A1	SHIM SET
16	31-8M0146566	BEARING, Roller
17	8245191	NUT
18	46-8M0077147	WATER PUMP BASE ASSEMBLY
19	27-8M0204678	GASKET
20	25-38099	O-RING Comment: (2.109 I.D.)
21	26-89238	OIL SEAL
22	26-16977	OIL SEAL
23	27-8M0090319	GASKET
24	27-858524	GASKET
25	8M0204677	FACE PLATE
26	46-96148T1	WATER PUMP BODY ASSEMBLY
27	48752T	INSERT
28	26-38970	SEAL
29	47-89984T4	IMPELLER
30	28-8M0214992	KEY
31	10-8M0215009	SCREW, (#14-8 x 2.25)
32	12-8M0204649	WASHER, (.281 x .500 x .060)
33	11-8267119	NUT, (.250-28)
34	12-36001	WASHER
35	11-13436	NUT
36	25-8M0214918	RING
37	23-29804T	SLEEVE
38	789022	SHAFT
39	53-29641	E RING
40	53-78907	RETAINING RING
41	25-25439	O-RING, (.862 x .103)
42	23-77631A2	BUSHING ASSEMBLY
43	26-8M0204708	OIL SEAL
44	12-77674	WASHER
45	10-79953Q04	SCREW, (.375-16 x .250)
46	22-8M0058389	SCREW, Magnetic
47	12-191833	WASHER, Fiber

▶Gear Housing(Prop - Without a Driveshaft Nut) (38 parts)

Ref	OEM Part #	Part Name
-	26-55682A1	SEAL KIT, Gear Housing
0	1647-9148T91	GEAR HOUSING Comment: (X-LONG - GRAY)
1	1647-8688T10	GEAR HOUSING Comment: (GRAY-BASIC) (CASTING # 1647-8675C)
50	89594A1	FOLLOWER
51	789562	SHIFT CAM
52	79911A1	ROD
53	24-79910	SPRING
54	12-78910	WASHER
55	17-8M0084245	PIN
56	15-47397A1	SHIM SET
57	31-78172A1	BEARING ASSEMBLY, Tapered Roller
58	43-43491T1	FORWARD GEAR ASSEMBLY
59	31-73363T	ROLLER BEARING
60	52-823174T	RATCHET
61	17-8M0084243	PIN, Cross
62	17-78909	PIN, Detent
63	24-78962	SPRING
64	44-94148	PROPELLER SHAFT
65	NSS	NOT SOLD SEPARATE, Reverse Gear Comment: (PART OF 43-43491A1)
66	681001	RING, Thrust
67	30-88957T	BEARING
68	25-8M0214920	O-RING
69	43567T1	BEARING CARRIER ASSEMBLY
70	31-30956T	BEARING, Needle
71	26-8M0204670	SEAL
72	26-8M0205729	SEAL, Oil
73	28-30281	KEY
74	14-79447	TAB WASHER
75	8M2011027	RETAINER
76	97-31640Q4	TRIM TAB ASSEMBLY
77	10-66024	SCREW, (.437-14 x 1.75)
78	12-45176	WASHER, (.453 x .812 x .105)
79	11-8M0204653	NUT, (.437-20)
80	10-74727	SCREW, (.375-16 X 6.00) Comment: (X-LONG)
81	12-835467Q01	THRUST HUB
82	12-31211Q03	WASHER, Splined
83	14-816629Q	TAB WASHER
84	11-52707Q1	NUT KIT, Propeller

▶Gear Housing(Propeller Shaft) (With a Driveshaft Nut) (38 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
0	1647-9148T91	GEAR HOUSING Comment: (X-LONG-GRAY)
1	1647-9148T47	GEAR HOUSING ASSEMBLY Comment: (GRAY-BASIC)(CASTING #1647-9147C)
48	89594A1	FOLLOWER
49	789562	SHIFT CAM
50	79911A1	ROD
51	24-79910	SPRING
52	12-78910	WASHER
53	17-8M0084245	PIN
54	15-47397A1	SHIM SET
55	31-78172A1	BEARING ASSEMBLY, Tapered Roller
56	43-44104T2	FORWARD GEAR ASSEMBLY
57	31-73363T	ROLLER BEARING Comment: (1.313 O.D.)
58	52-823174T	RATCHET
59	17-8M0084243	PIN, Cross
60	17-78909	PIN, Detent
61	24-78962	SPRING
62	44-94148	PROPELLER SHAFT
63	NSS	NOT SOLD SEPARATE, Reverse Gear Comment: (PART OF 43-44104AA2)
64	681001	RING, Thrust
65	30-88957T	BEARING
66	25-8M0214920	O-RING
67	43567T1	BEARING CARRIER ASSEMBLY
68	31-30956T	BEARING, Needle
69	26-8M0204670	SEAL
70	28-30281	KEY
71	14-79447	TAB WASHER
72	8M2011027	RETAINER
73	97-31640Q4	TRIM TAB ASSEMBLY
74	10-66024	SCREW, (.437-14 x 1.75)
75	10-45716	SCREW, (10-32 X .9375)
76	11-8M0204653	NUT, (.437-20)
77	10-74727	SCREW, (.375-16 X 6.00) Comment: (X-LONG)
78	12-835467Q01	THRUST HUB
79	12-31211Q03	WASHER, Splined
80	14-816629Q	TAB WASHER
81	11-52707Q1	NUT KIT, Propeller
82	13-423511	LOCKWASHER, Toothed

▶Hydraulic Pump (20 parts)

Ref	OEM Part #	Part Name
-	99073A2	OVERHAUL REPAIR KIT
1	89492T	ADAPTOR
2	803852	COUPLING
3	96598A1	MANUAL RELEASE Comment: (INCLUDES 3 O-RINGS)
4	89495	PUMP (INCLUDES SCREWS)
5	35-89496	FILTER
6	25-89498	O-RING
7	25-89497	O-RING
8	89499	DIPSTICK
9	90587T	RESERVOIR
10	10-90588	SCREW (INCLUDES O-RING)
11	16-90590	THRU STUD Comment: (LONG)
12	89484	END FRAME
13	89485	ARMATURE
14	12-89482	WASHER
15	89486	FIELD AND FRAME
16	89487	BRUSH CARD
17	89488	END FRAME
18	10-89489	THRU BOLT Comment: (4-9/16")
19	11-89481	NUT

▶Hydraulic Pump and Mounting Brackets (41 parts)

Ref	OEM Part #	Part Name
1	823653A9	HYDRAULIC PUMP
2	90318	BRACKET
3	10-90285	SCREW, (.312-18 x .625)
4	12-56720	WASHER, (.330 x .750 x .060)
5	10-32,11-8M0204718	NUT,
6	86-45915	TERMINAL BLOCK
7	10-62568	SCREW, (#10-16 x .375)
8	84-79138A9	CABLE ASSEMBLY, Black (NEGATIVE) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
9	88-8M0085705	CIRCUIT BREAKER (20 AMP.) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
10	10-8M0113176	SCREW, (#10-24 x .375) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
11	10-32,11-45076	NUT, Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
12	84-87379A5	WIRE Comment: (RED - 5-1/2")
13	84-79147A3	HARNESS ASSEMBLY Comment: (W/FUSE HOLDER)
14	88075	RETAINER
15	8M0185622	SOLENOID STARTER Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
16	10-41508	SCREW, (.250-20 x .500)
17	10,13-26996	LOCKWASHER,
18	10-32,11-68219	NUT,
19	13-8M0204647	LOCKWASHER, (.312)
20	11-8M0204668	NUT, (.312-18)
21	85-861680	BOOT Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
21A	46265	BOOT
22	94275	LINK Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
23	84-86322A15	CABLE ASSEMBLY, (5.50 Inches) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
24	84-79139A12	CABLE ASSEMBLY, Red (POSITIVE) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
25	88-79023T10	FUSE ASSEMBLY, (110 Ampere) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
26	12-96457	WASHER Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
27	11-21825	NUT, (.250-28) Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc/Mariner-6625220
28	87760T	PLATE
29	10-39349	SCREW, (.312-18 x .750)
30	13-8M0204647	LOCKWASHER, (.312)
31	10-90271	SCREW, (.375-16 x .62)
32	13-58643	LOCKWASHER, (.375)
33	87762	BRACKET
34	10-31830	BOLT, (.375-24 x 1.75)
35	13-58643	LOCKWASHER, (.375)
36	11-46335	NUT, (.375-24)
37	22-77366	FITTING Comment: (3/16 Inch Flare) SN# Merc-USA-5464485/AUS-8061769/Mariner-5875388 & Below
38	32-67742	HOSE (STARBOARD) Comment: SN# Merc-USA-5464485/AUS-8061769/Mariner-5875388 & Below
39	84-89017A1	TRIM SENDER HARNESS Comment: SN# Merc-USA-5464485/AUS-8061769/Mariner-5875388 & Below
40	54-75343	CLAMP Comment: SN# Merc-USA-5464485/AUS-8061769/Mariner-5875388 & Below

▶Hydraulic Pump(S/N-Mercury-5363917 & Below) (46 parts)

Ref	OEM Part #	Part Name
-	92975A32	HYDRAULIC PUMP
1	92975A32	HYDRAULIC PUMP
2	25-48171	O-RING, (.364. x .070)
3	69582A2	CONTROL VALVE
4	10-69697	SCREW, (.250-28 x 1.50)
5	13-26992	LOCKWASHER, (.250)
6	89-67458A7	SOLENOID (INCLUDES 25-69756 O-RING)
7	10-28636	SCREW, (.250-20 x .750)
8	13-26992	LOCKWASHER, (.250)
9	10,13-26996	LOCKWASHER,
10	10-32,11-68219	NUT,
11	32-67742	HOSE Comment: (STARBOARD)
12	55992	JUMPER WIRE Comment: (BLACK)
13	32988	BATTERY LEAD Comment: (NEGATIVE)
14	87762A04	TRIM PUMP MOUNTING BRACKET KIT
15	10-69698	BOLT, (.375-24 X 3.50)
16	13-58643	LOCKWASHER, (.375)
17	11-46335	NUT, (.375-24)
18	71976	MOUNTING PLATE
19	10-37562	SCREW, (.312-18 x 1.00)
20	13-8M0204647	LOCKWASHER, (.312)
21	11-8M0204668	NUT, (.312-18)
22	10-39349	SCREW, (.312-18 x .750)
23	84-68259A1	HARNESS
24	84-68260A1	HARNESS
25	54-22627	CLIP
26	10-37655	SCREW, (#10-32 x .500)
27	8M0084613	C WASHER
28	68037	BRACKET
29	10,13-26996	LOCKWASHER,
30	10-32,11-68219	NUT,
31	86-638131	TERMINAL BLOCK MARINER
32	10-37655	SCREW, (#10-32 x .500)
33	10-62568	SCREW, (#10-16 x .375)
34	68036	STRAP
35	10-38601	SCREW, (.250-28 x 1.250)
36	13-26992	LOCKWASHER, (.250)
37	11-29598	NUT, (.250-28)
38	36901	BUMPER
39	89-853654A1	STARTER SOLENOID
40	10,13-26996	LOCKWASHER,
41	10-32,11-68219	NUT,
42	13-8M0204647	LOCKWASHER, (.312)
43	11-8M0204668	NUT, (.312-18)
44	46265	BOOT
45	54-75343	CLAMP

▶Instrumentation (28 parts)

Ref	OEM Part #	Part Name
1	79-895283Q43	TACHOMETER
2	79101T	BRACKET
3	88-72729	LIGHT BULB
4	88-79888	SOCKET, Light Bulb
5	8-32,11-26419	NUT,
6	84-86323A5	CABLE ASSEMBLY, (1.50 Feet-Purple)
7	79-895292Q41	TRIM GAUGE
8	79480	BRACKET
9	88-72729	LIGHT BULB
10	88-79888	SOCKET, Light Bulb
11	8-32,11-26419	NUT,
12	8,13-26995	LOCKWASHER,
13	84-86396A8	HARNESS ASSEMBLY, Tachometer (5.00 Feet)
14	68878A6	ALARM HORN AND WIRE ASSEMBLY
15	68879	COVER
16	23-8M0084588	SPACER
17	12-24676	WASHER, (.200 x .440 x .032)
18	10-35401	SCREW, (#10 x 1.00)
19	79-895287Q41	TEMPERATURE GAUGE
20	88-72729	LIGHT BULB
21	88-79888	SOCKET, Light Bulb
22	12-26427	WASHER
23	79480	BRACKET
24	8-32,11-26419	NUT,
25	84-88032A3	CABLE ASSEMBLY, (23.00 Feet-Tan/Blue)
26	12415	TEMPERATURE SENDER
27	12419	COVER
28	19-12431T	PLUG

▶Oil Injection Components (42 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	12430A4	SENSOR ASSEMBLY
2	10-48409	SCREW, (#10-16 x .625)
3	41470A27	WARNING MODULE ASSEMBLY
4	12-38833	WASHER
5	10-690201	SCREW, (#10-32 x .875)
6	815699T	OIL PUMP ASSEMBLY
7	10-41507	SCREW, (#10-32 x 1.120)
8	193855	LINK ASSEMBLY
9	23-41429A2	BEARING ASSEMBLY
10	43-14563	DRIVEN GEAR
12	32-82381335	TUBING, (8.00 Inch)
13	21-424811	CHECK VALVE (NOT USED W/SQUARE FUEL PUMP)
14	1257-87421	TANK
15	36-43298A2	CAP ASSEMBLY
16	27-11009	GASKET Comment: (OLD DESIGN)
17	816190A4	ADAPTOR HOUSING ASSEMBLY
18	27-11009	GASKET Comment: (OLD DESIGN)
19	32-99802	TUBE
20	NLA	No Longer Available, Quick Disconnect Kit Comment: (Order Parts Separately)
21	32-99439	HOSE, (114.00 Inches)
22	12540A3	HOUSING
23	12242A1	LATCH
24	21-8781051	FITTING (CRANKCASE)
25	994436	OIL RESERVOIR
26	10-690201	SCREW, (#10-32 x .875)
27	12-42118	WASHER
28	25-42117	GROMMET
29	23-42116	BUSHING
30	32-82381455	TUBING
31	36-43300A9	CAP ASSEMBLY
32	27-43307T	GASKET
33	8M0187298	FLOAT ASSEMBLY
34	11-99265	PUSHNUT
35	54-415821	CLAMP (SMALL)
36	54-415823	CLAMP (LARGE)
37	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
38	22-42425	TEE
39	32-9072925	HOSE
40	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
41	10-42813	SCREW
42	25-11379	O-RING

▶Power Trim Components (48 parts)

Ref	OEM Part #	Part Name
1	99659A22	MANIFOLD ASSEMBLY Comment: (GRAY)
2	22-56800	PIPE PLUG, MANIFOLD
3	41493A7	TRIM CYLINDER ASSEMBLY Comment: (GRAY)
4	41492A1	GUIDE ASSEMBLY
5	25-41478A1	REPAIR KIT
6	41482A2	CHECK VALVE KIT
7	1100-8M0021648	GUIDE ASSEMBLY, TRIM ROD
8	878413A1	PISTON AND ROD ASSEMBLY, PORT
9	35-12184A1	TRIM FILTER ASSEMBLY
10	878414T01	PISTON AND ROD ASSEMBLY, STARBOARD
11	17-821539	PIN, Groove, TRIM CYLINDER (UPPER)
12	893929A01	VALVE ASSEMBLY
12A	53-815949001	E RING
13	10-4000327	SCREW, (M6 x 14), COVER
14	12-4002315	WASHER, COVER SCREW
15	99642	COVER, MANIFOLD
16	25-48462A4	O-RING KIT
17	19-99609A1	PLUG ASSEMBLY
18	99641A1	SHAFT ASSEMBLY
19	22-56800	PIPE PLUG, SHAFT
20	10-4008820	SCREW, (M6 x 20), PUMP AND MOTOR
21	13-400256	LOCKWASHER, (M6)
22	826729A10	PUMP AND MOTOR
23	99625002	SHAFT, UPPER
24	97-818298Q1	ANODE ASSEMBLY
25	10-8M0204707	SCREW, (M6 x 25), ANODE
26	12-8M0204649	WASHER, (.281 x .500 x .060), ANODE SCREW
27	8M0045383	STRIKER PLATE, TRIM SHAFT
28	13-58643	LOCKWASHER, (.375)
29	11-46335	NUT, (.375-24)
30	84-17201A1	CONTROL HARNESS ASSEMBLY, (6.00 Inches) Comment: (2 WIRE)
31	84-87379A14	WIRE ASSEMBLY, (2.750 Inches) Comment: (RED)
32	8M0185622	SOLENOID STARTER
33	10-28635	SCREW, (.250-20 x .620)
34	8-32,11-26419	NUT,
35	13-26992	LOCKWASHER, (.250)
36	11-94330	NUT, (.250-20)
37	85-97861	INSULATOR
38	54-22875	CLIP, PUMP WIRE
39	8M0084613	C WASHER, CLIP SCREW
40	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
41	17-878267	PIN, Groove, TRIM CYLINDER (LOWER)
42	10-4000377	SCREW, (M10 x 30), MANIFOLD
43	13-400258	LOCKWASHER, SS, MANIFOLD SCREW
44	11-8267098	NUT, (.250-20)
45	11051	BRACKET
46	10-73286	SCREW, (.250-20 x .500)
47	13-26992	LOCKWASHER, (.250)

▶Power Trim Pump(Eaton Rectangular Motor) (9 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	12659	FRAME AND FIELD KIT
2	12665	BRUSH SPRING KIT
3	13506	BRUSH CARD KIT
4	12662	PUMP AND END FRAME KIT
5	126631	PUMP SEAL KIT
6	12660	END FRAME KIT
7	12661	ARMATURE KIT
8	12664	THRU BOLT KIT

▶Power Trim Pump(Prestolite Round Motor) (13 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	826729A10	CARTRIDGE PUMP ASSEMBLY
2	392-8996	O-RING KIT
3	392-8986	ARMATURE
4	NLA	No Longer Available, Frame and Field
5	392-8992	O-RING
6	392-8993	SPRING KIT
7	392-8988	HEAD
8	392-8989	BRUSH KIT
9	392-8994	THRU BOLT KIT
10	392-8985	CLAMP
11	392-8990	NUT
12	392-8991	O-RING

▶Reed Block (29 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
1	NLA	No Longer Available, Housing-Reed Block Comment: (VERTICAL 5 PETAL REED)
2	10-69093	SCREW, (.25-20 X 1.50) Comment: (VERTICAL 5 PETAL REED)
3	27-935361	GASKET Comment: (VERTICAL 5 PETAL REED)
4	27-657443	GASKET Comment: (VERTICAL 5 PETAL REED)
5	75953	REED BLOCK Comment: (VERTICAL 5 PETAL REED)
6	34-75362A1	REED ASSEMBLY Comment: (VERTICAL 5 PETAL REED)
7	34-67298	REED STOP Comment: (VERTICAL 5 PETAL REED)
8	10-76497	SCREW (3/8") Comment: (VERTICAL 5 PETAL REED)
9	10-65746	SCREW, (.250-20 x .750) Comment: (VERTICAL 5 PETAL REED)
10	16-270372	STUD, (.250-28 x 1.125), CARB MOUNTING Comment: (VERTICAL 5 PETAL REED)
11	87628F2	REED BLOCK HOUSING Comment: (HORIZONTAL 7 PETAL REED)
12	10-28668	SCREW, (.250-20 x .875) Comment: (HORIZONTAL 7 PETAL REED)
13	27-127754	GASKET Comment: (HORIZONTAL 7 PETAL REED)
14	87692T3	BLOCK Comment: (HORIZONTAL 7 PETAL REED)
15	34-19719A1	REED ASSEMBLY Comment: (HORIZONTAL 7 PETAL REED)
16	903911	REED CLAMP Comment: (HORIZONTAL 7 PETAL REED)
17	10-57583T	SCREW, (#8-32 x .375) Comment: (HORIZONTAL 7 PETAL REED)
18	16-270372	STUD, (.250-28 x 1.125), CARB MOUNTING Comment: (HORIZONTAL 7 PETAL REED)
19	43517T	HOUSING Comment: (HORIZONTAL 5 PETAL REED)
20	10-28668	SCREW, (.250-20 x .875) Comment: (HORIZONTAL 5 PETAL REED)
21	27-967611	GASKET Comment: (HORIZONTAL 5 PETAL REED)
22	75953	REED BLOCK Comment: (HORIZONTAL 5 PETAL REED)
23	34-75362A1	REED ASSEMBLY Comment: (HORIZONTAL 5 PETAL REED)
24	961832	REED CLAMP Comment: (HORIZONTAL 5 PETAL REED)
25	10-57583T	SCREW, (#8-32 x .375) Comment: (HORIZONTAL 5 PETAL REED)
26	16-270372	STUD, (.250-28 x 1.125), CARB MOUNTING Comment: (HORIZONTAL 5 PETAL REED)
27	10-92160	SCREW, (.250-20 x .750) Comment: (HORIZONTAL 5 PETAL REED)
28	10-96529	SCREW, (.250-20 x 2.00) Comment: (HORIZONTAL 5 PETAL REED)

▶Relief Valve System (28 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
3	8M0039767	COVER Comment: (DESIGN I)
4	27-78690002	GASKET Comment: (DESIGN I)
5	NLA	No Longer Available, Plate-Relief Valve Comment: (DESIGN I)
6	65663A2	COVER ASSEMBLY Comment: (DESIGN II)
7	65664A1	PLATE ASSEMBLY Comment: (DESIGN II)
8	27-88907003	GASKET, RELIEF VALVE PLATE Comment: (DESIGN II)
9	10-38837	SCREW, (.312-18 x 1.12), COVER Comment: (DESIGN I & II)
10	648771	DIAPHRAGM Comment: (DESIGN I & II)
11	12-76451	WASHER Comment: (DESIGN I & II)
12	10-69570	SCREW, (#10-16 x .750) Comment: (DESIGN I & II)
13	24-64878	SPRING Comment: (DESIGN I & II)
14	86596	POPPET VALVE Comment: (DESIGN I & II)
15	65848	CARRIER Comment: (DESIGN I & II)
16	25-64872	GROMMET Comment: (DESIGN I & II)
17	14462A1	COVER Comment: (DESIGN III)
18	10-74824	SCREW, (.312-18 x 1.250) Comment: (DESIGN III)
19	27-78690002	GASKET Comment: (DESIGN III)
20	16497A1	PLATE Comment: (DESIGN III)
21	144791	DIAPHRAGM Comment: (DESIGN III)
22	16496	WATER DEFLECTOR Comment: (DESIGN III)
23	12-76451	WASHER Comment: (DESIGN III)
24	10-69570	SCREW, (#10-16 x .750) Comment: (DESIGN III)
25	24-64878	SPRING Comment: (DESIGN III)
26	14480	POPPET Comment: (DESIGN III)
27	65848	CARRIER Comment: (DESIGN III)
28	25-64872	GROMMET Comment: (DESIGN III)
29	12-85303	WASHER Comment: (DESIGN III)

▶Service/Support Material (1 parts)

Ref	OEM Part #	Part Name
-	90-11142880	OWNER'S GUIDE Comment: (GRAY)

▶Starter Motor(8 Tooth Pinion) (9 parts)

Ref	OEM Part #	Part Name
-	50-893893	STARTER MOTOR
1	90645	DRIVE KIT
2	13310T1	DRIVE
3	75660	PLATE
4	10-74968	BOLT
7	75658	ARMATURE Comment: (USE WITH 50-77141 MOTOR)
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER
11	15386001	END CAP

▶Starter Motor(9 Tooth Pinion) (9 parts)

Ref	OEM Part #	Part Name
-	50-86976	STARTER MOTOR
1	90646	DRIVE KIT
2	898265015	PINION
3	75660	PLATE
4	10-74968	BOLT
7	86178	ARMATURE
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER
11	15386001	END CAP

▶Swivel Bracket (50 parts)

Ref	OEM Part #	Part Name
-	27-89221A80	GASKET SET Comment: SN# Merc-6073192/Mariner-6055033 THRU Merc-6203990/Mariner-6201969
1	NLA	No Longer Available, Swivel Bracket Comment: (BLACK/GRAY) SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
1A	1499-8710T21	SWIVEL BRACKET Comment: (Gray) SN# 66255221 & Up
2	26-87735	SEAL, Oil
3	23-818764	BUSHING
4	25-33466	O-RING
5	23-67668	SPACER
6	22-8M0169589	FITTING, Grease
7	25-88341	GROMMET Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
7A	23-821207	BUSHING Comment: SN# 66255221 & Up
8	26-85023	SEAL, Oil Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
9	12-87161	WASHER Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
10	25-48171	O-RING, (.364. x .070) Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
11	85028A2	TILT LOCK LEVER Comment: (STBD) SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
12	23-86600	BUSHING Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
13	24-85367	SPRING Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
14	41052	PLUNGER Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
15	16-88876	STUD Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
16	86603	KNOB Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
17	864751	COUPLING Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
18	18-87200	PIN Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
19	24-88049	SPRING Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
20	18-93861	COTTER PIN Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
21	13-78854	WAVE WASHER
22	86580A1	BOTTOM YOKE Comment: (GRAY)
23	53-67684	RING, Retaining
24	12-67670	WASHER
25	17-67706A55	SWIVEL PIN AND STEERING ARM Comment: (Gray) SN# 66255221 & Up
26	10-8M0176309	SCREW, (.437-20 x 7.50)
27	78687T	MOUNT (UPPER)
28	12-66921	WASHER
29	12-78688	WASHER
30	11-8M0204653	NUT, (.437-20)
31	NLA	No Longer Available, Bumper Comment: SN# Merc-5464486/Mariner-5624878 THRU Merc-6073191/Mariner-6055032
31A	88882	BUMPER, Top Yoke Comment: SN# 66255221 & Up
32	92876A12	STEERING LINK ASSEMBLY
33	10-849838	SCREW, (.375-24 x 1.25)
34	11-8M0204726	NUT, (.375-24)
35	12-34931	WASHER, (.406 x .734 x .063 Stainless Steel)
36	86485A6	TILT SWITCH ASSEMBLY Comment: (MALE TERMINALS)
37	84-65017A14	HARNESS Comment: (MALE TERMINALS)
38	88342	STRAP
39	10-87926	SCREW, (#10-32 x .500)
40	54-54457	J CLIP
41	10-98256	SCREW, (.250-28 X .50)
42	12-8M0204649	WASHER, (.281 x .500 x .060)
43	8M0074846	TRIM SENDER
44	10-852368	SCREW, (#10-24 x .750)
45	10,13-26996	LOCKWASHER,
46	12-89302	WASHER, (.203 x .406 x .040)

▶Swivel Bracket(Merc S/N-USA-5464485/AUS-8061769 & Below ) (42 parts)

Ref	OEM Part #	Part Name
1	NLA	No Longer Available, Swivel Bracket
2	26-87735	SEAL, Oil
3	23-818764	BUSHING
4	25-33466	O-RING
5	23-67668	SPACER
6	22-8M0169589	FITTING, Grease
8	NLA	No Longer Available, Tilt Tube
9	NLA	No Longer Available, Shim
10	11-858869	NUT, (.875-14)
11	NLA	No Longer Available, Clamp
12	NLA	No Longer Available, Screw
12A	12-30164	WASHER, (.192 x .375 x .0312)
13	54-75275	CLAMP
14	NLA	No Longer Available, Nut
15	NLA	No Longer Available, Brace
16	NLA	No Longer Available, Pin
17	NLA	No Longer Available, Handle
18	18-25191	COTTER PIN
19	12-36001	WASHER
20	NLA	No Longer Available, Link
21	NLA	No Longer Available, Spring
22	NLA	No Longer Available, Pin
23	13-78854	WAVE WASHER
24	86580A1	BOTTOM YOKE
25	NLA	No Longer Available, Washer (Use where Applicable
26	53-67684	RING, Retaining
32	12-67670	WASHER
33	17-840792A1	SWIVEL PIN/STEERING ARM
34	10-8M0176309	SCREW, (.437-20 x 7.50)
35	77326	MOUNT Comment: (HEAVY DUTY)
36	12-66921	WASHER
37	12-78688	WASHER
38	11-8M0204653	NUT, (.437-20)
39	NLA	No Longer Available, Bumper
40	NLA	No Longer Available, Steering Link
41	10-849838	SCREW, (.375-24 x 1.25)
42	11-8M0204726	NUT, (.375-24)
43	12-34931	WASHER, (.406 x .734 x .063 Stainless Steel)
44	11-8M0204726	NUT, (.375-24)
45	NLA	No Longer Available, Cover
46	10-28635	SCREW, (.250-20 x .620)
47	13-26992	LOCKWASHER, (.250)

▶Throttle Lever and Shift Shaft (52 parts)

Ref	OEM Part #	Part Name
1	74897T	PIVOT
2	62459T	BALL JOINT ASSEMBLY
3	10-32,11-45076	NUT,
4	76035	ROD
5	10-32,11-46438	NUT,
6	41094A3	LEVER ASSEMBLY
7	10-75168	SCREW Comment: (1/4-28 THREAD)
8	11-29598	NUT, (.250-28) Comment: (1/4-28 THREAD)
9	52023	CAP Comment: (1/4-28 THREAD)
10	10-69560	SCREW, (.190-32 X 1.25)
11	10-32,11-68219	NUT,
12	48039	CAP
13	410952	LEVER
14	10-818165	SCREW, (.375-16 x 1.75)
15	23-55164	BUSHING
16	23-55171	BUSHING
17	24-55162	SPRING
18	12-68410	WASHER
19	10-64022	SCREW, (.250-20 x 2.125)
20	11-64015	NUT, (.250-20)
21	26852	CAP
22	39483	LATCH
23	10-69026	SCREW, (.250-28 x .88)
24	24-20099	SPRING
25	11-826709109	NUT, (.250-28)
26	95829	THROTTLE CONTROL ROD Comment: (6")
27	8M0221994	BARREL
28	95791	THROTTLE CAM Comment: (CASTING #95790)
29	16-20353	STUD, (.250-28 x 1.750)
30	23-26856	BUSHING
31	11-36069	NUT
32	24-41050	SPRING
33	814283A2	BRACKET
34	98889	LATCH Comment: (DESIGN II)
35	10-42975	SCREW, Drive Comment: (DESIGN II)
36	39519	CUP Comment: (DESIGN II)
37	24-91821	SPRING
38	24-79977	SPRING
39	87609A1	LEVER KIT Comment: (DESIGN I)
40	10-53167T	SCREW, (.312-18 x .880)
41	37896	GUIDE BLOCK
42	24-20099	SPRING
43	67073A1	LINK ROD ASSEMBLY
44	52100	WEAR PLATE
45	8M0036768	LATCH
46	12-35462	WASHER, (.2656 x .625 x .0625)
47	11-36069	NUT
48	79932A17	SHIFT SHAFT ASSEMBLY Comment: ASSEMBLY (X-LONG)
49	13-29720	WAVE WASHER
50	23-26600	BUSHING
51	12-35462	WASHER, (.2656 x .625 x .0625)
52	11-36069	NUT

▶Transom Bracket(ME-5464486-6073191/MA-5624878-6055032) (41 parts)

Ref	OEM Part #	Part Name
-	79879A1	REPAIR KIT
1	1494-7476T6	TRANSOM BRACKET Comment: (GRAY-PORT)
2	1495-7478T6	TRANSOM BRACKET Comment: (GRAY-STBD)
3	10-677552	SCREW, (.500-20 x 6.500)
4	10-8M0149747	SCREW, (.500-20 x 4.500)
5	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) SS
6	11-35000	NUT, (.500-20)
7	10-87180	BOLT, (.500-20 x 11.00)
8	11-82671317	NUT, (.500-20)
9	99170A2	TILT TUBE
10	13-88750	WASHER
11	11-859133	NUT Comment: (1"-14-GRAY)
12	25-45711	O-RING
13	85026T	PLATE
14	10-28636	SCREW, (.250-20 x .750)
15	12-8M0204649	WASHER, (.281 x .500 x .060)
16	85035T	SPACER
17	10-70732	SCREW, (.250-20 x 2.00)
18	12-8M0204649	WASHER, (.281 x .500 x .060)
19	89949A1	PLATE ASSEMBLY
20	10-90192	SCREW, (.250-20 x .875)
21	54-88512	CLAMP
22	10-88829	SCREW, (#10-24 x .500)
23	10,13-26996	LOCKWASHER,
24	79610A6	TRIM CYLINDER ASSEMBLY (79879A1 REPAIR KIT)
25	23-86489	BUSHING
26	12-85022	WASHER
27	24-30316	SPRING
28	17-85020T	PIVOT PIN
29	85024	SHAFT
30	23-86637	BEARING
31	17-91862	PIN
32	32-89023A2	HOSE Comment: (STARBOARD)
33	25-12602002	GROMMET
34	22-87207	CONNECTOR
35	87871T	COVER
36	27-87775	GASKET
37	25-45507	GROMMET
38	10-32866	SCREW, (#10-32 x 2.00)
39	10,13-26996	LOCKWASHER,
40	10-32,11-68219	NUT,

▶Transom Brackets(Merc S/N-USA-5464485/AUS-8061769 & Below ) (24 parts)

Ref	OEM Part #	Part Name
1	1474-7076	PORT TRANSOM BRACKET
2	10-677552	SCREW, (.500-20 x 6.500)
3	25-75320	O-RING
4	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) SS
5	11-35000	NUT, (.500-20)
6	17-25810	PIN
7	17-75319	ROLL PIN
8	75293	PORT TRIM STOP
9	75292	SHAFT
10	67718	STARBOARD TRIM STOP
11	NLA	No Longer Available, Trim Stop-Starboard
11A	79279	CLAMP
12	22-67667	CONNECTOR Comment: (PORT)
13	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) SS
14	11-35000	NUT, (.500-20)
15	76990	PAD
16	10-76841	SCREW, (.50-20 X 3.50)
17	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) SS
18	11-35000	NUT, (.500-20)
19	75290A1	TILT SENDER
20	10-37656	SCREW, (#10-32 X .62)
21	12-30164	WASHER, (.192 x .375 x .0312)
22	54-75343	CLAMP
23	17-75688	LOCATING PIN

▶Transom Brackets(Merc-6073192/Mariner-6055033 & Up) (21 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	3401-8718F8	TRANSOM BRACKET Comment: (GRAY -STARBOARD)
2	3400-8716A9	TRAMSOM BRACKET Comment: (GRAY -PORT)
3	22-8M0169588	FITTING, Grease (PORT)
5	99170A2	TILT TUBE
6	11-859133	NUT Comment: (GRAY)
7	25-45711	O-RING
8	13-88750	WASHER
9	11-858869	NUT, (.875-14)
10	10-8M0149747	SCREW, (.500-20 x 4.500)
11	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) SS
12	11-91962	NUT, (.500-20)
13	8M0115104	LEVER ASSEMBLY
14	13-99611	WAVE WASHER
15	23-65830	NYLINER
16	99633	KNOB
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY
21	11-23161	NUT, (.375-24)

▶Trim Cylinder(S/N-USA-5464485/AUS-8061769 & Below) (19 parts)

Ref	OEM Part #	Part Name
1	79114A4	TRIM CYLINDER ASSEMBLY
2	67694	PIN
3	67701	SHAFT
4	12-67745	WASHER
5	10-67756	SCREW
6	NLA	No Longer Available, Washer
7	67698T	SPACER
8	67700	COVER
9	10-35049	SCREW, (.250-20 x 2.75)
10	10-20665	SCREW, (.190-24 x .50)
11	23-67671	SPACER
12	67696	MANIFOLD
13	32-67683	HYDRAULIC TUBE (STARBOARD)
14	32-67681	HYDRAULIC TUBE (STARBOARD-DOWN)
15	32-67678	HYDRAULIC TUBE (STARBOARD - UP)
16	32-67682	HYDRAULIC TUBE (PORT)
17	32-67680	HYDRAULIC TUBE (PORT - UP)
18	32-67679	HYDRAULIC TUBE (PORT - DOWN)
19	28-20094	KEY, Woodruff

▶Wiring Harness, Starter Solenoid & Rectifier (50 parts)

Ref	OEM Part #	Part Name
1	434292	PLATE
2	332-7778A12	SWITCH BOX
3	10-90815	SCREW, (#12-24 X 2.25)
4	23-94304	SPACER (EARLY MODELS)
5	23-94453	BUSHING
6	84-62310A2	CABLE ASSEMBLY
7	10-32,11-45076	NUT,
8	84-60871A10	WIRE ASSEMBLY
9	10-62568	SCREW, (#10-16 x .375)
10	10-38055	SCREW, (.190-32 X .62)
11	84-65999A3	CABLE ASSEMBLY, (Black)
12	10-60411	SCREW, (1.25)
13	13-8M0204647	LOCKWASHER, (.312)
14	12-36042	WASHER
15	12-67264	WASHER, (Rubber)
16	23-67268	BUSHING
17	8M0058226	RECTIFIER
18	10-38055	SCREW, (.190-32 X .62)
19	10-32,11-45076	NUT,
20	87-33386A3	SWITCH ASSEMLBY Comment: (LEADS NOT ATTACHED)
21	10-38055	SCREW, (.190-32 X .62)
22	10-32,11-45076	NUT,
23	10-87926	SCREW, (#10-32 x .500)
24	84-88439A2	BATTERY CABLE Comment: (NEGATIVE)
25	84-96220A4	HARNESS
25A	84-87294A1	ENGINE HARNESS
26	88-8M0207796	FUSE, (20 Ampere)
27	84-95084A2	CABLE ASSEMBLY
28	54-816311T	CABLE TIE, (8.00 Inches)
29	89-853654A1	STARTER SOLENOID Comment: (10-32 5/16-18 TERMINALS)
30	10-32,11-45076	NUT, Comment: (10-32 5/16-18 TERMINALS)
31	13-53166	LOCKWASHER, (.312) Comment: (10-32 5/16-18 TERMINALS)
32	11-8M0204668	NUT, (.312-18) Comment: (10-32 5/16-18 TERMINALS)
33	10-31716	SCREW, (.250-20 x .62)
34	13-26992	LOCKWASHER, (.250)
35	84-65999A2	CABLE ASSEMBLY, (Black)
36	85-97861	INSULATOR
37	88825A7	VOLTAGE REGUALTOR Comment: (USE ON LATER MODELS)
38	10-48409	SCREW, (#10-16 x .625) Comment: (USE ON LATER MODELS)
39	84-13397A1	HARNESS ASSEMBLY Comment: (USE ON LATER MODELS)
40	10-32,11-45076	NUT, Comment: (USE ON LATER MODELS)
41	134731	FUSE HOLDER Comment: (USED ON EARLY MODELS)
42	86-66986	TERMINAL BLOCK Comment: (USED ON EARLY MODELS)
43	10-22523	SCREW, (.190-32 x .75) Comment: (USED ON EARLY MODELS)
44	10-22028	SCREW, (#10-32 x .50) Comment: (USED ON EARLY MODELS)
45	84-62189A1	WIRE ASSEMBLY (ORANGE) Comment: (USED ON EARLY MODELS)
46	67237	RETAINER Comment: (USED ON EARLY MODELS)
47	10-69570	SCREW, (#10-16 x .750) Comment: (USED ON EARLY MODELS)
48	25-92012	GROMMET Comment: (USED ON EARLY MODELS)
49	84-62824A1	CABLE Comment: (RED)(USED ON EARLY MODELS)

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury V-200 running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Productos vistos recientemente

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Popular Products

Popular Products

Popular Products

Mercury V-200 (5624878 THRU 0C100860) Parts & Diagrams

Categorías

Refined By Clear all

Marca

Caballo de fuerza

Motor

Disponibilidad

Precio

¿Necesitar ayuda?

Images

Product

Price

Qty

Options

Mercury V-200 (5624878 THRU 0C100860) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Productos vistos recientemente

Popular Products

Popular Products

Popular Products

Mercury V-200 (5624878 THRU 0C100860) Parts & Diagrams

Categorías

Refined By Clear all

Marca

Caballo de fuerza

Motor

Disponibilidad

Precio

¿Necesitar ayuda?

Images

Product

Price

Qty

Options

Mercury V-200 (5624878 THRU 0C100860) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Productos vistos recientemente

Shop the look

Choose Options

Recently Viewed

Edit Option

Back In Stock Notification

Choose Options

Popular Products