Mercury V-200XRI (EFI) (0C291520 THRU 0D081999) Parts & Diagrams

🔎 Mercury V-200XRI (EFI) Reference Library — Exploded parts diagrams (62 diagrams), specifications, common issues, and maintenance checklist.

The Mercury V-200XRI (EFI) is a 2-Stroke EFI, V6 60-degree outboard motor. Designed for large center-consoles, offshore sport-fishing boats, and multi-engine configurations.

Quick Reference Specifications

Specification	Value
Engine Type	2-Stroke EFI, V6 60-degree
Horsepower	200 HP
Displacement	2507 cc (2.5L / 153 CID)
Bore x Stroke	89 mm x 67 mm (3.501 in. x 2.650 in.)
Spark Plug (Type & Gap)	NGK BPZ8HS-10
Engine Oil Capacity	—
Recommended Engine Oil	Mercury 2-Stroke Outboard Oil (TCW-3)
Gear Case Oil Capacity	802 mL (27.1 oz)
Idle Speed (in gear)	650–700 RPM (in gear)
Full Throttle RPM Range	5000-5600
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury V-200XRI (EFI):

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury V-200XRI (EFI).

▶BLEED SYSTEM (10 parts)

Ref	OEM Part #	Part Name
1	32-892024122	TUBING, (20.00 Feet Bulk), BLEED
2	22-59169003	FITTING
3	21-426982	CHECK VALVE (PRESS-IN - 13/16" LONG)
4	21-426233	CHECK VALVE (PRESS-IN - 11/16" LONG)
5	22-15133	FITTING (PRESS-IN)
6	22-56759	FITTING, Press-In
7	22-15026	CAP, ELBOW (YELLOW)
8	22-18205	TEE
9	32-9912688	TUBING, (36.00 Inches Bulk)
10	35-8M0207786	FILTER

▶BOTTOM COWL (31 parts)

Ref	OEM Part #	Part Name
1	2197-9744A16	BOTTOM COWL ASSEMBLY , Gray (PORT)(Without Decals)
2	2197-9745A5	BOTTOM COWL ASSEMBLY (STARBOARD)(GRAY)(Without Decals)
3	18701A1	SEAL KIT, BOTTOM COWLS
4	10-18699	SCREW, (.250-20 x 1.320), COWL (STARBOARD)
5	21-817519A1	CHECK VALVE ASSEMBLY, Drain
6	22-813613	FITTING, TELLTALE
7	32-8M0108355	FUEL LINE, (57.00 Inches Bulk), TELLTALE
8	54-816311T	TIE STRAP, (8.00 Inches)
9	17-815296	LOCK PIN (OLD DESIGN)
10	87-8M0042301	SWITCH ASSEMBLY
11	8M0032848	RETAINER
12	22-815914	T-FITTING, TELL TALE
13	32-77653101	HOSE, (24.500 Inches Bulk)
14	19648A2	HANDLE ASSEMBLY (PORT) (GRAY)
15	19647A3	HANDLE ASSEMBLY (STARBOARD) (GRAY)
16	23-65830	NYLINER
17	13-99611	WAVE WASHER
18	19369	PAWL, STARBOARD
19	19370	PAWL, PORT
20	12-69057	WASHER, (.281 x .734 x .063)
21	13-26992	LOCKWASHER, (.250)
22	10-73286	SCREW, (.250-20 x .500)
23	54-19749	CLAMP, UPPER
24	54-197481	CLAMP, LOWER
25	10-92799	SCREW, (#10-16 x 1.12)
26	18872A2	COVER ASSEMBLY (GRAY)
27	11-8136921	LOCK NUT
33	10-18192	SCREW, (.250-20 x .620)
34	23-19666	BUSHING
35	18727	ROD
36	8130764	FRONT HANDLE (NEW DESIGN)

▶Bottom Cowl (36 parts)

Ref	OEM Part #	Part Name
1	2197-9744A16	BOTTOM COWL ASSEMBLY , Gray Comment: (PORT)
2	2197-9745A6	BOTTOM COWL ASSEMBLY (GRAY) Comment: (STARBOARD)
3	18701A1	SEAL KIT, BOTTOM COWLS-(PORT/STBD.)
4	10-18699	SCREW, (.250-20 x 1.320), COWL (STARBOARD)
5	21-817519A1	CHECK VALVE, Drain (PORT/STBD.)
6	22-813613	FITTING, TELLTALE-STARBOARD
7	32-8M0108355	FUEL LINE, (57.00 Inches Bulk), TELLTALE-STARBOARD
8	54-816311T	CABLE TIE, (8.00 Inches) (STARBOARD)
9	17-815296	LOCK PIN (USE WHERE APPLICABLE)(STARBOARD)
10	87-8M0042301	SWITCH ASSEMBLY
11	8M0032848	RETAINER
12	22-815914	T-FITTING, TELLTALE
13	32-77653101	HOSE, (24.500 Inches Bulk)
14	19648A2	HANDLE ASSEMBLY (GRAY)(PORT)
15	19647A3	HANDLE ASSEMBLY (GRAY)(STARBOARD)
16	23-65830	NYLINER
17	13-99611	WAVE WASHER
18	19369	PAWL (STARBOARD)
19	19370	PAWL (PORT)
20	12-69057	WASHER, (.281 x .734 x .063)
21	13-26992	LOCKWASHER, (.250)
22	10-73286	SCREW, (.250-20 x .500)
23	54-197491	CLAMP, UPPER (WITH POWER STEERING)
24	54-197481	CLAMP, LOWER
25	10-92799	SCREW, (#10-16 x 1.12)
26	18872A2	COVER ASSEMBLY (GRAY)
27	11-8136921	LOCK NUT
28	NSS	NOT SOLD SEPARATE, Front Handle Comment: (REPLACE WITH 813076A2)
29	NSS	NOT SOLD SEPARATE, Handle Comment: (REPLACE WITH 813076A2)
30	NSS	NOT SOLD SEPARATE, Lock-Handle Comment: (REPLACE WITH 813076A2)
31	NSS	NOT SOLD SEPARATE, Screw Comment: (REPLACE WITH 813076A2)
32	NSS	NOT SOLD SEPARATE, Spring Comment: (REPLACE WITH 813076A2)
33	10-18192	SCREW, (.25-20 x .62)
34	23-19666	BUSHING
35	18727	ROD
36	8130764	FRONT HANDLE

▶CRANKSHAFT(Conn Rod Forging # is 636-8118) (19 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	455-9536T4	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball (LOWER)
3	53-67446	RING
4	43-14513A09	GEAR KIT
5	10-813073	SCREW, (#6-32 x .620)
6	11-813134	NUT, (#6-32 Special)
7	31-16756A6	BEARING ASSEMBLY, Roller
8	54196A6	CARRIER ASSEMBLY
9	65800	PACKING
10	39-67377T	RING, SEALING (.124 THICK)
11	785-9737A5	PISTON (PORT - .015 O.S.) (200)
12	39-815268A4	PISTON RING (.015 O.S.) (200)
13	53-857196	RING, Lock
14	636-8119A6	CONNECTING ROD ASSEMBLY
15	10-93886	SCREW, (.312-28 x .875)
16	12-8M0032839	WASHER
17	29-67483	BEARING, Needle
18	8M0234886	BEARING KIT

▶CRANKSHAFT(Conn. Rod Forging # is 644-818141) (19 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	455-9536T4	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball (LOWER)
3	53-67446	RING
4	43-14513A09	GEAR KIT
5	10-813073	SCREW, (#6-32 x .620)
6	11-813134	NUT, (#6-32 Special)
7	31-16756A6	BEARING ASSEMBLY, Roller
8	54196A6	CARRIER ASSEMBLY
9	65800	PACKING
10	39-67377T	RING (.124 THICK)
11	785-9737A10	PISTON (PORT - .015 O.S.)
12	39-815268A4	PISTON RING (.015 O.S.)
13	53-857196	RING, Lock, PISTON
14	644-818141A13	CONNECTING ROD KIT
15	10-763491	SCREW, (.312-24 x .875), CONNECTING ROD
16	12-8M0012298	WASHER, NEEDLE LOCATING
17	29-8M0204691	BEARING, Needle, PISTON END
18	8M0234886	BEARING KIT

▶CYLINDER BLOCK AND END CAPS (43 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	884-9763T6	CYLINDER BLOCK (200)
2	16-76175	STUD, POWERHEAD (1-7/8")
3	16-8M0034454	STUD, POWERHEAD (6-3/4")
4	17-43044	PIN, Dowel, LOCATING
5	17-8M0036405	PIN (BEARING RACE)
6	27-11338	GASKET, SEALING
7	8M0088723	COVER, STARTER MOTOR (UPPER)
8	10-73657	SCREW, (.312-18 x 1.50), COVER TO CRANKCASE
9	13-8M0204647	LOCKWASHER, (.312)
10	76867	COVER, STARTER MOTOR (LOWER)
11	10-815549	SCREW, (.312-18 x 2), COVER TO CRANKCASE
12	23-99448	BUSHING
13	84-88807A20	CABLE ASSEMBLY, COVER
14	10-74824	SCREW, (.312-18 x 1.250)
15	1159-858521T1	END CAP ASSEMBLY, Upper
16	25-54029	O-RING, (2.800 x .103), END CAP
17	31-16756A4	BEARING ASSEMBLY, Roller, END CAP
18	26-41953	SEAL, END CAP
19	10-30225	SCREW AND LOCKWASHER, (.312-18 x 1.00)
20	54-63153	J CLIP
22	16-15094	STUD, (.190-32 x 1.870)
23	16-8M0034435	STUD, (#10-32 x 1.00), FLYWHEEL COVER TO BRACKET
24	23-67269	SPACER, FLYWHEEL COVER STUD
25	12-8M0204663	WASHER, FLYWHEEL COVER STUD
26	12-72761	WASHER, (.203 x .562 x .060), FLYWHEEL COVER STUD
27	10-32,11-816874	WING NUT, , FLYWHEEL COVER STUD
28	422482	BRACKET, FLYWHEEL COVER
29	10-49668	SCREW, (.250-20 x .750), BRACKET TO CRANKCASE
30	1156-7809T1	END CAP ASSEMBLY, LOWER
31	25-62700	O-RING, (3.237 x .103), END CAP
32	26-41953	SEAL, END CAP
33	10-28636	SCREW, (.250-20 x .750)
34	13-26992	LOCKWASHER, (.250), LOWER END CAP SCREW
35	10-64022	SCREW, (.250-20 x 2.125), ADJUSTING - CYLINDER BLOCK
36	11-64015	NUT, (.250-20), JAM - ADJUSTING SCREW
37	26852	CAP, NYLON - ADJUSTING SCREW
38	87076A10	IDLE SPEED CONTROL ASSEMBLY (200)
39	10-690201	SCREW, (#10-32 x .875)
40	12-38833	WASHER
41	93772A11	ADVANCED MODULE (175)
42	54-16793	CLAMP (175)
43	10-73286	SCREW, (.250-20 x .500) (175)

▶Carburetor (42 parts)

Ref	OEM Part #	Part Name
-	8107492	GASKET SET, Carb
1	3311-818650A59	CARBURETOR Comment: (200-Bottom)
2	810779	CAP
3	27-677511	GASKET, MOUNTING FLANGE
4	810764	EMULSION TUBE Comment: (200)
5	810748	ACCELERATOR LEVER ASSEMBLY
6	810723	ACCELERATOR LINK
7	NSS	NOT SOLD SEPARATE, Bushing, Accelerator Link
8	NSS	NOT SOLD SEPARATE, Ring, Accelerator Link
9	810722	THROTTLE LEVER (BOTTOM)
10	NSS	NOT SOLD SEPARATE, Screw, Accelerator Lever
11	1395-811284	SPACER Comment: (200)
12	12-810745	WASHER, LEVER RETAINER NUT
13	11-810744	NUT, LEVER RETAINER
14	NSS	NOT SOLD SEPARATE, Spring, Throttle Return
15	1399-3796	JET, (.076), BOWL VENT Comment: (200)
16	1399-5317	JET, (.046), IDLE AIR BLEED Comment: (200)
17	1399-3251	JET, (.034), PROGRESSION AIR Comment: (200)
18	17-810747	STEM, ACCELERATOR PUMP
19	810737	COVER ASSEMBLY, ACCELERATOR
20	NSS	NOT SOLD SEPARATE, Screw, Accelerator
21	NSS	NOT SOLD SEPARATE, Gasket, Fuel Bowl
22	NSS	NOT SOLD SEPARATE, Spring, Accelerator Pump
23	810762	PUMP CUP ASSEMBLY
24	NSS	NOT SOLD SEPARATE, Cup
25	NSS	NOT SOLD SEPARATE, Spring, Accelerator Pump
26	810738	FLOAT ASSEMBLY
27	NSS	NOT SOLD SEPARATE, Float Shaft
28	NSS	NOT SOLD SEPARATE, Screw, Float Shaft
29	1395-8116901	VALVE SEAT KIT
30	NSS	NOT SOLD SEPARATE, Gasket, Valve Seat
31	1395-811931	FUEL BOWL (CENTER/BOTTOM) Comment: (175-WMH-11)
32	1395-811694	PLUG, POWER JET
33	NSS	NOT SOLD SEPARATE, Gasket, Power/Progression Jet
34	1399-4216	JET, (.064) Comment: (175/200)
35	810763	POWER JET, POWER Comment: (200)
36	NSS	NOT SOLD SEPARATE, Screw, Fuel Bowl
37	NSS	NOT SOLD SEPARATE, Metering Ball
38	NSS	NOT SOLD SEPARATE, Metering Spring
39	NSS	NOT SOLD SEPARATE, Retainer, Metering Spring
40	1395-7900	TEE FITTING (TOP/CENTER)
41	1395-7901	ELBOW (BOTTOM)

▶Choke Plate and Throttle Levers (15 parts)

Ref	OEM Part #	Part Name
1	18866T	COVER, SOUND ATTENUATOR
2	10-48409	SCREW, (#10-16 x .625), COVER TO CHOKE PLATE
3	27-188891	GASKET, SOUND ATTENUATOR
4	817495A1	SOUNG ATTENUATOR PLATE
5	27-892211	GASKET, ATTENUATOR TO CARBURETOR
6	10-68000	SCREW, (.24-28 X 1.00), CHOKE PLATE TO CARBURETOR
7	12-20583	WASHER, CHOKE PLATE SCREW
8	21-64871A2	CHECK VALVE
9	32-892024122	TUBING, (20.00 Feet Bulk)
10	18180	THROTTLE LINK
11	18181	LINK
12	18178	ROLLER
13	10-87926	SCREW, (#10-32 x .500)
14	12-89302	WASHER, (.203 x .406 x .040)
15	13-69432	LOCKWASHER, (#10 External)

▶Crankshaft(Connecting Rod Forging # is 636-8118) (19 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	455-9536T4	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball, CRANKSHAFT (LOWER)
3	53-67446	RING, BALL BEARING
4	43-14513A09	GEAR KIT
5	10-813073	SCREW, (#6-32 x .620)
6	11-813134	NUT, (#6-32 Special)
7	54196A6	CARRIER ASSEMBLY, SEAL
8	65800	PACKING, CARRIER
9	39-67377T	RING, SEALING - CRANKSHAFT
10	31-16756A6	ROLLER BEARING, CRANKSHAFT
11	785-9737A5	PISTON (PORT-.015 O.S.) Comment: (200)
12	39-815268A4	PISTON RING (.015 O.S.) Comment: (200)
13	53-857196	RING, Lock
14	636-8119A6	CONNECTING ROD ASSEMBLY
15	10-93886	SCREW, (.3125-28 X .875), CONNECTING ROD
16	12-8M0032839	WASHER, NEEDLE LOCATING
17	8M0234886	BEARING KIT
18	29-67483	NEEDLE BEARING, PISTON END

▶Crankshaft(Connecting Rod Forging # is 644-818141) (19 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	455-9536T4	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball (LOWER)
3	53-67446	RING
4	43-14513A09	GEAR KIT
5	10-813073	SCREW, (#6-32 x .620)
6	11-813134	NUT, (#6-32 Special)
7	54196A6	CARRIER ASSEMBLY
8	65800	PACKING
9	39-67377T	RING, SEALING - CRANKSHAFT
10	31-16756A6	ROLLER BEARING, CRANKSHAFT
11	785-9737A10	PISTON (PORT-.015 O.S.) Comment: (200)
12	39-815268A4	PISTON RING (.015 O.S.) Comment: (200)
13	53-857196	RING, Lock
14	644-818141A13	CONNECTING ROD KIT
15	10-763491	SCREW, (.312-24 x .875), CONNECTING ROD
16	12-8M0012298	WASHER, NEEDLE LOCATING
17	8M0234886	BEARING KIT
18	29-8M0204691	NEEDLE BEARING, PISTON END

▶Cylinder Block and End Caps (39 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	884-9763T6	CYLINDER BLOCK (200)
2	16-8M0034455	STUD, POWERHEAD (1-3/4")
3	16-8M0034454	STUD, POWERHEAD (6-3/4")
4	17-43044	PIN, Dowel, LOCATING
5	17-8M0036405	PIN (BEARING RACE)
6	27-11338	GASKET, SEALING
7	8M0088723	COVER, STARTER MOTOR (UPPER)
8	10-73657	SCREW, (.312-18 x 1.50)
9	13-8M0204647	LOCKWASHER, (.312)
10	76867	COVER (LOWER)
11	10-815549	SCREW, (.312-18 x 2)
11A	23-99448	BUSHING
12	10-74824	SCREW, (.312-18 x 1.250)
13	1159-858521T1	UPPER END CAP ASSEMBLY, UPPER
14	25-54029	O-RING
15	31-16756A4	ROLLER BEARING
16	26-41953	SEAL
17	10-30225	SCREW WITH LOCKWASHER, (.312-18 x 1.00)
19	54-63153	J CLIP
20	16-15094	STUD, (.190-32 x 1.870)
21	16-8M0034435	STUD, (#10-32 x 1.00)
22	23-67269	SPACER, FLYWHEEL COVER STUD
23	12-8M0204663	WASHER, FLYWHEEL COVER STUD
24	12-72761	WASHER, FLYWHEEL COVER STUD
25	10-32,11-816874	WING NUT, , FLYWHEEL COVER STUD
26	422482	BRACKET, FLYWHEEL COVER
27	10-49668	SCREW, (.250-20 x .750), BRACKET TO CRANKCASE
28	1156-7809T1	END CAP ASSEMBLY, LOWER
29	25-62700	O-RING, (3.250 Inside Diameter), END CAP
30	26-41953	SEAL, END CAP
31	10-28636	SCREW, (.250-20 x .750)
32	13-26992	LOCKWASHER, (.250), LOWER END CAP SCREW
33	10-64022	SCREW, (.250-20 x 2.125), ADJUSTING - CYLINDER BLOCK
34	11-64015	NUT, ( #8-32), JAM - ADJUSTING SCREW
35	26852	CAP, NYLON - ADJUSTING SCREW
36	93772A11	ADVANCED MODULE Comment: SN# 0C247591 THRU 0C254931
37	10-690201	SCREW, (#10-32 x .875)
38	12-38833	WASHER

▶DETONATION CONTROLLER/TEMPERATURE SENSOR (20 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	826800A8	DETONATION CONTROLLER ASSEMBLY (200)
2	10-88447	SCREW, (.190-32 x 1.62), DETONATION CONTROLLER (200)
3	12-38833	WASHER, DETONATION CONTROLLER SCREW (200)
4	13381	PLATE (200)
5	84-88807A10	CABLE ASSEMBLY (200)
6	10-62568	SCREW, (#10-16 x .375), CABLE TO PLATE (200)
7	23-94304	SPACER (200)
8	41470A25	OIL INJECTION WARNING MODULE ASSEMBLY
9	14851T03	INDICATOR, THROTTLE POSITION
10	10-15150	SCREW, INDICATOR
11	8,13-26995	LOCKWASHER, , INDICATOR SCREW
12	12-30164	WASHER, INDICATOR SCREW
13	23-15885	SLEEVE
14	13221T01	TEMPERATURE SENSOR ASSEMBLY
15	25-45711	O-RING, (.612 x .103)
16	10-57583T	SCREW, (#8-32 x .375), TEMPERATURE SENSOR
17	8,13-26995	LOCKWASHER, , TEMPERATURE SENSOR SCREW
18	10-42813	SCREW
19	813501	PLATE

▶DRIVESHAFT HOUSING AND EXHAUST TUBE (39 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	1590-8343T11	DRIVESHAFT HOUSING (GRAY)
2	16-56295	STUD, (.437 x 2.69), DRIVE SHAFT HSG./GEAR HSG.
3	25067	BUMPER, LOWER MOUNT SCREW
4	10-898831	SCREW, (.500-20 x 6.00), LOWER MOUNT
5	78249	MOUNT, LOWER
6	12-49339	WASHER, (.8125), LOWER MOUNT SCREW
7	11-25096	NUT, LOWER MOUNT SCREW
8	88238A10	WIRE ASSEMBLY, Ground
9	54-8M0036782	CLAMP, LOWER MOUNT
10	10-66727	SCREW, (.312-18 x 1.250), LOWER MOUNT CLAMP ATTACHING
11	67077F1	COVER, LOWER MOUNT CLAMP (GRAY)
12	10-88417	SCREW, (#12-24 x .620), COVER ATTACHING
13	11-35521	NUT, NYLON - COVER TO CLAMP SCREW
14	88238A10	WIRE ASSEMBLY, Ground
15	10-41508	SCREW, (.250-20 x .500), GROUND WIRE
16	12-48926	WASHER, GEAR HOUSING STUD
17	11-29489	NUT, GEAR HOUSING STUD (CAP)
18	12-45176	WASHER, (.453 x .812 x .105), GEAR HOUSING STUD
19	11-8M0204653	NUT, (.437-20), GEAR HOUSING STUD
20	19-64649	PLUG, DRIVE SHAFT HOUSING
21	18276T	EXHAUST TUBE
22	66350001	SEAL, EXHAUST TUBE (LOWER)
23	8M0039076	SEAL, EXHAUST TUBE (UPPER)
24	32-8M0042788	TUBE, WATER
25	27-991734	GASKET, DRIVE SHAFT HOUSING TO PLATE
26	18233A20	PLATE ASSEMBLY, DRIVE SHAFT HOUSING
27	8M0043165	SEAL, BRACKET
28	68011	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500), BRACKET TO PLATE
30	17-43044	PIN, Dowel, LOCATING
31	26-38970	SEAL, WATER TUBE
32	10-90192	SCREW, (.250-20 x .750), EXTENSION TO PLATE
33	27-183076	GASKET, DRIVE SHAFT HOUSING PLATE
34	12-20553	WASHER, POWER HEAD STUD
35	11-69254	NUT, POWER HEAD STUD
36	879288T71	EXH. EXTENSION (200)
37	27-782461	GASKET, EXHAUST EXTENSION
38	814618	BOOT, IDLE EXHAUST

▶Driveshaft Housing (39 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	3503-813563T2	DRIVESHAFT HOUSING (GRAY)(X-LONG)
2	16-56295	STUD, (.437 x 2.69), DRIVE SHAFT HSG./GEAR HSG.
3	25067	BUMPER, LOWER MOUNT SCREW
4	10-898831	SCREW, (.500-20 x 6.00), LOWER MOUNT
5	77327	MOUNT (X-LONG) (USE ON XR4/MAGNUM II)
6	12-49339	WASHER, (.8125), LOWER MOUNT SCREW
7	11-25096	NUT, LOWER MOUNT SCREW
8	88238A10	GROUND WIRE ASSEMBLY
9	54-8M0036782	CLAMP, LOWER MOUNT
10	10-66727	SCREW, (.312-18 x 1.250), LOWER MOUNT CLAMP ATTACHING
11	67077F1	COVER, LOWER MOUNT CLAMP (GRAY)
12	10-88417	SCREW, (#12-24 x .620), COVER ATTACHING
13	11-35521	NUT, NYLON - COVER TO CLAMP SCREW
14	88238A10	GROUND WIRE ASSEMBLY
15	10-41508	SCREW, (.250-20 x .500), GROUND WIRE
16	12-48926	WASHER, GEAR HOUSING STUD
17	11-29489	NUT, GEAR HOUSING STUD (CAP)
18	12-45176	WASHER, (.453 x .812 x .105), GEAR HOUSING STUD
19	11-8M0204653	NUT, (.437-20), GEAR HOUSING STUD
20	19-64649	PLUG, DRIVE SHAFT HOUSING
21	18276T	EXHAUST TUBE
22	66350001	SEAL, EXHAUST TUBE - LOWER
23	8M0039076	SEAL, EXHAUST TUBE - UPPER
24	32-8M0042790	TUBE, WATER (X-LONG)
25	27-991734	GASKET, DRIVE SHAFT HOUSING TO PLATE
26	18233A20	PLATE ASSEMBLY, DRIVE SHAFT HOUSING
27	8M0043165	SEAL, BRACKET
28	68011	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500), BRACKET TO PLATE
30	17-43044	PIN, Dowel, LOCATING
31	26-38970	SEAL, WATER TUBE
32	10-90192	SCREW, (.250-20 x .750), EXTENSION TO PLATE
33	27-183076	GASKET
34	12-20553	WASHER, POWER HEAD STUD
35	11-69254	NUT, POWER HEAD STUD
36	879288T71	EXH. EXTENSION (135/150/175/200)
37	27-782461	GASKET, EXHAUST EXTENSION
38	814618	BOOT, IDLE EXHAUST

▶Dual Engine Extension Kit (18 parts)

Ref	OEM Part #	Part Name
-	92876A9	DUAL ENGINE EXTENSION KIT
1	19624A1	SEAL KIT
2	71565	TUBE-CABLE GUIDE, CABLE GUIDE
3	41055A1	MOUNT
4	14-42100	TAB WASHER
5	11-8M0041651	NUT, (.875-14)
6	88404	TAB WASHER
7	10-38601	SCREW, (.250-28 x 1.250)
8	17729A1	BRACKET
9	10-62055	SCREW, (.3125-24 x 1.25)
10	17728	TAB WASHER
11	10-849838	SCREW, (.375-24 x 1.25)
12	11-8M0204726	NUT, (.375-24)
13	97933A1	STEERING EYE
14	23-23651	SLEEVE, (1.625)
15	97931	TUBING, (4.00 Inches)
16	8M0026098	TUBE
17	11-42099	NUT, (.562-18)

▶E.C.U. ASSEMBLY (18 parts)

Ref	OEM Part #	Part Name
1	824003T16	E.C.U. ASSEMBLY (200)
2	23-34948	SPACER
3	54-146951	CLIP
4	90435	MOUNT, COWL MOUNTING BRACKET
5	12-21249	WASHER, MOUNT ATTACHING
6	11-8267089	NUT, (.250-28), MOUNT ATTACHING
7	84-88807A19	CABLE ASSEMBLY
8	14637	GROMMET
9	23-14636	BUSHING
10	10-28667	SCREW, (.250-20 x 1.00)
11	13-26992	LOCKWASHER, (.250)
12	12-65567	WASHER, (.265 x .750 x .048)
13	13202A2	WATER SENSOR MODULE ASSEMBLY
14	84-88807A18	CABLE ASSEMBLY (BLACK)
15	10-37571	SCREW, (.190-32 x .500), WATER SENSOR MODULE
16	12-89302	WASHER, (.203 x .406 x .040), WATER SENSOR MODULE SCREW
17	84-98866A14	WIRING HARNESS, E.C.U. AND INJECTORS
18	84-87895A4	CABLE (175)

▶EXHAUST MANIFOLD AND EXHAUST PLATE (47 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	19036T1	DIVIDER PLATE
2	27-190503	GASKET, DIVIDER PLATE
3	26-814754	SEAL, DIVIDER PLATE
4	54-814634	CLAMP
5	10-53167T	SCREW, (.312-18 x .880), DIVIDER PLATE
6	86-194373	TERMINAL BLOCK
7	10-90192	SCREW, (.250-20 x .750), TERMINAL BLOCK
8	8M0039767	COVER, RELIEF VALVE
9	10-32,11-45076	NUT, , TERMINAL BLOCK
10	10-32,11-813938	CAPNUT, , TERMINAL BLOCK
11	10-74824	SCREW, (.312-18 x 1.250)
12	27-78690002	GASKET, RELIEF VALVE PLATE
13	10-69570	SCREW, (#10-16 x .750), DIAPHRAGM TO PLATE
14	12-76451	WASHER, DIAPHRAGM SCREW
15	144791	DIAPHRAGM
16	16496	WATER DEFLECTOR
17	16497A1	PLATE, RELIEF VALVE
18	24-64878	SPRING, COMPRESSION POPPET VALVE
19	12-85303	WASHER, POPPET SPRING
20	14480	POPPET, VALVE
21	25-64872	GROMMET, POPPET VALVE
22	65848	CARRIER, POPPET VALVE
23	27-991764	GASKET, EXHAUST PLATE
24	18260T2	EXHAUST PATE, EXHAUST
26	17-43044	PIN, Dowel, LOCATING - EXHAUST PLATE
27	8M0043164	SEAL, EXHAUST PLATE
28	680101	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500)
30	22-89772	CONNECTOR, (.125-27) (STRAIGHT)
32	25-12602002	GROMMET
33	25-8M0179867	GROMMET
34	23-27132	BUSHING, EXHAUST PLATE
35	10-66727	SCREW, (.312-18 x 1.250)
36	10-68783	SCREW, (.312-18 x 2.50)
37	10-898833	SCREW, (.375-16 x 3.50)
38	812905T	BRACKET ASSEMBLY, FRONT
39	10-90285	SCREW, (.312-18 x .625), FRONT BRACKET
40	12-187031	WASHER
41	25-18778001	GROMMET
42	18578T09	BRACKET ASSEMBLY, REAR
43	22-8144301	FITTING, (.500-14)
44	22-920071	FITTING, (.250-18) (90 Degree)
45	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
46	54-816311T	TIE STRAP, (8.00 Inches)
47	12-20553	WASHER, POWERHEAD STUD
48	11-69254	NUT, POWERHEAD STUD

▶Exhaust Manifold and Exhaust Plate (49 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	27-190503	GASKET, DIVIDER PLATE
2	19036T1	DIVIDER PLATE
3	26-814754	SEAL, DIVIDER PLATE
4	54-814634	CLAMP
5	10-53167T	SCREW, (.312-18 x .880), DIVIDER PLATE
6	86-194373	TERMINAL BLOCK (3 TERMINALS)
7	10-90192	SCREW, (.250-20 x .750), TERMINAL BLOCK
8	8M0039767	COVER, RELIEF VALVE
9	10-32,11-45076	NUT, , TERMINAL BLOCK
10	10-32,11-813938	CAPNUT,
11	10-74824	SCREW, (.312-18 x 1.250), COVER TO CYLINDER BLOCK
12	27-78690002	GASKET, RELIEF VALVE PLATE
13	10-69570	SCREW, (#10-16 x .750), DIAPHRAGM TO PLATE
14	12-76451	WASHER, DIAPHRAGM SCREW
15	144791	DIAPHRAGM
16	16496	WATER DEFLECTOR
17	16497A1	PLATE, RELIEF VALVE
18	24-64878	SPRING, COMPRESSION POPPET VALVE
19	12-85303	WASHER, POPPET SPRING
20	14480	POPPET, VALVE
21	25-64872	GROMMET, POPPET VALVE
22	65848	CARRIER, POPPET VALVE
23	27-991764	GASKET, EXHAUST PLATE
24	18260T2	EXHAUST PATE (W/O FITTINGS)
25	22-687271	FITTING, (.250-18 Brass), EXHAUST PLATE (STARBOARD)
26	17-43044	PIN, Dowel
27	8M0043164	SEAL, EXHAUST PLATE
28	680101	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500), BRACKET TO EXHAUST PLATE
30	22-89772	CONNECTOR, (.125-27) (STRAIGHT)
31	32-77653101	HOSE, (24.500 Inches Bulk) (STARBOARD FITTINGS)
32	23-27132	BUSHING, EXHAUST PLATE
33	25-8M0179867	GROMMET
34	25-12602002	GROMMET, EXHAUST PLATE
35	10-66727	SCREW, (.312-18 x 1.250), EXHAUST PLATE ATTACHING
36	10-68783	SCREW, (.312-18 x 2.50), EXHAUST PLATE ATTACHING
37	10-898833	SCREW, (.375-16 x 3.50), EXHAUST PLATE ATTACHING
38	812905T	BRACKET ASSEMBLY, FRONT
39	10-90285	SCREW, (.312-18 x .625), FRONT BRACKET
40	12-187031	WASHER
41	25-18778001	GROMMET
42	18578T09	BRACKET ASSEMBLY, REAR
43	22-8144301	FITTING, (.500-14)
44	22-920071	FITTING, (.250-18) (90 DEG.)
45	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
46	54-816311T	CABLE TIE, (8.00 Inches)
47	12-20553	WASHER, POWERHEAD STUD
48	11-69254	NUT, POWERHEAD STUD

▶FLYWHEEL/STARTER MOTOR (24 parts)

Ref	OEM Part #	Part Name
1	18896A1	COVER KIT, FLYWHEEL
2	79022	MARKER, TIMING
3	10-37572	SCREW, (.190-32 x .380), TIMING MARKER
4	12-72761	WASHER, (.203 x .562 x .060), TIMING MARKER SCREW
5	19-89219001	PLUG, FLYWHEEL COVER
6	19-45907	PLUG, Yellow, FLYWHEEL
7	11-52901	NUT, (.625-18), FLYWHEEL
8	12-33001	WASHER, (.641 x 1.250 x .190), FLYWHEEL
9	271-859238T16	FLYWHEEL (OLD DESIGN)
10	10-32417	SCREW, (.250-28 x .625), FLYWHEEL PLATE (OLD DESIGN)
11	10-68997	SCREW, (.312-24 x .750), FLYWHEEL HUB (OLD DESIGN)
12	398-9610A5	STATOR
13	10-90045	SCREW, (#10-32 x 1.375), STATOR
14	10,13-26996	LOCKWASHER, , STATOR SCREW
15	96455A9	TRIGGER PLATE ASSEMBLY
16	84-93388A1	CABLE ASSEMBLY, Black
17	50-893893	STARTER MOTOR ASSEMBLY
18	23-8M0034918	COLLAR, STARTER MOTOR
19	8M0043376	STOP, RUBBER - STARTER MOTOR
20	13-26992	LOCKWASHER, (.250), STARTER MOTOR TERMINAL
21	11-20890	NUT, (.250-20), STARTER MOTOR TERMINAL
22	84-93388A14	CABLE ASSEMBLY, Black
23	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel, CABLE TO STARTER MOTOR
24	271-859238T16	FLYWHEEL (NEW DESIGN)

▶FUEL MANAGEMENT SYSTEM (46 parts)

Ref	OEM Part #	Part Name
1	14817A19	FUEL MANAGEMENT ASSEMBLY
2	67748	ROLLER, CAM
3	18715T	FUEL INJECTOR
4	35-17422	FILTER, INJECTOR
5	84-15443	HARNESS KIT
6	35-15442	FUEL FILTER KIT
7	35-150282	FUEL FILTER
8	10-400034	SCREW, (M5 x 14), FILTER COVER
9	13-400255	LOCKWASHER, (M5), COVER SCREW
10	32-1350385	HOSE (1/2" O.D.)
11	32-9912688	TUBING, (36.00 Inches Bulk) (1/8" I.D.)
12	32-892024122	TUBING, (20.00 Feet Bulk) (3/32" I.D.)
13	15027	REGULATOR, PRESSURE
14	814233	ELBOW KIT
15	27-18791	GASKET, PRESSURE REGULATOR
16	814012	PLATE, PRESSURE REGULATOR
17	10-814076	SCREW
18	814010	COVER KIT
19	10-4001987	SCREW, (M4 x 16), COVER TO SEPARATOR
20	8,13-26995	LOCKWASHER, , COVER SCREW
21	26-18790	SEAL, VAPOR SEPARATOR
22	15029	O-RING AND SEAL KIT
23	15446	FLOAT VALVE KIT
24	15445	FLOAT KIT
25	814011	BODY KIT
26	21-424811	CHECK VALVE
27	10-4000332	SCREW, (M6 x 35), SEPARATOR
28	15444	LINK
29	21-18241	CHECK VALVE
30	814077	VALVE, Shut-Off
31	26-18792	SEAL, INJECTOR MANIFOLD
32	23-19275	SPACER
34	23-814913	SPACER
35	12-35280	WASHER, (.255 x .620 x .030) (LARGE)
36	12-69057	WASHER (SMALL)
37	54-8M0214911	CLAMP, (15.7), HOSE
38	32-1350385	HOSE (1-3/4")
39	54-816311T	TIE STRAP, (8.00 Inches)
40	14639	BLANKET, FUEL PUMP
41	14640T	COVER, FUEL PUMP
42	10-32228	SCREW, (#10-32 x .625)
43	10,13-26996	LOCKWASHER,
44	10-845674	SCREW, (.250-20 x 4)
45	12-8M0204649	WASHER, (.281 x .500 x .060)
46	14307T01	FUEL PUMP
47	32-146332	HOSE

▶FUEL PUMP AND FUEL FILTER (38 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	15930A15	FUEL PUMP ASSEMBLY
2	21-857005A1	DIAPHRAGM KIT
3	NSS	NOT SOLD SEPARATE, Check Valve-Rubber
4	NSS	NOT SOLD SEPARATE, Gasket-Boost
5	NSS	NOT SOLD SEPARATE, Diaphragm
6	NSS	NOT SOLD SEPARATE, Gasket-Pulse
7	NSS	NOT SOLD SEPARATE, Spring
8	NSS	NOT SOLD SEPARATE, Cap
9	NSS	NOT SOLD SEPARATE, Check Valve
10	NSS	NOT SOLD SEPARATE, Retainer
11	NSS	NOT SOLD SEPARATE, Spring
12	NSS	NOT SOLD SEPARATE, Cap
13	27-8M0204705	GASKET, BASE
14	22-14868	FITTING, FUEL PUMP (ELBOW)
15	22-16604	FITTING, Straight, FUEL PUMP
16	32-8M0108349	TUBING
17	144303	BASE, FUEL PUMP
18	987752	PLATE, FUEL PUMP
19	22-56800	PLUG, Pipe (.0625-27)
20	22-15979	FITTING
21	10-16452	SCREW, (#12-24 x 2.00), FUEL PUMP
22	10-4000310	SCREW, (M5 x 40), FUEL PUMP TO CRANKCASE
23	12-4002314	WASHER, FUEL PUMP SCREW
24	32-9072925	HOSE, PULSE
25	22-997511	FITTING, PULSE HOSE (90 Degree)
26	32-1350385	TUBING, (30 Inch Bulk)
27	54-816311T	TIE STRAP, (8.00 Inches), FUEL TUBING
28	22-816856Q3	CONNECTOR ASSEMBLY, Fuel
29	10-69067	SCREW, (.250-20 x 1.375)
30	812782	SEAL
31	813657	BRACKET
32	10-69067	SCREW, (.250-20 x 1.375)
33	10-28668	SCREW, (.250-20 x .875), FUEL FILTER BASE
34	13170A3	BASE, FUEL FILTER
35	22-136071	FITTING, BASE
36	35-18458Q3	FUEL FILTER ASSEMBLY
37	14570	PROBE, WATER SENSING

▶Flywheel/Starter Motor (25 parts)

Ref	OEM Part #	Part Name
1	18896A1	COVER KIT, FLYWHEEL
2	79918A1	COVER KIT (NON-LOUVERED)
3	10-37572	SCREW, (.190-32 x .380), TIMING MARKER
4	12-72761	WASHER, TIMING MARKER SCREW
5	79022	MARKER, TIMING
6	19-45907	PLUG, (Yellow), FLYWHEEL
7	11-52901	NUT, (.625-18), FLYWHEEL
8	12-33001	WASHER, FLYWHEEL
9	271-859238A9	FLYWHEEL (USE WITH REF. NO. 2) Comment: (WITH SCREWS)
10	10-32417	SCREW, (.250-28 x .625), FLYWHEEL PLATE Comment: (WITH SCREWS)
11	10-68997	SCREW, (.3125-24 X .75), FLYWHEEL HUB Comment: (WITH SCREWS)
12	398-9873A4	STATOR (16 AMP - SEE NOTE) Comment: (USE WITH REF. NO. 2 & 25)(398-9873A4 STATOR IS INCLUDED WITH 271-817632A9 FLYWHEEL)
13	10-817044	SCREW Comment: (USE WITH REF. NO. 2 & 25)
14	10,13-26996	LOCKWASHER, Comment: (USE WITH REF. NO. 2 & 25)
15	96455A9	TRIGGER PLATE ASSEMBLY
16	84-93388A1	CABLE ASSEMBLY, Black
17	50-893893	STARTER MOTOR
18	23-8M0034918	COLLAR, STARTER MOTOR
19	8M0043376	STOP, RUBBER - STARTER MOTOR
20	13-26992	LOCKWASHER, (.250), STARTER MOTOR TERMINAL
21	11-20890	NUT, (.250-20), STARTER MOTOR TERMINAL
22	84-93388A14	WIRE, (Black)
23	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) SS, CABLE TO STARTER MOTOR
24	19-89219001	PLUG
25	271-859238A9	FLYWHEEL (USE WITH REF. NO. 2) Comment: (WITHOUT SCREWS)

▶Fuel Lines (25 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	22-816856Q3	FUEL CONNECTOR, Plastic
2	10-69067	SCREW, (.25-20 X 1.375), FUEL CONNECTOR
3	812782	SEAL
4	32-8M0108349	TUBING
5	54-816311T	CABLE TIE, (8.00 Inches)
6	22-814964	FITTING
7	22-19688	FITTING (ELBOW)
8	32-82381335	TUBING, (8.00 Inch)
9	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
10	35-816296Q03	FILTER, Fuel
11	27-67751	GASKET
12	16-270372	STUD, (.250-28 x 1.125)
13	54-8M0024808	J CLIP
14	10-55715	SCREW, (.250-20 x .880)
15	13-26992	LOCKWASHER, (.250)
16	11-29598	NUT, (.250-28)
17	32-9912878	HOSE, (26.00 Inches Bulk)
18	32-892024122	TUBING, (20.00 Feet Bulk)
19	42859A2	ENRICHNER VALVE
20	54-633001	CLAMP
21	10-73286	SCREW, (.250-20 x .500)
22	32-9912688	TUBING, (36.00 Inches Bulk)
23	86-45915	TERMINAL BLOCK
24	10-69079	SCREW, (#10-16 x .440)

▶Fuel Pump (23 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	15930A15	FUEL PUMP ASSEMBLY
2	21-857005A1	DIAPHRAGM KIT
3	NSS	NOT SOLD SEPARATE, Check Valve, Rubber
4	NSS	NOT SOLD SEPARATE, Check Valve
5	NSS	NOT SOLD SEPARATE, Retainer
6	NSS	NOT SOLD SEPARATE, Gasket-Boost
7	NSS	NOT SOLD SEPARATE, Cap
8	NSS	NOT SOLD SEPARATE, Spring
9	NSS	NOT SOLD SEPARATE, Diaphragm
10	NSS	NOT SOLD SEPARATE, Gasket-Pulse
11	NSS	NOT SOLD SEPARATE, Spring
12	NSS	NOT SOLD SEPARATE, Cap
13	27-8M0204705	GASKET, BASE
14	144303	BASE, FUEL PUMP
15	987752	PLATE, FUEL PUMP
16	22-56800	PLUG, Pipe (.0625-27)
17	22-15979	FITTING
18	10-16452	SCREW, (#12-24 x 2.00), FUEL PUMP
19	10-4000310	SCREW, (M5 x 40), FUEL PUMP TO CRANKCASE
20	12-4002314	WASHER, FUEL PUMP SCREW
21	32-9072925	HOSE
22	22-997511	FITTING, PULSE HOSE

▶GEAR HOUSING(DRIVE SHAFT)(2.0:1) (46 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	1647-9148T47	GEAR HOUSING ASSEMBLY
2	22-85822A10	CONNECTOR ASSEMLBY
3	17-43044	PIN, Dowel
4	16-8M0034464	STUD, (.438 x 3.69) (X-LONG)
5	16-8M0133358	STUD, (.44 x 2.06)
6	16-8M0034463	STUD, (.312 x 3.38)
7	16-306671	STUD, (.250-20/.250-28 x 3.125)
8	31-42647A1	BEARING ASSEMBLY, Roller
9	23-43998	SLEEVE
11	45-897625T	DRIVESHAFT (X-LONG)
13	12-92721	WASHER
14	11-35921	NUT, (.625-18)
15	15-42637A1	SHIM SET
16	31-8M0146566	BEARING, Roller
17	8245191	NUT
18	46-8M0077147	WATER PUMP BASE ASSEMBLY
19	27-8M0204678	GASKET
20	25-8M0142854	O-RING, (2.175 x .175)
21	26-89238	OIL SEAL
22	26-16977	OIL SEAL
23	27-8M0090319	GASKET, LOWER
24	27-858524	GASKET, UPPER
25	8M0204677	FACE PLATE
26	46-96148T1	WATER PUMP BODY ASSEMBLY
27	48752T	INSERT
28	26-38970	SEAL, RUBBER
29	47-89984T4	IMPELLER
30	28-8M0214992	KEY
31	10-8M0215009	SCREW, (#14-8 x 2.25)
32	12-8M0204649	WASHER, (.281 x .500 x .060)
33	11-8267119	NUT, (.250-28)
34	12-36001	WASHER
35	11-13436	NUT
36	25-8M0214918	RING (OLD DESIGN)
37	23-29804T	SLEEVE
38	789022	SHAFT, LOWER
39	53-29641	E RING
40	53-78907	RETAINING RING (OLD DESIGN)
41	25-25439	O-RING, (.862 x .103)
42	23-77631A2	BUSHING ASSEMBLY
43	26-8M0204708	OIL SEAL
44	12-77674	WASHER, RUBBER
45	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
46	22-8M0058389	SCREW, Magnetic, DRAIN
47	12-191833	WASHER, Fiber

▶GEAR HOUSING(DRIVESHAFT)(1.87:1) (46 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	1647-9148T47	GEAR HOUSING ASSEMBLY (BASIC - GRAY)
2	22-85822A10	CONNECTOR ASSEMLBY
3	17-43044	PIN, Dowel
4	16-786382	STUD, (.438 x 3.12)
5	16-8M0133358	STUD, (.44 x 2.06)
6	16-8M0034463	STUD, (.312 x 3.38)
7	16-306671	STUD, (.250-20/.250-28 x 3.125)
8	31-42647A1	BEARING ASSEMBLY, Roller
9	23-43998	SLEEVE, LUBRICATION
11	45-897624T	DRIVESHAFT
13	12-92721	WASHER
14	11-35921	NUT, (.625-18)
15	15-42637A1	SHIM SET
16	31-8M0146566	BEARING, Roller
17	8245191	NUT
18	46-8M0077147	WATER PUMP BASE ASSEMBLY
19	27-8M0204678	GASKET
20	25-8M0142854	O-RING, (2.175 x .175)
21	26-89238	OIL SEAL
22	26-16977	OIL SEAL
23	27-8M0090319	GASKET (LOWER)
24	27-858524	GASKET (UPPER)
25	8M0204677	FACE PLATE
26	46-96148T1	WATER PUMP BODY ASSEMBLY
27	48752T	INSERT
28	26-38970	SEAL
29	47-89984T4	IMPELLER
30	28-8M0214992	KEY
31	10-8M0215009	SCREW, (#14-8 x 2.25)
32	12-8M0204649	WASHER, (.281 x .500 x .060)
33	11-8267119	NUT, (.250-28)
34	12-36001	WASHER
35	11-13436	NUT
36	25-8M0214918	RING, RUBBER (DRIVE SHAFT) (OLD DESIGN)
37	23-29804T	SLEEVE
38	789022	SHAFT, SHIFT LOWER
39	53-29641	E RING
40	53-78907	RETAINING RING (OLD DESIGN)
41	25-25439	O-RING, (.862 x .103)
42	23-77631A2	BUSHING ASSEMBLY
43	26-8M0204708	OIL SEAL
44	12-77674	WASHER, RUBBER
45	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
46	22-8M0058389	SCREW, Magnetic, DRAIN
47	12-191833	WASHER, Fiber

▶GEAR HOUSING(PROPELLER SHAFT)(1.87:1) (37 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	1647-9148T47	GEAR HOUSING ASSEMBLY (BASIC - GRAY)
48	789562	SHIFT CAM
49	89594A1	FOLLOWER
50	79911A1	ROD
51	24-79910	SPRING
52	12-78910	WASHER
53	17-8M0084245	PIN
54	15-47397A1	SHIM SET (.002-3-5-10)
55	31-78172A1	BEARING ASSEMBLY, Tapered Roller
56	43-44104T2	FORWARD GEAR ASSEMBLY
57	31-549281	BEARING, Roller (1")
58	52-823174T	RATCHET
59	17-8M0084243	PIN, Cross
60	17-78909	PIN, Detent
61	24-78962	SPRING
62	44-94148	PROPELLER SHAFT
64	681001	RING, Thrust
65	30-88957T	BEARING, Ball
66	25-8M0214920	O-RING
67	43567T1	CARRIER ASSEMBLY, Bearing
68	31-30956T	BEARING, Needle
69	26-8M0204670	SEAL
70	28-30281	KEY
71	14-79447	TAB WASHER
72	8M2011027	RETAINER
73	97-31640Q4	TRIM TAB ASSEMBLY
74	10-66024	SCREW, (.437-14 x 1.75)
75	8M0039169	FILLER BLOCK
76	11-8M0204653	NUT, (.437-20)
77	10-65210	SCREW, (.375-16 x 1.00)
78	12-835467Q01	THRUST HUB
79	12-31211Q03	WASHER, Splined
80	14-816629Q	TAB WASHER
81	11-52707Q1	NUT KIT, Propeller
82	13-423511	LOCKWASHER, Toothed
83	12-45176	WASHER, (.453 x .812 x .105)

▶GEAR HOUSING(PROPELLER SHAFT)(2.0:1) (37 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	1647-9148T47	GEAR HOUSING ASSEMBLY (Basic)
48	789562	SHIFT CAM
49	89594A1	FOLLOWER, CAM
50	79911A1	ROD, CLUTCH ACTUATOR
51	24-79910	SPRING, COMPRESSION
52	12-78910	WASHER, COMPRESSION SPRING
53	17-8M0084245	PIN, SPRING LOCATOR
54	15-47397A1	SHIM SET, BEARING OUTER RACE (.002-3-5-10)
55	31-78172A1	BEARING ASSEMBLY, Tapered Roller
56	43-44102A2	FORWARD GEAR ASSEMBLY
57	31-549281	BEARING, Roller (1")
58	52-823174T	RATCHET, SLIDING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET TO PROPELLER SHAFT
60	17-78909	PIN, Detent, RATCHET
61	24-78962	SPRING, RETAINING-CROSS PIN
62	44-94148	PROPELLER SHAFT
64	681001	RING, THRUST - BEARING CARRIER
65	30-88957T	BEARING, Ball, BALL - REVERSE GEAR
66	25-8M0214920	O-RING, BEARING CARRIER
67	43567T1	CARRIER ASSEMBLY, Bearing
68	31-30956T	BEARING, Needle, BEARING CARRIER
69	26-8M0204670	SEAL, BEARING CARRIER
70	28-30281	KEY, LOCATING - BEARING CARRIER
71	14-79447	TAB WASHER, GEAR HOUSING COVER
72	8M2011027	RETAINER, GEAR HOUSING
73	97-31640Q4	TRIM TAB, GEAR HOUSING
74	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
75	8M0039169	FILLER BLOCK
76	11-8M0204653	NUT, (.437-20)
77	10-74727	SCREW, (.375-16 x 6.00)
78	12-835467Q01	THRUST HUB
79	12-31211Q03	WASHER, Splined
80	14-816629Q	TAB WASHER
81	11-52707Q1	NUT KIT, Propeller
82	13-423511	LOCKWASHER
83	12-45176	WASHER, (.453 x .812 x .105)

▶Gear Housing(Drive-Standard/Counter Rotation) (47 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	1674-814247T2	GEAR HOUSING , Basic Gray Comment: (Magnum II)
2	22-85822A10	CONNECTOR ASSEMLBY
3	17-43044	PIN, Dowel
4	16-8M0034464	STUD, (.438 x 3.69) (X-LONG)
5	16-8M0133358	STUD, (.44 x 2.06)
6	16-8M0034463	STUD, (.312 x 3.38)
7	16-306671	STUD, (.250-20/.250-28 x 3.125)
8	31-35934A1	ROLLER BEARING Comment: (XR4/Magnum II)
9	23-43998	SLEEVE
11	45-815168	DRIVESHAFT (X-Long) Comment: (XR4/Magnum II)
12	NSS	NOT SOLD SEPARATE, Pinion Gear (PART OF 43-18475A1) Comment: (175/200-Counter Rotation)
13	12-92721	WASHER
14	11-35921	NUT, (.625-18)
15	15-42637A1	SHIM SET
16	31-8M0146566	BEARING, Roller
17	8245191	NUT
18	46-8M0077147	WATER PUMP BASE ASSEMBLY
19	27-8M0204678	GASKET
20	25-8M0142854	O-RING, (2.175 x .175)
21	26-89238	OIL SEAL
22	26-16977	OIL SEAL
23	27-8M0090319	GASKET, LOWER
24	27-858524	GASKET, UPPER
25	8M0204677	FACE PLATE
26	46-96148T1	WATER PUMP BODY ASSEMBLY
27	48752T	INSERT
28	26-38970	SEAL, RUBBER
29	47-89984T4	IMPELLER
30	28-8M0214992	KEY
31	10-8M0215009	SCREW, (#14-8 x 2.25)
32	12-8M0204649	WASHER, (.281 x .500 x .060)
33	11-8267119	NUT, (.250-28)
34	12-36001	WASHER
35	11-13436	NUT
36	25-8M0214918	RING (Use where Applicable)
37	23-29804T	SLEEVE
38	8152641	SHIFT SHAFT Comment: (XR4/Magnum II)
39	53-29641	E-RING
40	53-78907	RETAINING RING (Use Where Applicable)
41	25-25439	O-RING, (.862 x .103)
42	23-77631A2	BUSHING ASSEMBLY
43	26-8M0204708	OIL SEAL
44	12-77674	WASHER, RUBBER
45	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
46	22-8M0058389	SCREW, Magnetic, DRAIN
47	12-191833	WASHER, Fiber

▶Gear Housing(Prop-Counter Rotation 135/150/175/200) (43 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
1	1647-9148T47	GEAR HOUSING ASSEMBLY (GRAY)(BASIC)
47	789562	SHIFT CAM
48	89594A1	FOLLOWER, CAM
49	79911A1	ROD, CLUTCH ACTUATOR
50	24-79910	SPRING, COMPRESSION
51	12-78910	WASHER, SPRING
52	17-8M0084245	PIN, SPRING LOCATOR
53	14469T	BEARING CUP
54	30-88957T	BEARING
55	NSS	NOT SOLD SEPARATE, Reverse Gear (PART OF 43-18572A1 or 43-18475A1)
56	31-15844	BEARING ASSEMBLY, Roller
57	17-78909	PIN, Detent, RATCHET
58	52-823174T	RATCHET, SLIDING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET
60	24-78962	SPRING, RETAINING - CROSS PIN
61	43-18475T1	FORWARD GEAR Comment: (175/200)
62	23-1761513	SPACER SHIM Comment: (.149)
63	31-15841	ROLLER BEARING
64	12-17616	THRUST RING
65	25-8M0214920	O-RING, BEARING CARRIER
66	18447T2	BEARING ADAPTOR
67	31-15843T	ROLLER BEARING
68	12-18448	THRUST WASHER
69	31-15842	BEARING, Thrust
70	44-18446	PROPELLER SHAFT
71	818896T2	BEARING CARRIER
72	31-30956T	ROLLER BEARING, BEARING CARRIER
73	26-8M0204670	SEAL
74	14-79447	TAB WASHER, GEAR HOUSING COVER
75	8M2011027	RETAINER, GEAR HOUSING
76	28-30281	KEY, LOCATING - BEARING CARRIER
77	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
78	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
79	8M0039169	FILLER BLOCK
80	12-45176	WASHER, (.453 x .812 x .105), DRIVE SHAFT HOUSING STUDS
81	11-8M0204653	NUT, (.437-20), DRIVE SHAFT HOUSING STUDS
82	12-835467Q01	THRUST HUB
83	12-31211Q03	WASHER, Splined, PROPELLER NUT
84	14-816629Q	TAB WASHER, PROPELLER NUT
85	11-52707Q1	NUT, Propeller
86	13-423511	LOCKWASHER, Toothed, PROPELLER SHAFT
87	10-65210	SCREW, (.375-16 x 1.00), GEAR HOUSING

▶Gear Housing(Prop-Standard Rotation135/150/175/200) (38 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	1647-9148T47	GEAR HOUSING ASSEMBLY (GRAY) (BASIC)
48	789562	SHIFT CAM
49	89594A1	FOLLOWER, CAM
50	79911A1	ROD, CLUTCH ACTUATOR
51	24-79910	SPRING, COMPRESSION
52	12-78910	WASHER, COMPRESSION SPRING
53	17-8M0084245	PIN, SPRING LOCATOR
54	15-47397A1	SHIM SET, BEARING OUTER RACE (.002-3-5-10)
55	31-78172A1	BEARING ASSEMBLY, Tapered Roller
56	43-44104T2	FORWARD GEAR ASSEMBLY Comment: (175/200)
57	31-549281	ROLLER BEARING (1")
58	52-823174T	RATCHET, SLIDING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET TO PROPELLER SHAFT
60	17-78909	PIN, Detent, RATCHET
61	24-78962	SPRING, RETAINING-CROSS PIN
62	44-94148	PROPELLER SHAFT
63	NSS	NOT SOLD SEPARATE, Reverse Gear (Part of 43-44102A2 or 43-44104A2)
64	681001	RING, Thrust, BEARING CARRIER
65	30-88957T	BEARING, BALL - REVERSE GEAR
66	25-8M0214920	O-RING, BEARING CARRIER
67	43567T1	BEARING CARRIER ASSEMBLY
68	31-30956T	ROLLER BEARING, BEARING CARRIER
69	26-8M0204670	SEAL, BEARING CARRIER
70	28-30281	KEY, LOCATING - BEARING CARRIER
71	14-79447	TAB WASHER, GEAR HOUSING COVER
72	8M2011027	RETAINER, GEAR HOUSING
73	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
74	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
75	8M0039169	FILLER BLOCK
76	11-8M0204653	NUT, (.437-20)
77	10-74727	SCREW, (.375-16 X 6.00)
78	12-835467Q01	THRUST HUB
79	12-31211Q03	WASHER, Splined
80	14-816629Q	TAB WASHER
81	11-52707Q1	NUT, Propeller
82	13-423511	LOCKWASHER, Toothed
83	12-45176	WASHER, (.453 x .812 x .105)

▶Gear Housing(Propshaft)(XR4/Magnum II) (32 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	1674-814247T2	GEAR HOUSING , Basic Gray
44	760394	SHIFT CAM
45	850315A1	CAM FOLLOWER ASSEMBLY
46	24-30622	SPRING, COMPRESSION - CAM FOLLOWER
47	15-44491A1	SHIM SET
48	31-30894A1	BEARING SET, Cup And Cone
49	43-16279A2	FORWARD GEAR
50	31-30895T	ROLLER BEARING
51	52-822539T	CLUTCH
52	17-8M0100263	PIN, Cross
53	24-30893	SPRING
54	44-12238T	PROPELLER SHAFT
55	NSS	NOT SOLD SEPARATE, Reverse Gear (Part of 43-16279A2)
56	12-76358	THRUST WASHER, BEARING CARRIER
57	25-29976	O-RING, BEARING CARRIER
58	41529T2	BEARING CARRIER ASSEMBLY
59	22-8M0169588	FITTING, Grease
60	31-30956T	ROLLER BEARING, BEARING CARRIER
61	26-8M0204670	SEAL
62	28-30281	KEY, LOCATING - BEARING CARRIER
63	14-52700	TAB WASHER, GEAR HOUSING COVER
64	52699	COVER, GEAR HOUSING
65	8M0039169	FILLER BLOCK
66	10-65210	SCREW, (.375-16 x 1.00) (HEX HEAD)
68	14-816629Q	TAB WASHER, PROPELLER NUT
69	11-52707Q1	NUT, Propeller
70	97-31640Q4	TRIM TAB ASSEMBLY
71	10-66024	SCREW, (.437-14 x 1.75)
72	12-45176	WASHER, (.453 x .812 x .105), DRIVE SHAFT HOUSING STUDS
73	11-8M0204653	NUT, (.437-20), DRIVE SHAFT HOUSING STUDS
74	13191Q01	THRUST HUB AND WASHER ASSEMBLY

▶IGNITION COIL/VOLTAGE REGULATOR (29 parts)

Ref	OEM Part #	Part Name
1	195872	PLATE, MOUNTING
2	10-99263	SCREW, VOLTAGE REGULATOR
3	13-26992	LOCKWASHER, (.250)
4	23-19661A1	SPACER
5	18736A21	VOLTAGE REGULATOR
6	18717	SEAL
7	89-8M0185144	SOLENOID (OFF WHITE)
8	10-31716	SCREW, (.250-20 x .620), STARTER SOLENOID
9	84-88807A6	CABLE ASSEMBLY, (3.50 Inches) Black
10	11-8267098	NUT, (.250-20), SOLENOID SCREW
11	8-32,11-26419	NUT, Brass, SOLENOID TERMINAL
12	11-94330	NUT, (.250-20) Brass, SOLENOID TERMINAL
13	84-69739A7	HARNESS ASSEMBLY (#2, 4 AND 6)
14	84-88807A8	CABLE ASSEMBLY, (3.50 Inches) Black
15	84-88807A29	CABLE ASSEMBLY (9" - BLACK)
16	54-816311T	TIE STRAP, (8.00 Inches)
17	43542	COVER, IGNITION COIL
18	339-832757A4	IGNITION COIL ASSEMBLY
19	10-90048	SCREW, (#10-32 x 2.125), IGNITION COIL COVER
20	10-32,11-90078	NUT, , COVER SCREW/GROUND WIRE
21	84-813715A9	CABLE KIT, HIGH TENSION
22	85-63709A1	BOOT/TERMINAL KIT, HIGH TENSION CABLE
23	33-13686Q	SPARK PLUG (NGK #BU8H)
24	10-32,11-45076	NUT, , IGNITION COIL TERMINAL
25	84-88807A13	CABLE ASSEMBLY (5-1/2" - BLACK)
26	10-69022	SCREW, (#10-32 x .500), GROUNDING WIRE
27	814423T	COVER, COIL PLATE
28	10-814343	SCREW, (#10-32 x 2.380), COVER
29	85-97861	INSULATOR

▶Ignition Coil/Voltage Regulator (36 parts)

Ref	OEM Part #	Part Name
1	195872	PLATE, MOUNTING
2	23-19661A1	SPACER Comment: (NEW DESIGN)
3	10-69067	SCREW, (.25-20 X 1.375) Comment: (NEW DESIGN)
4	13-26992	LOCKWASHER, (.250)
5	18736A21	VOLTAGE REGULATOR
6	18717	SEAL
7	89-8M0185144	SOLENOID (OFF WHITE)
8	10-31716	SCREW, (.250-20 x .62), STARTER SOLENOID
9	84-88807A6	WIRE, (3.50 Inches) Black
10	11-8267098	NUT, (.250-20), SOLENOID SCREW
11	8-32,11-26419	NUT, , SOLENOID TERMINAL
12	11-94330	NUT, (.250-20), SOLENOID TERMINAL
13	10-48409	SCREW, (#10-16 x .625), CABLE
14	84-88807A8	WIRE ASSEMBLY, (Black- 3.5 Inches)
15	84-88807A29	CABLE
16	54-816311T	CABLE TIE, (8.00 Inches)
17	43542	COVER, IGNITION COIL
18	339-832757A4	IGNITION COIL ASSEMBLY
19	10-90048	SCREW, (#10-32 x 2.125), IGNITION COIL COVER
20	10-32,11-90078	NUT, , COVER SCREW/GROUND WIRE
21	84-813715A9	CABLE KIT, HIGH TENSION
22	85-63709A1	BOOT KIT, HIGH TENSION CABLE
23	33-13686Q	SPARK PLUG (NGK #BU8H)
24	10-32,11-45076	NUT, , IGNITION COIL TERMINAL
25	84-88807A13	CABLE ASSEMBLY
26	10-69022	SCREW, (#10-32 x .500), GROUNDING WIRE
27	84-69739A6	HARNESS ASSEMBLY (# 1,3 & 5)
28	814423T	COVER, COIL PLATE
29	10-814343	SCREW, (#10-32 x 2.380), COIL PLATE COVER
30	19380	COVER
31	27-193901	GASKET
32	88825A7	VOLTAGE REGUALTOR
33	10-48409	SCREW, (#10-16 x .625)
34	10-32,11-45076	NUT,
35	84-13397A1	HARNESS ASSEMBLY
36	85-97861	INSULATOR

▶Instrumentation (31 parts)

Ref	OEM Part #	Part Name
1	79-895283Q43	TACHOMETER
2	79101T	BRACKET, MOUNTING
3	88-72729	LIGHT BULB
4	88-79888	SOCKET, Light Bulb
5	8-32,11-26419	NUT,
6	84-86396A8	HARNESS ASSEMBLY, Tachometer (5.00 Feet)
7	79-895287Q41	TEMPERATURE GAUGE
8	88-72729	LIGHT BULB
9	88-79888	SOCKET, Light Bulb
10	12-26427	WASHER
11	79480	BRACKET
12	8-32,11-26419	NUT,
13	84-88824A4	CABLE ASSEMBLY, (45.00 Inches-Tan)
14	79-895294Q41	SYNCHRONIZER GAUGE Comment: (COUNTER ROTATION ENGINES)
15	79480	BRACKET Comment: (COUNTER ROTATION ENGINES)
16	8-32,11-26419	NUT, Comment: (COUNTER ROTATION ENGINES)
17	88-72729	LIGHT BULB Comment: (COUNTER ROTATION ENGINES)
18	88-79888	SOCKET, Light Bulb Comment: (COUNTER ROTATION ENGINES)
19	145022	DRIVER, SYNCHRONIZER Comment: (COUNTER ROTATION ENGINES)
20	87-19674A1	SWITCH ASSEMBLY, Lanyard Comment: (COUNTER ROTATION ENGINES)
21	10-18303	SCREW, (.190-16 x 1.750) Comment: (COUNTER ROTATION ENGINES)
22	813679	ADAPTER Comment: (COUNTER ROTATION ENGINES)
23	15920Q54	LANYARD ASSEMBLY Comment: (COUNTER ROTATION ENGINES)
24	10-32866	SCREW, (#10-32 x 2.00) Comment: (COUNTER ROTATION ENGINES)
25	18321	CLAMP, Mounting Comment: (COUNTER ROTATION ENGINES)
26	12-24676	WASHER, (.200 x .440 x .032) Comment: (COUNTER ROTATION ENGINES)
27	10-32,11-68219	NUT, Comment: (COUNTER ROTATION ENGINES)
28	79146	RETAINER Comment: (COUNTER ROTATION ENGINES)
29	54-816311T	CABLE TIE, (8.00 Inches) Comment: (COUNTER ROTATION ENGINES)
30	812497A2	DIODE ASSEMBLY Comment: (COUNTER ROTATION ENGINES)
31	84-11149A3	CABLE ASSEMBLY (3") Comment: (COUNTER ROTATION ENGINES)

▶Key Switch Assembly (14 parts)

Ref	OEM Part #	Part Name
NS	8949112	KEY, Ignition (2F)
1	84-816626A20	KEY SWITCH ASSEMBLY (20")
2	90468A1	COVER ASSEMBLY, Key
3	76424	BRACKET
4	16-55422	STUD, (#10-32 x 2.00)
5	12-24676	WASHER, (.200 x .440 x .032)
6	10-32,11-68219	NUT,
7	816479A3	PLATE
8	87-88107A5	KEY SWITCH (SEE CHART FOR KEY)
9	11-879755	NUT, Special
10	38-90311	INSERT
11	68878A6	ALARM HORN AND WIRE ASSEMBLY
12	68879	COVER
13	23-812711	SPACER, (.250)

▶OIL INJECTION COMPONENTS (33 parts)

Ref	OEM Part #	Part Name
1	12430A4	SENSOR ASSEMBLY
2	10-48409	SCREW, (#10-16 x .625), SENSOR ATTACHING
3	815699T	PUMP ASSEMBLY, Oil (200)
4	25-11379	O-RING, OIL PUMP
5	23-41429A2	BEARING ASSEMBLY, DRIVE GEAR
6	43-14563	GEAR, Driven
7	10-41507	SCREW, (#10-32 x 1.120), OIL PUMP TO CRANKCASE
8	1938512	LINK ASSEMBLY, THROTTLE LEVER TO OIL PUMP
9	32-82381335	TUBING, (8.00 Inch), OIL PUMP
10	994436	OIL RESERVOIR
11	54-415823	CLAMP, OIL HOSE
12	32-82381455	TUBING, OIL RESERVOIR TO OIL PUMP
13	10-690201	SCREW, (#10-32 x .875), OIL RESERVOIR ATTACHING
14	12-42118	WASHER, OIL RESERVOIR SCREW
15	25-42117	GROMMET, OIL RESERVOIR SCREW
16	23-42116	BUSHING, OIL RESERVOIR SCREW
17	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
18	22-42425	TEE, OIL TUBING
19	32-9072925	HOSE, OIL (6-3/4")
20	54-816311T	TIE STRAP, (8.00 Inches)
21	32-99439	HOSE, (114.00 Inches), OIL
22	54-415824	CLAMP
24	21-8781051	FITTING, CHECK VALVE (CRANKCASE)
25	1257-87421	TANK
26	36-43298A2	CAP ASSEMBLY, OIL TANK
27	25-11332	O-RING, (2.225 x .210), CAP
28	816190A4	HOUSING ASSEMBLY, Adapter
29	25-11332	O-RING, (2.225 x .210), ADAPTOR HOUSING
30	32-99802	TUBE, OIL PICK-UP
31	36-43300A9	CAP ASSEMBLY, OIL RESERVOIR
32	27-43307T	GASKET, RESERVOIR CAP
33	8M0187298	FLOAT ASSEMBLY
34	11-99265	PUSHNUT

▶Oil Injection Components (43 parts)

Ref	OEM Part #	Part Name
1	12430A4	SENSOR ASSEMBLY
2	10-48409	SCREW, (#10-16 x .625), SENSOR ATTACHING
3	41470A26	WARNING MODULE ASSEMBLY
4	12-38833	WASHER, WARNING MODULE SCREW
5	10-690201	SCREW, (#10-32 x .875)
6	815699T	OIL PUMP ASSEMBLY (200)
7	8141032	BUSHING, Worm
8	25-11379	O-RING
9	23-41429A2	BEARING ASSEMBLY, DRIVE GEAR
10	43-14563	DRIVEN GEAR
12	10-42813	SCREW, WARNING MODULE LEAD
13	10-41507	SCREW, (#10-32 x 1.120)
14	1257-87421	TANK
15	36-43298A2	CAP ASSEMBLY, OIL TANK
16	25-11332	O-RING, CAP
17	816190A4	HOUSING ASSEMBLY, Adapter Comment: (New Design)
18	25-11332	O-RING, ADAPTOR HOUSING
19	32-99802	TUBE, OIL PICK-UP
20	NLA	No Longer Available, Quick Disconnect Kit (Order parts Separately)
21	32-99439	HOSE, (114.00 Inches) Comment: (New Design)
22	12540A3	HOUSING Comment: (Old Design)
23	12242A1	LATCH Comment: (Old Design)
24	21-8781051	FITTING, CHECK VALVE (CRANKCASE)
25	994436	OIL RESERVOIR
26	10-690201	SCREW, (#10-32 x .875), OIL RESERVOIR ATTACHING
27	12-42118	WASHER, OIL RESERVOIR SCREW
28	25-42117	GROMMET, OIL RESERVOIR SCREW
29	23-42116	BUSHING, OIL RESERVOIR SCREW
30	32-82381455	TUBING, OIL RESERVOIR TO OIL PUMP (5-1/4")
31	36-43300A9	CAP ASSEMBLY, OIL RESERVOIR
32	27-43307T	GASKET, RESERVOIR CAP
33	8M0187298	FLOAT ASSEMBLY
34	11-99265	PUSHNUT
35	54-415824	CLAMP, OIL HOSE
36	54-415823	CLAMP, OIL HOSE
37	32-8M0108355	FUEL LINE, (57.00 Inches Bulk), OIL
38	22-42425	TEE, OIL TUBING
39	32-9072925	HOSE, OIL (6-3/4")
40	32-8M0108355	FUEL LINE, (57.00 Inches Bulk)
41	54-816311T	CABLE TIE, (8.00 Inches)
42	1938516	LINK, THROTTLE LEVER TO OIL PUMP
43	12335A1	BRACKET KIT
44	12323A1	CORD/HOOK KIT

▶POWER TRIM COMPONENTS (39 parts)

Ref	OEM Part #	Part Name
1	99659A22	MANIFOLD ASSEMBLY (GRAY)
2	22-56800	PIPE PLUG, MANIFOLD
3	41493A7	TRIM CYLINDER ASSEMBLY (GRAY)
3A	811600	GUIDE KIT
4	41492A1	GUIDE ASSEMBLY
5	25-41478A1	REPAIR KIT
6	41482A2	CHECK VALVE KIT
7	1100-8M0021648	GUIDE ASSEMBLY, TRIM ROD
8	878413A1	PISTON AND ROD ASSEMBLY (PORT)
9	35-12184A1	TRIM FILTER ASSEMBLY
10	878414T01	PISTON AND ROD ASSEMBLY (STARBOARD)
11	17-821539	PIN, Groove, TRIM CYLINDER (UPPER)
12	893929A01	VALVE ASSEMBLY
12A	53-815949001	E RING
13	10-4000327	SCREW, (M6 x 14), COVER
14	12-4002315	WASHER, COVER SCREW
15	99642	COVER, MANIFOLD
16	25-48462A4	O-RING KIT
17	19-99609A1	PLUG ASSEMBLY
18	99641A1	SHAFT ASSEMBLY
19	22-56800	PIPE PLUG, SHAFT
20	10-4008820	SCREW, (M6 x 20), PUMP AND MOTOR
21	13-400256	LOCKWASHER, (M6)
22	826729A10	PUMP AND MOTOR
23	99625002	SHAFT, UPPER
24	97-818298Q1	ANODE ASSEMBLY
25	10-8M0204707	SCREW, (M6 x 25), ANODE
26	12-8M0204649	WASHER, (.281 x .500 x .060), ANODE SCREW
27	8M0045383	STRIKER PLATE, TRIM SHAFT
28	13-58643	LOCKWASHER, (.375)
29	11-46335	NUT, (.375-24)
30	84-814609A1	CONTROL HARNESS, POWER TRIM
31	84-88808A22	CABLE (6-7/8" - RED)
32	54-22875	CLIP, PUMP WIRE
33	8M0084613	C WASHER, CLIP SCREW
34	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
35	17-878267	PIN, Groove, TRIM CYLINDER (LOWER)
36	10-4000377	SCREW, (M10 x 30), MANIFOLD
37	13-400258	LOCKWASHER, Stainless Steel, MANIFOLD SCREW

▶POWER TRIM PUMP (9 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	12659	FRAME AND FIELD KIT
2	12665	BRUSH SPRING KIT
3	13506	BRUSH CARD KIT
4	12662	PUMP AND END FRAME KIT
5	126631	PUMP SEAL KIT
6	12660	END FRAME KIT
7	12661	ARMATURE KIT
8	12664	THRU BOLT KIT

▶Power Steering Components (44 parts)

Ref	OEM Part #	Part Name
1	17771	MOUNT
2	10-59702	SCREW, (.250-28 x .875)
3	88404	TAB WASHER
4	19624A1	SEAL KIT
5	71565	TUBE-CABLE GUIDE
6	17776	COUPLING
7	10-817040	SCREW, (.375-24 x 2.75)
8	12-34931	WASHER, (.406 x .734 x .063) SS
9	10-856722	SCREW
10	11-8M0204726	NUT, (.375-24)
11	14-42100	TAB WASHER
12	11-8M0041651	NUT, (.875-14)
13	811290	ACCUMULATOR
14	817372	BRACKET
15	10-16862	SCREW, (.250-10 x 1.25)
16	12-8M0204649	WASHER, (.281 x .500 x .060)
17	10-4000383	SCREW, (M10 x 70)
18	12-4002319	WASHER
19	11-40140	NUT, (M10)
20	828588A2	ACTUATOR
21	10-94319	SCREW, (.375-24 x 1.5)
22	23-17405	SPACER
23	11-8M0204726	NUT, (.375-24)
24	10-849838	SCREW, (.375-24 x 1.25)
25	92876A4	LINK ROD
26	12-68300	WASHER
27	10-8M0204707	SCREW, (M6 x 25)
28	12-4002315	WASHER
29	11-401386	NUT, (M6)
30	811292	CLAMP
31	10-818182	SCREW
32	11-400263	NUT, (M5 X 0.8)
33	811291	BRACKET
34	10-38601	SCREW, (.250-28 x 1.250)
35	54-197491	CLAMP
36	87-18211	RELAY SWITCH
37	84-18244A1	HARNESS ASSEMBLY
38	10-18124	SCREW, (10-32 x .75)
39	25-90329	GROMMET
40	23-309772	SPACER
41	816994	BRACKET
42	12-42118	WASHER
43	10-32,11-8M0204718	NUT,
44	37-81563024	DECAL

▶Power Trim Components(Design I) (39 parts)

Ref	OEM Part #	Part Name
1	99659A22	MANIFOLD ASSEMBLY (GRAY)
2	22-56800	PIPE PLUG, MANIFOLD
3	41493A7	TRIM CYLINDER ASSEMBLY (GRAY)
3A	811600	GUIDE KIT
4	41492A1	GUIDE ASSEMBLY
5	25-41478A1	REPAIR KIT
6	41482A2	CHECK VALVE KIT
7	1100-8M0021648	GUIDE ASSEMBLY, TRIM ROD
8	878413A1	PISTON AND ROD ASSEMBLY, PORT
9	35-12184A1	TRIM FILTER ASSEMBLY
10	878414T01	PISTON AND ROD ASSEMBLY, STARBOARD
11	17-821539	PIN, Groove (W/ HEAD)
12	893929A01	VALVE ASSEMBLY
12A	53-815949001	E RING
13	10-4000327	SCREW, (M6 x 14), COVER
14	12-4002315	WASHER, COVER SCREW
15	99642	COVER, MANIFOLD
16	25-48462A4	O-RING KIT
17	19-99609A1	PLUG ASSEMBLY
18	99641A1	SHAFT ASSEMBLY
19	22-56800	PIPE PLUG, SHAFT
20	10-4008820	SCREW, (M6 x 20), PUMP AND MOTOR
21	13-400256	LOCKWASHER, (M6)
22	826729A10	PUMP AND MOTOR
23	99625002	SHAFT, UPPER
24	97-818298Q1	ANODE ASSEMBLY
25	10-8M0204707	SCREW, (M6 x 25), ANODE
26	12-8M0204649	WASHER, (.281 x .500 x .060), ANODE SCREW
27	8M0045383	STRIKER PLATE, TRIM SHAFT
28	13-58643	LOCKWASHER, (.375)
29	11-46335	NUT, (.375-24)
30	84-814609A1	CONTROL HARNESS, POWER TRIM
31	84-87379A14	WIRE ASSEMBLY, (2.750 Inches) (RED)
32	54-22875	CLIP, PUMP WIRE
33	8M0084613	C WASHER, CLIP SCREW
34	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
35	17-878267	PIN, Groove, TRIM CYLINDER (LOWER)
36	10-4000377	SCREW, (M10 x 30), MANIFOLD
37	13-400258	LOCKWASHER, SS, MANIFOLD SCREW

▶Power Trim Components(Design II) (41 parts)

Ref	OEM Part #	Part Name
-	826729A10	POWER TRIM ASSEMBLY, COMPLETE
1	811604F	MANIFOLD ASSEMBLY
2	22-56800	PIPE PLUG
3	880952A03	TILT CYLINDER ASSEMBLY
4	811608	PISTON ROD (BOLT TYPE)
5	823553T	PISTON ROD (NUT TYPE)
6	878239A02	GUIDE KIT
7	811607A1	REPAIR KIT
8	811610A1	CHECK VALVE KIT
9	1100-8M0021648	GUIDE ASSEMBLY
10	878414T01	PISTON AND ROD ASSEMBLY (STARBOARD)
11	35-12184A1	TRIM FILTER ASSEMBLY
12	17-821539	PIN, Groove
13	893929A01	VALVE ASSEMBY
14	53-815949001	E RING
15	10-4000327	SCREW, (M6 x 14)
16	12-4002315	WASHER
17	811611	COVER
18	811612A3	O-RING KIT
19	19-811613	PLUG ASSEMBLY
20	8M0142997	SHAFT ASSEMBLY
21	22-56800	PIPE PLUG
22	878265A6	TRIM MOTOR
23	10-811616	SCREW (SHORT)
24	811617T1	PUMP
25	811619	DRIVESHAFT
26	99625002	SHAFT
27	97-818298Q1	ANODE ASSEMBLY
28	10-8M0204707	SCREW, (M6 x 25)
29	12-8M0204649	WASHER, (.281 x .500 x .060)
30	8M0045383	STRIKER PLATE
31	13-58643	LOCKWASHER, (.375)
32	11-46335	NUT, (.375-24)
33	17-878267	PIN, Groove
34	84-814609A1	CONTROL HARNESS, POWER TRIM
35	84-87379A14	WIRE ASSEMBLY, (2.750 Inches)
36	54-22875	CLIP, PUMP WIRE
37	8M0084613	C WASHER, CLIP SCREW
38	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
39	10-4000377	SCREW, (M10 x 30), MANIFOLD
40	13-400258	LOCKWASHER, SS, MANIFOLD SCREW

▶Power Trim Motor(Use With Design II Power Trim System) (6 parts)

Ref	OEM Part #	Part Name
-	878265A6	TRIM MOTOR
1	811624	FRAME AND FIELD KIT
2	811625	BRUSH CARD KIT
3	811623	END FRAME KIT
4	811626	SEAL KIT
5	811627	ARMATURE KIT

▶Power Trim Pump(Use With Design I Power Trim Pump) (9 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	12659	FRAME AND FIELD KIT
2	12665	BRUSH SPRING KIT
3	13506	BRUSH CARD KIT
4	12662	PUMP AND END FRAME KIT
5	126631	PUMP SEAL KIT
6	12660	END FRAME KIT
7	12661	ARMATURE KIT
8	12664	THRU BOLT KIT

▶REED BLOCK AND CYLINDER HEAD (30 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	18488F2	CYLINDER HEAD (200)
2	27-822844T05	GASKET (200)
3	10-13450	SCREW, (.375-16 x 2.30) (SPECIAL - 200)
4	12-25909	WASHER, (.406 x .812 x .065), CYLINDER HEAD SCREW
5	75692	THERMOSTAT
6	27-8M0204714	GASKET, THERMOSTAT
7	90390A1	COVER KIT, THERMOSTAT
8	10-35386	SCREW, (.312-18 x 1.00), THERMOSTAT COVER
9	22-687271	FITTING, (.250-18) 90 Degree - Brass, ELBOW - WATER HOSES
10	32-77653101	HOSE, (24.500 Inches Bulk), WATER DISTRIBUTION
11	22-68728	FITTING, THERMOSTAT COVER
12	54-816311T	TIE STRAP, (8.00 Inches), WATER HOSES
13	17-63779	PIN, Dowel (.250 x .625)
14	137151	RETAINER, SENSOR AND SENDER
15	10-98257	SCREW, (.312-18 x .500), RETAINER
16	10-28668	SCREW, (.250-20 x .875), REED BLOCK ATTACHING (200)
17	27-167371	GASKET, ADAPTOR PLATE
18	12124A3	PLATE ASSEMBLY (200)
19	903911	REED CLAMP (200)
20	27-883775	GASKET (200)
21	87692	REED BLOCK (200)
22	34-19719A1	REED ASSEMBLY (200)
23	10-28668	SCREW, (.250-20 x .875), ADAPTOR PLATE
24	10-823588	SCREW, (8-32 x .187), REEDS TO REED BLOCK Comment: (QTY. OF 60 ON 175)
25	825164A1	DETONATION SENSOR (200)
26	97465	TEMPERATURE SENDER (STARBOARD)
27	13536A6	TEMPERATURE SENSOR (PORT)
28	10-32,11-45076	NUT, (200)
29	54-8M0024808	J CLIP (200)

▶Reed Block and Cylinder Head (36 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	18488F2	CYLINDER HEAD Comment: (200)
2	27-822844T05	GASKET Comment: (20)(Component of Powerhead)(Head Gasket not included in Engine Gasket Set)
3	10-98534	SCREW, (.375-16 X 2.30)
4	12-25909	WASHER, (.406 x .812 x .065)
5	27-8M0204714	GASKET
6	90390A1	COVER KIT
7	75692	THERMOSTAT
8	10-35386	SCREW, (.312-18 x 1.00)
9	22-687271	FITTING, (.250-18 Brass)
10	32-77653101	HOSE, (24.500 Inches Bulk)
11	22-68728	FITTING
12	54-816311T	CABLE TIE, (8.00 Inches)
13	97465	TEMPERATURE SENDER (STBD.)
14	87628A7	ADAPTOR PLATE (200)
15	10-28668	SCREW, (.250-20 x .875)
16	27-883775	GASKET (200)
17	17-63779	PIN, Dowel (.250 x .625)
18	87692	REED BLOCK Comment: (200)
19	34-19719A1	REED ASSEMBLY Comment: (200)
20	903911	REED CLAMP Comment: (200)
21	10-823588	SCREW, (8-32 x .187) (QTY. OF 84 ON 200)
22	10-92160	SCREW, (.250-20 x .75) Comment: (135/150/MAGNUM II)
22/23	10-28668	SCREW, (.250-20 x .875) Comment: (200)
23	10-96529	SCREW, (.250-20 x 2.00) Comment: (135/150/MAGNUM II)
24	814612	THERMAL AIR VALVE
25	54-26404	CLAMP (1")
26	8M0084613	C WASHER
27	10-69079	SCREW, (#10-16 x .440)
28	13536A7	TEMPERATURE SENSOR (PORT)
29	137151	RETAINER
30	10-98257	SCREW, (.312-18 x .500)
31	22-56759	FITTING, Press-In
32	32-892024122	TUBING, (20.00 Feet Bulk)
33	21-426233	CHECK VALVE (PRESS-IN 11/16")
34	22-15133	FITTING (PRESS-IN)

▶STARTER MOTOR ASSEMBLY (9 parts)

Ref	OEM Part #	Part Name
-	50-893893	STARTER MOTOR ASSEMBLY
1	90645	DRIVE KIT
2	13310T1	PINION ASSEMBLY, Drive
3	75660	PLATE, DRIVE END
4	10-74968	BOLT, THRU
7	79216	ARMATURE
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER, BRUSH
11	15386001	END CAP, COMMUTATOR

▶SWIVEL BRACKET AND STEERING ARM (28 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (175)
1	1499-8710T21	SWIVEL BRACKET ASSEMBLY (GRAY)
2	26-87735	SEAL, Oil, SWIVEL BRACKET (LOWER)
3	23-818764	BUSHING, SWIVEL BRACKET (LOWER AND UPPER)
4	25-8M0214926	O-RING, SWIVEL BRACKET (UPPER)
5	23-816039	SPACER, SWIVEL BRACKET (UPPER)
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING, SWIVEL BRACKET
8	17-67706A55	SWIVEL PIN AND STEERING ARM (GRAY)
9	10-8M0176309	SCREW, (.437-20 x 7.50), STEERING ARM TO UPPER MOUNT
10	78687T	MOUNT, RUBBER (UPPER)
11	12-66921	WASHER, UPPER MOUNT BOLT
12	12-78688	WASHER, UPPER MOUNT BOLT
13	11-8M0204653	NUT, (.437-20), UPPER MOUNT BOLT
14	92876A12	LINK ASSEMBLY, Steering
15	10-849838	SCREW, (.375-24 x 1.25), STEERING LINK TO STEERING ARM
16	11-8M0204726	NUT, (.375-24), STEERING LINK SCREW
17	12-34931	WASHER, (.406 x .734 x .063) Stainless Steel, STEERING LINK TO STEERING ARM
19	86580A1	BOTTOM YOKE (GRAY)
20	53-67684	RING, Retaining, BOTTOM YOKE
21	12-816432	THRUST WASHER, THRUST - SWIVEL BRACKET
22	88882	BUMPER, Top Yoke
23	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET
24	54-54457	J CLIP
25	8M0074846	TRIM SENDER ASSEMBLY
26	10-852368	SCREW, (#10-24 x .750)
27	10,13-26996	LOCKWASHER,
28	12-89302	WASHER, (.203 x .406 x .040)

▶Service/Support Material (1 parts)

Ref	OEM Part #	Part Name
-	90-19592911	OWNER'S GUIDE (GRAY)

▶Starter Motor Assembly (11 parts)

Ref	OEM Part #	Part Name
-	50-893893	STARTER MOTOR
1	90645	DRIVE KIT
2	13310T1	DRIVE
3	75660	PLATE
4	10-74968	BOLT
6	NSS	NOT SOLD SEPARATE, Washer (AMERICAN BOSCH # WA3122)
7	79216	ARMATURE
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER
10	NSS	NOT SOLD SEPARATE, Screw (AMER. BOSCH # 02441-22-SC-30SM)
11	15386001	END CAP

▶Steering Attaching Kit(XR4/ Magnum II) (12 parts)

Ref	OEM Part #	Part Name
-	92876A8	STEERING ATTACHING KIT (SINGLE)
1	41055	MOUNT, STEERING TUBE
2	850791T	COUPLING, STEERING LINK
3	10-73732	SCREW, (.375-24 x 1.120), COUPLING
4	11-8M0204726	NUT, (.375-24), COUPLING SCREW
5	10-59702	SCREW, (.250-28 x .875), MOUNT ATTACHING
6	88404	TAB WASHER, MOUNT SCREW
7	71565	TUBE-CABLE GUIDE, STEERING
8	11-8M0041651	NUT, (.875-14), STEERING TUBE
9	14-42100	TAB WASHER, STEERING TUBE NUT
10	19624A1	SEAL KIT
11	42101	SPACER

▶Swivel Bracket(Casting #1499-8710-6) (25 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	1499-8710T21	SWIVEL BRACKET ASSEMBLY (GRAY)
2	26-87735	SEAL, Oil, SWIVEL BRACKET (LOWER)
3	23-818764	BUSHING, SWIVEL BRACKET-LOWER AND UPPER
4	25-33466	O-RING, UPPER
5	23-67668	SPACER, UPPER
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING, SWIVEL BRACKET
8	17-67706A55	SWIVEL PIN AND STEERING ARM (GRAY)
9	10-8M0176309	SCREW, (.437-20 x 7.50), STEERING ARM TO UPPER MOUNT
10	77326	MOUNT (X-LONG) (USE ON XR4/MAGNUM II)
11	12-66921	WASHER, UPPER MOUNT BOLT
12	12-78688	WASHER, UPPER MOUNT BOLT
13	11-8M0204653	NUT, (.437-20), UPPER MOUNT BOLT
14	92876A12	STEERING LINK ASSEMBLY
15	10-849838	SCREW, (.375-24 x 1.25), STEERING LINK TO STEERING ARM
16	11-8M0204726	NUT, (.375-24), STEERING LINK SCREW
17	12-34931	WASHER, (.406 x .734 x .063) SS, STEERING LINK TO STEERING ARM
18	13-78854	WAVE WASHER, BOTTOM YOKE
19	86580A1	BOTTOM YOKE (GRAY)
20	53-67684	RETAINING RING, BOTTOM YOKE
21	12-67670	WASHER
22	88882	BUMPER, TOP YOKE
23	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET
24	54-54457	J CLIP

▶Swivel Bracket(Casting #1499-8710-7) (27 parts)

Ref	OEM Part #	Part Name
1	1499-8710T21	SWIVEL BRACKET ASSEMBLY (GRAY)
2	26-87735	SEAL, Oil, SWIVEL BRACKET (LOWER)
3	23-818764	BUSHING, SWIVEL BRACKET-LOWER AND UPPER
4	23-816039	SPACER
5	25-8M0214926	O-RING
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING, SWIVEL BRACKET
8	12-816432	THRUST WASHER,
9	10-8M0176309	SCREW, (.437-20 x 7.50), STEERING ARM TO UPPER MOUNT
10	77326	MOUNT (X-LONG) (USE ON XR4/MAGNUM II)
11	12-66921	WASHER, UPPER MOUNT BOLT
12	12-78688	WASHER, UPPER MOUNT BOLT
13	11-8M0204653	NUT, (.437-20), UPPER MOUNT BOLT
14	92876A12	STEERING LINK ASSEMBLY
15	10-849838	SCREW, (.375-24 x 1.25), STEERING LINK TO STEERING ARM
16	11-8M0204726	NUT, (.375-24), STEERING LINK SCREW
17	12-34931	WASHER, (.406 x .734 x .063) SS, STEERING LINK TO STEERING ARM
18	17-67706A55	SWIVEL PIN AND STEERING ARM (GRAY)
19	86580A1	BOTTOM YOKE (GRAY)
20	53-67684	RETAINING RING, BOTTOM YOKE
21	88882	BUMPER, TOP YOKE
22	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET
23	54-54457	J CLIP
24	8M0074846	TRIM SENDER ASSEMBLY
25	10-852368	SCREW, (#10-24 x .750)
26	10,13-26996	LOCKWASHER,
27	12-89302	WASHER, (.203 x .406 x .040)

▶THROTTLE LEVER AND SHIFT SHAFT (48 parts)

Ref	OEM Part #	Part Name
1	74897T	PIVOT, TRIGGER PLATE
2	62459T	BALL JOINT ASSEMBLY, TRIGGER PLATE
3	10-32,11-45076	NUT, , LINK ROD
4	76035	ROD, TRIGGER PLATE
5	10-32,11-46438	NUT, , BALLJOINT
6	41094A3	LEVER ASSEMBLY, SPARK ADVANCE
7	10-64022	SCREW, (.250-20 x 2.125), SPARK ADVANCE LEVER - STOP
8	11-64015	NUT, (.250-20), SPARK ADVANCE STOP SCREW
9	26852	CAP, SPARK ADVANCE LEVER STOP SCREW
10	10-13627	SCREW, (.190-32 x 1.250)
11	10-32,11-68219	NUT, Stainless Steel, SPARK ADVANCE LEVER STOP SCREW
12	48039	CAP, SPARK ADVANCE LEVER STOP SCREW
13	410952	LEVER, THROTTLE CONTROL
14	10-818165	SCREW, (.375-16 x 1.75)
15	23-55164	BUSHING, THROTTLE LEVER
16	23-55171	BUSHING, SPARK ADVANCE LEVER
17	24-55162	SPRING
18	12-46765	WASHER, SPARK ADVANCE LEVER
19	10-64022	SCREW, (.250-20 x 2.125), THROTTLE LEVER - STOP
20	11-64015	NUT, (.250-20), THROTTLE LEVER STOP SCREW
21	26852	CAP, THROTTLE LEVER STOP SCREW
22	39483	LATCH, CABLE
23	10-69026	SCREW, (.250-28 x .880), CABLE LATCH TO THROTTLE LEVER
24	24-20099	SPRING, CABLE LATCH TO THROTTLE LEVER
25	11-826709109	NUT, (.250-28), CABLE LATCH SCREW
26	14634	ROD, THROTTLE CONTROL
27	14638	BARREL, THROTTLE CONTROL ROD
28	8142392	CAM
29	23-8M0215006	BUSHING
30	23-26856	BUSHING, THROTTLE CAM
31	11-826709109	NUT, (.250-28), THROTTLE CAM STUD
33	814283A2	BRACKET, ANCHOR - CONTROL CABLES
34	98889	LATCH, CONTROL CABLE
35	10-42975	SCREW, Drive, LATCH
36	10-53167T	SCREW, (.312-18 x .880), ANCHOR BRACKET ATTACHING
37	814284	GUIDE BLOCK, LINK ROD
38	24-20099	SPRING, LINK ROD TO GUIDE BLOCK
39	67073A1	LINK ROD ASSEMBLY
40	52100	WEAR PLATE, LINK ROD
41	8M0036768	LATCH
42	12-35462	WASHER, (.2656 x .625 x .0625) , LATCH
43	11-826709109	NUT, (.250-28), LINK ROD
44	79932A16	SHIFT SHAFT ASSEMBLY
45	13-29720	WAVE WASHER, LINK ROD
46	23-26600	BUSHING, NYLON - LINK ROD
47	12-35462	WASHER, (.2656 x .625 x .0625) , LINK ROD
48	11-826709109	NUT, (.250-28), LINK ROD TO SHIFT SHAFT
49	39519	CUP, BARREL RETAINER - ANCHOR BAR

▶TOP COWL AND FRONT SHIELD (28 parts)

Ref	OEM Part #	Part Name
1	2196-9743T10	TOP COWL ASSEMBLY (GRAY)(Without Decals)
2	812784	SEAL
3	815478	SEAL
4	815225	SOUND BLANKET (SIDE) Comment: (USE WITHOUT DEFLECTORS)
4/5	815225A1	SOUND BLANKET KIT Comment: (USE W/DEFLECTORS)
5	815226	SOUND BLANKET (TOP) Comment: (USE WITHOUT DEFLECTORS)
6	815227	SOUND BLANKET, FRONT
7	47341A11	ROPE AND HANDLE KIT Comment: MANUAL STARTING
8	11-815848	NUT, (.312)
9	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel
10	184741	BRACKET, REAR
11	25-18506001	GROMMET
12	10-28636	SCREW, (.250-20 x .750), REAR BRACKET
13	10-816992	SCREW
14	813096A2	HOOK
15	10-73286	SCREW, (.250-20 x .500)
16	8M0207770	ROLLER
17	53-13194	RING, Retaining
18	12-56720	WASHER, (.330 x .750 x .060)
19	187021	LOCATOR
20	893763	BRACKET ASSEMBLY, Latch Roller
21	813552	SPACER (OLD DESIGN)
21A	816838	SPACER
22	10-69267	SCREW, (.312-18 x 1.750)
23	18755A2	FRONT SHIELD ASSEMBLY (GRAY)(Without Decals)
25	10-77137	SCREW, (.190-16 x .620)
26	12-8M0204666	WASHER, (.203 x .500 x .032)
27	12-36001	WASHER

▶TRANSOM BRACKETS (22 parts)

Ref	OEM Part #	Part Name
1	3401-8718F8	TRANSOM BRACKET (STARBOARD) (GRAY)
2	3400-8716A9	TRAMSOM BRACKET (PORT) (GRAY)
3	22-8M0169588	FITTING, Grease
4	11-8M0041651	NUT, (.875-14)
5	99170A2	TILT TUBE
6	11-859133	NUT, TILT TUBE (GRAY)
7	25-45711	O-RING, (.612 x .103)
8	13-88750	WASHER
9	11-858869	NUT, (.875-14), TILT TUBE
10	10-8M0149747	SCREW, (.500-20 x 4.500), TRANSOM BRACKET TO TRANSOM
11	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel, TRANSOM BRACKET BOLT
12	11-91962	NUT, (.500-20), TRANSOM BRACKET BOLT
13	8M0115104	LEVER ASSEMBLY
14	13-99611	WAVE WASHER
15	23-65830	NYLINER
16	99633	KNOB (GRAY)
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY, TILT LOCK
21	11-23161	NUT, (.375-24), BOLT
22	814207	STOP

▶Throttle Lever and Shift Shaft (53 parts)

Ref	OEM Part #	Part Name
1	74897T	PIVOT, TRIGGER PLATE
2	62459T	BALL JOINT ASSEMBLY, TRIGGER PLATE
3	10-32,11-45076	NUT, , LINK ROD
4	76035	ROD, TRIGGER PLATE
5	10-32,11-46438	NUT, , BALL JOINT
6	41094A3	LEVER ASSEMBLY, SPARK ADVANCE
7	10-64022	SCREW, (.250-20 x 2.125), SPARK ADVANCE LEVER
8	11-64015	NUT, ( #8-32)
9	26852	CAP, SPARK ADVANCE LEVER STOP SCREW
10	10-69560	SCREW, (.190-32 X 1.25)
11	10-32,11-68219	NUT, , SPARK ADVANCE LEVER STOP SCREW
12	48039	CAP, SPARK ADVANCE LEVER STOP SCREW
13	410952	LEVER, THROTTLE CONTROL
14	10-818165	SCREW, (.375-16 x 1.75)
15	23-55164	BUSHING, THROTTLE LEVER
16	23-55171	BUSHING, SPARK ADVANCE LEVER
17	24-55162	SPRING, THROTTLE AND SPARK ADVANCE LEVER
18	12-46765	WASHER, SPARK ADVANCE LEVER
19	10-64022	SCREW, (.250-20 x 2.125), THROTTLE LEVER - STOP
20	11-64015	NUT, ( #8-32), THROTTLE LEVER STOP SCREW
21	26852	CAP, THROTTLE LEVER STOP SCREW
22	39483	LATCH, CABLE
23	10-69026	SCREW, (.250-28 x .88), CABLE LATCH TO THROTTLE LEVER
24	24-20099	SPRING, CABLE LATCH TO THROTTLE LEVER
25	11-826709109	NUT, (.250-28), CABLE LATCH SCREW
26	814929	ROD, THROTTLE CONTROL
27	14638	BARREL, THROTTLE CONTROL ROD
28	815539T	THROTTLE CAM
29	16-20353	STUD, (.250-28 x 1.750), THROTTLE CAM ATTACHING
30	23-8M0215006	BUSHING
31	11-826709109	NUT, (.250-28), THROTTLE CAM STUD
32	24-41050	SPRING, THROTTLE RETURN (OLD DESIGN)
33	814283A2	BRACKET, ANCHOR - CONTROL CABLES
34	98889	LATCH, CONTROL CABLE
35	10-42975	SCREW, Drive, LATCH
36	39519	CUP, BARREL RETAINER
37	23-26600	BUSHING, NYLON - LINK ROD
38	12-35462	WASHER, (.2656 x .625 x .0625) , LINK ROD
39	11-826709109	NUT, (.250-28), LINK ROD TO SHIFT SHAFT
40	10-53167T	SCREW, (.312-18 x .880), ANCHOR BRACKET
41	814284	GUIDE BLOCK, LINK ROD
42	24-20099	SPRING, LINK ROD TO GUIDE BLOCK
43	67073A1	LINK ROD ASSEMBLY
44	52100	WEAR PLATE, LINK ROD
45	8M0036768	LATCH
46	12-35462	WASHER, (.2656 x .625 x .0625) , LATCH
47	11-826709109	NUT, (.250-28), LINK ROD
48	79932A17	SHIFT SHAFT ASSEMBLY (X-LONG)
49	13-29720	WAVE WASHER, LINK ROD
50	87-814281A1	IDLE STABILIZING SHIFT KIT
51	10-77478	SCREW, (#6-32 x .875)
52	12-27882	WASHER
53	17461A3	RESISTOR MODULE

▶Top Cowl and Front Shield (32 parts)

Ref	OEM Part #	Part Name
1	2196-9742A91	TOP COWL ASSEMBLY (GRAY) Comment: (MAGNUM II)
2	812784	SEAL
3	815478	SEAL
4	814823	SOUND BLANKET (SIDE) Comment: (USE WITHOUT DEFLECTOR)
4/5	814823A1	SOUND BLANKT KIT Comment: (USE W/ DEFLECTOR)
5	814837	SOUND BLANKET Comment: (USE WITHOUT DEFLECTOR)
6	17196A1	SHIELD, AIR INLET Comment: (XR4/MAGNUM II)
7	11-11316	SPEED/NUT Comment: (XR4/MAGNUM II)
8	17238	SEAL, AIR INLET Comment: (XR4/MAGNUM II)
9	17195	SHIELD, AIR INLET (STBD) Comment: (XR4/MAGNUM II)
10	184741	BRACKET, REAR
11	25-18506001	GROMMET
12	10-28636	SCREW, (.250-20 x .750)
13	12-56720	WASHER, (.330 x .750 x .060)
14	813096A2	HOOK
15	10-73286	SCREW, (.250-20 x .500)
16	8M0207770	ROLLER
17	53-13194	RING, Retaining
18	10-816992	SCREW
19	187021	LOCATOR
20	893763	BRACKET
21	813552	SPACER
21A	816838	SPACER
22	10-69267	SCREW, (.312-18 x 1.750)
23	11-815848	NUT, (.312)
24	47341A11	ROPE AND HANDLE KIT (FOR MANUAL STARTING)
25	18755A2	FRONT SHIELD ASSEMBLY (GRAY)
26	813562	SEAL (OLD DESIGN)
27	10-77137	SCREW, (.190-16 X .62)
28	12-8M0204666	WASHER, (.203 x .500 x .032)
29	12-8M0042642	WASHER, (.323 x .563 x .063)
30	12-36001	WASHER

▶Transom Brackets (23 parts)

Ref	OEM Part #	Part Name
-	27-815791A92	GASKET SET Comment: (200)
1	3401-8718F8	TRANSOM BRACKET (STARBOARD) Comment: (GRAY)
2	3400-8716A9	TRAMSOM BRACKET (PORT) Comment: (GRAY)
3	22-8M0169588	FITTING, Grease
4	11-8M0041651	NUT, (.875-14)
5	99170A2	TILT TUBE
6	11-859133	NUT (1"-14) (GRAY)
7	25-45711	O-RING
8	13-88750	WAVE WASHER
9	11-858869	NUT, (.875-14)
10	10-8M0149747	SCREW, (.500-20 x 4.500)
11	12-8M0204648	WASHER
12	11-91962	NUT
13	8M0115104	LEVER ASSEMBLY
14	13-99611	WAVE WASHER
15	23-65830	NYLINER
16	99633	KNOB (GRAY)
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY
21	11-23161	NUT, (.375-24)
22	814207	STOP

▶WIRING HARNESS/STARTER SOLENOID (42 parts)

Ref	OEM Part #	Part Name
1	434292	IGNITION PLATE, IGNITION
2	332-7778A12	SWITCH BOX
3	10-13669	SCREW, (#12-24 x 2.00), SWITCH BOX
4	23-94453	BUSHING, SWITCH BOX SCREW
6	10-32,11-45076	NUT, , SWITCH BOX TERMINAL
7	84-60871A10	WIRE ASSEMBLY, SWITCH BOX
8	10-62568	SCREW, (#10-16 x .375), WIRE ATTACHING
9	84-65999A3	CABLE ASSEMBLY, Black
10	10-60411	SCREW, (1.25), IGNITION PLATE
11	13-8M0204647	LOCKWASHER, (.312), IGNITION PLATE SCREW
12	12-36042	WASHER, IGNITION PLATE SCREW
13	12-67264	WASHER, (Rubber), IGNITION PLATE SCREW
14	23-67268	BUSHING, IGNITION PLATE SCREW
15	87-33386A3	SWITCH ASSEMLBY
16	10-38055	SCREW, (.190-32 x .620), MERCURY SWITCH
17	10-32,11-45076	NUT, , MERCURY SWITCH TERMINAL
18	10-87926	SCREW, (#10-32 x .500), LEAD ATTACHING
19	84-88439A4	BATTERY CABLE, Negative
20	84-96220A12	HARNESS, ENGINE
21	88-8M0207796	FUSE, 20 Ampere
22	84-95084A2	CABLE ASSEMBLY, FUSE
24	54-816311T	TIE STRAP, (8.00 Inches), HARNESS AND CABLES
25	89-853654A1	SOLENOID ASSEMBLY, Starter
26	10-32,11-45076	NUT, , SOLENOID TERMINALS
27	13-53166	LOCKWASHER, (.312)
28	11-8M0204668	NUT, (.312-18), SOLENOID TERMINALS
29	10-31716	SCREW, (.250-20 x .620)
30	13-26992	LOCKWASHER, (.250)
31	84-65999A2	CABLE ASSEMBLY, Black, UPPER MOUNT
32	84-91865A1	CABLE ASSEMBLY (3" - WHITE/BLACK - 175)
33	54-47483	J CLIP
34	86-194372	TERMINAL BLOCK
35	10-38055	SCREW, (.190-32 x .620)
36	12-89302	WASHER, (.203 x .406 x .040)
37	10-32,11-45076	NUT,
38	814422T	COVER, IGNITION PLATE
39	10-88447	SCREW, (.190-32 x 1.62)
40	10-690201	SCREW, (#10-32 x .875)
41	12-89302	WASHER, (.203 x .406 x .040)
42	10,13-26996	LOCKWASHER,
43	84-62310A2	CABLE ASSEMBLY (175)
44	85-78866	INSULATOR

▶Wiring Harness/Starter Solenoid (45 parts)

Ref	OEM Part #	Part Name
1	434292	IGNITION PLATE
2	332-7778A12	SWITCH BOX
3	10-13669	SCREW, (12-24 x 2.00), SWITCH BOX TO IGNITION PLATE
4	23-94453	BUSHING, SWITCH BOX SCREW
5	84-62310A2	CABLE ASSEMBLY, SWITCH BOX TO SWITCH BOX
6	10-32,11-45076	NUT, , SWITCH BOX TERMINAL
7	84-60871A10	WIRE ASSEMBLY, SWITCH BOX
8	10-62568	SCREW, (#10-16 x .375), WIRE ATTACHING
9	84-65999A3	CABLE ASSEMBLY, (Black)
10	10-60411	SCREW, (1.25), IGNITION PLATE
11	13-8M0204647	LOCKWASHER, (.312), IGNITION PLATE SCREW
12	12-36042	WASHER, IGNITION PLATE SCREW
13	12-67264	WASHER, (Rubber), IGNITION PLATE SCREW
14	23-67268	BUSHING, IGNITION PLATE SCREW
15	87-33386A3	SWITCH ASSEMLBY
16	10-38055	SCREW, (.190-32 X .62), MERCURY SWITCH TO IGNITION PLATE
17	10-32,11-45076	NUT, , MERCURY SWITCH TERMINAL
18	10-87926	SCREW, (#10-32 x .500), LEAD ATTACHING
19	84-88439A4	BATTERY CABLE, Negative
20	84-96220A4	HARNESS, ENGINE (USE W/RECTIFIER)
21	88-8M0207796	FUSE, (20 Ampere)
22	84-95084A2	CABLE ASSEMBLY, FUSE
23	54-47483	J CLIP
24	54-816311T	CABLE TIE, (8.00 Inches), HARNESS AND CABLES
25	89-853654A1	STARTER SOLENOID
26	10-32,11-45076	NUT, , SOLENOID TERMINALS
27	13-53166	LOCKWASHER, (.312), SOLENOID TERMINALS
28	11-8M0204668	NUT, (.312-18), SOLENOID TERMINALS
29	10-31716	SCREW, (.250-20 x .62), SOLENOID TO IGNITION PLATE
30	13-26992	LOCKWASHER, (.250)
31	84-65999A2	CABLE ASSEMBLY, (Black), UPPER MOUNT
32	84-88528A2	CABLE ASSEMBLY (6" - RED/WHITE)
33	86-194372	TERMINAL BLOCK
34	10-38055	SCREW, (.190-32 X .62)
35	12-89302	WASHER, (.203 x .406 x .040)
36	10-32,11-45076	NUT,
37	814422T	COVER, IGNITION PLATE
38	10-88447	SCREW, (.190-32 x 1.62)
39	10-690201	SCREW, (#10-32 x .875)
40	12-89302	WASHER, (.203 x .406 x .040)
41	10,13-26996	LOCKWASHER,
42	8M0058226	RECTIFIER
43	10-38055	SCREW, (.190-32 X .62)
44	10-32,11-45076	NUT,
45	85-78866	INSULATOR

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury V-200XRI (EFI) running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Popular Products

Popular Products

Popular Products

Mercury V-200XRI (EFI) (0C291520 THRU 0D081999) Parts & Diagrams

Categories

Refined By Clear all

Brand

Horsepower

Engine

Availability

Price

Need Help?

Images

Product

Price

Qty

Options