Mercury V-200 (EFI) (0C100861 THRU 0C999999) Parts & Diagrams

🔎 Mercury V-200 (EFI) Reference Library — Exploded parts diagrams (26 diagrams), specifications, common issues, and maintenance checklist.

The Mercury V-200 (EFI) is a 2-Stroke EFI, V6 60-degree outboard motor. Designed for large center-consoles, offshore sport-fishing boats, and multi-engine configurations.

Quick Reference Specifications

Specification	Value
Engine Type	2-Stroke EFI, V6 60-degree
Horsepower	200 HP
Displacement	2507 cc (2.5L / 153 CID)
Bore x Stroke	89 mm x 67 mm (3.501 in. x 2.650 in.)
Spark Plug (Type & Gap)	NGK BPZ8HS-10
Engine Oil Capacity	—
Recommended Engine Oil	Mercury 2-Stroke Outboard Oil (TCW-3)
Gear Case Oil Capacity	802 mL (27.1 oz)
Idle Speed (in gear)	650–700 RPM (in gear)
Full Throttle RPM Range	5000-5600
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury V-200 (EFI):

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury V-200 (EFI).

▶BLEED SYSTEM (10 parts)

Ref	OEM Part #	Part Name
1	32-892024122	TUBING, (20.00 Feet Bulk), BLEED
2	22-59169003	FITTING
3	21-426982	CHECK VALVE (PRESS-IN - 13/16" LONG)
4	21-426233	CHECK VALVE (PRESS-IN - 11/16" LONG)
5	22-15133	FITTING (PRESS-IN)
6	22-56759	FITTING, Barbed (PRESS-IN)
7	22-15026	CAP, ELBOW (YELLOW)
8	22-18205	TEE
9	32-9912688	TUBING, (36.00 Inches Bulk)
10	35-8M0207786	FILTER

▶BOTTOM COWL (42 parts)

Ref	OEM Part #	Part Name
-	813096A1	REAR LATCH KIT Comment: ORDER WHEN REPLACING NON-ROLLER COMPONENTS. (A PRODUCT IMPROVEMENT.)
1	2197-9744A16	BOTTOM COWL (PORT) Comment: SN# C239553 & Up
2	2197-9745A5	BOTTOM COWL (STARBOARD) Comment: SN# C239553 & Up
3	18701A1	SEAL KIT, BOTTOM COWLS
3A	21-817519A1	CHECK VALVE
4	10-18699	SCREW, (.250-20 x 1.320), COWL (STARBOARD)
5	18872A1	COVER ASSEMBLY
6	11-8136921	LOCKNUT
7	54-816311T	TIE STRAP
8	18727	ROD
9	23-65830	NYLINER
10	23-19666	BUSHING
11	13-99611	WAVE WASHER
12	12-69057	WASHER, (.281 x .734 x .063)
13	10-18192	SCREW, (.250-20 x .620)
14	19648A2	HANDLE ASSEMBLY (PORT)
15	19647A3	HANDLE ASSEMBLY (STARBOARD)
16	19370	PAWL (PORT)
17	19369	PAWL (STARBOARD)
18	10-73286	SCREW, (.250-20 x .500) Stainless Steel
19	54-19749	CLAMP (UPPER)
20	54-197481	CLAMP (LOWER)
21	10-92799	SCREW, (#10-16 x 1.12)
22	84-16636A1	HARNESS ASSEMBLY, TRIM. Comment: SN# C239552 & Below
23	10-72202	SCREW, (#10-32 x 1.25) Comment: SN# C239552 & Below
24	12-8M0204666	WASHER, (.203 x .500 x .032) Comment: SN# C239552 & Below
25	10-32,11-8M0204718	NUT, Comment: SN# C239552 & Below
26	84-16639A1	HARNESS ASSEMBLY Comment: SN# C239552 & Below
27	88-8M0207796	FUSE, 20 Ampere Comment: SN# C239552 & Below
28	84-95084A2	CABLE ASSEMBLY, FUSE Comment: SN# C239552 & Below
29	22-813613	FITTING, TELLTALE
30	22-90824001	TEE, TELLTALE
31	32-8M0108355	LINE, (57.00 Inches Bulk), TELLTALE
32	8130762	FRONT HANDLE ASSEMBLY
33	813925	HANDLE LOCK
34	813926	HANDLE
35	24-8139291	SPRING
36	10-69079	SCREW, (#10-16 x .440)
37	17-815296	PIN, Lock
38	13-26992	LOCKWASHER, (.250) Stainless Steel
39	87-8M0042301	SWITCH ASSEMBLY Comment: SN# C239553 & Up
40	8M0032848	RETAINER, SWITCH Comment: SN# C239553 & Up

▶CRANKSHAFT, PISTONS AND CONNECTING RODS (18 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	455-8745T5	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball, CRANKSHAFT (LOWER)
3	53-67446	RING, BALL BEARING
4	43-99727A1	GEAR, Drive
5	54196A6	CARRIER ASSEMBLY, SEAL
6	65800	PACKING, CARRIER
7	39-78633	RING, SEALING - CRANKSHAFT (.139 THICK)
8	31-93495T	BEARING, Roller, CRANKSHAFT
9	53-67444	RING, Retaining, ROLLER BEARING
10	766-8667T41	PISTON ASSEMBLY (PORT)
11	39-813011A12	RING ASSEMBLY, Piston
12	53-857196	RING, Lock, PISTON
13	636-8119A6	CONNECTING ROD ASSEMBLY
14	10-93886	SCREW, (.312-28 x .875), CONNECTING ROD
15	12-8M0032839	WASHER, NEEDLE LOCATING
16	8M0234886	BEARING KIT, CRANKSHAFT END
17	29-67483	BEARING, Needle, PISTON END

▶CYLINDER BLOCK AND END CAPS (49 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	858-8712T41	CYLINDER BLOCK
2	16-76175	STUD, POWERHEAD Comment: (1-7/8")
3	16-8M0034454	STUD, POWERHEAD Comment: (6-3/4")
4	17-43044	PIN, Dowel, LOCATING
5	17-8M0036405	PIN, CYLINDER BLOCK (BEARING RACE)
6	27-11338	GASKET, SEALING
7	8M0088723	COVER, STARTER MOTOR (UPPER)
8	10-73657	SCREW, (.312-18 x 1.50), COVER TO CRANKCASE Comment: (1-1/2")
9	13-8M0204647	LOCKWASHER, (.312), STARTER MOTOR COVER SCREW
10	76867	COVER, STARTER MOTOR (LOWER)
11	10-815549	SCREW, (.312-18 x 2), COVER TO CRANKCASE Comment: (2")
12	23-99448	BUSHING
13	84-88807A20	CABLE ASSEMBLY, COVER
14	10-74824	SCREW, (.312-18 x 1.250), CRANKCASE TO CYLINDER BLOCK Comment: (1-1/4")
15	1159-9608T1	END CAP ASSEMBLY (UPPER)
16	25-54029	O-RING, (2.800 x .103), END CAP
17	31-93496T	BEARING, Roller, END CAP
18	26-41953	SEAL, END CAP
19	10-30225	SCREW AND LOCKWASHER, (.312-18 x 1.00), UPPER END CAP TO CYLINDER BLOCK (1")
20	10-24220	SCREW, (.190-24 x .190), SET - CYLINDER BLOCK (OLD DESIGN) Comment: (3/16")
21	22-38407	PLUG, (.500-14) Comment: CYLINDER BLOCK (WATER JACKET) (OLD DESIGN)
22	16-15094	STUD, (.190-32 x 1.870), FLYWHEEL COVER TO CYLINDER BLOCK Comment: (1-7/8")
23	16-8M0034435	STUD, (#10-32 x 1.00), FLYWHEEL COVER TO BRACKET Comment: (1")
24	23-67269	SPACER, FLYWHEEL COVER STUD
25	12-8M0204663	WASHER, FLYWHEEL COVER STUD
26	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, FLYHWEEL COVER STUD
27	11-816874	NUT, FLYWHEEL COVER STUD
28	422482	BRACKET, FLYWHEEL COVER
29	10-49668	SCREW, (.250-20 x .750), BRACKET TO CRANKCASE Comment: (3/4")
30	1156-7809T1	END CAP ASSEMBLY (LOWER)
31	25-62700	O-RING, (3.237 x .103), END CAP (3 3/4" I.D.)
32	26-41953	SEAL, END CAP
33	10-28636	SCREW, (.250-20 x .750), LOWER END CAP TO CYLINDER BLOCK Comment: (3/4")
34	13-26992	LOCKWASHER, (.250) Stainless Steel, LOWER END CAP SCREW
35	10-64022	SCREW, (.250-20 x 2.125), ADJUSTING - CYLINDER BLOCK
36	11-64015	NUT, (.250-20), JAM - ADJUSTING SCREW
37	26852	CAP, Nylon, NYLON - ADJUSTING SCREW
38	54-16793	CLAMP
39	10-73286	SCREW, (.250-20 x .500) Stainless Steel
40	87076A10	IDLE SPEED CONTROL ASSEMBLY
41	10-690201	SCREW, (#10-32 x .875), IDLE SPEED CONTROL
42	12-38833	WASHER, IDLE SPEED SONTROL SCREW
43	86-194372	TERMINAL BLOCK
44	10-48409	SCREW, (#10-16 x .625) Stainless Steel
45	12-89302	WASHER, (.203 x .406 x .040)
46	10-32,11-45076	NUT, Brass
47	10-32,11-813938	CAP NUT,
48	54-63153	J CLIP

▶DETONATION CONTROLLER/TEMPERATURE SENSOR (20 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	826800A8	CONTROLLER ASSEMBLY, Detonation
2	10-88447	SCREW, (.190-32 x 1.62), DETONATION CONTROLLER
3	12-38833	WASHER, DETONATION CONTROLLER SCREW
4	13381	PLATE
5	84-88807A10	CABLE ASSEMBLY
6	10-62568	SCREW, (#10-16 x .375), CABLE TO PLATE
7	23-94304	SPACER
8	41470A25	MODULE ASSEMBLY, Oil Injection Warning
9	14851T03	INDICATOR, THROTTLE POSITION
10	10-15150	SCREW, (#8-32 x .625), INDICATOR
11	8,13-26995	LOCKWASHER, Stainless Steel, INDICATOR SCREW
12	12-30164	WASHER, INDICATOR SCREW
13	23-15885	SLEEVE
14	13221T01	SENSOR ASSEMBLY, Temperature
15	25-45711	O-RING, (.612 x .103)
16	10-57583T	SCREW, (#8-32 x .375), TEMPERATURE SENSOR
17	8,13-26995	LOCKWASHER, Stainless Steel, TEMPERATURE SENSOR SCREW
18	10-42813	SCREW, (#10-32 X .380)
19	813501	PLATE

▶DRIVE SHAFT HOUSING AND EXHAUST TUBE (39 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	1590-8343A7	HOUSING ASSEMBLY, Driveshaft
2	16-56295	STUD, (.437 x 2.69), DRIVE SHAFT HSG./GEAR HSG.
3	25067	BUMPER, LOWER MOUNT SCREW
4	10-898831	SCREW, (.500-20 x 6.00), LOWER MOUNT
5	78249	MOUNT, LOWER
6	12-49339	WASHER, (.8125), LOWER MOUNT SCREW
7	11-25096	NUT, LOWER MOUNT SCREW
8	88238A10	CABLE ASSEMBLY, Ground
9	54-8M0036782	CLAMP, LOWER MOUNT
10	10-66727	SCREW, (.312-18 x 1.250), LOWER MOUNT CLAMP ATTACHING (1-1/4")
11	100-8M4500752	COVER, LOWER MOUNT CLAMP
12	10-88417	SCREW, (#12-24 x .620), COVER ATTACHING (5/8")
13	11-35521	NUT, NYLON-COVER TO CLAMP SCREW
14	88238A10	CABLE ASSEMBLY, Ground
15	10-41508	SCREW, (.250-20 x .500) Stainless Steel, GROUND WIRE
16	12-48926	WASHER, GEAR HOUSING STUD
17	11-29489	NUT, GEAR HOUSING STUD (CAP)
18	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, GEAR HOUSING STUD
19	11-8M0204653	NUT, (.437-20) Stainless Steel, GEAR HOUSING STUD
20	19-64649	PLUG, DRIVE SHAFT HOUSING
21	89743	TUBE, Exhaust
22	66350001	SEAL, EXHAUST TUBE-LOWER
23	86027	SEAL, EXHAUST TUBE-UPPER
24	32-8M0042788	TUBE, Water, WATER
25	27-991734	GASKET, DRIVE SHAFT HOUSING TO PLATE
26	41945A7	PLATE ASSEMBLY, DRIVE SHAFT HOUSING
27	8M0043165	SEAL, BRACKET
28	68011	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500), BRACKET TO PLATE (1/2")
30	17-43044	PIN, Dowel, LOCATING
31	26-38970	SEAL, WATER TUBE
32	10-90192	SCREW, (.250-20 x .750) Stainless Steel, EXTENSION TO PLATE
33	27-991772	GASKET Comment: DRIVE SHAFT HOUSING PLATE TO EXHAUST PLATE
34	12-20553	WASHER, POWER HEAD STUD
35	11-69254	NUT, POWER HEAD STUD
36	41941T	DIFFUSER, EXHAUST
37	27-782461	GASKET, EXHAUST EXTENSION
38	814630	PLUG, IDLE RELIEF

▶E.C.U. ASSEMBLY (17 parts)

Ref	OEM Part #	Part Name
1	14632A2	ECU, Engine Control Unit
2	23-34948	SPACER, COWL MOUNTING (UPPER)
3	54-146951	CLIP
4	90435	MOUNT, COWL MOUNTING BRACKET
5	12-21249	WASHER, MOUNT ATTACHING
6	11-8267089	NUT, (.250-28), MOUNT ATTACHING
7	84-88807A19	CABLE ASSEMBLY
8	14637	GROMMET
9	23-14636	BUSHING
10	10-28667	SCREW, (.250-20 x 1.00) Stainless Steel
11	13-26992	LOCKWASHER, (.250) Stainless Steel
12	12-65567	WASHER, (.265 x .750 x .048) Stainless Steel
13	13202A2	MODULE ASSEMBLY, Water Sensor
14	84-88807A18	CABLE ASSEMBLY (BLACK)
15	10-37571	SCREW, (.190-32 x .500), WATER SENSOR MODULE
16	12-89302	WASHER, (.203 x .406 x .040), WATER SENSOR MODULE SCREW
17	84-98866A14	HARNESS ASSEMBLY, E.C.U. AND INJECTORS

▶EXHAUST MANIFOLD AND EXHAUST PLATE (48 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	27-904841	GASKET, DIVIDER PLATE
2	99169A1	PLATE, DIVIDER
3	26-814754	SEAL, DIVIDER PLATE
4	193071	COVER, EXHAUST MANIFOLD
5	10-74824	SCREW, (.312-18 x 1.250), COVER AND PLATE TO CYLINDER BLOCK Comment: (1-1/4")
6	86-194373	TERMINAL BLOCK (3 TERMIALS)
7	90-13716	PARTS MANUAL, 7.5 /9.8 H.P., TERMIAL BL0CK
8	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, TERMIMAL BLOCK SCREW
9	10-32,11-45076	NUT, Brass, TERMINAL BLOCK
10	10-32,11-813938	CAP NUT, , TERMINAL BLOCK
11	10-74824	SCREW, (.312-18 x 1.250), COVER TO CYLINDER BLOCK Comment: (1-1/4")
12	27-78690002	GASKET, RELIEF VALVE PLATE
13	10-69570	SCREW, (#10-16 x .750), DIAPHRAGM TO PLATE Comment: (3/4")
14	12-76451	WASHER, DIAPHRAGM SCREW
15	144791	DIAPHRAGM
16	16496	DEFLECTOR, Water
17	16497A1	PLATE, RELIEF VALVE
18	24-64878	SPRING, (Black), COMPERSSION POPPER VALVE
19	12-85303	WASHER, POPPET SPRING
20	14480	POPPET, VALVE
21	25-64872	GROMMET, POPPET VALVE
22	65848	CARRIER, POPPET VALVE
23	27-991764	GASKET, EXHAUST PLATE
24	41944A5	PLATE ASSEMBLY, EXHAUST
25	22-996642	ELBOW, EXHAUST PLATE
26	17-43044	PIN, Dowel, LOCATING - EXHAUST PLATE
27	8M0043165	SEAL, EXHAUST PLATE
28	680101	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500), BRACKET TO EXHAUST PLATE Comment: (1/2")
30	12-20553	WASHER, POWERHEAD STUD
31	11-69254	NUT, POWWERHEAD STUD
32	23-27132	BUSHING, EXHAUST PLATE
33	25-8M0179867	GROMMET
34	25-12602002	GROMMET, EXHAUST PLATE
35	10-66727	SCREW, (.312-18 x 1.250), EXHAUST PLATE ATTACHING Comment: (1-1/4")
36	10-68783	SCREW, (.312-18 x 2.50), EXHAUST PLATE ATTACHING Comment: (2-1/2")
37	10-898833	SCREW, (.375-16 x 3.50), EXHAUST PLATE ATTACHING Comment: (3-1/2")
38	812905T	BRACKET ASSEMBLY, FRONT
39	10-90285	SCREW, (.312-18 x .625), FRONT BRAKET
40	12-187031	WASHER
41	25-18778001	GROMMET
42	18578T09	BRACKET ASSEMBLY, Rear, REAR
43	8M0039767	COVER, RELIEF VALVE (NEW DESIGN)
44	22-920071	FITTING, (.250-18) (90 DEGREES) (NEW DESIGN)
45	32-8M0108355	LINE, (57.00 Inches Bulk) (NEW DESIGN)
46	54-816311T	TIE STRAP (NEW DESIGN)
47	22-8144301	FITTING, (.500-14) (NEW DESIGN)

▶FLYWHEEL/STARTER MOTOR (23 parts)

Ref	OEM Part #	Part Name
1	18896A1	COVER KIT, FLYWHEEL
2	79022	MARKER, TIMING
3	10-37572	SCREW, (.190-32 x .380), TIMING MARKER
4	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, TIMING MARKER SCREW
5	19-89219001	PLUG, FLYWHEEL COVER
6	19-45907	PLUG, Yellow, FLYWHEEL
7	11-52901	NUT, (.625-18), FLYWHEEL
8	12-33001	WASHER, (.641 x 1.250 x .190), FLYWHEEL
9	271-859238T16	FLYWHEEL
10	10-32417	SCREW, (.250-28 x .625), FLYWHEEL PLATE
11	10-68997	SCREW, (.312-24 x .750), FLYWHEEL HUB
12	398-9610A5	STATOR
13	10-90045	SCREW, (#10-32 x 1.375), STATOR
14	10,13-26996	LOCKWASHER, Stainless Steel, STATOR SCREW
15	96455A9	PLATE ASSEMBLY, Trigger
16	84-93388A1	CABLE ASSEMBLY, (6.00 Inches) Black, PLATE TO STARTER MOTOR Comment: (BLACK)
17	50-893893	STARTER MOTOR ASSEMBLY
18	23-8M0034918	COLLAR, STARTER MOTOR
19	8M0043376	STOP, Rubber, RUBBER-STARTER MOTOR
20	13-26992	LOCKWASHER, (.250) Stainless Steel, STARTER MOTOR TERMINAL
21	11-20890	NUT, (.250-20), STARTER MOTOR TERMINAL
22	84-93388A14	CABLE ASSEMBLY, Black, SOLENOID TO STARTER MOTOR Comment: (BLACK)
23	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel, CABLE TO STARTER MOTOR

▶FUEL MANAGEMENT SYSTEM (47 parts)

Ref	OEM Part #	Part Name
.18	814010	COVER KIT
1	14817A2	MANAGEMENT ASSEMBLY, Fuel
2	67748	ROLLER, CAM
3	18715T	INJECTOR, Fuel
4	35-17422	FILTER, INJECTOR
5	84-15443	HARNESS KIT
6	35-15442	FILTER KIT, Fuel
7	35-150282	FILTER, Fuel
8	10-400034	SCREW, (M5 x 14), FILTER COVER
9	13-400255	LOCKWASHER, (M5), COVER SCREW
10	32-1350385	HOSE (1/2" O.D.)
11	32-9912688	TUBING, (36.00 Inches Bulk) (1/8" I.D.)
12	32-892024122	TUBING, (20.00 Feet Bulk) (3/32" I.D.)
13	15027	REGULATOR, PRESSURE
14	814233	ELBOW KIT
15	27-18791	GASKET, PRESSURE REGULATOR
16	814012	PLATE, PRESSURE REGULATOR
17	10-814076	SCREW
19	10-4001987	SCREW, (M4 x 16), COVER TO SEPARATOR
20	8,13-26995	LOCKWASHER, Stainless Steel, COVER SCREW
21	26-18790	SEAL, VAPOR SEPARATOR
22	15029	O-RING AND SEAL KIT
23	15446	VALVE KIT, Float
24	15445	FLOAT KIT
25	814011	BODY KIT
26	21-424811	CHECK VALVE
27	10-4000332	SCREW, (M6 x 35), SEPARATOR TO FUEL MANAGEMENT
28	15444	LINK
29	21-18241	CHECK VALVE
30	20-18348	VALVE, Shut Off
31	26-18792	SEAL, INJECTOR MANIFOLD
32	23-19275	SPACER
33	25-88033	GROMMET
34	23-814913	SPACER
35	12-35280	WASHER (LARGE)
36	12-69057	WASHER (SMALL)
37	54-8M0214911	CLAMP, (15.7), HOSE
38	32-1350385	HOSE (1-3/4")
39	54-816311T	TIE STRAP
40	14639	BLANKET, FUEL PUMP
41	14640T	COVER, FUEL PUMP
42	10-32228	SCREW, (#10-32 x .625)
43	10,13-26996	LOCKWASHER, Stainless Steel
44	10-845674	SCREW, (.250-20 x 4)
45	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
46	14307T01	PUMP, Fuel
47	32-146332	HOSE

▶FUEL PUMP AND FUEL FILTER (37 parts)

Ref	OEM Part #	Part Name
1	15930A15	PUMP ASSEMBLY, Fuel
2	21-857005A1	DIAPHRAGM KIT Comment: CONTENTS INDICATED BY FOOTNOTE 3
3	NSS	NOT SOLD SEPARATE, CHECK VALVE, RUBBER
4	NSS	NOT SOLD SEPARATE, GASKET, BOOST
5	NSS	NOT SOLD SEPARATE, DIAPHRAGM
6	NSS	NOT SOLD SEPARATE, GASKET, PULSE
7	NSS	NOT SOLD SEPARATE, SPRING
8	NSS	NOT SOLD SEPARATE, CAP
9	NSS	NOT SOLD SEPARATE, CHECK VAVLE
10	NSS	NOT SOLD SEPARATE, RETAINER
11	NSS	NOT SOLD SEPARATE, SPRING
12	NSS	NOT SOLD SEPARATE, CAP
13	27-8M0204705	GASKET, BASE
14	22-14868	FITTING, FUEL PUMP (ELBOW)
15	22-16604	FITTING, Straight (.125-27), FUEL PUMP (STRAIGHT)
16	32-8M0108349	TUBING
17	144303	BASE, FUEL PUMP
18	987752	PLATE, FUEL PUMP
19	22-56800	PLUG, Pipe (.0625-27)
20	22-15979	FITTING
21	10-16452	SCREW, (#12-24 x 2.00), FUEL PUMP
22	10-4000310	SCREW, (M5 x 40), FUEL PUMP TO CRANKCASE
23	12-4002314	WASHER, FUEL PUMP SCREW
24	32-9072925	HOSE, PULSE
25	22-997511	FITTING, (.0625-27) Brass, PULSE HOSE (90 DEGREE)
26	32-1350385	HOSE
27	54-816311T	TIE STRAP, FUEL TUBING
28	22-816856Q3	CONNECTOR, Fuel
29	10-69067	SCREW, (.250-20 x 1.375), FUEL CONNECTOR
30	812782	SEAL
31	813657	BRACKET
32	10-69067	SCREW, (.250-20 x 1.375)
33	10-28668	SCREW, (.250-20 x .875) Stainless Steel, FUEL FILTER BASE
34	13170A3	BASE, FUEL FILTER
35	22-136071	FITTING, BASE
36	35-18458Q3	FILTER ASSEMBLY, Fuel
37	14570	PROBE, WATER SENSING

▶GEAR HOUSING(PROPELLER SHAFT) (37 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	1647-9148T47	GEAR HOUSING ASSEMBLY (BASIC)
48	789562	SHIFT CAM
49	89594A1	FOLLOWER ASSEMBLY, CAM
50	79911A1	ROD, CLUTCH ACTUATOR
51	24-79910	SPRING, COMPRESSION
52	12-78910	WASHER, COMPRESSION SPRING
53	17-8M0084245	PIN, SPRING LOCATOR
54	15-47397A1	SHIM SET, BEARING OUTER RACE (.002-3-5-10)
55	31-78172A1	BEARING ASSEMBLY, Tapered Roller
56	43-44104T2	GEAR ASSEMBLY, Forward
57	31-73363T	BEARING, Roller (1.313 O.D.)
58	52-823174T	RATCHET, SLIDING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET TO PROPELLER SHAFT
60	17-78909	PIN, Detent, RATCHET
61	24-78962	SPRING, RETAINING-CROSS PIN
62	44-94148	PROPELLER SHAFT
64	681001	RING, THRUST Comment: BEARING CARRIER TO GEAR HOUSING
65	30-88957T	BEARING, Ball, BALL-REVERSE GEAR
66	25-8M0214920	O-RING, BEARING CARRIER
67	43567T1	CARRIER ASSEMBLY, Bearing
68	31-30956T	BEARING, Needle, BEARING CARRIER
69	26-8M0204670	SEAL, BEARING CARRIER
70	28-30281	KEY, LOCATING-BEARING CARRIER
71	14-79447	TAB WASHER, GEAR HOUSING COVER
72	8M2011027	RETAINER, GEAR HOUSING
73	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
74	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING (1-3/4")
75	8M0039169	FILLER BLOCK, FILLER BLOCK
76	11-8M0204653	NUT, (.437-20) Stainless Steel, DRIVE SHAFT HOUSING STUDS
77	10-65210	SCREW, (.375-16 x 1.00), GEAR HOUSING
78	12-835467Q01	THRUST HUB
79	12-31211Q03	WASHER, Splined, SPLINED-PROPELLER NUT
80	14-816629Q	TAB WASHER, PROPELLER NUT
81	11-52707Q1	PROP NUT KIT, (.750-16)
82	13-423511	LOCKWASHER, Toothed, PROPELLER SHAFT
83	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, DRIVE SHAFT HOUSING STUDS

▶Gear Housing, Driveshaft (46 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	1647-9148T47	GEAR HOUSING ASSEMBLY
2	22-85822A10	CONNECTOR ASSEMBLY, SPEEDOMETER
3	17-43044	PIN, Dowel, GEAR HOUSING LOCATING
4	16-786382	STUD, (.438 x 3.12), GEAR HOUSING (3-1/8")
5	16-8M0133358	STUD, (.44 x 2.06), GEAR HOUSING (2-1/16")
6	16-8M0034463	STUD, (.312 x 3.38), WATER PUMP (3-3/8")
7	16-306671	STUD, (.250-20/.250-28 x 3.125), WATER PUMP (3-1/8")
8	31-42647A1	BEARING ASSEMBLY, Roller, DRIVE SHAFT
9	23-43998	SLEEVE, LUBRICATION
11	45-897624T	DRIVESHAFT
13	12-92721	WASHER, PINION GEAR
14	11-35921	NUT, (.625-18), PINION GEAR TO DRIVE SHAFT
15	15-42637A1	SHIM SET Comment: ROLLER BEARING TO GEAR HOUSING
16	31-8M0146566	BEARING ASSEMBLY, Roller/Cup, DRIVE SHAFT
17	8245191	NUT, DRIVE SHAFT BEARING
18	46-8M0077147	BASE ASSEMBLY, Water Pump
19	27-8M0204678	GASKET, WATER PUMP TO GEAR HSG
20	25-8M0142854	O-RING, (2.175 x .175), WATER PUMP
21	26-89238	SEAL, Oil, WATER PUMP
22	26-16977	SEAL, Oil, WATER PUMP
23	27-8M0090319	GASKET, LOWER-WATER PUMP
24	27-858524	GASKET, UPPER-WATER PUMP
25	8M0204677	FACE PLATE, FACE-WATER PUMP
26	46-96148T1	BODY ASSEMBLY, Water Pump
27	48752T	INSERT, WATER PUMP BODY
28	26-38970	SEAL, RUBBER-WATER INLET TUBE
29	47-89984T4	IMPELLER, WATER PUMP
30	28-8M0214992	KEY, IMPELLER DRIVE
31	10-8M0215009	SCREW, (#14-8 x 2.25), WATER PUMP (2-1/4")
32	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, WATER PUMP SCREW AND STUD
33	11-8267119	NUT, (.250-28), WATER PUMP STUD
34	12-36001	WASHER, WATER PUMP STUD
35	11-13436	NUT, WATER PUMP STUD
36	25-8M0214918	RING, Rubber, RUBBER (DRIVE SHAFT)
37	23-29804T	SLEEVE, GUIDE-WATER INLET TUBE
38	789022	SHAFT, SHIFT (LOWER)
39	53-29641	E RING, RETAINING-SHIFT SHAFT
40	53-78907	RING, Retaining
41	25-25439	O-RING, (.862 x .103), SHIFT SHAFT BUSHING
42	23-77631A2	BUSHING ASSEMBLY, SHIFT SHAFT
43	26-8M0204708	SEAL, Oil, SHIFT SHAFT BUSHING
44	12-77674	WASHER, RUBBER-SHIFT SHAFT BUSHING
45	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
46	22-8M0058389	SCREW, Magnetic, DRAIN ( MAGNETIC)
47	12-191833	WASHER, Fiber, GREASE FILLER AND DRAIN SCREW

▶IGNITION COIL/VOLTAGE REGULATOR (30 parts)

Ref	OEM Part #	Part Name
1	195872	PLATE, MOUNTING
2	10-30720	SCREW, (.250-20 x 2.25), VOLTAGE REGULATOR
3	13-26992	LOCKWASHER, (.250) Stainless Steel
4	23-19661	BUSHING
5	18736A21	REGULATOR ASSEMBLY, Voltage
6	18717	SEAL
7	8M0185622	SOLENOID, Starter
8	10-90192	SCREW, (.250-20 x .750) Stainless Steel, STARTER SOLENOID
9	84-88807A6	CABLE ASSEMBLY, (3.50 Inches) Black (3-1/2" - BLACK)
10	11-8267098	NUT, (.250-20), SOLENOID SCREW
11	8-32,11-26419	NUT, Brass, SOLENOID TERMINAL (8-32)
12	11-94330	NUT, (.250-20) Brass, SOLENOID TERMINAL (1/4-20)
13	85-97861	INSULATOR, STARTER SOLENOID (OLD DESIGN)
14	84-88807A8	CABLE ASSEMBLY, (3.50 Inches) Black (3-1/2" - BLACK)
15	84-88807A29	CABLE ASSEMBLY (9" - BLACK)
16	54-816311T	TIE STRAP
17	43542	COVER, IGNITION COIL
18	339-832757A4	COIL ASSEMBLY, Ignition
19	10-90048	SCREW, (#10-32 x 2.125), IGNITION COIL COVER
20	10-32,11-90078	NUT, , COVER SCREW/GROUND WIRE
21	84-813715A9	CABLE KIT, Ignition, HIGH TENSION
22	85-63709A1	BOOT/TERMINAL KIT, HIGH TENSION CABLE
23	33-896329885	SPARK PLUG
24	10-32,11-45076	NUT, Brass, IGNITION COIL TERMINAL
25	84-88807A13	CABLE ASSEMBLY (5-1/2" - BLACK)
26	10-69022	SCREW, (#10-32 x .500) Stainless Steel, GROUNDING WIRE
27	84-69739A7	HARNESS ASSEMBLY, COIL TO SWITCH BOX Comment: (#2,4 AND 6)
28	54676	RETAINER, Two Wire
29	814423T	COVER, COIL PLATE Comment: SN# C239553 & Up
30	10-814343	SCREW, (#10-32 x 2.380) Comment: SN# C239553 & Up

▶INSTRUMENTATION (20 parts)

Ref	OEM Part #	Part Name
1	79-895283Q43	TACHOMETER
2	79101T	BRACKET, MOUNTING
3	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
4	88-79888	SOCKET, Light Bulb
5	8-32,11-26419	NUT, Brass (8-32)
6	84-86323A5	CABLE ASSEMBLY, (1.50 Feet) Purple, TRIM GAUGE (PURPLE - 1-1/2")
7	79-895292Q41	TRIM GAUGE
8	79480	BRACKET, MOUNTING - TRIM GAUGE
9	88-72729	LIGHT BULB, Wedge Base (14V - .19W), TRIM GAUGE
10	88-79888	SOCKET, Light Bulb, TRIM GAUGE
11	8-32,11-26419	NUT, Brass, TRIM GAUGE TERMINAL (8-32)
12	8,12-26427	WASHER, TRIM GAUGE TERMINAL
13	84-86396A8	HARNESS ASSEMBLY, Tachometer (5.00 Feet)
14	79-895287Q41	TEMPERATURE GAUGE
15	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
16	88-79888	SOCKET, Light Bulb
17	12-26427	WASHER
18	79480	BRACKET
19	8-32,11-26419	NUT, Brass
20	84-88824A4	CABLE ASSEMBLY, (45.00 Inches) Tan (TAN)

▶MISCELLANEOUS PARTS/ACCESSORIES (1 parts)

Ref	OEM Part #	Part Name
-	90-13492900	OWNERS GUIDE

▶OIL INJECTION COMPONENTS (38 parts)

Ref	OEM Part #	Part Name
1	12430A4	SENSOR ASSEMBLY
2	10-48409	SCREW, (#10-16 x .625) Stainless Steel, SENSOR ATTACHING (5/8")
3	815699T	PUMP ASSEMBLY, Oil
3A	8141032	BEARING (W/SEAL)
4	25-11379	O-RING, OIL PUMP
5	23-41429A2	BEARING ASSEMBLY, DRIVE GEAR
6	43-14563	GEAR, Driven
7	10-41507	SCREW, (#10-32 x 1.120), OIL PUMP TO CRANKCASE (1-1/8")
8	1938512	LINK ASSEMBLY, THROTTLE LEVER TO OIL PUMP
9	32-82381335	TUBING, OIL PUMP
10	994436	RESERVOIR, Oil
11	54-415823	CLAMP, OIL HOSE (LARGE)
12	32-82381455	TUBING, OIL RESERVOIR TO OIL PUMP
13	10-690201	SCREW, (#10-32 x .875), OIL RESERVOIR ATTACHING (7/8")
14	12-42118	WASHER, OIL RESERVOIR SCREW
15	25-42117	GROMMET, OIL RESERVOIR SCREW
16	23-42116	BUSHING, OIL RESERVOIR SCREW
17	32-8M0108355	LINE, (57.00 Inches Bulk), OIL
18	22-42425	TEE, OIL TUBING
19	32-9072925	HOSE, OIL (6-3/4")
21	32-99439	HOSE, (114.00 Inches), OIL
22	12540A3	HOUSING
23	12242A1	LATCH
24	21-8781051	FITTING, CHECK CALVE (CRANKCASE)
25	1257-87421	TANK
26	36-43298A2	CAP ASSEMBLY, OIL TANK
27	25-11332	O-RING, (2.225 x .210), CAP
28	816190A4	HOUSING ASSEMBLY, Adaptor
29	25-11332	O-RING, (2.225 x .210), ADAPTOR HOUSING
30	32-99802	TUBE, OIL PICK-UP
31	36-43300A9	CAP ASSEMBLY, OIL RESERVOIR
32	27-43307T	GASKET, RESERVOIR CAP
33	8M0187298	FLOAT ASSEMBLY
34	11-99265	PUSH NUT
35	54-415824	CLAMP, OIL HOSE (SMALL)
36	54-816311T	TIE STRAP
37	12335A1	BRACKET KIT
38	12323A1	CORD/HOOK KIT

▶POWER TRIM COMPONENTS (38 parts)

Ref	OEM Part #	Part Name
1	99659A21	MANIFOLD ASSEMBLY
2	22-56800	PIPE PLUG, MANIFOLD
3	41493A7	TRIM CYLINDER ASSEMBLY
4	41492A1	GUIDE ASSEMBLY
5	25-41478A1	REPAIR KIT
6	41482A2	CHECK VALVE KIT
7	1100-8M0021648	GUIDE ASSEMBLY, TRIM ROD
8	878413A1	PISTON/ROD ASSEMBLY, Power Trim (PORT)
9	35-12184A1	TRIM FILTER ASSEMBLY
10	878414T01	PISTON/ROD ASSEMBLY, Power Trim (STARBOARD)
11	17-821539	PIN, Groove, TRIM CYLINDER (UPPER)
12	893929A01	VALVE ASSEMBLY
12A	53-815949001	E RING
13	10-4000327	SCREW, (M6 x 14), COVER
14	12-4002315	WASHER, COVER SCREW
15	99642	COVER, MANIFOLD
16	25-48462A4	O-RING KIT
17	19-99609A1	PLUG ASSEMBLY
18	99641A1	SHAFT ASSEMBLY
19	22-56800	PIPE PLUG, SHAFT
20	10-4008820	SCREW, (M6 x 20), PUMP AND MOTOR
21	13-400256	LOCKWASHER, (M6)
22	826729A10	PUMP AND MOTOR
23	99625002	SHAFT, UPPER
24	97-818298Q1	ANODE ASSEMBLY
25	10-4000332	SCREW, (M6 x 35), ANODE
26	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, ANODE SCREW
27	8M0045383	STRIKER PLATE, TRIM SHAFT
28	13-58643	LOCKWASHER, (.375)
29	11-46335	NUT, (.375-24)
30	84-17201A5	HARNESS ASSEMBLY, Control, POWER TRIM (W/O FUSE)
31	84-88808A22	CABLE ASSEMBLY (6-3/8"-RED)
32	54-22875	CLIP, PUMP WIRE
33	8M0084613	C WASHER, CLIP SCREW
34	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
35	17-878267	PIN, Groove, TRIM CYLINDER (LOWER)
36	10-4000377	SCREW, (M10 x 30), MANFOLD
37	13-400258	LOCKWASHER, (M10) Stainless Steel, MANIFOLD SCREW

▶POWER TRIM PUMP (9 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	12659	FRAME AND FIELD KIT
2	12665	SPRING KIT, Brush
3	13506	BRUSH CARD KIT
4	12662	PUMP AND END FRAME KIT
5	126631	SEAL KIT, Pump
6	12660	END FRAME KIT
7	12661	ARMATURE KIT
8	12664	THRU BOLT KIT

▶REED BLOCK AND CYLINDER HEAD (28 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	15221A5	CYLINDER HEAD ASSEMBLY
2	27-41247T01	GASKET, CYLINDER HEAD
3	10-13450	SCREW, (.375-16 x 2.30), CYLINDER HEAD (SPECIAL)
4	12-25909	WASHER, (.406 x .812 x .065), CYLINDER HEAD SCREW
5	75692	THERMOSTAT
6	27-8M0204714	GASKET, THERMOSTAT
7	90390A1	COVER KIT, THERMOSTAT
8	10-35386	SCREW, (.312-18 x 1.00), THERMOSTAT COVER (1")
9	22-687271	FITTING, (.250-18) 90 Degree - Brass, ELBOW - WATER HOSES
10	32-77653101	HOSE, (24.500 Inches Bulk), WATER DISTRIBUTION
11	22-68728	FITTING, THERMOSTAT COVER TO WATER HOSES
12	54-816311T	TIE STRAP, WATER HOSES
13	13536A6	SENSOR ASSEMBLY, Temperature (PORT)
14	137151	RETAINER, SENSOR AND SENDER
15	10-98257	SCREW, (.312-18 x .500), RETAINER
16	825164A1	SENSOR, Detonation
17	10-32,11-45076	NUT, Brass, DETONATION SENSOR
18	14593A4	ADAPTOR PLATE ASSEMBLY
19	10-28668	SCREW, (.250-20 x .875) Stainless Steel, ADAPTOR PLATE
20	27-146971	GASKET, ADAPTOR PLATE
21	75953	REED BLOCK
22	34-75362A1	REED ASSEMBLY
23	961832	CLAMP, Reed
24	10-823588	SCREW, (#8-32 x .187), REEDS TO REED BLOCK
25	10-92160	SCREW, (.250-20 x .75), REED BLOCK ATTACHING (3/4")
26	10-90197	SCREW, (.250-20 x 1.125), REED BLOCK ATTACHING (2")
27	27-167371	GASKET, ADAPTOR PLATE

▶STARTER MOTOR ASSEMBLY (10 parts)

Ref	OEM Part #	Part Name
-	50-893893	STARTER MOTOR ASSEMBLY
1	90645	DRIVE KIT
2	13310T1	PINION ASSEMBLY, Drive
3	75660	PLATE, DRIVE END
4	10-74968	BOLT, THRU
7	79216	ARMATURE
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER, BRUSH
10	10-68586	SCREW, BRUSH AND HOLDER
11	15386001	END CAP, COMMUTATOR

▶SWIVEL BRACKET AND STEERING ARM (29 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	1499-8M0102865	SWIVEL BRACKET ASSEMBLY
2	26-87735	SEAL, Oil, SWIVEL BRACKET (LOWER)
3	23-818764	BUSHING, SWIVEL BRACKET (LOWER AND UPPER)
4	25-33466	O-RING, SWIVEL BRACKET (UPPER)
5	23-67668	SPACER, SWIVEL BRACKET (UPPER)
6	22-8M0169589	FITTING, Grease, GREASE
7	23-821207	BUSHING, SWIVEL BRACKET
8	17-67706A55	SWIVEL PIN ASSEMBLY
9	10-8M0176309	SCREW, (.437-20 x 7.50), STEERING ARM TO UPPER MOUNT
10	78687T	MOUNT, RUBBER (UPPER)
11	12-66921	WASHER, UPPER MOUNT BOLT
12	12-78688	WASHER, UPPER MOUNT BOLT
13	11-8M0204653	NUT, (.437-20) Stainless Steel, UPPER MOUNT BOLT
14	92876A12	LINK ASSEMBLY, Steering
15	10-849838	SCREW, (.375-24 x 1.25), STEERING LINK TO STEERING ARM
16	11-8M0204726	NUT, (.375-24), STEERING LINK SCREW
17	12-34931	WASHER, (.406 x .734 x .063) Stainless Steel, STEERING LINK TO STEERING ARM
18	13-78854	WAVE WASHER, BOTTOM YOKE
19	86580A1	YOKE ASSEMBLY, Bottom
20	53-67684	RING, Retaining, BOTTOM YOKE
21	12-67670	WASHER, THRUST-SWIVEL BRACKET
22	88882	BUMPER, Top Yoke, TOP YOKE
23	8M0074846	SENDER ASSEMBLY, Trim (OLD DESIGN)
24	10-852368	SCREW, (#10-24 x .750), TRIM SENDER (OLD DESIGN)
25	10,13-26996	LOCKWASHER, Stainless Steel, TRIM SENDER SCREW (OLD DESIGN)
26	12-89302	WASHER, (.203 x .406 x .040), TRIM SENDER SCREW (OLD DESIGN)
27	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET
28	54-54457	J CLIP

▶THROTTLE LEVER AND SHIFT SHAFT (49 parts)

Ref	OEM Part #	Part Name
1	74897T	PIVOT, TRIGGER PLATE
2	62459T	BALL JOINT ASSEMBLY, TRIGGER PLATE
3	10-32,11-45076	NUT, Brass, LINK ROD
4	76035	ROD, TRIGGER PLATE
5	10-32,11-46438	NUT, , BALL JOINT
6	41094A3	LEVER ASSEMBLY, SPARK ADVANCE
7	10-64022	SCREW, (.250-20 x 2.125), SPARK ADVANCE LEVER - STOP
8	11-64015	NUT, (.250-20), SPARK ADVANCE STOP SCREW
9	26852	CAP, Nylon, SPARK ADVANCE LEVER STOP SCREW
10	10-13627	SCREW, (.190-32 x 1.250), SPARK ADVANCE LEVER - STOP (1-1/4")
11	10-32,11-68219	NUT, Stainless Steel, SPARK ADVANCE LEVER STOP SCREW
12	48039	CAP, SPARK ADVANCE LEVER STOP SCREW
13	410952	LEVER, THROTTLE CONTROL
14	10-818165	SCREW, (.375-16 x 1.75), THROTTLE LEVER/ADVANCE LEVER (1-3/4")
15	23-55164	BUSHING, THROTTLE LEVER
16	23-55171	BUSHING, SPARK ADVANCE LEVER
17	24-68784	SPRING, THROTTLE AND SPARK ADVANCE LEVER
18	12-68410	WASHER, SPARK ADVANCE LEVER
19	10-64022	SCREW, (.250-20 x 2.125), THROTTLE LEVER - STOP (2-1/8")
20	11-64015	NUT, (.250-20), THROTTLE LEVER STOP SCREW
21	26852	CAP, Nylon, THROTTLE LEVER STOP SCREW
22	39483	LATCH, CABLE
23	10-69026	SCREW, (.250-28 x .880), CABLE LATCH TO THROTTLE LEVER
24	24-20099	SPRING, CABLE LATCH TO THROTTLE LEVER
25	11-826709109	NUT, (.250-28), CABLE LATCH SCREW
26	14634	ROD, THROTTLE CONTROL
27	14638	BARREL, THROTTLE CONTROL ROD
28	146351	CAM, Throttle
29	23-8M0215006	BUSHING
30	23-26856	BUSHING, THROTTLE CAM
31	11-826709109	NUT, (.250-28), THROTTLE CAM STUD
32	24-41050	SPRING, THROTTLE RETURN
33	814283A2	BRACKET, ANCHOR - CONTROL CABLES Comment: SN# C239553 & Up
34	98889	LATCH, CONTROL CABLE
35	10-42975	DRIVE SCREW, LATCH
36	10-53167T	SCREW, (.312-18 x .880), ANCHOR BRACKET ATTACHING
37	814284	GUIDE BLOCK, LINK ROD Comment: SN# C239553 & Up
38	24-20099	SPRING, LINK ROD TO GUIDE BLOCK
39	67073A1	LINK ROD ASSEMBLY
40	52100	WEAR PLATE, LINK ROD
41	8M0036768	LATCH, CONTROL CABLE FASTENING Comment: ANCHOR BRACKET
42	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel, LATCH
43	11-826709109	NUT, (.250-28), LINK ROD
44	79932A16	SHIFT SHAFT ASSEMBLY
45	13-29720	WAVE WASHER, LINK ROD
46	23-26600	BUSHING, NYLON - LINK ROD
47	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel, LINK ROD
48	11-826709109	NUT, (.250-28), LINK ROD TO SHIFT SHAFT
49	39519	CUP, BARRELL RETAINER - ANCHOR BAR

▶TOP COWL AND FRONT SHIELD (31 parts)

Ref	OEM Part #	Part Name
-	813096A1	REAR LATCH KIT Comment: ORDER WHEN REPLACING NON-ROLLER COMPONENTS. (A PRODUCT IMPROVEMENT.)
1	2196-9742T90	TOP COWL ASSEMBLY (ANNIVERSARY MODEL)
2	812784	SEAL
3	815478	SEAL
4	815225	SOUND BLANKET (SIDE)
5	815226	SOUND BLANKET (TOP)
5A	815227	SOUND BLANKET (FRONT)
6	17196A1	SHIELD, AIR INLET (ANNIVERSARY MODEL)
7	11-11316	SPEED NUT (ANNIVERSARY MODEL)
8	17238	SEAL, AIR INLET (ANNIVERSARY MODEL)
9	17195	SHIELD, AIR INLET (STARBOARD) (ANNIVERSARY MODEL)
10	184741	BRACKET, REAR
11	25-18506001	GROMMET
12	10-28636	SCREW, (.250-20 x .750), REAR BRACKET
13	13-26992	LOCKWASHER, (.250) Stainless Steel, REAR BRACKET SCREW
14	813096A2	HOOK
15	10-73286	SCREW, (.250-20 x .500) Stainless Steel
16	8M0207770	ROLLER
17	53-13194	RING, Retaining
18	813553	PLATE
19	187021	LOCATOR
20	893763	BRACKET ASSEMBLY, Latch Roller
21	813552	SPACER
22	10-31984	SCREW, (.312-18 x 1.375)
23	11-815848	NUT, (.312)
24	47341A11	ROPE AND HANDLE KIT, Manual/Emergency Start (FOR MANUAL STARTING)
25	18755A1	FRONT SHIELD ASSEMBLY
26	813562	SEAL
27	10-48409	SCREW, (#10-16 x .625) Stainless Steel
28	12-8M0204666	WASHER, (.203 x .500 x .032)
29	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel

▶TRANSOM BRACKETS (23 parts)

Ref	OEM Part #	Part Name
-	27-14697A87	GASKET SET
1	3401-8718F7	BRACKET ASSEMBLY, Transom (STARBOARD)
2	3400-8716A8	BRACKET ASSEMBLY, Transom (PORT)
3	22-8M0169588	FITTING, Grease, PORT TRANSOM BRACKET
5	99170A2	TILT TUBE
6	11-859133	NUT, TILT TUBE (1"-14)
7	25-45711	O-RING, (.612 x .103), TILT TUBE
8	13-88750	WASHER, TILT TUBE
9	11-858869	NUT, (.875-14), TILT TUBE (7/9-14)
10	10-8M0149747	SCREW, (.500-20 x 4.500), TRANSOM BRACKET TO TRANSOM
11	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel, TRANSOM BRACKET BOLT
12	11-91962	NUT, (.500-20), TRANSOM BRACKET BOLT
13	8M0115104	LEVER ASSEMBLY, TILT LOCK
14	13-99611	WAVE WASHER, TILT LEVER
15	23-65830	NYLINER, TILT LEVER
16	99633	KNOB, TILT LOCK LEVER
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY, TILT LOCK
21	11-23161	NUT, (.375-24), BOLT
22	814207	STOP, TILT LEVER
23	11-8M0041651	NUT, (.875-14)

▶WIRING HARNESS/STARTER SOLENOID (38 parts)

Ref	OEM Part #	Part Name
1	434292	IGNITION PLATE, IGNITION
2	332-7778A12	SWITCHBOX ASSEMBLY
3	10-13669	SCREW, (#12-24 x 2.00), SWITCH BOX TO IGNITION PLATE Comment: (2-1/2")
4	23-94453	BUSHING, SWITCH BOX SCREW
5	84-88528A2	CABLE ASSEMBLY (6" - RED/WHITE)
6	10-32,11-45076	NUT, Brass, SWITCH BOX TERMINAL
7	84-60871A10	WIRE ASSEMBLY, SWITCH BOX
8	10-62568	SCREW, (#10-16 x .375), WIRE ATTACHING
9	84-65999A3	CABLE ASSEMBLY, Black, BLACK
10	10-60411	SCREW, (1.25), IGNITION PLATE Comment: (1-1/4")
11	13-8M0204647	LOCKWASHER, (.312), IGNITION PLATE SCREW
12	12-36042	WASHER, IGNITION PLATE SCREW
13	12-67264	WASHER, (Rubber), IGNITION PLATE SCREW (RUBBER)
14	23-67268	BUSHING, IGNITION PLATE SCREW
15	87-33386A3	SWITCH ASSEMLBY
16	10-38055	SCREW, (.190-32 x .620), MERCURY SWITCH TO IGNITION PLATE Comment: (5/8")
17	10-32,11-45076	NUT, Brass, MERCURY SWITCH TERMINAL
18	10-87926	SCREW, (#10-32 x .500), LEAD ATTACHING Comment: (1/2")
19	84-88439A2	CABLE ASSEMBLY, Battery - Negative, NEGATIVE
20	84-96220A12	HARNESS ASSEMBLY, ENGINE
21	88-8M0207796	FUSE, 20 Ampere
22	84-95084A2	CABLE ASSEMBLY, FUSE
23	134731	HOLDER, Fuse
24	54-816311T	TIE STRAP, HARNESS AND CABLES
25	89-853654A1	SOLENOID, Starter
26	10-32,11-45076	NUT, Brass, SOLENOID TERMINALS (10-32)
27	13-53166	LOCKWASHER, (.312), SOLENOID TERMINALS (5/16")
28	11-8M0204668	NUT, (.312-18), SOLENOID TERMINALS (5/16-18)
29	10-31716	SCREW, (.250-20 x .620), SOLENOID TO IGNITION PLATE Comment: (5/8")
30	13-26992	LOCKWASHER, (.250) Stainless Steel Comment: SOLENOID TO IGNITION PLATE SCREW
31	84-65999A2	CABLE ASSEMBLY, Black, UPPER MOUNT (BLACK)
32	85-78866	INSULATOR, SOLENOID (OLD DESIGN)
33	54-47483	J CLIP
34	814422T	COVER, IGNITION PLATE Comment: SN# C239553 & Up
35	10-88447	SCREW, (.190-32 x 1.62) Comment: SN# C239553 & Up
36	10-690201	SCREW, (#10-32 x .875) Comment: SN# C239553 & Up
37	12-89302	WASHER, (.203 x .406 x .040) Comment: SN# C239553 & Up
38	13-26992	LOCKWASHER, (.250) Stainless Steel Comment: SN# C239553 & Up

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury V-200 (EFI) running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Popular Products

Popular Products

Popular Products

Mercury V-200 (EFI) (0C100861 THRU 0C999999) Parts & Diagrams

Categories

Refined By Clear all

Brand

Horsepower

Engine

Availability

Price

Need Help?

Images

Product

Price

Qty

Options