Mercury 75 (3 CYL.) (1B000000 & Up) Parts & Diagrams

🔎 Mercury 75 (3 CYL.) Reference Library — Exploded parts diagrams (37 diagrams), specifications, common issues, and maintenance checklist.

The Mercury 75 (3 CYL.) is a 4-Stroke, Inline 4-Cylinder, EFI, SOHC outboard motor. Suited for bay boats, pontoons, and center-console fishing boats requiring reliable mid-range power.

Quick Reference Specifications

Specification	Value
Engine Type	4-Stroke, Inline 4-Cylinder, EFI, SOHC
Horsepower	75 HP
Displacement	2100 cc
Bore x Stroke	90 mm x 81 mm
Spark Plug (Type & Gap)	NGK IZFR6F-11
Engine Oil Capacity	5.2 L (5.5 quart)
Recommended Engine Oil	Mercury FourStroke Oil 10W-30
Gear Case Oil Capacity	710 mL (24 fl oz)
Idle Speed (in gear)	650 ± 50 RPM (in gear)
Full Throttle RPM Range	4500-5500
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury 75 (3 CYL.):

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury 75 (3 CYL.).

▶Accessories (1 parts)

Ref	OEM Part #	Part Name
-	858566A1	FLUSH KIT, Coastal

▶Attenuator Plate (24 parts)

Ref	OEM Part #	Part Name
-	809837T97	POWERHEAD ASSEMBLY Comment: (Oil Injection)
1	42969A3	COVER ASSEMBLY, Attenuator
2	19-815784	CAP
3	27-828479	GASKET
4	NSS	NOT SOLD SEPARATE, Decal-Timing
5	NSS	NOT SOLD SEPARATE, Decal-Caution
6	10-878609	SCREW, (#10-16 x .600)
7	42970A2	PLATE ASSEMBLY, Attenuator
8	12-4002217	WASHER
9	11-826365	NUT
10	39519	CUP
11	98889	LATCH
12	27-151724	GASKET
13	8252041	LINK
14	67748	ROLLER
15	54-816311T	TIE STRAP, (8.00 Inches)
16	8M0084744	LINK ROD Comment: (Oil Injection)
17	11399A1	ARM ASSEMBLY
18	10-40056103	SCREW, (M5 x 6)
19	12-8M0204666	WASHER, (.203 x .500 x .032)
20	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (Cut ot 1.50 Inch Length) Comment: (Electric)
21	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (Cut ot 5.25 Inch Length) Comment: (Manual)
22	32-9912878	HOSE, (.187) (26.00 Inches Bulk) (Cut ot 5.25 Inch Length) Comment: (Electric/Manual)
23	22-830285	FITTING TEE Comment: (Electric)

▶Bleed System (8 parts)

Ref	OEM Part #	Part Name
-	809837T97	POWERHEAD ASSEMBLY Comment: (Oil Injection)
1	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 12.50 Inch Length)
2	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 6.00 Inch Length)
3	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 3.50 Inch Length)
4	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 2.50 Inch Length)
5	22-59169003	FITTING, Tee
6	21-149126	CHECK VALVE
7	22-15133	FITTING

▶Bottom Cowl (24 parts)

Ref	OEM Part #	Part Name
1	100-8M0107327	BOTTOM COWL ASSEMBLY, Starboard
2	25-822556003	GROMMET (Starboard)
3	8M0109216	SEAL, (36.00 Inches)
4	8M0043167	SEAL, Lower Cowl (44.75 Inches)
5	100-8M0107328	BOTTOM COWL ASSEMBLY, Port
6	25-822555001	GROMMET (Port)
7	8M0109216	SEAL, (36.00 Inches)
8	87-8M0042301	SWITCH ASSEMBLY Comment: (Power Trim)
9	8M0032848	RETAINER
10	22-813613	FITTING
11	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 28.00 Inch Length)
12	21-817519A2	CHECK VALVE ASSEMBLY, Drain
13	10-82130040	SCREW, (M6 x 40)
14	8M0041366	HANDLE Comment: (Black)
15	23-812707	BUSHING
16	13-F2047	WASHER, Wave
17	8M0001081	CAM
18	12-8M0214930	WASHER
19	13-26992	LOCKWASHER, (.250) Stainless Steel
20	10-28635	SCREW, (.250-20 x .620) Stainless Steel
21	822363T1	RETAINER
22	11-401386	NUT, (M6) Stainless Steel
23	12-8M0214930	WASHER
24	812830T01	PLUG Comment: (Non Power Trim/Manual Tilt Assist)

▶Carburetor (27 parts)

Ref	OEM Part #	Part Name
-	27-43004A99	GASKET SET, Powerhead
1	3301-824854T29	CARBURETOR, (WME-115-3) Comment: (Bottom)(90 Oil Injection) SN# USA-1B227000/BEL-0P401000 & Up
2	27-151724	GASKET, Flange
3	10-F10155	SCREW, Throttle Valve
4	1395-97244	VALVE, Throttle
5	NSS	NOT SOLD SEPARATE, Retaining Ring
6	F10064	SHAFT
7	1395-823632	SHAFT, Throttle Comment: (Top/Bottom)
8	1395-8236321	SHAFT, Throttle Comment: (Center)(WME-103/108/114/115)
9	1395-823633	SHAFT, Throttle Comment: (Center)(76/77/105/106)
10	1395-823634	SCREW (Top/Bottom)
11	1395-811220	SCREW, Cover Plate
12	1395-811221	COVER PLATE
13	NSS	NOT SOLD SEPARATE, Gasket-Cover Plate
14	NSS	NOT SOLD SEPARATE, Spring-Idle Needle
15	NSS	NOT SOLD SEPARATE, Idle Needle
16	1395-8087461	LEVER, Throttle (Top/Bottom)
17	NSS	NOT SOLD SEPARATE, Spring-Throttle Return
18	1395-808738	GASKET
19	NSS	NOT SOLD SEPARATE, Inlet Needle Valve
20	10-95951	VALVE, Inlet Needle
21	1395-9594	FLOAT
22	1395-811693	BOWL, Fuel
23	1395-808612	SCREW AND WASHER, (#8-32 x .750)
24	1395-811694	PLUG KIT
25	1395-802731	SEAL Comment: (Consists of 4 Seals)
26	1399-4217	JET, Main (.062) Comment: (WME-115-1)

▶Co-Pilot (10 parts)

Ref	OEM Part #	Part Name
-	56-52148A7	CO-PILOT ASSEMBLY
1	521481	PILOT ROD
2	11-8M0103848	NUT ASSEMBLY
3	10-56500	SCREW, (.250-28 x 1.250)
4	12-77674	WASHER
5	821621	KNOB, Prong
6	873491	ROD
7	23-521512	BUSHING
8	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel
9	11-826709111	NUT, (.312-24) Stainless Steel

▶Crankshaft, Pistons and Connecting Rods (23 parts)

Ref	OEM Part #	Part Name
-	809837T97	POWERHEAD ASSEMBLY Comment: (Oil Injection)
1	493-827616T1	CRANKSHAFT
2	30-43011T	BEARING, Ball, Lower
3	786611	WEAR SLEEVE
4	25-35126	O-RING, (.859 x .139)
5	39-818412A4	RING ASSEMBLY
6	28-91800	KEY, Woodruff
7	43-43019A1	GEAR ASSEMBLY
8	31-43013T3	BEARING ASSEMBLY, Roller, Upper
9	26-8M0214932	SEAL, Oil
10	25-823683	O-RING, (1.989 x .070) Comment: (1.989 X .070)(Round)
11	42943A1	BEARING ASSEMBLY, Roller
12	NSS	NOT SOLD SEPARATE, Roller Bearing
13	2704-821896A4	PISTON ASSEMBLY Comment: (.030 Oversize)
14	53-857196	LOCK RING
15	NSS	NOT SOLD SEPARATE, Piston Ring
16	39-822321A2	RING SET, Piston Comment: (.030 O.S.)
17	646-818846T6	CONNECTING ROD ASSEMBLY
18	12-8M0012298	WASHER
19	29-8M0214954	BEARING, Needle
20	10-94320	SCREW, (.375-24 x 1.250)
21	31-844338A01	BEARING/CAGE KIT
22	NSS	NOT SOLD SEPARATE, Roller Bearing

▶Cylinder Block (62 parts)

Ref	OEM Part #	Part Name
-	809837T97	POWERHEAD ASSEMBLY Comment: (Oil Injection)
1	876-898208A01	CYLINDER BLOCK ASSEMBLY Comment: SN# 0P401000 & Up
2	10-4009680	SCREW, (M10 x 80)
3	10-814776	SCREW, Adjusting (M6 x 55)
4	11-400212	NUT, (M6) Stainless Steel
5	42942	CAP
6	21-426233	CHECK VALVE (Press-In)
7	813801A1	CARRIER ASSEMBLY
8	21-42657A3	CHECK VALVE
9	17-8M0036405	PIN, Bearing Race
10	17-43044	PIN, Dowel - Without Hole (.375 x .625)
11	16-892561001	STUD, (M10 x 136)
12	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel
13	11-40140	NUT, (M10)
14	76867	COVER
15	10-81742750	SCREW, (M8 x 50)
16	428842	COVER, Top
17	65848	CARRIER
18	25-64872	GROMMET
19	86596T	POPPET VALVE
20	24-42996	SPRING, (Stainless Steel)
21	824703A1	PLUG KIT
22	NSS	NOT SOLD SEPARATE, Plug
23	10-82127335	SCREW, (M8 x 35 MM)
24	12621	COVER Comment: (Non Oil Injection)
25	27-126201	GASKET Comment: (Non Oil Injection)
26	10-82104512	SCREW, (M5 x 12) Comment: (Non Oil Injection)
27	16-8161949	STUD, (M6 x 44)
28	12-8M0204663	WASHER, (.187 x .500 x .062) Neoprene
29	11-816872	WING NUT
30	1034-9003A2	COVER ASSEMBLY
31	27-430057	GASKET
32	22-328022	PLUG, Pipe (.125-27) Brass
33	823462	LIFTING EYE Comment: (Non Oil Injection)
34	12-475331	THERMOSTAT WASHER Comment: (Non Oil Injection)
35	14586	THERMOSTAT Comment: (Oil Injection)
36	27-8M0204714	GASKET
37	27-430068	GASKET
38	8M0047619	COVER
39	10-82127335	SCREW, (M8 x 35 MM)
40	10-69570	SCREW, (#10-16 x .750)
41	12-94182	WASHER
42	648771	DIAPHRAGM
43	10-878609	SCREW, (#10-16 x .600)
44	44290T	RETAINER
45	787992	SENDER, Temperature
46	10-82127335	SCREW, (M8 x 35 MM)
47	54-814634	CLAMP
48	99162001	BOOT
49	821889A50	REV LIMITER Comment: (Jet)
50	10-82130030	SCREW, (M6 x 30)
51	84-855212A1	HARNESS ASSEMBLY, Adaptor Comment: (Oil Injection)
52	13541	PLUG, Male Comment: (Oil Injection)
53	12-8M0204666	WASHER, (.203 x .500 x .032)
54	22-857175	COUPLING INSERT Comment: (Saltwater)
55	22-857176	COUPLING BODY Comment: (Saltwater)
56	19-858240	CAP Comment: (Saltwater)
57	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) Comment: (Saltwater)
58	54-816311T	TIE STRAP, (8.00 Inches) Comment: (Saltwater)
59	22-857219	FITTING Comment: (Saltwater)
60	22-286241	FITTING Comment: (Saltwater)
61	54-850181	TIE STRAP, (11.750 Inches) Comment: (Saltwater)

▶Driveshaft Housing (25 parts)

Ref	OEM Part #	Part Name
1	1598-881913T02	HOUSING ASSEMBLY, Driveshaft Comment: (Jet)
2	16-9035015	STUD, (M10 x 227) Comment: (X-Long=25 Inch Model)
3	16-8M0034462	STUD, (M10 x 190) Comment: (X-Long=25 Inch Model)
4	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel
5	11-40140	NUT, (M10)
6	22-85822A4	PICKUP ASSEMBLY, Speedometer
7	22-433351	CONNECTOR, 90 Degree (.125-27) Nylon
8	22-85822T	CONNECTOR, Straight
9	881916	MOUNT
10	10-898835001	BOLT, (M12 x 154)
11	12-30119	WASHER, (.875 Inch Outside Diameter)
12	11-8M0204662	NUT, (M12)
13	88238A10	CABLE ASSEMBLY, Ground
14	10-41508	SCREW, (.250-20 x .500) Stainless Steel
15	8M0036786	CLAMP
16	11-35521	NUT
17	10-889833025	SCREW, (M8 x 25 MM)
18	100-8M4500754	COVER
19	10-88417	SCREW, (#12-24 x .620)
20	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel
21	12-881976	WASHER, Neoprene
22	816696T7	SPACER Comment: (LL=22.5 Inch Model)
23	17-8M0084244	PIN, Dowel - With Hole (.375 x .625) (With Hole) Comment: (LL/XL)(Front)
24	892214	PLATE WASHER
25	19-8M0026580	PLUG, Driveshaft Housing

▶Electrical Components (38 parts)

Ref	OEM Part #	Part Name
1	8327531	PLATE, Electrical
2	10-40011150	SCREW, (M8 x 30) Stainless Steel
3	12-49436	WASHER
4	23-8502341	BUSHING
5	25-833155	GROMMET
6	10-82239312	SCREW, (M5 x 12) Comment: (Electric)
7	8261151	CLAMP, Connector
8	84-88807A44	CABLE ASSEMBLY (10 Inch)
9	10-82239312	SCREW, (M5 x 12)
10	12-89302	WASHER, (.203 x .406 x .040)
11	84-850043A2	HARNESS ASSEMBLY, Engine Comment: (Electric)
12	88-812619	FUSE, Yellow - 20 Ampere Comment: (Electric)
13	84-850046A2	HARNESS ASSEMBLY, Ignition Comment: (Electric)
14	84-88439A3	CABLE ASSEMBLY, Positive - Battery Comment: (Electric)
15	85-830233	BOOT, Insulator - Red Comment: (Electric)
16	827509A10	CDM MODULE ASSEMBLY
17	84-821945A61	CABLE ASSEMBLY, Hi Tension
18	85-63709A1	BOOT/TERMINAL KIT
19	33-14103Q	SPARK PLUG Comment: (NGK#BUZHW-2)
20	10-82129116	SCREW, (M6 x 16)
21	89-817109A2	SOLENOID ASSEMBLY, (#10-32 / .3125-18 Terminals) Comment: (Electric)
22	25-822179	GROMMET Comment: (Electric)
23	23-8M0214955	BUSHING Comment: (Electric)
24	10-32,11-45076	NUT, Brass Comment: (Electric)
25	84-88807A16	CABLE ASSEMBLY, (4.00 Inches) Black Comment: (Electric)
26	13-8M0204647	LOCKWASHER, (.312) Comment: (Electric)
27	11-8M0204668	NUT, (.312-18) Comment: (Electric)
28	10-82129125	SCREW, (M6 x 25 MM) Comment: (Electric)
29	8M0084173	REGULATOR, Voltage Comment: (Electric)
30	54-816311T	TIE STRAP, (8.00 Inches) Comment: (Electric)
31	10-82129135	SCREW, (M6 x 35) Comment: (Electric)
32	54-54457	J CLIP Comment: (Electric)
33	84-88439A4	CABLE ASSEMBLY, Battery - Negative Comment: (Electric)
34	13541	PLUG, Male Comment: (Electric)
35	54-834813	CLAMP
36	84-850044A2	HARNESS ASSEMBLY, Engine Comment: (Manual)
37	54-816311T	TIE STRAP, (8.00 Inches) Comment: (Manual)
38	12-36001	WASHER

▶Exhaust Plate (27 parts)

Ref	OEM Part #	Part Name
1	881912T01	PLATE, Exhaust
2	17-23784	PIN, Dowel
3	881973	RETAINER
4	881915002	MOUNT
5	10-881975	SCREW, (M8 x 35 MM)
6	10-898487	BOLT, (M12 x 175)
7	11-896963	NUT, (M12)
8	23-11289	SPACER (X-Long)
9	43585	COUPLING
10	27-430086	GASKET
11	42966T07	TUBE, Exhaust
12	10-40011151	SCREW, (M8 x 35) Stainless Steel
13	8M0039075	SEAL
14	25-89417004	GROMMET
15	32-8M0042792	TUBE, Water - X Long (18.21 Inches)
16	824661	CLAMP
17	814080001	SEAL, Upper
18	10-889833045	SCREW, (M8 x 45)
19	881918T03	CLAMP, Bracket, Upper Mount
20	25-8M0179867	GROMMET (Manual Models)
21	23-48237	BUSHING
22	79932A23	SHIFT SHAFT ASSEMBLY (Manual Models)
23	42912A3	SHIFT LINK
24	23-48475	BUSHING
25	11-401386	NUT, (M6) Stainless Steel
26	10-40011151	SCREW, (M8 x 35) Stainless Steel
27	10-40011158	SCREW, (M8 x 70) Stainless Steel

▶Flywheel and Starter Motor (24 parts)

Ref	OEM Part #	Part Name
-	84-11149A27	CABLE ASSEMBLY Comment: (Electric)
1	19-45907	PLUG, Yellow
2	812777T1	COVER ASSEMBLY
3	11-42979	NUT, (M16)
4	12-33001	WASHER, (.641 x 1.250 x .190)
5	261-878226T16	FLYWHEEL ASSEMBLY Comment: (Electric-Non Oil Injection)
6	261-878226T8	FLYWHEEL ASSEMBLY Comment: (Manual)
7	398-832074A11	STATOR ASSEMBLY Comment: (Manual)
8	10-4013930	SCREW, (M5 x 30)
9	854512T	TRIGGER
10	56762	TIE STRAP, (4.00 Inches)
11	93254	SWIVEL BASE
12	93421	SWIVEL BALL
13	50-893891T	STARTER MOTOR ASSEMBLY
14	23-8M0034918	COLLAR
15	8M0043376	STOP
16	84-93388A1	CABLE ASSEMBLY, (6.00 Inches) Black
17	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel
18	84-93388A8	CABLE ASSEMBLY, (12.5 Inchs) Black
19	13-26992	LOCKWASHER, (.250) Stainless Steel
20	11-64015	NUT, (.250-20)
21	37-8272822	DECAL, Warning, High Voltage Comment: (Electric)
22	13541	PLUG, Male Comment: (Manual)
23	37-881865	DECAL, Caution-Start in Gear Comment: (Start In Gear) (Electric)

▶Fuel Pump (57 parts)

Ref	OEM Part #	Part Name
-	27-43004A99	GASKET SET, Powerhead
1	NSS	NOT SOLD SEPARATE, Fuel Pump
2	21-857005A1	DIAPHRAGM KIT
3	NSS	NOT SOLD SEPARATE, Check Valve
4	NSS	NOT SOLD SEPARATE, Retainer
5	NSS	NOT SOLD SEPARATE, Spring
6	NSS	NOT SOLD SEPARATE, Cap
7	NSS	NOT SOLD SEPARATE, Gasket-Boost
8	NSS	NOT SOLD SEPARATE, Cap
9	NSS	NOT SOLD SEPARATE, Spring
10	NSS	NOT SOLD SEPARATE, Gasket-Pulse
11	NSS	NOT SOLD SEPARATE, Diaphragm
12	27-8M0204705	GASKET
13	144303	BASE
14	987752	PLATE
15	22-996642	FITTING, Elbow 90 Degree (.125-27 x .250) Nylon
16	10-82104540	SCREW, (M5 x 40)
17	10-82130050	SCREW, (M6 x 50)
18	8M0214940	TIE STRAP, (5.50 Inches)
19	32-897930	Hose, Molded
20	22-291112	FITTING Comment: (To Crankcase)
21	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 2.00 Inch Length) Comment: (Oil Injection)(To Carburetor)
22	32-19017A1	LINE ASSEMBLY, Fuel Comment: (Oil Injection)
23	35-816296Q2	FILTER, Fuel Comment: (Oil Injection)
24	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 6.00 Inch Length) Comment: (Non Oil Injection)
25	32-822554	MOLDED HOSE Comment: (Oil Injection)
26	19-822772	PLUG, Non Commercial Engines Comment: (Oil Injection)
27	22-8189941	CHECK VALVE (Oil Injection) Comment: (Oil Injection)(To Oil Pump)
28	22-816856Q3	CONNECTOR ASSEMBLY, Fuel Comment: (Design I)
29	25-16524	O-RING, Fuel Connector Comment: (Design I)
30	10-4010635	SCREW, (M6 x 35) Stainless Steel Comment: (Design I)
31	25-145091	GROMMET Comment: (Design I)
32	22-822769	CONNECTOR Comment: (Design II)
33	32-85682257	TUBING, (26.00 Inches Bulk) (Cut to 4.00 Inch Length) Comment: (Design II)
34	25-145093	GROMMET Comment: (Design II)
35	89-819503A1	SOLENOID ASSEMBLY, Enrichner Valve Comment: (Electric)
36	32-1430165	TUBING, (38.00 Inches Bulk) (Cut to 15.00 Inch Length) Comment: (Electric)
37	32-9912688	TUBING, (36.00 Inches Bulk) (Cut to 11.50 Inch Length) Comment: (Electric)
38	54-188871	CLAMP Comment: (Electric)
39	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 17.00 Inch Length) Comment: (Non Oil Injection)(To Carburetor)
40	32-83476463	TUBING, (32.00 Inches Bulk) (Cut to 13.00 Inch Length) Comment: (Non Oil Injection)
41	23-83312531	INSULATING SLEEVE Comment: (Non Oil Injection)
42	35-826634T01	FILTER, Fuel Comment: (Non Oil Injection)
43	827961	BRACKET Comment: (Non Oil Injection)
44	10-82129114	SCREW, (M6 x 14) Comment: (Non Oil Injection)
45	10-4010630	SCREW, (M6 x 30) Stainless Steel Comment: (Non Oil Injection)
46	12-8M0214930	WASHER Comment: (Non Oil Injection)
47	23-42116	BUSHING Comment: (Non Oil Injection)
48	25-42117	GROMMET Comment: (Non Oil Injection)
49	858763	PRIMER BULB Comment: (Manual)
50	22-59169003	FITTING, Tee Comment: (Manual)
51	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 6.00 Inch Length) Comment: (Manual)
52	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 9.50 Inch Length) Comment: (Manual)
53	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 2.50 Inch Length) Comment: (Manual)(To Top Carburetor)
54	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 2.50 Inch Length) Comment: (Manual)
55	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 2.50 Inch Length) Comment: (Manual)(To Center Carburetor)
56	32-892024122	TUBING, (240.00 Inches Bulk) (Cut to 6.00 Inch Length) Comment: (Manual)(To Bottom Carburetor)

▶Gasket Set Components, Powerhead Overhaul (1 parts)

Ref	OEM Part #	Part Name
-	25-858225	O-RING (2.112)

▶Gear Housing(Driveshaft 2.31:1) (43 parts)

Ref	OEM Part #	Part Name
-	47-8M0100526	REPAIR KIT, Water Pump Impeller
1	1667-9011G59	GEAR HOUSING ASSEMBLY, Basic, Torpedo Diameter - 4.25 Inch / 107.95 mm
2	17-8M0084244	PIN, Dowel - With Hole (.375 x .625) , Front
3	43046	TUBE, Oiler
4	22-8M0058389	FITTING KIT, Magnetic, Plug Fill/Drain Comment: (Magnetic)
5	12-191833	WASHER
6	17-43044	PIN, Dowel - Without Hole (.375 x .625), Rear
7	31640T07	TRIM TAB
8	10-825427	SCREW, (.437-14 x 1.250) Stainless Steel
9	12-451761	WASHER, (.453 x .812 x .105) Black Oxide
10	43040T1	CARRIER ASSEMBLY
11	NSS	NOT SOLD SEPARATE, Needle Bearing
12	97-826134Q	ANODE
13	11-401386	NUT, (M6) Stainless Steel
14	10-4000333	SCREW, (M6 x 40)
15	NSS	NOT SOLD SEPARATE, Pinion Gear (12 Teeth) Comment: (Part of 43-882813A 3)
16	11-35921	NUT, (.625-18)
17	850307	CAM, Shift Control
18	31-883047A1	BEARING ASSEMBLY, Tapered Roller
19	15-44492A1	SHIM SET
20	45-43032A4	DRIVESHAFT ASSEMBLY Comment: (XL -36.915 Inch)
21	42461A1	SLEEVE/RING KIT
22	NSS	NOT SOLD SEPARATE, Seal Ring
23	43055A4	COVER ASSEMBLY, Water Pump
24	27-430331	GASKET
25	27-8M0214931	GASKET
26	26-43036	SEAL, Oil, Lower
27	26-43035	SEAL, Oil, Upper
28	27-8172771	GASKET
29	817275A2	HOUSING KIT, Upper Water Pump
30	8M0204709	FACEPLATE
31	10-82684430	SCREW, (M6 x 30)
32	430232	SEAL
33	28-8M0204723	KEY
34	47-43026T2	IMPELLER
35	10-82684425	SCREW, (M6 x 25)
36	853908A1	SHIFT SHAFT ASSEMBLY Comment: (XL-17 Inch)
37	53-29641	E RING
38	23-43052A4	BUSHING ASSEMBLY
39	25-8M0204681	O-RING, (1.424 x .103)
40	26-8M0204708	SEAL, Oil
41	10-82684425	SCREW, (M6 x 25)
42	26-861415	FACE SEAL

▶Gear Housing, Propeller Shaft - 2.31:1 Gear Ratio (30 parts)

Ref	OEM Part #	Part Name
-	27-13461A99	GASKET SET
1	1667-9011G59	GEAR HOUSING ASSEMBLY, Basic, Torpedo Diameter - 4.25 Inch / 107.95 mm
2	31-30894A1	BEARING SET, Cup And Cone
3	NSS	NOT SOLD SEPARATE, Cup
4	43-882813A3	GEAR KIT, Forward And Pinion 28 Teeth
5	31-30895T	BEARING, Needle
6	53-856823	RING, Retaining
7	850315A1	FOLLOWER KIT, Cam
8	30-44530	BALL
9	NSS	NOT SOLD SEPARATE, Slide
10	24-850327	SPRING
11	17-8M0100263	PIN, Cross
12	24-30893	SPRING
13	52-850048T	CLUTCH
14	44-8M0140445	PROPELLER SHAFT
15	43-882814T	GEAR, Reverse - 28 Teeth
16	8M0168901	CARRIER ASSEMBLY, Bearing
17	25-8M0214974	O-RING, (3.609 x .139)
18	31-30956T	BEARING, Needle
19	26-8M0205728	SEAL, Oil, Inner
20	26-8M0205729	SEAL, Oil, Outer
21	31-12578T	BEARING, Roller
22	12-12577	THRUST WASHER
23	31-12576	BEARING, Thrust
24	16-8M0034456	STUD, (M8 x 48)
25	12-855941	WASHER, (.323 x .590 x .112) Stainless Steel
26	11-401378	NUT, (M8)
27	15-44491A1	SHIM SET
28	8227731	INSERT, Threaded
29	NSS	NOT SOLD SEPARATE, Decal-Pinion Indentification

▶Induction Manifold and Reed Block (40 parts)

Ref	OEM Part #	Part Name
-	809837T97	POWERHEAD ASSEMBLY Comment: (Oil Injection)
1	42878A2	COVER/PLATE KIT, Exhaust
2	NSS	NOT SOLD SEPARATE, Baffle Plate
3	27-43004009	GASKET
4	10-82127335	SCREW, (M8 x 35 MM)
5	22-996642	FITTING, Elbow 90 Degree (.125-27 x .250) Nylon
6	27-430075	GASKET
7	42881A1	SHIFT RAIL ASSEMBLY
8	14-42981	TAB WASHER
9	10-40001134	SCREW, (M8 x 25)
10	988851	SLIDE
11	11-401386	NUT, (M6) Stainless Steel
12	12-35459	WASHER
13	11-401386	NUT, (M6) Stainless Steel
14	1169-858552T2	CAP ASSEMBLY, Lower End
15	21-426585	CHECK VALVE
16	26-419533	SEAL, Oil
17	25-89224	O-RING
18	10-4010825	SCREW, (M10 x 25) Hex Flange - Stainless Steel
19	8M0219198	REED BLOCK ASSEMBLY
20	NSS	NOT SOLD SEPARATE, Dowel Pin
21	27-139376	GASKET
22	34-43018A1	REED SET
23	14-429821	TAB WASHER
24	42924	RETAINER
25	10-88421471	SCREW, (M6 x 16)
26	827514	BRACKET Comment: (Oil Injection)
27	12-8M0204663	WASHER, (.187 x .500 x .062) Neoprene
28	11-816872	WING NUT
29	16-8161949	STUD, (M6 x 44)
30	884296T	MANIFOLD, Induction
31	10-82127335	SCREW, (M8 x 35 MM)
32	10-81742740	SCREW, (M8 x 40)
33	16-824470	STUD, (M8 x 1.25)
34	10-40001167	SCREW, (M8 x 110) (#3 CYLINDER)
35	32-8M0108349	TUBING, (.312) (70.00 Inches Bulk) (Cut to 4.00 Inch Length)
36	22-8585531	CONNECTOR Comment: (Manual)
37	22-996642	FITTING, Elbow 90 Degree (.125-27 x .250) Nylon
38	54-816311T	TIE STRAP, (8.00 Inches)
39	NSS	NOT SOLD SEPARATE, DECAL, EPA (2009 & Up) Comment: (Contact Mercury Marine Warranty Administration for Replacement-Service Bulletin 2009-18)

▶Jet Pump Assembly (32 parts)

Ref	OEM Part #	Part Name
-	856143A1	JET PUMP ASSEMBLY
1	855767T90	HOUSING, Pump
2	878377	SHIFT LINKAGE KIT
3	878382	CAM
4	878380	GATE, Reverse - With Bumper
5	32-827490	HOSE, Lube
6	10-848497	SCREW, (.312-18 x 1.00)
7	16-855840	STUD, (.312-18 x 1.81)
8	11-82670910	NUT, (.312-18) Stainless Steel
9	47-855708115	IMPELLER
10	85576890	HOUSING, Intake
11	855771	LINER
12	45-85576990	DRIVESHAFT
13	12-8796522	THRUST WASHER
14	30-8796531	BEARING, Ball
15	23-8271891	SLEEVE
16	11-8271901	NUT
17	808747	ADAPTOR, Pump
18	12-36001	WASHER
19	28-801405875	KEY
20	15-801404875	SHIM, Impeller
21	14-801403875	TAB WASHER
22	17-801407	PIN, Dowel
23	10-19923062	SCREW, (.250-20 x .625)
24	10-60411	SCREW, (.312-18 x 1.250)
25	801410	BRACKET, Cable Support
26	11-82670910	NUT, (.312-18)
27	10-4010860	SCREW, (M10 x 60) Hex Flange - Stainless Steel
28	10-4010890	SCREW, (M10 x 90) Hex Flange - Stainless Steel
29	10-4010870	SCREW, (M10 x 70) Hex Flange - Stainless Steel
30	10-843575	SCREW, (.375-16 x 4.00) Stainless Steel
31	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel

▶Jet Pump Componets (10 parts)

Ref	OEM Part #	Part Name
-	27-43004A99	GASKET SET, Powerhead
1	817275A2	HOUSING KIT, Upper Water Pump
2	27-8172771	GASKET
3	8M0204709	FACEPLATE
4	10-82684430	SCREW, (M6 x 30)
5	430232	SEAL
6	28-8M0204723	KEY
7	47-43026T2	IMPELLER
8	821889A50	REV LIMITER
9	10-82130030	SCREW, (M6 x 30)

▶Key Chart (1 parts)

Ref	OEM Part #	Part Name
-	8949112	KEY, Ignition (2F)

▶Lube Chart (0 parts)

▶Manual Tilt Assist Components (11 parts)

Ref	OEM Part #	Part Name
-	25-893922A01	O-RING KIT
1	893932A01	SHOCK ROD ASSEMBLY
2	25-893917A01	O-RING KIT, Cylinder
3	893903A01	PISTON ASSEMBLY, Trim Memory
4	893934A01	CYLINDER ASSEMBLY
5	893919A01	SCREW AND SEAL KIT
6	893933A01	ACCUMULATOR ASSEMBLY
7	893921A01	VALVE BODY ASSEMBLY
8	893923A01	CAM KIT
9	893924A01	VALVE KIT, Velocity
10	893925A01	REPAIR KIT

▶Oil Injection Components (28 parts)

Ref	OEM Part #	Part Name
-	27-43004A99	GASKET SET, Powerhead
1	1277-8M0219216	TANK ASSEMBLY, Oil
2	828475A1	CAP
3	25-26318T	O-RING
4	828793	DIPSTICK
5	11-65110	NUT
6	19299A1	VENT ASSEMBLY
7	21-64871	VALVE
8	8287201	BRACKET
9	99160001	BOOT
10	10-4010620	SCREW, (M6 x 20) Stainless Steel
11	25-825380001	GROMMET
12	23-828350	BUSHING
13	12-4002318	WASHER
14	10-81893435	SCREW, (M8 x 35)
15	87-12886A6	SWITCH ASSEMBLY
16	10-58376	SCREW, (.164-18 x .375)
17	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel
18	43-430204	GEAR, Driven
19	25-8M0204667	O-RING
20	17335A3	ADAPTOR ASSEMBLY
21	23-17597	BUSHING
22	23-17596	BUSHING
23	42959A2	PUMP ASSEMBLY, Oil
24	10-82104540	SCREW, (M5 x 40)
25	32-82381335	TUBING, (15.00 Inches Bulk) (Cut to 6.00 Inch Length) Comment: A=To Fuel Pump
26	32-82381455	TUBING, (25.00 Inches Bulk) (Cut to 11.00 Inch Length)
27	8M0214940	TIE STRAP, (5.50 Inches)

▶Power Trim Assembly - Components, 2B092563 and Up (19 parts)

Ref	OEM Part #	Part Name
-	25-8M0171820	O-RING KIT, Power Trim
1	8M0089943	MANIFOLD KIT
2	893929A01	VALVE KIT, Relief
3	8M0089945	VALVE KIT
4	8M0090404	VALVE KIT - (TRIM LIMIT)
5	833063	O-RING
6	8M0055260	DOWEL PINS
7	19-811613	PLUG ASSEMBLY
8	10-833047	SCREW, (.250-20 x 2.250)
9	8M0089941	CYLINDER ASSEMBLY
10	8M0207768	CABLE ASSEMBLY
11	8M6002690	SCREW
12	8M0171822	PISTON ASSEMBLY, Memory
13	25-8M0171819	O-RING KIT
14	8M0171821	SHOCK ROD KIT
15	10-8M0089946	SCREW KIT (COMPLETE TRIM)
16	8M0142591	MOTOR KIT
17	8M0090403	COUPLING / DRIVESHAFT KIT
18	8M0089944	PUMP ASSEMBLY

▶Power Trim Assembly, 2B092563 and Up (10 parts)

Ref	OEM Part #	Part Name
1	8M0171818	POWER TRIM ASSEMBLY
2	17-8M0161312	PIN, Shock Rod
3	17-821539	PIN, Trilobe
4	17-818898	PIN, Anchor
5	84-8M0092077	HARNESS ASSEMBLY, Trim
6	8M0207773	RELAY ASSEMBLY
7	828102	BRACKET
8	23-8M0214955	BUSHING
9	25-818967	GROMMET
10	10-82129125	SCREW, (M6 x 25 MM)

▶Power Trim Components, 2B092562 and Below (26 parts)

Ref	OEM Part #	Part Name
-	25-893914A02	O-RING KIT (COMPLETE TRIM)
1	8M0171821	SHOCK ROD KIT
2	25-8M0171819	O-RING KIT, Rebuild
3	8M0171822	PISTON ASSEMBLY, Memory
4	893916A01	CYLINDER ASSEMBLY
5	893905A02	VALVE KIT, Trim Limit
6	893906A02	PUMP ASSEMBLY
7	893907A02	MOTOR KIT
8	22-8134351	PLUG
9	893929A01	MANUAL RELEASE ASSEMBLY
10	893909A02	MANIFOLD KIT
11	10-809876A1	SCREW KIT, Motor
12	88238A18	CABLE ASSEMBLY
13	809877A1	DRIVESHAFT/SEAL KIT
14	35-893912A02	FILTER KIT
15	893913A02	POPPET KIT
16	8M0207773	RELAY ASSEMBLY
17	23-8M0214955	BUSHING
18	25-818967	GROMMET
19	828102	BRACKET
20	NSS	NOT SOLD SEPARATE, Decal, Trim Relay
21	84-8M0092077	HARNESS ASSEMBLY, Trim
22	10-82129125	SCREW, (M6 x 25 MM)
23	54-22740	CLIP
24	10-878609	SCREW, (#10-16 x .600)
25	8M0084613	C WASHER

▶Service/Support Material (1 parts)

Ref	OEM Part #	Part Name
-	NSS	NOT SOLD SEPARATE, DECAL, EPA (2009 & Up) Comment: (Contact Mercury Marine Warranty Administration for Replacement-Service Bulletin 2009-18)

▶Starter Assembly(Manual) (44 parts)

Ref	OEM Part #	Part Name
-	816728T14	STARTER ASSEMBLY, Recoil
1	85174A2	HANDLE ASSEMBLY
2	NSS	NOT SOLD SEPARATE, Retainer
3	8220721	REST
4	8M0043270	SEAL
5	10-82130050	SCREW, (M6 x 50)
6	23-8217021	SPACER
7	23-816086	BUSHING
8	25-815795	GROMMET
9	12-69057	WASHER, (.281 x .734 x .063) Comment: (Quantity of 2 used in Front. Quantity of 4 used in Back)
10	855596	BRACKET
11	855597	BRACKET
12	10-40011129	SCREW, (M6 x 25) Stainless Steel
13	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel
14	11-401386	NUT, (M6) Stainless Steel
15	11704A1	PULLEY KIT
16	NSS	NOT SOLD SEPARATE, Spacer
17	12-67983	WASHER
18	8567541	CABLE, Interlock
19	10-8214281	SCREW, (#10-16 x .625)
20	12-73288	WASHER, (.220 x .500 x .030) Stainless Steel
21	18-26811	COTTER PIN
22	10-878608	SCREW, (#10-16 x .500)
23	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel
24	18-26811	COTTER PIN
25	24-826791	SPRING
26	8166903	LEVER
27	816712T01	CAM
28	816711	RETAINER
29	10-8182491	SCREW, (#10-16 x 1.00)
30	13-826229	LOCKWASHER
31	24-86857T01	SPRING
32	50-825269T01	SHEAVE, Starter
33	24-86851T02	SPRING
34	868501	CAM
35	53-86849T01	RING, Retaining
36	50-12066Q10	ROPE
37	816728T05	HOUSING
38	24-868523	SPRING
39	86853T01	CAM
40	10-826253	SCREW, (.250-20 x .625)
41	8M0183792	BUSHING
42	53-818853	RING, Retaining
43	NSS	NOT SOLD SEPARATE, Decal-Manual Start

▶Starter Motor, Service (14 parts)

Ref	OEM Part #	Part Name
-	50-893891T	STARTER MOTOR ASSEMBLY
1	90643	DRIVE KIT
2	685753	DRIVE ASSEMBLY
3	75660	PLATE
4	10-75385	BOLT
5	75386	ARMATURE
6	898265016	BRUSH/SPRING KIT
7	23-57387	BUSHING
8	NSS	NOT SOLD SEPARATE, Washer (AMER. BOSCH #WA-1728)
9	13-26992	LOCKWASHER, (.250) Stainless Steel
10	11-20890	NUT, (.250-20)
11	898265014	HOLDER
12	NSS	NOT SOLD SEPARATE (AMER. BOSCH #02441-22-SC-30SM DRIVE TIGHT
13	15386001	END CAP

▶Steering Handle (36 parts)

Ref	OEM Part #	Part Name
NS	22-8M0169589	FITTING, Grease
1	12020A3	HANDLE ASSEMBLY, Steering Arm
2	23-42992T02	BUSHING
3	48414	HOUSING
4	48519	PLATE
5	27-48518	GASKET
6	10-878609	SCREW, (#10-16 x .600)
7	10-878608	SCREW, (#10-16 x .500)
8	54-889729	CLAMP
9	10-40007112	SCREW, (M5 x 40)
10	10-32,11-816874	WING NUT,
12	87-823609A15	SWITCH KIT, Stop - Throttle Handle
13	87-8M0104612	SWITCH ASSEMBLY, Stop
14	12018A4	TUBE ASSEMBLY, Throttle
15	NSS	NOT SOLD SEPARATE, Drive Wheel
16	NSS	NOT SOLD SEPARATE, Roll Pin
17	10-62568	SCREW, (#10-16 x .375)
18	8M0221732	GRIP
19	54-648551	CLAMP
20	11-40140	NUT, (M10)
21	8885242	CONDUIT
22	8M0026078	GUIDE TUBE
23	89578	BARREL
24	10-32,10-824081	SET SCREW,
25	12019	CABLE ASSEMBLY
26	8M0204660	GUIDE
27	20007	ANCHOR
28	8-32,10-8M0204644	SET SCREW,
29	10-823567105	SCREW, (M10 x 105) Hex Flange - Stainless Steel
30	48416	CAP
31	12-4002319	WASHER
32	12-12024	WASHER, (.402 x .787 x .039 Bellevi)
33	23-146011	SPACER
34	12-8M0214963	WASHER, (.406 x .750 x .105) Stainless Steel Comment: (Use Where Applicable)
35	54-816311T	TIE STRAP, (8.00 Inches)
36	NSS	NOT SOLD SEPARATE, Decal-Throttle

▶Steering Handle Components (47 parts)

Ref	OEM Part #	Part Name
1	12022A22	BRACKET ASSEMBLY
2	10-849838	SCREW, (.375-24 x 1.250)
3	11-8M0204726	NUT, (.375-24) Stainless Steel
4	16-8M0034421	STUD, (.3125 x 2.50)
5	822263	SPACER
6	12-8M0204690	WASHER, (.344 x .688 x .065) Stainless Steel
7	11-82670911	NUT, (.312-24) Stainless Steel
8	121051	GROMMET
9	84-12649A5	HARNESS ASSEMBLY Comment: (Electric)
10	87-88107A5	SWITCH KIT, Key Comment: (Reference Key Chart Section for Key)(Electric)
11	11-879755	NUT, Special - Black Nylon Comment: (Black Nylon) (Electric)
12	13541	PLUG, Male Comment: (Electric)
13	12015A1	COVER
14	10-878608	SCREW, (#10-16 x .500)
15	19-889730	PLUG Comment: (Manual Tilt Assist)
16	87-11083A4	SWITCH ASSEMBLY, Stop
17	15920Q54	LANYARD ASSEMBLY
18	8M0032846	RETAINER, Brass
19	10-4000358	SCREW, (M8 x 50)
20	14-42981	TAB WASHER
21	23-889732	BUSHING
22	12021A1	LEVER ASSEMBLY, Shift
23	12-815351	WASHER
24	16-8M0034452	STUD, (.375-24 x 1.125)
25	98530	KNOB
26	495636	SHIFT ROD
27	48419T	ROD END
28	23-26856	BUSHING
29	12-35950	WASHER, (.273 x .437 x .031) Stainless Steel
30	18-25191	COTTER PIN
31	12016A2	DETENT/SPRING KIT
32	NSS	NOT SOLD SEPARATE, Spring
33	87-14645A4	TRIM SWITCH Comment: (Power Trim)
34	49440	NUT, (.468-32) Comment: (Power Trim)
35	NSS	NOT SOLD SEPARATE, Decal Comment: (Power Trim)
36	84-815851A2	HARNESS ASSEMBLY, Stop Comment: (Manual Tilt Assist)
37	84-821028A2	CABLE ASSEMBLY Comment: (Manual Tilt Assist)
38	815803	PLUG Comment: (Manual Tilt Assist)
39	816051A2	HORN ASSEMBLY
40	84-11149A3	CABLE ASSEMBLY
41	84-86324A2	CABLE ASSEMBLY Comment: (Electric)
42	824930T2	BRACKET
43	87-8M0052927	SWITCH
44	10-88075020	SCREW, (M3 x 20)
45	824923	PLATE
46	84-824934A3	HARNESS ASSEMBLY
47	NSS	NOT SOLD SEPARATE, Decal-Shift

▶Swivel Bracket and Steering Arm (19 parts)

Ref	OEM Part #	Part Name
1	1400-8M0220957	SWIVEL BRACKET
2	26-87735	SEAL, Oil, Lower
3	23-818764	BUSHING
4	25-8M0214926	O-RING
5	23-816039	SPACER
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING
8	10-64014	SCREW, (.250-28 x .500)
9	12-816432	THRUST WASHER
10	99661A35	SWIVEL PIN ASSEMBLY
11	92876A12	LINK ROD ASSEMBLY
12	10-849838	SCREW, (.375-24 x 1.250)
13	11-8M0204726	NUT, (.375-24) Brass
14	12-37828	WASHER, (.390 x .625 x .062) Stainless Steel
15	11-8M0204726	NUT, (.375-24) Stainless Steel
16	8M0000519	BUMPER
17	881914T01	YOKE, Bottom
18	53-67684	RING, Retaining
19	11288001	BUMPER, Bottom Yoke (X-Long)

▶Throttle Lever and Linkage (27 parts)

Ref	OEM Part #	Part Name
1	42946T1	LEVER, Throttle
2	10-827008	SCREW, (M5 x 35)
3	826264	CAP
4	24-826382	SPRING
5	429471	LEVER, Spark Advance
6	10-814776	SCREW, Adjusting (M6 x 55)
7	11-400212	NUT, (M6) Stainless Steel
8	42942	CAP
9	93254	SWIVEL BASE
10	93421	SWIVEL BALL
11	878172	ROD, Spark Advance
12	23-812930A1	BUSHING
13	NSS	NOT SOLD SEPARATE, Insert
14	10-4007180	SCREW, (M10 x 45)
15	12-42980	WASHER
16	24-55162	SPRING
17	42927	INSERT
18	12-35459	WASHER
19	11-401386	NUT, (M6) Stainless Steel
20	878420T	ROD, Throttle
21	23-8M0215006	BUSHING
22	42948A7	CAM ASSEMBLY, Throttle
23	16-8161949	STUD, (M6 x 44)
24	24-14159	SPRING
25	12-69056	WASHER, (.255 x .620 x .030) Stainless Steel
26	11-401386	NUT, (M6) Stainless Steel
27	NSS	NOT SOLD SEPARATE (Decal-Idle Screw-Arrow up)

▶Tiller Handle Adaptor Kit(Jet 65) (20 parts)

Ref	OEM Part #	Part Name
-	850000A3	TILLER HANDLE ADAPTOR KIT
1	832001A6	CABLE ASSEMBLY, Shift
2	11-401386	NUT, (M6) Stainless Steel
3	988851	SLIDE
4	828095	BRACKET
5	824930T2	BRACKET
6	54-8054441	CLIP
7	10-40011126	SCREW, (M6 x 13) Stainless Steel
8	828096	BLOCK, Shift Cable-Retaining
9	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
10	10-71958	SCREW, (.250-28 x 1.75)
11	13-26992	LOCKWASHER, (.250) Stainless Steel
12	828094	BLOCK, Shift Cable-Retaining
13	10-72734	SET SCREW, (#10-32 x .310)
14	12-35459	WASHER
15	11-35888	NUT, (.250-28) Stainless Steel
16	87-8M0052927	SWITCH
17	10-88075020	SCREW, (M3 x 20)
18	824923	PLATE
19	84-824934A1	CABLE ASSEMBLY

▶Tools, SPECIAL (1 parts)

Ref	OEM Part #	Part Name
-	91-14310T1	WEAR SLEEVE INSTALLATION TOOL Comment: (Gear Housing)

▶Top Cowl (24 parts)

Ref	OEM Part #	Part Name
1	100-8M0107148	TOP COWL ASSEMBLY Comment: (Silver-Manual)
2	828716A2	CAP
3	828352	SEAL
4	8283511	SEAL
5	821875F2	CAP, Upper Comment: (Silver)
6	819813T1	BRACKET, Cover Latch
7	893763	BRACKET ASSEMBLY, Latch Roller
8	13-53166	LOCKWASHER, (.312)
9	10-90285	SCREW, (.312-18 x .625)
10	F481434	GUIDE, Cowl Latch Bracket
11	11-91925	PUSH NUT
12	10-822512	SCREW, (.250-20 x 1.00)
13	19-823865	CAP PLUG
14	10-82130016	SCREW, (M6 x 16)
15	823830	SUPPORT
16	10-8231871	SCREW, (M4 x 14.5)
17	8,13-26995	LOCKWASHER, Stainless Steel
18	8233941	BRACKET
19	11-8237515	NUT, (M4)
20	823685A02	SOUND BLANKET KIT, (Pre-Applied Pressure Sensitive Adhesive)
21	NSS	NOT SOLD SEPARATE, Sound Blanket Comment: (Electric)
22	47341A11	ROPE AND HANDLE KIT, Manual Starting
23	NSS	NOT SOLD SEPARATE, Starter Rope
24	NSS	NOT SOLD SEPARATE, Envelope

▶Transom Bracket (42 parts)

Ref	OEM Part #	Part Name
1	3426-828334T02	BRACKET, Transom Comment: (Starboard)
2	3425-828333T07	BRACKET ASSEMBLY, Transom Comment: (Port)
3	22-8M0169588	FITTING, Grease Comment: (Port)
4	826125A1	TILT TUBE Comment: (Stainless Steel)
5	11-826135	NUT, (1.00-14) Nylon Insert Comment: (Brass)
6	25-45711	O-RING, (.612 x .103)
7	13-88750	WASHER
8	11-826164	NUT, (.875-14) Comment: (Brass)
9	10-8M0149747	SCREW, (.500-20 x 4.500)
10	12-8M0204665	WASHER, (.530 x .870 x .105) Stainless Steel
11	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel
12	11-82671117	NUT, (.500-20)
13	24-830899	SPRING, Tension
14	8M0109798	LEVER ASSEMBLY, Tilt Lock
15	23-65830	NYLINER
16	24-830900	SPRING, Compression
17	99633	KNOB
18	17-99615	PIN, Groove
19	17-893709	PIN
20	8M0086406	BRACKET, Anchor
21	10-858771	SCREW, (M10 x 30)
22	12-4002319	WASHER
23	11-40114	NUT, (M10 x 1.5)
24	97-818298Q1	ANODE
25	10-8M0204707	SCREW, (M6 x 25)
26	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
27	54-22740	CLIP Comment: (Power Trim Model)
28	8M0084613	C WASHER Comment: (Power Trim Model)
29	10-878609	SCREW, (#10-16 x .600) Comment: (Power Trim Model)
30	8M0171818	PUMP ASSEMBLY, Power Trim Comment: (See Power Trim Components for parts breakdown)
31	17-8M0026068	PIN ASSEMBLY, Tilt Lock Comment: (Manual Tilt)
32	37-830253	DECAL, Tilt Lock Comment: (Manual Tilt)
33	11-826709110	NUT, (.312-18) Stainless Steel
34	8353511	LINK ROD Comment: (Manual Tilt)
35	832042	ARM Comment: (Manual Tilt)
36	23-832040	BUSHING Comment: (Manual Tilt)
37	832039	LEVER, Tilt Comment: (Manual Tilt)
38	8M0007469	TILT KNOB Comment: (Manual Tilt)
39	835249T1	MANUAL TILT ASSEMBLY Comment: (See Manual Tilt Components for parts breakdown)
40	99625002	SHAFT, Upper
41	17-818898	PIN, Anchor
42	17-821539	PIN, Trilobe

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury 75 (3 CYL.) running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Popular Products

Popular Products

Popular Products

Mercury 75 (3 CYL.) (1B000000 & Up) Parts & Diagrams

Categories

Refined By Clear all

Brand

Horsepower

Engine

Availability

Price

Need Help?

Images

Product

Price

Qty

Options