– JLM Marine Boat Parts Limited

Mercury 30 JET (3 CYL.) (0P017000 THRU 0P153499) Parts & Diagrams

🔎 Mercury 30 JET (3 CYL.) Reference Library — Exploded parts diagrams (61 diagrams), specifications, common issues, and maintenance checklist.

The Mercury 30 JET (3 CYL.) is a 4-Stroke, Inline 3-Cylinder, EFI outboard motor. Commonly used on jon boats, pontoons, and mid-size utility craft.

Quick Reference Specifications

Specification	Value
Engine Type	4-Stroke, Inline 3-Cylinder, EFI
Horsepower	30 HP
Displacement	526 cc
Bore x Stroke	61 mm x 60 mm
Spark Plug (Type & Gap)	NGK BKR6E
Engine Oil Capacity	3.0 L (3.17 quart)
Recommended Engine Oil	SAE 25W-40 Mercury FourStroke Oil
Gear Case Oil Capacity	340 mL (11.5 fl oz)
Idle Speed (in gear)	700 ± 50 RPM (in gear)
Full Throttle RPM Range	5250-6250
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury 30 JET (3 CYL.):

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury 30 JET (3 CYL.).

▶Accessories (2 parts)

Ref	OEM Part #	Part Name
-	821455A22	TILLER HANDLE KIT, Electric Start Comment: (NON-BIGFOOT)
0	88825A6	REGULATOR KIT, Voltage

▶Adaptor Plate (29 parts)

Ref	OEM Part #	Part Name
1	8M0162935	DIPSTICK
2	825989003	DIPSTICK TUBE Comment: SN# 0T178499 & Below
3	825989003	DIPSTICK TUBE Comment: SN# 0T178500 & Up
4	8560552	SEAL
5	825228A24	ADAPTOR PLATE Comment: SN# 0T178499 & Below
6	17-23784	PIN, Dowel Comment: SN# 0T178499 & Below
7	8289151	HEAT SHIELD
8	825228A17	ADAPTOR PLATE Comment: SN# 0T178500 & Up
9	19-822464	PLUG
10	10-4007455	SCREW, (M6 x 55) Comment: SN# 0T178500 & Up
11	54-855228	CLAMP
12	17-23784	PIN, Dowel
13	22-629101	FITTING, Elbow - 90 Degree (.125-27)
14	54-816311T	TIE STRAP, (8.00 Inches)
15	26-16977	SEAL, Oil Comment: (BIGFOOT)
16	23-856743	BUSHING Comment: (NON-BIGFOOT)
17	22-384073	PLUG, Pipe
18	25-822408001	GROMMET Comment: (NON-BIGFOOT)
19	27-8M0213113	GASKET
20	25-845746	O-RING
21	10-8M0204741	SCREW, (M6 x 20) Stainless Steel
22	856592	DEFLECTOR, Oil
23	8M0210772	BODY ASSEMBLY, Oil Pressure Relief
24	18-45882	COTTER PIN
25	8252151	PLUNGER
26	24-825216	SPRING
27	893765	PLATE, Oil Pickup-Top
28	32-854793	HOSE, Oil Pickup
29	893700	BAFFLE

▶Attenuator Plate (23 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	828164	ATTENUATOR, Sound
2	10-40019127	SCREW, (M6 x 16)
3	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel
4	19-815784	CAP
5	828928	BRACKET
6	26-812889	SEAL
7	828927	BRACKET
8	10-4000363	SCREW, (M8 x 100)
9	11399A1	ARM ASSEMBLY
10	67748	ROLLER
11	10-40056103	SCREW, (M5 x 6)
12	12-8M0204666	WASHER, (.203 x .500 x .032)
13	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (4-1/4 Inch) Comment: (Electric)
14	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (3 Inch) Comment: (Electric)
15	22-830285	FITTING TEE Comment: (Electric)
16	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (1 Inch) Comment: (Electric)
17	54-816311T	TIE STRAP, (8.00 Inches)
18	27-8144461	GASKET, Flange
19	825204T03	LINK, Throttle
20	37-8272822	DECAL, Warning, High Voltage Comment: (Manual)
21	NSS	NOT SOLD SEPARATE Comment: (Decal-Caution)
22	NSS	NOT SOLD SEPARATE Comment: (Decal-Caution in Gear Idle) (Electric)

▶Bottom Cowl (73 parts)

Ref	OEM Part #	Part Name
1	24-824992	SPRING, Detent
2	24-824993	SPRING, Backing
3	824994	SPRING, Plate
4	10-82191916	SCREW, (M5 x 14)
5	8280471	STRAP
6	10-4006731	SCREW, (M6 x 16)
7	8M0039049	CLAMP
8	10-40011130	SCREW, (M6 x 30) Stainless Steel
9	87-8M0052927	SWITCH Comment: (Electric Handle)
10	10-88075020	SCREW, (M3 x 20) Comment: (Electric Handle)
11	824923	PLATE Comment: (Electric Handle)
12	84-824934A3	HARNESS ASSEMBLY Comment: (Electric Handle)
13	8M0036802	CAP Comment: (Non-Handle)
14	10-4006731	SCREW, (M6 x 16) Comment: (Non-Handle)
15	8M0041741	LEVER Comment: (Non-Handle)
16	42927	INSERT Comment: (Non-Handle)
17	17-8224561	PIN Comment: (Non-Handle)
18	23-26954	BUSHING Comment: (Non-Handle)
19	23-48475	BUSHING Comment: (Non-Handle)
20	822459	RETAINER Comment: (Non-Handle)
21	11-401386	NUT, (M6) Stainless Steel Comment: (Non-Handle)
22	12-69056	WASHER, (.255 x .620 x .030) Stainless Steel Comment: (Non-Handle)
23	8224701	LINK, Shift Comment: (Non-Handle)
24	23-48475	BUSHING Comment: (Non-Handle)
25	98889	LATCH Comment: (Non-Handle)
26	39519	CUP Comment: (Non-Handle)
27	821483A6	SHIFT SHAFT, Horizontal
28	821487	LEVER, Interlock Actuating Comment: (Manual)
29	10-878607	SCREW, (#10-16 x .375)
30	84-88807A28	CABLE ASSEMBLY (Black-7 1/2 Inch)
31	8M0037997	SHIFT ROD Comment: (Handle)
32	18-210711	COTTER PIN Comment: (Handle)
33	17-8251851	PIN Comment: (Handle)
34	13-827418	LOCKWASHER Comment: (Handle)
35	822011	LEVER, Shift Comment: (Handle)
36	13-825273	WAVE WASHER Comment: (Handle)
37	10-40011107	SCREW, (M5 x 16) Stainless Steel Comment: (Handle)
38	10-42975	DRIVE SCREW
39	25-828462001	GROMMET
40	19-17230	PLUG
41	822424001	SEAL Comment: (Handle)
42	19-823874001	SEAL, Throttle Cable Comment: (Non-Handle)
43	4023-828165A1	BOTTOM COWL Comment: (Black)
44	21-817519A1	CHECK VALVE ASSEMBLY, Drain
45	25-8M0179867	GROMMET Comment: (Non Power Trim)
46	19-824076001	PLUG Comment: (Non-Handle)
47	8214901	HANDLE Comment: (Manual Handle)
48	823572001	SEAL Comment: (Manual Handle)
49	84-8M0210763	ALARM ASSEMBLY, Audio Warning Comment: (Manual Handle)
50	12-8M0214930	WASHER Comment: (Manual Handle)
51	10-82239312	SCREW, (M5 x 12) Comment: (Manual Handle)
52	10-40011107	SCREW, (M5 x 16) Stainless Steel Comment: (Manual Handle)
53	87-8M0042301	SWITCH ASSEMBLY Comment: (Power Trim)
54	812830T01	PLUG, Trim Switch Comment: (Non Power Trim)
55	8M0032848	RETAINER
56	10-1993716	SCREW, (M6 x 16)
57	828464	CAM, Latch
58	13-12134	WASHER, Wave
59	23-812707	BUSHING
60	22-813613	FITTING
61	54-816311T	TIE STRAP, (8.00 Inches)
62	32-7568058	HOSE, (15.00 Inches)
63	23-812707	BUSHING
64	823573F1	LEVER, Cowl Latch
65	10-40011129	SCREW, (M6 x 25) Stainless Steel
66	23-822003	BUSHING
67	25-822002	GROMMET
68	19-824473	PLUG, Warning Alarm Comment: (Electric)
69	10-878608	SCREW, (#10-16 x .500)
70	8M0043169	BUMPER
71	828463	LATCH, Front
72	10-4001987	SCREW, (M4 x 16)
73	25-16226	GROMMET

▶Camshaft/Oil Pump (14 parts)

Ref	OEM Part #	Part Name
-	27-825231A99	GASKET SET, Engine
1	10-82761140	SCREW, (M10 x 40)
2	12-4002319	WASHER
3	8M0151040	BELT
4	833104T6	GEAR, Driven
5	17-825956	PIN, Dowel
6	400-8M0183249	CAMSHAFT Comment: (MANUAL)
7	402-834781T1	CAMSHAFT Comment: (ELECTRIC)
8	17-826149	PIN
9	825058A1	PUMP ASSEMBLY, Oil
10	25-826152	O-RING
11	25-826154	O-RING
12	25-826153	O-RING
13	10-4000333	SCREW, (M6 x 40)

▶Carburetor (28 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	3301-824902T30	CARBURETOR, (WME 93-3), Bottom Comment: (Electric)
2	1395-823632	SHAFT, Throttle, Top/Bottom Comment: (WME-69/91)
3	1395-823633	SHAFT, Throttle, Center Comment: (WME-69/91)
4	1395-823636	SHAFT, Throttle, Bottom Comment: (WME-53/68/92/93)
5	1395-823634	SCREW, Top/Bottom
6	NSS	NOT SOLD SEPARATE Comment: (Spring-Throttle Return)
7	NSS	NOT SOLD SEPARATE Comment: (Idle Needle)
8	NSS	NOT SOLD SEPARATE Comment: (Spring-Idle Needle)
9	NSS	NOT SOLD SEPARATE Comment: (Gasket-Cover Plate)
10	1395-811221	COVER PLATE
11	1395-811220	SCREW, Cover Plate
12	27-8144461	GASKET, Flange
13	1395-8113522	LEVER, Oil Pump, Bottom Comment: (WME-53/68/92/93)
14	1395-8086121	SCREW, Lever Retainer, Bottom Comment: (WME-53/68/92/93)
15	10-F10155	SCREW, Throttle Valve
16	1395-97245	VALVE, Throttle
17	NSS	NOT SOLD SEPARATE Comment: (Retaining Ring)
18	F10064	SHAFT
19	1395-808738	GASKET
20	NSS	NOT SOLD SEPARATE Comment: (Gasket-Fuel Bowl)
21	10-95951	VALVE, Inlet Needle
22	1395-9594	FLOAT
23	1395-808612	SCREW AND WASHER, (#8-32 x .750)
24	1395-811693	BOWL, Fuel, Center/Bottom Comment: (WME-69/91)
25	1395-811694	PLUG KIT Comment: (WME-69/91)
26	1395-802731	SEAL (Consists of 4 Seals)
27	1395-6359	JET, (.052) Comment: (WME-68/93)

▶Carburetor(0T178499 and Below) (30 parts)

Ref	OEM Part #	Part Name
-	854256	REPAIR KIT, Carburetor
1	3329-830276T12	CARBURETOR Comment: (BOTTOM)
2	10-854246	SCREW
3	854245	PLATE
4	NSS	NOT SOLD SEPARATE, Gasket
5	854254T	ENRICHENER
6	NSS	NOT SOLD SEPARATE, O Ring
7	854255	PLATE
8	803919	IDLE JET
9	803912	JET
10	19-854248	PLUG, Rubber
11	803915	JET
12	854247	VALVE, Float
13	803914	MAIN NOZZLE
14	854253	FLOAT
15	NSS	NOT SOLD SEPARATE, Float Pin
16	NSS	NOT SOLD SEPARATE, Gasket
17	803917	FLOAT BOWL Comment: (CENTER/BOTTOM)
18	10-8542463	SCREW
19	10-8542462	SCREW, Drain
20	NSS	NOT SOLD SEPARATE, Washer
21	10-803913	SCREW Comment: (BOTTOM)
22	24-803923	SPRING Comment: (TOP/CENTER)
23	24-803924	SPRING Comment: (TOP/CENTER)
24	24-854249	SPRING Comment: (BOTTOM)
25	NSS	NOT SOLD SEPARATE, Spring
26	854251	PLUNGER
27	NSS	NOT SOLD SEPARATE, Rubber Bellows
28	NSS	NOT SOLD SEPARATE, Screw-Plunger Retaining
29	NSS	NOT SOLD SEPARATE, Plunger Rod

▶Carburetor(0T178500 and Up) (36 parts)

Ref	OEM Part #	Part Name
-	8542561	REPAIR KIT, Carburetor
1	3329-830276T33	CARBURETOR Comment: (Bottom)
2	10-854246	SCREW
3	854245	PLATE
4	27-8542572	GASKET
5	854254T2	ENRICHENER
6	NSS	NOT SOLD SEPARATE, O Ring
7	854255	PLATE
8	19-880814	CAP
9	10-880841	SCREW, Adjusting
10	25-880842	O-RING
11	24-880815	SPRING
12	80391242	JET, Pilot
13	25-880843	O-RING
14	19-880844	PLUG
15	80391595	JET, Main
16	8039143	MAIN NOZZLE
17	854247	VALVE, Float
18	8542531	FLOAT
19	17-8542581	PIN, Float
20	10-880845	SCREW
21	27-8542573	GASKET
22	8039171	FLOAT BOWL Comment: (Center/Bottom)
23	10-8542463	SCREW
24	10-8542464	SCREW, Drain
25	12-8542591	WASHER
26	10-803925	SCREW, Synchronization Comment: (Top/Center)
27	24-880846	SPRING Comment: (Top/Center)
28	24-803923	SPRING Comment: (Top/Center)
29	10-803913	SCREW Comment: (Bottom)
30	24-854249	SPRING Comment: (Bottom)
31	24-880847	SPRING
32	8542511	PLUNGER
33	10-880848	SCREW
34	NSS	NOT SOLD SEPARATE, Rubber Bellows
35	880849	PLUNGER ROD

▶Clamp Bracket (42 parts)

Ref	OEM Part #	Part Name
1	3411-821773T1	CLAMP BRACKET Comment: (Port) (Black)
2	3412-821774T8	CLAMP BRACKET Comment: (Storboard) (Black)
3	10-818883A1	THUMB SCREW ASSEMBLY Comment: (Manual)
4	NSS	NOT SOLD SEPARATE Comment: Handle (Manual)
5	NSS	NOT SOLD SEPARATE Comment: Rivet (Manual)
6	12-818884	WASHER Comment: (Manual)
7	10-768042	SHOULDER SCREW, Hex Comment: (Manual)
8	8224011	CAP Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)
9	17-25810	PIN Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)
10	23-86637	BEARING Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)
11	17-8224002	PIN Comment: (O.D. Of Ref. # 11 is .75 & Ref. # 10 is not flanged)
12	822401	CAP Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)
13	17-25319	PIN, (.125 x 0.75 Inches) Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)
14	23-823589	BUSHING Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)
15	17-8224001	PIN Comment: (O.D. Of Ref. # 15 is .56 & Ref. # 14 is flanged)
16	97-8252711	ANODE
17	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
18	10-8M0204707	SCREW, (M6 x 25)
19	11-82671117	NUT, (.500-20)
20	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel
21	10-814259	SCREW, (.500-20 x 4.00)
22	37-830253	DECAL, Tilt Lock
23	NSS	NOT SOLD SEPARATE Comment: (Decal-Warning)
24	828533T1	TRIM, Hydraulic Assist Comment: (Gas Assist Trim)
25	88238A11	CABLE ASSEMBLY Comment: (Gas Assist Trim)
26	828924	LEVER, Tilt Comment: (Gas Assist Trim)
27	8M0007469	TILT KNOB Comment: (Gas Assist Trim)
28	828930	ARM, Lever Comment: (Gas Assist Trim)
29	13-31030	WAVE WASHER Comment: (Gas Assist Trim)
30	17-25319	PIN, (.125 x 0.75 Inches) Comment: (Gas Assist Trim)
31	8289961	LINK Comment: (Gas Assist Trim)
32	10-32,11-8M0204718	NUT, Comment: (Gas Assist Trim)
33	17-822481001	PIN, Anchor (14 mm) Comment: (Gas Assist/Power Trim)
34	23-822482	BUSHING Comment: (Gas Assist/Power Trim)
35	23-822484	BUSHING Comment: (Gas Assist/Power Trim)
36	12-825190	WASHER Comment: (Gas Assist/Power Trim)
37	11-826712	NUT Comment: (Gas Assist/Power Trim)
38	10-4009040	SCREW, (M10 x 40) Stainless Steel Comment: (Gas Assist/Power Trim)
39	12-4002319	WASHER Comment: (Gas Assist/Power Trim)
40	11-40140	NUT, (M10) Comment: (Gas Assist/Power Trim)
41	17-853923A1	PIN Comment: (Non-Power Trim)
42	24-821461	SPRING Comment: (Non-Power Trim)

▶Crankshaft, Piston and Connecting Rods (16 parts)

Ref	OEM Part #	Part Name
-	61-803016T01	POWERHEAD ASSEMBLY Comment: (BIGFOOT)
1	401-834774T2	CRANKSHAFT Comment: (BIGFOOT)
2	28-893761	KEY
3	28-91800	KEY, Woodruff
4	8M0151047	SEAL
5	8M0151048	SEAL
6	600-893530T01	CONNECTING ROD
7	10-8M0049884	BOLT
8	23-893630002	BEARING, Blue
9	700-893524T02	PISTON Comment: (.50 O/S)(BARE PISTON)
10	39-893525A03	RING, Piston (TOP) Comment: (.50MM O/S)
11	39-893525A03	RING, Piston (Second) Comment: (.50MM O/S)
12	39-893950	RING, Oil
13	41-893863	PIN, Piston
14	40-825017	RETAINER
15	833102T	GEAR, Drive

▶Crankshaft, Pistons and Connection Rods (20 parts)

Ref	OEM Part #	Part Name
-	852067T98	POWERHEAD ASSEMBLY
1	2411-827954T3	CRANKSHAFT ASSEMBLY
2	43-43019A2	GEAR ASSEMBLY
3	30-63742T	BEARING, Ball
4	53-812877	RING, Retaining
5	28-91800	KEY, Woodruff
6	31-818889A1	BEARING ASSEMBLY, Roller Comment: (Top)
7	26-8173971	SEAL, Oil
8	827955A2	BEARING ASSEMBLY
9	NSS	NOT SOLD SEPARATE Comment: (Roller)
10	NSS	NOT SOLD SEPARATE Comment: (Ring-Seal)
11	705-850026T2	PISTON Comment: (.015 Over Size)
12	53-857196	LOCK RING
13	39-821695A6	RING SET, Piston Comment: (.015 Over Size)
14	NSS	NOT SOLD SEPARATE Comment: Piston Ring (Chrome Face)
15	640-9612A6	CONNECTING ROD ASSEMBLY
16	12-8M0012298	WASHER
17	29-8M0214934	BEARING
18	10-91012	SCREW, (.250-28 Special)
19	8M0234886	BEARING KIT

▶Cylinder Block (31 parts)

Ref	OEM Part #	Part Name
-	61-803016T01	POWERHEAD ASSEMBLY Comment: (BIGFOOT)
1	800-893500T02	CYLINDER BLOCK Comment: (BIGFOOT)
2	17-825010	PIN, Dowel
3	22-479452	PLUG
4	22-384073	PLUG, Pipe (1/2-14)
5	22-416223	PIPE PLUG (3/4-14)
6	23-893631002	BEARING, Blue Comment: (BLUE)
7	822625	NIPPLE, (M20)
8	10-82506182	SCREW, (M8 x 82)
9	10-8M0205943	SCREW, (M6 x 35)
10	27-8M0213112	GASKET
11	35-8M0162830	FILTER ASSEMBLY, Oil
12	27-8M4500244	GASKET
13	8M0183025	COVER, Exhaust
14	22-479452	PLUG
15	855676003	THERMOSTAT
16	27-8M0177107	GASKET
17	8M0188835	COVER
18	10-8M0205943	SCREW, (M6 x 35)
19	22-996642	FITTING, Elbow 90 Degree (.125-27 x .250) Nylon
20	54-816311T	TIE STRAP, (8.00 Inches)
21	32-8M0108349	TUBING, (28.00 Inches Bulk) (Cut to 11 Inches)
22	8M0214984	SENSOR ASSEMBLY, Temperature
23	25-627021	O-RING, (.301 x .070)
24	893697	LIFTING EYE
25	10-857139	SCREW, (M8 x 35)
26	NSS	NOT SOLD SEPARATE, Plug-Serial Number
27	32-77653101	HOSE, (48.00 Inches Bulk) (Cut to 18 Inches) Comment: SN# 0T178499 & Below
28	882831	BRACKET, Trim Relay Comment: (Power Trim) SN# 0T294232 & Up
29	10-8248324	SCREW, (M6 x 16) Comment: (Power Trim) SN# 0T294232 & Up
30	10-82129130	SCREW, (M6 x 30) Comment: (Power Trim) SN# 0T294232 & Up

▶Cylinder Block and Crankcase (41 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	2801-827953T7	CYLINDER BLOCK
2	10-81742780	SCREW, (M8 x 80)
3	10-81742730	SCREW, (M8 x 30)
4	21-426585	CHECK VALVE
5	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 15.00 Inch Length)
6	21-426232	CHECK VALVE (Press-In)
7	812888A2	CARRIER ASSEMBLY
8	21-42657A4	CHECK VALVE
9	10-814776	SCREW, Adjusting (M6 x 55)
10	11-400212	NUT, (M6) Stainless Steel
11	42942	CAP
12	17-43044	PIN, Dowel - Without Hole (.375 x .625) (Locating)
13	17-8M0084653	PIN (Bearing Race)
14	27-827284	GASKET
15	16-8161949	STUD, (M6 x 44)
16	22-185981	PLUG, Pipe (.375-18)
17	22-328022	PLUG, Pipe (.125-27) Brass
18	22-19725	ELBOW
19	21-426585	CHECK VALVE
20	827251A1	COVER
21	850897	LIFTING EYE Comment: (Manual)
22	10-40011149	SCREW, (M8 x 25) Stainless Steel Comment: (Manual)
23	NSS	NOT SOLD SEPARATE Comment: (Decal-Serialization)
24	10-40011149	SCREW, (M8 x 25) Stainless Steel
25	889735	CARRIER
26	850055001	THERMOSTAT, 43Â°C (110Â°F)
27	26-854639001	SEAL
28	787992	SENDER, Temperature
29	889733	RETAINER
30	10-878609	SCREW, (#10-16 x .600)
31	12-8M0204666	WASHER, (.203 x .500 x .032)
32	22-996642	FITTING, Elbow 90 Degree (.125-27 x .250) Nylon
33	12-8M0204663	WASHER, (.187 x .500 x .062) Neoprene Comment: (Electric)
34	12-69056	WASHER, (.255 x .620 x .030) Stainless Steel Comment: (Electric)
35	11-816872	WING NUT Comment: (Electric)
36	22-56759	FITTING, Barbed Comment: (Electric)
37	8129962	COVER Comment: (Manual)
38	25-48462	O-RING, (.614 x .070) Comment: (Manual)
39	10-40011108	SCREW, (M5 x 20) Stainless Steel Comment: (Manual)
40	32-892024122	TUBING, (20.00 Feet Bulk) (Cut to 5.50 Inch Length)

▶Cylinder Head (32 parts)

Ref	OEM Part #	Part Name
-	61-803016T01	POWERHEAD ASSEMBLY Comment: (BIGFOOT)
1	834778T2	CYLINDER HEAD
2	8M0054272	GUIDE
3	53-825038	CIRCLIP
4	826887M	ANODE
5	25-825040	GROMMET
6	826888M	COVER
7	10-8M0204741	SCREW, (M6 x 20) Stainless Steel
8	10-827607	BOLT
9	27-827610	GASKET
10	10-84088M	SCREW, (M6 x 10)
11	27-827610	GASKET
12	26-825048	SEAL, Oil
13	22-822644	PIPE PLUG
14	25-8M0162934	O-RING
15	8M0174399	COVER
16	NSS	NOT SOLD SEPARATE, Decal-Servicing Referral
17	NSS	NOT SOLD SEPARATE, Decal-Engine Oil/Valve Clearance
18	27-8M0118180	GASKET
19	10-8M0204741	SCREW, (M6 x 20) Stainless Steel
20	10-893745025	SCREW, (M6 x 25)
21	10-82503395	SCREW, (M9 x 95)
22	17-825010	PIN, Dowel
23	859578A1	PLUG ASSEMBLY, Oil
24	NSS	NOT SOLD SEPARATE, O Ring
25	855236	PLATE, Baffle
26	10-4005785	SCREW, (M4 x 10)
27	22-629101	FITTING, Elbow - 90 Degree (.125-27)
28	22-825054	BREATHER PIPE
29	830294T1	BRACKET Comment: (HANDLE)
30	10-40011126	SCREW, (M6 x 13) Stainless Steel Comment: (HANDLE)
31	54-8M0024808	J CLIP Comment: (USE WHERE APPLICABLE)

▶Driveshaft Housing (26 parts)

Ref	OEM Part #	Part Name
1	42941001	SEAL, Water Tube
2	3532-825218T5	HOUSING ASSEMBLY, Driveshaft Comment: (Long) SN# 0T178499 & Below
3	825220T06	PIPE, Exhaust Comment: (LONG)
4	10-824459110	SCREW, (M8 x 110) Stainless Steel
5	10-88960845	SCREW, (M8 x 45) (M8 X 45)
6	8288181	PLUG, Drain
7	27-8M0204692	GASKET
8	826276	BUMPER
9	8M0151042	GROMMET Comment: (LONG)
10	16-903501	STUD, (M10 x 100) Comment: (BIGFOOT)
11	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel
12	11-40140	NUT, (M10)
13	32-897971A01	TUBE, Water Comment: (LONG)
14	54-828529	GUIDE
15	8M0043364	BUMPER Comment: (LONG)
16	1503-852421T3	HOUSING ASSEMBLY, Driveshaft Comment: (Bigfoot) SN# 0T178499 & Below
17	893770	PLATE Comment: (BIGFOOT)
18	10-1993325	SCREW, (M10 x 25 MM) Comment: (BIGFOOT)
19	22-85822A7	SPEEDOMETER PICK UP Comment: (BIGFOOT)
20	22-85822T	CONNECTOR, Straight Comment: (BIGFOOT)
21	22-8M0181450	FITTING Comment: (BIGFOOT)
22	23-813745	SPACER Comment: (BIGFOOT)
23	43585	COUPLING Comment: (BIGFOOT)
24	23-855623	BUSHING Comment: (BIGFOOT)
25	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel Comment: (BIGFOOT)
26	54-816311T	TIE STRAP, (8.00 Inches) Comment: (BIGFOOT)

▶Driveshaft Housing/Exhaust Plate (49 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	10-40011155	SCREW, (M8 x 55) Stainless Steel
2	25-93221002	GROMMET
3	99019	CLAMP
4	42941001	SEAL, Water Tube
5	32-8M0042794	TUBE, Water Comment: (Long)
6	87917217T	TUBE, Exhaust
7	10-40011153	SCREW, (M8 x 45) Stainless Steel
8	27-8M0000821	GASKET, Driveshaft Housing
9	821439T4	ADAPTOR PLATE
10	17-23784	PIN, Dowel
11	10-4010875	SCREW, (M10 x 75) Hex Flange - Stainless Steel
12	8M0043148	SEAL, Bottom Cowl
13	822419	COUPLER
14	25-822408001	GROMMET
15	880042	SHIFT SHAFT (Upper)
16	12-89302	WASHER, (.203 x .406 x .040)
17	17-822417	PIN
18	18-210711	COTTER PIN
19	8M0000520	SCREW, (M12 x 162)
20	1400-8M4501487	MOUNT
21	10-40011153	SCREW, (M8 x 45) Stainless Steel
22	88238A10	CABLE ASSEMBLY, Ground
23	12-32834	WASHER, Neoprene
24	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel
25	11-896963	NUT, (M12)
26	828466A1	TRIM COVER Comment: (Black)
27	8M0043155	BUMPER
28	10-826173	SCREW, (M5 x .8 x 60)
29	12-73288	WASHER, (.220 x .500 x .030) Stainless Steel
30	11-401365	NUT, (M5) Stainless Steel
31	8M0043170	BUMPER
32	822395001	SEAL
33	828495001	SEAL, Idle Relief
34	10-817430110	SCREW, (M10 x 110)
35	3525-821841T7	HOUSING, Driveshaft Comment: (Black) (Short) (Jet)
36	16-823984	STUD, (M10 x 50)
37	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel
38	11-40140	NUT, (M10)
39	8284842	MOUNT (Lower)
40	828485F1	COVER, Mount Comment: (Black)
41	10-40011151	SCREW, (M8 x 35) Stainless Steel
42	850030F1	YOKE, Bottom Comment: (Black)
43	10-8M0038368	SCREW, (M8 x 40) Stainless Steel
44	12-36001	WASHER
45	11-401378	NUT, (M8)
46	10-828556	SCREW, (M12 x 125)
47	11-896963	NUT, (M12)
48	88238A11	CABLE ASSEMBLY (A = To Portside of Swivel Bracket)

▶Electrical Components (43 parts)

Ref	OEM Part #	Part Name
1	8302351	PLATE, Electrical
2	10-82239312	SCREW, (M5 x 12)
3	12-89302	WASHER, (.203 x .406 x .040)
4	56762	TIE STRAP, (4.00 Inches)
5	821889A50	REV LIMITER Comment: (Electric)
6	8266241	CLAMP Comment: (Electric)
7	10-82239312	SCREW, (M5 x 12) Comment: (Electric)
8	89-8M0185146	SOLENOID ASSEMBLY Comment: (Electric)
9	23-8M0214955	BUSHING Comment: (Electric)
10	25-818967	GROMMET Comment: (Electric)
11	10-82129125	SCREW, (M6 x 25 MM) Comment: (Electric)
12	11-64015	NUT, (.250-20) Comment: (Electric)
13	13-26992	LOCKWASHER, (.250) Stainless Steel Comment: (Electric)
14	84-88807A33	CABLE ASSEMBLY Comment: (Electric)
15	84-88807A16	CABLE ASSEMBLY, (4.00 Inches) Black Comment: (Electric)
16	8-32,11-26419	NUT, Brass Comment: (Electric)
17	8M0084173	REGULATOR, Voltage Comment: (Electric)
18	10-82129140	SCREW, (M6 x 40) Comment: (Electric)
19	54-8M0024808	J CLIP Comment: (Electric)
20	85-830233	BOOT, Insulator - Red Comment: (Electric)
21	84-88439A4	CABLE ASSEMBLY, Battery - Negative Comment: (Electric)
22	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel (Quantity of 3 on Electric)
23	54-816311T	TIE STRAP, (8.00 Inches)
24	10-82129125	SCREW, (M6 x 25 MM)
25	84-88807A31	CABLE ASSEMBLY
26	10-81742720	SCREW, (M8 x 20) Comment: (Manual)
27	10-82129116	SCREW, (M6 x 16) Comment: (Manual)
28	54-54457	J CLIP (Quanity of 3 on Electric)
29	84-850220A2	HARNESS ASSEMBLY, Engine Comment: (Electric)
30	88-812619	FUSE, Yellow - 20 Ampere Comment: (Electric)
31	25-822002	GROMMET
32	23-822003	BUSHING
33	12-8M0214930	WASHER
34	10-40011129	SCREW, (M6 x 25) Stainless Steel
35	84-850221A2	HARNESS ASSEMBLY, Ignition
36	827509A10	CDM MODULE ASSEMBLY Comment: (11 Inch Leads)
37	84-857124A1	CABLE ASSEMBLY, Hi-Tension
38	85-857074A1	BOOT/TERMINAL KIT
39	33-896329885	SPARK PLUG Comment: (NGK#BUZ8H)
40	10-82129116	SCREW, (M6 x 16)
41	84-850052A1	HARNESS ASSEMBLY, Power Comment: (Manual)
42	84-11149T31	HARNESS ASSEMBLY Comment: (Manual)
43	84-852375A4	HARNESS ASSEMBLY Comment: (Electric)

▶Electrical Components(0G960499 and Below) (44 parts)

Ref	OEM Part #	Part Name
-	61-803016T01	POWERHEAD ASSEMBLY Comment: (BIGFOOT)
1	89-8M0185146	SOLENOID ASSEMBLY Comment: (ELECTRIC)
2	23-8M0214955	BUSHING Comment: (ELECTRIC)
3	25-818967	GROMMET Comment: (ELECTRIC)
4	8-32,11-26419	NUT, Brass Comment: (ELECTRIC)
5	11-94330	NUT, (.250-20) Brass Comment: (ELECTRIC)
6	84-88439A9	CABLE ASSEMBLY, Battery - Positive Comment: (ELECTRIC)
7	85-79695T	BOOT, Insulator - Black Comment: (ELECTRIC)
8	84-93388A13	CABLE ASSEMBLY Comment: (ELECTRIC)
9	84-88439A4	CABLE ASSEMBLY, Battery - Negative Comment: (ELECTRIC)
10	50-893887T	STARTER MOTOR ASSEMBLY Comment: (ELECTRIC)
11	10-40011149	SCREW, (M8 x 25) Stainless Steel Comment: (MANUAL)
12	10-8248324	SCREW, (M6 x 16) Comment: (MANUAL)
13	54-8M0024808	J CLIP Comment: (ELECTRIC)
14	87-8M0098207	PRESSURE SWITCH
15	8M0082988	SENSOR
16	10-40011107	SCREW, (M5 x 16) Stainless Steel
17	10-82130025	SCREW, (M6 x 25)
18	12-65567	WASHER, (.265 x .750 x .048) Stainless Steel
19	859224	PLATE
20	23-822003	BUSHING
21	25-8M0190980	GROMMET
22	87843302S	ECM, Engine Control Module
23	23-8539201	BUSHING
24	10-82129140	SCREW, (M6 x 40)
25	33-827858Q	SPARK PLUG, NGK-DPR6EA-9
26	NSS	NOT SOLD SEPARATE, Decal-Coil Identification
27	339-830404T3	COIL, Ignition
28	10-8M0204741	SCREW, (M6 x 20) Stainless Steel
29	84-854781A2	HARNESS ASSEMBLY, Engine Wiring Comment: (ELECTRIC)
30	88-812619	FUSE, Yellow - 20 Ampere Comment: (ELECTRIC)
31	828054	COVER, Fuse Comment: (ELECTRIC)
32	8261151	CLAMP, Connector Comment: (ELECTRIC)
33	10-8248324	SCREW, (M6 x 16) Comment: (ELECTRIC)
34	84-852375A6	HARNESS ASSEMBLY, Extension Comment: (ELECTRIC HANDLE)
35	54-816311T	TIE STRAP, (8.00 Inches)
36	54-47483	J CLIP Comment: (MANUAL)
37	883071T	REGULATOR, Voltage Comment: (ELECTRIC)
38	54-8M0024808	J CLIP Comment: (ELECTRIC)
39	10-8248324	SCREW, (M6 x 16) Comment: (MANUAL)
40	10-82129110	SCREW, (M6 x 10) Comment: (ELECTRIC)
41	13541	PLUG, Male Comment: (Quantity of 2 on Manual)
42	10-8248324	SCREW, (M6 x 16)
43	84-858884A1	CABLE ASSEMBLY

▶Electrical Components(0G960500 and Up) (48 parts)

Ref	OEM Part #	Part Name
-	61-803016T01	POWERHEAD ASSEMBLY Comment: (BIGFOOT)
1	89-8M0185146	SOLENOID ASSEMBLY Comment: (ELECTRIC)
2	23-8M0214955	BUSHING Comment: (ELECTRIC)
3	25-818967	GROMMET Comment: (ELECTRIC)
4	8-32,11-26419	NUT, Brass Comment: (ELECTRIC)
5	11-94330	NUT, (.250-20) Brass Comment: (ELECTRIC)
6	84-88439A9	CABLE ASSEMBLY, Battery - Positive Comment: (ELECTRIC)
7	85-8500671	BOOT, Insulator - Red Comment: (ELECTRIC)
8	84-93388A13	CABLE ASSEMBLY Comment: (ELECTRIC)
9	84-88439A4	CABLE ASSEMBLY, Battery - Negative Comment: (ELECTRIC)
10	50-893887T	STARTER MOTOR ASSEMBLY Comment: (ELECTRIC)
11	10-40011149	SCREW, (M8 x 25) Stainless Steel Comment: (MANUAL)
12	10-8248324	SCREW, (M6 x 16) Comment: (MANUAL)
13	87-8M0098207	PRESSURE SWITCH
14	8M0082988	SENSOR
15	10-40011107	SCREW, (M5 x 16) Stainless Steel
16	10-82130025	SCREW, (M6 x 25)
17	12-8M0214930	WASHER
18	859224	PLATE
19	856836001	RETAINER Comment: (ELECTRIC)
20	856040	BRACKET Comment: (ELECTRIC)
21	10-82129114	SCREW, (M6 x 14) Comment: (ELECTRIC)
22	92753	RETAINER Comment: (ELECTRIC)(Quantity of 2 on Handle)
23	23-856954	BUSHING
24	25-8M0190980	GROMMET
25	87843302S	ECM, Engine Control Module Comment: SN# 0T178499 & Below
26	23-8539201	BUSHING
27	10-82129140	SCREW, (M6 x 40)
28	33-827858Q	SPARK PLUG, NGK-DPR6EA-9
29	339-858942T1	COIL ASSEMBLY, Ignition
30	10-8M0204741	SCREW, (M6 x 20) Stainless Steel
31	84-859196T1	HARNESS ASSEMBLY, Engine Wiring Comment: (MANUAL)
32	84-859197T1	HARNESS ASSEMBLY, Engine Wiring Comment: (ELECTRIC) SN# 0T178499 & Below
33	88-812619	FUSE, Yellow - 20 Ampere Comment: (ELECTRIC)
34	828054	COVER, Fuse Comment: (ELECTRIC)
35	84-852375A6	HARNESS ASSEMBLY, Extension Comment: (ELECTRIC HANDLE)
36	54-816311T	TIE STRAP, (8.00 Inches)
37	54-8M0024808	J CLIP Comment: (MANUAL)
38	883071T1	REGULATOR, Voltage Comment: (ELECTRIC)
39	893771	BRACKET Comment: (ELECTRIC)
40	8308971	FOAM PAD Comment: (ELECTRIC)
41	10-8248324	SCREW, (M6 x 16) Comment: (MANUAL)
42	10-82129110	SCREW, (M6 x 10) Comment: (ELECTRIC)
43	13541	PLUG, Male Comment: (MALE)
44	84-877860T1	CABLE ASSEMBLY Comment: (Use where Applicable)
45	10-8248324	SCREW, (M6 x 16)
46	54-8M0024808	J CLIP Comment: (ELECTRIC-NON POWER TRIM)
47	10-8248324	SCREW, (M6 x 16) Comment: (ELECTRIC-NON POWER TRIM)

▶Flywheel (13 parts)

Ref	OEM Part #	Part Name
1	859284T2	FLYWHEEL COVER Comment: (ELECTRIC)
2	10-8248326	SCREW, (M6 x 25 MM) Comment: (ELECTRIC)
3	37-804654A01	DECAL, EPA Label Information Comment: (ELECTRIC)(2001)
4	284-832010T32	FLYWHEEL Comment: (ELECTRIC)
5	284-832010T27	FLYWHEEL Comment: (MANUAL)
6	NSS	NOT SOLD SEPARATE, Decal-Warning Spinning Flywheel
7	NSS	NOT SOLD SEPARATE, Decal-Timing Marks
8	NSS	NOT SOLD SEPARATE, Decal-Warning-Neutral
9	11-893789	NUT
10	12-893762	WASHER
11	10-4013930	SCREW, (M5 x 30) Comment: (Electric) SN# 0G960500 & Up
12	398-852386T8	STATOR Comment: (Manual) SN# 0G960499 & Below
13	834838	LOAD RING

▶Flywheel and Stator(Electric) (11 parts)

Ref	OEM Part #	Part Name
1	812777T1	COVER ASSEMBLY
2	11-42979	NUT, (M16)
3	12-33001	WASHER, (.641 x 1.250 x .190)
4	261-859234T24	FLYWHEEL
5	398-832075A21	IGNITION STATOR KIT
6	10-4013930	SCREW, (M5 x 30)
7	854512T	TRIGGER
8	93421	SWIVEL BALL
9	93254	SWIVEL BASE
10	54-816311T	TIE STRAP, (8.00 Inches)
11	37-804665A04	DECAL, EPA Label Information Comment: (2004)

▶Flywheel and Stator(Manual) (10 parts)

Ref	OEM Part #	Part Name
1	261-859234T25	FLYWHEEL
2	11-42979	NUT, (M16)
3	12-33001	WASHER, (.641 x 1.250 x .190)
4	398-832074A11	STATOR
5	10-4013930	SCREW, (M5 x 30)
6	854512T	TRIGGER
7	93421	SWIVEL BALL
8	93254	SWIVEL BASE
9	54-816311T	TIE STRAP, (8.00 Inches)
10	13541	PLUG, Male

▶Fuel Lines (17 parts)

Ref	OEM Part #	Part Name
1	32-856607	HOSE
2	32-856609	HOSE
3	856610	LINKAGE
4	23-803896	BUSHING
5	823548T	TIE STRAP
6	32-856613	HOSE
7	32-856611	HOSE and SLEEVE
8	22-822771	CONNECTOR
9	22-878404	FITTING, 45 Degree Comment: SN# 0T178500 & Up
10	32-878423	HOSE Comment: SN# 0T178500 & Up
11	32-85682239	TUBING, (17.00 Inches Bulk) (Cut to 3-1/2 Inches) Comment: SN# 0T178500 & Up
12	32-82381310	HOSE (90MM) Comment: SN# 0T178500 & Up
13	54-878425	CLIP Comment: SN# 0T178500 & Up
14	56762	TIE STRAP, (4.00 Inches)
15	12-8542592	WASHER
16	18-880850	COTTER PIN
17	22-878593	Y-CONNECTOR Comment: SN# 0T178500 & Up

▶Fuel Pump (24 parts)

Ref	OEM Part #	Part Name
-	27-825231A99	GASKET SET, Engine
1	35-877565T1	FILTER, Fuel
2	54-816311T	TIE STRAP, (8.00 Inches)
3	32-8M0108355	HOSE, (57.00 Inches Bulk) (Cut to 14 Inches)
4	32-8M0108355	HOSE, (57.00 Inches Bulk) (Cut to 19 Inches)
5	22-8M0148585	CONNECTOR ASSEMBLY, Fuel
6	826398T3	PUMP, Fuel
7	10-809564	SCREW, (M5 x 35)
8	809565	COVER
9	8095611	DIAPHRAGM
10	10-41889M	SCREW, (M3 x 5)
11	11-82537M	NUT
12	21-41888M	CHECK VALVE
13	8095612	DIAPHRAGM
14	17-8095661	PIN
15	24-809562	SPRING
16	11-82388M	NUT, (M5)
17	24-8095621	SPRING
18	8095631	PLUNGER
19	25-8M0052669	O-RING
20	10-82684430	SCREW, (M6 x 30)
21	19-854310	PLUG
22	54-8M0024808	J CLIP
23	8M0007776	DEFLECTOR, Cowl

▶Fuel Pump(Electric) (38 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	NSS	NOT SOLD SEPARATE Comment: (Diaphragm Kit)
2	21-857005A1	DIAPHRAGM KIT
3	NSS	NOT SOLD SEPARATE Comment: (Diaphragm)
4	NSS	NOT SOLD SEPARATE Comment: (Retainer)
5	NSS	NOT SOLD SEPARATE Comment: (Spring)
6	NSS	NOT SOLD SEPARATE Comment: (Cap)
7	NSS	NOT SOLD SEPARATE Comment: (Spring)
8	NSS	NOT SOLD SEPARATE Comment: (Cap)
9	NSS	NOT SOLD SEPARATE Comment: (Diaphragm)
10	27-8M0204705	GASKET
11	NSS	NOT SOLD SEPARATE Comment: (Gasket-Boost)
12	NSS	NOT SOLD SEPARATE Comment: (Gasket-Pulse)
13	987752	PLATE
14	22-433351	CONNECTOR, (90 Degree) With Vibraseal
15	10-82130050	SCREW, (M6 x 50)
16	144303	BASE
17	32-831949	HOSE
18	35-816296Q2	FILTER, Fuel
19	32-830761	LINE, Fuel
20	54-816311T	TIE STRAP, (8.00 Inches)
21	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 1.25 Inch Length) Comment: (50)
22	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 1.25 Inch Length) Comment: (50)
23	22-818993	CONNECTOR, Tee Comment: (50)
24	32-82381335	TUBING, (15.00 Inches Bulk) (Cut to 1.50 Inch Length) Comment: (50)
25	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 22.00 Inch Length)
26	22-8189941	CHECK VALVE
27	22-816856T01	CONNECTOR ASSEMBLY, Fuel
28	10-4000332	SCREW, (M6 x 35)
29	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (Cut to 4.25 Inch Length)
30	54-633003	CLAMP
31	89-819503A5	SOLENOID KIT, Enrichner Valve
32	32-9912688	TUBING, (36.00 Inches Bulk) (Cut to 8.00 Inch Length)
33	32-9912688	TUBING, (36.00 Inches Bulk) (Cut to 4.00 Inch Length)
34	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 14.00 Inch Length)
35	22-59169003	FITTING, Tee
36	32-9912688	TUBING, (36.00 Inches Bulk) (Cut to 2.00 Inch Length)
37	10-4006731	SCREW, (M6 x 16)

▶Fuel Pump(Manual) (30 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	NSS	NOT SOLD SEPARATE Comment: (Fuel Pump)
2	21-857005A1	DIAPHRAGM KIT
3	NSS	NOT SOLD SEPARATE Comment: (Diaphragm Kit)
4	NSS	NOT SOLD SEPARATE Comment: (Retainer)
5	NSS	NOT SOLD SEPARATE Comment: (Spring)
6	NSS	NOT SOLD SEPARATE Comment: (Cap)
7	NSS	NOT SOLD SEPARATE Comment: (Diaphragm)
8	NSS	NOT SOLD SEPARATE Comment: (Cap)
9	NSS	NOT SOLD SEPARATE Comment: (Diaphragm)
10	27-8M0204705	GASKET
11	NSS	NOT SOLD SEPARATE Comment: (Gasket-Boost)
12	NSS	NOT SOLD SEPARATE Comment: (Gasket-Pulse)
13	987752	PLATE
14	22-433351	CONNECTOR, (90 Degree) With Vibraseal
15	10-82130050	SCREW, (M6 x 50)
16	144303	BASE
17	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (22 Inch)
18	54-816311T	TIE STRAP, (8.00 Inches)
19	32-830761	LINE, Fuel
20	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (Cut to 4.25 Inch Length)
21	35-816296Q2	FILTER, Fuel
22	32-831949	HOSE
23	22-59169003	FITTING, Tee
24	32-892024122	TUBING, (20.00 Feet Bulk) (Cut to 9.50 Inch Length)
25	858763	PRIMER BULB
26	22-816856T01	CONNECTOR ASSEMBLY, Fuel
27	10-4000332	SCREW, (M6 x 35)
28	32-892024122	TUBING, (20.00 Feet Bulk) (Cut to 5.50 Inch Length)5-1/2 Inch)
29	32-892024122	TUBING, (20.00 Feet Bulk) (Cut to 1.50 Inch Length)1-1/2 Inch)

▶Gasket Set Components-Engine Overhaul (2 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
0	27-8144461	GASKET, Flange, Carburetor

▶Gear Housing(Driveshaft)(1.83:1 Gear Ratio) (40 parts)

Ref	OEM Part #	Part Name
-	821354A2	REPAIR KIT, Water Pump
1	1682-821306T12	GEAR HOUSING ASSEMBLY, Basic Comment: (Basic-Black)
2	818226A1	SEAL/PLATE KIT
3	NSS	NOT SOLD SEPARATE Comment: (Plate)
4	10-79953Q04	SCREW KIT, (.375-16 x .250) Drain (.375-16 X .25)
5	12-191833	WASHER
6	22-8M0058389	FITTING KIT, Magnetic, Plug Fill/Drain
7	12-191833	WASHER
8	11-55910	NUT, (.437-20)
9	43-822161T2	GEAR, Pinion (12 Teeth)
10	31-821321A2	BEARING ASSEMBLY
11	NSS	NOT SOLD SEPARATE Comment: (Cup)
12	10-8248324	SCREW, (M6 x 16)
13	46-821351A3	HOUSING ASSEMBLY, Water Pump Upper
14	8235471	SEAL
15	12-866451	WASHER
16	28-8M0214993	KEY
17	12-866451	WASHER
18	27-822189	GASKET, Upper Water Pump
19	27-8M0214956	GASKET, Lower Water Pump (Lower)
20	8213542	FACE PLATE
21	47-8M0204712	IMPELLER
22	46-821307A2	BASE ASSEMBLY, Water Pump
23	26-821309	SEAL
24	26-821310	SEAL
25	25-821308	O-RING, (1.421 x .139)
26	45-822159T1	DRIVESHAFT Comment: (Long)
27	30-821311	BEARING, Ball
28	823548T	TIE STRAP
29	822158	BOOT
30	821827	RETAINER
31	25-26855	O-RING, (1.609 x .139)
32	25-85594	O-RING, (.239 x .174)
33	12-814803	WASHER
34	821319A1	SHIFT SHAFT Comment: (Long)
35	11-400212	NUT, (M6) Stainless Steel
36	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
37	17-85593	PIN, (.078 x .437)
38	8213161	CAM, Shift
39	17-822369	PIN, (.125 x .625)

▶Gear Housing(Driveshaft-2.31:1 Gear Ratio) (43 parts)

Ref	OEM Part #	Part Name
-	47-8M0100526	REPAIR KIT, Water Pump Impeller
1	1667-9011G59	GEAR HOUSING ASSEMBLY, Basic
2	17-8M0084244	PIN, Dowel - With Hole (.375 x .625) (FRONT)
3	43046	TUBE, Oiler
4	22-8M0058389	FITTING KIT, Magnetic, Plug Fill/Drain
5	12-191833	WASHER, Fiber
6	17-43044	PIN, Dowel - Without Hole (.375 x .625) (REAR)
7	31640T07	TRIM TAB
8	10-825427	SCREW, (.437-14 x 1.250) Stainless Steel
9	12-451761	WASHER, (.453 x .812 x .105) Black Oxide
10	43040T1	CARRIER ASSEMBLY
11	NSS	NOT SOLD SEPARATE, Needle Bearing
12	97-826134Q	ANODE
13	11-401386	NUT, (M6)
14	10-4000333	SCREW, (M6 x 40)
15	43-44484T	GEAR, Pinion (13 Teeth)
16	11-35921	NUT, (.625-18)
17	850307	CAM, Shift Control
18	31-42677A1	BEARING ASSEMBLY, Tapered Roller
19	15-44492A1	SHIM SET
20	45-854808A1	DRIVESHAFT ASSEMBLY
21	42461A1	SLEEVE/RING KIT
22	NSS	NOT SOLD SEPARATE, Ring Seal
23	43055A4	COVER ASSEMBLY, Water Pump
24	27-430331	GASKET
25	27-8M0214931	GASKET
26	26-43036	SEAL, Oil (LOWER)
27	26-43035	SEAL, Oil (UPPER)
28	27-8172771	GASKET
29	817275A2	HOUSING KIT, Upper Water Pump
30	8M0204709	FACEPLATE
31	10-8M0214957	SCREW, (M6 x 30)
32	8M0204658	SEAL
33	28-8M0204723	KEY
34	47-43026T2	IMPELLER
35	10-8248326	SCREW, (M6 x 25 MM)
36	853906A1	SHIFT SHAFT ASSEMBLY
37	53-29641	E RING
38	23-43052A4	BUSHING ASSEMBLY
39	25-8M0204681	O-RING, (1.424 x .103)
40	26-8M0204708	SEAL, Oil
41	10-8248326	SCREW, (M6 x 25 MM)
42	26-861415	FACE SEAL

▶Gear Housing(Driveshaft-2:1 Gear Ratio) (39 parts)

Ref	OEM Part #	Part Name
-	821354A2	REPAIR KIT, Water Pump
1	1682-821306T12	GEAR HOUSING ASSEMBLY, Basic Comment: (BASIC)
2	818226A1	SEAL/PLATE KIT
3	NSS	NOT SOLD SEPARATE, Plate
4	10-79953Q04	SCREW KIT, (.375-16 x .250) (.375-16 X .25)
5	12-191833	WASHER, Fiber
6	22-8M0058389	FITTING KIT, Magnetic, Plug Fill/Drain Comment: (MAGNETIC)
7	12-191833	WASHER, Fiber
8	11-55910	NUT, (.437-20)
9	43-821326T1	GEAR, Pinion - 13 Teeth
10	31-821321A2	BEARING ASSEMBLY
11	NSS	NOT SOLD SEPARATE, Cup
12	10-8248324	SCREW, (M6 x 16)
13	46-821351A3	HOUSING ASSEMBLY, Water Pump Upper
14	8235471	SEAL Comment: (LONG - 2-1/4)
15	12-866451	WASHER
16	28-8M0214993	KEY
17	12-866451	WASHER
18	27-822189	GASKET, Upper Water Pump
19	27-8M0214956	GASKET, Lower Water Pump (LOWER)
20	8213542	FACE PLATE
21	47-8M0204712	IMPELLER
22	46-821307A2	BASE ASSEMBLY, Water Pump
23	26-821309	SEAL
24	26-821310	SEAL
25	25-821308	O-RING, (1.421 x .139)
26	45-826194A1	DRIVESHAFT Comment: (LONG)
27	30-821311	BEARING, Ball
28	823548T	TIE STRAP
29	822158	BOOT
30	821827	RETAINER
31	25-26855	O-RING, (1.609 x .139)
32	25-85594	O-RING, (.239 x .174)
33	12-814803	WASHER
34	827865A1	SHIFT SHAFT Comment: (LONG)
35	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
36	17-85593	PIN, (.078 x .437)
37	8213161	CAM, Shift
38	17-822369	PIN, (.125 x .625)

▶Gear Housing(Prop Shaft - 2.31:1 - S/N-0T625303 and below) (36 parts)

Ref	OEM Part #	Part Name
-	26-43035A4	SEAL KIT, Gear Housing
1	1667-9011G59	GEAR HOUSING ASSEMBLY, Basic
2	31-30894A1	BEARING SET, Cup And Cone
3	NSS	NOT SOLD SEPARATE, Cup
4	43-859472A3	GEAR ASSEMBLY, Forward - 30 Teeth
5	31-30895T	BEARING, Needle
6	53-856823	RING, Retaining
7	850315A1	FOLLOWER KIT, Cam
8	30-44530	BALL
9	NSS	NOT SOLD SEPARATE, Slide
10	24-850327	SPRING
11	52-850048T	CLUTCH
12	17-8M0100263	PIN, Cross
13	24-30893	SPRING
14	44-8M0140445	PROPELLER SHAFT
15	43-850034T	GEAR, Reverse (30 Teeth)
16	8M0168901	CARRIER ASSEMBLY, Bearing
17	25-8M0214974	O-RING, (3.609 x .139)
18	31-30956T	BEARING, Needle
19	26-8M0205728	SEAL, Oil (INNER)
20	26-8M0205729	SEAL, Oil (OUTER)
21	31-12578T	BEARING, Roller
22	12-12577	THRUST WASHER
23	31-12576	BEARING, Thrust
24	16-8M0034456	STUD, (M8 x 48)
25	12-855941	WASHER, (.323 x .590 x .112) Stainless Steel
26	11-401378	NUT, (M8)
27	15-44491A1	SHIM SET
28	8227731	INSERT, Threaded
29	NSS	NOT SOLD SEPARATE, Decal
30	NSS	NOT SOLD SEPARATE, Decal-Prop Operation
31	13191Q01	THRUST WASHER
32	11-52707Q1	PROP NUT KIT, (.750-16)
33	14-816629Q	TAB WASHER
34	10-4000380	SCREW, (M10 x 45)
35	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel

▶Gear Housing, Propeller Shaft - 1.83:1 Gear Ratio (36 parts)

Ref	OEM Part #	Part Name
-	823547A2	SEAL KIT
1	1682-821306T12	GEAR HOUSING ASSEMBLY, Basic Comment: (Basic-Black)
40	17-821327	PIN, Dowel
41	27-823942	GASKET
42	32-8M0026108	TUBE
43	19-824928001	PLUG, Rubber
44	821829	SCREEN
45	822157T2	TRIM TAB
46	10-82497020	SCREW, (M8 x 20)
47	12-72397	WASHER
48	43-822162T2	GEAR, Forward (22 Teeth)
49	31-8M0103470	BEARING ASSEMBLY, Roller
50	NSS	NOT SOLD SEPARATE Comment: (Cup)
51	31-41326	BEARING, Roller
52	821578	FOLLOWER, Cam
53	24-8261991	SPRING
54	17-8M0020999	PIN
55	52-821314T	CLUTCH
56	24-38114	SPRING
57	44-8M0140441	PROPELLER SHAFT
58	43-822163T1	GEAR, Reverse (22 Teeth)
59	30-20839T	BEARING, Ball
60	8M0168900	CARRIER ASSEMBLY, Bearing
61	25-815460	O-RING
62	31-21700	BEARING, Needle
63	26-8M0205511	SEAL, Oil
64	26-8M0203757	SEAL, Oil
65	12-855941	WASHER, (.323 x .590 x .112) Stainless Steel Comment: (Use with Threaded Insert)
66	10-85594030	SCREW, (M8 x 30) Comment: (Use with Threaded Insert)
67	8227731	INSERT, Threaded
68	NSS	NOT SOLD SEPARATE (Decal 1.83:1) (12 X 22)
69	73345A1	THRUST HUB
70	11-69578Q1	PROP NUT KIT
71	14-8M0214942	TAB WASHER
72	10-4000380	SCREW, (M10 x 45)
73	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel

▶Gear Housing, Propeller Shaft - 2:1 Gear Ratio (37 parts)

Ref	OEM Part #	Part Name
-	823547A2	SEAL KIT
1	1682-821306T12	GEAR HOUSING ASSEMBLY, Basic Comment: (BASIC)
39	17-821327	PIN, Dowel
40	27-823942	GASKET
41	32-8M0026108	TUBE
42	19-824928001	PLUG, Rubber
43	821829	SCREEN
44	822157T2	TRIM TAB
45	10-82497020	SCREW, (M8 x 20)
46	12-72397	WASHER
47	43-821315T1	GEAR ASSEMBLY, Forward - 26 Teeth
48	31-8M0103470	BEARING ASSEMBLY, Roller
49	NSS	NOT SOLD SEPARATE, Cup
50	31-41326	BEARING, Roller
51	821578	FOLLOWER, Cam
52	24-8261991	SPRING
53	17-8M0020999	PIN
54	52-821314T	CLUTCH
55	24-38114	SPRING
56	44-8M0140441	PROPELLER SHAFT
57	43-821312T1	GEAR, Reverse - 26 Teeth
58	30-20839T	BEARING, Ball
59	8M0168900	CARRIER ASSEMBLY, Bearing
60	25-815460	O-RING
61	31-21700	BEARING, Needle
62	26-8M0205511	SEAL, Oil
63	26-8M0203757	SEAL, Oil
64	12-855941	WASHER, (.323 x .590 x .112) Stainless Steel
65	10-85594030	SCREW, (M8 x 30)
66	8227731	INSERT, Threaded
67	NSS	NOT SOLD SEPARATE, Decal (2:1)
68	73345A1	THRUST HUB
69	11-69578Q1	PROP NUT KIT
70	14-8M0214942	TAB WASHER
71	10-4000380	SCREW, (M10 x 45)
72	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel
73	19-95925	PLUG

▶Induction Manifold and Reed Block (28 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	27-8M0000822	GASKET
2	1171-9812A8	END CAP ASSEMBLY
3	26-828932	SEAL, Oil
4	26-41953	SEAL
5	25-8M0142854	O-RING, (2.175 x .175)
6	10-81742720	SCREW, (M8 x 20)
7	19077A07	BRACKET ASSEMBLY
8	16-8161949	STUD, (M6 x 44)
9	12-8M0204663	WASHER, (.187 x .500 x .062) Neoprene Comment: (Electric)
10	12-69056	WASHER, (.255 x .620 x .030) Stainless Steel Comment: (Electric)
11	11-816872	WING NUT Comment: (Electric)
12	10-82127335	SCREW, (M8 x 35 MM)
13	827998A1	MANIFOLD ASSEMBLY, Induction
14	22-19725	ELBOW Comment: (Electric)
15	22-19725	ELBOW Comment: (Manual)
16	22-15026	CAP Comment: (Manual)
17	54-816311T	TIE STRAP, (8.00 Inches)
18	27-812869	GASKET
19	10-81742730	SCREW, (M8 x 30)
20	8M0219197	REED BLOCK ASSEMBLY
21	27-812868	GASKET
22	NSS	NOT SOLD SEPARATE Comment: (Dowel Pin)
23	34-812880A03	REED ASSEMBLY
24	14-429821	TAB WASHER
25	812879002	RETAINER, Reed Comment: (50)
26	825267	RETAINER, Reed Comment: (40)
27	10-88421471	SCREW, (M6 x 16)

▶Intake (17 parts)

Ref	OEM Part #	Part Name
-	27-825231A99	GASKET SET, Engine
1	10-82615890	SCREW, (M6 x 90)
2	856126T	INTAKE, Air
3	25-856525	O-RING
4	834783T	PLATE
5	834784T1	ISOLATOR Comment: (30)
6	19-827633	PLUG
7	856127A2	ATTENUATOR, Sound
8	10-8M0204741	SCREW, (M6 x 20) Stainless Steel
9	23-17044M	BUSHING
10	54-850181	TIE STRAP, (11.750 Inches)
11	26-856128001	SEAL
12	25-8250572	O-RING
13	17-23784	PIN, Dowel
14	10-8248326	SCREW, (M6 x 25 MM)
15	32-8M0182223	BREATHER HOSE
16	54-816311T	TIE STRAP, (8.00 Inches)

▶Intake/Exhaust Valves (18 parts)

Ref	OEM Part #	Part Name
-	27-825231A99	GASKET SET, Engine
1	8M0119204	VALVE, Exhaust
2	832990T1	VALVE, Intake
3	12-825044	WASHER, Valve Spring
4	26-822647	SEAL, Valve Stem
5	24-823678	SPRING, Valve Outer
6	822650	RETAINER
7	28-893554	KEY
8	898821A01	ROCKER ARM
9	10-825046	SCREW
10	11-826150	NUT
11	834780T1	SHAFT, Rocker
12	19-825042	PLUG
13	825050	BRACKET
14	825051	PLATE
15	24-825052	SPRING
16	24-854713	SPRING
17	10-82641030	SCREW, (M8 x 30)

▶Jet Components (12 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	10-8248324	SCREW, (M6 x 16)
2	46-821351A3	HOUSING ASSEMBLY, Water Pump Upper
3	8235471	SEAL
4	12-866451	WASHER
5	28-8M0214993	KEY
6	12-866451	WASHER
7	27-822189	GASKET, Upper Water Pump
8	27-8M0214956	GASKET, Lower Water Pump
9	8213542	FACE PLATE
10	47-8M0204712	IMPELLER
11	854491	EXTENSION, Water Tube

▶Jet Pump Assembly (33 parts)

Ref	OEM Part #	Part Name
-	856143A5	JET PUMP ASSEMBLY Comment: (With Stainless Steel Impeller)
1	801411401	HOUSING, Pump
2	32-827490	HOSE, Lube
3	878376	SHIFT LINKAGE KIT
4	878381	CAM
5	878379	GATE, Reverse - With Bumper
6	47-855708T40	IMPELLER Comment: (Stainless Steel)
7	80141240	HOUSING, Intake
8	827188T1	LINER
9	45-801413401	DRIVESHAFT
10	12-879652	THRUST WASHER
11	30-879653	BEARING, Ball
12	23-827189	SLEEVE
13	11-827190	NUT
14	28-801405625	KEY, Impeller
15	15-801404625	SHIM, Impeller
16	14-801403625	TAB WASHER
17	10-90192	SCREW, (.250-20 x .750) Stainless Steel
18	10-19923088	SCREW, (.250-20 x .875)
19	12-35044	WASHER, (.281 x .625 x .065) Stainless Steel
20	10-19923062	SCREW, (.250-20 x .625)
21	10-60411	SCREW, (.312-18 x 1.250)
22	801410	BRACKET, Cable Support
23	11-82670910	NUT, (.312-18)
24	17-801406	PIN, Dowel
25	10-19924275	SCREW, (.312-18 x 2.75)
26	12-8M0207778	WASHER
27	10-19925125	SCREW, (.375-16 x 1.25)
28	853881	ADAPTOR
29	10-1993330	SCREW, (M10 x 1.5 x 30)
30	12-34931	WASHER, (.406 x .734 x .063) Stainless Steel
31	10-87810178	SCREW, (M10 x 35)
32	17-821327	PIN, Dowel

▶Linkage(Electric Bigfoot) (28 parts)

Ref	OEM Part #	Part Name
1	10-40011158	SCREW, (M8 x 70) Stainless Steel
2	10-814776	SCREW, Adjusting (M6 x 55)
3	11-401196	NUT, (M6)
4	42942	CAP
5	822682A4	LEVER ASSEMBLY, Throttle Comment: (DESIGN II)
6	883160	RETAINER Comment: (DESIGN II)
7	23-825078	BUSHING
8	822459	RETAINER
9	8259571	LEVER, Shift
10	827706A4	BRACKET
11	98889	LATCH
12	10-8248324	SCREW, (M6 x 16)
13	23-15885	SLEEVE
14	893777	SHIFT ROD
15	8501631	GUIDE, Shift Rod
16	893769A01	SHIFT LINK
17	23-48475	BUSHING
18	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
19	11-401386	NUT, (M6)
20	18-210711	COTTER PIN
21	850166T2	LEVER ASSEMBLY, Shift Shaft
22	23-850165	BUSHING
23	8535853	CAM, Throttle
24	23-309772	SPACER
25	12-4002314	WASHER
26	10-40056107	SCREW, (M5 x 16)
27	822682A4	LEVER, Throttle Comment: (DESIGN I)
28	826587	RETAINER Comment: (DESIGN I)

▶Linkage(Manual Bigfoot-0G960499 and Below) (28 parts)

Ref	OEM Part #	Part Name
1	10-40011158	SCREW, (M8 x 70) Stainless Steel
2	10-814776	SCREW, Adjusting (M6 x 55)
3	11-401196	NUT, (M6)
4	42942	CAP
5	826587	RETAINER
6	822682A4	LEVER, Throttle
7	23-825078	BUSHING
8	822459	RETAINER
9	8259571	LEVER, Shift
10	827706A4	BRACKET
11	98889	LATCH
12	10-8248324	SCREW, (M6 x 16)
13	23-15885	SLEEVE
14	8501631	GUIDE, Shift Rod
15	893769A01	SHIFT LINK
16	23-48475	BUSHING
17	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
18	11-401386	NUT, (M6)
19	18-210711	COTTER PIN
20	850166T2	LEVER ASSEMBLY, Shift Shaft
21	23-850165	BUSHING
22	8535853	CAM, Throttle
23	23-309772	SPACER
24	12-4002314	WASHER
25	10-40056107	SCREW, (M5 x 16)
26	854467	ROD
27	12016A2	DETENT/SPRING KIT
28	NSS	NOT SOLD SEPARATE, Spring

▶Linkage(Manual Bigfoot-0G960500 and Up) (24 parts)

Ref	OEM Part #	Part Name
1	10-40011158	SCREW, (M8 x 70) Stainless Steel
2	10-814776	SCREW, Adjusting (M6 x 55)
3	11-401196	NUT, (M6)
4	42942	CAP
5	822682A4	LEVER ASSEMBLY, Throttle Comment: (DESIGN II)
6	10-8248326	SCREW, (M6 x 25 MM)
7	858245	SHIFT GUIDE
8	10-82239312	SCREW, (M5 x 12)
9	858246	SHIFT SLIDE
10	12016A2	DETENT/SPRING KIT
11	NSS	NOT SOLD SEPARATE, Spring
12	858247	SHIFT ROD
13	18-210711	COTTER PIN
14	11-401386	NUT, (M6)
15	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
16	858248	SHIFT LINK
17	23-48475	BUSHING
18	850166T2	LEVER ASSEMBLY, Shift Shaft
19	23-850165	BUSHING
20	8535853	CAM, Throttle
21	23-309772	SPACER
22	12-4002314	WASHER
23	10-40056107	SCREW, (M5 x 16)
24	822682A4	LEVER, Throttle Comment: (DESIGN I)

▶Linkage(Non Bigfoot) (34 parts)

Ref	OEM Part #	Part Name
1	10-40011158	SCREW, (M8 x 70) Stainless Steel
2	10-814776	SCREW, Adjusting (M6 x 55) Comment: (30 HP)
3	11-401196	NUT, (M6) Comment: (30 HP)
4	23-823807	BUSHING Comment: (30 HP)
5	10-814776	SCREW, Adjusting (M6 x 55) Comment: (40 HP)
6	11-401196	NUT, (M6) Comment: (40 HP)
7	42942	CAP Comment: (40 HP)
8	822682A4	LEVER ASSEMBLY, Throttle Comment: (DESIGN II)
9	883160	RETAINER Comment: (ELECTRIC)(DESIGN II)
10	23-825078	BUSHING
11	822459	RETAINER Comment: (NON HANDLE)
12	8259571	LEVER, Shift Comment: (NON HANDLE)
13	827706A4	BRACKET Comment: (NON HANDLE)
14	98889	LATCH Comment: (NON HANDLE)
15	10-8248324	SCREW, (M6 x 16) Comment: (NON HANDLE)
16	23-15885	SLEEVE Comment: (NON HANDLE)
17	882820	SHIFT ROD Comment: (NON HANDLE)
18	8535853	CAM, Throttle
19	23-309772	SPACER
20	12-4002314	WASHER
21	10-40056107	SCREW, (M5 x 16)
22	826588A4	SHIFT SHAFT ASSEMBLY, Horizontal
23	8277071	RETAINER
24	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
25	18-210711	COTTER PIN
26	24-826077	SPRING, Detent
27	24-824993	SPRING, Backing
28	824994	SPRING, Plate
29	10-40011107	SCREW, (M5 x 16) Stainless Steel
30	87-8M0052927	SWITCH Comment: (ELECTRIC HANDLE MODELS)
31	10-88075020	SCREW, (M3.5 x 20) Stainless Steel Comment: (ELECTRIC HANDLE MODELS)
32	824923	PLATE Comment: (ELECTRIC HANDLE MODELS)
33	822682A4	LEVER, Throttle Comment: (DESIGN I)
34	826587	RETAINER Comment: (DESIGN I)

▶Lube Chart (0 parts)

▶Manual Starter (33 parts)

Ref	OEM Part #	Part Name
-	835253A13	STARTER ASSEMBLY, Recoil
1	835253A12	HOUSING ASSEMBLY, Recoil
2	8167122	CAM
3	24-8267911	SPRING
4	8M0026455	SEAL
5	835256T	ROLLER
6	23-852987T	BUSHING
7	826414T	WASHER
8	10-82684430	SCREW, (M6 x 30)
9	13-826229	LOCKWASHER
10	24-86857T01	SPRING
11	50-854317T5	SHEAVE ASSEMBLY, Starter
12	868501	CAM
13	24-86851T02	SPRING
14	53-86849T01	RING, Retaining
15	24-868523	SPRING
16	86853T01	CAM
17	10-826253	SCREW, (.250-20 x .625)
18	50-12066Q10	ROPE
19	856073	LEVER, Interlock
20	856072T	RETAINER
21	24-856138T03	SPRING
22	854779T	BUSHING
23	10-8182491	SCREW, (#10-16 x 1.00)
24	85174A1	HANDLE ASSEMBLY
25	NSS	NOT SOLD SEPARATE
26	10-8248326	SCREW, (M6 x 25 MM)
27	856754	CABLE, Interlock
28	10-8214281	SCREW, (#10-16 x .625)
29	12-73288	WASHER, (.220 x .500 x .030) Stainless Steel
30	18-26811	COTTER PIN
31	10-40011107	SCREW, (M5 x 16) Stainless Steel
32	37-804654A01	DECAL, EPA Label Information Comment: (2001)

▶Manual Tilt (15 parts)

Ref	OEM Part #	Part Name
-	25-893922A01	O-RING KIT
1	8M0118572	SHOCK ROD ASSEMBLY
2	893903A01	PISTON ASSEMBLY, Trim Memory
3	25-893917A01	O-RING KIT, Cylinder
4	NSS	NOT SOLD SEPARATE, O Ring
5	893918A01	CYLINDER ASSEMBLY
6	893919A01	SCREW AND SEAL KIT
7	893920A01	ACCUMULATOR ASSEMBLY
8	893921A01	VALVE BODY ASSEMBLY
9	893923A01	CAM KIT
10	893924A01	VALVE KIT, Velocity
11	893925A01	REPAIR KIT
12	8M0207768	CABLE ASSEMBLY, Ground
13	17-19607	PIN
14	17-821539	PIN, Trilobe

▶Oil Injection Components (28 parts)

Ref	OEM Part #	Part Name
-	27-828553A97	GASKET SET
1	23-822003	BUSHING
2	25-822002	GROMMET
3	10-40011129	SCREW, (M6 x 25) Stainless Steel
4	1276-828163A2	TANK ASSEMBLY, Oil
5	36-828765A2	CAP ASSEMBLY
6	NSS	NOT SOLD SEPARATE, Tether
7	11-821285	PUSH NUT
8	19299A1	VENT ASSEMBLY
9	21-64871	VALVE
10	8M0039080	SEAL
11	54-816311T	TIE STRAP, (8.00 Inches)
12	25-813644002	GROMMET
13	87-12886A6	SWITCH ASSEMBLY
14	10-58376	SCREW, (.164-18 x .375)
15	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel
16	23-826084	SPACER
17	32-82381335	TUBING, (15.00 Inches Bulk) (12 Inch)
18	818902A2	PUMP ASSEMBLY, Oil Injection Comment: (40)
19	818902A1	PUMP ASSEMBLY, Oil Injection Comment: (50)
20	25-36390	O-RING
21	25-8M0204667	O-RING
22	10-40011108	SCREW, (M5 x 20) Stainless Steel
23	43-19277	GEAR, Driven
24	23-19278A2	BEARING ASSEMBLY
25	23-17597	BUSHING (Flanged)
26	23-17596	BUSHING
27	8M0084729	LINK

▶Power Trim (31 parts)

Ref	OEM Part #	Part Name
-	25-827668A1	O-RING KIT
1	822344T14	POWER TRIM ASSEMBLY
2	893931A01	SHOCK ROD ASSEMBLY
3	827671A1	PILOT CHECK ASSEMBLY
4	827672A1	TILT RELIEF VALVE ASSEMBLY
5	827673A1	SEAT ASSEMBLY, Suction
6	827674A1	PUMP ASSEMBLY
7	NSS	NOT SOLD SEPARATE Comment: (Ball/Spring)
8	NSS	NOT SOLD SEPARATE Comment: (Screw)
9	NSS	NOT SOLD SEPARATE Comment: (Filter)
10	NSS	NOT SOLD SEPARATE Comment: (O Ring)
11	827675A1	MOTOR ASSEMBLY
12	NSS	NOT SOLD SEPARATE Comment: (Screw)
13	NSS	NOT SOLD SEPARATE Comment: (Washer)
14	88238A15	CABLE ASSEMBLY
15	NSS	NOT SOLD SEPARATE Comment: (O Ring)
16	NSS	NOT SOLD SEPARATE Comment: (Coupler)
17	827676	PISTON, Memory
18	893929A01	MANUAL RELEASE ASSEMBLY
19	19-811613	PLUG ASSEMBLY
20	831276T	BRACKET
21	84-826802A9	HARNESS ASSEMBLY, Trim
22	10-82129125	SCREW, (M6 x 25 MM)
23	8M0207773	RELAY ASSEMBLY
24	828102	BRACKET
25	25-818967	GROMMET
26	23-8M0214955	BUSHING
27	NSS	NOT SOLD SEPARATE Comment: (Decal)
28	10-878609	SCREW, (#10-16 x .600)
29	8M0084613	C WASHER
30	54-22740	CLIP

▶Service and Support Material (1 parts)

Ref	OEM Part #	Part Name
0	37-804654A01	DECAL, EPA Label Information Comment: (2001)

▶Service/Support Material (1 parts)

Ref	OEM Part #	Part Name
0	37-804665A04	DECAL, EPA Label Information Comment: (2004)

▶Starter Assembly(Manual) (38 parts)

Ref	OEM Part #	Part Name
-	816728T14	STARTER ASSEMBLY, Recoil
1	85174A1	HANDLE ASSEMBLY
2	NSS	NOT SOLD SEPARATE Comment: (Retainer)
3	NSS	NOT SOLD SEPARATE Comment: (Rest)
4	8M0043416	SEAL
5	10-4010630	SCREW, (M6 x 30) Stainless Steel
6	23-830190	SPACER
7	23-816086	BUSHING
8	25-8157951	GROMMET
9	12-858779	WASHER, (.265 x .750 x .048)
10	11-401196	NUT, (M6)
11	8567541	CABLE, Interlock
12	10-8214281	SCREW, (#10-16 x .625)
13	12-73288	WASHER, (.220 x .500 x .030) Stainless Steel
14	18-26811	COTTER PIN
15	10-878608	SCREW, (#10-16 x .500)
16	18-26811	COTTER PIN
17	816728T05	HOUSING
18	24-826791	SPRING
19	8166903	LEVER
20	816712T01	CAM
21	816711	RETAINER
22	10-8182491	SCREW, (#10-16 x 1.00)
23	13-826229	LOCKWASHER, SPRING
24	24-86857T01	SPRING
25	50-825269T01	SHEAVE, Starter
26	24-86851T02	SPRING
27	868501	CAM
28	53-86849T01	RING, Retaining
29	50-12066Q10	ROPE
30	24-868523	SPRING
31	86853T01	CAM
32	10-826253	SCREW, (.250-20 x .625)
33	8M0183792	BUSHING
34	53-818853	RING, Retaining
35	NSS	NOT SOLD SEPARATE Comment: (Timing Decal)
36	NSS	NOT SOLD SEPARATE Comment: (Decal-Caution in Gear Idle)
37	37-804665A04	DECAL, EPA Label Information Comment: (2004)

▶Starter Motor (16 parts)

Ref	OEM Part #	Part Name
1	50-893890T	STARTER MOTOR ASSEMBLY
2	10-965661	THRU BOLT
3	90643	DRIVE KIT
4	685753	DRIVE ASSEMBLY
5	8236392	DRIVE CAP
6	965651	ARMATURE
7	8119011	CAP, Commutator
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER
10	F15158	SCREW
11	13-26992	LOCKWASHER, (.250) Stainless Steel
12	11-64015	NUT, (.250-20)
13	84-88439A9	CABLE ASSEMBLY, Battery - Positive
14	10-40011153	SCREW, (M8 x 45) Stainless Steel
15	NSS	NOT SOLD SEPARATE, Decal-Warning
16	823989	BRACKET, Oil Tank

▶Steering Arm (30 parts)

Ref	OEM Part #	Part Name
1	11-896963	NUT, (M12)
2	893773002	STRAP
3	8M0224385	MOUNT
4	12-4002321	WASHER, (12.80 mm x 24.0 mm x 2.4 mm) Stainless Steel Comment: (BIGFOOT)
5	10-8M0204741	SCREW, (M6 x 20) Stainless Steel
6	8M0156878	BUMPER
7	8M0156878	BUMPER Comment: (BIGFOOT)
8	53-89531	RING, Retaining
9	8M0118183	ARM, Steering
10	8M0184092	BRACKET Comment: (ELECTRIC)
11	14-8M0009820	TAB WASHER Comment: (ELECTRIC)
12	10-4000377	SCREW, (M10 x 30) Comment: (ELECTRIC)
13	10-898835001	BOLT, (M12 x 154)
14	23-8279971	SPACER Comment: (LONG)
15	893590T01	SWIVEL TUBE Comment: (LONG)
16	84-88238T01	CABLE ASSEMBLY
17	8M0207768	CABLE ASSEMBLY, Ground
18	10-823567105	SCREW, (M10 x 105) Hex Flange - Stainless Steel
19	893703	BRACKET
20	10-878607	SCREW, (#10-16 x .380)
21	11-40140	NUT, (M10)
22	11-8M0204726	NUT, (.375-24) Comment: (HANDLE)
23	823792	LEVER Comment: (HANDLE)
24	12-29330	WASHER Comment: (HANDLE)
25	821961	ROD (THREADED) Comment: (HANDLE)
26	821957	BRAKE PLATE Comment: (HANDLE)
27	8165621	DISC Comment: (HANDLE)
28	8M0007471	PLATE Comment: (HANDLE)
29	8165621	DISC Comment: (HANDLE)
30	10-768042	SHOULDER SCREW, Hex Comment: (HANDLE)

▶Swivel Bracket (27 parts)

Ref	OEM Part #	Part Name
1	19608A14	ATTACHING KIT, Engine Steering Comment: (Non-Handle)
2	10-823919	SCREW, (.375-24 x 1.500) Comment: (Non-Handle)
3	12-8M0109680	WASHER, (.390 x .546 x .12) Comment: (Non-Handle)
4	12-37828	WASHER, (.390 x .625 x .062) Stainless Steel Comment: (Non-Handle)
5	11-8M0204726	NUT, (.375-24) Stainless Steel Comment: (Non-Handle)
6	822397	PUCK Comment: (Non-Handle)
7	3410-827402T5	SWIVEL BRACKET ASSEMBLY
8	23-8217711	BUSHING (Upper)
9	22-8M0169589	FITTING, Grease Comment: (Quanty of 4 on Handle Version)
10	23-821777	BUSHING (Lower)
11	26-8M0205512	SEAL
12	NSS	NOT SOLD SEPARATE Comment: (Decal-Serial Overlaminate)
13	88238A11	CABLE ASSEMBLY
14	12-19619	WASHER
15	10-40011149	SCREW, (M8 x 25) Stainless Steel Comment: (Non-Handle)
16	8282451	SEAL Comment: (Non-Handle)
17	19624A1	SEAL KIT Comment: (Non-Handle)
18	25-29619	O-RING, (.583 x .103) Comment: (NonHandle)
19	23-78861	SPACER Comment: (Non-Handle)
20	12-19619	WASHER
21	8M0041938	TILT TUBE
22	11-858869	NUT, (.875-14)
23	37-8237011	DECAL, Co-Pilot
24	17-821539	PIN, Trilobe
25	23-823507	BUSHING
26	17-822480	PIN, Pivot (Upper)
27	10-878607	SCREW, (#10-16 x .375)

▶Swivel Tube (14 parts)

Ref	OEM Part #	Part Name
1	821769T2	SWIVEL TUBE HEAD, Gray
2	8M0184092	BRACKET Comment: (Non-Handle)
3	14-8M0009820	TAB WASHER Comment: (Non-Handle)
4	10-4000377	SCREW, (M10 x 30) Comment: (Non-Handle)
5	11-8M0204726	NUT, (.375-24) Stainless Steel
6	823792	LEVER
7	12-29330	WASHER
8	821961	ROD (Threaded)
9	821957	BRAKE PLATE
10	8165621	DISC
11	8M0007471	PLATE
12	8165621	DISC
13	10-768042	SHOULDER SCREW, Hex
14	8M0156878	BUMPER

▶Throttle Lever and Linkage (32 parts)

Ref	OEM Part #	Part Name
1	42946T1	LEVER, Throttle
2	10-817582	SCREW, Adjusting (M5 x 35)
3	11-400211	NUT, (M5) Stainless Steel
4	42927	INSERT
5	12-35459	WASHER
6	11-401386	NUT, (M6) Stainless Steel
7	10-814776	SCREW, Adjusting (M6 x 55)
8	11-400212	NUT, (M6) Stainless Steel
9	42942	CAP
10	23-812930A1	BUSHING
11	NSS	NOT SOLD SEPARATE Comment: (Insert)
12	10-4007180	SCREW, (M10 x 45)
13	23-8M0215006	BUSHING
14	24-55162	SPRING
15	12-42980	WASHER
16	19663T02	LEVER, Spark Advance
17	878172	ROD
18	93254	SWIVEL BASE
19	10-814776	SCREW, Adjusting (M6 x 55)
20	11-400212	NUT, (M6) Stainless Steel
21	42942	CAP
22	93421	SWIVEL BALL
23	16-8161949	STUD
24	24-817702	SPRING Comment: (Electric)
25	828160A2	CAM ASSEMBLY, Throttle
26	23-8M0215006	BUSHING
27	878174	ROD, Throttle
28	12-65567	WASHER, (.265 x .750 x .048) Stainless Steel
29	11-401386	NUT, (M6) Stainless Steel
30	12-828494	WASHER Comment: (Electric)
31	8214943	BRACKET Comment: (Handle Versions)
32	10-4006731	SCREW, (M6 x 16) Comment: (Handle Versions)

▶Tiller Handle (43 parts)

Ref	OEM Part #	Part Name
-	37-8M0032728	DECAL, Lanyard, Black
1	822148A7	COVER KIT
2	822150	PULLEY
3	NSS	NOT SOLD SEPARATE Comment: (Case)
4	10-878608	SCREW, (#10-16 x .500)
5	4324212	CABLE ASSEMBLY, Throttle (28.50 Inches)
6	4324213	CABLE ASSEMBLY, Throttle (30.00 Inches)
7	85-960099	SLEEVE, (12.00 Inches)
8	10-82526225	SCREW, (M8 x 25 MM)
9	8M0072298	COVER Comment: (Black)
10	23-821477	BUSHING
11	828813T1	ARM, Steering Handle Comment: (Black)
12	822441	RETAINER
13	10-40011107	SCREW, (M5 x 16) Stainless Steel
14	10-8M0204707	SCREW, (M6 x 25)
15	892995	LOCK, Throttle
16	24-96203	SPRING
17	821972T	KNOB, Throttle
18	8M0138696	TILLER TUBE
19	37-8242004	DECAL Comment: (Turtle/Rabbit)
20	821465	HANDLE, Throttle
21	8M0221732	GRIP
22	87-8M0104614	SWITCH ASSEMBLY
23	10-824848110	SCREW, (M10 x 110)
24	14-8M0009820	TAB WASHER
25	823687	CLIP
26	23-828569	SPACER
27	821455A4	BRACKET, Tiller Comment: (Black)
28	13-826792	WAVE WASHER
29	23-821477	BUSHING
30	12-827314	WASHER
31	87-11083A31	SWITCH
32	8M0032846	RETAINER, Brass
33	15920Q54	LANYARD ASSEMBLY
34	54-816311T	TIE STRAP, (8.00 Inches)
35	NSS	NOT SOLD SEPARATE, Decal-Shift (F-N-R)
36	15920Q54	LANYARD ASSEMBLY
37	10-40011151	SCREW, (M8 x 35) Stainless Steel
38	830180A01	HANDLE
39	23-830181	BUSHING
40	8301821	SHIFT ROD
41	14-8M0009820	TAB WASHER
42	10-82484890	SCREW, (M10 x 90)

▶Tools (68 parts)

Ref	OEM Part #	Part Name
-	91-31229A7	PULLER KIT, Bearing
1	44357Q2	FLUSHING ATTACHMENT
2	802889Q1	PUMP ASSEMBLY, Crankcase Oil
3	91-802653Q02	WRENCH, Oil Filter
4	91-8M0161873	HOLDER TOOL, Flywheel
5	91-83164M	FLYWHEEL PULLER
6	91-99379	TIMING LIGHT
7	91-890451	ADAPTOR TOOL, Direct Voltage
8	91-854009A3	TACH MULTI METER
9	91-823686A2	DIGITAL DIAGNOSTIC TESTER
10	91-8226086	CARTRIDGE
11	84-822560A7	HARNESS ASSEMBLY, Adaptor
12	84-822560A10	HARNESS ASSEMBLY, Adaptor
13	91-36392	GAUGE TOOL, Carburetor
14	91-809495001	REMOVER TOOL, Valve Guide
15	91-809496A1	INSTALLER TOOL, Valve Guide Bushing
16	91-809497A1	REAMER TOOL, Valve Guide
17	91-809494A1	COMPRESSOR TOOL, Valve Spring
18	NSS	NOT SOLD SEPARATE, Valve Seat Cutter Kit Comment: (OBTAIN LOCALLY)
19	FT2997	COMPRESSOR TOOL, Piston Ring
20	91-827001A1	STAND TOOL, Powerhead
21	91-24697	EXPANDER TOOL, Piston Ring
22	91-74951	SPANNER WRENCH
23	91-822778A3	DOWN PRESSURE KIT
24	91-63209	HEAT LAMP
25	31-85560	BEARING, Thrust
26	91-13779	REMOVER TOOL, Bearing
27	NSS	NOT SOLD SEPARATE, Expanding rod Comment: (P/N-CG-41-11)
28	NSS	NOT SOLD SEPARATE, Collet Comment: (P/N-CG-41-14)
29	11-24156	NUT, (.625-18)
30	12-34961	WASHER
31	91-29310	PLATE
32	91-31229	SHAFT
33	91-36571T	WRENCH TOOL, Driveshaft Bearing
34	91-37323	DRIVER ROD TOOL, Needle Bearings
35	91-15755T	MANDREL
36	91-36569T	DRIVE HEAD TOOL
37	91-27780	PULLER
38	91-37241	PULLER PLATE
39	91-37312T	DRIVER HEAD TOOL
40	91-817011T	INSTALLER TOOL, Needle Bearing
41	91-83180M	HOLDING TOOL, Driveshaft
42	91-825197T	INSTALLER TOOL, Oil Seal
43	91-817007T	INSTALLER TOOL, Seal
44	91-825198	MANDREL
45	91-825199	PILOT
46	91-825200A1	HOOK TOOL, Spring
47	91-826872	INSTALLER TOOL, Bearing
48	FT8950	TESTER KIT
49	91-12349A05	LOCATION TOOL, Pinion
50	91-13945	INSTALLATION TOOL, Bearing
51	91-13949	DRIVER TOOL, Oil Seal
52	91-14308T02	RACE TOOL, Bearing
53	91-14309T02	INSTALLATION TOOL, Bearing
54	91-14310T1	WEAR SLEEVE INSTALLATION TOOL
55	91-14311A04	PRE LOAD TOOL, Bearing
56	91-8M0053505	INDICATOR TOOL, Backlash
57	91-31106T	MANDREL, Bearing Driver Cup
58	91-31108T	DRIVER, Oil Seal
59	91-34569A1	PULLER ASSEMBLY, Slide Hammer
60	91-46086A1	PULLER JAW ASSEMBLY
61	91-37350T	MANDREL
62	91-56775T	HOLDING TOOL, Driveshaft
63	91-58222A1	DIAL INDICATOR TOOL
64	91-85716	PULLER TOOL
65	91-83155	ADAPTER KIT, Dial Indicator
66	91-83165T	PULLER ASSEMBLY
67	91-856875A1	INSTALLATION TOOL, Bearing

▶Tools, Special (1 parts)

Ref	OEM Part #	Part Name
0	91-37241	PULLER PLATE, Universal Comment: (Gear Housing)

▶Top Cowl (27 parts)

Ref	OEM Part #	Part Name
1	4019-825239T14	TOP COWL ASSEMBLY Comment: (Silver)(Electric)
2	4019-825239T12	TOP COWL ASSEMBLY Comment: (Silver)(Manual)
3	8M0041044	BRACKET, Cowl Support Comment: (Rear)
4	828433T	SPACER, Bracket
5	10-83208630	SCREW
6	11-400632	NUT
7	893763	BRACKET ASSEMBLY, Latch Roller
8	10-4006731	SCREW, (M6 x 16)
9	813546003	MOUNT
10	47341A11	ROPE AND HANDLE KIT, Manual Starting
11	8M0041646	BRACKET, Cowl Support - Front Comment: (Front)
12	828503	LATCH KEEPER
13	10-83208616	SCREW
14	11-400632	NUT
15	8M0038217	DUCT, Air Inlet
16	NSS	NOT SOLD SEPARATE Comment: (Induction Insert)
17	10-F2317	SCREW, (.250-20 x .875)
18	8M0043404	SEAL
19	813504A1	GAUGE KIT, Oil Level Comment: (Electric)
20	813505	GROMMET Comment: (Electric)
21	113171	RETAINER Comment: (Electric)
22	11-65110	NUT Comment: (Electric)
23	828180A02	SOUND BLANKET KIT (All)
24	NSS	NOT SOLD SEPARATE Comment: (Storboard and Rear)
25	NSS	NOT SOLD SEPARATE Comment: (Port and Rear)
26	NSS	NOT SOLD SEPARATE Comment: (Tape)
27	37-82409316	DECAL, F-N-R Shift

▶Transom Bracket (48 parts)

Ref	OEM Part #	Part Name
1	3420-8M0084195	CLAMP BRACKET ASSEMBLY Comment: (PORT - MANUAL LONG BIGFOOT)
2	22-8M0169588	FITTING, Grease
3	17-99604	PIN, Groove
4	3419-822867F1	CLAMP BRACKET Comment: (PORT - MANUAL LONG BIGFOOT)
5	893704T01	LEVER ASSEMBLY, Tilt Lock
6	24-99622	SPRING
7	23-65830	NYLINER
8	24-812708	SPRING
9	812709	KNOB
10	17-99615	PIN, Groove
11	12-19619	WASHER
12	18486F5	BRACKET, Anchor
13	97-818298Q1	ANODE KIT
14	10-8M0204707	SCREW, (M6 x 25)
15	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
16	10-4000355	SCREW, (M8 x 35) Comment: (35 MM)
17	13-400257	LOCKWASHER, (M8)
18	11-401388	NUT, (M8) Stainless Steel
19	17-8M0026068	PIN ASSEMBLY, Tilt Lock Comment: (NON POWER TRIM)
20	24-821461	SPRING Comment: (NON POWER TRIM)
21	8M0041938	TILT TUBE
22	11-858869	NUT, (7/8-14)
23	19624A1	SEAL KIT Comment: (NON-HANDLE)
24	25-29619	O-RING, (.583 x .103) Comment: (NON-HANDLE)
25	23-78861	SPACER Comment: (NON-HANDLE)
26	54-22740	CLIP Comment: (POWER TRIM)
27	8M0084613	C WASHER Comment: (POWER TRIM)
28	10-878609	SCREW, (#10-16 x .600) Comment: (POWER TRIM)
29	10-814259	SCREW, (.500-20 x 4.00)
30	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel
31	11-82671117	NUT, (.500-20)
32	8M0084737	LINK Comment: (NON POWER TRIM)
33	19615A05	LEVER ASSEMBLY, Tilt Comment: (NON POWER TRIM)
34	23-812707	BUSHING Comment: (NON POWER TRIM)
35	12-8M0042643	WASHER, (.520 x .850 x .060) Nylon - Black Comment: (NON POWER TRIM)
36	13-99611	WAVE WASHER Comment: (NON POWER TRIM)
37	8M0007469	TILT KNOB Comment: (NON POWER TRIM)
38	10-19611	SCREW, (.375-16 x .62) Comment: (NON POWER TRIM)
39	10-4009040	SCREW, (M10 x 40) Stainless Steel
40	12-4002319	WASHER
41	11-40140	NUT, (M10)
42	37-830253	DECAL, Tilt Lock
43	10-818883A1	THUMB SCREW ASSEMBLY Comment: (MANUAL BIGFOOT)
44	12-818884	WASHER Comment: (MANUAL BIGFOOT)
45	10-768042	SHOULDER SCREW, Hex Comment: (MANUAL BIGFOOT)
46	NSS	NOT SOLD SEPARATE, Handle Comment: (MANUAL BIGFOOT)
47	NSS	NOT SOLD SEPARATE, Rivet Comment: (MANUAL BIGFOOT)
48	NSS	NOT SOLD SEPARATE, Decal-Warning Comment: (MANUAL BIGFOOT)

▶Trim Switch Kit (8 parts)

Ref	OEM Part #	Part Name
-	87-18286A18	SWITCH KIT, Trim (10.00 Feet)
1	18861	RETAINER
2	814820	ADAPTOR
3	NSS	NOT SOLD SEPARATE Comment: (Switch)
4	88-8M0207796	FUSE, 20 Ampere
5	84-95084A2	CABLE ASSEMBLY
6	84-11149A2	CABLE ASSEMBLY, (6.00 Inches)
7	10-813523	SCREW, (#10-16 x 2.25)

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury 30 JET (3 CYL.) running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Productos vistos recientemente

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Popular Products

Popular Products

Popular Products

Mercury 30 JET (3 CYL.) (0P017000 THRU 0P153499) Parts & Diagrams

Categorías

Refined By Clear all

Marca

Caballo de fuerza

Motor

Disponibilidad

Precio

¿Necesitar ayuda?

Images

Product

Price

Qty

Options

Mercury 30 JET (3 CYL.) (0P017000 THRU 0P153499) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Productos vistos recientemente

Popular Products

Popular Products

Popular Products

Mercury 30 JET (3 CYL.) (0P017000 THRU 0P153499) Parts & Diagrams

Categorías

Refined By Clear all

Marca

Caballo de fuerza

Motor

Disponibilidad

Precio

¿Necesitar ayuda?

Images

Product

Price

Qty

Options

Mercury 30 JET (3 CYL.) (0P017000 THRU 0P153499) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Productos vistos recientemente

Shop the look

Choose Options

Recently Viewed

Edit Option

Back In Stock Notification

Choose Options

Popular Products