Mercury V-175 (0C100861 THRU 0C239552) Parts & Diagrams

🔎 Mercury V-175 Reference Library — Exploded parts diagrams (43 diagrams), specifications, common issues, and maintenance checklist.

The Mercury V-175 is a 2-Stroke, V6 60-degree outboard motor. Designed for large center-consoles, offshore sport-fishing boats, and multi-engine configurations.

Quick Reference Specifications

Specification	Value
Engine Type	2-Stroke, V6 60-degree
Horsepower	175 HP
Displacement	2507 cc (2.5L / 153 CID)
Bore x Stroke	89 mm x 67 mm (3.501 in. x 2.650 in.)
Spark Plug (Type & Gap)	NGK BPZ8HS-10
Engine Oil Capacity	—
Recommended Engine Oil	Mercury 2-Stroke Outboard Oil (TCW-3)
Gear Case Oil Capacity	980 mL (33.1 oz)
Idle Speed (in gear)	650–700 RPM (in gear)
Full Throttle RPM Range	5000-5600
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury V-175:

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury V-175.

▶Bottom Cowl (39 parts)

Ref	OEM Part #	Part Name
-	813096A1	REAR LATCH KIT
1	2197-9744A16	BOTTOM COWL ASSEMBLY, PORT (GRAY)
2	2197-9745A2	BOTTOM COWL ASSEMBLY, STARBOARD (GRAY)
3	18701A1	SEAL KIT, BOTTOM COWLS
4	10-18699	SCREW, (.250-20 x 1.320), COWL (STANDARD)
5	18872A2	COVER ASSEMBLY (GRAY)
6	11-8136921	LOCKNUT
7	54-816311T	TIE STRAP
8	18727	ROD
9	23-65830	NYLINER
10	23-19666	BUSHING
11	13-99611	WAVE WASHER
12	12-69057	WASHER, (.281 x .734 x .063)
13	10-18192	SCREW, (.250-20 x .620)
14	19648A2	HANDLE ASSEMBLY, PORT (GRAY)
15	19647A3	HANDLE ASSEMBLY, STARBOARD (GRAY)
16	19370	PAWL, PORT Comment: SEE NOTE
17	19369	PAWL, STARBOARD Comment: SEE NOTE
18	10-90047	SCREW
19	54-19749	CLAMP, UPPER
20	54-197481	CLAMP, LOWER
21	10-92799	SCREW, (#10-16 x 1.12)
22	84-16636A1	HARNESS ASSEMBLY, TRIM
23	10-72202	SCREW, (#10-32 x 1.25)
24	12-8M0204666	WASHER, (.203 x .500 x .032)
25	10-32,11-8M0204718	NUT,
26	84-16639A1	HARNESS ASSEMBLY
27	88-8M0207796	FUSE, 20 Ampere
28	84-95084A2	CABLE ASSEMBLY, FUSE
29	22-813613	FITTING, TELLTALE
30	22-90824001	TEE, TELLTALE
31	32-8M0108355	LINE, (57.00 Inches Bulk), TELLTALE
32	8130762	FRONT HANDLE ASSEMBLY
33	813925	HANDLE LOCK
34	813926	HANDLE
35	24-8139291	SPRING
36	10-69079	SCREW, (#10-16 x .440)
37	17-815296	PIN, Lock
38	13-26992	LOCKWASHER, (.250) Stainless Steel

▶CARBURETOR ASSEMBLY (28 parts)

Ref	OEM Part #	Part Name
-	1395-8506	REPAIR KIT, Carburetor
1	1374-9242A12	CARBURETOR (BOTTOM)
3	NSS	NOT SOLD SEPARATE, GASKET, COVER PLATE
4	1395-6032	PLATE, COVER
5	NSS	NOT SOLD SEPARATE, SCREW, COVER PLATE
6	1395-7822	BOWL, Fuel (CENTER/BOTTOM)
7	NSS	NOT SOLD SEPARATE, SCREW, FUEL BOWL
8	1395-6025	PLUG, MAIN JET
9	NSS	NOT SOLD SEPARATE, GASKET, MAIN JET
10	1399-4215	JET, Main Fuel (.066)
11	NSS	NOT SOLD SEPARATE, SCREW, FLOAT PIN
12	NSS	NOT SOLD SEPARATE, GASKET, INLET NEEDLE AND SEAT
13	1395-7824	NEEDLE/SEAT ASSEMBLY, Inlet
14	NSS	NOT SOLD SEPARATE, GASKET, NOZZLE BOSS
15	1395-9267	FLOAT
16	NSS	NOT SOLD SEPARATE, PIN, FLOAT LEVER
17	NSS	NOT SOLD SEPARATE, GASKET, FUEL BOWL
18	1395-4541	SCREW, IDLE AIR BLEED JET
19	NSS	NOT SOLD SEPARATE, GASKET, BLEED JET PLUG
20	1395-6030	JET, (.070), IDLE AIR BLEED
21	1395-6027	SCREW, THROTTLE LEVER
22	37-37752	DECAL, THROTTLE
23	NSS	NOT SOLD SEPARATE, SPRING, THROTTLE RETURN
24	1395-6031	SPACER, THROTTLE LEVER
25	1395-6022	SHAFT, THROTTLE
26	NSS	NOT SOLD SEPARATE, RING, RETAINER - THROTTLE SHAFT
27	1395-9416	VALVE, Throttle
28	NSS	NOT SOLD SEPARATE, SCREW, THROTTLE VALVE

▶CRANKSHAFT, PISTONS AND CONNECTING RODS (18 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	455-8745T5	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball, CRANKSHAFT (LOWER)
3	53-67446	RING, BALL BEARING
4	43-99727A1	GEAR, Drive
5	54196A6	CARRIER ASSEMBLY, SEAL
6	65800	PACKING, CARRIER
7	39-78633	RING, SEALING - CRANKSHAFT (.139 THICK)
8	31-93495T	BEARING, Roller, CRANKSHAFT
9	53-67444	RING, Retaining, ROLLER BEARING
10	766-8667T41	PISTON ASSEMBLY (PORT)
11	39-813011A12	RING ASSEMBLY, Piston
12	53-857196	RING, Lock, PISTON
13	636-8119A6	CONNECTING ROD ASSEMBLY
14	10-93886	SCREW, (.312-28 x .875), CONNECTING ROD
15	12-8M0032839	WASHER, NEEDLE LOCATING
16	8M0234886	BEARING KIT, CRANKSHAFT END
17	29-67483	BEARING, Needle, PISTON END

▶CYLINDER BLOCK AND END CAPS (46 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	858-8712A39	CYLINDER BLOCK
2	16-76175	STUD, POWERHEAD Comment: (1-7/8")
3	16-8M0034454	STUD, POWERHEAD Comment: (6-3/4")
4	17-43044	PIN, Dowel, LOCATING
5	17-8M0036405	PIN, CYLINDER BLOCK (BEARING RACE)
6	27-11338	GASKET, SEALING
7	8M0088723	COVER, STARTER MOTOR (UPPER)
8	10-73657	SCREW, (.312-18 x 1.50), COVER TO CRANKCASE
9	13-8M0204647	LOCKWASHER, (.312), STARTER MOTOR COVER SCREW
10	76867	COVER, STARTER MOTOR (LOWER)
11	10-815549	SCREW, (.312-18 x 2), COVER TO CRANKCASE
11A	23-99448	BUSHING
12	10-74824	SCREW, (.312-18 x 1.250), CRANKCASE TO CYLINDER BLOCK
13	1159-9608T1	END CAP ASSEMBLY, UPPER
14	25-54029	O-RING, (2.800 x .103), END CAP
15	31-93496T	BEARING, Roller, END CAP
16	26-41953	SEAL, END CAP
17	10-30225	SCREW AND LOCKWASHER, (.312-18 x 1.00), UPPER END CAP TO CYLINDER BLOCK
18	10-24220	SCREW, (.190-24 x .190), SET - CYLINDER BLOCK
19	22-38407	PLUG, (.500-14), CYLINDER BLOCK (WATER JACKET) Comment: (OLD DESIGN)
20	16-15094	STUD, (.190-32 x 1.870), FLYWHEEL COVER TO CYLINDER BLOCK
21	16-8M0034435	STUD, (#10-32 x 1.00), FLYWHEEL COVER TO BRACKET
22	23-67269	SPACER, FLYWHEEL COVER STUD
23	12-8M0204663	WASHER, FLYWHEEL COVER STUD
24	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, FLYWHEEL COVER STUD
25	11-816874	NUT, FLYWHEEL COVER STUD
26	422482	BRACKET, FLYWHEEL COVER
27	10-49668	SCREW, (.250-20 x .750), BRACKET TO CRANKCASE
28	1156-7809T1	END CAP ASSEMBLY, LOWER
29	25-62700	O-RING, (3.237 x .103), END CAP
30	26-41953	SEAL, END CAP
31	10-28636	SCREW, (.250-20 x .750), LOWER END CAP TO CYLINDER BLOCK
32	13-26992	LOCKWASHER, (.250) Stainless Steel, LOWER END CAP SCREW
33	10-64022	SCREW, (.250-20 x 2.125), ADJUSTING - CYLINDER BLOCK
34	11-64015	NUT, (.250-20), JAM - ADJUSTING SCREW
35	26852	CAP, Nylon, ADJSUTING SCREW
36	86-194372	TERMINAL BLOCK
37	10-48409	SCREW, (#10-16 x .625) Stainless Steel
38	12-89302	WASHER, (.203 x .406 x .040)
39	10-32,11-45076	NUT, Brass
40	10-32,11-813938	CAP NUT,
41	87076A4	IDLE SPEED CONTROL ASSEMBLY
42	10-690201	SCREW, (#10-32 x .875)
43	12-38833	WASHER
44	54-63153	J CLIP

▶Carburetor Assembly (29 parts)

Ref	OEM Part #	Part Name
-	814787	REPAIR KIT, Carburetor Comment: (WH-41A)
1	3307-9671A9	CARBURETOR Comment: (Bottom)(WH-41A)
2	1399-3796	JET, (.076), Bowl Vent
3	NSS	NOT SOLD SEPARATE, Gasket-Cover Plate
4	1395-6032	PLATE, Cover
5	NSS	NOT SOLD SEPARATE, Screw-Cover Plate
6	1395-7822	BOWL, Fuel Comment: (Center/Bottom)
7	NSS	NOT SOLD SEPARATE, Screw-Fuel Bowl
8	1395-6025	PLUG, Main Jet
9	NSS	NOT SOLD SEPARATE
10	1399-3794	JET, (.074), Main Fuel (For High Altitude jets, consult your service manual for correct sizes and part numbers)
11	NSS	NOT SOLD SEPARATE, Screw-Float Pin
12	NSS	NOT SOLD SEPARATE, Gasket-Inlet Needle and Seat
13	814786	NEEDLE/SEAT ASSEMBLY, Inlet Comment: (WH-41A)
14	NSS	NOT SOLD SEPARATE, Gasket-Nozzle Boss
15	1395-9267	FLOAT
16	NSS	NOT SOLD SEPARATE, Pin-Float Lever
17	NSS	NOT SOLD SEPARATE, Gasket-Fuel Bowl
18	1395-4541	SCREW, Idle Air Bleed Jet
19	NSS	NOT SOLD SEPARATE, Gasket-Bleed Jet Plug
20	1395-6246	JET, (.048), Idle Air Bleed Comment: (WH-41A)
21	1395-6027	SCREW, Throttle Lever
22	814679	LEVER, Throttle
23	NSS	NOT SOLD SEPARATE, Spring-Throttle Return
24	1395-6031	SPACER, Throttle Lever
25	1395-6022	SHAFT, Throttle
26	NSS	NOT SOLD SEPARATE, Ring-Retainer-Throttle Shaft
27	1395-6023	VALVE, Throttle
28	NSS	NOT SOLD SEPARATE, Screw-Throttle Valve

▶Choke Plate and Throttle Levers (22 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	67246T	COVER, INDUCTION SILENCER
2	10-30720	SCREW, (.250-20 x 2.25), COVER TO CHOKE PLATE
3	13-26992	LOCKWASHER, (.250) Stainless Steel, COVER SCREW
4	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, COVER SCREW
5	19-90585	PLUG, INDUCTION SILENCER COVER
6	27-672751	GASKET, COVER
7	799831	PLATE, CHOKE
8	27-672741	GASKET, CHOKE PLATE TO CARBURETOR
9	10-68000	SCREW, (.250-28 x 1.00), CHOKE PLATE TO CARBURETOR
10	12-20583	WASHER, CHOKE PLATE SCREW
11	67760	LINK, Throttle
12	67759	LEVER, Throttle, UPPER
13	10-15124	SCREW, (#10-32 x .750), THROTTLE LEVERS TO THROTTLE LINK
14	10,13-26996	LOCKWASHER, Stainless Steel, THROTTLE LEVERS SCREW
15	12-8M0204666	WASHER, (.203 x .500 x .032), THROTTLE LEVERS SCREW
16	41049	LEVER, Throttle, CENTER
17	67749	LEVER, Throttle, LOWER
18	67748	ROLLER, LOWER THROTTLE LEVER
19	17-67297	PIN, Clevis, THROTTLE LEVES TO THROTTLE LINK
20	12-89302	WASHER, (.203 x .406 x .040), CLEVIS PIN
21	18-26953	COTTER PIN, CLEVIS PIN

▶Crankshaft, Pistons and Connecting Rods (18 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	455-8745T5	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball, CRANKSHAFT (LOWER)
3	53-67446	RING, BALL BEARING
4	43-99727A1	GEAR, Drive
5	54196A6	CARRIER ASSEMBLY, SEAL
6	65800	PACKING, CARRIER
7	39-78633	RING, SEALING-CRANKSHAFT (.139 THICK)
8	31-93495T	BEARING, Roller, CRANKSHAFT
9	53-67444	RING, Retaining, ROLLER BEARING
10	766-8667A43	PISTON ASSEMBLY, Port (Port) Comment: (.015 Oversize)
11	39-815267A4	RING SET, Piston Comment: (.015 Oversize)
12	53-857196	RING, Lock, PISTON
13	636-8119A6	CONNECTING ROD ASSEMBLY
14	10-93886	SCREW, (.312-28 x .875), CONNECTING ROD
15	12-8M0032839	WASHER, NEEDLE LOCATING
16	8M0234886	BEARING KIT, CRANKSHAFT END
17	29-67483	BEARING, Needle, PISTON END

▶Cylinder Block and End Caps (46 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	858-8712A43	CYLINDER BLOCK
2	16-76175	STUD Comment: (1-7/8")
3	16-8M0034454	STUD, POWERHEAD Comment: (6-3/4")
4	17-43044	PIN, Dowel, LOCATING
5	17-8M0036405	PIN, CYLINDER BLOCK (BEARING RACE)
6	27-11338	GASKET, SEALING
7	8M0088723	COVER, STARTER MOTOR (UPPER)
8	10-73657	SCREW, (.312-18 x 1.50), COVER TO CRANKCASE
9	13-8M0204647	LOCKWASHER, (.312), STARTER MOTOR COVER SCREW
10	76867	COVER, STARTER MOTOR (LOWER)
11	10-815549	SCREW, (.312-18 x 2), COVER TO CRANKCASE
11A	23-99448	BUSHING
12	10-74824	SCREW, (.312-18 x 1.250), CRANKCASE TO CYLINDER BLOCK
13	1159-9608T1	END CAP ASSEMBLY, UPPER
14	25-54029	O-RING, (2.800 x .103), END CAP
15	31-93496T	BEARING, Roller, END CAP
16	26-41953	SEAL, END CAP
17	10-30225	SCREW AND LOCKWASHER, (.312-18 x 1.00), UPPER END CAP TO CYLINDER BLOCK
18	10-24220	SCREW, (.190-24 x .190), SET-CYLINDER BLOCK
19	22-38407	PLUG, (.500-14), CYLINDER BLOCK (WATER JACKET) Comment: (Use where Applicable)
20	16-15094	STUD, (.190-32 x 1.870), FLYWHEEL COVER TO CYLINDER BLOCK
21	16-8M0034435	STUD, (#10-32 x 1.00), FLYWHEEL COVER TO BRACKET
22	23-67269	SPACER, FLYWHEEL COVER STUD
23	12-8M0204663	WASHER, FLYWHEEL COVER STUD
24	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, FLYWHEEL COVER STUD
25	11-816874	NUT, FLYWHEEL COVER STUD
26	422482	BRACKET, FLYWHEEL COVER
27	10-49668	SCREW, (.250-20 x .750), BRACKET TO CRANKCASE
28	1156-7809T1	END CAP ASSEMBLY, LOWER
29	25-62700	O-RING, (3.237 x .103), END CAP
30	26-41953	SEAL, END CAP
31	10-28636	SCREW, (.250-20 x .750), LOWER END CAP TO CYLINDER BLOCK
32	13-26992	LOCKWASHER, (.250) Stainless Steel, LOWER END CAP SCREW
33	10-64022	SCREW, (.250-20 x 2.125), ADJUSTING-CYLINDER BLOCK
34	11-64015	NUT, (.250-20), JAM-ADJUSTING SCREW
35	26852	CAP, Nylon, NYLON-ADJUSTING SCREW
36	54-63153	J CLIP
37	86-194372	TERMINAL BLOCK
38	10-48409	SCREW, (#10-16 x .625) Stainless Steel
39	12-89302	WASHER, (.203 x .406 x .040)
40	10-32,11-45076	NUT, Brass
41	10-32,11-813938	CAP NUT,
42	93772A11	MODULE
43	10-690201	SCREW, (#10-32 x .875), ADVANCE
44	66517	RESTRICTOR, BLEED-CYLINDER BLOCK

▶DRIVESHAFT HOUSING AND EXHAUST TUBE (38 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	3503-9748A2	HOUSING ASSEMBLY, Driveshaft Comment: (X-LONG) (GRAY)
2	16-56295	STUD, (.437 x 2.69), DRIVESHAFT HSG./GEAR HSG.
3	25067	BUMPER, LOWER MOUNT SCREW
4	10-898831	SCREW, (.500-20 x 6.00), LOWER MOUNT
5	77327	MOUNT, LOWER Comment: (X-LONG)
6	12-49339	WASHER, (.8125), LOWER MOUNT SCREW
7	11-25096	NUT, LOWER MOUNT SCREW
8	88238A10	CABLE ASSEMBLY, Ground
9	54-8M0036782	CLAMP, LOWER MOUNT
10	10-66727	SCREW, (.312-18 x 1.250), LOWER MOUNT CLAMP
11	67077F1	COVER, LOWER MOUNT CLAMP Comment: (GRAY)
12	10-88417	SCREW, (#12-24 x .620), COVER ATTACHING
13	11-35521	NUT, NYLON - COVER TO CLAMP SCREW
14	88238A10	CABLE ASSEMBLY, Ground
15	10-41508	SCREW, (.250-20 x .500) Stainless Steel, GROUND WIRE
16	12-73862	WASHER, GEAR HOUSING STUD
17	11-29489	NUT, GEAR HOUSING STUD (CAP)
18	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, GEAR HOUSING STUD
19	11-8M0204653	NUT, (.437-20) Stainless Steel, GEAR HOUSING STUD
20	19-64649	PLUG, DRIVESHAFT HOUSING
21	89743	TUBE, Exhaust
22	66350001	SEAL, EXHAUST TUBE - LOWER
23	86027	SEAL, EXHAUST TUBE - UPPER
24	32-8M0042790	TUBE, WATER Comment: (X-LONG)
25	27-991734	GASKET, DRIVESHAFT HOUSING TO PLATE
26	41945A7	PLATE ASSEMBLY, DRIVESHAFT HOUSING
27	8M0043165	SEAL
28	68011	BRACKET, SEAL RETAINING
29	10-48408	SCREW, (#10-16 x .500), BRACKET TO PLATE
30	17-43044	PIN, Dowel, LOCATING
31	26-38970	SEAL, WATER TUBE
32	10-90192	SCREW, (.250-20 x .750) Stainless Steel, EXTENSION TO PLATE
33	27-991772	GASKET
34	12-20553	WASHER, POWER HEAD STUD
35	11-69254	NUT, POWER HEAD STUD
36	879288T71	EXTENSION, EXHAUST
37	27-782461	GASKET, EXHAUST EXTENSION

▶Driveshaft Housing and Exhaust Tube (38 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	1590-8343A8	HOUSING ASSEMBLY, Driveshaft (GRAY)
2	16-56295	STUD, (.437 x 2.69), DRIVE SHAFT HSG./GEAR HSG.
3	25067	BUMPER, LOWER MOUNT SCREW
4	10-898831	SCREW, (.500-20 x 6.00), LOWER MOUNT
5	77327	MOUNT, LOWER
6	12-49339	WASHER, (.8125), LOWER MOUNT SCREW
7	11-25096	NUT, LOWER MOUNT SCREW
8	88238A10	CABLE ASSEMBLY, Ground
9	54-8M0036782	CLAMP, LOWER MOUNT
10	10-66727	SCREW, (.312-18 x 1.250), LOWER MOUNT CLAMP ATTACHING
11	67077F1	COVER, LOWER MOUNT CLAMP (GRAY)
12	10-88417	SCREW, (#12-24 x .620), COVER ATTACHING
13	11-35521	NUT, NYLON-COVER TO CLAMP SCREW
14	88238A10	CABLE ASSEMBLY, Ground
15	10-41508	SCREW, (.250-20 x .500) Stainless Steel, GROUND WIRE
16	12-73862	WASHER, GEAR HOUSING STUD
17	11-29489	NUT, GEAR HOUSING STUD (CAP)
18	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, GEAR HOUSING STUD
19	11-8M0204653	NUT, (.437-20) Stainless Steel, GEAR HOUSING STUD
20	19-64649	PLUG, DRIVE SHAFT HOUSING
21	89743	TUBE, Exhaust
22	66350001	SEAL, EXHAUST TUBE-LOWER
23	86027	SEAL, EXHAUST TUBE-UPPER
24	32-8M0042788	TUBE, Water, WATER
25	27-991734	GASKET, DRIVE SHAFT HOUSING TO PLATE
26	41945A7	PLATE ASSEMBLY, DRIVE SHAFT HOUSING
27	8M0043165	SEAL, BRACKET
28	68011	BRACKET, SEAL RETAINING
29	10-48408	SCREW, (#10-16 x .500), BRACKET TO PLATE
30	17-43044	PIN, Dowel, LOCATING
31	26-38970	SEAL, WATER TUBE
32	10-90192	SCREW, (.250-20 x .750) Stainless Steel, DIFFUSER TO PLATE
33	27-991772	GASKET, DRIVE SHAFT HOUSING PLATE TO EXHAUST PLATE
34	12-20553	WASHER, POWER HEAD STUD
35	11-69254	NUT, POWER HEAD STUD
36	17303T1	DIFFUSER, EXHAUST
37	27-782461	GASKET, EXHAUST DIFFUSER

▶Dual Engine Extension Kit (18 parts)

Ref	OEM Part #	Part Name
-	92876A9	DUAL ENGINE EXTENSION KIT
1	19624A1	SEAL KIT
2	71565	TUBE, Cable Guide, CABLE GUIDE
3	41055	MOUNT
4	14-42100	TAB WASHER
5	11-8M0041651	NUT, (.875-14)
6	88404	TAB WASHER
7	10-38601	SCREW, (.250-28 x 1.250)
8	17729A1	BRACKET
9	10-62055	SCREW, (.312-24 x 1.250)
10	17728	TAB WASHER
11	10-849838	SCREW, (.375-24 x 1.25)
12	11-8M0204726	NUT, (.375-24)
13	97933A1	STEERING EYE
14	23-23651	SLEEVE, (1.625)
15	97931	TUBING, (4.00 Inches)
16	8M0026098	TUBE
17	11-42099	NUT, (.562-18)

▶Exhaust Manifold and Exhaust Plate (48 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	27-904841	GASKET, DIVIDER PLATE
2	99169A1	DIVIDER PLATE, DIVIDER
3	26-814754	SEAL, DIVIDER PLATE
4	193071	COVER, EXHAUST MANIFOLD
5	10-74824	SCREW, (.312-18 x 1.250), COVER AND PLATE TO CYLINDER BLOCK
6	86-194373	TERMINAL BLOCK (3 TERMINALS)
7	10-31716	SCREW, (.250-20 x .620), TERMINAL BLOCK
8	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, TERMINAL BLOCK SCREW
9	10-32,11-45076	NUT, Brass, TERMINAL BLOCK
10	10-32,11-813938	CAP NUT,
11	10-74824	SCREW, (.312-18 x 1.250), COVER TO CYLINDER BLOCK
12	27-78690002	GASKET, RELIEF VALVE PLATE
13	10-69570	SCREW, (#10-16 x .750), DIAPHRAGM TO PLATE
14	12-76451	WASHER, DIAPHRAGM SCREW
15	144791	DIAPHRAGM
16	16496	DEFLECTOR, Water
17	16497A1	PLATE, RELIEF VALVE
18	24-64878	SPRING, (Black), COMPRESION POPPET VALVE
19	12-85303	WASHER, POPPET SPRING
20	14480	POPPET, VALVE
21	25-64872	GROMMET, POPPET VALVE
22	65848	CARRIER, POPPET VALVE
23	27-991764	GASKET, EXHAUST PLATE
24	41944A5	PLATE ASSEMBLY, EXHAUST
25	22-996642	ELBOW, EXHAUST PLATE
26	17-43044	PIN, Dowel, LOCATING-EXHAUST PLATE
27	8M0043165	SEAL, EXHAUST PLATE
28	680101	BRACKET, SEAL RETAINING
29	10-48408	SCREW, (#10-16 x .500), BRACKET TO EXHAUST PLATE
30	12-20553	WASHER, POWERHEAD STUD
31	11-69254	NUT, POWERHEAD STUD
32	23-27132	BUSHING, EXHAUST PLATE
33	25-8M0179867	GROMMET
34	25-12602002	GROMMET, EXHAUST PLATE
35	10-66727	SCREW, (.312-18 x 1.250), EXHAUST PLATE ATTACHING
36	10-68783	SCREW, (.312-18 x 2.50), EXHAUST PLATE ATTACHING
37	10-898833	SCREW, (.375-16 x 3.50), EXHAUST PLATE ATTACHING
38	812905T	BRACKET ASSEMBLY, FRONT
39	10-90285	SCREW, (.312-18 x .625), FRONT BRACKET
40	12-187031	WASHER
41	25-18778001	GROMMET
42	18578T09	BRACKET ASSEMBLY, Rear, REAR
43	8M0039767	COVER, RELIEF VALVE (NEW DESIGN)
44	22-920071	FITTING, (.250-18) (90 DEG.) (NEW DESIGN)
45	32-8M0108355	LINE, (57.00 Inches Bulk) (NEW DESIGN)
46	54-816311T	TIE STRAP (NEW DESIGN)
47	22-8144301	FITTING, (.500-14) (NEW DESIGN)

▶FUEL PUMP AND CARBURETOR (47 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	1374-9242A10	CARBURETOR (TOP)
2	1374-9242A11	CARBURETOR (CENTER)
3	1374-9242A12	CARBURETOR (BOTTOM)
4	1395-6232	FITTING, FUEL INLET (UPPER/LOWER)
5	22-70007	FITTING, 45 Degree, FUEL INLET (MIDDLE)
6	27-904301	GASKET, CARBURETOR
7	11-8M0207775	NUT, (1/4-28X7/32), CARBURETOR MOUNTING
8	54-816311T	TIE STRAP, FUEL HOSE TO CARBURETOR
9	42859A2	VALVE ASSEMBLY, Enrichner
10	54-633001	CLAMP, ENRICHNER VALVE
11	10-73286	SCREW, (.250-20 x .500) Stainless Steel, VALVE CLAMP
12	86-45915	TERMINAL BLOCK, REED BLOCK HOUSING
13	10-35519	SCREW, (#10-16 x .500), TERMINAL BLOCK ATTACHING
14	32-892024122	TUBING, (20.00 Feet Bulk), TOP CARBURETOR TO VALVE (7-3/4")
15	32-9912688	TUBING, (36.00 Inches Bulk), CARBURETOR TO CARBURETOR (4-1/4")
16	15930A15	PUMP ASSEMBLY, Fuel
17	21-857005A1	DIAPHRAGM KIT
18	NSS	NOT SOLD SEPARATE, CHECK VALVE, RUBBER
19	NSS	NOT SOLD SEPARATE, GASKET, BOOST
20	NSS	NOT SOLD SEPARATE, DIAPHRAGM
21	NSS	NOT SOLD SEPARATE, GASKET, PULSE
22	NSS	NOT SOLD SEPARATE, SPRING
23	NSS	NOT SOLD SEPARATE, CAP
24	NSS	NOT SOLD SEPARATE, CHECK VALVE
25	NSS	NOT SOLD SEPARATE, RETAINER
26	NSS	NOT SOLD SEPARATE, SPRING
27	NSS	NOT SOLD SEPARATE, CAP
28	27-8M0204705	GASKET, BASE
29	144303	BASE, FUEL PUMP
30	987752	PLATE, FUEL PUMP
31	22-56800	PLUG, Pipe (.0625-27)
32	22-19688	FITTING
33	10-16452	SCREW, (#12-24 x 2.00), FUEL PUMP
34	10-4000310	SCREW, (M5 x 40), FUEL PUMP TO CRANKCASE
35	12-4002314	WASHER, FUEL PUMP SCREW
36	22-14868	FITTING, FUEL PUMP (ELBOW)
37	22-19688	FITTING, FUEL PUMP (ELBOW)
38	32-8M0108355	LINE, (57.00 Inches Bulk)
39	35-816296Q03	FILTER, Fuel
40	54-15279	CLAMP, FUEL FILTER
41	22-64705	FITTING, PULSE HOSE
42	32-8M0108349	TUBING
43	22-424253	TEE
44	22-816856Q3	CONNECTOR, Fuel
45	10-69067	SCREW, (.250-20 x 1.375)
46	812782	SEAL

▶Flywheel and Starter Motor (23 parts)

Ref	OEM Part #	Part Name
1	18896A1	COVER KIT, FLYWHEEL
2	79022	MARKER, TIMING MARKER
3	10-37572	SCREW, (.190-32 x .380), TIMING MARKER
4	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, TIMING MARKER SCREW
5	19-89219001	PLUG, FLYWHEEL COVER
6	19-45907	PLUG, Yellow, FLYWHEEL
7	11-52901	NUT, (.625-18), FLYWHEEL
8	12-33001	WASHER, (.641 x 1.250 x .190), FLYWHEEL
9	271-859238T16	FLYWHEEL
10	10-32417	SCREW, (.250-28 x .625), FLYWHEEL PLATE
11	10-68997	SCREW, (.312-24 x .750), FLYWHEEL HUB
12	398-9610A5	STATOR
13	10-90045	SCREW, (#10-32 x 1.375), STATOR
14	10,13-26996	LOCKWASHER, Stainless Steel, STATOR SCREW
15	96455A9	PLATE ASSEMBLY, Trigger
16	84-93388A1	CABLE ASSEMBLY, (6.00 Inches) Black Comment: PLATE TO STARTER MOTOR
17	50-893893	STARTER MOTOR ASSEMBLY
18	23-8M0034918	COLLAR, STARTER MOTOR
19	8M0043376	STOP, Rubber, RUBBER - STARTER MOTOR
20	13-26992	LOCKWASHER, (.250) Stainless Steel, STARTER MOTOR TERMINAL
21	11-20890	NUT, (.250-20), STARTER MOTOR TERMINAL
22	84-93388A14	CABLE ASSEMBLY, Black (BLACK) Comment: SOLENOID TO STARTER MOTOR
23	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel, CABLE TO STARTER MOTOR

▶Flywheel/Starter Motor (23 parts)

Ref	OEM Part #	Part Name
1	18896A1	COVER KIT, Flywheel
2	79022	MARKER, Timing
3	10-37572	SCREW, (.190-32 x .380), Timing Marker
4	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, Timing Marker Screw
5	19-89219001	PLUG, Flywheel Cover
6	19-45907	PLUG, Yellow, Flywheel
7	11-52901	NUT, (.625-18), Flywheel
8	12-33001	WASHER, (.641 x 1.250 x .190), Flywheel
9	271-859238T16	FLYWHEEL
10	10-32417	SCREW, (.250-28 x .625), Flywheel Plate
11	10-68997	SCREW, (.312-24 x .750), Flywheel Hub
12	398-9610A5	STATOR
13	10-90045	SCREW, (#10-32 x 1.375), Stator
14	10,13-26996	LOCKWASHER, Stainless Steel, Stator Screw
15	96455A9	PLATE ASSEMBLY, Trigger
16	84-93388A1	CABLE ASSEMBLY, (6.00 Inches) Black, Plate to Starter Motor
17	50-893893	STARTER MOTOR ASSEMBLY
18	23-8M0034918	COLLAR, Starter Motor
19	8M0043376	STOP, Rubber, Rubber-Starter Motor
20	13-26992	LOCKWASHER, (.250) Stainless Steel, Starter Motor to Terminal
21	11-20890	NUT, (.250-20), Starter Motor Terminal
22	84-93388A14	CABLE ASSEMBLY, Black, Solenoid to Starter Motor
23	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel, Cable to Starer Motor

▶Fuel Pump and Carburetor (47 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	3307-9671A7	CARBURETOR Comment: (TOP) (WH-41A)
2	3307-9671A8	CARBURETOR Comment: (CENTER) (WH-41A)
3	3307-9671A9	CARBURETOR Comment: (BOTTOM) (WH-41A)
4	1395-6232	FITTING, FUEL INLET (UPPER)
5	22-70007	FITTING, 45 Degree, FUEL INLET
6	27-904301	GASKET, CARBURETOR
7	11-8M0207775	NUT, (1/4-28X7/32), CARBURETOR MOUNTING
8	54-816311T	TIE STRAP, FUEL HOSE TO CARBURETOR
9	42859A2	VALVE ASSEMBLY, Enrichner
10	54-633001	CLAMP, ENRICHENER VALVE
11	10-73286	SCREW, (.250-20 x .500) Stainless Steel, VALVE CLAMP
12	86-45915	TERMINAL BLOCK, REED BLOCK HOUSING
13	10-35519	SCREW, (#10-16 x .500), TERMINAL BLOCK ATTACHING
14	32-892024122	TUBING, (20.00 Feet Bulk), TOP CARBURETOR TO VALVE (7.75 Inches)
15	32-9912688	TUBING, (36.00 Inches Bulk), CARBURETOR TO CARBURETOR (4.25 Inches)
16	15930A15	PUMP ASSEMBLY, Fuel
17	21-857005A1	DIAPHRAGM KIT
18	NSS	NOT SOLD SEPARATE, Check Valve-Rubber
19	NSS	NOT SOLD SEPARATE, Gasket-Boost
20	NSS	NOT SOLD SEPARATE, Diaphragm
21	NSS	NOT SOLD SEPARATE, Gasket-Pulse
22	NSS	NOT SOLD SEPARATE, Spring
23	NSS	NOT SOLD SEPARATE, Cap
24	NSS	NOT SOLD SEPARATE, Check Valve
25	NSS	NOT SOLD SEPARATE, Retainer
26	NSS	NOT SOLD SEPARATE, Spring
27	NSS	NOT SOLD SEPARATE, Cap
28	27-8M0204705	GASKET, BASE
29	144303	BASE, FUEL PUMP
30	987752	PLATE, FUEL PUMP
31	22-56800	PLUG, Pipe (.0625-27)
32	22-19688	FITTING
33	10-16452	SCREW, (#12-24 x 2.00), FUEL PUMP
34	10-4000310	SCREW, (M5 x 40), FUEL PUMP TO CRANKCASE
35	12-4002314	WASHER, FUEL PUMP SCREW
36	22-14868	FITTING, FUEL PUMP
37	22-19688	FITTING, FUEL PUMP
38	32-8M0108355	LINE, (57.00 Inches Bulk)
39	35-816296Q03	FILTER, Fuel
40	54-15279	CLAMP, FUEL FILTER
41	22-64705	FITTING, PULSE HOSE
42	32-8M0108349	TUBING
43	22-424253	TEE
44	22-816856Q3	CONNECTOR, Fuel
45	10-69067	SCREW, (.250-20 x 1.375)
46	812782	SEAL

▶GEAR HOUSING(DRIVE-STANDARD/COUNTER ROTATION) (46 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	1647-9148T47	GEAR HOUSING ASSEMBLY Comment: (GRAY)
2	22-85822A10	CONNECTOR ASSEMBLY, SPEEDOMETER
3	17-43044	PIN, Dowel, GEAR HOUSING LOCATING
4	16-8M0034464	STUD, (.438 x 3.69), GEAR HOUSING Comment: (X-LONG)
5	16-8M0133358	STUD, (.44 x 2.06), GER HOUSING
6	16-8M0034463	STUD, (.312 x 3.38), WATER PUMP
7	16-306671	STUD, (.250-20/.250-28 x 3.125), WATER PUMP
8	31-42647A1	BEARING ASSEMBLY, Roller, DRIVESHAFT
9	23-43998	SLEEVE, LUBRICATION
11	45-897625T	DRIVESHAFT Comment: (EXTRA LONG)
13	12-92721	WASHER, PINION GEAR
14	11-35921	NUT, (.625-18), PINION GEAR TO DRIVESHAFT
15	15-42637A1	SHIM SET
16	31-8M0146566	BEARING ASSEMBLY, Roller/Cup, DRIVESHAFT
17	8245191	NUT, DRIVESHAFT BEARING
18	46-8M0077147	BASE ASSEMBLY, Water Pump
19	27-8M0204678	GASKET, WATER PUMP TO GEAR HSG
20	25-38099	O-RING, WATER PUMP (2.109 I.D.)
21	26-89238	SEAL, Oil, WATER PUMP
22	26-16977	SEAL, Oil, WATER PUMP
23	27-8M0090319	GASKET, LOWER - WATER PUMP
24	27-858524	GASKET, UPPER - WATER PUMP
25	8M0204677	FACE PLATE, WATER PUMP
26	46-96148T1	BODY ASSEMBLY, Water Pump
27	48752T	INSERT, WATER PUMP BODY
28	26-38970	SEAL, RUBBER - WATER INLET TUBE
29	47-89984T4	IMPELLER, WATER PUMP
30	28-8M0214992	KEY, IMPELLER DRIVE
31	10-8M0215009	SCREW, (#14-8 x 2.25), WATER PUMP
32	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, WATER PUMP SCREW AND STUD
33	11-8267119	NUT, (.250-28), WATER PUMP STUD
34	12-36001	WASHER, WATER PUMP STUD
35	11-13436	NUT, WATER PUMP STUD
36	25-8M0214918	RING, Rubber, DRIVESHAFT
37	23-29804T	SLEEVE, GUIDE - WATER INLET TUBE
38	789022	SHAFT, SHIFT - LOWER
39	53-29641	E RING, RETIANING - SHIFT SHAFT
40	53-78907	RING, Retaining
41	25-25439	O-RING, (.862 x .103), SHIFT SHAFT BUSHING
42	23-77631A2	BUSHING ASSEMBLY, SHIFT SHAFT
43	26-8M0204708	SEAL, Oil, SHIFT SHAFT BUSHING
44	12-77674	WASHER, RUBBER - SHIFT SHAFT BUSHING
45	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
46	22-8M0058389	SCREW, Magnetic, DRAIN
47	12-191833	WASHER, Fiber, GREASE FILLER AND DRAIN SCREW

▶GEAR HOUSING(PROPELLER SHAFT) (COUNTER ROTATION) (42 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
1	1647-9148T47	GEAR HOUSING ASSEMBLY Comment: (BASIC GRAY)
47	789562	SHIFT CAM
48	89594A1	FOLLOWER ASSEMBLY, CAM
49	79911A1	ROD, CLUTCH ACTUATOR
50	24-79910	SPRING, COMPRESSION
51	12-78910	WASHER, SPRING
52	17-8M0084245	PIN, SPRING LOCATOR
53	14469T	CUP, Bearing
54	30-88957T	BEARING, Ball
56	31-15844	BEARING ASSEMBLY, Roller
57	17-78909	PIN, Detent, RATCHET
58	52-823174T	RATCHET, SLIDING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET
60	24-78962	SPRING, RETAINING - CROSS PIN
61	43-18475T1	GEAR ASSEMBLY, Forward
62	23-1761513	SPACER SHIM, (.149)
63	31-15841	BEARING, Roller
64	12-17616	THRUST RING
65	25-8M0214920	O-RING, BEARING CARRIER
66	18447T2	ADAPTOR ASSEMBLY, Bearing
67	31-15843T	BEARING, Roller
68	12-18448	THRUST WASHER
69	31-15842	BEARING, Thrust
70	44-18446	PROPELLER SHAFT
71	818896T2	CARRIER ASSEMBLY, Bearing
72	31-30956T	BEARING, Needle, BEARING CARRIER
73	26-8M0204670	SEAL, BEARING CARRIER
74	14-79447	TAB WASHER, GEAR HOUSING COVER
75	8M2011027	RETAINER, GEAR HOUSING
76	28-30281	KEY, LOCATING - BEARING CARRIER
77	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
78	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
79	8M0039169	FILLER BLOCK
80	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, DRIVESHAFT HOUSING STUDS
81	11-8M0204653	NUT, (.437-20) Stainless Steel, DRIVESHAFT HOUSING STUDS
82	12-835467Q01	THRUST HUB
83	12-31211Q03	WASHER, Splined, PROPELLER NUT
84	14-816629Q	TAB WASHER, PROPELLER NUT
85	11-52707Q1	PROP NUT KIT, (.750-16)
86	13-423511	LOCKWASHER, Toothed, PROPELLER SHAFT
87	10-74727	SCREW, (.375-16 x 6.00), GEAR HOUSING

▶GEAR HOUSING(PROPELLER SHAFT) (STANDARD ROTATION) (37 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	1647-9148T47	GEAR HOUSING ASSEMBLY Comment: (BASIC) (GRAY)
48	789562	SHIFT CAM
49	89594A1	FOLLOWER ASSEMBLY, CAM
50	79911A1	ROD, CLUTCH ACTUATOR
51	24-79910	SPRING, COMPRESSION
52	12-78910	WASHER, COOMPRESSION SPRING
53	17-8M0084245	PIN, SPRING LOCATOR
54	15-47397A1	SHIM SET, BEARING OUTER RACE (.002-3-5-10)
55	31-78172A1	BEARING ASSEMBLY, Tapered Roller
56	43-44104T2	GEAR ASSEMBLY, Forward
57	31-43999	BEARING, Roller, FORWARD GEAR Comment: (1.308 O.D.)
58	52-823174T	RATCHET, SLIDING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET TO PROPELLER SHAFT
60	17-78909	PIN, Detent, RATCHET
61	24-78962	SPRING, RETAINING - CROSS PIN
62	44-94148	PROPELLER SHAFT
64	681001	RING, THRUST
65	30-88957T	BEARING, Ball, REVERSE GEAR
66	25-8M0214920	O-RING, BEARING CARRIER
67	43567T1	CARRIER ASSEMBLY, Bearing
68	31-30956T	BEARING, Needle, BEARING CARRIER
69	26-8M0204670	SEAL, BEARING CARRIER
70	28-30281	KEY, LOCATING, BEARING CARRIER
71	14-79447	TAB WASHER, GEAR HOUSING COVER
72	8M2011027	RETAINER, GEAR HOUSING
73	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
74	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
75	8M0039169	FILLER BLOCK
76	11-8M0204653	NUT, (.437-20) Stainless Steel, DRIVESHAFT HOUSING STUDS
77	10-74727	SCREW, (.375-16 x 6.00), GEAR HOUSING Comment: (X-LONG)
78	12-835467Q01	THRUST HUB
79	12-31211Q03	WASHER, Splined, PROPELLER NUT
80	14-816629Q	TAB WASHER, PROPELLER NUT
81	11-52707Q1	PROP NUT KIT, (.750-16)
82	13-423511	LOCKWASHER, Toothed, PROPELLER SHAFT
83	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, DRIVESHAFT HOUSING STUDS

▶Gear Housing(Driveshaft-Casting # is 1655-9572C) (44 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
1	1674-814247T9	GEAR HOUSING ASSEMBLY (GRAY)
2	22-85822A10	CONNECTOR ASSEMBLY, SPEEDOMETER
3	17-43044	PIN, Dowel, GEAR HOUSING LOCATING
4	16-786382	STUD, (.438 x 3.12), GEAR HOUSING
5	16-8M0133358	STUD, (.44 x 2.06), GEAR HOUSING
6	16-8M0034463	STUD, (.312 x 3.38), WATER PUMP
7	16-306671	STUD, (.250-20/.250-28 x 3.125), WATER PUMP
8	31-32898T	BEARING
9	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
10	22-8M0058389	SCREW, Magnetic, DRAIN
11	45-15298	DRIVESHAFT, GREASE FILLER
12	NSS	NOT SOLD SEPARATE, PINION GEAR (PART OF 43-16279A2)
13	12-191833	WASHER, GREASE FILLER AND DRAIN SCREW
14	11-35921	NUT, (.625-18)
15	15-42637A1	SHIM SET
16	31-8M0146566	BEARING ASSEMBLY, Roller/Cup
17	8245191	NUT, DRIVESHAFT BEARING
18	46-8M0077147	BASE ASSEMBLY, Water Pump
19	27-8M0204678	GASKET
20	25-38099	O-RING (2.109 I.D.)
21	26-89238	SEAL, Oil
22	26-16977	SEAL, Oil
23	27-8M0090319	GASKET, LOWER
24	27-858524	GASKET, UPPER
25	8M0204677	FACE PLATE
26	46-96148T1	BODY ASSEMBLY, Water Pump
27	48752T	INSERT, WATER PUMP BODY
28	26-38970	SEAL, RUBBER
29	47-89984T4	IMPELLER, WATER PUMP
30	28-8M0214992	KEY, IMPELLER DRIVE
31	10-8M0215009	SCREW, (#14-8 x 2.25)
32	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
33	11-8267119	NUT, (.250-28)
34	12-36001	WASHER
35	11-13436	NUT
36	25-8M0214918	RING, Rubber, RUBBER
37	23-29804T	SLEEVE, GUIDE
38	15299	SHAFT, SHIFT-LOWER
39	53-29641	E RING
40	25-25439	O-RING, (.862 x .103)
41	23-77631A2	BUSHING ASSEMBLY
42	26-8M0204708	SEAL, Oil
43	12-77674	WASHER

▶Gear Housing(Driveshaft-Casting # is1674-814247C) (44 parts)

Ref	OEM Part #	Part Name
-	46-96148A8	REPAIR KIT, Water Pump
1	1674-814247T2	GEAR HOUSING ASSEMBLY, Basic - Gray
2	22-85822A10	CONNECTOR ASSEMBLY
2A	23-43998	SLEEVE
3	17-43044	PIN, Dowel
4	16-786382	STUD, (.438 x 3.12)
5	16-8M0133358	STUD, (.44 x 2.06)
6	16-8M0034463	STUD, (.312 x 3.38)
7	16-306671	STUD, (.250-20/.250-28 x 3.125)
8	31-35934A1	BEARING ASSEMBLY, Roller
9	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
10	22-8M0058389	SCREW, Magnetic, DRAIN
11	45-815168	DRIVESHAFT
12	NSS	NOT SOLD SEPARATE, PINION GEAR (PART OF 43-16279A2)
13	12-191833	WASHER, Fiber
14	11-35921	NUT, (.625-18)
15	15-42637A1	SHIM SET
16	31-8M0146566	BEARING ASSEMBLY, Roller/Cup
17	8245191	NUT
18	46-8M0077147	BASE ASSEMBLY, Water Pump
19	27-8M0204678	GASKET
20	25-8M0142854	O-RING, (2.175 x .175)
21	26-89238	SEAL, Oil
22	26-16977	SEAL, Oil
23	27-8M0090319	GASKET, LOWER
24	27-858524	GASKET, UPPER
25	8M0204677	FACE PLATE
26	46-96148T1	BODY ASSEMBLY, Water Pump
27	48752T	INSERT
28	26-38970	SEAL, RUBBER
29	47-89984T3	IMPELLER
30	28-8M0214992	KEY
31	10-8M0215009	SCREW, (#14-8 x 2.25)
32	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
33	11-8267119	NUT, (.250-28)
34	12-36001	WASHER
35	11-13436	NUT
37	23-29804T	SLEEVE
38	8152641	SHIFT SHAFT
39	53-29641	E RING
40	25-25439	O-RING, (.862 x .103)
41	23-77631A2	BUSHING ASSEMBLY
42	26-8M0204708	SEAL, Oil
43	12-77674	WASHER, RUBBER -SHIFT SHAFT BUSHING

▶Gear Housing, Propeller Shaft - Casting # is 1655-9572C (34 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
1	1674-814247T9	GEAR HOUSING ASSEMBLY (GRAY)
44	760394	CAM, Shift Control
45	850315A1	FOLLOWER KIT, Cam
46	24-30622	SPRING
47	15-44491A1	SHIM SET
48	31-30894A1	BEARING SET, Cup And Cone
49	43-16279A2	GEAR ASSEMBLY, Forward
50	31-30895T	BEARING, Needle
51	52-822539T	RATCHET
52	17-8M0100263	PIN, Cross
53	24-30893	SPRING
54	44-12238T	PROPELLER SHAFT
55	NSS	NOT SOLD SEPARATE, REVERSE GEAR (PART OF 43-16279A2)
56	12-76358	THRUST WASHER
57	25-29976	O-RING
58	41529T2	CARRIER ASSEMBLY, Bearing
59	22-8M0169588	FITTING, Grease
60	31-30956T	BEARING, Needle
61	26-8M0204670	SEAL
62	28-30281	KEY
63	14-52700	TAB WASHER
64	52699	COVER
65	8M0039169	FILLER BLOCK
66	10-30206	SCREW, (.375-16 x 1.00) Stainless Steel
67	12-31211Q03	WASHER, Splined
68	14-816629Q	TAB WASHER
69	11-52707Q1	PROP NUT KIT, (.750-16)
70	97-15300	TRIM TAB, Anodic
71	10-15797	SCREW
72	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel
73	11-8M0204653	NUT, (.437-20) Stainless Steel
74	13191Q01	THRUST WASHER
75	13-423511	LOCKWASHER, Toothed

▶Gear Housing, Propeller Shaft - Casting # is 1674-814247C (32 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
1	1674-814247T2	GEAR HOUSING ASSEMBLY, Basic - Gray
44	760394	CAM, Shift Control
45	850315A1	FOLLOWER KIT, Cam
46	24-30622	SPRING
47	15-44491A1	SHIM SET
48	31-30894A1	BEARING SET, Cup And Cone
49	43-16279A2	GEAR ASSEMBLY, Forward
50	31-30895T	BEARING, Needle
51	52-822539T	CLUTCH
52	17-8M0100263	PIN, Cross
53	24-30893	SPRING
54	44-12238T	PROPELLER SHAFT
55	NSS	NOT SOLD SEPARATE, REVERSE GEAR (PART OF 43-16279A2)
56	12-76358	THRUST WASHER
57	25-29976	O-RING
58	41529T2	CARRIER ASSEMBLY, Bearing
59	22-8M0169588	FITTING, Grease
60	31-30956T	BEARING, Needle
61	26-8M0204670	SEAL
62	28-30281	KEY
63	14-52700	TAB WASHER
64	52699	COVER
65	8M0039169	FILLER BLOCK
66	10-65210	SCREW, (.375-16 x 1.00)
68	14-816629Q	TAB WASHER
69	11-52707Q1	PROP NUT KIT, (.750-16)
70	97-31640Q4	TRIM TAB ASSEMBLY
71	10-66024	SCREW, (.437-14 x 1.75)
72	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel
73	11-8M0204653	NUT, (.437-20) Stainless Steel
74	13191Q01	THRUST WASHER

▶IGNITION COIL/VOLTAGE REGULATOR (28 parts)

Ref	OEM Part #	Part Name
1	195872	PLATE, MOUNTING
2	10-30720	SCREW, (.250-20 x 2.25), VOLTAGE REGULATOR
3	13-26992	LOCKWASHER, (.250) Stainless Steel
4	23-19661	BUSHING
5	18736A21	REGULATOR ASSEMBLY, Voltage
6	18717	SEAL
7	8M0185622	SOLENOID, Starter
8	10-28635	SCREW, (.250-20 x .620) Stainless Steel, STARTER SOLENOID
9	84-88807A6	CABLE ASSEMBLY, (3.50 Inches) Black
10	11-8267098	NUT, (.250-20), SOLENOID SCREW
11	8-32,11-26419	NUT, Brass, SOLENOID TERMINAL
12	11-94330	NUT, (.250-20) Brass, SOLENOID TERMINAL
13	85-97861	INSULATOR, STARTER SOLENOID
14	84-88807A8	CABLE ASSEMBLY, (3.50 Inches) Black
15	84-88807A29	CABLE ASSEMBLY (9" - BLACK)
16	54-816311T	TIE STRAP
17	43542	COVER, IGNITION COIL
18	339-832757A4	COIL ASSEMBLY, Ignition
19	10-90048	SCREW, (#10-32 x 2.125), IGNITION COIL COVER
20	10-32,11-90078	NUT, , COVER SCREW/GROUND WIRE
21	84-813715A9	CABLE KIT, Ignition, HIGH TENSION
22	85-63709A1	BOOT/TERMINAL KIT, HIGH TENSION CABLE
23	33-13686Q	SPARK PLUG
24	10-32,11-45076	NUT, Brass, IGNITION COIL TERMINAL
25	84-88807A13	CABLE ASSEMBLY
26	10-69022	SCREW, (#10-32 x .500) Stainless Steel, GROUNDING WIRE
27	84-69739A6	HARNESS ASSEMBLY, COIL TO SWITCH BOX Comment: (#1, 3 AND 5)
28	54676	RETAINER, Two Wire

▶INSTRUMENTATION(MERCURY AND MARINER) (36 parts)

Ref	OEM Part #	Part Name
1	79-895283Q43	TACHOMETER
2	79101T	BRACKET, MOUNTING
3	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
4	88-79888	SOCKET, Light Bulb
5	8-32,11-26419	NUT, Brass
6	84-86323A5	CABLE ASSEMBLY, (1.50 Feet) Purple, TRIM GUAGE
7	79-895292Q41	TRIM GAUGE
8	79480	BRACKET, MOUNTING - TRIM GAUGE
9	88-72729	LIGHT BULB, Wedge Base (14V - .19W), TRIM GAUGE
10	88-79888	SOCKET, Light Bulb, TRIM GAUGE
11	8-32,11-26419	NUT, Brass, TRIM GAUGE TERMINAL
12	84-86396A8	HARNESS ASSEMBLY, Tachometer (5.00 Feet)
13	79-895287Q41	TEMPERATURE GAUGE
14	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
15	88-79888	SOCKET, Light Bulb
16	12-26427	WASHER
17	79480	BRACKET
18	8-32,11-26419	NUT, Brass
19	84-88824A4	CABLE ASSEMBLY, (45.00 Inches) Tan
20	79-895294Q41	SYNCHRONIZER GAUGE Comment: COUNTER ROTATION ENGINES
21	79480	BRACKET Comment: COUNTER ROTATION ENGINES
22	8-32,11-26419	NUT, Brass Comment: COUNTER ROTATION ENGINES
23	88-72729	LIGHT BULB, Wedge Base (14V - .19W) Comment: COUNTER ROTATION ENGINES
24	88-79888	SOCKET, Light Bulb Comment: COUNTER ROTATION ENGINES
25	145022	DRIVER, SYNCHRONIZED Comment: COUNTER ROTATION ENGINES
26	87-19674A1	SWITCH ASSEMBLY, Lanyard Comment: COUNTER ROTATION ENGINES
27	10-18303	SCREW, (.190-16 x 1.750) Stainless Steel Comment: COUNTER ROTATION ENGINES
28	813679	ADAPTER Comment: COUNTER ROTATION ENGINES
29	15920Q54	LANYARD ASSEMBLY Comment: COUNTER ROTATION ENGINES
30	10-32866	SCREW, (#10-32 x 2.00) Stainless Steel Comment: COUNTER ROTATION ENGINES
31	18321	CLAMP, Mounting Comment: COUNTER ROTATION ENGINES
32	54-816311T	TIE STRAP Comment: COUNTER ROTATION ENGINES
33	10-32,11-68219	NUT, Stainless Steel Comment: COUNTER ROTATION ENGINES
34	79146	RETAINER Comment: COUNTER ROTATION ENGINES
36	812497A2	DIODE ASSEMBLY Comment: COUNTER ROTATION ENGINES
37	84-11149A2	CABLE ASSEMBLY, (6.00 Inches) Comment: COUNTER ROTATION ENGINES

▶Ignition Coil/Voltage Regulator (31 parts)

Ref	OEM Part #	Part Name
1	195872	PLATE, Mounting
2	10-30720	SCREW, (.250-20 x 2.25), Voltage Regulator
3	13-26992	LOCKWASHER, (.250) Stainless Steel
4	23-19661	BUSHING
5	18736A21	REGULATOR ASSEMBLY, Voltage
6	18717	SEAL
7	8M0185622	SOLENOID, Starter
8	10-28635	SCREW, (.250-20 x .620) Stainless Steel, Starter Solenoid
9	84-88807A6	CABLE ASSEMBLY, (3.50 Inches) Black
10	11-8267098	NUT, (.250-20), Solenoid Screw
11	8-32,11-26419	NUT, Brass, Solenoid Terminal
12	11-94330	NUT, (.250-20) Brass, Solenoid Terminal
13	85-97861	INSULATOR, Starter Solenoid
14	84-88807A8	CABLE ASSEMBLY, (3.50 Inches) Black
15	84-88807A29	CABLE ASSEMBLY
16	54-816311T	TIE STRAP
17	43542	COVER, Ignition Coil
18	339-832757A4	COIL ASSEMBLY, Ignition
19	10-90048	SCREW, (#10-32 x 2.125), Ignition Coil Cover
20	10-32,11-90078	NUT, , Cover Screw/Ground Wire
21	84-813715A9	CABLE KIT, Ignition, High Tension
22	85-63709A1	BOOT/TERMINAL KIT, High Tension Cable
23	33-13686Q	SPARK PLUG
24	10-32,11-45076	NUT, Brass, Ignition Coil Terminal
25	84-88807A13	CABLE ASSEMBLY
26	10-69022	SCREW, (#10-32 x .500) Stainless Steel, Grounding Wire
27	84-69739A6	HARNESS ASSEMBLY, Coil to Switch Box Comment: (#1, 3 and 5)
28	54676	RETAINER, Two Wire
29	87-814407A3	SWITCH KIT, Tilt (Powerboat)
30	87-814407A2	TILT SWITCH (Powerboat)
31	99629A3	LEVER ASSEMBLY, Tilt (Powerboat)

▶Instrumentation (20 parts)

Ref	OEM Part #	Part Name
1	79-895283Q43	TACHOMETER
2	79101T	BRACKET, MOUNTING
3	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
4	88-79888	SOCKET, Light Bulb
5	8-32,11-26419	NUT, Brass
6	84-86323A5	CABLE ASSEMBLY, (1.50 Feet) Purple, TRIM GAUGE
7	79-895292Q41	TRIM GAUGE
8	79480	BRACKET, MOUNTING-TRIM GAUGE
9	88-72729	LIGHT BULB, Wedge Base (14V - .19W), TRIM GAUGE
10	88-79888	SOCKET, Light Bulb, TRIM GAUGE
11	8-32,11-26419	NUT, Brass, TRIM GAUGE TERMINAL
12	12-26427	WASHER, TRIM GAUGE TERMINAL
13	84-86396A8	HARNESS ASSEMBLY, Tachometer (5.00 Feet)
14	79-895287Q41	TEMPERATURE GAUGE
15	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
16	88-79888	SOCKET, Light Bulb
17	12-26427	WASHER
18	79480	BRACKET
19	8-32,11-26419	NUT, Brass
20	84-88824A4	CABLE ASSEMBLY, (45.00 Inches) Tan

▶KEY SWITCH ASSEMBLY (14 parts)

Ref	OEM Part #	Part Name
-	8949112	KEY, Ignition (2F)
1	84-816626A20	KEY SWITCH ASSEMBLY (20')
2	90468A1	COVER ASSEMBLY, Key, IGNITION SWITCH KEYS
3	76424	BRACKET, IGNITION SWITCH
4	16-55422	STUD, (#10-32 x 2.00), SWITCH ATTACHING
5	12-24676	WASHER, (.200 x .440 x .032), SWITCH ATTACHING STUD
6	10-32,11-68219	NUT, Stainless Steel, SWITCH ATTACHING STUD
7	816479A3	PLATE, SWITCH MOUNT
8	87-88107A5	KEY SWITCH (SEE BELOW FOR KEY)
9	11-879755	NUT, Special - Chrome Brass, IGNITION SWITCH
10	38-90311	INSERT, SWITCH PLATE
11	68878A6	HORN ASSEMBLY, Buzzer Alarm
12	68879	COVER, ALARM HORN
13	23-812711	SPACER, (.250)

▶Oil Injection Components (41 parts)

Ref	OEM Part #	Part Name
1	12430A4	SENSOR ASSEMBLY
2	10-48409	SCREW, (#10-16 x .625) Stainless Steel, SENSOR ATTACHING
3	41470A26	WARNING MODULE ASSEMBLY
4	12-38833	WASHER, WARNING MODULE SCREW
5	10-690201	SCREW, (#10-32 x .875), WARNING MODULE TO CYLINDER BLOCK
6	815698T	PUMP ASSEMBLY, Oil
7	10-41507	SCREW, (#10-32 x 1.120), OIL PUMP TO CRANKCASE
8	193856	LINK, THROTTLE LEVER TO OIL PUMP
9	23-41429A2	BEARING ASSEMBLY, DRIVE GEAR
10	43-14563	GEAR, Driven
11	32-82381335	TUBING, OIL PUMP TO TEE
12	10-42813	SCREW, (#10-32 X .380), WARNING MODULE LEAD
13	25-11379	O-RING, OIL PUMP
14	1257-87421	TANK
15	36-43298A2	CAP ASSEMBLY, OIL TANK
16	25-11332	O-RING, (2.225 x .210), CAP
17	816190A4	HOUSING ASSEMBLY, Adaptor
18	25-11332	O-RING, (2.225 x .210), ADAPTOR HOUSING
19	32-99802	TUBE, OIL PICK-UP
20	816190A4	HOUSING ASSEMBLY, Flywheel
21	32-99439	HOSE, (114.00 Inches), OIL
22	12540A3	HOUSING
23	12242A1	LATCH
24	21-8781051	FITTING, CHECK VALVE (CRANKCASE)
25	994436	RESERVOIR, Oil
26	10-690201	SCREW, (#10-32 x .875), OIL RESERVOIR ATTACHING
27	12-42118	WASHER, OIL RESERVOIR SCREW
28	25-42117	GROMMET, OIL RESERVOIR SCREW
29	23-42116	BUSHING, OIL RESERVOIR SCREW
30	32-82381455	TUBING, OIL RESERVOIR TO OIL PUMP (5-1/4")
31	36-43300A9	CAP ASSEMBLY, OIL RESERVOIR
32	27-43307T	GASKET, RESERVOIR CAP
33	8M0187298	FLOAT ASSEMBLY
34	11-99265	PUSH NUT
35	54-415821	CLAMP, OIL HOSE (SMALL)
36	54-415823	CLAMP, OIL HOSE (LARGE)
37	32-8M0108355	LINE, (57.00 Inches Bulk), OIL
38	22-42425	TEE, OIL TUBING
39	32-9072925	HOSE, OIL (6-3/4")
40	32-8M0108355	LINE, (57.00 Inches Bulk)
41	8141032	BEARING

▶Power Trim Components (38 parts)

Ref	OEM Part #	Part Name
1	99659A22	MANIFOLD ASSEMBLY (GRAY)
2	22-56800	PIPE PLUG, MANIFOLD
3	41493A7	TRIM CYLINDER ASSEMBLY (GRAY)
4	41492A1	GUIDE ASSEMBLY
5	25-41478A1	REPAIR KIT
6	41482A2	CHECK VALVE KIT
7	1100-8M0021648	GUIDE ASSEMBLY, TRIM ROD
8	878413A1	PISTON/ROD ASSEMBLY, Power Trim, PORT
9	35-12184A1	TRIM FILTER ASSEMBLY
10	878414T01	PISTON/ROD ASSEMBLY, Power Trim, STARBOARD
11	17-821539	PIN, Groove, TRIM CYLINDER (UPPER)
12	893929A01	VALVE ASSEMBLY
12A	53-815949001	E RING
13	10-4000327	SCREW, (M6 x 14), COVER
14	12-4002315	WASHER, COVER SCREW
15	99642	COVER, MANIFOLD
16	25-48462A4	O-RING KIT
17	19-99609A1	PLUG ASSEMBLY
18	99641A1	SHAFT ASSEMBLY
19	22-56800	PIPE PLUG, SHAFT
20	10-4008820	SCREW, (M6 x 20), PUMP AND MOTOR
21	13-400256	LOCKWASHER, (M6)
22	826729A10	PUMP AND MOTOR
23	99625002	SHAFT, UPPER
24	97-818298Q1	ANODE ASSEMBLY
25	10-4000332	SCREW, (M6 x 35), ANODE
26	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, ANODE SCREW
27	8M0045383	STRIKER PLATE, TRIM SHAFT
28	13-58643	LOCKWASHER, (.375)
29	11-46335	NUT, (.375-24)
30	84-17201A5	HARNESS ASSEMBLY, Control, POWER TRIM
31	84-87379A14	WIRE ASSEMBLY, (2.750 Inches) (RED)
32	54-22875	CLIP, PUMP WIRE
33	8M0084613	C WASHER, CLIP SCREW
34	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
35	17-878267	PIN, Groove, TRIM CYLINDER (LOWER)
36	10-4000377	SCREW, (M10 x 30), MANIFOLD
37	13-400258	LOCKWASHER, (M10) Stainless Steel, MANIFOLD SCREW

▶Power Trim Pump (9 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	12659	FRAME AND FIELD KIT
2	12665	SPRING KIT, Brush
3	13506	BRUSH CARD KIT
4	12662	PUMP AND END FRAME KIT
5	126631	SEAL KIT, Pump
6	12660	END FRAME KIT
7	12661	ARMATURE KIT
8	12664	THRU BOLT KIT

▶REED BLOCK AND CYLINDER HEAD (39 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	15221A5	CYLINDER HEAD ASSEMBLY
2	27-41247T01	GASKET, CYLINDER HEAD
3	10-98534	SCREW, (.375-16 x 2.30), CYLINDER HEAD
4	12-25909	WASHER, (.406 x .812 x .065), CYLINDER HEAD SCREW
5	27-8M0204714	GASKET, THERMOSTAT
6	90390A1	COVER KIT, THERMOSTAT
7	75692	THERMOSTAT
8	10-35386	SCREW, (.312-18 x 1.00), THERMOSTAT COVER
9	22-687271	FITTING, (.250-18) 90 Degree - Brass, WATER HOSES
10	32-77653101	HOSE, (24.500 Inches Bulk), WATER DISTRIBUTION
11	22-68728	FITTING, THERMOSTAT COVER TO WATER HOSES
12	54-816311T	TIE STRAP, WATER HOSES
13	97465	SENDER, Temperature (STARBOARD)
14	99747A9	HOUSING, REED BLOCK
15	10-69067	SCREW, (.250-20 x 1.375), REED BLOCK HOUSING
16	27-935361	GASKET, REED BLOCK HOUSING
17	27-657443	GASKET, REED BLOCK
18	75953	REED BLOCK
19	34-75362A1	REED ASSEMBLY
20	961832	CLAMP, Reed
21	10-57583T	SCREW, (#8-32 x .375), REEDS TO REED BLOCK
22	10-65746	SCREW, (.250-20 x .750), REED BLOCK ATTACHING
23	16-270372	STUD, (.250-28 x 1.125), CARBURETOR MOUNTING
24	21-426585	CHECK VALVE
25	32-892024122	TUBING, (20.00 Feet Bulk), BLEED LINE
26	22-56759	CONNECTOR, BLEED HOSE (PRESS-IN)
27	21-64871A2	CHECK VALVE
28	21-42657A3	CHECK VALVE
29	22-15133	FITTING, BLEED HOSE TO CYLINDER BLOCK (90 DEG.)
30	13536A7	SENSOR ASSEMBLY, Temperature (PORT) Comment: (MERCURY/MARINER)
31	137151	RETAINER (QTY. OF 1 W/SEA RAY)
32	10-98257	SCREW, (.312-18 x .500) (QTY. OF 1 W/SEA RAY)
33	187531	SENDER, Temperature Comment: (SEA RAY)
34	84-88824A8	CABLE ASSEMBLY, TEMPERATURE SENDER Comment: (SEA RAY)
35	54-26404	CLAMP (1")
36	8M0084613	C WASHER
37	10-62568	SCREW, (#10-16 x .375)
38	22-64705	FITTING

▶Reed Block and Cylinder Head (37 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	15221A5	CYLINDER HEAD ASSEMBLY
2	27-41247T01	GASKET, CYLINDER COVER
3	10-98534	SCREW, (.375-16 x 2.30), CYLINDER HEAD
4	12-25909	WASHER, (.406 x .812 x .065), CYLINDER HEAD SCREW
5	27-8M0204714	GASKET, THERMOSTAT
6	90390A1	COVER KIT, THERMOSTAT
7	10-35386	SCREW, (.312-18 x 1.00), THERMOSTAT COVER
8	22-687271	FITTING, (.250-18) 90 Degree - Brass, ELBOW - WATER HOSES
9	32-77653101	HOSE, (24.500 Inches Bulk), WATER DISTRUBUTION
10	22-68728	FITTING, THERMOSTAT COVER TO WATER HOSES
11	54-816311T	TIE STRAP, WATER HOSES
12	97465	SENDER, Temperature (STARBOARD)
13	75692	THERMOSTAT
14	13536A7	SENSOR ASSEMBLY, Temperature (PORT)
15	137151	RETAINER, SENSOR AND SENDER
16	10-98257	SCREW, (.312-18 x .500), RETAINER
17	99747A9	HOUSING, REED BLOCK
18	10-69067	SCREW, (.250-20 x 1.375), REED BLOCK HOUSING
19	27-935361	GASKET, REED BLOCK HOUSING
20	27-657443	GASKET, REED BLOCK
21	75953	REED BLOCK
22	34-75362A1	REED ASSEMBLY
23	961832	CLAMP, Reed
24	10-57583T	SCREW, (#8-32 x .375), REED TO REED BLOCK
25	10-65746	SCREW, (.250-20 x .750), REED BLOCK ATTACHING
26	16-270372	STUD, (.250-28 x 1.125), CARBURETOR MOUNTING
27	21-426585	CHECK VALVE, BLEED HOSE TO REED BLOCK HOUSING
28	22-15133	FITTING, BLEED HOSE TO CYLINDER BLOCK (90 DEG.)
29	32-892024122	TUBING, (20.00 Feet Bulk), BLEED LINE
30	21-42657A3	CHECK VALVE
31	22-56759	CONNECTOR, BLEED HOSE (PRESS-IN)
32	21-64871A2	CHECK VALVE
33	54-26404	CLAMP (1")
34	10-69079	SCREW, (#10-16 x .440), CLIP
35	8M0084613	C WASHER
36	22-64705	FITTING

▶SWIVEL BRACKET AND STEERING ARM (29 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	1499-8710T21	SWIVEL BRACKET ASSEMBLY Comment: (GRAY)
2	26-87735	SEAL, Oil, SWIVEL BRACKET (LOWER)
3	23-818764	BUSHING, SWIVEL BRACKET (LOWER AND UPPER)
4	25-33466	O-RING, SWIVEL BRACKET (UPPER)
5	23-67668	SPACER, SWIVEL BRACKET (UPPER)
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING, SWIVEL BRACKET
8	17-67706A55	SWIVEL PIN ASSEMBLY, Gray
9	10-8M0176309	SCREW, (.437-20 x 7.50), STEERING ARM TO UPPER MOUNT
10	77326	MOUNT, RUBBER - UPPER Comment: (X-LONG)
11	12-66921	WASHER, UPPER MOUNT BOLT
12	12-78688	WASHER, UPPER MOUNT BOLT
13	11-8M0204653	NUT, (.437-20) Stainless Steel, UPPER MOUNT BOLT
14	92876A12	LINK ASSEMBLY, Steering Comment: (MERCURY AND MARINER)
15	10-849838	SCREW, (.375-24 x 1.25), STEERING LINK TO STEERING ARM Comment: (MERCURY AND MARINER)
16	11-8M0204726	NUT, (.375-24), STEERING LINK SCREW Comment: (MERCURY AND MARINER)
17	12-34931	WASHER, (.406 x .734 x .063) Stainless Steel, STEERING LINK TO STEERING ARM Comment: (MERCURY AND MARINER)
18	13-78854	WAVE WASHER, BOTTOM YOKE
19	86580A1	YOKE ASSEMBLY, Bottom Comment: (GRAY)
20	53-67684	RING, Retaining, BOTTOM YOKE
21	12-67670	WASHER, THRUST - SWIVEL BRACKET
22	88882	BUMPER, Top Yoke
23	8M0074846	SENDER ASSEMBLY, Trim
24	10-852368	SCREW, (#10-24 x .750), TRIM SENDER
25	10,13-26996	LOCKWASHER, Stainless Steel, TRIM SENDER SCREW
26	12-89302	WASHER, (.203 x .406 x .040), TRIM SENDER SCREW
27	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET
28	54-54457	J CLIP

▶Service/Support Material (1 parts)

Ref	OEM Part #	Part Name
-	90-18110890	OWNERS GUIDE, SEA RAY

▶Starter Motor (10 parts)

Ref	OEM Part #	Part Name
-	50-893893	STARTER MOTOR ASSEMBLY
1	90645	DRIVE KIT
2	13310T1	PINION ASSEMBLY, Drive
3	75660	PLATE, DRIVE END
4	10-74968	BOLT, THRU
7	79216	ARMATURE
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER, BRUSH
10	10-68586	SCREW, BRUSH AND HOLDER
11	15386001	END CAP, COMMUTATOR

▶Starter Motor Assembly (11 parts)

Ref	OEM Part #	Part Name
-	50-893893	STARTER MOTOR ASSEMBLY
1	90645	DRIVE KIT
2	13310T1	PINION ASSEMBLY, Drive
3	75660	PLATE, Drive End
4	10-74968	BOLT, Thru
5	NSS	NOT SOLD SEPARATE, Washer-Thru Bolt Comment: (American Bosh #WA3122)
6	79216	ARMATURE
7	898265016	BRUSH/SPRING KIT
8	898265014	HOLDER, Brush
9	10-68586	SCREW, Brush and Holder
10	15386001	END CAP, Commutator

▶Swivel Bracket and Steering Arm (29 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	1499-8710T21	SWIVEL BRACKET ASSEMBLY (GRAY)
2	26-87735	SEAL, Oil, SWIVEL BRACKET (LOWER)
3	23-818764	BUSHING, SWIVEL BRACKET (LOWER AND UPPER)
4	25-33466	O-RING, SWIVEL BRACKET (UPPER)
5	23-67668	SPACER, SWIVEL BRACKET (UPPER)
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING, SWIVEL BRACKET
8	17-67706A55	SWIVEL PIN ASSEMBLY, Gray (GRAY)
9	10-8M0176309	SCREW, (.437-20 x 7.50), STEERING ARM TO UPPER MOUNT
10	77326	MOUNT, RUBBER-UPPER
11	12-66921	WASHER, UPPER MOUNT BOLT
12	12-78688	WASHER, UPPER MOUNT BOLT
13	11-8M0204653	NUT, (.437-20) Stainless Steel, UPPER MOUNT BOLT
14	92876A12	LINK ASSEMBLY, Steering
15	10-849838	SCREW, (.375-24 x 1.25), STEERING LINK TO STEERING ARM
16	11-8M0204726	NUT, (.375-24), STEERING LINK SCREW
17	12-34931	WASHER, (.406 x .734 x .063) Stainless Steel, STEERING LINK TO STEERING ARM
18	13-78854	WAVE WASHER, BOTTOM YOKE
19	86580A1	YOKE ASSEMBLY, Bottom (GRAY)
20	53-67684	RING, Retaining, BOTTOM YOKE
21	12-67670	WASHER, THRUST-SWIVEL BRACKET
22	88882	BUMPER, Top Yoke, TOP YOKE
23	8M0074846	SENDER ASSEMBLY, Trim
24	10-852368	SCREW, (#10-24 x .750), TRIM SENDER
25	10,13-26996	LOCKWASHER, Stainless Steel, TRIM SENDER SCREW
26	12-89302	WASHER, (.203 x .406 x .040), TRIM SENDER SCREW
27	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET
28	54-54457	J CLIP

▶TRANSOM BRACKETS (21 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	3401-8718F8	BRACKET ASSEMBLY, Transom Comment: (STARBOARD) (GRAY)
2	3400-8716A9	BRACKET ASSEMBLY, Transom Comment: (PORT) (GRAY)
3	22-8M0169588	FITTING, Grease, PORT TRANSOM BRACKET
5	99170A2	TILT TUBE
6	11-859133	NUT, TILT TUBE (1"-14) Comment: (GRAY)
7	25-45711	O-RING, (.612 x .103), TILT TUBE
8	13-88750	WASHER, TILT TUBE
9	11-858869	NUT, (.875-14), TILT TUBE
10	10-8M0149747	SCREW, (.500-20 x 4.500), TRANSOM BRACKET TO TRANSOM
11	12-24501	WASHER, TRANSOM BRACKET BOLT Comment: (UPPER - SEA RAY)
12	11-91962	NUT, (.500-20), TRANSOM BRACKET BOLT
13	8M0115104	LEVER ASSEMBLY, TILT LOCK
14	13-99611	WAVE WASHER, TILT LEVER
15	23-65830	NYLINER, TILT LEVER
16	99633	KNOB, TILT LOCK LEVER Comment: (GRAY)
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY, TILT LOCK
21	11-23161	NUT, (.375-24), BOLT

▶Throttle Lever and Shift Shaft (49 parts)

Ref	OEM Part #	Part Name
1	74897T	PIVOT, TRIGGER PLATE
2	62459T	BALL JOINT ASSEMBLY, TRIGGER PLATE
3	10-32,11-45076	NUT, Brass, LINK ROD
4	76035	ROD, TRIGGER PLATE
5	10-32,11-46438	NUT, , BALL JOINT
6	41094A3	LEVER ASSEMBLY, SPARK ADVANCE
7	10-64022	SCREW, (.250-20 x 2.125)
8	11-64015	NUT, (.250-20)
9	26852	CAP, Nylon
10	10-69560	SCREW, (.190-32 x 1.250), SPARK ADVANCE LEVER - STOP
11	10-32,11-68219	NUT, Stainless Steel, SPARK ADVANCE LEVER STOP SCREW
12	48039	CAP
13	410952	LEVER, THROTTLE CONTROL
14	10-818165	SCREW, (.375-16 x 1.75)
15	23-55164	BUSHING, THROTTLE LEVER
16	23-55171	BUSHING
17	24-68784	SPRING
18	12-68410	WASHER
19	10-64022	SCREW, (.250-20 x 2.125)
20	11-64015	NUT, (.250-20)
21	26852	CAP, Nylon
22	39483	LATCH, CABLE
23	10-69026	SCREW, (.250-28 x .880)
24	24-20099	SPRING
25	11-826709109	NUT, (.250-28)
26	79949	ROD, THROTTLE CONTROL
27	8M0221994	BARREL
28	95791	CAM, Throttle
29	16-20353	STUD, (.250-28 x 1.750), THROTTLE CAM ATTACHING
30	23-26856	BUSHING, THROTTLE CAM
31	11-36069	NUT, THROTTLE CAM STUD
32	24-41050	SPRING, THROTTLE RETURN
33	814283A2	BRACKET, ANCHOR-CONTROL CABLES
34	98889	LATCH, CONTROL CABLE
35	10-42975	DRIVE SCREW
36	10-53167T	SCREW, (.312-18 x .880)
37	37896	GUIDE BLOCK, LINK ROD
38	24-20099	SPRING
39	67073A1	LINK ROD ASSEMBLY
40	52100	WEAR PLATE, LINK ROD
41	8M0036768	LATCH
42	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel
43	11-36069	NUT
44	79932A17	SHIFT SHAFT ASSEMBLY Comment: X-Long
45	13-29720	WAVE WASHER
46	23-26600	BUSHING, NYLON
47	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel
48	11-36069	NUT
49	39519	CUP

▶Top Cowl and Front Shield (30 parts)

Ref	OEM Part #	Part Name
-	813096A1	REAR LATCH KIT
1	2196-9743T11	TOP COWL ASSEMBLY (GRAY)
2	812784	SEAL
3	815478	SEAL
4	814823	SOUND BLANKET (SIDE)
5	814837	SOUND BLANKET (TOP)
6	18755A2	FRONT SHIELD ASSEMBLY (GRAY)
7	813562	SEAL
8	10-48409	SCREW, (#10-16 x .625) Stainless Steel
9	12-42118	WASHER
10	184741	BRACKET, REAR
11	25-18506001	GROMMET
12	10-28636	SCREW, (.250-20 x .750), REAR BRACKET
13	13-26992	LOCKWASHER, (.250) Stainless Steel, REAR BRACKET SCREW
14	813096A2	HOOK Comment: SEE NOTE
15	10-73286	SCREW, (.250-20 x .500) Stainless Steel
16	8M0207770	ROLLER
17	53-13194	RING, Retaining
18	813553	PLATE
19	187021	LOCATOR
20	893763	BRACKET ASSEMBLY, Latch Roller
21	813552	SPACER
22	10-31984	SCREW, (.312-18 x 1.375)
23	11-82670910	NUT, (.312-18)
24	47341A11	ROPE AND HANDLE KIT, Manual/Emergency Start (FOR MANUAL STARTING)
25	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel
26	813562	SEAL
27	10-48409	SCREW, (#10-16 x .625) Stainless Steel
28	12-42118	WASHER
29	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel

▶Transom Bracket (21 parts)

Ref	OEM Part #	Part Name
-	27-11338A88	GASKET SET, Engine Overhaul
1	3401-8718F8	BRACKET ASSEMBLY, Transom (STARBOARD) (GRAY)
2	3400-8716A9	BRACKET ASSEMBLY, Transom (PORT) (GRAY)
3	22-8M0169588	FITTING, Grease, PORT TRANSOM BRACKET
5	99170A2	TILT TUBE
6	11-859133	NUT, TILT TUBE (1"-14) (GRAY)
7	25-45711	O-RING, (.612 x .103), TILT TUBE
8	13-88750	WASHER, TILT TUBE
9	11-858869	NUT, (.875-14), TILT TUBE
10	10-8M0149747	SCREW, (.500-20 x 4.500), TRANSOM BRACKET TO TRANSOM
11	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel, TRANSOM BRACKET BOLT
12	11-91962	NUT, (.500-20), TRANSOM BRACKET BOLT
13	8M0115104	LEVER ASSEMBLY, TILT LOCK
14	13-99611	WAVE WASHER, TILT LEVER
15	23-65830	NYLINER
16	99633	KNOB, TILT LOCK LEVER (GRAY)
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY, TILT LOCK
21	11-23161	NUT, (.375-24)

▶Wiring Harness/Starter Solenoid (33 parts)

Ref	OEM Part #	Part Name
1	434292	PLATE, IGNITION
2	332-7778A12	SWITCHBOX ASSEMBLY
3	10-13669	SCREW, (#12-24 x 2.00), SWITCH BOX TO IGNITION PLATE
4	23-94453	BUSHING, SWITCH BOX SCREW
5	84-62310A2	CABLE ASSEMBLY, SWITCH BOX TO SWITCH BOX
6	10-32,11-45076	NUT, Brass, SWITCH BOX TERMINAL
7	84-60871A10	WIRE ASSEMBLY, SWITCH BOX
8	10-62568	SCREW, (#10-16 x .375), WIRE ATTACHING
9	84-65999A3	CABLE ASSEMBLY, Black
10	10-60411	SCREW, (1.25), IGNITION PLATE
11	13-8M0204647	LOCKWASHER, (.312), IGNITION PLATE SCREW
12	12-36042	WASHER, IGNITION PLATE SCREW
13	12-67264	WASHER, (Rubber), IGNITION PLATE SCREW
14	23-67268	BUSHING, IGNITION PLATE SCREW
15	87-33386A3	SWITCH ASSEMLBY
16	10-38055	SCREW, (.190-32 x .620)
17	10-32,11-45076	NUT, Brass, MERCURY SWITCH TERMINAL
18	10-87926	SCREW, (#10-32 x .500), LEAD ATTACHING
19	84-88439A2	CABLE ASSEMBLY, Battery - Negative, NEGATIVE - MERCURY/MARINER
20	84-96220A12	HARNESS ASSEMBLY, ENGINE
21	88-8M0207796	FUSE, 20 Ampere
22	84-95084A2	CABLE ASSEMBLY, FUSE
23	134731	HOLDER, Fuse
24	54-816311T	TIE STRAP, HARNESS AND CABLES
25	89-853654A1	SOLENOID, Starter
26	10-32,11-45076	NUT, Brass, SOLENOID TERMINALS
27	13-53166	LOCKWASHER, (.312), SOLENOID TERMINALS
28	11-8M0204668	NUT, (.312-18), SOLENOID TERMINALS
29	10-31716	SCREW, (.250-20 x .620), SOLENOID TO IGNITION PLATE
30	13-26992	LOCKWASHER, (.250) Stainless Steel
31	84-65999A2	CABLE ASSEMBLY, Black, UPPER MOUNT
32	85-78866	INSULATOR, SOLENOID
33	54-47483	J CLIP

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury V-175 running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Popular Products

Popular Products

Popular Products

Mercury V-175 (0C100861 THRU 0C239552) Parts & Diagrams

Categories

Refined By Clear all

Brand

Horsepower

Engine

Availability

Price

Need Help?

Images

Product

Price

Qty

Options