Customer Service: info@jlm-marine.com
Free shipping. No Minimum Purchase
🔎 Tohatsu MFS25/30C Reference Library — Exploded parts diagrams (26 diagrams), specifications, common issues, and maintenance checklist.
The Tohatsu MFS25/30C is a 4-Stroke EFI 3-Cylinder outboard motor. Commonly used on jon boats, pontoons, and mid-size utility craft.
| Specification | Value |
|---|---|
| Engine Type | 4-Stroke EFI 3-Cylinder |
| Horsepower | 25 HP |
| Displacement | 526 cc |
| Bore x Stroke | 61.0 x 60.0 mm |
| Spark Plug (Type & Gap) | NGK MR7F |
| Engine Oil Capacity | 1.8 L (with filter) |
| Recommended Engine Oil | SAE 10W-30 |
| Gear Case Oil Capacity | 0.37 L |
| Idle Speed (in gear) | 800 RPM (in gear) |
| Full Throttle RPM Range | 5000-6000 RPM |
| Fuel | Unleaded Gasoline, 87 Octane min. |
Always verify specifications against your owner's manual for your specific serial number range.
Below are common maintenance scenarios for the Tohatsu MFS25/30C:
Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Tohatsu MFS25/30C.
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3NVQ87304-0 | LOWER UNIT ASSY (UL) |
| 2 | 3NWB87090-1 | ENGINE SHORT BLOCK KIT |
| 3 | 3R3-01144-0 | * GASKET |
| 4 | 3R0-87321-1 | LOWER UNIT GASKET SET |
| 5 | 3R0-87322-0 | WATER PUMP REPAIR KIT |
| 6 | 9101E3-5616 | * BOLT |
| 7 | 951407-0312 | * SPRING PIN 3-12 |
| 8 | 9701-1-1103 | * SPARK PLUG (DCPR6E) |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3NVQ67100-0 | BOTTOM COWL |
| 2 | 346-67113-0 | MOUNT 8.5-14-2.5 |
| 3 | 346-67114-1 | SPACER 6.2-9-15.7 |
| 4 | 3NV-67141-0 | HOOK LEVER |
| 5 | 338-67147-0 | SEAL RING 13.8-22-3.7 |
| 7 | 350-67105-0 | HOOK LEVER BUSHING 14-16.5-17.7 |
| 8 | 941403-1400 | WAVE WASHER d=14 |
| 9 | 3NV-67142-0 | COVER HOOK |
| 10 | 9101E3-0612 | BOLT |
| 11 | 3R0-66308-0 | WASHER 6-16-1.5 |
| 12 | 344-67177-1 | GREASE FITTING |
| 13 | 3R3-67162-0 | GROMMET 25-15-3 |
| 14 | 345-67117-0 | GROMMET 17-2.7 |
| 15 | 3KY-67117-0 | GROMMET |
| 16 | 3NW-63624-0 | GROMMET |
| 17 | 3NV-63624-0 | GROMMET |
| 18 | 394-70260-0 | FUEL CONNECTOR (MALE) |
| 19 | 3H6-70262-0 | FUEL CONNECTOR PROTECTOR |
| 21 | 98AB-50-370 | HOSE |
| 22 | 338-02215-0 | CLIP φ10 |
| 23 | 98AR-50-480 | HOSE |
| 24 | 3T1-01138-0 | NIPPLE 6-8-11 |
| 25 | 3R3-71040-0 | PILOT LAMP ASSY |
| 26 | 398-06830-0 | STOP SWITCH ASSY |
| 27 | 353-06821-0 | * STOP SWITCH LANYARD ASSY |
| 28 | 3AC-72200-0 | STOP SWITCH DECAL |
| 29 | 3KY-72618-0 | GROMMET |
| 30 | 3T1-72403-0 | FLUSHING CONNECTOR |
| 31 | 3R0-07422-0 | O-RING 3.1-24.4 |
| 32 | 3T1-72404-0 | FLUSHING CONNECTOR CAP |
| 33 | 3FW-72410-1 | FLUSHING HOSE |
| 34 | 3T1-07737-1 | CLIP φ17.8 |
| 35 | 3F3-72616-1 | GASKET |
| 36 | 3NV-72617-0 | PTT SWITCH ASSY BRACKET |
| 38 | 3NV-63628-0 | CLAMP |
| 40 | 3AA-76026-0 | MAIN SWITCH ASSY |
| 41 | 3NV-76080-0 | NEUTRAL SWITCH |
| 42 | 398-76083-0 | NEUTRAL SWITCH ACTUATOR |
| 43 | 3NV-76081-0 | NEUTRAL SWITCH BRACKET |
| 44 | 9101E3-5616 | BOLT |
| 45 | 338-67163-0 | GROMMET 18-2.5 |
| 46 | 3AC-72615-0 | PTT SWITCH ASSY |
| 47 | 3NW-04055-0 | LOW PERMEATION HOSE |
| 48 | 3GT-35143-0 | CLIP φ9.4 |
| 49 | 9101E3-0630 | BOLT |
| 50 | 346-67115-0 | WASHER 6.5-21-1 |
| 51 | 3AC-76190-0 | WARNING DECAL |
| 52 | 3NVQ67483-0 | REMOTE CONT CABLE STAY COVER |
| 53 | 3NV-67578-0 | SHIFT DECAL |
| 54 | 9101E3-5630 | BOLT |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AEQ62112-2 | CLAMP BRACKET (R) |
| 2 | 3AEQ62113-2 | CLAMP BRACKET (L) |
| 3 | 3B7-60218-1 | ANODE |
| 4 | 910103-5630 | BOLT |
| 5 | 3H8-72049-0 | CO-PILOT DECAL |
| 6 | 3AC-62191-0 | SWIVEL BRACKET SHAFT ASSY |
| 7 | 346-62127-0 | CAP NUT |
| 8 | 349-62126-0 | BUSHING |
| 9 | 346-62124-1 | NYLON NUT 7/8-14 |
| 10 | 346-62117-1 | DISTANCE PIECE |
| 11 | 9301E3-0600 | NUT |
| 12 | 9401E3-0600 | WASHER |
| 13 | 345-62121-1 | THRUST ROD |
| 14 | 345-62122-2 | THRUST ROD SPRING |
| 15 | 3AEQ62310-2 | SWIVEL BRACKET |
| 16 | 344-67177-1 | GREASE FITTING |
| 17 | 3C8-62396-1 | GROUND L=210 |
| 18 | 398-62396-1 | GROUND L=130 |
| 20 | 3AC-62450-0 | FRICTION LEVER ASSY |
| 21 | 3AC-63012-0 | * GRIP |
| 23 | 3R3-62443-0 | WASHER 8.1-20-0.8 |
| 24 | 3R3-62445-0 | BOLT M8 P1.25 |
| 25 | 3R3-62448-1 | WASHER 8.5-38-3 |
| 26 | 3R3-62449-0 | DISC 8.5-38-2 |
| 27 | 930403-0800 | NYLON NUT 8-P1.25 |
| 29 | 3AHQ62010-0 | STEERING SHAFT ASSY |
| 30 | 3AC-62447-0 | PLATE |
| 31 | 910103-5616 | BOLT |
| 32 | 3AC-63619-0 | COLLAR 6.5-10.7-6.5 |
| 33 | 353-62417-0 | BUSHING 30-36-41 |
| 34 | 353-62423-1 | THRUST PLATE (UPPER) 31-50-2 |
| 35 | 353-62415-0 | O-RING 3.5-29.7 |
| 36 | 945103-2800 | C-RING d=28 |
| 37 | 3AEQ61411-1 | MOUNT BRACKET |
| 38 | 3C8-61336-0 | DAMPER (LOWER) |
| 39 | 3C8-61302-1 | RUBBER MOUNT (LOWER) |
| 40 | 3R0-61321-0 | BOLT 12-143 |
| 41 | 353-61334-0 | WASHER 13-34-3 |
| 42 | 3C7-61338-0 | DAMPER 21-36-5 |
| 43 | 3R0-61324-0 | NYLON NUT 12-P1.25 |
| 44 | 9402E3-1200 | WASHER |
| 45 | 3R0Q61342-0 | MOUNT HOLDING PLATE (LOWER) |
| 46 | 9101E3-5620 | BOLT |
| 47 | 3A3-62396-1 | GROUND L=110 |
| 48 | 910103-5612 | BOLT |
| 49 | 3R0-61301-1 | RUBBER MOUNT (UPPER) |
| 50 | 3R0-61307-0 | BOLT 10-111 |
| 51 | 930103-1000 | NUT 10-P1.5 |
| 52 | 3R0-61333-0 | DAMPER (UPPER) |
| 53 | 3R0-61337-1 | DAMPER (UPPER) |
| 54 | 3R0-61323-0 | LOCK PLATE |
| 55 | 345-61322-2 | WASHER 10.1-18-2.5 |
| 56 | 3R0-61335-0 | LOCK PLATE |
| 57 | 3R0-61312-1 | RUBBER MOUNT RETAINER |
| 58 | 9101E3-0620 | BOLT |
| 59 | 349Q62993-2 | TILT STOPPER |
| 60 | 951403-0640 | SPRING PIN |
| 61 | 346-62437-0 | BUSHING 10.2-12-29.5 |
| 62 | 3AC-62439-0 | SETTING PLATE |
| 63 | 3AC-63201-0 | BOLT 10-25 |
| 64 | 3C8-62421-1 | FRICTION SPRING |
| 65 | 346-62438-0 | SETTING PIECE |
| 66 | 346-66322-0 | REVERSE LOCK |
| 67 | 349-66313-0 | REVERSE LOCK ARM |
| 68 | 336-66319-1 | PIVOT BOLT |
| 70 | 346-66321-0 | REVERSE LOCK ROD |
| 71 | 951503-0212 | SPLIT PIN 2-12 |
| 72 | 3P0-66311-0 | REVERSE LOCK LEVER |
| 73 | 3AL-66333-0 | REVERSE LOCK LEVER GRIP |
| 74 | 346-66334-0 | STOPPER |
| 75 | 3AL-05254-0 | SHOULDER BOLT 6-8 |
| 76 | 940103-0800 | WASHER |
| 77 | 3AL-05212-0 | BUSHING 8.1-20 |
| 78 | 3AA-83719-0 | WASHER 8.5-18-1.6 |
| 79 | 3R0-66308-0 | WASHER 6-16-1.5 |
| 80 | 349-66312-0 | REVERSE LOCK LINK |
| 81 | 346-66323-1 | REVERSE LOCK LEVER SPRING |
| 82 | 3R0-66332-0 | REVERSE LOCK SPRING (L) |
| 83 | 3R3Q62001-0 | STEERING BRACKET |
| 84 | 3R3-62094-2 | BOLT 10-80 |
| 85 | 9401E3-1000 | WASHER |
| 87 | 3AC-72120-0 | RIGGING BOLT SET |
| 88 | 9161E3-0885 | * BOLT |
| 89 | 9401E3-0800 | * WASHER |
| 90 | 9301E3-0800 | * NUT |
| 91 | 3AAQ62105-0 | CLAMP SCREW KIT |
| 92 | 3AAQ62108-0 | * CLAMP SCREW ASSY |
| 93 | 3AA-62106-0 | ** CLAMP SCREW |
| 94 | 332Q62102-1 | ** CLAMP SCREW HANDLE |
| 95 | 3C8-62104-2 | ** RIVET 3-22 |
| 96 | 332-62101-1 | * CLAMP SCREW PAD |
| 97 | 3C8-62107-0 | * SHOULDER BOLT |
| 98 | 3NV-62415-0 | O-RING |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AFQ77211-1 | CLAMP BRACKET (PTT-R) |
| 2 | 3AFQ77212-2 | CLAMP BRACKET (PTT-L) |
| 3 | 398-62396-1 | GROUND L=130 |
| 4 | 910103-5612 | BOLT |
| 5 | 3B7-60218-1 | ANODE |
| 6 | 910103-5630 | BOLT |
| 7 | 3AD-62191-0 | SWIVEL BRACKET SHAFT ASSY |
| 8 | 3C8-77213-0 | BUSHING |
| 9 | 3R0-77118-0 | PTT THRUST ROD |
| 10 | 951603-1000 | SNAP PIN |
| 11 | 3ACQ77208-2 | SWIVEL BRACKET ASSY |
| 12 | 353-63207-0 | COLLAR 10.2-12-12 |
| 13 | 3R0-62473-0 | TILT STOPPER SPRING |
| 14 | 3AC-77151-1 | PT ASSY |
| 15 | 1H2-31534-0 | LEAD WIRE BAND 300 |
| 16 | 3KY-77071-0 | CYLINDER PIN (UPPER) |
| 17 | 3R0-77075-0 | BUSHING 13-16-40 |
| 18 | 3R0-77076-0 | BUSHING 13-17-19.5 |
| 19 | 910103-0612 | BOLT |
| 20 | 345-05122-1 | WASHER 6.5-23-1.5 |
| 21 | 3KY-77101-0 | CYLINDER PIN (LOWER) |
| 22 | 3C8-77076-1 | BUSHING 18-24-22 |
| 23 | 3R0-77112-0 | WASHER 18.2-34-1 |
| 24 | 945103-1800 | C-RING d=18 |
| 25 | 336-06973-0 | CLAMP 6-9.5L |
| 26 | 345-06915-0 | CLAMP 6.5-14L |
| 27 | 921503-5612 | SCREW |
| 28 | 3Y1-76145-0 | TERMINAL CAP 8-13-28 |
| 29 | 3R0Q77601-2 | GAS SHOCK ABSORBER |
| 30 | 3R0-66311-0 | REVERSE LOCK LEVER |
| 31 | 3AL-66333-0 | REVERSE LOCK LEVER GRIP |
| 32 | 346-66334-0 | STOPPER |
| 33 | 3V2-60001-0 | BOLT 6-35 |
| 34 | 9401E3-0600 | WASHER |
| 35 | 9301E3-0600 | NUT |
| 36 | 3R0-77105-0 | COLLAR 18.2-21.7-30 |
| 37 | 3AD-72120-0 | RIGGING BOLT SET |
| 38 | 3C7-62133-2 | * BOLT 12-105 P1.25 |
| 39 | 353-61334-0 | * WASHER 13-34-3 |
| 40 | 3C7-62139-1 | * NUT 12-P1.25 |
| 41 | 9401E3-1200 | * WASHER |
| 42 | 3GF-62466-1 | TILT STOPPER KIT |
| 43 | 951403-3516 | * SPRING PIN 3.5-16 |
| 44 | 369-62433-1 | * TILT STOPPER GRIP |
| 45 | 3C8-77217-0 | CLAMP SCREW KIT |
| 46 | 3C8-77216-0 | * CLAMP SCREW (PTT) |
| 47 | 332-62101-1 | * CLAMP SCREW PAD |
| 48 | 3C8-62107-0 | * SHOULDER BOLT |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3B7Q84340-3 | REMOTE CONTROL HEAD ASSY (RC5B) |
| 2 | 921603-0512 | * SCREW |
| 3 | 353-76037-0 | * CABLE TERMINAL PLUG |
| 4 | 3A3-84432-0 | * BUSHING |
| 5 | 3A3-84375-0 | * SCREW |
| 6 | 3A3-84374-0 | * SPACER |
| 7 | 353-84371-0 | * WASHER |
| 8 | 930103-0600 | * NUT |
| 9 | 3A3-84383-0 | * WASHER |
| 10 | 3A3-84421-0 | * ROLLER |
| 11 | 3A3-84422-0 | * THRUST PLATE |
| 12 | 3A3-84431-0 | * BUSHING |
| 13 | 940103-0800 | * WASHER |
| 14 | 3A3-84442-0 | * BOLT |
| 15 | 353-84388-0 | * DETENT ROLLER |
| 16 | 3B7Q84312-0 | * FREE THROTTLE LEVER |
| 17 | 921503-0406 | * SCREW |
| 18 | 3A3-84423-0 | * DETENT RETAINER |
| 19 | 921603-0518 | * SCREW |
| 20 | 3A3-84307-0 | * DETENT SPRING |
| 21 | 3A3-84424-0 | * FREE THROTTLE ROLLER |
| 22 | 3A3-84426-0 | * ROLLER RETAINER |
| 23 | 3A3-84425-0 | * FREE THROTTLE SPRING |
| 24 | 3A3-84365-1 | * THROTTLE ARM |
| 25 | 3A3-84428-0 | * THROTTLE FRICTION ARM |
| 26 | 945303-0600 | * E-RING d=6 |
| 27 | 353-84394-0 | * WASHER |
| 28 | 3A3-84427-0 | * ADJUST SCREW |
| 29 | 3A3-84381-0 | * SHIFT GEAR ASSY |
| 30 | 3A3-83314-2 | * CABLE TERMINAL |
| 31 | 3A3-84364-2 | * DRIVE GEAR |
| 32 | 3A3-84429-0 | * WIRE COVER |
| 33 | 930103-0500 | * NUT |
| 34 | 910103-0525 | * BOLT |
| 35 | 3A3-84376-0 | * GROMMET |
| 36 | 3B7Q84441-0 | * REAR HOUSING |
| 37 | 3B7Q84366-0 | * REAR PANEL |
| 38 | 3A3-84401-0 | * NEUTRAL LOCK ARM |
| 39 | 3A3-84403-0 | * NEUTRAL LOCK SPRING |
| 40 | 3A3-84407-0 | * WASHER |
| 41 | 921503-0510 | * SCREW |
| 42 | 3A3-84451-0 | * TILT SWITCH COVER |
| 43 | 3A3-84404-0 | * GRIP |
| 44 | 3B7Q84343-0 | * CONTROL LEVER |
| 45 | 3A3-84452-0 | * TILT SWITCH PLUG |
| 46 | 3A3-84368-0 | * WAVE WASHER |
| 47 | 3A3-84391-0 | * FREE THROTTLE DRUM |
| 48 | 3A3-84435-0 | * BUSHING |
| 49 | 3A3-84406-0 | * PLATE |
| 50 | 3A3-81301-0 | TWIN REMOTE CONTROL KIT |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 353-76020-3 | MAIN SWITCH ASSY |
| 2 | 3F3-76219-0 | * MAIN SWITCH KEY No.303 |
| 3 | 3A3-76086-1 | NEUTRAL SWITCH (REMOTE CONT) |
| 4 | 921503-5316 | SCREW |
| 5 | 3A3-72560-0 | PTT SWITCH ASSY |
| 6 | 921503-0206 | SCREW |
| 7 | 3A3-72591-0 | PTT SWITCH COVER |
| 8 | 3C8-76171-0 | OVERHEAT BUZZER |
| 9 | 3A3-06830-0 | STOP SWITCH ASSY |
| 10 | 353-06821-0 | * STOP SWITCH LANYARD ASSY |
| 11 | 3A3-76115-1 | CORD ASSY L=6200 |
| 12 | 353-72546-0 | ASSIST CORD (RED) L=200 |
| 13 | 3N5-84331-0 | DECAL (LEVER) |
| 14 | 3N5-84333-0 | DECAL (TOHATSU) |
| 15 | 3N5-84336-0 | SHIFT POSITION DECAL |
| 16 | 3N5-84465-0 | SHIFT POSITION SIDE DECAL |
| 17 | 3A3-84398-0 | BAND |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3NWB01000-0 | CYLINDER HEAD COMPLETE |
| 2 | 3NVB01001-0 | * CYLINDER HEAD ASSY |
| 3 | 9153F4-0635 | * STUD |
| 4 | 3AD-07010-1 | * CAMSHAFT ASSY |
| 5 | 3AC-07010-1 | * CAMSHAFT ASSY |
| 6 | 3H8-07025-0 | * OIL SEAL 18-35-8 |
| 7 | 3AE-07235-0 | * ROCKER ARM |
| 8 | 3R0-07238-0 | * ADJUSTING SCREW |
| 9 | 3H8-07237-0 | * ADJUSTING NUT |
| 10 | 3AE-07220-0 | * ROCKER ARM SHAFT |
| 11 | 3AE-07226-0 | * ROCKER ARM SHAFT |
| 12 | 910124-5635 | * BOLT |
| 13 | 3H8-07225-0 | * ROCKER SHAFT SPRING L=30 |
| 14 | 3H8-07229-0 | * ROCKER SHAFT SPRING L=50 |
| 15 | 3R3-07227-0 | * WASHER 13.2-21.8-2 |
| 16 | 3H8-07239-0 | * COLLAR 13.1-15.9-22.5 |
| 17 | 3AE-07895-0 | * INTAKE VALVE KIT |
| 18 | 3AE-07896-0 | * EXHAUST VALVE KIT |
| 19 | 3AE-07901-0 | ** INTAKE VALVE |
| 20 | 3AE-07902-0 | ** EXHAUST VALVE |
| 21 | 3AE-07921-0 | ** RETAINER |
| 22 | 3AE-07923-0 | ** COTTER |
| 23 | 3AE-07203-0 | * VALVE SPRING L=35 |
| 24 | 3H6-07205-0 | * VALVE SPRING SEAT |
| 25 | 3R3-07204-0 | * INTAKE VALVE STEM SEAL |
| 26 | 3R3-07206-0 | * EXHAUST VALVE STEM SEAL |
| 27 | 3AE-07600-0 | * OIL PUMP ASSY |
| 28 | 9101F4-0645 | * BOLT |
| 30 | 3R0-07639-0 | * O-RING φ1.9 |
| 31 | 3AD-01005-0 | CYLINDER HEAD GASKET |
| 32 | 3H8-01013-0 | CYLINDER HEAD BOLT 8-60 |
| 33 | 345-01111-0 | DOWEL PIN 6-12 |
| 34 | 9161F4-0653 | BOLT |
| 35 | 9401E3-0600 | WASHER |
| 36 | 3R0-01094-0 | PLATE |
| 37 | 910121-0612 | BOLT |
| 40 | 3ACB01020-0 | CYLINDER HEAD COVER ASSY |
| 41 | 3R0-01024-0 | CYLINDER HEAD COVER GASKET |
| 42 | 9101F4-5630 | BOLT |
| 43 | 3T4-06972-1 | CLAMP 6.5-87P |
| 44 | 3R0-07431-0 | BREATHER CHAMBER COVER |
| 45 | 921521-5508 | SCREW |
| 46 | 3R0-71015-1 | OIL FILLER CAP |
| 47 | 3R0-07422-0 | O-RING 3.1-24.4 |
| 48 | 9701-1-1103 | SPARK PLUG (DCPR6E) |
| 49 | 3AC-07435-0 | BREATHER HOSE |
| 51 | 3R0-07737-1 | CLIP φ15.5 |
| 52 | 98AM120-290 | HOSE |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3NVB01100-0 | CYL BLOCK & CRANKCASE ASSY |
| 2 | 345-01111-0 | * DOWEL PIN 6-12 |
| 3 | 3H8-07636-0 | * OIL FILTER BOLT |
| 4 | 3R0-01113-1 | * BOLT 8-90 |
| 5 | 9161F9-0640 | * BOLT |
| 6 | 9401E3-0600 | * WASHER |
| 7 | 3BJ-07615-0 | OIL FILTER |
| 8 | 3NV-01030-0 | THERMOSTAT |
| 9 | 3H6B01031-0 | THERMOSTAT CAP |
| 10 | 346-01032-0 | THERMOSTAT CAP GASKET |
| 11 | 9101E3-5630 | BOLT |
| 12 | 3P0-01143-0 | ANODE PLUG |
| 13 | 3T5-10046-0 | O-RING 1.9-13 |
| 14 | 3P0-60218-0 | ANODE |
| 15 | 921503-0530 | SCREW |
| 16 | 3R0-01303-0 | ENGINE BASEMENT GASKET |
| 17 | 3AC-69000-0 | STARTER LOCK CABLE BRACKET |
| 18 | 910103-0612 | BOLT |
| 19 | 3C7-01513-2 | HANGER |
| 20 | 9101F4-5820 | BOLT |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3NVB01300-0 | ENGINE BASEMENT ASSY |
| 2 | 3V2-07620-0 | PLUNGER ASSY |
| 3 | 3R3-07710-1 | OIL STRAINER ASSY |
| 4 | 98AH-95-220 | HOSE |
| 5 | 369-84398-0 | BAND 158 |
| 6 | 3AC-07421-0 | OIL LEVEL GAUGE |
| 7 | 346-01215-0 | OIL SEAL 16-28-6 |
| 8 | 3R0-61012-0 | DRIVE SHAFT HOUSING GASKET |
| 9 | 3R0-67116-0 | ENGINE BASEMENT SEAL |
| 10 | 345-01111-0 | DOWEL PIN 6-12 |
| 11 | 3AEQ61192-2 | DRIVE SHAFT HOUSING (L) |
| 12 | 3R0-65207-0 | WATER PIPE STOPPER |
| 13 | 3R3-07705-1 | DRAIN BOLT 14-14 |
| 14 | 3R3-07406-0 | WASHER 14.5-24-1 |
| 15 | 3B7-61017-3 | BOLT 8-105 |
| 16 | 3R0-61017-1 | BOLT 8-40 |
| 17 | 9401E3-0800 | WASHER |
| 18 | 3R0Q61028-0 | COVER |
| 19 | 3R0-61029-0 | GASKET |
| 20 | 9101E3-5618 | BOLT |
| 21 | 345-06915-0 | CLAMP 6.5-14L |
| 22 | 3ACQ61208-0 | IDLE EXHAUST PORT COVER |
| 23 | 3AC-62114-0 | PLATE |
| 24 | 3R0-61207-0 | IDLE EXHAUST PORT GASKET |
| 25 | 3AC-61220-1 | IDLE EXHAUST PORT GASKET |
| 26 | 9101E3-5620 | BOLT |
| 27 | 3AC-61182-0 | GROMMET |
| 28 | 3NVQ61210-0 | APRON |
| 29 | 3F3-67213-1 | SEAL L=263 |
| 30 | 3T1-61213-0 | SEAL |
| 31 | 3AC-61217-0 | TAPPING SCREW M6-60 |
| 32 | 9401E3-0600 | WASHER |
| 33 | 3NV-61212-0 | GROMMET |
| 34 | 346Q61110-5 | EXTENSION HOUSING |
| 35 | 9161E3-0835 | BOLT |
| 36 | 9161E3-0845 | BOLT |
| 37 | 3P0-66233-0 | WASHER 8.1-16-1.5 |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3H6-07611-0 | OIL PRESSURE SWITCH |
| 2 | 3KY-07612-0 | GROMMET |
| 3 | 3AC-07613-0 | OIL PRESSURE SWITCH LEAD WIRE L=160 |
| 4 | 3Y9-72514-0 | WATER TEMPERATURE SENSOR |
| 5 | 3G9-66136-0 | * O-RING 2-10 |
| 6 | 3AC-76065-2 | RECTIFIER COMPLETE |
| 8 | 3AC-76066-0 | FUSE WIRE ASSY |
| 9 | 3T5-76247-0 | * FUSE 20A |
| 10 | 3A3-76037-0 | CABLE TERMINAL PLUG |
| 11 | 3C8-76010-1 | STARTER MOTOR ASSY |
| 12 | 3C8-76015-0 | * PINION ASSY |
| 13 | 3C8-75015-0 | * WASHER |
| 14 | 3C8-75014-0 | * BRUSH HOLDER ASSY |
| 15 | 921521-6408 | * SCREW |
| 16 | 3C8-75016-0 | * BUSHING |
| 17 | 3C8-75017-0 | * BUSHING |
| 18 | 3C8-75018-0 | * O-RING |
| 21 | 930203-0600 | * NUT |
| 22 | 3C8-75019-0 | * BOLT |
| 23 | 941321-0500 | * SPRING WASHER |
| 24 | 940221-0500 | * WASHER |
| 25 | 910103-5830 | BOLT |
| 26 | 3R0-76009-0 | STARTER MOTOR BAND |
| 27 | 3C8-76007-0 | DAMPER |
| 28 | 910103-5820 | BOLT |
| 29 | 3AC-76120-0 | BATTERY CABLE L=2500 |
| 30 | 3AA-76145-0 | TERMINAL CAP 13-13-28 |
| 31 | 3R3-76141-0 | STARTER CABLE L=270 |
| 33 | 3Y0-76145-0 | TERMINAL CAP 8-18-28 |
| 34 | 910103-5612 | BOLT |
| 35 | 3AC-06901-0 | BRACKET |
| 36 | 3T5-84398-0 | BAND 104 |
| 38 | 3AC-10211-0 | ISC VALVE |
| 39 | 940103-0600 | WASHER |
| 41 | 3AC-02501-0 | PLATE |
| 42 | 3AC-06920-0 | RUBBER MOUNT 11.8-14-1.5 |
| 43 | 3A0-76079-0 | COLLAR 6.2-9-7.4 |
| 44 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 45 | 910103-0620 | BOLT |
| 46 | 3AC-62004-0 | CORD HOLDER |
| 47 | 910103-5625 | BOLT |
| 48 | 3AC-76171-0 | OVERHEAT BUZZER |
| 49 | 3AC-10215-0 | MAT SENSOR |
| 50 | 3AC-04319-0 | GROMMET 8-2.5 |
| 51 | 3AC-06135-0 | HOLDER |
| 52 | 3H8-76040-0 | STARTER SOLENOID |
| 53 | 910103-5610 | BOLT |
| 54 | 3AC-72580-0 | PTT SOLENOID SWITCH (A) |
| 55 | 3AC-72581-0 | PTT SOLENOID SWITCH (B) |
| 56 | 930103-0600 | * NUT |
| 57 | 941303-0600 | * SPRING WASHER |
| 58 | 3C7-72583-0 | SOLENOID SWITCH CORD (B) L=150 |
| 59 | 3C8-72583-1 | SOLENOID SWITCH CORD (B) L=150 |
| 60 | 3Y1-76145-0 | TERMINAL CAP 8-13-28 |
| 61 | 3AC-72569-0 | EXTENSION CORD (PTT) |
| 63 | 3AC-06919-0 | COVER ASSY |
| 64 | 309-65032-0 | GROMMET 10.2-8 |
| 65 | 910103-5616 | BOLT |
| 66 | 910103-5620 | BOLT |
| 67 | 3AC-72028-0 | WIRING DIAGRAM DECAL |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AC-10150-0 | VAPOR SEPARATOR ASSY |
| 2 | 3AC-03235-0 | * O-RING |
| 3 | 921503-6416 | * SCREW |
| 4 | 3AC-03230-0 | * FLOAT |
| 5 | 3F3-03232-0 | * FLOAT ARM PIN |
| 6 | 344-03244-0 | * CLIP |
| 7 | 921503-0408 | * SCREW |
| 8 | 3R3-03239-0 | * FLOAT VALVE ASSY |
| 9 | 3AC-03292-0 | * DRAIN SCREW |
| 10 | 3AC-03116-0 | * O-RING |
| 11 | 3AC-06952-0 | * TERMINAL HOLDER |
| 12 | 3AD-03116-0 | * O-RING |
| 13 | 3AC-04310-0 | * FUEL FEED PUMP ASSY |
| 14 | 3AC-04322-0 | * FILTER (INLET) |
| 15 | 3AC-10154-0 | * FUEL REGULATOR |
| 16 | 3AC-10095-0 | * O-RING |
| 17 | 3AC-04313-0 | * GROMMET 10.4-4 |
| 18 | 3AC-03234-0 | * SCREW |
| 19 | 98AB-30-300 | * HOSE |
| 20 | 3AD-04319-0 | * GROMMET |
| 21 | 346-67115-0 | WASHER 6.5-21-1 |
| 22 | 346-67113-0 | MOUNT 8.5-14-2.5 |
| 23 | 3B7-06920-0 | RUBBER MOUNT 8.5-14-2.5 |
| 24 | 346-67114-1 | SPACER 6.2-9-15.7 |
| 25 | 910103-0630 | BOLT |
| 26 | 3T4-06972-1 | CLAMP 6.5-87P |
| 27 | 98AB-30-540 | HOSE |
| 28 | 3AC-10175-0 | FUEL COOLER ASSY |
| 29 | 3AC-10046-0 | * O-RING 1.9-7.8 |
| 30 | 3AC-10164-0 | * O-RING 1.9-6.8 |
| 31 | 921503-6410 | * SCREW |
| 32 | 910103-5635 | BOLT |
| 33 | 3AC-02239-0 | PLATE |
| 34 | 3AC-10019-0 | GASKET |
| 35 | 3ACB10143-0 | HIGH PRESSURE FUEL FILTER |
| 36 | 3AC-10145-0 | FUEL FILTER RUBBER MOUNT |
| 37 | 3AD-02209-0 | LOW PERMEATION HOSE L=190 |
| 38 | 3AC-02209-0 | LOW PERMEATION HOSE L=140 |
| 39 | 3AC-02210-0 | LOW PERMEATION HOSE L=100 |
| 40 | 3AL-02210-0 | LOW PERMEATION HOSE L=340 |
| 41 | 3AD-02210-0 | LOW PERMEATION HOSE L=300 |
| 42 | 3AC-70013-0 | PIPE JOINT |
| 43 | 3AD-06157-0 | PROTECTOR φ18-240 |
| 44 | 3AD-06133-0 | PROTECTOR φ18-130 |
| 45 | 3AC-10087-0 | CLAMP φ16.8 |
| 46 | 3AC-09056-1 | CLIP φ13.5 |
| 47 | 3T5-10086-0 | CLAMP 21/32 |
| 48 | 3NV-65210-0 | COOLING HOSE |
| 50 | 3AC-10144-0 | FUEL FILTER BAND |
| 51 | 910103-5616 | BOLT |
| 52 | 3H8-04000-1 | FUEL PUMP ASSY |
| 53 | 3H8-62415-0 | O-RING 3.5-25.7 |
| 54 | 910103-5625 | BOLT |
| 55 | 98AB-50-370 | HOSE |
| 56 | 98AB-50-600 | HOSE |
| 58 | 3NW-04055-0 | LOW PERMEATION HOSE |
| 59 | 3GT-35143-0 | CLIP φ9.4 |
| 60 | 3AD-02230-0 | FUEL FILTER ASSY |
| 61 | 3AD-02237-0 | * CUP |
| 62 | 3AD-02235-0 | * O-RING |
| 63 | 3AD-02234-0 | * FILTER |
| 64 | 930103-0800 | NUT |
| 65 | 940103-0800 | WASHER |
| 66 | 941303-0800 | SPRING WASHER |
| 67 | 3AC-10320-0 | AIR VENT ASSY |
| 68 | 3AC-06302-0 | RUBBER MOUNT |
| 69 | 3AC-76174-0 | STAY |
| 70 | 98AB-50-040 | HOSE |
| 71 | 3AD-10170-0 | ORIFICE |
| 72 | 338-02215-0 | CLIP φ10 |
| 73 | 98AL-40-620 | HOSE |
| 74 | 338-01133-0 | CLIP φ7 |
| 75 | 369-84398-0 | BAND 158 |
| 76 | 3NV-04055-0 | LOW PERMEATION HOSE |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3H6-70200-2 | PRIMER BULB ASSY |
| 2 | 3C7-70220-1 | * JOINT ASSY (INLET) |
| 3 | 3C7-70224-1 | * JOINT ASSY (OUTLET) |
| 4 | 3GF-70211-1 | * PRIMER BULB |
| 5 | 3C7-70217-0 | * CLAMP |
| 6 | 98AB-70-700 | * HOSE |
| 7 | 98AB-701600 | * HOSE |
| 8 | 3GR-70280-0 | * FUEL CONNECTOR MARK |
| 9 | 3GF-70281-0 | * FUEL CONNECTOR |
| 10 | 3GR-70250-0 | * FUEL CONNECTOR |
| 11 | 332-70201-0 | * CLAMP |
| 12 | 3C7-70177-1 | FUEL TANK ASSY 25L |
| 13 | 3AC-70177-2 | FUEL TANK ASSY 25L |
| 14 | 3C7-70050-1 | * FUEL GAUGE VENT CAP ASSY (25L) |
| 15 | 3AC-70052-1 | * FUEL TANK CAP ASSY |
| 16 | 3AC-70055-0 | * RETAINING RING |
| 18 | 3C7-70155-0 | * PICK-UP ELBOW ASSY (25L) |
| 19 | 3E0-70270-0 | * QUICK-CONNECTOR (MALE) |
| 20 | 3C7-70199-0 | * O-RING |
| 21 | 3C7-70113-0 | * FILTER |
| 22 | 3AC-70157-0 | * FUEL PICK-UP ASSY W/GAUGE |
| 23 | 3AC-70140-0 | * SCREW |
| 24 | 3AC-70145-0 | * WASHER |
| 25 | 3AC-70150-0 | * GASKET |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AEQ60000-2 | GEAR CASE ASSY |
| 2 | 3AE-60211-0 | * ROLLER BEARING 20-27-30 |
| 3 | 332-60005-2 | PLUG 8-8 |
| 4 | 332-60006-0 | GASKET 8.1-15-1 |
| 5 | 3C8-60217-1 | TRIM TAB |
| 6 | 910103-5620 | BOLT |
| 7 | 369-60206-0 | WATER STRAINER |
| 8 | 9218E3-0620 | SCREW |
| 9 | 3NV-64020-0 | BEVEL GEAR B |
| 10 | 346-64027-1 | NUT |
| 11 | 346-64327-0 | DRIVE SHAFT SPRING |
| 12 | 346-64328-0 | DRIVE SHAFT SPRING GUIDE |
| 13 | 3R0-64301-0 | DRIVE SHAFT (S) |
| 14 | 346-60213-0 | TAPERED ROLLER BEARING 32004 |
| 15 | 345-65021-0 | WATER PUMP IMPELLER |
| 16 | 332-65022-0 | KEY 20-4.6-2 |
| 17 | 3R0-65016-0 | PUMP CASE (UPPER) |
| 18 | 3R0-65011-0 | PUMP CASE LINER |
| 19 | 3B7-65014-0 | WATER PIPE SEAL (LOWER) |
| 20 | 346-65017-2 | PUMP CASE (LOWER) |
| 21 | 346-65013-0 | OIL SEAL 17-30-9 |
| 22 | 348-65029-1 | GUIDE PLATE GASKET |
| 23 | 3R0-65018-0 | PUMP CASE GASKET |
| 24 | 334-65012-0 | DOWEL PIN 4-10 |
| 25 | 336-62415-0 | O-RING 3.5-36 |
| 26 | 3R0-65025-0 | WATER PUMP GUIDE PLATE |
| 27 | 9101E3-5652 | BOLT |
| 28 | 346-64084-0 | SHIM 35-41.9-0.5 |
| 29 | 3NV-66014-0 | CAM ROD (UL) |
| 30 | 3AC-66011-1 | CLUTCH CAM |
| 31 | 951407-0312 | SPRING PIN 3-12 |
| 32 | 3R0-66031-0 | CAM ROD BUSHING |
| 33 | 332-66021-0 | O-RING 2.4-5.8 |
| 34 | 3C8-66032-0 | O-RING 3.5-21.7 |
| 35 | 9101E3-5612 | BOLT |
| 36 | 3R0-66308-0 | WASHER 6-16-1.5 |
| 37 | 346-66037-0 | CAM ROD HOLDER |
| 38 | 9161E3-0840 | BOLT |
| 39 | 9161E3-0845 | BOLT |
| 40 | 9153E3-0830 | STUD |
| 41 | 9301E3-0800 | NUT |
| 42 | 9401E3-0800 | WASHER |
| 43 | 3R0-65120-0 | WATER PIPE (UL) |
| 44 | 3R0-65206-0 | WATER PIPE SEAL (UPPER) |
| 45 | 98AM120-015 | HOSE |
| 46 | 3A1-60235-0 | WATER STRAINER SET |
| 47 | 930403-0400 | * NYLON NUT 4-P0.7 |
| 48 | 9215E3-0430 | * SCREW |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 346-60215-0 | TAPERED ROLLER BEARING 30205 |
| 2 | 349Q60100-7 | PROPELLER SHAFT HOUSING ASSY |
| 3 | 346Q60101-8 | * PROPELLER SHAFT HOUSING |
| 4 | 346-60102-0 | * ROLLER BEARING 18-25-2.5 |
| 5 | 9601-0-6205 | * BALL BEARING 6205 |
| 6 | 332-60103-0 | * O-RING 3-62.5 |
| 7 | 3AC-60111-0 | * OIL SEAL 18-28-8 |
| 8 | 9101E3-5830 | BOLT |
| 9 | 3NV-64010-0 | BEVEL GEAR ASSY (A) |
| 10 | 369-64082-1 | SHIM 26.5-34.8-0.15 |
| 11 | 3NV-64030-0 | BEVEL GEAR C |
| 12 | 346-64032-0 | WASHER 18-24-1.5 |
| 13 | 346-64211-6 | PROPELLER SHAFT |
| 14 | 3AC-64215-1 | CLUTCH |
| 15 | 346-64218-0 | PIN |
| 16 | 332-64221-0 | SPRING |
| 17 | 350-64222-1 | SPRING RETAINER |
| 18 | 346-64219-0 | SNAP |
| 19 | 3C8-64223-1 | PUSH ROD |
| 20 | 965002-0803 | BALL 3/8 |
| 21 | 3R0B64527-0 | PROPELLER ASSY (13") |
| 22 | 3R0-87326-0 | PROPELLER HARDWARE KIT |
| 23 | 346-64231-5 | * THRUST HOLDER |
| 24 | 346-64124-5 | * WASHER 12.5-32-2.5 |
| 25 | 346-64121-5 | * PROPELLER NUT |
| 26 | 951503-0322 | * SPLIT PIN 3-22 |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AC-02010-1 | INTAKE MANIFOLD ASSY |
| 2 | 345-01111-0 | * DOWEL PIN 6-12 |
| 3 | 3R0-02095-0 | * BOLT 5-10 |
| 4 | 3R0-02112-0 | * WASHER 5.3-12-1 |
| 5 | 3AC-10200-0 | FUEL RAIL ASSY |
| 6 | 3AC-10162-0 | * O-RING 1.9-4.8 |
| 7 | 3AC-77367-0 | * JOINT |
| 8 | 3AC-10098-0 | * VALVE ASSY (PRESSURE CHECK) |
| 9 | 3AC-10099-0 | * CAP |
| 10 | 3AC-10169-0 | * HOLDING PLATE |
| 11 | 921503-0410 | * SCREW |
| 12 | 3AC-10300-1 | * FUEL INJECTOR ASSY |
| 13 | 3AC-10304-1 | ** O-RING 3.6-6.5 |
| 14 | 3AC-10303-1 | ** O-RING |
| 15 | 3AC-10161-0 | * NIPPLE 8-6-13 |
| 16 | 3T5-10162-0 | * O-RING 1.9-9.8 |
| 17 | 3T5-10169-0 | * HOLDING PLATE |
| 20 | 309-06972-0 | CLAMP 6.5-47.5P |
| 21 | 3AC-10214-0 | MAP SENSOR |
| 22 | 98AL-40-110 | HOSE |
| 23 | 338-01133-0 | CLIP φ7 |
| 24 | 3AC-07233-0 | PLATE |
| 25 | 910103-5616 | BOLT |
| 26 | 3AC-06920-0 | RUBBER MOUNT 11.8-14-1.5 |
| 27 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 28 | 3A0-76079-0 | COLLAR 6.2-9-7.4 |
| 29 | 910103-0620 | BOLT |
| 30 | 3AC-03952-0 | INSULATOR |
| 31 | 3AC-02012-0 | O-RING 1.9-31.2 |
| 32 | 9161F4-0653 | BOLT |
| 33 | 940103-0600 | WASHER |
| 34 | 930103-0600 | NUT |
| 36 | 3AC-02203-0 | FUEL HOSE |
| 37 | 3AD-10100-1 | THROTTLE BODY ASSY |
| 38 | 3AD-63749-0 | THROTTLE CAM ASSY |
| 39 | 3AC-63727-1 | SPRING |
| 40 | 353-76079-0 | COLLAR 6.2-9-9.3 |
| 41 | 910103-0625 | BOLT |
| 42 | 346-67115-0 | WASHER 6.5-21-1 |
| 43 | 3AC-10104-0 | GASKET |
| 44 | 910103-5625 | BOLT |
| 45 | 3AD-02409-0 | INTAKE SILENCER ASSY |
| 46 | 3AC-02418-0 | GASKET |
| 47 | 910103-5620 | BOLT |
| 48 | 3AC-02409-0 | INTAKE SILENCER ASSY |
| 49 | 3AC-02416-0 | * INTAKE SILENCER COVER |
| 50 | 3AC-10130-0 | * AIR FILTER |
| 51 | 3AC-02414-0 | * INTAKE SILENCER GASKET |
| 52 | 3AC-05913-0 | * TAPPING SCREW 5-16 |
| 53 | 3AC-63624-0 | GROMMET |
| 54 | 3AC-63737-0 | STAY |
| 55 | 910103-5612 | BOLT |
| 56 | 3AD-02203-0 | FUEL HOSE |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AD-06101-0 | FLYWHEEL ASSY |
| 2 | 3AC-06123-0 | ALTERNATOR ASSY |
| 3 | 334-00131-0 | KEY 19-7-5 |
| 4 | 353-00132-0 | NUT 18-P1.5 |
| 5 | 353-00133-0 | WASHER 19-34-3 |
| 6 | 3AC-01047-0 | PLUG |
| 7 | 3AD-06864-0 | PRE-COATED BOLT 6-25 |
| 8 | 3AC-06008-1 | COIL BRACKET |
| 9 | 3AC-06864-0 | PRE-COATED BOLT 6-30 |
| 10 | 3AC-06071-0 | PULSAR COIL #1 |
| 11 | 3AD-06071-0 | PULSAR COIL #2 |
| 12 | 910103-5512 | BOLT |
| 14 | 398-06972-0 | CLAMP 6.5-67P |
| 15 | 910103-5612 | BOLT |
| 16 | 3PB-06401-0 | ECU ASSY （25 EU） |
| 17 | 3AC-03169-0 | * PLUG |
| 18 | 910103-0616 | BOLT |
| 20 | 3T4-06972-1 | CLAMP 6.5-87P |
| 21 | 3AC-10204-0 | ECU BRACKET ASSY |
| 22 | 3AC-06920-0 | RUBBER MOUNT 11.8-14-1.5 |
| 23 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 24 | 3A0-76079-0 | COLLAR 6.2-9-7.4 |
| 25 | 910103-0620 | BOLT |
| 26 | 3AC-06133-0 | PROTECTOR φ8-22 |
| 27 | 3NW-10205-0 | ECU CORD ASSY |
| 28 | 3A3-76037-0 | CABLE TERMINAL PLUG |
| 30 | 3T5-84398-0 | BAND 104 |
| 32 | 369-84398-0 | BAND 158 |
| 33 | 3AC-76091-0 | LEAD WIRE BAND 200 |
| 34 | 3AC-06469-0 | IGNITION COIL W/R-CAP |
| 35 | 3AC-06999-0 | * PLUG CAP W/RESISTANCE |
| 36 | 910103-5620 | BOLT |
| 37 | 309-06972-0 | CLAMP 6.5-47.5P |
| 38 | 336-76091-0 | LEAD WIRE BAND 100 |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GL-72571-0 | TRIM METER KIT |
| 2 | 3GL-72524-0 | HOUR METER ASSY |
| 3 | 3GL-72529-0 | VOLTMETER ASSY |
| 4 | 3GL-72672-0 | SPEEDOMETER KIT (60MPH) |
| 5 | 3GL-72596-0 | FUEL METER ASSY |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3KY-72637-0 | TOCS STARTER KIT |
| 2 | 3KY-76131-0 | * ENGINE DROP CABLE |
| 3 | 3KY-76120-0 | * BATTERY CABLE |
| 5 | 3KY-76153-0 | * TERMINATOR (MALE) |
| 6 | 3KY-76152-0 | * TERMMINATOR (FEMALE) |
| 7 | 3KY-76151-0 | * TEE CONNECTOR |
| 9 | 3KY-72600-0 | FUEL METER KIT |
| 10 | 3NV-76133-0 | INTERFACE CABLE |
| 11 | 3KY-72573-0 | EXTENSION CORD (TRIM SENSOR) L=6000 |
| 12 | 3KY-76132-0 | TRUNK CABLE L=5m |
| 13 | 3KY-72638-0 | TACHOMETER KIT |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3BJ-72100-0 | TOOL KIT |
| 2 | 3B7-72201-0 | SAFETY ROPE φ5-1600 |
| 3 | 3AC-76160-2 | RECTIFIER KIT |
| 4 | 3AC-76065-2 | * RECTIFIER COMPLETE |
| 5 | 910103-5625 | * BOLT |
| 6 | 3AC-76161-0 | * EXTENSION CORD L=3000 |
| 7 | 3T5-76247-0 | ** FUSE 20A |
| 8 | 3B7-72530-2 | TACHOMETER ASSY |
| 14 | 3N8-72640-1 | TACHOMETER W/OIL LAMP |
| 15 | 3B7-72658-0 | * OIL BULB 12V-1.7W |
| 16 | 3B7-72659-0 | * METER BULB 12V-1.8W |
| 17 | 3B7-72656-0 | * METER DAMPER |
| 18 | 3B7-72661-0 | * FITTING PLATE |
| 19 | 930103-0500 | * NUT |
| 20 | 941303-0500 | * SPRING WASHER |
| 21 | 361-72539-0 | TACHOMETER LEAD WIRE L=6000 |
| 32 | 3E0-72529-0 | VOLTMETER ASSY |
| 35 | 3B7-72662-0 | * FITTING PLATE |
| 38 | 3E0-72524-0 | HOUR METER ASSY |
| 39 | 3B7-72657-0 | * METER BULB 12V-1.7W |
| 41 | 3B7-72664-0 | * FITTING PLATE |
| 44 | 3R0-72525-2 | TRIM METER KIT |
| 45 | 3T1-72571-0 | * TRIM METER ASSY |
| 46 | 3T1-72659-0 | ** METER BULB 12V-1.7W |
| 47 | 3T1-72653-0 | ** METER BULB CAP |
| 48 | 3B7-72655-0 | ** METER DAMPER |
| 49 | 3T1-72665-0 | ** FITTING PLATE |
| 50 | 941303-0400 | ** SPRING WASHER |
| 51 | 930203-0400 | ** NUT |
| 52 | 3Z4-72574-0 | * TRIM SENSOR L=1700 |
| 53 | 910103-0620 | * BOLT |
| 54 | 3C8-66308-0 | * WASHER 6-16-1.5 |
| 55 | 336-06973-0 | * CLAMP 6-9.5L |
| 56 | 921503-5612 | * SCREW |
| 57 | 3T1-72573-0 | * EXTENSION CORD (TRIM SENSOR) L=6000 |
| 58 | 3R0-72537-1 | METER LEAD WIRE L=2000 |
| 59 | 353-72548-0 | ASSIST CORD (BLK) L=200 |
| 60 | 3T1-72405-0 | * HOSE JOINT (WATER-WORKS) |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AC-00030-1 | CRANKSHAFT ASSY |
| 2 | 3AE-07408-0 | PLAIN SHAFT BEARING |
| 3 | 3R0-00122-0 | OIL SEAL 38-50-8 |
| 4 | 3R0-00121-0 | OIL SEAL 35-50-8 |
| 5 | 3R0-00040-0 | CONNECTING ROD ASSY |
| 6 | 3H6-00059-0 | * CONNECTING ROD BOLT |
| 7 | 3FS-87130-0 | PISTON REPAIR KIT |
| 8 | 3AE-00001-1 | * PISTON |
| 9 | 3AE-00021-0 | * PISTON PIN |
| 10 | 3H6-00024-0 | * PISTON PIN CLIP |
| 11 | 3FS-87123-0 | PISTON RING SET |
| 12 | 3AC-00011-0 | * PISTON RING |
| 13 | 3AC-00012-0 | * PISTON RING |
| 14 | 3AC-00013-0 | * PISTON RING-OIL |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AC-77175-0 | MANUAL VALVE ASSY |
| 2 | 3R0-77409-0 | * SEAL SET |
| 3 | 3R0-77177-0 | * O-RING 2.4-9.8 |
| 4 | 3Z5-77171-0 | C-RING |
| 5 | 3AD-77367-0 | JOINT |
| 6 | 3AC-77374-0 | NUT |
| 7 | 3AC-77382-0 | DUST SEAL |
| 8 | 3AC-77384-0 | O-RING 2.4-12.3 |
| 9 | 3AC-77361-0 | CYLINDER |
| 10 | 3AC-77363-0 | INNER TUBE |
| 11 | 3AC-77365-0 | PISTON ROD ASSY |
| 12 | 3AC-77375-0 | O-RING 2-28.5 |
| 13 | 3AC-77377-0 | FREE PISTON |
| 14 | 3AC-77376-0 | BACK-UP RING |
| 15 | 3AC-77398-0 | O-RING 2.4-27.7 |
| 16 | 3AC-77392-0 | O-RING 2-43.5 |
| 17 | 3AC-77383-0 | O-RING 2-34.5 |
| 18 | 3AC-77173-0 | SEAL WASHER |
| 19 | 3AC-77453-0 | VALVE SEAT |
| 20 | 3R0-77451-0 | O-RING 1.5-3.5 |
| 21 | 3R0-77457-0 | BALL |
| 22 | 3AC-77454-0 | SPRING SEAT |
| 23 | 3R0-77455-0 | SPRING |
| 24 | 3B7-77433-0 | O-RING 1.5-6.5 |
| 25 | 3R0-77430-0 | PUMP |
| 26 | 3B7-77431-1 | BOLT |
| 27 | 3E0-77163-0 | COUPLING |
| 28 | 3AC-77180-0 | MOTOR ASSY |
| 29 | 3R0-77167-0 | O-RING 2-62.5 |
| 30 | 3C8-77182-0 | O-RING 2.4-66.6 |
| 31 | 3R0-77165-0 | RESERVE TANK |
| 32 | 3R0-77159-0 | BOLT |
| 33 | 3R0-77168-0 | CAP |
| 34 | 3R0-77169-0 | O-RING 1.9-9.8 |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3R0-10060-0 | DRIVE PULLEY |
| 2 | 3T5-10131-0 | KEY 13.4-5-4 |
| 3 | 3R0-10063-0 | BELT GUIDE |
| 4 | 3R0-10068-0 | NUT |
| 5 | 3R0-10069-0 | LOCK WASHER |
| 6 | 3H8-10062-2 | DRIVEN PULLEY |
| 7 | 309-00131-0 | KEY 10-3.7-3 |
| 8 | 3H8-10066-0 | WASHER 6.5-19-3.2 |
| 9 | 3AA-60108-0 | PRE-COATED BOLT 6-20 |
| 10 | 3AC-10045-0 | TIMING BELT |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3AC-05090-0 | RECOIL STARTER ASSY |
| 2 | 3AC-05105-0 | * STARTER CASE |
| 3 | 3H8-05004-0 | * STARTER SPRING |
| 4 | 3R3-05106-0 | * REEL |
| 5 | 3R3-05003-0 | * RATCHET |
| 6 | 3R3-05011-0 | * E-RING d=10 |
| 7 | 3R3-05012-0 | * RETURN SPRING |
| 8 | 3H8-05123-1 | * RETURN SPRING |
| 9 | 3R3-05006-0 | * FRICTION PLATE |
| 10 | 3R3-05138-0 | * BOLT |
| 11 | 3R3-05013-0 | * STARTER ROPE φ5-1800 |
| 12 | 3AC-05019-0 | * STARTER HANDLE |
| 13 | 3AB-05131-0 | * ROPE ANCHOR |
| 14 | 3R3-05252-0 | * STARTER LOCK |
| 15 | 3R3-05216-0 | * STARTER LOCK SPRING |
| 16 | 3R3-05007-0 | * FRICTION SPRING |
| 17 | 3AC-05258-0 | STARTER LOCK CAM SPRING |
| 18 | 3AC-05207-0 | STARTER LOCK WIRE |
| 19 | 3NV-67503-0 | STARTER SEAL |
| 20 | 3AL-60108-0 | PRE-COATED BOLT 6-20 |
| 21 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 22 | 3F3-76042-2 | NUT |
| 23 | 3R3-06308-0 | BELT COVER |
| 24 | 3R0-06303-1 | COLLAR 6.2-9-12.3 |
| 25 | 3BJ-06283-0 | COLLAR 6.1-9-7.4 |
| 26 | 910103-0620 | BOLT |
| 27 | 910103-0625 | BOLT |
| 28 | 3PA-72181-0 | CAUTION DECAL (B) |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3NV-83880-1 | REMOTE CONTROL FITTING ASSY |
| 2 | 3NV-66122-0 | * SHIFT ARM |
| 3 | 3KY-76079-0 | * COLLAR 6.5-10.5-9.3 |
| 4 | 3C8-66308-0 | * WASHER 6-16-1.5 |
| 5 | 910103-5620 | * BOLT |
| 6 | 3NV-66134-0 | * SHIFT LEVER ROD |
| 7 | 3B7-83715-2 | * CABLE JOINT |
| 8 | 3AA-83719-0 | * WASHER 8.5-18-1.6 |
| 9 | 951603-0800 | * SNAP PIN d=8 |
| 10 | 3R0-66126-0 | * BRACKET |
| 11 | 3NV-83734-0 | * CABLE CLIP |
| 12 | 9101E3-5616 | * BOLT |
| 13 | 3NV-83732-0 | * GROMMET |
| 14 | 345-67117-0 | * GROMMET 17-2.7 |
| 15 | 3NV-83830-0 | * STEERING HOOK PLATE |
| 16 | 910103-1030 | * BOLT |
| 17 | 940103-1000 | * WASHER |
| 18 | 3FW-84905-0 | DRAG LINK ASSY |
| 19 | 353-84918-0 | * NYLON NUT 3/8-24UNF |
| 20 | 353-84916-0 | * WASHER 9.6-18-2 |
| 21 | 3F3-84908-0 | * SEAL RING |
| 22 | 3FW-84914-0 | * SPACER 9.6-19-26.5 |
| 23 | 3E0-84917-0 | * BOLT 3/8-50 |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3Y3-66110-0 | SHIFT LEVER |
| 2 | 3H6-63619-1 | COLLAR 6.5-10.5-10 |
| 3 | 346-67115-0 | WASHER 6.5-21-1 |
| 4 | 9101E3-0625 | BOLT |
| 5 | 3NVQ67480-0 | SHIFT LEVER BRACKET |
| 6 | 9101E3-5616 | BOLT |
| 7 | 3NW-66134-0 | SHIFT LEVER ROD |
| 8 | 3AA-83719-0 | WASHER 8.5-18-1.6 |
| 9 | 951603-0800 | SNAP PIN d=8 |
| 10 | 3NV-66130-0 | SHIFT LEVER SHAFT ASSY |
| 11 | 3GF-66113-1 | SHIFT LEVER STOPPER |
| 12 | 3C8-66116-0 | SHIFT LEVER STOPPER |
| 13 | 3V1-66145-0 | HOLDER |
| 15 | 9101E3-5612 | BOLT |
| 16 | 3NV-63621-0 | GROMMET |
| 17 | 3NV-63508-0 | THROTTLE WIRE BRACKET |
| 18 | 3NV-63622-0 | THROTTLE DRUM ASSY |
| 19 | 3KY-76079-0 | COLLAR 6.5-10.5-9.3 |
| 20 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 21 | 910103-0620 | BOLT |
| 22 | 3NV-63617-0 | THROTTLE ROD |
| 23 | 3R0-66211-0 | SHIFT ROD |
| 24 | 3AL-66241-1 | SHIFT ROD JOINT |
| 25 | 951403-0312 | SPRING PIN 3-12 |
| 26 | 3M2-66226-0 | GROMMET 17-3 |
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3NVQ67645-0 | TOP COWL ASSY (SERVICE) |
| 2 | 3NVQ67640-0 | * TOP COWL SUB-ASSY |
| 3 | 3NV-67501-0 | ** TOP COWL SEAL |
| 4 | 3R0-67517-0 | ** ROLLER 6.1-14.7-14 |
| 5 | 945303-0500 | ** E-RING d=5 |
| 6 | 346-67115-0 | ** WASHER 6.5-21-1 |
| 7 | 3NW-87801-0 | * DECAL SET MFS25C |
| 8 | 3KY-67531-0 | * FRONT DECAL |
| 9 | 3R0-72180-0 | CAUTION DECAL (A) |
| 10 | 3AC-72185-0 | CAUTION DECAL |
Regular maintenance keeps your Tohatsu MFS25/30C running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.
