– Page 2 – JLM Marine Boat Parts Limited

Mercury 90 (6 CYL.) (8071020 AND UP) Parts & Diagrams

🔎 Mercury 90 (6 CYL.) Reference Library — Exploded parts diagrams (29 diagrams), specifications, common issues, and maintenance checklist.

The Mercury 90 (6 CYL.) is a 4-Stroke, Inline 4-Cylinder, EFI, SOHC outboard motor. Suited for bay boats, pontoons, and center-console fishing boats requiring reliable mid-range power.

Quick Reference Specifications

Specification	Value
Engine Type	4-Stroke, Inline 4-Cylinder, EFI, SOHC
Horsepower	90 HP
Displacement	2100 cc
Bore x Stroke	90 mm x 81 mm
Spark Plug (Type & Gap)	NGK IZFR6F-11
Engine Oil Capacity	5.2 L (5.5 quart)
Recommended Engine Oil	Mercury FourStroke Oil 10W-30
Gear Case Oil Capacity	710 mL (24 fl oz)
Idle Speed (in gear)	650 ± 50 RPM (in gear)
Full Throttle RPM Range	5000-6000
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury 90 (6 CYL.):

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury 90 (6 CYL.).

▶BOTTOM COWL AND SHIFT LINKAGE (30 parts)

Ref	OEM Part #	Part Name
1	2115-8963A1	BOTTOM COWL
2	52862A2	DRIP TRAY ASSEMBLY, BOTTOM COWL
3	37940	PAD, SOUND - DRIP TRAY
4	10-48408	SCREW, DRIP TRAY TO BOTTOM COWL (1/2")
5	32-8M0108355	HOSE, DRIP TRAY TO BOTTOM COWL (8")
6	39616	BOOT, CONTROL CABLES
7	76369	SPACER, BOTTOM COWL
8	10-48591	SCREW, SPACER TO BOTTOM COWL (1/2")
9	37637	BOOT, FUEL CONNECTOR
13	32-8M0108355	HOSE, TELL TALE (21-1/2")
14	52889	NOZZLE, TELL TALE HOSE TO BOTTOM COWL
15	10-48408	SCREW Comment: TELL TALE NOZZLE TO BOTTOM COWL (1/2")
16	22-782792	ELBOW, TELL TALE HOSE TO CYLINDER BLOCK
17	60304A54	SHIFT SHAFT ASSEMBLY, UPPER
18	23-26600	BUSHING, SHIFT SHAFT
20	73402	LINK ROD ASSEMBLY
21	12-35462	WASHER, LINK ROD
22	11-826709109	NUT, LINK ROD
23	13-29720	WASHER, WAVE - INK ROD
24	52732A6	BRACKET, ANCHOR - CONTROL CABLES
25	39519	CAP, BARREL RETAINER
26	87609A1	LEVER, NYLON - SHIFT CABLE LOCKING
27	17-47175	PIN, LOCKING LEVER AND COVER
28	39667	COVER, NYLON - SHIFT CABLE
29	87609A1	LINK, LOCKING LEVER TO COVER
30	10-35386	SCREW Comment: ANCHOR BRACKET TO CYLINDER BLOCK (1")
31	24-20099	SPRING, LINK ROD TO GUIDE BLOCK
32	37896	GUIDE BLOCK, LINK ROD
33	52100	WEAR PLATE, LINK ROD
34	8M0036768	LATCH, CONTROL CABLE FASTENING

▶CARBURETOR ASSEMBLY (22 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
--	1395-51091	REPAIR PARTS KIT (1 PER CARBURETOR) Comment: WMK-39
1	1368-7469A16	CARBURETOR (CENTER/BOTTOM) Comment: STAMPED WMK-39
2	1395-8673	FLOAT ASSEMBLY, STAMPED WMK-39
6	1395-83181	INLET NEEDLE, SEAT/GASKET - WMK-35/WMK-39
10	1395-5680	COVER, FLOAT BOWL
11	1395-5733	JET, BOWL VENT (.092)
12	1395-5734	HOSE, ECONIMIZER
13	10-52195	SCREW, FLOAT BOWL COVER
14	1395-4804	SCREW, FLOAT BOWL COVER
15	13-26995	LOCKWASHER, FLOAT BOWL COVER SCREW
17	8146791	LEVER, THROTTLE (SEE NOTE BELOW)
18	1395-6027	SCREW, THROTTLE STOP LEVER
19	1395-7942	SHAFT, THROTTLE (CENTER/BOTTOM)
21	1395-4540	SCREW, BODY (IDLE TUBE)
22	1395-7874	SHUTTER, THROTTLE
27	1395-4542	SCREW, PLUG - MAIN NOZZLE
28	1395-6029	JET, MAIN FUEL (.068) - STANDARD
29	1395-4541	SCREW, PLUG - MAIN FUEL JET CHANNEL
32	1395-4543	SCREW, BODY CHANNEL
34	27-481641	GASKET, CARBURETOR FLANGE
35	11-64809	NUT, CARBURETOR STUD

▶CARBURETOR LINKAGE CHOKE SOLENOID (31 parts)

Ref	OEM Part #	Part Name
1	54293A10	CHOKE SOLENOID Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
2	13-26996	LOCKWASHER, SOLENOID TERMINAL Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
3	11-68219	NUT, SOLENOID TERMINAL Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
4	10-25299	SCREW, CHOKE SOLENOID (3/4") Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
5	13-8M0204647	LOCKWASHER, CHOKE SOLENOID SCREW Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
6	90548A1	PLUNGER AND LINK ASSEMBLY Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
7	85943A1	LEVER, THROTTLE (UPPER CARBURETOR)
8	10-60293	SCREW, THROTTLE LEVER
8A	12-74726	WASHER, THROTTLE LEVER SCREW
9	1368-7469A16	CARBURETOR (CENTER/BOTTOM) Comment: STAMPED WMK-39
10	53720A2	THROTTLE PICK-UP BRACKET ASSEMBLY
11	10-66104	SCREW, THROTTLE BRACKET
12	28-89694	KEY, THROTTLE COUPLING
17	90242A1	KNOB, CHOKE ROD Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
18	25-20116	GROMMET, CHOKE ROD Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
19	49589	STRAP, CHOKE KNOB TO CHOKE ROD Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
20	10-77137	SCREW, STRAP TO CHOKE KNOB (5/8") Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
22	48203	CHOKE ROD Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
23	10-48591	SCREW, STRAP TO CHOKE ROD (1/2") Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
24	11-46438	NUT, STRAP TO CHOKE ROD SCREW Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
25	48152	CHOKE SHUTTER Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
26	16-69037	STUD, CHOKE SHUTTER PIVOT Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
27	11-20110	NUT, CHOKE SHUTTER STUD Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
28	35-57819	SCREEN ASSEMBLY, FILTER Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
29	10-23015	SCREW, UPPER SCREEN TO CARBURETOR (1") Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
30	24-57818	SPRING, UPPER SCREEN SCREW Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
31	11-20110	NUT, SCREEN SCREW Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
32	24-48230	SPRING, CHOKE ROD TENSION Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
33	10-657461	STUD, CHOKE ROD SPRING TO CARBURETOR Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
34	23-32427	SPACER, CHOKE ROD SPRING STUD Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW
35	11-8M0207775	NUT, CHOKE ROD SPRING STUD Comment: UNITED STATES 6026608 AND BELOW AUSTRALIA 8074512 AND BELOW CANADA 7185072 AND BELOW

▶COWLING AND FRONT COVER (15 parts)

Ref	OEM Part #	Part Name
1	2183-7928A3	FRONT COVER ASS'Y (W/O DECALS) Comment: UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
2	56849	KNOB, FRONT COVER
3	12-30771	WASHER, COVER KNOB (RUBBER)
4	12-59572	WASHER, COVER KNOB (PLASTIC)
5	24-30772	SPRING, TENSION - KNOB
6	17-29077	ROLL PIN, TENSION SPRING TO KNOB
7	31089	STRIP, SOUND Comment: UNITED STATES 5825802 AND BELOW AUSTRALIA 8071019 AND BELOW CANADA 7170897 AND BELOW
8	38674	BAG, STARTER ROPE
9	35769	SEAL, SOUND - UPPER Comment: UNITED STATES 5825802 AND BELOW AUSTRALIA 8071019 AND BELOW CANADA 7170897 AND BELOW
9A	94924	SEAL, SOUND - UPPER Comment: UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
10	53334	SEAL, SOUND - TOP Comment: UNITED STATES 5825802 AND BELOW AUSTRALIA 8071019 AND BELOW CANADA 7170897 AND BELOW
11	2136-4660A4	WRAP AROUND COWL ASSEMBLY, (W/O DECALS)
12	46785A1	COWL LATCH ASSEMBLY
13	30413	HOOK, COWL LATCH
14	30021	BLANKET, SOUND (EARLY MODELS ONLY)

▶CRANKSHAFT, PISTONS AND CONNECTING RODS (31 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	436-9072A1	CRANKSHAFT ASSEMLBY
3	30-62567T	BALL BEARING, UPPER
4	30-63742T	BALL BEARING, LOWER
5	54196A6	CARRIER ASSEMBLY, "O" RING
6	65800	"O" RING, CARRIER
7	535-5397A4	CENTER MAIN BEARING ASSEMBLY
8	17-20032	DOWEL PIN, CENTER MAIN BEARING
9	29-714221	NEEDLE BEARING, OUTER RACE
10	26113T	RACE, OUTER (PAIR)
11	53-26933	SNAP RING, OUTER RACE
12	17-47246	DOWEL PIN, STEPPED
13	10-22968	SCREW, CENTER MAIN BEARING
14	11-8M0207775	NUT, BEARING SCREW
15	540-5266T5	MAIN BEARING ASSEMBLY, VALVE TYPE
16	17-20032	DOWEL PIN, MAIN BEARING
17	10-45775	SCREW, MAIN BEARING
18	11-45774	NUT, MAIN BEARING SCREW
19	34-56007A1	REED SET, MATCHED
20	34-56008	REED STOP, REED VALVES
21	10-62204	SCREW, REED STOP
22	11-53153	NUT, REED STOP SCREW
23	774-9137A14	PISTON/PISTON PIN ASS'Y (.030 OVERSIZE)
24	53-857196	LOCK RING, PISTON PIN
25	39-88392A12	PISTON RING (.030 OVERSIZE)
26	624-8101A3	CONNECTING ROD AND CAP ASSEMBLY
27	31-62596A1	BEARING ASSEMBLY, CRANKPIN
28	10-91012	SCREW, CONNECTING ROD - W/O NUTS
29	11-49091	NUT, CONNECTING ROD SCREW - WITH NUTS
30	29-8M0214934	NEEDLE BEARING, PISTON PIN
31	12-8M0032839	WASHER, NEEDLE LOCATING

▶CYLINDER BLOCK AND CRANKCASE ASSEMBLY (26 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	852-8311A4	BLOCK/CRANKCASE ASS'Y Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
2	27-53862	GASKET, CRANKCASE TO CYLINDER BLOCK
3	66517	RESTRICTION, CRANKCASE BLEED
4	16-64936	STUD, CARBURETOR (1-3/16")
5	16-64281	STUD, CRANKCASE TO EXTENSION PLATE (1-7/8")
6	17-43044	DOWEL PIN, CRANKCASE TO CYLINDER BLOCK
7	17-63779	DOWEL PIN, CYLINDER BLOCK TO MAIN BEARING
8	16-64282	STUD, CYLINDER BLOCK TO PLATE (4")
9	86473	COVER, STARTER MOTOR - TOP
10	10-73279	SCREW, TOP COVER (1-7/8")
11	13-8M0204647	LOCKWASHER, TOP COVER SCREWS
13	76867	COVER, STARTER MOTOR - BOTTOM
14	10-73279	SCREW, BOTTOM COVER (1-7/8")
15	13-8M0204647	LOCKWASHER, BOTTOM COVER SCREW
17	10-74824	SCREW, CRANKCASE TO CYLINDER BLOCK (1-1/4")
18	12-22753	WASHER, CRANKCASE SCREWS
19	11-29250	NUT, CRANKCASE SCREWS (LOWER)
20	10-20359	SCREW, CENTER MAIN BEARING LOCKING
21	14-20091	TAB WASHER, BEARING LOCKING SCREW
25	21-42866	CHECK VALVE, BLEED HOSE - UPPER
26	32-9938779	HOSE, BLEED (22")
27	21-428671	CHECK VALVE, BLEED HOSE - LOWER
28	22-996642	ELBOW, BALANCE HOSE
29	32-8M0108355	HOSE, BALANCE - MAIN BEARING (6-1/4")
30	22-97231	TEE, BLEED BASE Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP

▶DRIVE SHAFT HOUSING ASSEMBLY (38 parts)

Ref	OEM Part #	Part Name
1	1573-5239A4	DRIVE SHAFT HOUSING ASSEMBLY
2	16-56295	STUD, DRIVE SHAFT HOUSING
3	19-64649	PLUG, PLASTIC - TRIM TAB SCREW HOLE
5	37417	COVER, TRIM - DRIVE SHAFT HOUWING
6	10-57807	SCREW, TRIM COVER TO BOTTOM COWL
6A	25-92012	GROMMET, PLASTIC - TRIM COVER SCREW
6B	84-88238T01	GROUND STRAP ASSEMBLY, TRIM COVER SCREW
6C	10-62568	SCREW, GROUND STRAP ATTACHING
7	32-60897	TUBE, WATER INLET
8	78184T	EXHAUST TUBE
8A	65638	BOOT, EXHAUST TUBE
11	11-69254	NUT, POWERHEAD STUDS (3/8-24)
12	12-20553	WASHER, POWERHEAD STUDS
14	92704	GUIDE, PUSH ROD Comment: NOT USED WITH FULL POWER TRIM UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
15	43417A2	ROD, PUSH Comment: NOT USED WITH FULL POWER TRIM UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
16	11-28770	NUT, JAM - PUSH ROD Comment: NOT USED WITH FULL POWER TRIM UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
17	89813	YOKE, PUSH ROD Comment: NOT USED WITH FULL POWER TRIM UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
19	18-25191	COTTER PIN, PUSH ROD Comment: NOT USED WITH FULL POWER TRIM
20	75296	MOUNT, RUBBER - UPPER
21	12-47840	WASHER, RUBBER - UPPER MOUNT BOLT
22	12-31263	WASHER, UPPER MOUNT BOLT
23	11-8M0204653	NUT, UPPER MOUNT BOLT
24	75299	MOUNT, RUBBER - LOWER
25	10-75284	SCREW, LOWER MOUNT (5-1/2")
26	12-49339	WASHER, LOWER MOUNT SCREW
27	11-25096	NUT, LOWER MOUNT SCREW
28	25067	BUMPER, RUBBER - LOWER MOUNTING SCREW
30	11-8M0204653	NUT, GEAR HOUSING STUDS
31	12-45176	WASHER, GEAR HOUSING STUDS
32	11-29489	NUT, GEAR HOUSING STUDS
33	12-45176	WASHER, GEAR HOUSING STUDS
34	35608	CLAMP, LOWER MOUNT
35	24-35522	SPRING, TENSION - LOWER MOUNT CLAMP
36	10-29256	SCREW, LOWER MOUNT CLAMP
37	35474T	COVER, LOWER MOUNT CLAMP
38	11-35521	NUT, LOWER MOUNT CLAMP COVER
39	10-87884	SCREW, COVER TO LOWER CLAMP MOUNT
40	88238A10	WIRE ASSEMBLY, GROUND

▶END CAPS, MANIFOLD AND EXHAUST COVERS (32 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	852-8311A4	CYL. BLOCK/CRANKCASE ASS'Y Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
2	1161-7616A2	END CAP ASSEMBLY
3	26-41953	OIL SEAL, END CAP
4	25-47254	"O" RING
5	15-73644A1	SHIM, END CAP (.006-10)
6	10-812618	SCREW, END CAP (1")
7	1148-5410T1	END CAP ASSEMBLY, LOWER
9	26-41953	OIL SEAL, END CAP
10	25-32546	"O" RING, END CAP
11	15-20085A1	SHIM, END CAP (.005-10)
12	10-30225	SCREW, END CAP (1")
13	71808	COVER, WATER JACKET
14	27-721421	GASKET, WATER JACKET COVER
15	10-53167T	SCREW, WATER JACKET COVER (7/8")
16	12-8M0042642	WASHER, WATER JACKET COVER SCREW
17	27-854952	GASKET, CYLINDER BLOCK TO BAFFLE PLATE
18	757781	BAFFLE PLATE, EXHAUST MANIFOLD
19	27-854972	GASKET Comment: BAFFLE PLATE TO EXHAUST MANIFOLD COVER
20	99896A1	COVER, EXHAUST MANIFOLD
21	10-53576	SCREW, MANIFOLD COVER
23	1023-8368A1	COVER, CYLINDER BLOCK Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
24	27-981853	GASKET, CYLINDER BLOCK Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
25	10-8M0214943	SCREW, COVER (1")
27	22-68307	PIPE PLUG, CYLINDER BLOCK COVER
28	37440	BRACKET, MOUNT SUPPORT
29	10-35386	SCREW, BRACKET TO CYLINDER BLOCK (1")
30	87872	COVER, TRANSFER PORT
31	27-856730	GASKET, TRANSFER PORT COVER
32	10-28636	SCREW, TRANSFER PORT COVER (3/4")
33	46933A3	GROUND STRAP ASSEMBLY Comment: CYLINDER BLOCK COVER
34	10-62568	SCREW, GROUND STRAP (3/8")

▶EXHAUST EXTENSION PLATE (21 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	43289A2	PLATE ASSEMBLY, EXHAUST EXTENSION
2	23-27132	BUSHING, NYLON - EXHAUST EXTENSION PLATE
3	37918	SEAL, EXHAUST EXTENSION PLATE
4	99358	STRIP, RETAINING - PLATE SEAL
5	10-37571	SCREW, SEAL AND RETAINING STRIP (1/2")
6	17-23784	DOWEL PIN, EXHAUST EXTENSION PLATE
7	27-692381	GASKET, POWERHEAD
8	10-66023	SCREW, ADAPTOR PLATE TO HOUSING PLATE (2")
10	10-66023	SCREW Comment: HOUSING PLATE TO DRIVE SHAFT HOUSING (2")
11	27-661021	GASKET, PLATE TO DRIVE SHAFT HOUSING PLATE
14	26-60898	SEAL, DRIVE SHAFT HOUSING PLATE
15	43290A4	PLATE ASSEMBLY, DRIVE SHAFT HOUSING
16	26-38970	SEAL, RUBBER - WATER INLET TUBE
17	17-23784	DOWEL PIN, DRIVE SHAFT HOUSING PLATE
18	27-62362	GASKET, MEGAPHONE
19	99699	MEGAPHONE, EXHAUST
20	10-60480	SCREW, MEGAPHONE (1-1/8")
21	12-8M0204649	WASHER, MEGAPHONE SCREW
22	12-20553	WASHER, POWERHEAD STUD
23	11-82671013	NUT, POWERHEAD STUD

▶FLYWHEEL, STARTER MOTOR AND STATOR (19 parts)

Ref	OEM Part #	Part Name
1	19-45907	PLUG, FLYWHEEL
2	11-52901	NUT, FLYWHEEL
3	12-33001	WASHER, FLYWHEEL
4	248-8722A7	FLYWHEEL ASSEMBLY
5	10-32417	SCREW, FLYWHEEL PLATE
6	10-68997	SCREW, FLYWHEEL HUB
7	398-5454A17	STATOR ASSEMBLY
8	10-75840	SCREW, STATOR (7/8")
9	96455A9	TRIGGER PLATE
10	54-61001	CLAMP, TRIGGER HARNESS
11	50-898265010	STARTER MOTOR
12	23-8M0034918	COLLAR, STARTER MOTOR
13	23-56774	SPACER, STARTER MOTOR
14	8M0043376	STOP, RUBBER - STARTER MOTOR
15	84-93388A1	WIRE, PLATE TO STARTER MOTOR (BLACK)
16	10-69035	SCREW, CABLE TO STARTER MOTOR
17	84-93389A6	WIRE, SOLENOID TO STARTER MOTOR (YELLOW)
18	13-26992	LOCKWASHER, STARTER MOTOR TERMINAL
19	11-64015	NUT, STARTER MOTOR TERMINAL

▶FUEL PUMP AND FUEL LINE ASSEMBLY (43 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	13527A1	FUEL PUMP ASSEMBLY
2	21-8M0084277	CHECK VALVE ASSEMBLY
3	89031A3	DIAPHRAGM ASSEMBLY
8	35-59072	SCREEN, FUEL INLET
9	25-35480	"O" RING, FUEL INLET COVER
10	25-38933	GASKET, COVER SCREW
11	23004	RETAINER, CHACK VALVE
12	10-43725	SCREW, RETAINER
13	86295	BASE, FUEL PUMP
14	879901	PULSE CHAMBER, FUEL PUMP
15	35-91078A1	COVER, FUEL INLET
16	10-89766	SCREW, FUEL FILTER COVER (5/8")
16A	22-64705	FITTING, INLET COVER
17	10-73013	SCREW, FUELD PUMP (1-1/2")
18	13-26996	LOCKWASHER, FUEL PUMP SCREW
19	22-19688	FITTING, FUEL OUTLET
20	32-8M0108355	FUEL LINE, FUEL PUMP TO CARBURETOR
21	54-68424	CLAMP, FUEL LINE ATTACHING
22	22-19688	FITTING, ELBOW - WUPPER CARBURETOR
23	22-73318	TEE, FUEL LINE
24	22-64706001	FITTING, TEE - CENTER CARBURETOR
25	22-19688	FITTING, ELBOW - LOWER CARBURETOR
26	32-8M0108355	FUEL LINE, ADAPTOR TO FUEL PUMP (11")
27	22-63981	ELBOW, FUEL LINE TO ADAPTOR
28	30186	ADAPTOR, CHECK UNIT (FUEL LINE) Comment: IDENTIFIED BY 30186 CASTING ON REF. #28
29	30187	STEM, CHECK UNIT ADAPTORS Comment: IDENTIFIED BY 30186 CASTING ON REF. #28
30	24-30189	SPRING, ADAPTOR STEM Comment: IDENTIFIED BY 30186 CASTING ON REF. #28
31	25-16524	"O" RING, ADAPTOR STEM
32	30188	CUP WASHER, ADAPTOR
33	10-36154	SCREW, ADAPTOR TO BOTTOM COWL (1-3/8")
34	11-36069	NUT, ADAPTOR SCREW
35	42859A2	VALVE, ENRICHER Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
36	22-90275	CONNECTOR, ENRICHER VALVE (BOTTOM) Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
37	22-73817	CONNECTOR, ENRICHER VALVE (SIDE) Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
38	90345	BRACKET, ENRICHER VALVE Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
39	10-89075	SCREW, VALVE TO BRACKET Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
40	10-73286	SCREW, BRACKET TO REED BLOCK HOUSING (1/2") Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
41	86-45915	TERMINAL BLOCK, REED BLOCK HOUSING Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
42	10-69079	SCREW, TERMINAL BLOCK Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
43	10-20411	SCREW, WIRE TO TERMINAL BLOCK Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
44	32-9912688	FUEL LINE, ENRICHER VALVE Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
45	22-90275	CONNECTOR, TOP CARBURETOR (90 DEG.)

▶GEAR HOUSING (DRIVE SHAFT) (49 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
--	1655-7333T24	GEAR HOUSING ASSEMBLY, COMPLETE
1	1655-7333T23	GEAR HOUSING ASSEMBLY
1A	22-85822A10	CONNECTOR ASSEMBLY, SPEEDOMETER
2	17-8M0084726	DOWEL PIN, GEAR HOUSING LOCATING
3	16-57921	STUD, GEAR HOUSING (4")
4	16-8M0133358	STUD, GEAR HOUSING (2-1/16)
5	16-8M0034463	STUD, WATER PUMP (3-3/8")
6	16-69501	STUD, WATER PUMP (3-1/8")
7	31-32898T	ROLLER BEARING, DRIVE SHAFT
8	45-42646	DRIVE SHAFT
9	43-68548T3	PINION GEAR, DRIVE SHAFT
10	11-35921	NUT, PINION GEAR TO DRIVE SHAFT
11	15-57007A1	SHIM, BALL BEARING
12	31-69220T	ROLLER BEARING, DRIVE SHAFT
14	27-8M0214962	GASKET, WATER PUMP
15	25-8M0214923	"O" RING, WATER PUMP
16	46-96146A5	WATER PUMP BASE ASSEMBLY
17	26-94038	OIL SEAL, WATER PUMP
18	26-16977	OIL SEAL, WATER PUMP
19	17-35973	DOWEL PIN, WATER PUMP
20	27-8M0090319	GASKET, LOWER - WATER PUMP TO FACE PLATE
21	8M0204677	FACE PLATE
22	27-858524	GASKET, UPPER - FACE PLATE TO WATER PUMP
23	46-96148T1	WATER PUMP BODY ASSEMBLY
24	48752T	INSERT, WATER PUMP
26	26-38970	SEAL, RUBBER - WATER INLET TUBE
27	47-89984T4	IMPELLER, WATER PUMP
28	28-8M0214992	KEY, IMPELLER DRIVE
29	10-8M0215009	SCREW, WATER PUMP (14-8 - HEX WASHER HEAD)
30	13-26992	LOCKWASHER, WATER PUMP SCREW
31	12-8M0204649	WASHER, WATER PUMP SCREW AND STUD
32	11-35888	NUT, WATER PUMP SCREW
33	12-36001	WASHER, WATER PUMP STUD
34	11-82670911	,NUT, WATER PUMP STUD
35	25-8M0214918	RING, RUBBER - DRIVE SHAFT
36	23-29804T	SLEEVE, GUIDE - WATER INLET TUBE
37	37641001	SEAL, EXHAUST
38	38051	PLATE, SUPPORT - EXHAUST TUBE SEAL
39	76062A1	SHAFT ASSEMBLY, SHIFT - LOWER
40	53-29641	"E" RING, RETAINING - SHIFT SHAFT
41	25-25439	"O" RING, SHIFT SHAFT BUSHING
42	23-77631A2	BUSJING ASSEMBLY, SHIFT SHAFT
43	26-8M0204708	OIL SEAL, SHIFT SHAFT BUSHING
44	12-77674	WASHER, RUBBER - SHIFT SHAFT BUSHING
45	78036	SPACER, LOWER Comment: NOT USED WITH FULL POWER TRIM
46	43308T1	CAM, REVERSE LOCKING Comment: NOT USED WITH FULL POWER TRIM
47	22-8M0058389	PLUG, DRAIN (MAGNETIC)
48	12-191833	WASHER, GREASE FILLER AND VENT HOLE SCREW

▶GEAR HOUSING (PROPELLER SHAFT) (32 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	1655-7333T23	GEAR HOUSING ASSEMBLY
49	760394	SHIFT CAM
50	30625	CAM FOLLOWER
51	30624	SLIDE, CROSS PIN
52	24-30622	SPRING, COMPRESSION - CAM FOLLOWER
53	15-30923A1	SHIM, BEARING OURTER RACE (.002-3-5-10)
54	31-30894A1	TAPERED ROLLER BEARING ASSEMBLY
55	31-30895T	ROLLER BEARING, FORWAR GEAR
56	43-68447T1	FORWARD GEAR
57	52-822539T	RATCHET, SLIDING GEAR
58	17-8M0100263	CROSS PIN, RATCHET TO PROPELLER SHAFT
59	24-30893	SPRING, RETAINING - CROSS PIN
60	44-93003	PROPELLER SHAFT
61	43-76250T	REVERSE GEAR
62	12-76358	WASHER, THRUST - BEARING CARRIER
63	25-29976	"O" RING, BEARING CARRIER
64	41529T2	BEARING CARRIER ASS'Y - WITH GREASE FITTING
64A	22-8M0169588	GREASE FITTING - WITH GREASE FITTING
65	31-30956T	ROLLER BEARING, BEARING CARRIER
66	26-8M0205729	OIL SEAL (OUTSIDE) - CUTTER
67	28-30281	KEY, LOCATING - BEARING CARRIER
68	14-52700	TAB WASHER, GEAR HOUSING COVER
69	52699	COVER, GEAR HOUSING
70	97-31640Q4	TRIM TAB, GEAR HOUSING
71	10-66024	SCREW, TRIM TAB TO GEAR HOUSING (1-3/4)
72	12-45176	WASHER, DRIVE SHAFT HOUSING STUDS
73	11-8M0204653	NUT, DRIVE SHAFT HOUSING STUDS
74	10-65210	SCREW, GEAR HOUSING
75	13191Q01	THRUST HUB
76	14-816629Q	TAB WASHER, PROPELLER NUT
77	11-52707Q1	PROPELLER NUT

▶HYDRAULIC PUMP ASSEMBLY (METAL RESERVOIR) (18 parts)

Ref	OEM Part #	Part Name
-	92975A32	HYDRAULIC PUMP ASSEMBLY, COMPLETE
1	25-48171	"O" RING, HYDRAULIC PUMP
2	392-7734	VALVE BODY AND GEAR ASSEMBLY
3	10-20411	SCREW, VALVE BODY TO RESERVOIR
4	392-7735	SEAL, RESERVOIR TO VALVE BODY AND GEAR
5	392-2939	RESERVOIR ASSEMBLY
6	10-62269	SCREW, VENT - HYDRAULIC PUMP
7	10-79953Q04	SCREW, FILLER - HYDRAULIC PUMP
8	12-191833	WASHER, SEALING - FILLER SCREW
9	392-2623	WASHER, THRUST - ARMATURE
10	392-2943	ARMATURE, FIELD AND FRAME
11	392-2942	FIELD AND FRAME ASSEMBLY
12	392-2944	BALL, COMMUTATOR END PLATE
13	392-2940	PLATE ASSEMBLY, COMMUTATOR END
14	392-8989	BRUSH SET, COMMUTATOR END PLATE
15	392-2529	SPRING SET, BRUSH TENSION
16	392-2938	BOLT SET Comment: THRU - PLATE AND FRAME TO RESERVOIR
17	13-26996	LOCKWASHER, THRU BOLT

▶HYDRAULIC PUMP ASSEMBLY (PLASTIC RESERVOIR) (16 parts)

Ref	OEM Part #	Part Name
-	92975A32	HYDRAULIC PUMP ASSEMBLY
1	25-48171	"O" RING, HYDRAULIC PUMP
2	92975A32	VALVE BODY AND GEAR ASSEMBLY
3	10-69570	SCREW, VALVE BODY TO RESERVOIR
4	392-7735	SEAL, RESERVOIR TO VALVE BODY AND GEAR
5	392-7731	RESERVOIR ASSEMBLY (PLASTIC)
6	392-7732	WASHER, THRUST - ARMATURE
7	392-7729	ARMATURE, FIELD AND FRAME
8	392-8261	FIELD AND FRAME ASSEMBLY
9	392-7730	BALL, COMMUTATOR END PLATE
10	392-8262	PLATE ASSEMBLY, COMMUTATOR END
11	392-8989	BRUSH SET, COMMUTATOR END PLATE
12	392-2529	SPRING SET, BRUSH TENSION
13	392-7733	BOLT SET Comment: THRU - PLATE AND FRAME TO RESERVOIR
14	392-7727	COUPLER AND SHAFT
15	392-7728	FILL PLUG, RESERVOIR

▶MISCELLANEOUS PARTS/ACCESSORIES (1 parts)

Ref	OEM Part #	Part Name
-	37-13137A87	DECAL SET

▶POWER TRIM COMPONENTS (WITH CIRCUIT BREAKER AND FUSE) (40 parts)

Ref	OEM Part #	Part Name
--	25-48171	"O" RING, MANIFOLD PLATE (SEE REF. #2)
1	92975A32	HYDRAULIC PUMP ASS'Y Comment: (PLASTIC RESERVOIR) SEE NOTE
2	25-48171	"O" RING, MANIFOLD PLATE
3	10-79953Q04	SCREW, FILLER - HYDRAULIC PUMP
4	12-191833	WASHER, SEALING - FILLER SCREW
5	10-62269	SCREW, VENT - HYDRAULIC PUMP
6	45336	PLATE, MANIFOLD
7	45197A2	CONTROL VALVE ASSEMBLY
8	25-45254	"O" RING, CONTROL VALVE (3/4" O.D.)
9	25-48171	"O" RING, CONTROL VALVE (1/2" O.D.)
10	25-45253	"O" RING, CONTROL VALVE (5/8" O.D.)
11	10-56500	SCREW Comment: VALVE AND MANIFOLD PLATE TO PUMP (1-1/4")
12	22-46008	PLUG, CONTROL VALVE (1/2-20")
13	84-79147A3	CONNECTOR AND HARNESS
14	45377T	BRACKET, MOUNTING
15	10-35386	SCREW Comment: MOUNTING BRACKET TO HYDRAULIC PUMP (1")
16	13-39107	LOCKWASHER, MOUNTING BRACKET SCREW
17	11-21908	NUT, MOUNTING BRACKET SCREW
18	10-68298	BOLT, HYDRAULIC PUMP TO BOAT (3-1/4")
19	11-82671112	NUT, HYDRAULIC PUMP BOLT
20	94279	BRACKET, MOUNTING - STARTER SOLENOID
21	10-28638	SCREW Comment: MOUNTING BRACKET TO HYDRAULIC PUMP
22	11-24656	NUT Comment: MOUNTING BRACKET TO HYDRAULIC PUMP THRU BOLT
23	8M0185622	STARTER SOLENOID
24	8,13-26995	LOCKWASHER, SOLENOID TERMINAL
25	11-26419	NUT, SOLENOID TERMINAL (8-32)
26	13-26992	LOCKWASHER, SOLENOID TERMINAL (1/4)
27	11-94330	NUT, SOLENOID TERMINAL (1/4-20)
28	85-861680	BOOT, RUBBER - STARTER SOLENOID TERMINAL
29	10-41508	SCREW Comment: STARTER SOLENOID TO MOUNTING BRACKET
30	94275	LINK, SOLENOID TO SOLENOID
31	84-79138A1	BATTERY LEAD (NEGATIVE)
32	88-8M0085705	CIRCUIT BREAKER (20AMP.)
33	10-8M0113176	SCREW, CIRCUIT BREAKER
34	11-45076	NUT, CIRCUIT BREAKER TERMINAL (10-32)
35	84-87379A5	WIRE, SOLENOID TO CIRCUIT BREAKER (RED)
36	88-79023T90	FUSE ASSEMBLY (90 AMP.)
37	12-96457	WASHER, FUSE TERMINAL
38	11-21825	NUT, FUSE TERMINAL (1/4-28)
39	84-61600A9	WIRE, STARTER SOLENOID (BLACK)

▶POWER TRIM COMPONENTS (WITHOUT CIRCUIT BREAKER AND FUSE) (39 parts)

Ref	OEM Part #	Part Name
--	25-48171	"O" RING, MANIFOLD PLATE (SEE REF. #2)
1	92975A32	HYDRAULIC PUMP ASS'Y
2	25-48171	"O" RING, MANIFOLD PLATE
3	10-79953Q04	SCREW, FILLER - HYDRAULIC PUMP
4	12-191833	WASHER, SEALING - FILLER SCREW
5	10-62269	SCREW, VENT - HYDRAULIC PUMP
6	32988	BATTERY LEAD (NEGATIVE)
7	45336	PLATE, MANIFOLD
8	45197A2	CONTROL VALVE ASSEMBLY
9	25-45254	"O" RING, CONTROL VALVE (3/4" O.D.)
10	25-48171	"O" RING, CONTROL VALVE (1/2" O.D.)
11	25-45253	"O" RING, CONTROL VALVE (5/8" O.D.)
12	10-56500	SCREW Comment: VALVE AND MANIFOLD PLATE TO PUMP (1-1/4")
13	22-46008	PLUG, CONTROL VALVE (1/2-20")
14	84-74023A1	CONNECTOR AND HARNESS
15	45377T	BRACKET, MOUNTING
16	10-35386	SCREW Comment: MOUNTING BRACKET TO HYDRAULIC PUMP (1")
17	13-39107	LOCKWASHER, MOUNTING BRACKET SCREW
18	11-21908	NUT, MOUNTING BRACKET SCREW
19	10-68298	BOLT, HYDRAULIC PUMP TO BOAT (3-1/4")
20	11-82671112	NUT, HYDRAULIC PUMP BOLT
21	89-853654A1	STARTER SOLENOID
22	10,13-26996	LOCKWASHER, SOLENOID TERMINAL
23	10,11-68219	NUT, SOLENOID TERMINAL
24	13-8M0204647	LOCKWASHER, SOLENOID TERMINAL (5/16")
25	11-8M0204668	NUT, SOLENOID TERMINAL (5/16")
26	46265	BOOT, RUBBER - STARTER SOLENOID TERMINAL
27	74407T	BRACKET, MOUNTING - STARTER SOLENOID
28	10-21140	SCREW Comment: MOUNTING BRACKET TO HYDRAULIC PUMP (1/2")
29	13-26992	LOCKWASHER, MOUNTING BRACKET SCREW
30	11-24656	NUT Comment: MOUNTING BRACKET TO HYDRAULIC PUMP THRU BOLT
31	269011	BUMPER, RUBBER - SOLENOID BRACKET
32	55992	JUMPER WIRE (NEGATIVE)
33	74406	BRACKET, MOUNTING - STARTER SOLENOID
34	10-69028	SCREW Comment: MOUNTING BRACKET TO HYDRAULIC PUMP (3/4")
35	13-26992	LOCKWASHER, MOUNTING BRACKET SCREW
36	10-34290	SCREW Comment: STARTER SOLENOID TO MOUNTING BRACKET (5/8")
37	13-26992	LOCKWASHER, STARTER SOLENOID SCREW
38	11-21825	NUT, STARTER SOLENOID SCREW

▶POWER TRIM CYLINDER REPAIR KITS (USE WITH 76509A3) (2 parts)

Ref	OEM Part #	Part Name
-	64507A1	REPAIR KIT (SEE NOTE BELOW)
12	64505A1	RETAINER ASSEMBLY, PISTON

▶POWER TRIM CYLINDER REPAIR KITS (USE WITH 92194A14) (1 parts)

Ref	OEM Part #	Part Name
-	92188A2	REPAIR KIT (SEE NOTE BELOW)

▶PROPELLERS (RIGHT HAND ROTATION) (1 parts)

Ref	OEM Part #	Part Name
-	48-77350A45	PROPELLER ASSEMBLY (ALUMINUM)(PITCH 23") Comment: 3 BLADES

▶STARTER MOTOR ASSEMBLY (15 parts)

Ref	OEM Part #	Part Name
-	50-898265010	STARTER MOTOR ASSEMBLY
1	90644	DRIVE KIT
2	685753	DRIVE ASSEMBLY
3	75660	PLATE, DRIVE END
4	10-74968	BOLT, THRU
5	13-61789	LOCKWASHER, THRU BOLT
6	74964	ARMATURE
7	898265016	BRUSH SET
8	23-57387	BUSHING, INSULATING
9	12-38013	WASHER, INPUT STUD
10	13-26992	LOCKWASHER, INPUT STUD
11	11-20890	NUT, INPUT STUD
12	898265014	HOLDER, BRUSH
13	10-68586	SCREW, BRUSH AND HOLDER
14	15386001	END CAP, COMMUTATOR

▶SWITCH BOX AND STARTER SOLENOID (25 parts)

Ref	OEM Part #	Part Name
1	89748T	PLATE, ELECTRICAL MOUNTING
2	10-455611	SCREW, PLATE TO CYLINDER BLOCK (1-1/8")
3	12-8M0204649	WASHER, PLATE SCREW
4	87-33386A3	SWITCH ASSEMBLY, MERCURY
5	10-25764	SCREW, MERCURY SWITCH TO PLATE (5/8")
6	11-45076	NUT, WIRE TO MERCURY SWITCH
7	8M0058226	RECTIFIER
8	10-25764	SCREW, RECTIFIER TO IGNITION PLATE (5/8")
9	11-45076	NUT, RECTIFIER TERMINALS
10	89-8M0185149	STARTER SOLENOID Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
11	8,13-26995	LOCKWASHER, SOLENOID TERMINALS Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
12	11-26419	NUT, SOLENOID TERMINALS (8-32) Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
13	13-26992	LOCKWASHER, SOLENOID TERMINALS (1/4") Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
14	11-94330	NUT, SOLENOID TERMINALS (1/4 - 20) Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
15	10-38601	SCREW, STARTER SOLENOID TO PLATE (1/2")
16	13-26992	LOCKWASHER, STARTER SOLENOID SCREW
17	46265	BOOT, TERMINAL - STARTER SOLENOID
18	90547	LOCATOR, STARTER SOLENOID
19	332-7778A12	SWITCH BOX
20	10-20619	SCREW, SWITCH BOX (1-3/8")
21	23-94304	SPACER, SWITCH BOX SCREW
22	84-60871A10	WIRE ASSEMBLY, SWITCH BOX
23	10-62568	SCREW, WIRE
24	84-62310A3	CABLE ASSEMBLY Comment: SWITCH BOX TO SWITCH BOX (WHITE/BLACK)
25	11-45076	NUT, SWITCH BOX TERMINAL

▶SWIVEL BRACKET ASSEMBLY (15 parts)

Ref	OEM Part #	Part Name
1	1482-7670A5	SWIVEL BRACKET ASSEMBLY
3	23-69341	BUSHING, SWIVEL BRACKET
4	12-69342	WASHER, SWIVEL PIN - UPPER
5	26-37448	OIL SEAL, SWIVEL BRACKET
7	22-8M0169589	GREASE FITTING, SWIVEL BRACKET
10	13-88507	WAVE WASHER, SWIVEL PIN - LOWER
11	28205T	STRAP STOP Comment: DRIVE SHAFT HOUSING TO SWIVEL BRACKET
12	10-28200	SCREW Comment: STRAP STOP TO DRIVE SHAFT HOUSING (2-7/8")
13	11-25269	NUT, STRAP STOP FASTENING SCREW
14	17-73593A2	SWIVEL PIN AND ARM ASSEMBLY
15	73984T	BOTTOM YOKE
16	53-73591	RETAINING REING, BOTTOM YOKE
17	28203	BUMPER, STEERING ARM
18	10-49554	BOLT, STEERING ARM TO UPPER MOUNT (5-7/8")
19	11-8M0204653	NUT, STEERING ARM BOLT

▶THROTTLE LEVER AND LINK RODS (40 parts)

Ref	OEM Part #	Part Name
1	79900	LEVER, THROTTLE
2	10-31830	SCREW, THROTTLE LEVER TO EXHAUST COVER
3	12-8M0042641	WASHER, THROTTLE LEVER SCREW
4	23-45818	BUSHING, THROTTLE LEVER SCREW
5	11-8M0204726	NUT, THROTTLE LEVER SCREW
6	37587	SWIVEL, THROTTLE LEVER TO THROTTLE CABLE
7	11-35888	NUT, THROTTLE CABLE TO SWIVEL
8	10-75168	SCREW, ADJUSTING - THROTTLE LEVER
9	11-29598	NUT, ADJUSTING SCREW
10	52023	CAP, NYLON - ADJUSTING SCREW
11	77013A1	SWIVEL ASSEMBLY, THROTTLE LEVER
12	23-26856	BUSHING, SWIVEL
13	12-73288	WASHER, SWIVEL
14	13-29402	WAVE WASHER, SWIVEL
15	11-45774	NUT, SWIVEL TO THROTTLE LEVER
16	85300	LINK ROD, THROTTLE
17	23-74213	SWIVEL, LINK ROD TO THROTTLE CAM
18	85441	THROTTLE CAM
19	85082	HOUSING, THROTTLE - UPPER
20	24-95721	SPRING, TORSION - SHAFT
21	12-85303	WASHER, PLASTIC - THROTTLE CAM
22	79903F1	HOUSING, THROTTLE - LOWER
23	13-86498	WAVE WASHER, SHAFT
24	87937	SHAFT, THROTTLE AND SPARK ADVANCE
25	10-28239	SCREW, THROTTLE HOUSING
26	12-35462	WASHER, THROTTLE HOUSING SCREW
27	11-8267088	NUT, THROTTLE HOUSING SCREW
28	10-75168	SCREW, ADJUSTING - LOWER HOUSING (2-1/4")
29	11-29598	NUT, ADJUSTING SCREW
30	52023	CAP, NYLON - ADJUSTING SCREW
31	10-60464	SCREW, ADJUSTING - LOWER HOUSING (2-1/8")
32	11-68219	NUT, ADJUSTING SCREW
33	48039	CAP, NYLON - ADJUSTING SCREW
34	77013A1	SWIVEL ASSEMLBY, SPARK LINK
35	23-26856	BUSHING, SWIVEL
36	12-73288	WASHER, SWIVEL
37	13-29402	WAVE WASHER, SWIVEL
38	11-45774	NUT, SWIVEL
39	85301	SPARK LINK
40	74897T	BARREL, SPARK LINK TO TRIGGER

▶TOP COWL AND SUPPORT BRACKETS (37 parts)

Ref	OEM Part #	Part Name
1	2114-7934T	TOP COWL (WITHOUT DECALS) Comment: UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
2	93122A1	RETAINER ASSEMBLY, TOP COWL Comment: UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
3	35496	PAD, BUMPER - TOP COWL RETAINER Comment: UNITED STATES 5825802 AND BELOW AUSTRALIA 8071019 AND BELOW CANADA 7170897 AND BELOW
4	10-53167T	SCREW, RETAINER TO TOP COWL (7/8") Comment: UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
5	13-39107	LOCKWASHER, RETAINER SCREW
6	76370	SHIELD, TOP COWL - REAR
7	10-37370	SCREW, SHIELD TO TOP COWL (5/8")
8	13-37371	LOCKWASHER, SHIELD SCREW
9	47341A11	ROPE, STARTER (FOR MANUAL STARTING ONLY)
10	52739	HINGE, COWL LATCH - TOP COWL
11	94918F1	LEVER, COWL LATCH HINGE
12	17-58998	ROLL PIN, COWL LATCH LEVER TO HINGE
13	55455	HOOK, TOP COWL LATCH - REAR
14	10-22956	SCREW, REAR HOOK TO TOP COWL (7/8")
15	13-26992	LOCKWASHER, REAR HOOK SCREW
16	79897A4	FRAME, TOP COWL SUPPORT
18	46096	MOUNT, RUBBER - TOP COWL FRAME (HEAVY DUTY)
19	11-35888	NUT, RUBBER MOUNT
20	86472	BRACKET, TOP COWL SUPPORT - REAR
21	31014	MOUNT, RUBBER - REAR SUPPORT BRACKET
22	13-26992	LOCKWASHER, RUBBER MOUNT
23	11-29598	NUT, RUBBER MOUNT
24	10-37562	SCREW, REAR BRACKET TO FRAME (1")
26	13-8M0204647	LOCKWASHER, REAR BRACKET SCREW
27	10-37562	SCREW, REAR BRACKET TO BOTTOM COWL (1")
28	13-8M0204647	LOCKWASHER, REAR SUPPORT BRACKET SCREW
29	42706A1	BRACKET ASSEMBLY, TOP COWL - FRONT
30	10-60411	SCREW Comment: FRONT BRACKET TO BOTTOM COWL (1-1/4")
31	13-8M0204647	LOCKWASHER, FRONT SUPPORT BRACKET SCREW
32	10-60411	SCREW Comment: FRONT BRACKET TO TOP COWL FRAME (1-1/2")
33	13-8M0204647	LOCKWASHER, FRONT SUPPORT BRACKET SCREW
34	37640	MOUNT, RUBBER - FRONT SUPPORT BRACKET
35	13-8M0204647	LOCKWASHER, RUBBER MOUNT
36	11-28770	NUT, RUBBER MOUNT
37	87991	POINTER, TIMING
38	10-28636	SCREW, TIMING POINTER (3/4")
39	12-35462	WASHER, TIMING POINTER SCREW

▶TRANSOM BRACKET (38 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	1496-8822A1	TRANSOM BRACKET
2	89099	TILT TUBE
3	13-89297	WASHER, WAVE - TILT TUBE
4	11-858869	NUT, TILT TUBE
5	23-87642	SPACER, TRANSOM BRACKET STUD
6	16-87643	STUD Comment: TRANSOM BRACKET - NOT USED WITH POWER TRIM
7	12-36001	WASHER, TRANSOM BRACKET STUD
8	13-8M0204647	LOCKWASHER, TRANSOM BRACKET STUD
9	11-28770	NUT, TRANSOM BRACKET STUD
10	17-8M0026068	TILT LOCK PIN ASSEMBLY Comment: NOT USED WITH POWER TRIM
11	10-677552	BOLT, TRANSOM BRACKET (6")
12	12-8M0204648	WASHER, TRANSOM BRACKET BOLT
13	11-91962	NUT, TRANSOM BRACKET BOLT
14	89116	PIN, UPPER SHOCK MOUNTING
15	23-89117	BUSHING, UPPER SHOCK MOUNTING PIN
16	79659	COUPLING, TILT LOCK
17	18-47959	COTTER PIN, TILT LOCK
18	26-22734	OIL SEAL, SWIVEL BRACKET (TILT LOCK)
19	12-76388	WASHER, TILT LOCK
20	25-627021	"O" RING, TILT LOCK
21	89105	TILT LOCK
22	14664A3	REVERSE LOCK ASS'Y Comment: NOT USED WITH POWER TRIM UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
23	24-78203A2	SPRING ASSEMLBY Comment: NOT USED WITH POWER TRIM UNITED STATES 5825803 AND UP AUSTRALIA 8071020 AND UP CANADA 7170898 AND UP
24	56349	SHAFT, REVERSE LOCK PIVOT Comment: NOT USED WITH POWER TRIM
25	18-45882	COTTER PIN, LOCK TO SHAFT Comment: NOT USED WITH POWER TRIM
27	55-28414	PIN, LOWER SHOCK MOUNTING
28	10-21937	SCREW, LOWER SHOCK PIN (2")
29	11-8M0207775	NUT, LOWER SHOCK PIN SCREW
30	55-58780A7	SHOCK ABSORBER Comment: - NOT USED WITH POWER TRIM
31	12-28196	WASHER, UPPER BUSHING RETAINER (INNER) Comment: - NOT USED WITH POWER TRIM
32	23-32171	BUSHING, RUBBER - SHOCK ABSORBER (UPPER) Comment: - NOT USED WITH POWER TRIM
33	23-28198	BUSHING, RUBBER - SHOCK ABSORBER (LOWER) Comment: - NOT USED WITH POWER TRIM
34	12-69374	WASHER, UPPER/LOWER SHOCK PIN (LOWER) Comment: - NOT USED WITH POWER TRIM
35	10-69375	SCREW, UPPER AND LOWER SHOCK PIN Comment: - NOT USED WITH POWER TRIM
36	24-94891	SPRING, COIL - SWIVEL BRACKET Comment: - NOT USED WITH POWER TRIM
37	17-38311	PIN, COIL SPRING MOUNTING Comment: - NOT USED WITH POWER TRIM
38	23-28688	SPACER, RUBBER - COIL SPRING Comment: - NOT USED WITH POWER TRIM

▶TRIM CYLINDERS AND HYDRAULIC HOSES (56 parts)

Ref	OEM Part #	Part Name
1	92194A14	TRIM CYLINDER ASS'Y Comment: (IDENTIFY BY NO CASTING #)
2	22-8M0169589	GREASE FITTING, TRIM CYLINDER
3	10-45265	SCREW, BLEED
4	25-45016	"O" RING, BLEED SCREW
5	10-92050	SCREW Comment: TRIM CYLINDER (1-1/2") - WITHOUT TAPPED HOLE
6	12-8M0204648	WASHER, TRIM CYLINDER BOLT
7	23-45280	SPACER, TRIM CYLINDER - LOWER
8	23-94907A1	BUSHING, RUBBER - TRIM CYLINDER
9	89108A3	BRACKET, TRIM CYLINDER (PORT)
10	26-70608	OIL SEAL, PORT BRACKET
11	89290	PLUNGER, LIMIT SWITCH ACTUATING
12	24-95881	SPRING, TENSION - LIMIT SWITCH PLUNGER
13	16-45282	STUD, MOUNTING BRACKET
14	13-8M0204647	LOCKWASHER, MOUNTING BRACKET STUD
15	11-28770	NUT, MOUNTING BRACKET STUD
16	10-45263	SCREW, MOUNTING BRACKET (2-1/4")
17	10-89673	BOLT, MOUNTING BRACKET TO TRANSOM (5")
18	12-68410	WASHER, MOUNTING BRACKET BOLT
19	11-82671112	NUT, MOUNTING BRACKET BOLT
20	89111T	BRACKET, TRIM CYLINDER (STARBOARD)
21	10-45328	SCREW Comment: TRIM CYLINDER TO MOUNTING BRACKET (3-9/16")
22	12-37807	WASHER Comment: TRIM CYLINDER SCREW (STARBOARD ONLY)
23	11-20696	NUT, TRIM CYLINDER SCREW
24	24-24390	SPRING, TENSION - ADJUSTING STUD
25	16-8M0034461	STUD, ADJUSTING - CUT-OUT LIMIT SWITCH
26	11-859124	NUT, JAM - LIMIT SWITCH ADJUSTING STUD
27	99897	CAM, LIMIT SWITCH ADJUSTING STUD
28	86967	PLATE, RETAINING - LIMIT SWITCH CAM
29	10-68513	SCREW, RETAINING PLATE AND CAM
30	13-26996	LOCKWASHER Comment: RETAINING PLATE AND CAM SCREW
31	45326A2	SWITCH ASSEMBLY, CUT-OUT LIMIT
32	23-45354	BUSHING, RUBBER - CUT-OUT LIMIT SWITCH
33	10-47255	SCREW, CUT-OUT LIMIT SWITCH (9/16")
34	89272	COVER, LIMIT SWITCH
35	27-892731	GASKET, LIMIT SWITCH COVER
36	10-34994	SCREW, LIMIT SWITCH COVER (7/16")
37	12-38833	WASHER, LIMIT SWITCH COVER SCREW
38	87774A1	COVER, INLET - TRANSOM
39	27-87775	GASKET, INLET COVER
40	25-45507	GROMMET, RUBBER - INLET COVER
41	10-32866	SCREW, INLET COVER TO BOAT (2")
42	13-26996	LOCKWASHER, INLET COVER SCREW
43	11-68219	NUT, INLET COVER SCREW
44	32-88005	HOSE, TRIM Comment: CYLINDER TO CONTROL VALVE (5') - 12/32" O.D.
45	32-88006	HOSE, LIFT Comment: CYLINDER TO CONTROL VALVE (5') - 17/32" O.D.
46	25-12602002	GROMMET, RUBBER (7/16" I.D. - 7/8" LONG)
47	73519A1	TILT STOP
48	69259	TUBE, MOUNTING - TILT STOP
49	77669	PIN, MOUNTING TUBE
50	63473	TUBE, CUSHION
51	18-36002	COTTER PIN, MOUNTING TUBE PIN
52	18-45882	COTTER PIN, TILT PIN RETAINING
53	12-39304	WASHER, TILT PIN
54	23-89112	BUSHING, MOUNTING BRACKET
55	70679	COVER, TRIM CYLINDER Comment: NOT USED ON LATE MODELS
56	10-37655	SCREW, TRIM CYLINDER COVER Comment: NOT USED ON LATE MODELS

▶WIRING HARNESS AND IGNITION COIL (25 parts)

Ref	OEM Part #	Part Name
1	339-832757A4	IGNITION COIL
2	43542	COVER, IGNITION COIL
3	10-88856	SCREW, IGNITION COIL COVER (2")
4	11-45076	NUT, IGNITION COIL TERMINAL
5	84-60466A1	CABLE ASSEMBLY, IGNITION COIL (BLACK)
6	84-813715A1	CABLE, HIGH TENSION
7	332-2854T01	BOOT, COIL END
8	85-63709A1	PROTECTOR, SPARK PLUG END
9	33-896329827	SPARK PLUG (CHAMPION #L76-V)
10	84-85537A1	HARNESS, COIL TO SWITCH BOX (#1, 3 AND 5)
11	54-63153	CLIP, HARNESS TO COIL COVER
12	84-96188A4	WIRING HARNESS Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
13	88-8M0207796	FUSE Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
14	84-95084A2	WIRE, FUSE HOLDER Comment: UNITED STATES 6026609 AND UP AUSTRALIA 8074513 AND UP CANADA 7185073 AND UP
15	54-88608	CLAMP, WIRING HARNESS
16	10-28636	SCREW, WIRING HARNESS CLAMP
17	13-26996	LOCKWASHER, WIRING HARNESS CLAMP SCREW
18	89047	BRACKET, WIRING HARNESS
19	10-24637	SCREW, WIRING HARNESS BRACKET
20	12-38833	WASHER, BRACKET SCREW
21	11-20110	NUT, BRACKET SCREW
22	88751	CLAMP, WIRING HARNESS
23	10-28636	SCREW, WIRING HARNESS CLAMP
24	12-20533	WASHER, CLAMP SCREW
25	84-88439A4	BATTERY CABLE (NEGATIVE)

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury 90 (6 CYL.) running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Недавно просмотренные продукты

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Popular Products

Popular Products

Popular Products

Mercury 90 (6 CYL.) (8071020 AND UP) Parts & Diagrams

Категории

Refined By Clear all

Бренд

Лошадиная сила

Двигатель

Доступность

Цена

Нужна помощь?

Images

Product

Price

Qty

Options

Mercury 90 (6 CYL.) (8071020 AND UP) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Недавно просмотренные продукты

Popular Products

Popular Products

Popular Products

Mercury 90 (6 CYL.) (8071020 AND UP) Parts & Diagrams

Категории

Refined By Clear all

Бренд

Лошадиная сила

Двигатель

Доступность

Цена

Нужна помощь?

Images

Product

Price

Qty

Options

Mercury 90 (6 CYL.) (8071020 AND UP) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Недавно просмотренные продукты

Shop the look

Choose Options

Recently Viewed

Edit Option

Back In Stock Notification

Choose Options

Popular Products