Mercury V-200 (0C100861 THRU 0C291519) Parts & Diagrams

🔎 Mercury V-200 Reference Library — Exploded parts diagrams (28 diagrams), specifications, common issues, and maintenance checklist.

The Mercury V-200 is a 2-Stroke EFI, V6 60-degree outboard motor. Designed for large center-consoles, offshore sport-fishing boats, and multi-engine configurations.

Quick Reference Specifications

Specification	Value
Engine Type	2-Stroke EFI, V6 60-degree
Horsepower	200 HP
Displacement	2507 cc (2.5L / 153 CID)
Bore x Stroke	89 mm x 67 mm (3.501 in. x 2.650 in.)
Spark Plug (Type & Gap)	NGK BPZ8HS-10
Engine Oil Capacity	—
Recommended Engine Oil	Mercury 2-Stroke Outboard Oil (TCW-3)
Gear Case Oil Capacity	802 mL (27.1 oz)
Idle Speed (in gear)	650–700 RPM (in gear)
Full Throttle RPM Range	5000-5600
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury V-200:

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury V-200.

▶BOTTOM COWL (42 parts)

Ref	OEM Part #	Part Name
-	813096A1	REAR LATCH KIT
1	2197-9744A16	BOTTOM COWL Comment: (PORT) (GRAY) SN# 0C239553 & Up
2	2197-9745A6	BOTTOM COWL Comment: (STBD) (GRAY) SN# 0C239553 & Up
3	18701A1	SEAL KIT, BOTTOM COWLS
3A	21-817519A1	CHECK VALVE
4	10-18699	SCREW, (.250-20 x 1.320), COWL Comment: (STARBOARD)
5	18872A2	COVER ASSEMBLY Comment: (GRAY)
6	11-8136921	LOCKNUT
7	54-816311T	TIE STRAP
8	18727	ROD
9	23-65830	NYLINER
10	23-19666	BUSHING
11	13-99611	WAVE WASHER
12	12-69057	WASHER, (.281 x .734 x .063)
13	10-18192	SCREW, (.250-20 x .620)
14	19648A2	HANDLE ASSEMBLY (PORT) Comment: (GRAY)
15	19647A3	HANDLE ASSEMBLY (STARBOARD) Comment: (GRAY)
16	19370	PAWL (PORT)
17	19369	PAWL (STARBOARD)
18	10-73286	SCREW, (.250-20 x .500) Stainless Steel
19	54-19749	CLAMP, UPPER
20	54-197481	CLAMP, LOWER
21	10-92799	SCREW, (#10-16 x 1.12)
22	84-16636A1	HARNESS ASSEMBLY, TRIM Comment: SN# 0C239552 & Below
23	10-72202	SCREW, (#10-32 x 1.25) Comment: SN# 0C239552 & Below
24	12-8M0204666	WASHER, (.203 x .500 x .032) Comment: SN# 0C239552 & Below
25	10-32,11-8M0204718	NUT, Comment: SN# 0C239552 & Below
26	84-16639A1	HARNESS ASSEMBLY Comment: SN# 0C239552 & Below
27	88-8M0207796	FUSE, 20 Ampere Comment: SN# 0C239552 & Below
28	84-95084A2	CABLE ASSEMBLY, FUSE Comment: SN# 0C239552 & Below
29	22-813613	FITTING, TELLTALE
30	22-90824001	TEE, TELLTALE
31	32-8M0108355	LINE, (57.00 Inches Bulk), TELLTALE
32	8130762	FRONT HANDLE ASSEMBLY
33	813925	HANDLE LOCK
34	813926	HANDLE
35	24-8139291	SPRING
36	10-69079	SCREW, (#10-16 x .440)
37	17-815296	PIN, Lock
38	13-26992	LOCKWASHER, (.250) Stainless Steel
39	87-8M0042301	SWITCH ASSEMBLY Comment: SN# 0C239553 & Up
40	8M0032848	RETAINER, SWITCH Comment: SN# 0C239553 & Up

▶CARBURETOR ASSEMBLY (29 parts)

Ref	OEM Part #	Part Name
-	1395-7826	REPAIR KIT, CARBURETOR
1	1374-9242T44	CARBURETOR (BOTTOM)
2	1399-6249	JET, Main (.096)
3	NSS	NOT SOLD SEPARATE, GASKET, COVER PLATE
4	1395-6032	PLATE, COVER
5	1395-9597	SCREW, COVER PLATE
6	1395-7822	BOWL, Fuel (CENTER/BOTTOM)
7	NSS	NOT SOLD SEPARATE, SCREW, FUEL BOWL
8	1395-6025	PLUG, MAIN JET
9	NSS	NOT SOLD SEPARATE, GASKET, MAIN JET
10	1399-3518	JET, (.082), MAIN FUEL
11	NSS	NOT SOLD SEPARATE, SCREWM FLOAT PIN
12	NSS	NOT SOLD SEPARATE, GASKET, INLET NEEDLE AND SEAT
13	1395-7824	NEEDLE/SEAT ASSEMBLY, Inlet
14	NSS	NOT SOLD SEPARATE, GASKET, NOZZLE BOSS
15	1395-9267	FLOAT
16	NSS	NOT SOLD SEPARATE, PIN, FLOAT LEVER
17	NSS	NOT SOLD SEPARATE, GASKET, FUEL BOWL
18	1395-4541	SCREW, IDLE AIR BLEED JET
19	NSS	NOT SOLD SEPARATE, GASKET, BLEED JET PLUG
20	1399-5213	JET, Main (.056), IDLE AIR BLEED (.056)
21	1395-6027	SCREW, THROTTLE LEVER
22	87607	LEVER, Throttle
23	NSS	NOT SOLD SEPARATE, SPRING, THROTTLE RETURN
24	1395-6031	SPACER, THROTTLE LEVER
25	1395-6022	SHAFT, THROTTLE
26	NSS	NOT SOLD SEPARATE, RING, RETAINER - THROTTLE SHAFT
27	1395-9416	VALVE, Throttle
28	NSS	NOT SOLD SEPARATE, SCREW, THROTTLE VALVE

▶CHOKE PLATE AND THROTTLE LEVERS(S/N-C239552 AND BELOW) (20 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	18734	COVER, SOUND ATTENUATOR
2	10-68000	SCREW, (.250-28 x 1.00), SOUND ATTENUATOR
3	12-20583	WASHER, SOUND ATTENUATOR SCREW
4	10-48408	SCREW, (#10-16 x .500), COVER TO SOUND ATTENUATOR
5	27-877361	GASKET, COVER
6	194261	PLATE, SOUND ATTENUATOR
7	27-892211	GASKET, SOUND ATTENUATOR TO CARBURETOR
8	43440T	INLET, SOUND ATTENUATOR
9	10-48408	SCREW, (#10-16 x .500), INLET TO SOUND ATTENUATOR
10	87604	LINK, Throttle
11	828277A1	LEVER ASSEMBLY, Throttle
12	828277A1	LEVER, Throttle
13	67748	ROLLER, LOWER THROTTLE LEVER
14	10-15124	SCREW, (#10-32 x .750)
15	10,13-26996	LOCKWASHER, Stainless Steel, THROTTLE LEVERS SCREW
16	12-8M0204666	WASHER, (.203 x .500 x .032), THROTTLE LEVERS SCREW
17	17-67297	PIN, Clevis, THROTTLE LEVERS TO THROTTLE LINK
18	12-89302	WASHER, (.203 x .406 x .040), CLEVIS PIN
19	18-26953	COTTER PIN, CLEVIS PIN

▶CHOKE PLATE AND THROTTLE LEVERS(S/N-C239553 AND UP) (19 parts)

Ref	OEM Part #	Part Name
1	18866T	COVER, SOUND ATTENUATOR
2	10-92051	SCREW, (10-16 x .75)
3	27-188891	GASKET, SOUND ATTENUATOR
4	817495A1	PLATE, Sound Attenuator
5	27-892211	GASKET, PLATE TO CARBURETOR
6	10-68000	SCREW, (.250-28 x 1.00), SOUND ATTENUATOR
7	12-20583	WASHER, SOUND ATTENUATOR SCREW
8	21-64871A2	CHECK VALVE
9	22-15026	CAP
10	87604	LINK, Throttle
11	828277A1	LEVER ASSEMBLY, Throttle
12	828277A1	LEVER, Throttle
13	67748	ROLLER, LOWER THROTTLE LEVER
14	10-15124	SCREW, (#10-32 x .750), THROTTLE LEVERS TO THROTTLE LINK
15	10,13-26996	LOCKWASHER, Stainless Steel, THROTTLE LEVERS SCREW
16	12-8M0204666	WASHER, (.203 x .500 x .032), THROTTLE LEVERS SCREW
17	17-67297	PIN, Clevis, THROTTLE LEVERS TO THROTTLE LINK
18	12-89302	WASHER, (.203 x .406 x .040), CLEVIS PIN
19	18-26953	COTTER PIN, CLEVIS PIN

▶CRANKSHAFT, PISTONS AND CONNECTING RODS (18 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	455-8745T5	CRANKSHAFT ASSEMBLY
2	30-67923T	BEARING, Ball, CRANKSHAFT (LOWER)
3	53-67446	RING, BALL BEARING
4	43-99727A1	GEAR, Drive
5	54196A6	CARRIER ASSEMBLY, SEAL
6	65800	PACKING, CARRIER
7	39-78633	RING, SEALING - CRANKSHAFT Comment: (.139 THICK)
8	31-93495T	BEARING, Roller, CRANKSHAFT
9	53-67444	RING, Retaining, ROLLER BEARING
10	766-8667T41	PISTON ASSEMBLY Comment: (PORT)
11	39-813011A12	RING ASSEMBLY, Piston
12	53-857196	RING, Lock, PISTON
13	636-8119A6	CONNECTING ROD ASSEMBLY
14	10-93886	SCREW, (.312-28 x .875), CONNECTING ROD
15	12-8M0032839	WASHER, NEEDLE LOCATING
16	8M0234886	BEARING KIT, CRANKSHAFT END
17	29-67483	BEARING, Needle, PISTON END

▶CYLINDER BLOCK AND END CAPS (50 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	858-8712A59	CYLINDER BLOCK
2	16-76175	STUD, POWERHEAD (1-7/8")
3	16-8M0034454	STUD, POWERHEAD Comment: (6-3/4")
4	17-43044	PIN, Dowel, LOCATING
5	17-8M0036405	PIN, CYLINDER BLOCK (BEARING RACE)
6	27-11338	GASKET, SEALING
7	8M0088723	COVER, STARTER MOTOR (UPPER)
8	10-73657	SCREW, (.312-18 x 1.50), COVER TO CRANKCASE
9	13-8M0204647	LOCKWASHER, (.312), STARTER MOTOR COVER SCREW
10	76867	COVER, STARTER MOTOR (LOWER)
11	10-815549	SCREW, (.312-18 x 2), COVER TO CRANKCASE
11A	23-99448	BUSHING
12	10-74824	SCREW, (.312-18 x 1.250), CRANKCASE TO CYLINDER BLOCK
13	1159-9608T1	END CAP ASSEMBLY, UPPER
14	25-54029	O-RING, (2.800 x .103), END CAP
15	31-93496T	BEARING, Roller, END CAP
16	26-41953	SEAL, END CAP
17	10-30225	SCREW AND LOCKWASHER, (.312-18 x 1.00), UPPER END CAP TO CYLINDER BLOCK
18	10-24220	SCREW, (.190-24 x .190), SET - CYLINDER BLOCK Comment: (OLD DESIGN)
19	22-38407	PLUG, (.500-14), CYLINDER BLOCK (WATER JACKET) Comment: (OLD DESIGN)
20	16-15094	STUD, (.190-32 x 1.870), FLYWHEEL COVER TO CYLINDER BLOCK
21	16-8M0034435	STUD, (#10-32 x 1.00), FLYWHEEL COVER TO BRACKET
22	23-67269	SPACER, FLYWHEEL COVER STUD
23	12-8M0204663	WASHER, FLYWHEEL COVER STUD
24	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, FLYWHEEL COVER STUD
25	11-816874	NUT, FLYWHEEL COVER STUD
26	422482	BRACKET, FLYWHEEL COVER
27	10-49668	SCREW, (.250-20 x .750), BRACKET TO CRANKCASE
28	1156-7809T1	END CAP ASSEMBLY, LOWER
29	25-62700	O-RING, (3.237 x .103), END CAP
30	26-41953	SEAL, END CAP
31	10-28636	SCREW, (.250-20 x .750)
32	13-26992	LOCKWASHER, (.250) Stainless Steel, LOWER END CAP SCREW
33	10-64022	SCREW, (.250-20 x 2.125), ADJUSTING - CYLINDER BLOCK
34	11-64015	NUT, (.250-20), JAM - ADJUSTING SCREW
35	26852	CAP, Nylon, ADJUSTING SCREW
36	93772A2	STABILIZER
37	10-690201	SCREW, (#10-32 x .875)
38	12-38833	WASHER
39	86-194372	TERMINAL BLOCK
40	10-48409	SCREW, (#10-16 x .625) Stainless Steel
41	12-89302	WASHER, (.203 x .406 x .040)
42	10-32,11-45076	NUT, Brass
43	10-32,11-813938	CAP NUT,
44	54-63153	J CLIP
45	88825A7	VOLTAGE REGUALTOR
46	10-48409	SCREW, (#10-16 x .625) Stainless Steel, VOLTAGE REGULATOR
47	10-32,11-45076	NUT, Brass, VOLTAGE REGULATOR
48	84-13397A1	HARNESS ASSEMBLY

▶DRIVESHAFT HOUSING AND EXHAUST TUBE (39 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	3503-9748A2	HOUSING ASSEMBLY, Driveshaft Comment: (X-Long-Gray)
2	16-56295	STUD, (.437 x 2.69), DRIVESHAFT HSG./GEAR HSG.
3	25067	BUMPER, LOWER MOUNT SCREW
4	10-898831	SCREW, (.500-20 x 6.00), LOWER MOUNT
5	77327	MOUNT, LOWER Comment: (X-Long)
6	12-49339	WASHER, (.8125), LOWER MOUNT SCREW
7	11-25096	NUT, LOWER MOUNT SCREW
8	88238A10	CABLE ASSEMBLY, Ground
9	54-8M0036782	CLAMP, LOWER MOUNT
10	10-66727	SCREW, (.312-18 x 1.250)
11	67077F1	COVER, LOWER MOUNT CLAMP Comment: (Gray)
12	10-88417	SCREW, (#12-24 x .620), COVER ATTACHING
13	11-35521	NUT, NYLON - COVER TO CLAMP SCREW
14	88238A10	CABLE ASSEMBLY, Ground
15	10-41508	SCREW, (.250-20 x .500) Stainless Steel, GROUND WIRE
16	12-48926	WASHER, GEAR HOUSING STUD
17	11-29489	NUT, GEAR HOUSING STUD (CAP)
18	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, GEAR HOUSING STUD
19	11-8M0204653	NUT, (.437-20) Stainless Steel, GEAR HOUSING STUD
20	19-64649	PLUG, DRIVESHAFT HOUSING
21	89743	TUBE, Exhaust
22	66350001	SEAL, EXHAUST TUBE - LOWER
23	86027	SEAL, EXHAUST TUBE - UPPER
24	32-8M0042790	TUBE, WATER Comment: (X-Long)
25	27-991734	GASKET, DRIVESHAFT HOUSING TO PLATE
26	41945A7	PLATE ASSEMBLY, DRIVESHAFT HOUSING
27	8M0043165	SEAL, BRACKET
28	68011	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500), BRACKET TO PLATE
30	17-43044	PIN, Dowel, LOCATING
31	26-38970	SEAL, WATER TUBE
32	10-90192	SCREW, (.250-20 x .750) Stainless Steel, EXTENSION PLATE
33	27-991772	GASKET
34	12-20553	WASHER, POWER HEAD STUD
35	11-69254	NUT, POWER HEAD STUD
36	41941T	DIFFUSER
37	27-782461	GASKET, EXHAUST EXTENSION
38	814630	PLUG, IDLE RELIEF Comment: SN# 0C239553 & Up

▶Dual Engine Extension Kit (18 parts)

Ref	OEM Part #	Part Name
-	92876A9	DUAL ENGINE EXTENSION KIT
1	19624A1	SEAL KIT
2	71565	TUBE, Cable Guide, CABLE GUIDE
3	41055	MOUNT
4	14-42100	TAB WASHER
5	11-8M0041651	NUT, (.875-14)
6	88404	TAB WASHER
7	10-38601	SCREW, (.250-28 x 1.250)
8	17729A1	BRACKET
9	10-62055	SCREW, (.312-24 x 1.250)
10	17728	TAB WASHER
11	10-849838	SCREW, (.375-24 x 1.25)
12	11-8M0204726	NUT, (.375-24)
13	97933A1	STEERING EYE
14	23-23651	SLEEVE, (1.625)
15	97931	TUBING, (4.00 Inches)
16	8M0026098	TUBE
17	11-42099	NUT, (.562-18)

▶EXHAUST MANIFOLD AND EXHAUST PLATE (48 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	27-904841	GASKET, DIVIDER PLATE
2	99169A1	PLATE, DIVIDER
3	26-814754	SEAL, DIVIDER PLATE
4	193071	COVER, EXHAUST MAINFOLD
5	10-74824	SCREW, (.312-18 x 1.250)
6	86-194373	TERMINAL BLOCK (3 TERMINALS)
7	10-31716	SCREW, (.250-20 x .620), TERMINAL BLOCK
8	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, TERMINAL BLOCK SCREW
9	10-32,11-45076	NUT, Brass, TERMINAL BLOCK
10	10-32,11-813938	CAP NUT,
11	10-74824	SCREW, (.312-18 x 1.250), COVER TO CYLINDER BLOCK
12	27-78690002	GASKET, RELIEF VALVE PLATE
13	10-69570	SCREW, (#10-16 x .750), DIAPHRAGM TO PLATE
14	12-76451	WASHER, DIAPHRAGM SCREW
15	144791	DIAPHRAGM
16	16496	DEFLECTOR, Water
17	16497A1	PLATE, RELIEF VALVE
18	24-64878	SPRING, (Black), COMPRESSION POPPET VALVE
19	12-85303	WASHER, POPPET SPRING
20	14480	POPPET, VALVE
21	25-64872	GROMMET, POPPET VALVE
22	65848	CARRIER, POPPET VALVE
23	27-991764	GASKET, EXHAUST PLATE
24	41944A5	PLATE ASSEMBLY, EXHAUST
25	22-996642	ELBOW, EXHAUST PLATE
26	17-43044	PIN, Dowel, LOCATING - EXHAUST PLATE
27	8M0043165	SEAL, EXHAUST PLATE
28	680101	BRACKET, SEAL RETAINING
29	10-878608	SCREW, (#10-16 x .500), BRACKET TO EXHAUST PLATE
30	12-20553	WASHER, POWERHEAD STUD
31	11-69254	NUT, POWERHEAD STUD
32	23-27132	BUSHING, EXHAUST PLATE
33	25-8M0179867	GROMMET
34	25-12602002	GROMMET, EXHAUST PLATE
35	10-66727	SCREW, (.312-18 x 1.250), EXHAUST PLATE ATTACHING
36	10-68783	SCREW, (.312-18 x 2.50), EXHAUST PLATE ATTACHING
37	10-898833	SCREW, (.375-16 x 3.50), EXHAUST PLATE ATTACHING
38	812905T	BRACKET ASSEMBLY, FRONT
39	10-90285	SCREW, (.312-18 x .625), FRONT BRACKET
40	12-187031	WASHER
41	25-18778001	GROMMET
42	18578T09	BRACKET ASSEMBLY, Rear
43	8M0039767	COVER, RELIEF VALVE Comment: (NEW DESIGN)
44	22-920071	FITTING, (.250-18) (90 DEG.) Comment: (NEW DESIGN)
45	32-8M0108355	LINE, (57.00 Inches Bulk) Comment: (NEW DESIGN)
46	54-816311T	TIE STRAP Comment: (NEW DESIGN)
47	22-8144301	FITTING, (.500-14) Comment: (NEW DESIGN)

▶FLYWHEEL/STARTER MOTOR (24 parts)

Ref	OEM Part #	Part Name
1	18896A1	COVER KIT, FLYWHEEL (LOUVERED)
2	79918A1	COVER KIT, FLYWHEEL (NON-LOUVERED)
3	10-37572	SCREW, (.190-32 x .380), TIMING MARKER
4	12-72761	WASHER, (.203 x .562 x .060) Stainless Steel, TIMING MARKER SCREW
5	79022	MARKER, TIMING
6	19-45907	PLUG, Yellow, FLYWHEEL
7	11-52901	NUT, (.625-18), FLYWHEEL
8	12-33001	WASHER, (.641 x 1.250 x .190), FLYWHEEL
9	271-859238A9	FLYWHEEL Comment: Use with Non-Louvered Cover
10	10-32417	SCREW, (.250-28 x .625), FLYWHEEL PLATE
11	10-68997	SCREW, (.312-24 x .750), FLYWHEEL HUB
12	398-5454A35	STATOR Comment: Use with Non-Louvered Cover
13	10-19926100	SCREW, (#10-24 x 1.00) Comment: Use with Non-Louvered Cover
14	10,13-26996	LOCKWASHER, Stainless Steel Comment: Use with Louvered Cover
15	96455A9	PLATE ASSEMBLY, Trigger
16	84-93388A1	CABLE ASSEMBLY, (6.00 Inches) Black, PLATE TO STARTER MOTOR
17	50-893893	STARTER MOTOR ASSEMBLY
18	23-8M0034918	COLLAR, STARTER MOTOR
19	8M0043376	STOP, Rubber, STARTER MOTOR
20	13-26992	LOCKWASHER, (.250) Stainless Steel, STARTER MOTOR TERMINAL
21	11-20890	NUT, (.250-20), STARTER MOTOR TERMINAL
22	84-93388A14	CABLE ASSEMBLY, Black, SOLENOID TO STARTER MOTOR
23	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel, CABLE TO STARTER MOTOR
24	19-89219001	PLUG, FLYWHEEL COVER

▶FUEL PUMP AND CARBURETOR (48 parts)

Ref	OEM Part #	Part Name
1	1374-9242T42	CARBURETOR (TOP)
2	1374-9242T43	CARBURETOR (CENTER)
3	1374-9242T44	CARBURETOR (BOTTOM)
4	22-70007	FITTING, 45 Degree, FUEL INLET (MIDDLE)
5	1395-7900	TEE FITTING, FUEL INLET (MIDDLE)
6	1395-7901	ELBOW, FUEL INLET-UPPER AND LOWER
7	27-677511	GASKET, CARBURETOR
8	11-8M0207775	NUT, (1/4-28X7/32), CARBURETOR MOUNTING
9	42859A2	VALVE ASSEMBLY, Enrichner
10	54-633001	CLAMP, ENRICHENER VALVE
11	10-73286	SCREW, (.250-20 x .500) Stainless Steel, VALVE CLAMP
12	86-45915	TERMINAL BLOCK, REED BLOCK HOUSING
13	10-38055	SCREW, (.190-32 x .620), TERMINAL BLOCK
13A	10-62568	SCREW, (#10-16 x .375)
14	32-892024122	TUBING, (20.00 Feet Bulk), TOP CARBURETOR TO VALVE
15	32-9912688	TUBING, (36.00 Inches Bulk), CARBURETOR (4-1/4")
16	32-8M0108355	LINE, (57.00 Inches Bulk)
17	15930A15	PUMP ASSEMBLY, Fuel
18	21-857005A1	DIAPHRAGM KIT
19	NSS	NOT SOLD SEPARATE, CHECK VALVE, RUBBER
20	NSS	NOT SOLD SEPARATE, GASKET, BOOST
21	NSS	NOT SOLD SEPARATE, DIAPHRAGM
22	NSS	NOT SOLD SEPARATE, GASKET, PULSE
23	NSS	NOT SOLD SEPARATE, SPRING
24	NSS	NOT SOLD SEPARATE, CAP
25	NSS	NOT SOLD SEPARATE, CHECK VALVE
26	NSS	NOT SOLD SEPARATE, RETAINER
27	NSS	NOT SOLD SEPARATE, SPRING
28	NSS	NOT SOLD SEPARATE, CAP
29	27-8M0204705	GASKET, BASE
30	22-14868	FITTING, FUEL PUMP (ELBOW)
31	22-19688	FITTING, FUEL PUMP (ELBOW)
32	144303	BASE, FUEL PUMP
33	987752	PLATE, FUEL PUMP
34	22-56800	PLUG, Pipe (.0625-27)
35	22-15979	FITTING
36	10-16452	SCREW, (#12-24 x 2.00), FULE PUMP
37	10-4000310	SCREW, (M5 x 40), FUEL PUMP TO CRANKCASE
38	12-4002314	WASHER, FUEL PUMP SCREW
39	32-9072925	HOSE, PULSE
40	22-997511	FITTING, (.0625-27) Brass, PULSE HOSE (90 DEG.)
41	32-8M0108349	TUBING, TO CENTER CARBURETOR
42	54-816311T	TIE STRAP, FUEL TUBING
43	35-816296Q03	FILTER, Fuel
44	22-424253	TEE
45	22-816856Q3	CONNECTOR, Fuel
46	10-69067	SCREW, (.250-20 x 1.375), FUEL CONNECTOR
47	812782	SEAL

▶GEAR HOUSING(DRIVE-STANDARD/COUNTER ROTATION) (47 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	1647-9148T47	GEAR HOUSING ASSEMBLY (GRAY)
2	22-85822A10	CONNECTOR ASSEMBLY, SPEEDOMETER
3	17-43044	PIN, Dowel, GEAR HOUSING LOCATING
4	16-8M0034464	STUD, (.438 x 3.69), GEAR HOUSING Comment: (X-LONG)
5	16-8M0133358	STUD, (.44 x 2.06)
6	16-8M0034463	STUD, (.312 x 3.38), WATER PUMP
7	16-306671	STUD, (.250-20/.250-28 x 3.125), WATER PUMP
8	31-42647A1	BEARING ASSEMBLY, Roller, DRIVESHAFT
9	23-43998	SLEEVE, LUBRICATION
11	45-897625T	DRIVESHAFT Comment: (X-LONG)
12	NSS	NOT SOLD SEPARATE, Pinion Gear (Part of 43-44104A2 or 43-18475A1)
13	12-92721	WASHER, PINION GEAR
14	11-35921	NUT, (.625-18), PINION GEAR TO DRIVESHAFT
15	15-42637A1	SHIM SET, ROLLER BEARING TO GEAR HOUSING
16	31-8M0146566	BEARING ASSEMBLY, Roller/Cup, DRIVESHAFT
17	8245191	NUT, DRIVESHAFT BEARING
18	46-8M0077147	BASE ASSEMBLY, Water Pump
19	27-8M0204678	GASKET, WATER PUMP TO GEAR HSG
20	25-38099	O-RING, WATER PUMP (2.109 I.D.)
21	26-89238	SEAL, Oil, WATER PUMP
22	26-16977	SEAL, Oil, WATER PUMP
23	27-8M0090319	GASKET, LOWER - WATER PUMP
24	27-858524	GASKET, UPPER - WATER PUMP
25	8M0204677	FACE PLATE, WATER PUMP
26	46-96148T1	BODY ASSEMBLY, Water Pump
27	48752T	INSERT, WATER PUMP BODY
28	26-38970	SEAL, RUBBER - WATER INLET TUBE
29	47-89984T4	IMPELLER, WATER PUMP
30	28-8M0214992	KEY
31	10-8M0215009	SCREW, (#14-8 x 2.25), WATER PUMP
32	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, WATER PUMP SCREW AND STUD
33	11-8267119	NUT, (.250-28), WATER PUMP STUD
34	12-36001	WASHER, WATER PUMP STUD
35	11-13436	NUT, WATER PUMP STUD
36	25-8M0214918	RING, Rubber (DRIVESHAFT)
37	23-29804T	SLEEVE, GUIDE - WATER INLET TUBE
38	789022	SHAFT, SHIFT - LOWER
39	53-29641	E RING, RETAINING - SHIFT SHAFT
40	53-78907	RING, Retaining
41	25-25439	O-RING, (.862 x .103), SHIFT SHAFT BUSHING
42	23-77631A2	BUSHING ASSEMBLY, SHIFT SHAFT
43	26-8M0204708	SEAL, Oil, SHIFT SHAFT BUSHING
44	12-77674	WASHER, RUBBER - SHIFT SHAFT BUSHING
45	10-79953Q04	SCREW, (.375-16 x .250), GREASE FILLER
46	22-8M0058389	SCREW, Magnetic, DRAIN
47	12-191833	WASHER, Fiber, GREASE FILLER AND DRAIN SCREW

▶GEAR HOUSING(PROPELLER SHAFT) (COUNTER ROTATION) (42 parts)

Ref	OEM Part #	Part Name
-	26-89238A2	SEAL KIT
1	1647-9148T47	GEAR HOUSING ASSEMBLY (BASIC) Comment: (GRAY)
47	789562	SHIFT CAM
48	89594A1	FOLLOWER ASSEMBLY, CAM
49	79911A1	ROD, CLUTCH ACTUATOR
50	24-79910	SPRING, COMPRESSION
51	12-78910	WASHER, SPRING
52	17-8M0084245	PIN, SPRING LOCATOR
53	14469T	CUP, Bearing
54	30-88957T	BEARING, Ball
56	31-15844	BEARING ASSEMBLY, Roller
57	17-78909	PIN, Detent, RATCHET
58	52-823174T	RATCHET, SLIDIING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET
60	24-78962	SPRING, RETAINING - CROSS PIN
61	43-18475T1	GEAR ASSEMBLY, Forward
62	23-1761513	SPACER SHIM, (.149)
63	31-15841	BEARING, Roller
64	12-17616	THRUST RING
65	25-8M0214920	O-RING, BEARING CARRIER
66	18447T2	ADAPTOR ASSEMBLY, Bearing
67	31-15843T	BEARING, Roller
68	12-18448	THRUST WASHER
69	31-15842	BEARING, Thrust
70	44-18446	PROPELLER SHAFT
71	818896T2	CARRIER ASSEMBLY, Bearing
72	31-30956T	BEARING, Needle, BEARING CARRIER
73	26-8M0204670	SEAL, BEARING CARRIER
74	14-79447	TAB WASHER, GEAR HOUSING COVER
75	8M2011027	RETAINER, GEAR HOUSING
76	28-30281	KEY, LOCATING - BEARIING CARRIER
77	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
78	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
79	8M0039169	FILLER BLOCK
80	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, DRIVESHAFT HOUSING STUDS
81	11-8M0204653	NUT, (.437-20) Stainless Steel, DRIVESHAFT HOUSING STUDS
82	12-835467Q01	THRUST HUB
83	12-31211Q03	WASHER, Splined, PROPELLER NUT
84	14-816629Q	TAB WASHER, PROPELLER NUT
85	11-52707Q1	PROP NUT KIT, (.750-16)
86	13-423511	LOCKWASHER, Toothed, PROPELLER SHAFT
87	10-74727	SCREW, (.375-16 x 6.00), GEAR HOUSING

▶GEAR HOUSING(PROPELLER SHAFT) (STANDARD ROTATION) (37 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	1647-9148T47	GEAR HOUSING ASSEMBLY (BASIC) Comment: (GRAY)
48	789562	SHIFT CAM
49	89594A1	FOLLOWER ASSEMBLY, CAM
50	79911A1	ROD, CLUTCH ACTUATOR
51	24-79910	SPRING, COPRESSION
52	12-78910	WASHER, COMPRESSION SPRING
53	17-8M0084245	PIN, SPRING LOCATOR
54	15-47397A1	SHIM SET, BEARING OUTER RACE (.001-3-5-10)
55	31-78172A1	BEARING ASSEMBLY, Tapered Roller
56	43-44104T2	GEAR ASSEMBLY, Forward
57	31-73363T	BEARING, Roller (1.313 O.D.)
58	52-823174T	RATCHET, SLIDING CLUTCH
59	17-8M0084243	PIN, Cross, RATCHET TO PROPELLER SHAFT
60	17-78909	PIN, Detent, RATCHET
61	24-78962	SPRING, RETAINING - CROSS PIN
62	44-94148	PROPELLER SHAFT
64	681001	RING, THRUST
65	30-88957T	BEARING, Ball, REVERSE GEAR
66	25-8M0214920	O-RING, BEARING CARRIER
67	43567T1	CARRIER ASSEMBLY, Bearing
68	31-30956T	BEARING, Needle, BEARING CARRIER
69	26-8M0204670	SEAL, BEARING CARRIER
70	28-30281	KEY, LOCATING - BEARING CARRIER
71	14-79447	TAB WASHER, GEAR HOUSING COVER
72	8M2011027	RETAINER, GEAR HOUSING
73	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
74	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
75	8M0039169	FILLER BLOCK
76	11-8M0204653	NUT, (.437-20) Stainless Steel, DRIVESHAFT HOUSING STUDS
77	10-74727	SCREW, (.375-16 x 6.00), GEAR HOUSING Comment: (X-LONG)
78	12-835467Q01	THRUST HUB
79	12-31211Q03	WASHER, Splined, PROPELLER NUT
80	14-816629Q	TAB WASHER, PROPELLER NUT
81	11-52707Q1	PROP NUT KIT, (.750-16)
82	13-423511	LOCKWASHER, Toothed, PROPELLER SHAFT
83	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, DRIVESHAFT HOUSING STUDS

▶IGNITION COIL/VOLTAGE REGULATOR (35 parts)

Ref	OEM Part #	Part Name
1	195872	PLATE, MOUNTING
2	10-86885	SCREW, (.250-20 x 1.500) Stainless Steel, COVER
3	13-26992	LOCKWASHER, (.250) Stainless Steel
4	23-19661	BUSHING
5	18736A21	REGULATOR ASSEMBLY, Voltage
6	18717	SEAL
7	8M0185622	SOLENOID, Starter
8	10-90192	SCREW, (.250-20 x .750) Stainless Steel, STARTER SOLENOID
9	84-88807A6	CABLE ASSEMBLY, (3.50 Inches) Black
10	11-8267098	NUT, (.250-20), SOLENOID SCREW
11	8-32,11-26419	NUT, Brass, SOLENOID TERMINAL
12	11-94330	NUT, (.250-20) Brass, SOLENOID TERMINAL
13	85-97861	INSULATOR, STARTER SOLENOID (OLD DESIGN)
14	84-88807A8	CABLE ASSEMBLY, (3.50 Inches) Black
15	84-88807A29	CABLE ASSEMBLY
16	54-816311T	TIE STRAP
17	43542	COVER, IGNITION COIL
18	339-832757A4	COIL ASSEMBLY, Ignition
19	10-90048	SCREW, (#10-32 x 2.125), IGNITION COIL COVER
20	10-32,11-90078	NUT, , COVER SCREW/GROUND WIRE
21	84-813715A9	CABLE KIT, Ignition, HIGH TENSION
22	85-63709A1	BOOT/TERMINAL KIT, HIGH TENSION CABLE
23	33-13686Q	SPARK PLUG
24	10-32,11-45076	NUT, Brass, IGNITION COIL TERMINAL
25	84-88807A13	CABLE ASSEMBLY
26	10-69022	SCREW, (#10-32 x .500) Stainless Steel, GROUNDING WIRE
27	84-69739A6	HARNESS ASSEMBLY, COIL TO SWITCH BOX Comment: (#1, 3 AND 5)
28	54676	RETAINER, Two Wire
29	814423T	COVER, COIL PLATE Comment: SN# 0C239553 & Up
30	10-814343	SCREW, (#10-32 x 2.380) Comment: SERIAL (0C239553 AND ABOVE ) SN# 0C239553 & Up
31	87-814407A3	SWITCH KIT, Tilt, POWERBOAT
32	87-814407A2	TILT SWITCH, POWERBOAT
33	99629A3	LEVER ASSEMBLY, Tilt, POWERBOAT
34	19380	COVER
35	27-193901	GASKET

▶Instrumentation(Mercury and Mariner) (37 parts)

Ref	OEM Part #	Part Name
1	79-895283Q43	TACHOMETER (6K)
2	79101T	BRACKET, MOUNTING
3	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
4	88-79888	SOCKET, Light Bulb
5	8-32,11-26419	NUT, Brass
6	84-86323A5	CABLE ASSEMBLY, (1.50 Feet) Purple, TRIM GAUGE
7	79-895292Q41	TRIM GAUGE
8	79480	BRACKET, MOUNTING - TRIM GAUGE
9	88-72729	LIGHT BULB, Wedge Base (14V - .19W), TRIM GAUGE
10	88-79888	SOCKET, Light Bulb, TRIM GAUGE
11	8-32,11-26419	NUT, Brass, TRIM GAUGE TERMINAL
12	84-86396A8	HARNESS ASSEMBLY, Tachometer (5.00 Feet)
13	79-895287Q41	TEMPERATURE GAUGE
14	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
15	88-79888	SOCKET, Light Bulb
16	12-26427	WASHER
17	79480	BRACKET
18	8-32,11-26419	NUT, Brass
19	84-88824A4	CABLE ASSEMBLY, (45.00 Inches) Tan
20	79-895294Q41	SYNCHRONIZER GAUGE Comment: (Counter Rotation)
21	79480	BRACKET Comment: (Counter Rotation)
22	8-32,11-26419	NUT, Brass Comment: (Counter Rotation)
23	88-72729	LIGHT BULB, Wedge Base (14V - .19W) Comment: (Counter Rotation)
24	88-79888	SOCKET, Light Bulb Comment: (Counter Rotation)
25	145022	DRIVER, SYNCHRONIZER Comment: (Counter Rotation)
26	87-19674A1	SWITCH ASSEMBLY, Lanyard Comment: (Counter Rotation)
27	10-18303	SCREW, (.190-16 x 1.750) Stainless Steel Comment: (Counter Rotation)
28	813679	ADAPTER Comment: (Counter Rotation)
29	15920Q54	LANYARD ASSEMBLY Comment: (Counter Rotation)
30	10-32866	SCREW, (#10-32 x 2.00) Stainless Steel Comment: (Counter Rotation)
31	18321	CLAMP, Mounting Comment: (Counter Rotation)
32	12-24676	WASHER, (.200 x .440 x .032) Comment: (Counter Rotation)
33	10-32,11-68219	NUT, Stainless Steel Comment: (Counter Rotation)
34	79146	RETAINER Comment: (Counter Rotation)
35	54-816311T	TIE STRAP Comment: (Counter Rotation)
36	812497A2	DIODE ASSEMBLY Comment: (Counter Rotation)
37	84-11149A2	CABLE ASSEMBLY, (6.00 Inches) Comment: (Counter Rotation)

▶Key Switch(Counter Rotation Engines) (14 parts)

Ref	OEM Part #	Part Name
-	8949112	KEY, Ignition (2F)
1	84-816626A20	KEY SWITCH ASSEMBLY (20')
2	90468A1	COVER ASSEMBLY, Key, IGNITION SWITCH KEYS
3	76424	BRACKET, IGNITION SWITCH
4	16-55422	STUD, (#10-32 x 2.00), SWITCH ATTACHING
5	12-24676	WASHER, (.200 x .440 x .032), SWITCH ATTACHING STUD
6	10-32,11-68219	NUT, Stainless Steel, SWITCH ATTACHING STUD
7	816479A3	PLATE, SWITCH MOUNT
8	87-88107A5	KEY SWITCH, IGNITION (SEE BELOW FOR KEYS)
9	11-879755	NUT, Special - Chrome Brass, IGNITION SWITCH
10	38-90311	INSERT, SWITCH PLATE
11	68878A6	HORN ASSEMBLY, Alarm
12	68879	COVER, ALARM HORN
13	23-812711	SPACER, (.250)

▶MISCELLANEOUS PARTS AND ACCESSORIES (1 parts)

Ref	OEM Part #	Part Name
-	37-813038A90	DECAL SET (SILVER) Comment: (GRAY)

▶OIL INJECTION COMPONENTS (41 parts)

Ref	OEM Part #	Part Name
1	12430A4	SENSOR ASSEMBLY
2	10-48409	SCREW, (#10-16 x .625) Stainless Steel, SENSOR ATTACHING
3	41470A26	WARNING MODULE ASSEMBLY
4	12-38833	WASHER, WARNING MODULE SCREW
5	10-690201	SCREW, (#10-32 x .875), WARNING MODULE TO CYLINDER BLOCK
6	815699T	PUMP ASSEMBLY, Oil
7	10-41507	SCREW, (#10-32 x 1.120)
8	193855	LINK ASSEMBLY, THROTTLE LEVER TO OIL PUMP
9	23-41429A2	BEARING ASSEMBLY, DRIVE GEAR
10	43-14563	GEAR, Driven
11	32-82381335	TUBING, OIL PUMP TO TEE
12	10-42813	SCREW, (#10-32 X .380), WARNING MODULE LEAD
13	25-11379	O-RING, OIL PUMP
14	1257-87421	TANK
15	36-43298A2	CAP ASSEMBLY, OIL TANK
16	25-11332	O-RING, (2.225 x .210), CAP
17	816190A4	HOUSING ASSEMBLY, Adaptor
18	25-11332	O-RING, (2.225 x .210), ADAPTOR HOUSING
19	32-99802	TUBE, OIL PICK-UP
20	816190A4	HOUSING ASSEMBLY, Flywheel
21	32-99439	HOSE, (114.00 Inches), OIL
22	12540A3	HOUSING
23	12242A1	LATCH
24	21-8781051	FITTING, CHECK VALVE (CRANKCASE)
25	994436	RESERVOIR, Oil
26	10-690201	SCREW, (#10-32 x .875), OIL RESERVOIR ATTACHING
27	12-42118	WASHER, OIL RESERVOIR SCREW
28	25-42117	GROMMET, OIL RESERVOIR SCREW
29	23-42116	BUSHING, OIL RESERVOIR SCREW
30	32-82381455	TUBING, OIL RESERVOIR TO OIL PUMP (5-1/4")
31	36-43300A9	CAP ASSEMBLY, OIL RESERVOIR
32	27-43307T	GASKET, RESERVOIR CAP
33	8M0187298	FLOAT ASSEMBLY
34	11-99265	PUSH NUT
35	54-415824	CLAMP, OIL HOSE (SMALL)
36	54-415823	CLAMP, OIL HOSE (LARGE)
37	32-8M0108355	LINE, (57.00 Inches Bulk), OIL
38	22-42425	TEE, OIL TUBING
39	32-9072925	HOSE, OIL (6-3/4")
40	32-8M0108355	LINE, (57.00 Inches Bulk)
41	8141032	BEARING

▶POWER TRIM COMPONENTS (38 parts)

Ref	OEM Part #	Part Name
1	99659A22	MANIFOLD ASSEMBLY Comment: (GRAY)
2	22-56800	PIPE PLUG, MANIFOLD
3	41493A7	TRIM CYLINDER ASSEMBLY Comment: (GRAY)
4	41492A1	GUIDE ASSEMBLY
5	25-41478A1	REPAIR KIT
6	41482A2	CHECK VALVE KIT
7	1100-8M0021648	GUIDE ASSEMBLY, TRIM ROD
8	878413A1	PISTON/ROD ASSEMBLY, Power Trim (PORT)
9	35-12184A1	TRIM FILTER ASSEMBLY
10	878414T01	PISTON/ROD ASSEMBLY, Power Trim (STARBOARD)
11	17-821539	PIN, Groove, TRIM CYLINDER (UPPER)
12	893929A01	VALVE ASSEMBLY
12A	53-815949001	E RING
13	10-4000327	SCREW, (M6 x 14), COVER
14	12-4002315	WASHER, COVER SCREW
15	99642	COVER, MANIFOLD
16	25-48462A4	O-RING KIT
17	19-99609A1	PLUG ASSEMBLY
18	99641A1	SHAFT ASSEMBLY
19	22-56800	PIPE PLUG, SHAFT
20	10-4008820	SCREW, (M6 x 20), PUMP AND MOTOR
21	13-400256	LOCKWASHER, (M6)
22	826729A10	PUMP AND MOTOR
23	99625002	SHAFT, UPPER
24	97-818298Q1	ANODE ASSEMBLY
25	10-4000332	SCREW, (M6 x 35), ANODE
26	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, ANODE SCREW
27	8M0045383	STRIKER PLATE, TRIM SHAFT
28	13-58643	LOCKWASHER, (.375)
29	11-46335	NUT, (.375-24)
30	84-17201A5	HARNESS ASSEMBLY, Control, POWER TRIM Comment: (WITHOUT FUSE)
31	84-87379A14	WIRE ASSEMBLY, (2.750 Inches) (RED)
32	54-22875	CLIP, PUMP WIRE
33	8M0084613	C WASHER, CLIP SCREW
34	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
35	17-878267	PIN, Groove, TRIM CYLINDER (LOWER)
36	10-4000377	SCREW, (M10 x 30), MANIFOLD
37	13-400258	LOCKWASHER, (M10) Stainless Steel, MANIFOLD SCREW

▶Power Trim Pump (9 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	12659	FRAME AND FIELD KIT
2	12665	SPRING KIT, Brush
3	13506	BRUSH CARD KIT
4	12662	PUMP AND END FRAME KIT
5	126631	SEAL KIT, Pump
6	12660	END FRAME KIT
7	12661	ARMATURE KIT
8	12664	THRU BOLT KIT

▶REED BLOCK AND CYLINDER HEAD (34 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	15221A5	CYLINDER HEAD ASSEMBLY
2	27-41247T01	GASKET, CYLINDER HEAD
3	10-98534	SCREW, (.375-16 x 2.30), CYLINDER HEAD
4	12-25909	WASHER, (.406 x .812 x .065), CYLINDER HEAD SCREW
5	27-8M0204714	GASKET, THERMOSTAT
6	90390A1	COVER KIT, THERMOSTAT
7	75692	THERMOSTAT
8	10-35386	SCREW, (.312-18 x 1.00), THERMOSTAT COVER
9	22-687271	FITTING, (.250-18) 90 Degree - Brass, ELBOW - WATER HOSES
10	97465	SENDER, Temperature
11	32-77653101	HOSE, (24.500 Inches Bulk), WATER DISTRIBUTION
12	22-68728	FITTING, THERMOSTAT COVER TO WATER HOSES
13	54-816311T	TIE STRAP, WATER HOSES
14	13536A7	SENSOR ASSEMBLY, Temperature
15	137151	RETAINER, SENSOR AND SENDER
16	10-98257	SCREW, (.312-18 x .500), RETAINER
17	43517T	HOUSING, REED BLOCK
18	10-28668	SCREW, (.250-20 x .875) Stainless Steel, REED BLOCK HOUSING
19	27-967611	GASKET, REED BLOCK HOUSING
20	75953	REED BLOCK
21	34-75362A1	REED ASSEMBLY
22	961832	CLAMP, Reed
23	10-823588	SCREW, (#8-32 x .187), REEDS TO REED BLOCK
24	10-92160	SCREW, (.250-20 x .75), REED BLOCK ATTACHING
25	16-270372	STUD, (.250-28 x 1.125), CARBURETOR MOUNTING
26	10-96529	SCREW, (.250-20 x 2.00), REED BLOCK ATTACHING
27	54-23567	CLIP
28	10-69079	SCREW, (#10-16 x .440)
29	8M0084613	C WASHER
30	22-15133	FITTING, BLEED HOSE Comment: (PRESS IN)
31	22-56759	FITTING, Barbed, BLEED HOSE Comment: (PRESS IN)
32	32-892024122	TUBING, (20.00 Feet Bulk), BLEED
33	21-426982	CHECK VALVE, BLEED HOSE Comment: (PRESS-IN - 13/16" LONG)

▶SWIVEL BRACKET AND STEERING ARM (29 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	1499-8710T21	SWIVEL BRACKET ASSEMBLY Comment: (GRAY)
2	26-87735	SEAL, Oil, SWIVEL BRACKET (LOWER)
3	23-818764	BUSHING, SWIVEL BRACKET (LOWER AND UPPER)
4	25-33466	O-RING, SWIVEL BRACKET (UPPER)
5	23-67668	SPACER, SWIVEL BRACKET (UPPER)
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING, SWIVEL BRACKET
8	17-67706A55	SWIVEL PIN ASSEMBLY Comment: (GRAY)
9	10-8M0176309	SCREW, (.437-20 x 7.50), STEERING ARM TO UPPER MOUNT
10	77326	MOUNT, RUBBER - UPPER Comment: (X-LONG)
11	12-66921	WASHER, UPPER MOUNT BOLT
12	12-78688	WASHER, UPPER MOUNT BOLT
13	11-8M0204653	NUT, (.437-20) Stainless Steel, UPPER MOUNT BOLT
14	92876A12	LINK ASSEMBLY, Steering
15	10-849838	SCREW, (.375-24 x 1.25), STEERING LINK TO STEERING ARM
16	11-8M0204726	NUT, (.375-24), STEERING LINK SCREW
17	12-34931	WASHER, (.406 x .734 x .063) Stainless Steel, STEERING LINK TO STEERING ARM
18	13-78854	WAVE WASHER, BOTTOM YOKE
19	86580A1	YOKE ASSEMBLY, Bottom Comment: (GRAY)
20	53-67684	RING, Retaining, BOTTOM YOKE
21	12-67670	WASHER, THRUST - SWIVEL BRACKET
22	88882	BUMPER, Top Yoke
23	8M0074846	SENDER ASSEMBLY, Trim (OLD DESIGN)
24	10-852368	SCREW, (#10-24 x .750), TRIM SENDER (OLD DESIGN)
25	10,13-26996	LOCKWASHER, Stainless Steel, TRIM SENDER SCREW (OLD DESIGN)
26	12-89302	WASHER, (.203 x .406 x .040), TRIM SENDER SCREW (OLD DESIGN)
27	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET
28	54-54457	J CLIP

▶Starter Motor (10 parts)

Ref	OEM Part #	Part Name
-	50-893893	STARTER MOTOR ASSEMBLY
1	90645	DRIVE KIT
2	13310T1	PINION ASSEMBLY, Drive
3	75660	PLATE, DRIVE END
4	10-74968	BOLT, THRU
7	79216	ARMATURE
8	898265016	BRUSH/SPRING KIT
9	898265014	HOLDER, BRUSH
10	10-68586	SCREW, BRUSH AND HOLDER
11	15386001	END CAP, COMMUTATOR

▶THROTTLE LEVER AND SHIFT SHAFT (49 parts)

Ref	OEM Part #	Part Name
1	74897T	PIVOT, TRIGGER PLATE
2	62459T	BALL JOINT ASSEMBLY, TRIGGER PLATE
3	10-32,11-45076	NUT, Brass, LINK ROD
4	76035	ROD, TRIGGER PLATE
5	10-32,11-46438	NUT, , BALL JOINT
6	41094A3	LEVER ASSEMBLY, SPARK ADVANCE
7	10-64022	SCREW, (.250-20 x 2.125), SPARK ADVANCE LEVER - STOP
8	11-64015	NUT, (.250-20), SPARK ADVANCE STOP SCREW
9	26852	CAP, Nylon, SPARK ADVANCE LEVER STOP SCREW
10	10-69560	SCREW, (.190-32 x 1.250), SPARK ADVANCE LEVER
11	10-32,11-68219	NUT, Stainless Steel, SPARK ADVANCE LEVER STOP SCREW
12	48039	CAP, SPARK ADVANCE LEVER STOP SCREW
13	410952	LEVER, THROTTLE CONTROL
14	10-818165	SCREW, (.375-16 x 1.75)
15	23-55164	BUSHING, THROTTLE LEVER
16	23-55171	BUSHING, SPARK ADVANCE LEVER
17	24-68784	SPRING, THROTTLE AND SPARK ADVANCE LEVER
18	12-68410	WASHER, SPARK ADVANCE LEVER
19	10-64022	SCREW, (.250-20 x 2.125)
20	11-64015	NUT, (.250-20), THROTTLE LEVER STOP SCREW
21	26852	CAP, Nylon, THROTTLE LEVER STOP SCREW
22	39483	LATCH, CABLE
23	10-69026	SCREW, (.250-28 x .880), CABLE LATCH TO THROTTLE LEVER
24	24-20099	SPRING, CABLE LATCH TO THROTTLE LEVER
25	11-826709109	NUT, (.250-28), CABLE LATCH SCREW
26	95829	ROD, Throttle Control
27	8M0221994	BARREL, THROTTLE CONTROL ROD
28	95791	CAM, Throttle
29	16-20353	STUD, (.250-28 x 1.750), THROTTLE CAM ATTACHING
30	23-26856	BUSHING, THROTTLE CAM
31	11-826709109	NUT, (.250-28), THROTTLE CAM STUD
32	24-41050	SPRING, THOTTLE RETURN
33	814283A2	BRACKET, ANCHOR Comment: SN# 239553 & Up
34	98889	LATCH, CONTROL CABLE
35	10-42975	DRIVE SCREW, LATCH
36	39519	CUP, BARREL RETAINER - ANCHOR BAR
37	23-26600	BUSHING, NYLON - LINK ROD
38	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel, LINK ROD
39	11-826709109	NUT, (.250-28), LINK ROD TO SHIFT SHAFT
40	10-53167T	SCREW, (.312-18 x .880), ANCHOR BRACKET ATTACHING
41	814284	GUIDE BLOCK, LINK ROD Comment: SN# 239553 & Up
42	24-20099	SPRING, LINK ROD TO GUIDE BLOCK
43	67073A1	LINK ROD ASSEMBLY
44	52100	WEAR PLATE, LINK ROD
45	8M0036768	LATCH, CONTROL CABLE FASTENING
46	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel, LATCH
47	11-826709109	NUT, (.250-28), LINK ROD
48	79932A17	SHIFT SHAFT ASSEMBLY (X-LONG)
49	13-29720	WAVE WASHER, LINK ROD

▶TOP COWL AND FRONT SHIELD (26 parts)

Ref	OEM Part #	Part Name
-	813096A1	REAR LATCH KIT
1	2196-9743T11	TOP COWL ASSEMBLY Comment: (GRAY)
2	812784	SEAL
3	815478	SEAL
4	814823	SOUND BLANKET (SIDE)
5	814837	SOUND BLANKET (TOP)
6	18755A2	FRONT SHIELD ASSEMBLY Comment: (GRAY)
7	813562	SEAL
8	10-48409	SCREW, (#10-16 x .625) Stainless Steel
9	12-8M0204666	WASHER, (.203 x .500 x .032)
10	184741	BRACKET, REAR
11	25-18506001	GROMMET
12	10-28636	SCREW, (.250-20 x .750), REAR BRACKET
13	13-26992	LOCKWASHER, (.250) Stainless Steel, REAR BRACKET SCREW
14	813096A2	HOOK
15	10-73286	SCREW, (.250-20 x .500) Stainless Steel
16	8M0207770	ROLLER
17	53-13194	RING, Retaining
18	813553	PLATE
19	187021	LOCATOR
20	893763	BRACKET ASSEMBLY, Latch Roller
21	813552	SPACER
22	10-31984	SCREW, (.312-18 x 1.375)
23	11-815848	NUT, (.312)
24	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel
25	47341A11	ROPE AND HANDLE KIT, Manual/Emergency Start (FOR MANUAL STARTING)

▶TRANSOM BRACKETS (23 parts)

Ref	OEM Part #	Part Name
-	27-89221A88	GASKET SET
1	3401-8718F8	BRACKET ASSEMBLY, Transom Comment: (STARBOARD)(GRAY)
2	3400-8716A9	BRACKET ASSEMBLY, Transom Comment: (PORT)(GRAY)
3	22-8M0169588	FITTING, Grease, PORT TRANSOM BRACKET
4	11-8M0041651	NUT, (.875-14)
5	99170A2	TILT TUBE
6	11-859133	NUT, TILT TUBE (1"-14) Comment: (GRAY)
7	25-45711	O-RING, (.612 x .103), TILT TUBE
8	13-88750	WASHER, TILT TUBE
9	11-858869	NUT, (.875-14), TILT TUBE
10	10-8M0149747	SCREW, (.500-20 x 4.500), TRANSOM BRACKET TO TRANSOM
11	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel, TRANSOM BRACKET BOLT
12	11-91962	NUT, (.500-20), TRANSOM BRACKET BOLT
13	8M0115104	LEVER ASSEMBLY, TILT LOCK
14	13-99611	WAVE WASHER, TILT LEVER
15	23-65830	NYLINER, TILT LEVER
16	99633	KNOB, TILT LEVER Comment: (GRAY)
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY, TILT LOCK
21	11-23161	NUT, (.375-24), BOLT
22	814207	STOP, TILT LEVER

▶WIRING HARNESS/STARTER SOLENOID (41 parts)

Ref	OEM Part #	Part Name
1	434292	IGNITION PLATE
2	332-7778A12	SWITCHBOX ASSEMBLY
3	10-13669	SCREW, (#12-24 x 2.00)
4	23-94453	BUSHING
5	84-62310A2	CABLE ASSEMBLY
6	10-32,11-45076	NUT, Brass
7	84-60871A10	WIRE ASSEMBLY
8	10-62568	SCREW, (#10-16 x .375)
9	84-65999A3	CABLE ASSEMBLY, Black
10	10-60411	SCREW, (1.25)
11	13-8M0204647	LOCKWASHER, (.312)
12	12-36042	WASHER
13	12-67264	WASHER, (Rubber)
14	23-67268	BUSHING
15	87-33386A3	SWITCH ASSEMLBY
16	10-38055	SCREW, (.190-32 x .620)
17	10-32,11-45076	NUT, Brass
18	10-87926	SCREW, (#10-32 x .500)
19	84-88439A4	CABLE ASSEMBLY, Battery - Negative
20	84-96220A4	HARNESS ASSEMBLY Comment: (USE WITH 62351A1 RECTIFIER)
21	88-8M0207796	FUSE, 20 Ampere
22	84-95084A2	CABLE ASSEMBLY
23	134731	HOLDER, Fuse
24	54-816311T	TIE STRAP
25	89-853654A1	SOLENOID, Starter
26	10-32,11-45076	NUT, Brass
27	13-53166	LOCKWASHER, (.312)
28	11-8M0204668	NUT, (.312-18)
29	10-31716	SCREW, (.250-20 x .620)
30	13-26992	LOCKWASHER, (.250) Stainless Steel
31	84-65999A2	CABLE ASSEMBLY, Black
32	85-78866	INSULATOR (OLD DESIGN)
33	54-47483	J CLIP
34	814422T	COVER Comment: SN# 0C239553 & Up
35	10-88447	SCREW, (.190-32 x 1.62) Comment: SN# 0C239553 & Up
36	10-690201	SCREW, (#10-32 x .875) Comment: SN# 0C239553 & Up
37	12-89302	WASHER, (.203 x .406 x .040) Comment: SN# 0C239553 & Up
38	10,13-26996	LOCKWASHER, Stainless Steel Comment: SN# 0C239553 & Up
39	8M0058226	RECTIFIER
40	10-38055	SCREW, (.190-32 x .620)
41	10-32,11-45076	NUT, Brass

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury V-200 running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Popular Products

Popular Products

Popular Products

Mercury V-200 (0C100861 THRU 0C291519) Parts & Diagrams

Categories

Refined By Clear all

Brand

Horsepower

Engine

Availability

Price

Need Help?

Images

Product

Price

Qty

Options