Images
Product
Price
Qty
Options
- $23.51
- $23.51
- Unit price
- per
$23.51
$38.50
$8.41
$8.41
Customer Service: info@jlm-marine.com
Free shipping. No Minimum Purchase
Tohatsu MD30/40/50B2/MWD50B2 (2018) Parts & Diagrams
🔎 Tohatsu MD30/40/50B2/MWD50B2 Reference Library — Exploded parts diagrams (36 diagrams), specifications, common issues, and maintenance checklist.
The Tohatsu MD30/40/50B2/MWD50B2 is a 2-Stroke TLDI outboard motor. Commonly used on jon boats, pontoons, and mid-size utility craft.
Quick Reference Specifications
| Specification | Value |
|---|---|
| Engine Type | 2-Stroke TLDI |
| Horsepower | 30 HP |
| Displacement | 697 |
| Bore x Stroke | 68 x 64 |
| Spark Plug (Type & Gap) | NGK IZFR6Q |
| Engine Oil Capacity | — |
| Recommended Engine Oil | TC-W3 Certified 2-Stroke Oil |
| Gear Case Oil Capacity | — |
| Idle Speed (in gear) | — |
| Full Throttle RPM Range | 5150-5850 |
| Fuel | Unleaded Gasoline, 87 Octane min. |
Always verify specifications against your owner's manual for your specific serial number range.
Common Issues & Recommended Parts
Below are common maintenance scenarios for the Tohatsu MD30/40/50B2/MWD50B2:
- Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
- Fuel System Issues / Hard Starting: Stale fuel and ethanol-related deposits are common in 2-stroke carbureted engines. Clean or rebuild carburetors and replace fuel lines if deteriorated. → Recommended: Carburetor Repair Kit, Fuel Line Assembly
- Spark Plug Fouling: 2-stroke engines are prone to spark plug fouling from oil residue, especially at low RPM. Replace plugs at each annual service. → Recommended: OEM Spark Plugs
- Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
- Thermostat Failure: A stuck thermostat can cause overheating or poor warm-up. Replace if operating temperature is inconsistent. → Recommended: Thermostat Assembly
Parts Diagrams & OEM Part Numbers
Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Tohatsu MD30/40/50B2/MWD50B2.
▶Fig.01CYLINDER・CRANK CASE (51 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5B01100-0 | CYL BLOCK & CRANKCASE ASSY |
| 3 | 910103-0618 | * BOLT |
| 4 | 353-76079-0 | * COLLAR 6.2-9-9.3 |
| 5 | 916124-0845 | * BOLT |
| 7 | 3B7-76093-0 | GROMMET 25-5 |
| 8 | 3T5B01021-0 | CYLINDER HEAD COVER |
| 9 | 3T5-01024-0 | CYLINDER HEAD COVER GASKET |
| 10 | 334-65012-0 | DOWEL PIN 4-10 |
| 11 | 910121-5620 | BOLT |
| 12 | 345-01030-0 | THERMOSTAT |
| 13 | 3T5B01031-1 | THERMOSTAT CAP ASSY |
| 14 | 3T5-01032-0 | THERMOSTAT CAP GASKET |
| 15 | 9101E3-5625 | BOLT |
| 16 | 3GFB01091-0 | CYLINDER HEAD |
| 17 | 3T5-01005-0 | CYLINDER HEAD GASKET |
| 18 | 345-01111-0 | DOWEL PIN 6-12 |
| 19 | 3C8-01012-0 | CYLINDER HEAD BOLT |
| 20 | 345-01015-0 | WASHER 8.5-19.5-3.2 |
| 21 | 3T5-06971-1 | CLAMP 8.5-85P |
| 22 | 3C8-01513-1 | HANGER |
| 23 | 9101F4-0835 | BOLT |
| 24 | 940121-0800 | WASHER |
| 25 | 3Z5B02300-1 | EXHAUST COVER ASSY |
| 26 | 3C8-02302-0 | EXHAUST COVER (INNER) |
| 27 | 3C8-02305-2 | EXHAUST COVER GASKET |
| 28 | 9161F9-0630 | BOLT |
| 29 | 940103-0600 | WASHER |
| 30 | 940121-0600 | WASHER |
| 31 | 3T4-06972-1 | CLAMP 6.5-87P |
| 32 | 9106E3-0808 | BOLT |
| 33 | 332-60006-0 | GASKET 8.1-15-1 |
| 34 | 338-60218-2 | ANODE |
| 36 | 9701-1-1111 | SPARK PLUG(IZFR6Q) |
| 37 | 98AB-50-250 | HOSE φ5-φ10 |
| 38 | 98AB-50-075 | HOSE |
| 39 | 98AB-50-115 | HOSE |
| 40 | 338-02215-0 | CLIP φ10 |
| 41 | 393-01160-0 | CHECK VALVE |
| 42 | 98AL-40-355 | HOSE |
| 43 | 98AL-40-205 | HOSE |
| 44 | 98AL-40-335 | HOSE |
| 45 | 338-01133-0 | CLIP φ7 |
| 46 | 3PR-06972-0 | CLAMP 6.5-47.5P |
| 47 | 910103-0610 | BOLT |
| 48 | 910103-5610 | BOLT |
| 49 | 3T7-01175-0 | NIPPLE ASSY (CHECK VALVE) |
| 50 | 3C8-01291-0 | CRANKCASE HEAD |
| 51 | 346-01216-0 | O-RING 1.7-59 |
| 52 | 3T5-00122-0 | OIL SEAL 25-40-8 |
| 53 | 3C8-01215-0 | OIL SEAL 16-28-7 |
| 54 | 910103-5620 | BOLT |
▶Fig.02PISTON・CRANK SHAFT (15 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-00050-1 | CRANKSHAFT ASSY W/GEAR |
| 2 | 3J2-00114-0 | * MAIN BEARING 6305 |
| 3 | 3C8-09060-0 | * OIL PUMP DRIVE GEAR |
| 4 | 945107-2500 | * C-RING d=25 |
| 5 | 345-00042-0 | ROLLER BEARING 17-21-27 |
| 6 | 3T5-00113-0 | MAIN BEARING |
| 7 | 3T5-00121-0 | * OIL SEAL 36-46-6 |
| 8 | 353-00108-0 | O-RING 2.4-44.7 |
| 9 | 346-00115-0 | THRUST PLATE |
| 10 | 3GF-87131-0 | PISTON REPAIR KIT (0.5 O/S) |
| 11 | 3GF-00004-1 | * PISTON (0.5 O/S) |
| 12 | 3C8-00021-1 | * PISTON PIN |
| 13 | 334-00024-1 | * PISTON PIN CLIP |
| 14 | 3GF-87124-0 | PISTON RING SET (0.5 O/S) |
| 15 | 3T5-00014-0 | * PISTON RING (0.5 O/S) |
▶Fig.03AIR CHAMBER (11 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5B02240-0 | AIR CHAMBER ASSY |
| 2 | 3T5-02100-1 | REED VALVE ASSY |
| 3 | 3T5-02104-2 | INTAKE MANIFOLD GASKET |
| 4 | 921521-6516 | SCREW |
| 5 | 3T5-02241-0 | BOLT 6-25 |
| 6 | 3GFB02246-0 | AIR CHAMBER COVER ASSY |
| 7 | 345-76092-0 | GROMMET 20-3 |
| 8 | 3GF-01139-0 | SEALING CAP |
| 9 | 3T5-02245-0 | AIR CHAMBER COVER GASKET |
| 10 | 910103-5625 | BOLT |
| 11 | 3Z5-06972-1 | CLAMP 7-120P |
▶Fig.04 AIR RAIL (51 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-10080-1 | AIR RAIL ASSY |
| 2 | 3T5-10166-0 | NIPPLE |
| 3 | 3T5-10098-0 | VALVE ASSY (PRESSURE CHECK) |
| 4 | 3T5-10167-0 | PLUG 10.5 |
| 5 | 3T5-10164-1 | O-RING 1.9-6.8 |
| 6 | 3T5-10165-0 | PLUG STOPPER |
| 7 | 910103-6612 | BOLT |
| 8 | 98AY-45-105 | HOSE |
| 9 | 3T5-10091-0 | CLAMP 29/64 |
| 10 | 910103-0865 | BOLT |
| 11 | 940103-0800 | WASHER |
| 12 | 3T5-06971-1 | CLAMP 8.5-85P |
| 13 | 3GF-10310-0 | AIR INJECTOR COMPLETE |
| 14 | 3T5-10317-0 | * O-RING 5-52 |
| 15 | 3Y9-10311-1 | * O-RING 2.4-9.6 |
| 16 | 3Y9-10312-0 | DISC SPRING |
| 17 | 3T5-10314-0 | FUEL INJECTOR INSERT |
| 18 | 3T5-10316-0 | SEAL |
| 19 | 3T5-10315-0 | FUEL INJECTOR ADAPTER |
| 20 | 3T5-10300-0 | FUEL INJECTOR ASSY |
| 21 | 3T5-10304-0 | * O-RING 2.8-20.2 |
| 22 | 3T5-10303-0 | * O-RING 3.5-7.5 |
| 23 | 3T5-10148-0 | FUEL REGULATOR ASSY |
| 26 | 3GF-10090-0 | AIR REGULATOR ASSY |
| 27 | 3T5-10095-0 | * O-RING 2.5-20 |
| 28 | 3T5-10094-0 | * O-RING 2.5-5 |
| 29 | 3T5-10302-0 | HOLDING PLATE |
| 30 | 3Y9-10302-0 | HOLDING PLATE |
| 31 | 3PR-06972-0 | CLAMP 6.5-47.5P |
| 32 | 3T5-10088-0 | AIR HOSE ASSY |
| 34 | 3GF-10089-0 | FUEL HOSE ASSY |
| 35 | 3T5-10162-0 | * O-RING 1.9-9.8 |
| 36 | 3Z4-06157-0 | * PROTECTOR φ18-135 |
| 37 | 3T5B10143-0 | * HIGH PRESSURE FUEL FILTER |
| 38 | 3T5-10145-0 | * FUEL FILTER RUBBER MOUNT |
| 39 | 3U1-06157-0 | * PROTECTOR φ18-150 |
| 40 | 3T5-10086-0 | * CLAMP 21/32 |
| 41 | 3Z5-10144-0 | FUEL FILTER BAND |
| 42 | 3T5-10169-0 | HOLDING PLATE |
| 43 | 3T5-10153-0 | COLLAR 6.7-12.7-3 |
| 44 | 910103-6616 | BOLT |
| 45 | 3A3-62396-1 | GROUND L=110 |
| 46 | 3T5-10099-0 | CAP |
| 47 | 98AB-50-530 | HOSE |
| 48 | 3Z0-84398-0 | BAND 203 |
| 49 | 3GJ-02165-1 | FUEL HOSE W/PROTECTOR |
| 50 | 3GT-35143-0 | CLIP φ9.4 |
| 51 | 345-06915-0 | CLAMP 6.5-14L |
| 52 | 98AB-50-280 | HOSE |
| 53 | 338-02215-0 | CLIP φ10 |
| 54 | 3T5-72196-0 | AIR RAIL DECAL |
▶Fig.05 AIR COMPRESSOR (32 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-10060-0 | DRIVE PULLEY |
| 2 | 3T5-10068-2 | NUT |
| 3 | 3T5-10131-0 | KEY ｔ=4 |
| 4 | 3T5-10063-0 | BELT GUIDE |
| 5 | 3GFB10000-0 | AIR COMPRESSOR ASSY |
| 6 | 3GFB10009-0 | * COMPRESSOR HEAD ASSY |
| 8 | 3T5-04308-0 | ** ADAPTER |
| 9 | 3T5-04309-0 | ** WASHER 10.2-17-2 |
| 10 | 910124-7630 | * BOLT |
| 11 | 3T5-10012-1 | * GASKET |
| 12 | 3T5-10010-0 | * REED VALVE ASSY |
| 13 | 3T5-10019-0 | * GASKET |
| 14 | 3GF-87330-0 | * PISTON & CONNECTING ROD ASSY |
| 15 | 3T5-10025-0 | * AIR COMPRESSOR PISTON RING |
| 16 | 3GF-87331-0 | * COMPRESSOR CRANKSHAFT ASSY |
| 17 | 9601-0-6203 | * BALL BEARING 6203 |
| 18 | 3T1-10042-0 | * COLLAR 13.5-25-13 |
| 19 | 3T5-10046-0 | * O-RING 1.9-13 |
| 20 | 3GFB10048-0 | * AIR COMPRESSOR CYLINDER ASSY |
| 21 | 3T5B10051-0 | * AIR COMPRESSOR HOUSING ASSY |
| 22 | 3T5-10054-0 | * GASKET |
| 23 | 3T5-10041-0 | * OIL SEAL 25-45-8 |
| 24 | 910103-5625 | * BOLT |
| 26 | 3PR-06972-0 | * CLAMP 6.5-47.5P |
| 27 | 3T5-10062-0 | * DRIVEN PULLEY |
| 28 | 309-00132-0 | * NUT 10-P1.25 |
| 29 | 3B7-01116-0 | * WASHER 10.5-20-3.2 |
| 30 | 910103-7835 | BOLT |
| 31 | 334-65012-0 | DOWEL PIN 4-10 |
| 32 | 3T5-10061-0 | DRIVE BELT |
| 33 | 3GF-10130-0 | AIR FILTER ASSY |
| 34 | 98AT130-060 | HOSE |
▶Fig.06 FUEL FEED PUMP (25 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-04310-0 | FUEL FEED PUMP ASSY |
| 2 | 3T5-04302-0 | * FUEL FEED PUMP |
| 3 | 3T5-04311-0 | * CASE ASSY |
| 4 | 3T5-04312-0 | * UPPER CASE ASSY |
| 5 | 3T5-04308-0 | * ADAPTER |
| 6 | 3T5-04309-0 | * WASHER 10.2-17-2 |
| 7 | 3T5-04116-0 | * GASKET |
| 8 | 3T5-04313-0 | * GROMMET 37.3-18 |
| 9 | 3T5-04314-0 | * GROMMET 24.3-35-5 |
| 10 | 3T5-04236-0 | * CABLE TERMINAL ASSY (POSITIVE) |
| 11 | 3T5-04237-0 | * CABLE TERMINAL ASSY (NEGATIVE) |
| 12 | 3T5-04317-0 | * GROMMET |
| 13 | 3T5-04318-0 | * GROMMET |
| 14 | 3T5-04238-0 | * CORD |
| 15 | 3T5-04239-0 | * CORD COVER |
| 16 | 910103-5512 | * BOLT |
| 17 | 940103-0500 | * WASHER |
| 18 | 3PR-06972-0 | * CLAMP 6.5-47.5P |
| 19 | 3T5-04319-0 | * GROMMET 7.5-16.8 |
| 20 | 910103-6518 | * BOLT |
| 21 | 910103-6630 | BOLT |
| 22 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 23 | 3F3-06920-0 | RUBBER MOUNT 8.5-12-2 |
| 24 | 346-67114-1 | SPACER 6.2-9-15.7 |
| 25 | 3T5-06920-0 | RUBBER MOUNT 8.5-18-7 |
▶Fig.07 THROTTLE (35 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3C8-63711-1 | ADVANCER ARM |
| 2 | 3C8-63733-0 | ROD SNAP 5-3 |
| 3 | 3T5-63702-1 | LINK ROD ASSY (THROTTLE) |
| 4 | 3T5-10109-1 | LINK ROD ASSY (TPS) |
| 5 | 910103-0635 | BOLT |
| 7 | 3C8-63732-0 | COLLAR 6.2-12-17 |
| 8 | 3B7-83715-2 | CABLE JOINT |
| 9 | 3AA-83719-0 | WASHER 8.5-18-1.6 |
| 10 | 951603-0800 | SNAP PIN d=8 |
| 11 | 3C8-05213-0 | THROTTLE LIMITER ARM |
| 12 | 9101F4-0625 | BOLT |
| 13 | 910103-0610 | BOLT |
| 15 | 353-76079-0 | COLLAR 6.2-9-9.3 |
| 16 | 398-06972-0 | CLAMP 6.5-67P |
| 17 | 3C8-05221-0 | THROTTLE LIMITER ROD 3.5-56 |
| 18 | 3C8-05223-0 | ROD SNAP 3.5-4 |
| 19 | 3GM-10100-0 | THROTTLE BODY ASSY |
| 20 | 3T5-63718-0 | THROTTLE CAM |
| 21 | 3T5-63721-0 | BUSHING 6-24-7 |
| 22 | 910103-6618 | BOLT |
| 23 | 346-67115-0 | WASHER 6.5-21-1 |
| 24 | 346-05228-1 | BALL JOINT |
| 25 | 930203-0600 | NUT |
| 26 | 940103-0600 | WASHER |
| 27 | 3T5-10110-0 | TPS ASSY |
| 28 | 3T5-10107-0 | * RUBBER MOUNT |
| 29 | 3T5-10128-0 | COLLAR 4.2-6-10.5 |
| 30 | 921503-6420 | SCREW |
| 31 | 3T5-10129-0 | WASHER 4.2-12.5-0.8 |
| 32 | 98AB-30-310 | HOSE |
| 33 | 3T5-84398-0 | BAND 104 |
| 34 | 338-01133-0 | CLIP φ7 |
| 35 | 3T5-10104-0 | GASKET |
| 36 | 3T5-02241-0 | BOLT 6-25 |
| 37 | 3T5-72195-0 | TPS DECAL |
▶Fig.08 VAPOR SEPARATOR・FUEL LINE (49 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-10150-1 | VAPOR SEPARATOR ASSY |
| 2 | 922531-6414 | * SCREW |
| 3 | 921503-6430 | * SCREW |
| 4 | 3T5-03230-0 | * FLOAT |
| 5 | 3F3-03232-0 | * FLOAT ARM PIN |
| 6 | 921503-0408 | * SCREW |
| 7 | 3R3-03239-0 | * FLOAT VALVE ASSY |
| 8 | 344-03244-0 | * CLIP |
| 9 | 3T5-03235-0 | * O-RING |
| 10 | 345-03292-0 | * DRAIN SCREW |
| 11 | 336-03293-0 | * O-RING |
| 12 | 910103-6630 | BOLT |
| 13 | 346-67115-0 | WASHER 6.5-21-1 |
| 14 | 346-67113-0 | MOUNT 8.5-14-2.5 |
| 15 | 3B7-06920-0 | RUBBER MOUNT 8.5-14-2.5 |
| 16 | 346-67114-1 | SPACER 6.2-9-15.7 |
| 17 | 98AB-50-075 | HOSE |
| 18 | 3GA-02165-0 | FUEL HOSE W/PROTECTOR L=75 |
| 20 | 3T5-84398-0 | BAND 104 |
| 21 | 98AB-70-180 | HOSE |
| 22 | 3GF-02170-1 | FUEL HOSE W/PROTECTOR L=180 |
| 23 | 3C7-02215-0 | CLIP φ12 |
| 24 | 356-04000-1 | FUEL PUMP ASSY |
| 25 | 334-04004-0 | * PUMP COVER |
| 26 | 9225F2-6528 | * SCREW |
| 27 | 334-04005-0 | * PUMP DIAPHRAGM |
| 28 | 334-04007-0 | * DIAPHRAGM GASKET |
| 29 | 356-04044-0 | * CHECK VALVE |
| 30 | 921722-0306 | * SCREW |
| 31 | 930222-0300 | * NUT |
| 32 | 356-04030-0 | * DIAPHRAGM GASKET SET |
| 33 | 346-04901-2 | GASKET |
| 34 | 910103-6640 | BOLT |
| 35 | 98AB-50-190 | HOSE |
| 36 | 3GG-02165-1 | FUEL HOSE W/PROTECTOR L=190 |
| 38 | 3GT-35143-0 | CLIP φ9.4 |
| 39 | 3T5-02230-0 | FUEL FILTER ASSY |
| 40 | 3B7-02237-0 | * CUP |
| 41 | 3B7-02235-0 | * O-RING |
| 42 | 3B7-02234-0 | * FILTER |
| 43 | 3T5-02229-0 | * FLOAT |
| 44 | 3B7-02236-0 | * O-RING |
| 45 | 930103-0800 | NUT |
| 46 | 940103-0800 | WASHER |
| 47 | 3GF-02239-0 | PLATE |
| 48 | 910103-6614 | BOLT |
| 49 | 98AB-50-260 | HOSE |
| 50 | 3GF-02165-0 | FUEL HOSE W/PROTECTOR L=260 |
| 51 | 338-02215-0 | CLIP φ10 |
▶Fig.09 MAGNETO (13 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-06191-0 | FLYWHEEL W/RING GEAR |
| 2 | 3Y9-06123-0 | ALTERNATOR ASSY |
| 3 | 921503-0635 | SCREW |
| 4 | 941303-0600 | SPRING WASHER |
| 5 | 334-00131-0 | KEY 19-7-5 |
| 6 | 353-00132-0 | NUT 18-P1.5 |
| 7 | 353-00133-0 | WASHER 19-34-3 |
| 8 | 3T5-06145-0 | PICK-UP COIL |
| 9 | 910103-6512 | BOLT |
| 10 | 3T5-06008-1 | COIL BRACKET |
| 11 | 910103-7625 | BOLT |
| 12 | 3PR-06972-0 | CLAMP 6.5-47.5P |
| 13 | 334-65012-0 | DOWEL PIN 4-10 |
▶Fig.10 ELECTRIC PARTS (ECU・DIAGRAM) (42 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GM-06401-1 | ECU ASSY |
| 2 | 910103-6630 | BOLT |
| 3 | 346-67115-0 | WASHER 6.5-21-1 |
| 4 | 346-67113-0 | MOUNT 8.5-14-2.5 |
| 5 | 3B7-06920-0 | RUBBER MOUNT 8.5-14-2.5 |
| 6 | 3T5-67114-0 | SPACER 6.2-9-16.6 |
| 8 | 3Z5-06469-0 | IGNITION COIL W/R-CAP |
| 11 | 3Z5-06470-0 | IGNITION COIL W/R-CAP |
| 12 | 3H6-06999-0 | * PLUG CAP W/RESISTANCE |
| 13 | 369-84398-0 | * BAND 158 |
| 14 | 910103-7635 | BOLT |
| 15 | 3PR-06972-0 | CLAMP 6.5-47.5P |
| 17 | 910103-6614 | BOLT |
| 18 | 3Z5-76060-2 | RECTIFIER COMPLETE |
| 19 | 910103-5620 | BOLT |
| 20 | 3GF-76110-1 | CORD ASSY |
| 21 | 3A3-76037-0 | CABLE TERMINAL PLUG |
| 22 | 353-76037-0 | CABLE TERMINAL PLUG |
| 23 | 3T5-72585-0 | SOLENOID SWITCH BRACKET ASSY |
| 24 | 3T9-76064-0 | FUSE HOLDER BRACKET |
| 25 | 3T5-06437-0 | TAPPING SCREW 6-16 |
| 26 | 3T4-06972-1 | CLAMP 6.5-87P |
| 27 | 3H8-76040-0 | STARTER SOLENOID |
| 28 | 910103-5610 | BOLT |
| 29 | 3R3-76141-0 | STARTER CABLE L=270 |
| 31 | 3Y9-76062-1 | FUSE WIRE ASSY |
| 32 | 3Z5-76066-0 | FUSE WIRE ASSY |
| 33 | 3T5-76249-0 | * FUSE 30A |
| 34 | 3Y9-76248-0 | * FUSE 25A |
| 35 | 3T5-76246-0 | * FUSE 15A |
| 36 | 3C8-72580-0 | PTT SOLENOID SWITCH (A) |
| 37 | 3C8-72581-0 | PTT SOLENOID SWITCH (B) |
| 37a | 930103-0600 | * NUT |
| 37b | 941303-0600 | * SPRING WASHER |
| 38 | 3T5-76142-1 | GROUND CABLE L=140&285 |
| 39 | 910103-6625 | BOLT |
| 40 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 41 | 3F3-06920-0 | RUBBER MOUNT 8.5-12-2 |
| 42 | 3T5-76079-0 | COLLAR 6.2-9-10.7 |
| 43 | 3A3-76145-0 | TERMINAL CAP 8-13-28 |
| 45 | 3Y9-72514-0 | WATER TEMPERATURE SENSOR |
| 46 | 3G9-66136-0 | * O-RING 2-10 |
▶Fig.11 ELECTRIC PARTS (STARTER MOTOR) (30 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-06301-0 | RING GEAR COVER |
| 2 | 3GF-06304-0 | COLLAR 9.1-16-10.8 |
| 3 | 3B7-06305-0 | RUBBER MOUNT 9-16-4.3 |
| 4 | 3KZ-72181-1 | CAUTION DECAL (B) |
| 5 | 3Y9-72194-0 | FUSE DECAL |
| 7 | 3FW-72026-0 | SPARK PLUG DECAL (IZFR6Q) |
| 8 | 910103-0625 | BOLT |
| 9 | 3GF-76010-0 | STARTER MOTOR ASSY |
| 10 | 3GF-76015-0 | * PINION ASSY |
| 11 | 3GF-75015-0 | * WASHER |
| 12 | 3GF-75014-0 | * BRUSH HOLDER ASSY |
| 13 | 921521-6408 | * SCREW |
| 14 | 3GF-75016-0 | * BUSHING 1 |
| 15 | 3GF-75017-0 | * BUSHING 2 |
| 16 | 3GF-75018-0 | * O-RING |
| 17 | 940103-0600 | * WASHER |
| 18 | 941303-0600 | * SPRING WASHER |
| 19 | 930203-0600 | * NUT |
| 20 | 3GF-75019-0 | * BOLT |
| 21 | 941321-0500 | * SPRING WASHER |
| 22 | 940221-0500 | * WASHER |
| 23 | 910103-5825 | BOLT |
| 24 | 3T5B05101-0 | BRACKET |
| 25 | 3C8-76007-0 | DAMPER |
| 26 | 3C8-76009-0 | STARTER MOTOR BAND |
| 27 | 910103-6825 | BOLT |
| 28 | 910103-6820 | BOLT |
| 29 | 3B7-76120-2 | BATTERY CABLE L=3000 |
| 30 | 910103-6616 | BOLT |
| 31 | 3B7-76145-0 | TERMINAL CAP 8-13-30 |
▶Fig.12 OIL PUMP (43 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5-09000-0 | OIL PUMP ASSY |
| 2 | 3B7-09002-0 | * O-RING 1.6-19.2 |
| 3 | 3B7-09004-0 | * AIR VENT BOLT |
| 4 | 3B7-09006-0 | * WASHER |
| 5 | 3C8-09050-1 | OIL PUMP BOLT |
| 6 | 941303-0600 | SPRING WASHER |
| 7 | 3C8-09065-0 | OIL PUMP DRIVEN GEAR |
| 8 | 3C8-09069-0 | BUSHING 9-20-20.8 |
| 9 | 3C8-09053-1 | OIL PUMP ROD |
| 10 | 3B7-05243-0 | BALL JOINT CONNECTOR |
| 11 | 930103-0500 | NUT |
| 12 | 3B7-09075-1 | CHECK VALVE COMPLETE |
| 13 | 99AA-6-0570 | PIPE |
| 14 | 99AA-6-0175 | PIPE |
| 15 | 3GT-35143-0 | CLIP φ9.4 |
| 18 | 99AA-2-0120 | PIPE |
| 19 | 99AA-2-0160 | PIPE |
| 20 | 99AA-2-0140 | PIPE |
| 22 | 99AA-2-0200 | PIPE |
| 23 | 99AA-2-0100 | PIPE |
| 24 | 3B7-09052-0 | CLIP φ6.9 |
| 25 | 3T5-84398-0 | BAND 104 |
| 26 | 3T5-71010-0 | OIL TANK |
| 27 | 3C8-71015-0 | OIL FILLER CAP |
| 28 | 3C8-71016-0 | GASKET 36-52-2 |
| 29 | 3C8-71017-0 | CAP HOOK |
| 30 | 3C8-71018-0 | OIL TANK CAP CHECK VALVE |
| 31 | 3T5-71020-0 | OIL LEVEL SENSOR |
| 32 | 910103-6630 | BOLT |
| 33 | 346-67115-0 | WASHER 6.5-21-1 |
| 34 | 346-67113-0 | MOUNT 8.5-14-2.5 |
| 35 | 3B7-06920-0 | RUBBER MOUNT 8.5-14-2.5 |
| 36 | 346-67114-1 | SPACER 6.2-9-15.7 |
| 37 | 3T4-06972-1 | CLAMP 6.5-87P |
| 38 | 3C7-71030-0 | OIL FILTER ASSY |
| 39 | 3B7-02237-0 | * CUP |
| 40 | 3B7-02235-0 | * O-RING |
| 41 | 3C7-71033-0 | * FILTER |
| 42 | 3B7-02236-0 | * O-RING |
| 43 | 930103-0800 | NUT |
| 44 | 940103-0800 | WASHER |
| 45 | 3T5-02239-0 | PLATE |
| 46 | 910103-6614 | BOLT |
▶Fig.13 DRIVE SHAFT HOUSING (27 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3C8Q01301-0 | ENGINE BASEMENT |
| 2 | 3C8-01303-4 | ENGINE BASEMENT GASKET |
| 3 | 3C8-67116-0 | ENGINE BASEMENT SEAL L=805 |
| 4 | 910103-5625 | BOLT |
| 5 | 345-01111-0 | DOWEL PIN 6-12 |
| 6 | 3E3-02311-0 | EXHAUST PIPE |
| 7 | 3C8-02319-0 | BOLT 8-30 |
| 8 | 3C8-02312-2 | EXHAUST PIPE GASKET |
| 9 | 3C8Q61192-4 | DRIVE SHAFT HOUSING (L) |
| 10 | 3C8-61012-2 | DRIVE SHAFT HOUSING GASKET |
| 11 | 3MC-61017-0 | BOLT |
| 12 | 9401E3-0800 | WASHER |
| 13 | 3C8Q61110-0 | EXTENSION HOUSING |
| 14 | 9101E3-5835 | BOLT |
| 15 | 346-65204-0 | WATER PIPE AUXILIARY MOUNT |
| 16 | 346-66037-0 | CAM ROD HOLDER |
| 17 | 353-66024-0 | STOPPER |
| 18 | 910103-5612 | BOLT |
| 19 | 3C8-61180-0 | EXHAUST HOUSING |
| 20 | 3C8-61182-0 | GROMMET |
| 21 | 3C8-61184-0 | BOLT 8-30 |
| 22 | 3C8-61181-2 | EXHAUST HOUSING GASKET |
| 23 | 3C8Q61210-1 | APRON |
| 24 | 3C8-61212-0 | GROMMET |
| 25 | 3C8-61213-1 | SEAL |
| 26 | 9215E3-5540 | SCREW |
| 27 | 930403-0500 | NYLON NUT 5-P0.8 |
▶Fig.14 GEAR CASE (DRIVE SHAFT) (47 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3C8Q60090-1 | GEAR CASE ASSY |
| 2 | 345-60211-0 | * ROLLER BEARING 22-30-30 |
| 3 | 332-60005-2 | PLUG 8-8 |
| 4 | 332-60006-0 | GASKET 8.1-15-1 |
| 5 | 3B7-60015-1 | PLUG M10P1.25 |
| 6 | 3B7-60016-1 | GASKET 10.1-15-1 |
| 7 | 3C8-60217-1 | TRIM TAB |
| 8 | 910103-5620 | BOLT |
| 9 | 3C8-64020-2 | BEVEL GEAR B |
| 10 | 3C8-64027-0 | NUT |
| 11 | 345-64084-0 | SHIM 41-51.5-0.5 |
| 12 | 3C8-64303-0 | DRIVE SHAFT (UL) |
| 13 | 3C8-60213-0 | BALL BEARING 6304 |
| 14 | 3C8-64327-0 | DRIVE SHAFT SPRING |
| 15 | 3C8-65021-2 | WATER PUMP IMPELLER |
| 16 | 332-65022-0 | KEY 20-4.6-2 |
| 17 | 3T5-65016-0 | PUMP CASE (UPPER) |
| 18 | 3T5-65011-0 | PUMP CASE LINER |
| 19 | 3C8-65014-0 | WATER PIPE SEAL (LOWER) |
| 20 | 3C8-65017-1 | PUMP CASE (LOWER) |
| 21 | 3C8-64084-0 | SHIM 32.9-26-0.5 |
| 22 | 3C8-60223-0 | OIL SEAL 17-33-6 |
| 23 | 345-65015-0 | O-RING 3.2-47 |
| 24 | 334-65012-0 | DOWEL PIN 4-10 |
| 25 | 3C8-65025-0 | WATER PUMP GUIDE PLATE |
| 26 | 3C8-65029-2 | GUIDE PLATE GASKET |
| 27 | 3T5-65018-2 | PUMP CASE GASKET |
| 28 | 9101E3-5855 | BOLT |
| 29 | 3C8-60204-0 | SUB-WATER INLET STRAINER |
| 30 | 910103-5616 | BOLT |
| 31 | 3C8-66011-0 | CLUTCH CAM |
| 32 | 3C8-66014-0 | CAM ROD (UL) |
| 33 | 951407-0312 | SPRING PIN 3-12 |
| 34 | 3C8-66031-1 | CAM ROD BUSHING |
| 35 | 332-66021-0 | O-RING 2.4-5.8 |
| 36 | 3C8-66032-0 | O-RING 3.5-21.7 |
| 37 | 3C8-66241-0 | SHIFT ROD JOINT |
| 38 | 951403-0312 | SPRING PIN 3-12 |
| 39 | 353-66024-0 | STOPPER |
| 40 | 9101E3-5612 | BOLT |
| 41 | 9101E3-5835 | BOLT |
| 42 | 3C8-65120-0 | WATER PIPE (UL) |
| 43 | 345-65206-0 | WATER PIPE SEAL (UPPER) |
| 44 | 345-65205-0 | COLLAR 18-20-4.5 |
| 45 | 3C8-60205-1 | WATER STRAINER SET |
| 46 | 921503-0438 | * SCREW |
| 47 | 930403-0400 | * NYLON NUT 4-P0.7 |
▶Fig.15 GEAR CASE (PROPELLER SHAFT) (28 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 345-60215-0 | TAPERED ROLLER BEARING 32007 |
| 2 | 3C8Q60100-1 | PROPELLER SHAFT HOUSING ASSY |
| 3 | 3C8Q60101-1 | * PROPELLER SHAFT HOUSING |
| 4 | 9601-0-6007 | * BALL BEARING 6007 |
| 5 | 345-60103-0 | * O-RING 3.5-69.4 |
| 6 | 345-60211-0 | * ROLLER BEARING 22-30-30 |
| 7 | 3F3-60223-0 | * OIL SEAL 22-37-8 |
| 8 | 3C8-60108-2 | PRE-COATED BOLT 6-25 6-25 |
| 9 | 9401E3-0600 | WASHER |
| 10 | 3C8-64010-1 | BEVEL GEAR ASSY (A) |
| 11 | 3C8-64030-0 | BEVEL GEAR C |
| 12 | 345-64032-0 | WASHER 22.1-28-3 |
| 13 | 353-64038-0 | SHIM 36-44-0.1 |
| 14 | 3C8-64211-0 | PROPELLER SHAFT |
| 15 | 3C8-64215-2 | CLUTCH |
| 16 | 3C8-64217-0 | PIN |
| 17 | 3C8-64219-1 | SNAP |
| 18 | 3C8-64221-0 | SPRING |
| 19 | 3C8-64222-0 | SPRING RETAINER |
| 20 | 3C8-64223-1 | PUSH ROD |
| 21 | 965002-0803 | BALL 3/8 |
| 22 | 3T5B64532-1 | PROPELLER ASSY (15) |
| 23 | 3TW-87326-0 | PROPELLER HARDWARE KIT |
| 24 | 3C8-64231-0 | * THRUST HOLDER |
| 25 | 3TW-64232-0 | * STOPPER |
| 26 | 3TW-64124-0 | * WASHER 17-40-3 |
| 27 | 353-64121-0 | * PROPELLER NUT M16P1.5 |
| 28 | 951503-0325 | * SPLIT PIN 3-25 |
▶Fig.16 BRACKET (1) MANUAL TILT (EFO/EPO MODEL) (57 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3C8Q62112-1 | CLAMP BRACKET (R) |
| 2 | 3C8Q62113-1 | CLAMP BRACKET (L) |
| 3 | 3AC-62191-0 | SWIVEL BRACKET SHAFT ASSY |
| 4 | 346-62124-1 | NYLON NUT 7/8-14 |
| 5 | 349-62126-0 | BUSHING |
| 6 | 3C8-62132-0 | BUSHING 22-25-35.5 |
| 7 | 346-62127-0 | CAP NUT |
| 8 | 3C8-62117-1 | DISTANCE PIECE 9.4-13.8-116 |
| 9 | 930103-0800 | NUT |
| 11 | 3C8-62120-1 | BOLT 8-170 |
| 12 | 3C8-62121-1 | THRUST ROD |
| 13 | 345-62122-2 | THRUST ROD SPRING |
| 14 | 3C8Q62310-3 | SWIVEL BRACKET |
| 15 | 3E3Q62010-0 | STEERING SHAFT ASSY |
| 16 | 345-62417-0 | BUSHING 26-32 |
| 17 | 3A0-62423-2 | THRUST PLATE (UPPER) 27-50-1 |
| 18 | 346-62424-1 | THRUST PLATE (LOWER) 26.5-46-1 |
| 19 | 3H8-62415-0 | O-RING 3.5-25.7 |
| 20 | 945103-2500 | C-RING d=25 |
| 21 | 940103-0600 | WASHER |
| 22 | 3C8-61302-1 | RUBBER MOUNT (LOWER) |
| 23 | 3C8Q61411-3 | MOUNT BRACKET |
| 24 | 3C8-61336-0 | DAMPER (LOWER) |
| 25 | 3C8-61321-1 | BOLT 12-114.5 |
| 27 | 3C7-61338-0 | DAMPER 21-36-5 |
| 28 | 930403-1200 | NYLON NUT 12-P1.75 |
| 29 | 9402E3-1200 | WASHER |
| 30 | 3C8Q61342-0 | MOUNT HOLDING PLATE (LOWER) |
| 31 | 9101E3-5620 | BOLT |
| 32 | 3B7-60218-1 | ANODE |
| 33 | 910103-5630 | BOLT |
| 34 | 3E3-61301-2 | RUBBER MOUNT (UPPER) |
| 35 | 353-61307-1 | BOLT 3/8-100 |
| 36 | 3E3-61333-0 | DAMPER (UPPER) |
| 37 | 353-61335-0 | WASHER 10-29-3 |
| 38 | 3E3-61335-0 | LOCK PLATE |
| 39 | 3C8-61341-0 | MOUNT HOLDING PLATE (UPPER) |
| 40 | 9101E3-5835 | BOLT |
| 41 | 3C8-62396-1 | GROUND L=210 |
| 42 | 398-62396-1 | GROUND L=130 |
| 44 | 3A3-62396-1 | GROUND L=110 |
| 45 | 910103-5612 | BOLT |
| 46 | 345-62441-0 | FRICTION PIECE |
| 47 | 346-62421-1 | FRICTION SPRING |
| 49 | 3C8-72120-0 | RIGGING BOLT SET |
| 50 | 3C7-62133-2 | * BOLT 12-105 P1.25 |
| 51 | 353-61334-0 | * WASHER 13-34-3 |
| 52 | 940103-1200 | * WASHER |
| 53 | 3C7-62139-1 | * NUT 12-P1.25 |
| 54 | 3RSQ62105-0 | CLAMP SCREW KIT |
| 55 | 3RSQ62108-0 | * CLAMP SCREW ASSY |
| 56 | 3RS-62106-0 | ** CLAMP SCREW |
| 57 | 3RSQ62102-0 | ** CLAMP SCREW HANDLE |
| 58 | 951403-0622 | ** SPRING PIN |
| 59 | 332-62101-1 | * CLAMP SCREW PAD |
| 60 | 945303-0600 | * E-RING d=6 |
| 61 | 9402E3-0800 | WASHER |
▶Fig.17 MANUAL TILT (EFO/EPO MODEL) (27 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3C8Q62431-0 | TILT STOPPER ASSY |
| 2 | 346-62437-0 | BUSHING 10.2-12-29.5 |
| 3 | 346-62439-1 | SETTING PLATE |
| 4 | 9101E3-5820 | BOLT |
| 5 | 3C8-62421-1 | FRICTION SPRING |
| 6 | 346-62438-0 | SETTING PIECE |
| 7 | 3E3-62141-0 | TILT ASSISTANT SPRING (R) |
| 8 | 3E3-62142-0 | TILT ASSISTANT SPRING (L) |
| 9 | 3C8-62143-0 | TILT ASSISTANT SHAFT |
| 10 | 3C8-66352-2 | REVERSE LOCK (L) |
| 11 | 3C8-66351-2 | REVERSE LOCK (R) |
| 12 | 3C8-66313-4 | REVERSE LOCK ARM |
| 13 | 3C8-66319-1 | REVERSE LOCK SHAFT |
| 14 | 945303-0600 | E-RING d=6 |
| 15 | 3C8-66321-0 | REVERSE LOCK ROD |
| 16 | 951503-0212 | SPLIT PIN 2-12 |
| 17 | 3E3-62436-1 | TILT STOPPER LEVER |
| 18 | 3C8-66332-2 | REVERSE LOCK SPRING (L) |
| 19 | 3AL-05254-0 | SHOULDER BOLT 6-8 |
| 20 | 3R0-66308-0 | WASHER 6-16-1.5 |
| 21 | 3AL-05212-0 | BUSHING 8.1-20 |
| 22 | 3AA-83719-0 | WASHER 8.5-18-1.6 |
| 23 | 940103-0800 | WASHER |
| 24 | 3C8-66318-1 | LINK |
| 25 | 3C8-66336-0 | SPRING |
| 26 | 346-66333-0 | REVERSE LOCK LEVER GRIP |
| 27 | 346-66334-0 | STOPPER |
▶Fig.18 BRACKET (2) POWER TRIM & TILT/GAS ASSIST (55 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GFQ77211-0 | CLAMP BRACKET (PTT-R) |
| 2 | 3GFQ77212-0 | CLAMP BRACKET (PTT-L) |
| 3 | 3B7-60218-1 | ANODE |
| 4 | 910103-5630 | BOLT |
| 5 | 3AD-62191-0 | SWIVEL BRACKET SHAFT ASSY |
| 6 | 3C8-77213-0 | BUSHING |
| 7 | 3R0-77118-0 | PTT THRUST ROD |
| 8 | 951603-1000 | SNAP PIN |
| 9 | 3GFQ77208-0 | SWIVEL BRACKET ASSY |
| 10 | 344-67177-1 | * GREASE FITTING |
| 13 | 3GFQ62010-0 | STEERING SHAFT ASSY |
| 14 | 353-62417-0 | BUSHING 30-36-41 |
| 15 | 9101E3-0830 | BOLT |
| 16 | 353-62423-1 | THRUST PLATE (UPPER) 31-50-2 |
| 17 | 353-62415-0 | O-RING 3.5-29.7 |
| 18 | 945103-2800 | C-RING d=28 |
| 19 | 3Z5Q61411-1 | MOUNT BRACKET |
| 20 | 353-63207-0 | COLLAR 10.2-12-12 |
| 21 | 3R0-62473-0 | TILT STOPPER SPRING |
| 22 | 3Z5-77601-0 | GAS SHOCK ABSORBER |
| 23 | 3R0-66311-0 | REVERSE LOCK LEVER |
| 24 | 3AL-66333-0 | REVERSE LOCK LEVER GRIP |
| 25 | 346-66334-0 | STOPPER |
| 26 | 3V2-60001-0 | BOLT 6-35 |
| 27 | 9301E3-0600 | NUT |
| 28 | 9401E3-0600 | WASHER |
| 29 | 3C8-62396-1 | GROUND L=210 |
| 30 | 910103-5608 | BOLT |
| 31 | 940103-0600 | WASHER |
| 32 | 3Z5-77150-2 | PTT ASSY |
| 33 | 3KY-77071-0 | CYLINDER PIN (UPPER) |
| 34 | 3R0-77075-0 | BUSHING 13-16-40 |
| 35 | 3R0-77076-0 | BUSHING 13-17-19.5 13-17-19.5 |
| 36 | 9101E3-0612 | BOLT |
| 37 | 345-05122-1 | WASHER 6.5-23-1.5 |
| 38 | 3KY-77101-0 | CYLINDER PIN (LOWER) |
| 39 | 3C8-77076-1 | BUSHING 18-24-22 |
| 40 | 3Z5-77103-0 | BUSHING 18-24-57.5 18-24-60 |
| 41 | 3R0-77112-0 | WASHER 18.2-34-1 |
| 42 | 945103-1800 | C-RING d=18 |
| 45 | 345-06915-0 | CLAMP 6.5-14L |
| 47 | 3Z4-72574-0 | TRIM SENSOR L=1700 |
| 48 | 910103-0620 | BOLT |
| 49 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 50 | 336-06973-0 | CLAMP 6-9.5L |
| 51 | 921503-5612 | SCREW |
| 52 | 398-62396-1 | GROUND L=130 |
| 53 | 910103-5612 | BOLT |
| 54 | 3GF-62466-1 | TILT STOPPER KIT |
| 55 | 951403-3516 | * SPRING PIN 3.5-16 |
| 56 | 369-62433-1 | * TILT STOPPER GRIP |
| 57 | 3RS-77217-0 | CLAMP SCREW KIT |
| 58 | 3RS-77216-0 | * CLAMP SCREW (PTT) |
| 59 | 332-62101-1 | * CLAMP SCREW PAD |
| 60 | 945303-0600 | * E-RING d=6 |
▶Fig.19 POWER TRIM & TILT (27 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3Z5-77180-0 | MOTOR ASSY |
| 2 | 3Z5-77190-0 | * ARMATURE ASSY |
| 3 | 3Z5-77192-0 | * MOTOR BRACKET ASSY |
| 4 | 3Z5-77182-0 | ** O-RING 2-55.5 |
| 5 | 3Z5-77191-0 | ** BREAKER |
| 6 | 3E0-77183-0 | ** BRUSH |
| 7 | 3E0-77184-0 | ** BRUSH SPRING |
| 8 | 921503-0520 | * SCREW |
| 9 | 3Z5-77166-0 | COUPLING |
| 10 | 3B7-77167-0 | O-RING 1.8-69.6 |
| 11 | 3Z5-77194-0 | SCREW |
| 12 | 3Z5-77460-0 | VALVE ASSY |
| 13 | 3Z5-77450-0 | RELIEF VALVE ASSY |
| 14 | 3R0-77451-0 | * O-RING 1.5-3.5 |
| 15 | 3B7-77430-0 | PUMP |
| 16 | 3B7-77432-1 | BOLT |
| 17 | 3B7-77431-1 | BOLT |
| 18 | 3B7-77433-0 | O-RING 1.5-6.5 |
| 19 | 3B7-77434-1 | FILTER |
| 20 | 3Z5-77165-1 | RESERVE TANK |
| 21 | 3Z5-77159-0 | BOLT |
| 22 | 3Z5-77221-0 | CAP ASSY |
| 23 | 3Z5-77175-0 | MANUAL VALVE ASSY |
| 24 | 3R0-77173-0 | SEAL WASHER |
| 25 | 3Z5-77171-0 | C-RING |
| 26 | 3Z5-77367-0 | JOINT |
| 27 | 3Z5-77225-0 | PTT O-RING SET |
▶Fig.20 TILLER HANDLE (F TYPE) (41 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5Q63003-1 | TILLER HANDLE ASSY |
| 2 | 3C8Q63011-2 | * TILLER HANDLE |
| 3 | 3C8-63041-1 | * THROTTLE SHAFT |
| 4 | 345-63048-0 | * THROTTLE SHAFT DAMPER |
| 5 | 398-63053-0 | * SPACER |
| 6 | 951403-0310 | * SPRING PIN 3-10 |
| 7 | 350-63046-0 | * BUSHING 8.4-10-11 |
| 8 | 921803-0525 | * SCREW |
| 9 | 3C8-63063-0 | * THROTTLE SHAFT SUPPORT |
| 10 | 9101E3-5612 | * BOLT |
| 11 | 3V1-63035-1 | * FRICTION PIECE |
| 12 | 3V1-63077-0 | * ADJUSTING NUT |
| 13 | 3V1-63036-0 | * SPRING |
| 14 | 910103-0625 | * BOLT |
| 15 | 3T5-72019-0 | * THROTTLE DECAL |
| 16 | 398-63012-0 | * GRIP |
| 17 | 3C8-63101-0 | BUSHING |
| 18 | 3B2-63108-0 | WASHER 30-45-1 |
| 19 | 3B2-63109-0 | WAVE WASHER 30-45-1.2 |
| 20 | 3C8-63102-1 | BUSHING |
| 21 | 9401E3-1000 | WASHER |
| 22 | 930103-1000 | NUT 10-P1.5 |
| 23 | 3C8-63607-0 | CLIP |
| 24 | 3C8-63600-1 | THROTTLE WIRE |
| 25 | 3C8-63508-1 | THROTTLE WIRE BRACKET |
| 26 | 910103-0614 | BOLT |
| 27 | 940103-0600 | WASHER |
| 28 | 3PR-06972-0 | CLAMP 6.5-47.5P |
| 29 | 910103-5625 | BOLT |
| 30 | 3T5-62004-0 | CORD HOLDER |
| 31 | 921903-0625 | SCREW |
| 32 | 3E3Q62001-0 | STEERING BRACKET |
| 33 | 3C8-62097-0 | STUD 10-50 P1.25 |
| 34 | 3C8-62098-0 | NYLON NUT 10-P1.25 |
| 35 | 9402E3-1000 | WASHER |
| 36 | 3T5-84335-0 | MAIN SWITCH DECAL |
| 37 | 3E5Q63028-1 | TILLER HANDLE HOLDER ASSY |
| 38 | 9153E3-1022 | * STUD |
| 39 | 345-06915-0 | CLAMP 6.5-14L |
| 40 | 910103-5612 | BOLT |
| 41 | 930103-0600 | NUT |
▶Fig.21 SWITCH BOX (F TYPE) (22 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5Q76032-0 | SWITCH BOX |
| 2 | 3T5-76230-0 | SWITCH BOX COVER |
| 3 | 921503-5510 | SCREW |
| 4 | 385-76020-1 | MAIN SWITCH ASSY |
| 5 | 353-76203-3 | * MAIN SWITCH KEY F-303 |
| 6 | 353-76205-1 | MAIN SWITCH KEY COVERING CAP |
| 7 | 3T5-76022-0 | MAIN SWITCH CAP (WATERPROOF) |
| 8 | 3T5-06830-0 | STOP SWITCH ASSY |
| 9 | 353-06821-0 | * STOP SWITCH LANYARD ASSY |
| 10 | 3T5-71040-0 | PILOT LAMP ASSY |
| 15 | 3T5-72611-0 | PTT SWITCH COVER (B) |
| 16 | 921503-0512 | SCREW |
| 17 | 940103-0500 | WASHER |
| 18 | 3C8-76171-0 | OVERHEAT BUZZER |
| 19 | 3T5-76174-0 | STAY |
| 20 | 910103-6612 | BOLT |
| 21 | 3GF-76119-0 | CORD ASSY L=1000 |
| 22 | 3B7-76035-0 | COVER |
| 23 | 3T5-72198-0 | WARNING LAMP DECAL |
| 24 | 3T5-76037-0 | CABLE TERMINAL PLUG |
| 25 | 3A3-76037-0 | CABLE TERMINAL PLUG |
| 26 | 353-76037-0 | CABLE TERMINAL PLUG |
▶Fig.22 BOTTOM COWL (50 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 346-67113-0 | MOUNT 8.5-14-2.5 |
| 2 | 346-67114-1 | SPACER 6.2-9-15.7 |
| 3 | 9101E3-0630 | BOLT |
| 4 | 346-67115-0 | WASHER 6.5-21-1 |
| 5 | 3T5-67150-0 | PLUG |
| 6 | 3C8Q67141-0 | HOOK LEVER |
| 7 | 338-67147-0 | SEAL RING 13.8-22-3.7 |
| 8 | 369-67105-0 | HOOK LEVER BUSHING |
| 9 | 3C8-67142-1 | COVER HOOK |
| 10 | 910103-0612 | BOLT |
| 11 | 3C8-83732-0 | GROMMET |
| 12 | 3T5-67162-0 | GROMMET |
| 13 | 3C8-76116-1 | GROMMET |
| 15 | 345-76092-0 | GROMMET 20-3 |
| 16 | 338-67163-0 | GROMMET 18-2.5 |
| 17 | 345-67117-0 | GROMMET 17-2.7 |
| 18 | 3C8-63624-0 | GROMMET 30-12-2.5 |
| 19 | 3B2-67187-0 | GROMMET 16-17.5 |
| 20 | 3B7-01046-0 | PLUG |
| 21 | 345-66226-0 | GROMMET 17-3 |
| 22 | 3B2-70260-1 | FUEL CONNECTOR (MALE) |
| 23 | 332-70261-0 | NUT 10-P1.25 |
| 24 | 336-70112-0 | GASKET 10.2-16-0.5 |
| 25 | 3T1-01138-0 | NIPPLE 6-8-11 |
| 26 | 98AB-50-250 | HOSE φ5-φ10 |
| 27 | 98AB-50-260 | HOSE φ5-φ10 |
| 28 | 3GF-02165-0 | FUEL HOSE W/PROTECTOR L=260 |
| 29 | 338-02215-0 | CLIP φ10 |
| 30 | 3N4-76142-1 | GROUND CABLE L=270 |
| 31 | 910103-6612 | BOLT |
| 32 | 398-76080-1 | NEUTRAL SWITCH |
| 33 | 398-76083-0 | NEUTRAL SWITCH ACTUATOR |
| 34 | 3B7-63731-0 | WASHER 12.5-24-1 |
| 35 | 3C8Q83737-0 | CABLE CLIP BRACKET ASSY |
| 36 | 3Z5-83738-0 | * CLUTCH CABLE CLIP BRACKET |
| 38 | 910103-5612 | * BOLT |
| 39 | 3C8-83821-0 | SCREW 4-20 P0.5 |
| 40 | 941303-0400 | SPRING WASHER |
| 41 | 3C8Q76118-0 | CLAMP |
| 42 | 910103-5625 | BOLT |
| 43 | 910103-5616 | BOLT |
| 44 | 3GF-72615-0 | PTT SWITCH ASSY |
| 45 | 3F3-72616-1 | GASKET |
| 46 | 3GF-72617-0 | PTT SWITCH ASSY BRACKET |
| 47 | 910103-6614 | BOLT |
| 48 | 3C8Q67110-1 | BOTTOM COWL W/GROMMET |
| 49 | 3C8Q67100-2 | * BOTTOM COWL |
| 50 | 3F3-72618-0 | * GROMMET 47-2.5 |
| 51 | 3TW-67179-0 | DRAIN PLUG |
| 52 | 369-66043-1 | GROMMET 10.7-3.5 |
▶Fig.23 SHIFT (37 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3C8-67146-0 | WASHER 14-22-1 |
| 2 | 941403-1400 | WAVE WASHER d=14 |
| 3 | 3C8-66308-0 | WASHER 6-16-1.5 |
| 5 | 3C8-66122-1 | SHIFT ARM |
| 6 | 350-67101-0 | BUSHING |
| 7 | 941403-1200 | WAVE WASHER d=12 |
| 8 | 3C8-66225-0 | SHIFT ROD LEVER |
| 10 | 3C8-66113-1 | SHIFT DETENT SPRING |
| 11 | 3C8-66117-0 | SHIFT DETENT SUPPORTER |
| 12 | 3PR-06972-0 | CLAMP 6.5-47.5P |
| 13 | 910103-5616 | BOLT |
| 14 | 3C8-66135-0 | SHIFT LEVER SHAFT |
| 15 | 951703-0800 | SNAP RETAINER ｄ=8 |
| 16 | 3AA-83719-0 | WASHER 8.5-18-1.6 |
| 17 | 3T5-66110-0 | SHIFT LEVER |
| 18 | 3T5-67147-0 | SEAL RING 13.8-22-5 |
| 19 | 350-67105-0 | HOOK LEVER BUSHING 14-16.5-17.7 |
| 20 | 3T5-66129-0 | SHIFT LEVER (REMOTE CONTROL) |
| 21 | 910103-0670 | BOLT |
| 22 | 930403-0600 | NYLON NUT 6-P1.0 |
| 23 | 3T5-66134-0 | SHIFT LEVER ROD |
| 24 | 3B7-83715-2 | CABLE JOINT |
| 25 | 3B2-83865-0 | NUT 10-32UNF |
| 26 | 951503-0212 | SPLIT PIN 2-12 |
| 27 | 951603-0800 | SNAP PIN d=8 |
| 28 | 940103-0500 | WASHER |
| 29 | 3C8-66211-0 | SHIFT ROD |
| 30 | 951403-0312 | SPRING PIN 3-12 |
| 31 | 3T5-67578-0 | SHIFT DECAL |
| 32 | 3C8-84910-2 | DRAG LINK ASSY |
| 33 | 3C8-84914-1 | * COLLAR 9.6-13-6.5 |
| 34 | 3C8-84916-0 | * COLLAR 9.6-19-6 |
| 35 | 951503-0215 | * SPLIT PIN |
| 36 | 3C8-84917-0 | * BOLT 3/8-19 |
| 37 | 353-84918-0 | * NYLON NUT 3/8-24UNF |
| 38 | 353-84916-0 | * WASHER 9.6-18-2 |
| 39 | 3F3-84908-0 | * SEAL RING |
▶Fig.24 TOP COWL (18 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T1-72043-0 | OIL CAUTION DECAL |
| 2 | 3GFQ67645-6 | TOP COWL ASSY |
| 3 | 3GFQ67640-0 | * TOP COWL SUB-ASSY |
| 4 | 3C8-66308-0 | ** WASHER 6-16-1.5 |
| 5 | 930403-0600 | ** NYLON NUT 6-P1.0 |
| 6 | 3C8-67501-1 | ** TOP COWL SEAL |
| 7 | 3E3Q67210-1 | ** FILLER LID |
| 8 | 3B7-67211-0 | ** FILLER LID HINGE |
| 9 | 3C8-67212-1 | ** SPRING |
| 10 | 910103-0614 | ** BOLT |
| 11 | 930103-0600 | ** NUT |
| 12 | 941303-0600 | ** SPRING WASHER |
| 13 | 3E3-67213-0 | ** SEAL L=275 |
| 14 | 3E3Q67521-1 | ** TILT HANDLE |
| 15 | 3GM-87802-3 | * DECAL SET (MD30B2 EU) |
| 16 | 3KY-67531-0 | * FRONT DECAL |
| 17 | 3C7-72180-3 | CAUTION DECAL (A) |
| 18 | 3AC-72185-0 | CAUTION DECAL |
▶Fig.25 AMULTI TILLER HANDLE (56 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GFQ63000-3 | TILLER HANDLE KIT |
| 2 | 3GF-63600-0 | * THROTTLE WIRE |
| 3 | 3GF-66196-0 | * SHIFT CABLE |
| 4 | 398-06830-0 | * STOP SWITCH ASSY |
| 5 | 353-06821-0 | ** STOP SWITCH LANYARD ASSY |
| 6 | 3AH-72615-0 | * PTT SWITCH ASSY |
| 7 | 3GF-76020-0 | * MAIN SWITCH ASSY |
| 8 | 3GF-76219-0 | ** MAIN SWITCH KEY |
| 9 | 3GF-76205-0 | ** MAIN SWITCH KEY COVERING CAP |
| 10 | 3T5-76022-0 | * MAIN SWITCH CAP (WATERPROOF) |
| 11 | 3GF-71040-0 | * PILOT LAMP ASSY |
| 12 | 3GF-72019-0 | * THROTTLE DECAL |
| 13 | 3GF-67578-1 | * SHIFT DECAL |
| 14 | 3GF-72198-0 | * WARNING LAMP DECAL |
| 15 | 3GF-72200-0 | * STOP SWITCH DECAL |
| 16 | 3GF-84339-0 | * INSTRUCTION DECAL |
| 17 | 3GF-63320-0 | * TILLER HANDLE COVER |
| 18 | 3GF-63624-0 | * GROMMET |
| 19 | 3GG-76119-1 | * CORD ASSY |
| 20 | 3GFQ62000-0 | * STEERING BRACKET ASSY |
| 21 | 3GF-65012-0 | ** DOWEL PIN 8-16 |
| 22 | 3GF-62097-0 | * STUD M10-45 P1.25 |
| 23 | 3C8-62098-0 | * NYLON NUT 10-P1.25 |
| 24 | 9402E3-1000 | * WASHER |
| 25 | 3GF-63201-0 | * BOLT 10-80 P1.25 |
| 26 | 3GF-63305-0 | * CONICAL SPRING WASHER 10.5-21-2.3 |
| 27 | 3GF-63025-0 | * SPACER 10.5-23-9 |
| 28 | 3GF-63102-0 | * BUSHING 10.5-12.7-13.5 |
| 29 | 9401E3-1000 | * WASHER |
| 30 | 3GF-63310-0 | * LOCK NUT 10-P1.25 |
| 31 | 3GF-62004-0 | * CORD HOLDER |
| 32 | 3T5-06437-0 | * TAPPING SCREW 6-16 |
| 33 | 3GF-62400-0 | * FRICTION LEVER BRACKET |
| 34 | 3V1-60108-0 | * PRE-COATED BOLT 6-16 |
| 35 | 3GF-62445-0 | * BOLT 8-32 P1.25 |
| 36 | 3GF-62447-0 | * PLATE |
| 37 | 3V5-62442-0 | * NYLON NUT 8-P1.25 |
| 38 | 3B7-63730-0 | * WASHER 8.5-24-1.5 |
| 39 | 3GF-62449-0 | * DISC 8.5-25-2 |
| 40 | 3GF-62441-0 | * FRICTION LEVER |
| 41 | 3AC-63012-0 | * GRIP |
| 42 | 346-66334-0 | * STOPPER |
| 43 | 3R3-62443-0 | * WASHER 8.1-20-0.8 |
| 44 | 398-76080-1 | * NEUTRAL SWITCH |
| 45 | 398-76083-0 | * NEUTRAL SWITCH ACTUATOR |
| 46 | 3B7-63731-0 | * WASHER 12.5-24-1 |
| 47 | 3GF-63205-0 | * SCREW SET |
| 48 | 3GF-63193-0 | * GRIP PARTS KIT |
| 49 | 3GF-63062-0 | * THROTTLE SHAFT KIT |
| 50 | 3GF-63067-0 | * THROTTLE LINK ASSY |
| 51 | 3GF-63032-0 | * THROTTLE FRICTION ASSY |
| 52 | 3GF-66160-0 | * SHIFT UNIT ASSY |
| 53 | 3GF-66158-0 | * SHIFT LEVER KIT |
| 54 | 3GF-66198-0 | * CABLE BRACKET KIT |
| 55 | 3GF-76175-0 | * BUZZER KIT |
| 56 | 346-62127-0 | * CAP NUT |
▶Fig.25 FUEL TANK (19 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GF-70200-5 | PRIMER BULB ASSY |
| 2 | 3C7-70220-1 | JOINT ASSY (INLET) |
| 3 | 3C7-70224-1 | JOINT ASSY (OUTLET) |
| 4 | 3GF-70211-1 | * PRIMER BULB |
| 5 | 3C7-70217-0 | CLAMP |
| 6 | 98AB-70-700 | * HOSE |
| 7 | 98AB-701600 | * HOSE |
| 8 | 3B7-70280-1 | FUEL CONNECTOR MARK |
| 9 | 3GF-70281-0 | FUEL CONNECTOR |
| 10 | 3GF-70250-1 | FUEL CONNECTOR |
| 11 | 332-70201-0 | CLAMP |
| 12 | 3KZ-70177-0 | FUEL TANK ASSY 25L |
| 13 | 3RS-70020-0 | * FUEL TANK CAP ASSY |
| 14 | 3RS-70021-0 | ** TANK FILLER CAP GASKET |
| 15 | 3E0-70270-0 | * QUICK-CONNECTOR (MALE) |
| 16 | 3AC-70157-0 | * FUEL PICK-UP ASSY W/GAUGE |
| 17 | 3AC-70140-0 | * SCREW |
| 18 | 3AC-70145-0 | * WASHER |
| 19 | 3AC-70150-0 | * GASKET |
▶Fig.26 COMPONENT PARTS OF REMOTE CONTROL (52 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3U2B84500-0 | REMOTE CONTROL HEAD ASSY(RC12F) |
| 2 | 3A3-84365-1 | * THROTTLE ARM |
| 3 | 3A3-84428-0 | * THROTTLE FRICTION ARM |
| 4 | 945303-0600 | * E-RING d=6 |
| 5 | 353-84394-0 | * WASHER |
| 6 | 3U2-84427-0 | * ADJUSTING SCREW |
| 7 | 3A3-84381-0 | * SHIFT GEAR ASSY |
| 8 | 3A3-83314-2 | * CABLE TERMINAL |
| 9 | 3A3-84364-2 | * DRIVE GEAR |
| 10 | 930103-0500 | * NUT |
| 11 | 910103-0525 | * BOLT |
| 12 | 3A3-84376-0 | * GROMMET |
| 13 | 3U2B84441-0 | * REAR HOUSING |
| 14 | 3U2B84366-0 | * REAR PANEL |
| 15 | 3U2-84401-0 | * NEUTRAL LOCK ARM |
| 16 | 3A3-84403-0 | * NEUTRAL LOCK SPRING |
| 17 | 3U2-84404-0 | * GRIP |
| 18 | 3U2-84343-0 | * CONTROL LEVER |
| 19 | 3A3-84368-0 | * WAVE WASHER |
| 20 | 3A3-84391-0 | * FREE THROTTLE DRUM |
| 21 | 3A3-84435-0 | * BUSHING |
| 22 | 3A3-84422-0 | * THRUST PLATE |
| 23 | 921603-0512 | * SCREW |
| 24 | 3VK-84339-0 | * INSTRUCTION DECAL |
| 25 | 3A3-84432-0 | * BUSHING |
| 26 | 3U2-84375-0 | * SCREW |
| 27 | 3VK-84375-0 | * SCREW |
| 28 | 3VL-84375-0 | * SCREW |
| 29 | 3A3-84374-0 | * SPACER |
| 30 | 353-84371-0 | * WASHER |
| 31 | 3U2-84371-0 | * WASHER |
| 32 | 930103-0600 | * NUT |
| 33 | 3A3-84383-0 | * WASHER |
| 34 | 3A3-84421-0 | * ROLLER |
| 35 | 3U2-84431-0 | * BUSHING |
| 36 | 940103-0800 | * WASHER |
| 37 | 3U2-84442-0 | * BOLT |
| 38 | 353-84388-0 | * DETENT ROLLER |
| 39 | 3U2B84312-0 | * FREE THROTTLE LEVER |
| 40 | 921503-0406 | * SCREW |
| 41 | 3A3-84423-0 | * DETENT RETAINER |
| 42 | 3A3-84307-0 | * DETENT SPRING |
| 43 | 3A3-84424-0 | * FREE THROTTLE ROLLER |
| 44 | 3A3-84426-0 | * ROLLER RETAINER |
| 45 | 3A3-84425-0 | * FREE THROTTLE SPRING |
| 46 | 3U2-63107-0 | * COVER |
| 47 | 3U2-63506-0 | * HOLDER |
| 48 | 3U2-84917-0 | * BOLT |
| 49 | 3U2-77367-0 | * JOINT |
| 50 | 3U2-72187-0 | * CAUTION DECAL(SIGP) |
| 51 | 3U2B84440-0 | * FRONT HOUSING |
| 52 | 3U2-06973-0 | * CLAMP |
▶Fig.27 COMPONENT PARTS OF REMOTE CONTROL (ELECTRIC PARTS) (17 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GF-76020-0 | MAIN SWITCH ASSY |
| 2 | 3GF-76219-0 | * MAIN SWITCH KEY |
| 3 | 3GF-76205-0 | * MAIN SWITCH KEY COVERING CAP |
| 4 | 3T5-76115-1 | CORD ASSY L=6200 |
| 5 | 353-72546-0 | ASSIST CORD (RED) L=200 |
| 6 | 3U2-84331-0 | DECAL (LEVER) |
| 7 | 3U2-84336-0 | SHIFT POSITION DECAL |
| 8 | 3A3-84398-0 | BAND |
| 9 | 3U2-84398-0 | BAND |
| 10 | 3T5-76086-0 | NEUTRAL SWITCH (REMOTE CONT) |
| 11 | 921503-5316 | SCREW |
| 12 | 3C8-76171-0 | OVERHEAT BUZZER |
| 13 | 3A3-06830-0 | STOP SWITCH ASSY |
| 14 | 353-06821-0 | * STOP SWITCH LANYARD ASSY |
| 15 | 3U2-72200-0 | STOP SWITCH DECAL |
| 16 | 3U2-84334-0 | REMOTE CONTROL LOGO DECAL |
| 17 | 3U2-72615-0 | PTT SWITCH ASSY |
▶Fig.28 ACCESSORIES (1) (35 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3H6-72100-0 | TOOL KIT |
| 2 | 3B7-72201-0 | SAFETY ROPE φ5-1600 |
| 3 | 3T5-72050-0 | BUZZER CAUTION DECAL |
| 5 | 3Z5-72640-1 | TACHOMETER W/OIL LAMP |
| 6 | 3B7-72658-0 | * OIL BULB 12V-1.7W |
| 7 | 3B7-72659-0 | * METER BULB 12V-1.7W |
| 8 | 3B7-72656-0 | * METER DAMPER |
| 9 | 3B7-72661-0 | * FITTING PLATE |
| 10 | 930203-0500 | * NUT |
| 11 | 941303-0500 | * SPRING WASHER |
| 12 | 3T5-72537-1 | METER LEAD WIRE L=8000 |
| 14 | 3T1-72571-0 | TRIM METER ASSY |
| 15 | 3T1-72659-0 | * METER BULB 12V-1.7W |
| 16 | 3T1-72653-0 | * METER BULB CAP |
| 17 | 3B7-72655-0 | * METER DAMPER |
| 18 | 3T1-72665-0 | * FITTING PLATE |
| 19 | 941303-0400 | * SPRING WASHER |
| 20 | 930203-0400 | * NUT |
| 21 | 3A3-81301-0 | TWIN REMOTE CONTROL KIT |
| 22 | 3E3-84830-0 | STEERING HOOK |
| 23 | 3E3-62097-0 | STUD 10-25 P1.25 |
| 24 | 3C8-62098-0 | NYLON NUT 10-P1.25 |
| 25 | 940203-1000 | WASHER |
| 26 | 3C8Q84960-0 | CLEVIS ASSY |
| 27 | 3C8-84962-0 | * COLLAR 9.6-13-20.5 |
| 28 | 353-84916-0 | * WASHER 9.6-18-2 |
| 29 | 3C8-84963-0 | * BOLT 3/8-43 |
| 30 | 353-84918-0 | * NYLON NUT 3/8-24UNF |
| 31 | 3C8-84964-0 | * BOLT 3/8-35 |
| 32 | 3KY-72575-0 | TRIM SENSOR KIT |
| 33 | 3Z4-72574-0 | * TRIM SENSOR L=1700 |
| 34 | 910103-0620 | * BOLT |
| 35 | 3C8-66308-0 | * WASHER 6-16-1.5 |
| 36 | 336-06973-0 | * CLAMP 6-9.5L |
| 37 | 921503-5612 | * SCREW |
▶Fig.28A ACCESSORIES (2) (7 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GL-72571-0 | TRIM METER KIT |
| 2 | 3GL-72647-1 | TACHOMETER |
| 3 | 3GL-72524-0 | HOUR METER ASSY |
| 4 | 3GL-72529-0 | VOLTMETER ASSY |
| 5 | 3GL-72598-0 | WATER PRESSURE METER KIT |
| 6 | 3GL-72672-0 | SPEEDOMETER KIT (60MPH) |
| 7 | 3GL-72596-0 | FUEL METER ASSY |
▶Fig.29 OPTIONAL PARTS (1) (17 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3B7-72530-2 | TACHOMETER ASSY |
| 2 | 3B7-72659-0 | * METER BULB 12V-1.7W |
| 3 | 3B7-72656-0 | * METER DAMPER |
| 4 | 3B7-72661-0 | * FITTING PLATE |
| 5 | 930103-0500 | * NUT |
| 6 | 941303-0500 | * SPRING WASHER |
| 7 | 3T5-72539-0 | TACHOMETER LEAD WIRE L=2000 |
| 21 | 3E0-72524-0 | HOUR METER ASSY |
| 24 | 3B7-72664-0 | * FITTING PLATE |
| 27 | 3E0-72529-0 | VOLTMETER ASSY |
| 28 | 3B7-72657-0 | * METER BULB 12V-1.7W |
| 29 | 3B7-72655-0 | * METER DAMPER |
| 30 | 3B7-72662-0 | * FITTING PLATE |
| 31 | 930203-0400 | * NUT |
| 32 | 941303-0400 | * SPRING WASHER |
| 43 | 353-72521-1 | METER LAMP SWITCH |
| 44 | 353-72548-0 | ASSIST CORD (BLK) L=200 |
▶Fig.31 AOPTIONAL PARTS (4) (11 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3KY-72637-0 | TOCS STARTER KIT |
| 2 | 3KY-76131-0 | * ENGINE DROP CABLE L=6m |
| 3 | 3KY-76120-0 | * BATTERY CABLE |
| 5 | 3KY-76153-0 | * TERMINATOR (MALE) |
| 6 | 3KY-76152-0 | * TERMINATOR (FEMALE) |
| 7 | 3KY-76151-0 | * TEE CONNECTOR |
| 8 | 3KY-72672-0 | SPEEDOMETER KIT (60MPH) |
| 9 | 3KY-72600-0 | FUEL METER KIT |
| 11 | 3KY-72573-0 | EXTENSION CORD (TRIM SENSOR) L=6000 |
| 12 | 3KY-76132-0 | BACKBONE CABLE L=5m |
| 13 | 3KY-72638-0 | TACHOMETER KIT |
▶Fig.31 OPTIONAL PARTS (3) (5 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3Z4-72573-0 | EXTENSION CORD (TRIM SENSOR) L=2000 |
| 2 | 3B7-60007-0 | FLUSHING PLUG |
| 3 | 3T5-76114-0 | EXTENSION CORD L=2000 (11P) |
| 4 | 3T5-76112-0 | EXTENSION CORD L=2000 (2P) |
| 5 | 3T5-71042-0 | EXTENSION CORD |
▶Fig.32A RIGGING KIT(1) (9 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3Y9-76049-0 | LEAD WIRE L=200 |
| 2 | 3Y9-76251-0 | LAMP PANEL ASSY |
| 3 | 3GLQ84550-3 | PRE-RIGGING KIT |
| 4 | 3U2B84500-0 | * REMOTE CONTROL HEAD ASSY(RC12F) |
| 5 | 3T5-72537-1 | * METER LEAD WIRE L=8000 |
| 6 | 3T1-72573-0 | * EXTENSION CORD (TRIM SENSOR) L=6000 |
| 7 | 353-72548-0 | * ASSIST CORD (BLK) L=200 |
| 8 | 3GM-84550-2 | PRE-RIGGING KIT |
| 9 | 3GF-84560-1 | * RIGGING CORD KIT |
▶Fig.32B RIGGING KIT(2) (12 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3GF-84556-1 | PRE-RIGGING KIT(GENERIC FLUSH) |
| 5 | 3GM-84550-2 | * PRE-RIGGING KIT |
| 11 | 3GGQ84555-2 | PRE-RIGGING KIT (GENERIC SIDE) |
| 12 | 3GF-72647-1 | * TACHOMETER |
| 13 | 3GF-72571-0 | * TRIM METER KIT |
| 14 | 3KY-72575-0 | * TRIM SENSOR KIT |
| 15 | 3GLQ84550-3 | * PRE-RIGGING KIT |
| 16 | 3E3-84830-0 | * STEERING HOOK |
| 17 | 3E3-62097-0 | * STUD 10-25 P1.25 |
| 18 | 3C8-62098-0 | * NYLON NUT 10-P1.25 |
| 19 | 940203-1000 | * WASHER |
| 20 | 3C8-84910-2 | * DRAG LINK ASSY |
▶Fig.33 ASSEMBLY・KIT PARTS (8 parts)
| Ref | OEM Part # | Part Name |
|---|---|---|
| 1 | 3T5Q87304-6 | LOWER UNIT ASSY (UL) |
| 2 | 3GFB87090-4 | ENGINE SHORT BLOCK KIT |
| 3 | 3T5-87121-8 | POWER HEAD GASKET SET |
| 4 | 9101E3-5855 | * BOLT |
| 5 | 3Z5-65238-1 | * PUMP CASE LINER |
| 6 | 3T5-87321-3 | LOWER UNIT GASKET SET |
| 7 | 951407-0312 | * SPRING PIN 3-12 |
| 8 | 3GF-10230-0 | ALTITUDE ADJUSTMENT KIT |
100-Hour / Annual Service Checklist
Regular maintenance keeps your Tohatsu MD30/40/50B2/MWD50B2 running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.
- Replace water pump impeller and inspect wear plate
- Inspect and clean carburetor(s); check fuel mixture settings
- Replace spark plugs and check ignition timing
- Drain and refill lower unit gear oil; inspect for water contamination
- Inspect fuel lines, primer bulb, and fuel filter for deterioration
- Check and replace sacrificial anodes (zinc or aluminum)
- Inspect propeller for damage; check shaft seal and cotter pin
- Decarbonize exhaust ports and piston crown if needed
- Lubricate all grease points (steering, tilt tube, shift linkage)
- Inspect control cables and throttle/shift linkage for smooth operation
- Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
- Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.
Recently Viewed Products
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
Example product title
- $19.99
- $19.99
- Unit price
- per
- Choosing a selection results in a full page refresh.