– Page 2 – JLM Marine Boat Parts Limited

Mercury 90 (6 CYL.) (6436123 & Up) Parts & Diagrams

🔎 Mercury 90 (6 CYL.) Reference Library — Exploded parts diagrams (29 diagrams), specifications, common issues, and maintenance checklist.

The Mercury 90 (6 CYL.) is a 4-Stroke, Inline 4-Cylinder, EFI, SOHC outboard motor. Suited for bay boats, pontoons, and center-console fishing boats requiring reliable mid-range power.

Quick Reference Specifications

Specification	Value
Engine Type	4-Stroke, Inline 4-Cylinder, EFI, SOHC
Horsepower	90 HP
Displacement	2100 cc
Bore x Stroke	90 mm x 81 mm
Spark Plug (Type & Gap)	NGK IZFR6F-11
Engine Oil Capacity	5.2 L (5.5 quart)
Recommended Engine Oil	Mercury FourStroke Oil 10W-30
Gear Case Oil Capacity	710 mL (24 fl oz)
Idle Speed (in gear)	650 ± 50 RPM (in gear)
Full Throttle RPM Range	5000-6000
Fuel	Unleaded Gasoline, 87 Octane min.

Always verify specifications against your owner's manual for your specific serial number range.

Common Issues & Recommended Parts

Below are common maintenance scenarios for the Mercury 90 (6 CYL.):

Water Pump / Overheating: If the tell-tale stream is weak or absent, the water pump impeller likely needs replacement. Inspect annually or every 100 hours. → Recommended: Water Pump Impeller Kit
Engine Oil / Maintenance Light: 4-stroke engines require regular oil and filter changes. Use marine-grade oil rated for your engine. Change every 100 hours or annually. → Recommended: Oil Filter, Engine Oil
Fuel Injector Issues (EFI models): Rough idle or misfires may indicate clogged fuel injectors. Use fuel stabilizer and clean injectors periodically. → Recommended: Fuel Injector, Fuel Filter
Gear Case Oil Leak: Check lower unit seals if gear oil appears milky (water contamination). Replace seals and gaskets during lower unit service. → Recommended: Lower Unit Seal Kit, Drain Plug Gaskets
Anode Corrosion: Inspect sacrificial anodes regularly, especially in saltwater. Replace when 50% depleted to protect against galvanic corrosion. → Recommended: Zinc/Aluminum Anode Kit

Parts Diagrams & OEM Part Numbers

Expand the sections below to view detailed exploded parts diagrams and find the exact OEM replacement components for your Mercury 90 (6 CYL.).

▶AUTO-BLEND(WITH WARNING HORN) (22 parts)

Ref	OEM Part #	Part Name
-	1301931	AUTO-BLEND
1	16612	TANK KIT, Oil
2	13996	HANDLE KIT
3	36-13986	CAP, OIL TANK
4	16614	HARDWARE KIT
5	19-13979	PLUG KIT, Drain
6	16611	DIAPHRAGM KIT
7	13990	BRACKET
8	13993	BAND
9	13983	BRACKET (LEFT)
10	13984	BRACKET (RIGHT)
11	16613	COVER
12	35-13985	FILTER/SENSOR KIT, Oil
13	13987	HORN KIT
14	84-13988	HARNESS ASSEMBLY
15	88-13989	FUSE (.5 AMP)
16	35-18089	FILTER KIT, Fuel
17	32-13992	VINYL TUBE
18	32-13995	TUBE KIT, Fuel
19	15387A1	STRAINER ASSEMBLY, Oil
20	21-16615	CHECK VALVE KIT
21	27-16616	GASKET KIT

▶Auto-Blend (22 parts)

Ref	OEM Part #	Part Name
-	130194	AUTO BLEND ASSEMBLY
1	16612	TANK KIT, Oil
2	13996	HANDLE KIT
3	36-16619	CAP, Oil Tank
4	16614	HARDWARE KIT
5	19-13979	PLUG KIT, Drain
6	16611	DIAPHRAGM KIT
7	16620	BRACKET KIT, Mounting
8	13993	BAND
9	13983	BRACKET, Left
10	13984	BRACKET, Right
11	16613	COVER
12	35-13985	FILTER/SENSOR KIT, Oil
13	35-18576	FILTER KIT, Fuel
14	32-13992	VINYL TUBE
15	16618	STRAINER, Oil
16	21-16615	CHECK VALVE KIT
17	16621	PLATE
18	19265	MODULE KIT
19	16623	BRACKET KIT
20	27-16616	GASKET KIT
21	84-14585A1	HARNESS ASSEMBLY, Auto Blend

▶BOTTOM COWL AND SHIFT LINKAGE (32 parts)

Ref	OEM Part #	Part Name
1	2115-8963A2	COWL ASSEMBLY, BOTTOM Comment: (GRAY)
2	52862A2	DRIP TRAY ASSEMBLY, BOTTOM COWL
3	37940	SOUND PAD, DRIP TRAY
4	10-48408	SCREW, (#10-16 x .500), DRIP TRAY TO BOTTOM COWL
5	32-8M0108355	HOSE, DRIP TRAY TO BOTTOM COWL (8")
6	76369	SPACER, BOTTOM COWL
7	10-35519	SCREW, (#10-16 x .500), SPACER TO BOTTOM COWL
8	39616	BOOT, CONTROL CABLES - BOTTOM COWL
9	37637	BOOT, FUEL CONNECTOR - BOTTOM COWL
10	32-8M0108355	LINE, (57.00 Inches Bulk), TELL TALE (21-1/2")
11	52889	NOZZLE, TELL TALE HOSE TO BOTTOM COWL
12	10-48408	SCREW, (#10-16 x .500)
13	22-782792	ELBOW, TELL TALE HOSE TO CYLINDER BLOCK
14	60304A54	SHIFT SHAFT ASSEMBLY, UPPER
15	23-26856	BUSHING, SHIFT SHAFT
16	73402	SHIFT LINK
17	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel, LINK ROD
18	11-36069	NUT, LINK ROD
19	13-29720	WAVE WASHER, LINK ROD
20	24-20099	SPRING, LINK ROD TO GUIDE BLOCK
21	37896	GUIDE BLOCK, LINK ROD
22	52732A6	BRACKET, ANCHOR - CONTROL CABLES
23	98889	LATCH Comment: (DESIGN II)
24	10-42975	DRIVE SCREW Comment: (DESIGN II)
25	87609A1	LEVER, NYLON - SHIFT CABLE LOCKING Comment: (DESIGN I)
26	17-47175	PIN Comment: (DESIGN I)
27	90211	COVER, NYLON - SHIFT CABLE Comment: (DESIGN I)
28	65799T	LINK, LOCKING LEVER TO COVER Comment: (DESIGN I)
29	39519	CUP, BARREL RETAINER - ANCHOR
30	10-35386	SCREW, (.312-18 x 1.00)
31	52100	WEAR PLATE, LINK ROD
32	8M0036768	LATCH

▶CARBURETOR (35 parts)

Ref	OEM Part #	Part Name
--	1395-51091	REPAIR PARTS KIT Comment: (1 PER CARBURETOR)
1	1368-7472A29	CARBURETOR (BOTTOM) Comment: (115)
2	1395-8673	FLOAT ASSEMBLY
3	NSS	NOT SOLD SEPARATE, PIN-FLOAT LEVER PINION
4	NSS	NOT SOLD SEPARATE, LEVER, FLOAT (LOWER)
5	NSS	NOT SOLD SEPARATE, LEVER, FLOAT (UPPER)
6	1395-83181	NEEDLE, Inlet, SEAT AND GASKET
7	NSS	NOT SOLD SEPARATE, GASKET-INLET SEAT
8	NSS	NOT SOLD SEPARATE, GASKET, FLOAT BOWL COVER
9	1395-5680	COVER, FLOAT BOWL
10	1395-8423	JET, (.094), BOWL VENT Comment: (115)
11	1395-5734	HOSE, ECONOMIZER
12	10-52195	SCREW, FLOAT BOWL COVER
13	1395-4804	SCREW, FLOAT BOWL COVER
14	8,13-26995	LOCKWASHER, Stainless Steel, FLOAT BOWL COVER SCREW
15	8146791	LEVER, THROTTLE (SEE NOTE)
16	1395-6027	SCREW, THROTTLE STOP LEVER
17	1395-7942	SHAFT, THROTTLE Comment: (CENTER/BOTTOM)
18	NSS	NOT SOLD SEPARATE, IDLE TUBE
19	1395-4540	SCREW, BODY (IDLE TUBE)
20	1395-8964	SHUTTER, Throttle Comment: (115)
21	NSS	NOT SOLD SEPARATE, SCREW-THROTTLE SHUTTER
22	NSS	NOT SOLD SEPARATE, SPRING, IDLE ADJUSTMENT SCREW
23	NSS	NOT SOLD SEPARATE, SCREW, IDLE ADJUSTMENT
24	NSS	NOT SOLD SEPARATE, MAIN NOZZLE
25	1395-4542	SCREW, PLUG - MAIN NOZZLE
26	1395-6207	JET, (.072) Comment: (90/115)
27	1395-4541	SCREW, PLUG - MAIN FUEL JET CHANNEL
28	NSS	NOT SOLD SEPARATE, GASKET, JET CHANNEL PLUG SCREW
29	52106A1	VENTURI, Plastic
30	NSS	NOT SOLD SEPARATE, SPRING, THROTTLE SHAFT RETURN
31	1395-4543	SCREW, BODY CHANNEL
32	NSS	NOT SOLD SEPARATE, WELCH PLUG, BODY CHANNEL
33	27-481641	GASKET, CARBURETOR FLANGE
34	11-64809	NUT, CARBURETOR SUTD

▶CARBURETOR AND ENRICHNER VALVE (20 parts)

Ref	OEM Part #	Part Name
1	1368-7472A27	CARBURETOR (TOP) Comment: (115)
1A	1368-7472A28	CARBURETOR (CENTER) Comment: (115)
2	1368-7472A29	CARBURETOR (BOTTOM) Comment: (115)
3	85943A1	LEVER ASSEMBLY, THROTTLE (UPPER CARBURETOR)
4	10-60293	SCREW, (#5-40 x .500), THROTTLE LEVER
5	12-74726	WASHER
6	53720A2	COUPLING ASSEMBLY
7	10-66104	SCREW, (#8-32 x .790), THROTTLE BRACKET
8	28-89694	KEY, THROTLE COUPLING
9	42859A2	VALVE, Enrichner Comment: (ATTACHES WITH BRACKET)
10	22-90275	CONNECTOR, ENRICHNER VALVE (BOTTOM)
11	22-73817	CONNECTOR, (90 Degree), ENRICHNER VALVE (SIDE)
12	90345	BRACKET, ENRICHNER VALVE
13	10-89075	SCREW, VALVE TO BRACKET
14	42859A2	VALVE ASSEMBLY, Enrichner Comment: (ATTACHES WITH CLAMP)
16	10-73286	SCREW, (.250-20 x .500) Stainless Steel, CARBURETOR
17	86-45915	TERMINAL BLOCK, REED BLOCK HOUSING
18	10-69079	SCREW, (#10-16 x .440), TERMINAL BLOCK
19	10-20411	SCREW, (.190-24 x .62), WIRE TO TERMINAL BLOCK
20	32-9912688	TUBING, (36.00 Inches Bulk), ENRICHNER VALVE

▶COWLING AND FRONT COVER(BLACK) (11 parts)

Ref	OEM Part #	Part Name
1	2183-7928A3	FRONT COVER ASSEMBLY
2	56849	KNOB, FRONT COVER
3	12-30771	WASHER, COVER KNOB (RUBBER)
4	12-59572	WASHER, COVER KNOB (PLASTIC)
5	24-30772	SPRING, TENSION - KNOB
6	17-29077	PIN, Roll, TENSION SPRING TO KNOB
7	38674	BLANKET, STARTER ROPE
8	94924	SEAL, SOUND - UPPER
9	2136-4660A4	WRAP AROUND COWL ASSEMBLY
10	46785A1	LATCH ASSEMBLY, Cowl
11	30413	HOOK, COWL LATCH

▶COWLING AND FRONT COVER(GRAY) (12 parts)

Ref	OEM Part #	Part Name
1	2171-6497A7	FRONT COVER
2	56849	KNOB, FRONT COVER
3	12-30771	WASHER, COVER KNOB (RUBBER)
4	12-59572	WASHER, COVER KNOB (PLASTIC)
5	24-30772	SPRING, TENSION - KNOB
6	17-29077	PIN, Roll, TENSION SPRING TO KNOB
7	77790	STRIP, SOUNG
8	38674	BLANKET, STARTER ROPE
10	77544	SEAL, SOUND - TOP
11	2172-6498A9	WRAP AROUND COWL
12	46785A1	LATCH ASSEMBLY, Cowl
13	30413	HOOK, COWL LATCH

▶CRANKSHAFT, PISTONS AND CONNECTING RODS (31 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	436-9072A1	CRANKSHAFT ASSEMBLY
2	30-62567T	BEARING, Ball, UPPER
3	30-63742T	BEARING, Ball, LOWER
4	54196A6	CARRIER ASSEMBLY
5	65800	PACKING, CARRIER
6	535-5397A4	BEARING ASSEMBLY, Center Main
7	17-20032	PIN, Dowel, CENTER MAIN BEARING
8	29-714221	BEARING, Needle, OUTER RACE
9	26113T	RACE, OUTER (PAIR)
10	53-26933	RING, Snap, OUTER RACE
11	17-47246	PIN, Dowel, STEPPED
12	10-22968	SCREW, (.250-28 x 1.25), CENTER MAIN BEARING
13	11-8M0207775	NUT, (1/4-28X7/32), BEARING SCREW
14	540-8663A3	BEARING ASSEMBLY, Main Comment: (115)
15	17-20032	PIN, Dowel, MAIN BEARING
16	10-45775	SCREW, (#12-28 x .560) , MAIN BEARING
17	11-45774	NUT, MAIN BEARING SCREW
18	34-99422A1	REED SET, MATCHED Comment: (115)
19	34-99421	STOP, Reed, 4 PETAL Comment: (115)
20	10-62204	SCREW, REED STOP
21	11-53153	NUT, REED STOP SCREW
22	774-9137A11	PISTON ASSEMBLY Comment: (.030 O.S.)(115)
23	53-857196	RING, Lock, PISTON PIN
24	39-88392A12	RING SET, Piston - .030 Oversize
25	624-8101A3	CONNECTING ROD ASSEMBLY
26	31-62596A1	BEARING ASSEMBLY, CRANKPIN
27	29-8M0214934	BEARING, PISTON PIN
28	12-8M0032839	WASHER, NEEDLE LOCATING
29	10-91012	SCREW, (.250-28 Special), CONNECTING ROD
30	15-38095A1	SHIM, CRANKSHAFT BALL BEARING

▶CYLINDER BLOCK AND CRANKCASE ASSEMBLY (28 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	852-8310A4	CYLINDER BLOCK ASSEMBLY Comment: (115)
2	27-53862	GASKET, CRANKCASE TO CYLINDER BLOCK
3	66517	RESTRICTOR, CRANKCASE BLEED
4	16-64936	STUD, CARBURETOR (1-1/4")
5	16-64281	STUD, (.375-16/.375-24 x 1.880)
6	17-43044	PIN, Dowel, CRANKCASE TO CYLINDER BLOCK
7	17-63779	PIN, Dowel (.250 x .625), CYLINDER BLOCK TO MAIN BEARING
8	16-64282	STUD, (4 In.), CYLINDER BLOCK TO PLATE (4")
9	86473	COVER, STARTER MOTOR - TOP
10	10-73279	SCREW, (.312-18 x 1.880), TOP COVER
11	13-8M0204647	LOCKWASHER, (.312)
12	76867	COVER, BOTTOM
13	10-73279	SCREW, (.312-18 x 1.880), BOTTOM COVER
14	13-8M0204647	LOCKWASHER, (.312)
15	10-74824	SCREW, (.312-18 x 1.250), CRANKCASE TO CYLINDER BLOCK
16	12-26020	WASHER
18	10-20359	SCREW, (.375-16 x 1.00), CENTER MAIN BEARING LOCKING
19	14-20091	TAB WASHER, BEARING LOCKING SCREW
20	21-42866	CHECK VALVE, BLEED HOSE - UPPER
21	32-9938779	HOSE, BLEED (22")
22	21-428671	CHECK VALVE, BLEED HOSE - LOWER
23	22-996642	ELBOW, BALANCE HOSE
24	32-8M0108355	LINE, (57.00 Inches Bulk) (6-1/4")
25	22-97231	TEE, BLEED HOSE
26	12-20553	WASHER, POWERHEAD STUDS
27	11-82671013	NUT, (.375-24), POWERHEAD STUDS
28	11-69254	NUT, POWERHEAD STUDS

▶DRIVESHAFT HOUSING ASSEMBLY (32 parts)

Ref	OEM Part #	Part Name
-	17-8M0084726	PIN, Dowel (.187 x .530), SPACER Comment: (EXTRA LONG SHAFT)
1	1573-5239A51	HOUSING ASSEMBLY, Driveshaft - Mariner
2	16-56295	STUD, (.437 x 2.69)
3	19-64649	PLUG, PLASTIC - TRIM TAB SCREW HOLE
4	37417F2	COVER, TRIM Comment: (MARINER)
5	10-57807	SCREW, (#10-16 x .750) Stainless Steel
6	25-92012	GROMMET, TRIM COVER SCREW
7	84-88238T01	CABLE ASSEMBLY, TRIM COVER SCREW
8	10-62568	SCREW, (#10-16 x .375), GROUND STRAP ATTACHING
9	32-77121	TUBE, WATER INLET Comment: (EXTRA LONG SHAFT)
10	78184T	TUBE, EXHAUST Comment: (LONG SHAFT)
11	65638	BOOT, EXHAUST TUBE
12	75299	MOUNT, RUBBER - LOWER Comment: (LONG SHAFT)
13	10-43426	SCREW, UPPER MOUNT
14	11-25096	NUT, MOUNT SCREW
15	12-30119	WASHER, (.875 Inch Outside Diameter), UPPER MOUNT SCREW
16	88238A10	CABLE ASSEMBLY, Ground
17	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, GEAR HOUSING STUDS
18	11-29489	NUT, GEAR HOUSING STUDS
19	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel, GEAR HOUSING STUDS
20	11-8M0204653	NUT, (.437-20) Stainless Steel, GEAR HOUSING
21	35608	CLAMP, LOWER MOUNT TO DRIVESHAFT HOUSING
22	24-35522	SPRING, TENSION - LOWER MOUNT CLAMP
23	10-29256	SCREW, (.312-18 x .875)
24	35474F2	COVER, Lower Mount Clamp Comment: (GRAY)
25	11-35521	NUT, LOWER MOUNT CLAMP COVER
26	10-87884	SCREW, (#12-14 x .920)
27	10-28200	SCREW, (.375-24 x 2.875), DRIVESHAFT HOUSING Comment: EARLY MODELS
28	12-34714	WASHER, HOUSING SCREW Comment: EARLY MODELS
29	11-25269	NUT, (.375-24) Comment: EARLY MODELS
30	10-41508	SCREW, (.250-20 x .500) Stainless Steel, GROUND WIRE
31	12-49339	WASHER, (.8125), LOWER MOUNT

▶END CAP, MANIFOLD AND EXHAUST COVERS (32 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	852-8310A4	CYLINDER BLOCK ASSEMBLY Comment: (115)
2	1161-7616A2	END CAP ASSEMBLY
3	26-41953	SEAL, END CAP
4	25-47254	O-RING
5	15-73644A1	SHIM, END CAP (.006-10)
6	10-812618	SCREW, END CAP (1")
7	1148-5410T1	END CAP ASSEMBLY, LOWER
8	26-41953	SEAL, END CAP
9	25-32546	O-RING, END CAP
10	15-20085A1	SHIM SET, END CAP (.005-10)
11	10-30225	SCREW AND LOCKWASHER, (.312-18 x 1.00), END CAP
12	71808	COVER, WATER JACKET
13	27-721421	GASKET, WATER JACKET COVER
14	10-53167T	SCREW, (.312-18 x .880), WATER JACKET COVER
15	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel
16	27-854952	GASKET, CYLINDER BLOCK TO BAFFLE PLATE
17	757781	PLATE, Baffle, EXHAUST MANIFOLD
18	27-854972	GASKET
19	99896A1	COVER, EXHAUST MANIFOLD
20	10-53576	SCREW, (.312-18 x 1.125), MANIFOLD COVER
21	1023-8368A1	COVER, CYLINDER BLOCK
22	27-981853	GASKET, CYLINDER BLOCK COVER
23	10-8M0214943	SCREW, COVER (1")
24	46933A3	STRAP ASEMBLY, Ground
25	10-62568	SCREW, (#10-16 x .375), GROUND STRAP
26	87-96829A1	SWITCH ASSEMBLY, Temperature
27	37440	BRACKET, MOUNT SUPPORT
28	10-35386	SCREW, (.312-18 x 1.00), BRACKET TO CYLINDER BLOCK
29	87872	COVER, TRANSFER PORT
30	27-856730	GASKET, TRANSFER PORT COVER
31	10-28636	SCREW, (.250-20 x .750), TRANSFER PORT COVER

▶EXHAUST EXTENSION PLATE (17 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	43289A2	PLATE ASSEMBLY, EXHAUST EXTENSION
2	23-27132	BUSHING, NYLON - EXHAUST EXTENSION PLATE
3	17-23784	PIN, Dowel, EXHAUST EXTENSION PLATE
4	37918	SEAL, EXHAUST PLATE
5	99358	STRIP, RETAINING - EXHAUST EXTENSION PLATE
6	10-37571	SCREW, (.190-32 x .500)
7	27-692381	GASKET, POWERHEAD
8	10-66023	SCREW, (.312-18 x 2.00) Flange Head, ADAPTOR PLATE TO HOUSING PLATE
9	10-66023	SCREW, (.312-18 x 2.00) Flange Head
10	27-661021	GASKET, DRIVESHAFT HOUSING PLATE
11	26-60898	SEAL, DRIVESHAFT HOUSING PLATE
12	43290A4	PLATE ASSEMBLY, DRIVESHAFT HOUSING
13	26-38970	SEAL, RUBBER - WATER INLET TUBE
14	17-23784	PIN, Dowel, DRIVESHAFT HOUSING PLATE
15	99700	TUBE, Exhaust Comment: (115)
16	10-65414	SCREW (3/4 INCH)

▶FLYWHEEL, STARTER MOTOR AND STATOR (19 parts)

Ref	OEM Part #	Part Name
1	19-45907	PLUG, Yellow, FLYWHEEL
2	11-52901	NUT, (.625-18), FLYWHEEL
3	12-33001	WASHER, (.641 x 1.250 x .190), FLYWHEEL
4	248-8722A7	FLYWHEEL ASSEMBLY
5	10-32417	SCREW, (.250-28 x .625), FLYWHEEL PLATE
6	10-68997	SCREW, (.312-24 x .750), FLYWHEEL HUB
7	398-5454A17	STATOR ASSEMBLY
8	10-75840	SCREW, (#10-24 x .880), STATOR
9	96455A9	PLATE ASSEMBLY, Trigger
10	54-61001	J CLIP, TRIGGER HARNESS
11	50-898265010	STARTER MOTOR ASSEMBLY
12	23-8M0034918	COLLAR, STARTER MOTOR
13	23-56774	SPACER, STARTER MOTOR
14	8M0043376	STOP, RUBBER - STARTER MOTOR
15	84-93388A1	CABLE ASSEMBLY, (6.00 Inches) Black, PLATE TO STARTER MOTOR
16	10-69035	SCREW AND LOCKWASHER, (.250-20 x .625) Stainless Steel, CABLE TO STARTER MOTOR
17	84-93389A6	CABLE ASSEMBLY, SOLENOID TO STARTER MOTOR (YELLOW)
18	13-26992	LOCKWASHER, (.250) Stainless Steel, STARTER MOTOR TERMINAL
19	11-64015	NUT, (.250-20), STARTER MOTOR TERMINAL

▶FUEL PUMP AND FUEL LINES(NEW STYLE FUEL PUMP) (43 parts)

Ref	OEM Part #	Part Name
-	32-18176A1	HOSE KIT
1	14360A78	PUMP ASSEMBLY, Fuel
2	21-857005A1	DIAPHRAGM KIT
3	NSS	NOT SOLD SEPARATE, CHECK VALVE-RUBBER
4	NSS	NOT SOLD SEPARATE, GASKET-BOOST
5	NSS	NOT SOLD SEPARATE, DIAPHRAGM
6	NSS	NOT SOLD SEPARATE, GASKET-PULSE
7	NSS	NOT SOLD SEPARATE, SPRING
8	NSS	NOT SOLD SEPARATE, CAP
9	NSS	NOT SOLD SEPARATE, CHECK VALVE
10	NSS	NOT SOLD SEPARATE, RETAINER
11	NSS	NOT SOLD SEPARATE, SPRING
12	NSS	NOT SOLD SEPARATE, CAP
13	27-8M0204705	GASKET, BASE
14	NSS	NOT SOLD SEPARATE, GASKET-MOUNTING PLATE
15	144303	BASE, FUEL PUMP
16	987752	PLATE, FUEL PUMP
17	22-56800	PLUG, Pipe (.0625-27)
18	22-19688	FITTING
19	10-4000310	SCREW, (M5 x 40), FUEL PUMP
20	10-16452	SCREW, (#12-24 x 2.00), FUEL PUMP TO CRANKCASE
21	32-8M0108349	TUBING
22	35-816296Q2	FILTER, Fuel
23	54-816311T	TIE STRAP, FUEL TUBING
24	22-64705	FITTING, FUEL LINE
25	32-8M0108355	LINE, (57.00 Inches Bulk)
26	22-19688	FITTING, UPPER CARBURETOR
27	22-18214	TEE, FUEL LINE
28	22-64706001	TEE, CENTER CARBURETOR
29	22-19688	FITTING, LOWER CARBURETOR
30	22-36221	ELBOW, FUEL LINE TO ADAPTOR
31	30186	ADAPTOR, CHECK UNIT
32	30187	STEM, CHECK UNIT ADAPTOR
33	24-30189	SPRING, ADAPTOR STEM
34	25-16524	O-RING, ADAPTOR STEM
35	30188	WASHER, ADAPTOR
36	10-36154	SCREW, (.250-28 x 1.380), ADAPTOR TO BOTTOM COWL
37	11-36069	NUT, ADAPTOR SCREW
38	14439A2	PLATE, MOUNTING
39	10-20189	SCREW, (.190-32 x .75), PALTE TO CRANKCASE
40	10,13-26996	LOCKWASHER, Stainless Steel, PLATE SCREW
41	32-18176	HOSE
42	32-18175	HOSE

▶FUEL PUMP AND FUEL LINES(OLD STYLE FUEL PUMP) (45 parts)

Ref	OEM Part #	Part Name
1	13527A1	PUMP ASSEMBLY, Fuel
2	21-8M0084277	CHECK VALVE ASSEMBLY
3	89031A3	DIAPHRAGM ASSEMBLY
4	NSS	NOT SOLD SEPARATE, GASKET-FUEL PUMP
5	NSS	NOT SOLD SEPARATE, GASKET-PULSE CHAMBER
6	NSS	NOT SOLD SEPARATE, GASKET-FUEL PUMP
7	NSS	NOT SOLD SEPARATE, GASKET-CHECK VALVE TO HOUSING
8	35-59072	SCREEN, FUEL INLET
9	25-35480	O-RING, (1.237 x .103), FUEL INLET COVER
10	25-38933	O-RING, COVER SCREW
11	23004	RETAINER, CHECK VALVE
12	10-43723	SCREW, (#6-32 x .500), RETAINER
13	86295	BASE, FUEL PUMP
14	879901	PULSE CHAMBER, FUEL PUMP
15	35-91078A1	COVER ASSEMBLY, FUEL INLET
16	10-89766	SCREW, (#10-32 x .620) Stainless Steel, FUEL FILTER COVER
17	22-64705	FITTING, INLET COVER
18	10-41772	SCREW, FUEL PUMP (1-1/2")
19	10,13-26996	LOCKWASHER, Stainless Steel
20	22-19688	FITTING, FUEL OUTLET
21	86026	RETAINER, SPRING
22	24-86207	SPRING, COMPRESSION
23	86252	CAP, SPRING END
24	32-8M0108355	LINE, (57.00 Inches Bulk) (W/O INLINE FILTER)
25	54-68424	CLAMP, FUEL LINE ATTACHING
26	22-19688	FITTING, ELBOW - UPPER CARBURETOR
27	22-73318	TEE, Plastic, FUEL LINE
28	22-64706001	TEE, CENTER CARBURETOR
29	22-19688	FITTING, LOWER CARBURETOR
30	32-8M0108355	LINE, (57.00 Inches Bulk), ADAPTOR TO FUEL PUMP (18-1/2")
31	22-63981	FITTING, FUEL LINE TO ADAPTOR
32	30186	ADAPTOR, CHECK UNIT
33	30187	STEM, CHECK UNIT ADAPTOR
34	24-30189	SPRING, ADAPTOR STEM
35	25-16524	O-RING, ADAPTOR STEM
36	30188	WASHER, ADAPTOR
37	10-36154	SCREW, (.250-28 x 1.380), ADAPTOR TO BOTTON COWL
38	11-36069	NUT, ADAPTOR SCREW
39	32-8M0108355	LINE, (57.00 Inches Bulk)
40	54-68424	CLAMP, FUEL LINE -WITH INLINE FILTER
41	35-816296Q03	FILTER, Fuel
42	54-26404	CLAMP, FUEL FILTER -WITH INLINE FILTER
43	10-78291	SCREW, (.190-24 x .500), FUEL FILTER CLAMP -WITH INLINE FILTER
44	8M0084613	C WASHER
45	10,13-26996	LOCKWASHER, Stainless Steel, CLAMP SCREW -WITH INLINE FILTER

▶GEAR HOUSING(DRIVESHAFT) (48 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	1655-7333A43	GEAR HOUSING ASSEMBLY Comment: (BASIC)(GRAY)
2	22-85822A10	CONNECTOR ASSEMBLY, SPEEDOMETER
3	17-8M0084726	PIN, Dowel (.187 x .530), GEAR HOUSING LOCATING
4	16-77169	STUD (9") Comment: (EXTRA LONG)
5	16-74730	STUD (7") Comment: (EXTRA LONG)
6	16-8M0034463	STUD, (.312 x 3.38), WATER PUMP
7	16-69501	STUD, WATER PUMP (3-1/8")
8	31-32898T	BEARING, DRIVESHAFT
9	45-42645	DRIVESHAFT Comment: (EXTRA LONG SHAFT)
10	43-68548T3	GEAR, Pinion
11	11-35921	NUT, (.625-18)
12	23-70412	SPACER
13	15-57007A1	SHIM
14	31-69220T	BEARING, Roller
15	27-8M0214962	GASKET
16	25-8M0214923	O-RING, (1.984 x .139)
17	46-96146A5	BASE ASSEMBLY, Water Pump
18	26-94038	SEAL, Oil, WATER PUMP
19	26-16977	SEAL, Oil, WATER PUMP
20	27-8M0090319	GASKET, LOWER
21	8M0204677	FACE PLATE
22	27-858524	GASKET, UPPER
23	46-96148T1	BODY ASSEMBLY, Water Pump
24	48752T	INSERT, WATER PUMP
25	26-38970	SEAL, RUBBER - WATER INLET TUBE
26	47-89984T4	IMPELLER, WATER PUMP
27	28-8M0214992	KEY, IMPELLER DRIVE
28	10-8M0215009	SCREW, (#14-8 x 2.25), WATER PUMP
29	12-20583	WASHER
30	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
31	11-8267119	NUT, (.250-28)
32	12-36001	WASHER
33	11-82670911	NUT, (.312-24) Stainless Steel
34	25-8M0214918	RING, Rubber, DRIVESHAFT
35	23-29804T	SLEEVE, GUIDE - WATER INLET TUBE
36	37641001	SEAL, EXHAUST
37	38051	PLATE, SUPPORT - EXHAUST TUBE SEAL
38	77122	SHAFT, SHIFT - LOWER Comment: (EXTRA LONG SHAFT)
39	53-29641	E RING, RETAINING - SHIFT SHAFT
40	25-25439	O-RING, (.862 x .103), SHIFT SHAFT BUSHING
41	23-77631A2	BUSHING ASSEMBLY, SHIFT SHAFT
42	26-8M0204708	SEAL, Oil, SHIFT SHAFT BUSHING
43	12-77674	WASHER, RUBBER - SHIFT SHAFT BUSHING
44	78036	BASE Comment: (NON-POWER TRIM)
45	43308T1	CAM Comment: (NON-POWER TRIM)
46	22-8M0058389	SCREW, Magnetic, DRAIN
47	12-191833	WASHER, Fiber, GREASE FILLER AND VENT HOLE SCREW

▶GEAR HOUSING(PROPELLER SHAFT) (32 parts)

Ref	OEM Part #	Part Name
-	27-85653A87	GASKET SET
1	1655-7333A43	GEAR HOUSING ASSEMBLY Comment: (BASIC)(GRAY)
48	760394	CAM, Shift Control
49	44532A1	FOLLOWER ASSEMBLY, Cam
51	24-30622	SPRING, COMPRESSION - CAM FOLLOWER
52	15-30923A1	SHIM, BEARING OUTER RACE (.002-3-5-10)
53	31-30894A1	BEARING SET, Cup And Cone
54	43-68447T1	GEAR ASSEMBLY, Forward
55	31-30895T	BEARING, Needle, FORWARD GEAR
56	52-822539T	RATCHET, SLIDING GEAR
57	17-8M0100263	PIN, Cross, RATCHET TO PROPELLER SHAFT
58	24-30893	SPRING, RETAINING - CROSS PIN
59	44-93003	PROPELLER SHAFT
60	43-76250T	GEAR, Reverse
61	12-76358	THRUST WASHER, BEARING CARRIER
62	25-29976	O-RING, BEARING CARRIER
63	41529T2	CARRIER ASSEMBLY, Bearing
64	22-8M0169588	FITTING, Grease
65	31-30956T	BEARING, Needle, BEARING CARRIER
66	26-8M0204670	SEAL (INSIDE)
67	26-8M0205729	SEAL, Oil, CUTTER (OUTSIDE)
68	28-30281	KEY, LOCATING - BEARING CARRIER
69	14-52700	TAB WASHER, GEAR HOUSING COVER
70	52699	COVER, GEAR HOUSING
71	97-31640Q4	TRIM TAB ASSEMBLY, GEAR HOUSING
72	10-66024	SCREW, (.437-14 x 1.75), TRIM TAB TO GEAR HOUSING
73	12-45176	WASHER, (.453 x .812 x .105) Stainless Steel
74	11-8M0204653	NUT, (.437-20) Stainless Steel
75	10-74727	SCREW, (.375-16 x 6.00), GEAR HOUSING Comment: (EXTRA LONG SHAFT)
76	13191Q01	THRUST WASHER
77	14-816629Q	TAB WASHER, PROPELLER NUT
78	11-52707Q1	PROP NUT KIT, (.750-16)

▶POWER TRIM COMPONENTS (44 parts)

Ref	OEM Part #	Part Name
1	99659A22	MANIFOLD ASSEMBLY Comment: (GRAY)
2	22-56800	PIPE PLUG, MANIFOLD
3	41493A7	TRIM CYLINDER ASSEMBLY Comment: (GRAY)
4	41492A1	GUIDE ASSEMBLY
5	25-41478A1	REPAIR KIT
6	41482A2	CHECK VALVE KIT
7	1100-8M0021648	GUIDE ASSEMBLY, TRIM ROD
8	878413A1	PISTON/ROD ASSEMBLY, Power Trim, PORT
9	35-12184A1	TRIM FILTER ASSEMBLY
10	878414T01	PISTON/ROD ASSEMBLY, Power Trim, STARBOARD
11	17-821539	PIN, Groove, TRIM CYLINDER (UPPER)
12	893929A01	VALVE ASSEMBLY
12A	53-815949001	E RING
13	10-4000327	SCREW, (M6 x 14), COVER
14	12-4002315	WASHER, COVER SCREW
15	99642	COVER, MANIFOLD
16	25-48462A4	O-RING KIT
17	19-99609A1	PLUG ASSEMBLY
18	99641A1	SHAFT ASSEMBLY
19	22-56800	PIPE PLUG, SHAFT
20	10-4008820	SCREW, (M6 x 20), PUMP AND MOTOR
21	13-400256	LOCKWASHER, (M6)
22	826729A10	PUMP AND MOTOR
23	99625002	SHAFT, UPPER
24	97-818298Q1	ANODE ASSEMBLY
25	10-4000332	SCREW, (M6 x 35), ANODE
26	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel, ANODE SCREW
27	8M0045383	STRIKER PLATE, TRIM SHAFT
28	13-58643	LOCKWASHER, (.375)
29	11-46335	NUT, (.375-24)
30	84-17201A1	CABLE ASSEMBLY, (6.00 Inches) (2 WIRE)
31	84-79139A14	WIRE ASSEMBLY (11 -1/2" - RED)
32	8M0185622	SOLENOID, Starter
33	10-85486	SCREW, (.250-20 x .380) Stainless Steel, STARTER SOLENOID
34	8-32,11-26419	NUT, Brass, SOLENOID TERMINAL
35	13-26992	LOCKWASHER, (.250) Stainless Steel, SOLENOID TERMINAL
36	11-94330	NUT, (.250-20) Brass, SOLENOID TERMINAL
37	85-97861	INSULATOR, STARTER SOLENOID
38	54-8M0024808	J CLIP, PUMP WIRE
39	8M0084613	C WASHER, CLIP SCREW
40	10-69079	SCREW, (#10-16 x .440), CLIP TO TRANSOM BRACKET
41	17-878267	PIN, Groove, TRIM CYLINDER (LOWER)
42	10-4000377	SCREW, (M10 x 30), MANIFOLD
43	13-400258	LOCKWASHER, (M10) Stainless Steel, MANIFOLD SCREW

▶Power Trim Pump(Eaton Rectangular Motor) (9 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP AND MOTOR
1	12659	FRAME AND FIELD KIT
2	12665	SPRING KIT, Brush
3	13506	BRUSH CARD KIT
4	12662	PUMP AND END FRAME KIT
5	126631	SEAL KIT, Pump
6	12660	END FRAME KIT
7	12661	ARMATURE KIT
8	12664	THRU BOLT KIT

▶Power Trim Pump(Prestolite Round Motor) (13 parts)

Ref	OEM Part #	Part Name
-	826729A10	PUMP ASSEMBLY, Power Trim
1	826729A10	PUMP ASSEMBLY
2	392-8996	O-RING KIT
3	392-8986	ARMATURE
4	392-8987	FRAME AND FIELD
5	392-8992	O-RING, HEAD
6	392-8993	SPRING KIT, BRUSH
7	392-8988	HEAD, COMMUTATOR END
8	392-8989	BRUSH KIT
9	392-8994	THRU BOLT KIT
10	392-8985	CLAMP, LEAD WIRE
11	392-8990	NUT, PACKING
12	392-8991	O-RING, PACKING NUT

▶STARTER MOTOR ASSEMBLY (14 parts)

Ref	OEM Part #	Part Name
-	50-898265010	STARTER MOTOR ASSEMBLY
1	90644	DRIVE KIT
2	685753	DRIVE ASSEMBLY
3	75660	PLATE, DRIVE END
4	10-74968	BOLT, THRU
6	74964	ARMATURE
7	898265016	BRUSH/SPRING KIT
8	23-57387	BUSHING, INSULATING
9	12-38013	WASHER, INPUT STUD
10	13-26992	LOCKWASHER, (.250) Stainless Steel, INPUT STUD
11	11-20890	NUT, (.250-20), INPUT STUD
12	898265014	HOLDER, BRUSH
13	10-68586	SCREW, BRUSH AND HOLDER
14	15386001	END CAP, COMMUTATOR

▶SWITCH BOX AND STARTER SOLENOID (23 parts)

Ref	OEM Part #	Part Name
1	89748T	PLATE, ELECTRICAL MOUNTING
2	10-455611	SCREW, (.250-20 x 1.12), PLATE TO CYLINDER BLOCK
3	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
4	87-33386A3	SWITCH ASSEMLBY, MERCURY
5	10-25764	SCREW, (.190-32 x .50), MERCURY SWITCH TO PLATE
6	10-32,11-45076	NUT, Brass
7	8M0058226	RECTIFIER
8	10-25764	SCREW, (.190-32 x .50), RECTIFIER TO IGNITION PLATE
9	10-32,11-45076	NUT, Brass, RECTIFIER TERMINALS
10	89-8M0185149	SOLENOID ASSEMBLY, Starter
12	8-32,11-26419	NUT, Brass, SOLENOID TERMINALS
13	13-26992	LOCKWASHER, (.250) Stainless Steel, SOLENOID TERMINALS
14	11-94330	NUT, (.250-20) Brass, SOLENOID TERMINALS
15	10-28635	SCREW, (.250-20 x .620) Stainless Steel, STARTER SOLENOID TO PLATE
16	13-26992	LOCKWASHER, (.250) Stainless Steel
17	85-97861	INSULATOR, STARTER SOLENOID
18	332-7778A12	SWITCHBOX ASSEMBLY
19	10-20619	SCREW, (#12-24 x 1.25), SWITCH BOX
21	84-60871A10	WIRE ASSEMBLY, SWITCH BOX
22	10-69079	SCREW, (#10-16 x .440), WIRE
23	84-62310A3	CABLE ASSEMBLY
24	10-32,11-45076	NUT, Brass
25	23-94304	SPACER

▶SWIVEL BRACKET AND STEERING ARM (49 parts)

Ref	OEM Part #	Part Name
-	41760A2	REPAIR KIT, Shock Absorber
1	1499-8710T21	SWIVEL BRACKET ASSEMBLY Comment: (GRAY)
2	26-87735	SEAL, Oil, LOWER
3	23-818764	BUSHING, LOWER AND UPPER
4	25-33466	O-RING, UPPER
5	23-67668	SPACER, UPPER
6	22-8M0169589	FITTING, Grease
7	23-821207	BUSHING
8	99661A2	SWIVEL PIN ASSEMBLY
9	10-99621	SCREW, (.437-20 x 6.620)
10	75296	MOUNT, RUBBER - UPPER
11	12-47840	WASHER
12	12-31263	WASHER
13	11-8M0204653	NUT, (.437-20) Stainless Steel
14	92876A12	LINK ASSEMBLY, Steering
15	10-849838	SCREW, (.375-24 x 1.25)
16	11-8M0204726	NUT, (.375-24)
17	12-34931	WASHER, (.406 x .734 x .063) Stainless Steel
18	13-78854	WAVE WASHER, BOTTOM YOKE
19	99644F2	YOKE, Bottom Comment: (GRAY)
20	53-67684	RING, Retaining
21	12-67670	WASHER, THRUST
22	14664A2	LOCK, Reverse
23	11-82670911	NUT, (.312-24) Stainless Steel Comment: (NON-POWER TRIM)
24	996361	YOKE Comment: (NON-POWER TRIM)
25	24-44297	SPRING Comment: (NON-POWER TRIM)
26	12-8M0042642	WASHER, (.323 x .563 x .063) Stainless Steel Comment: (NON-POWER TRIM)
27	43414	PUSH ROD (LONG SHAFT) Comment: (NON-POWER TRIM)
28	92704	GUIDE, PUSH ROD Comment: (NON-POWER TRIM)
29	23-69132	BUSHING, REVERSE LOCK SHAFT Comment: (NON-POWER TRIM)
30	17-99663	PIN, Clevis, REVERSE LOCK Comment: (NON-POWER TRIM)
31	18-25191	COTTER PIN, CLEVIS PIN Comment: (NON-POWER TRIM)
32	24-996261	SPRING, REVERSE LOCK Comment: (NON-POWER TRIM)
33	18-47959	COTTER PIN Comment: (NON-POWER TRIM)
34	99606	SHAFT, REVERSE LOCK Comment: (NON-POWER TRIM)
35	18-45882	COTTER PIN, SHAFT Comment: (NON-POWER TRIM)
36	99653	BRACKET, SHOCK ABSORBER Comment: (NON-POWER TRIM)
37	99619	SHAFT, SHOCK ABSORBER (LOWER) Comment: (NON-POWER TRIM)
38	17-821539	PIN, Groove, SHOCK ABSORBER Comment: (NON-POWER TRIM)
39	10-4000377	SCREW, (M10 x 30), BRACKET Comment: (NON-POWER TRIM)
40	13-400258	LOCKWASHER, (M10) Stainless Steel Comment: (NON-POWER TRIM)
41	97-818298Q1	ANODE ASSEMBLY
42	10-4000332	SCREW, (M6 x 35), ANODE
43	12-8M0204649	WASHER, (.281 x .500 x .060) Stainless Steel
44	55-99724T15	SHOCK ABSORBER Comment: (GRAY)(NON-POWER TRIM)
45	23-821207	BUSHING, SHOCK ABSORBER Comment: (NON-POWER TRIM)
46	99625002	SHAFT, SHOCK ABSORBER (UPPER) Comment: (NON-POWER TRIM)
47	28203	BUMPER, TOP YOKE
48	10-64014	SCREW, (.250-28 x .500), SWIVEL BRACKET

▶Service/Support Material (1 parts)

Ref	OEM Part #	Part Name
-	37-87132A87	DECAL SET Comment: (115)(GRAY)

▶TACHOMETER (6 parts)

Ref	OEM Part #	Part Name
1	79-895283Q45	TACHOMETER Comment: (7K)
2	79101T	BRACKET, MOUNTING
3	88-72729	LIGHT BULB, Wedge Base (14V - .19W)
4	88-79888	SOCKET, Light Bulb
5	8-32,11-26419	NUT, Brass
6	84-86396A8	HARNESS ASSEMBLY, Tachometer (5.00 Feet)

▶THROTTLE LEVER AND LINK RODS (40 parts)

Ref	OEM Part #	Part Name
1	79900	LEVER, THROTTLE
2	10-818165	SCREW, (.375-16 x 1.75) Comment: (USE W/O NUT)
3	12-68410	WASHER Comment: (USE W/O NUT)
4	11-8M0204726	NUT, (.375-24)
5	23-45818	BUSHING, THROTTLE LEVER SCREW
6	37587	SWIVEL, THROTTLE LEVER TO THROTTLE CABLE
7	11-8M0207775	NUT, (1/4-28X7/32), THROTTLE CABLE TO SWIVEL
8	10-75168	SCREW, ADJUSTING - THROTTLE LEVER
9	11-29598	NUT, (.250-28) Stainless Steel, ADJUSTING SCREW
10	52023	CAP, NYLON - ADJUSTING SCREW
11	77013A1	SWIVEL, THROTTLE LEVER
12	23-26856	BUSHING, SWIVEL
13	12-73288	WASHER, SWIVEL
14	13-29402	WAVE WASHER, SWIVEL
15	11-45774	NUT, SWIVEL TO THROTTLE LEVER
16	85300	LINK ROD, THROTTLE
17	23-74213	BARREL, LINK ROD TO THROTTLE CAM
18	88754	CAM, Throttle Comment: (115)
19	85082	HOUSING, THROTTLE - UPPER
20	24-95721	SPRING, TORSION - SHAFT
21	12-85303	WASHER, PLASTIC - THROTTLE CAM
22	79903F1	HOUSING, THROTTLE - LOWER
23	13-86498	WAVE WASHER, SHAFT
24	87937	SHAFT, THROTTLE AND SPARK ADVANCE
25	10-28239	SCREW, (.250-20 x 2.50), THROTTLE HOUSING
26	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel, THROTTLE HOUSING SCREW
27	11-8267088	NUT, (.250-20), THROTTLE HOUSING SCREW
28	10-75168	SCREW, ADJUSTING - LOWER HOUSING (2-1/4")
29	11-29598	NUT, (.250-28) Stainless Steel, ADJUSTING SCREW
30	52023	CAP, NYLON - ADJUSTING SCREW
31	10-60464	SCREW, ADJUSTING - LOWER HOUSING (2-1/8")
32	10-32,11-68219	NUT, Stainless Steel, ADJUSTING SCREW
33	48039	CAP, NYLON - ADJUSTING SCREW
34	77013A1	SWIVEL, SPARK LINK
35	23-26856	BUSHING, SWIVEL
36	13-29402	WAVE WASHER, SWIVEL
37	12-73288	WASHER, SWIVEL
38	11-45774	NUT, SWIVEL
39	85301	SPARK LINK
40	74897T	PIVOT, SPARK LINK TO TRIGGER

▶TOP COWL AND SUPPORT BRACKETS (40 parts)

Ref	OEM Part #	Part Name
1	2162-6392T6	TOP COWL ASSEMBLY Comment: (GRAY)
2	76440	RETAINER ASSEMBLY Comment: (GRAY)
3	10-25299	SCREW, (.312-18 x .75) Comment: (GRAY)
4	13-39107	LOCKWASHER, (.312-24)
5	76433	SHIELD, REAR Comment: (GRAY)
6	10-48409	SCREW, (#10-16 x .625) Stainless Steel, SHIELD TO TOP COWL
7	47341A11	ROPE AND HANDLE KIT, Manual/Emergency Start, STARTER (FOR MANUAL STARTING ONLY)
8	52739	HINGE, COWL LATCH - TOP COWL
9	94918F1	LEVER, COWL LATCH HINGE
10	17-58998	PIN, COWL LATCH LEVER TO HINGE
11	55455	HOOK, TOP COWL LATCH - REAR
12	10-22956	SCREW, (.250-28 x .880), REAR HOOK TO TOP COWL
13	13-26992	LOCKWASHER, (.250) Stainless Steel
14	79897A4	FRAME, TOP COWL SUPPORT
15	46096	MOUNT, RUBBER - TOP COWL FRAME Comment: (HEAVY DUTY)
16	11-8M0207775	NUT, (1/4-28X7/32), RUBBER MOUNT
17	86472	BRACKET, TOP COWL SUPPORT - REAR
18	31014	MOUNT, RUBBER - REAR SUPPORT BRACKET
19	13-26992	LOCKWASHER, (.250) Stainless Steel, RUBBER MOUNT
20	11-29598	NUT, (.250-28) Stainless Steel
21	10-37562	SCREW, (.312-18 x 1.00) Stainless Steel, REAR BRACKET TO FRAME
22	13-8M0204647	LOCKWASHER, (.312)
23	10-37562	SCREW, (.312-18 x 1.00) Stainless Steel, REAR BRACKET TO BOTTOM COWL
24	13-8M0204647	LOCKWASHER, (.312)
25	42706A1	BRACKET ASSEMBLY, TOP COWL - FRONT
26	10-60411	SCREW, (1.25), FRONT BRACKET TO BOTTOM COWL
27	13-8M0204647	LOCKWASHER, (.312)
28	10-60411	SCREW, (1.25), FRONT BRACKET TO TOP COWL FRAME
29	13-8M0204647	LOCKWASHER, (.312)
30	37640	MOUNT, RUBBER - FRONT SUPPORT BRACKET
31	13-8M0204647	LOCKWASHER, (.312)
32	11-28770	NUT, (.312-24) Stainless Steel
33	87991	POINTER, TIMING
34	10-28636	SCREW, (.250-20 x .750), TIMING POINTER
35	12-35462	WASHER, (.2656 x .625 x .0625) Stainless Steel
36	87076A4	IDLE SPEED CONTROL ASSEMBLY Comment: (115)
37	10-24637	SCREW, (#10-32 x .875), IDLE SPEED CONTROL ATTACHING Comment: (115)
38	10-32,11-20110	NUT, Comment: (115)
39	12-38833	WASHER Comment: (115)
40	54-47483	J CLIP, FRONT COWL SUPPORT

▶TRANSOM BRACKET (21 parts)

Ref	OEM Part #	Part Name
1	3401-8718F8	BRACKET ASSEMBLY, Transom (STARBOARD) Comment: MARINER
2	3400-8716A9	BRACKET ASSEMBLY, Transom (PORT) Comment: MARINER
3	22-8M0169588	FITTING, Grease, PORT TRANSOM BRACKET
4	17-8M0026068	PIN ASSEMBLY, Tilt Lock (NON-POWER TRIM)
5	99170A2	TILT TUBE
6	11-859133	NUT, (1.00-14), TILT TUBE
7	25-45711	O-RING, (.612 x .103), TILT TUBE
8	13-88750	WASHER, TILT TUBE
9	11-858869	NUT, (.875-14), TILT TUBE
10	10-8M0149747	SCREW, (.500-20 x 4.500), TRANSOM BRACKET TO TRANSOM
11	12-8M0204648	WASHER, (1.5 x 3.05 x 0.13) Stainless Steel, TRANSOM BRACKET BOLT
12	11-91962	NUT, (.500-20), TRANSOM BRACKET BOLT
13	8M0115104	LEVER ASSEMBLY, TILT LOCK
14	13-99611	WAVE WASHER, TILT LEVER
15	23-65830	NYLINER, TILT LEVER
16	99633	KNOB, TILT LOCK LEVER Comment: (MARINER)
17	17-99615	PIN, Groove
18	24-99622	SPRING
19	17-99604	PIN, Groove
20	10-96930A1	BOLT ASSEMBLY, TILT LOCK
21	11-23161	NUT, (.375-24)

▶WIRING HARNESS AND IGNITION COIL (25 parts)

Ref	OEM Part #	Part Name
1	339-832757A4	COIL ASSEMBLY, Ignition
2	43542	COVER, IGNITION COIL
3	10-88856	SCREW, (.190-32 x 2.00), IGNITION COIL COVER
4	10-32,11-45076	NUT, Brass, IGNITION COIL TERMINAL
5	84-88807A13	CABLE ASSEMBLY, IGNITION COIL (BLACK - 5-1/4")
6	84-813715A10	CABLE ASSEMBLY, HIGH TENSION
7	85-63709A1	BOOT/TERMINAL KIT, SPARK PLUG END
8	33-14103550	SPARK PLUG, (NGK-BUZHW) (CANADA/BELGIUM)
9	84-85537A1	HARNESS ASSEMBLY, COIL TO SWITCH BOX (#1, 3 AND 5)
11	84-96188A4	HARNESS ASSEMBLY
12	88-8M0207796	FUSE, 20 Ampere
13	84-95084A2	CABLE ASSEMBLY, FUSE HOLDER
14	54-88608	CLAMP, WIRING HARNESS
15	10-28636	SCREW, (.250-20 x .750), WIRING HARNESS CLAMP
16	10,13-26996	LOCKWASHER, Stainless Steel
17	89047	BRACKET, WIRING HARNESS
18	10-24637	SCREW, (#10-32 x .875), WIRING HARNESS BRACKET
19	12-38833	WASHER
20	10-32,11-20110	NUT,
21	88751	CLAMP, WIRING HARNESS
22	10-28636	SCREW, (.250-20 x .750), WIRING HARNESS CLAMP
23	12-20533	WASHER
24	84-88439A4	CABLE ASSEMBLY, Battery - Negative
25	12-30164	WASHER, (.192 x .375 x .0312) Stainless Steel
26	134731	HOLDER, Fuse

100-Hour / Annual Service Checklist

Regular maintenance keeps your Mercury 90 (6 CYL.) running reliably season after season. Most of these tasks can be performed with basic tools and the factory service manual.

Replace water pump impeller and inspect wear plate
Change engine oil and oil filter (check drain plug washer)
Replace spark plugs and check ignition timing
Drain and refill lower unit gear oil; inspect for water contamination
Inspect fuel lines, primer bulb, and fuel filter for deterioration
Check and replace sacrificial anodes (zinc or aluminum)
Inspect propeller for damage; check shaft seal and cotter pin
Check valve clearance (refer to service manual for specifications)
Lubricate all grease points (steering, tilt tube, shift linkage)
Inspect control cables and throttle/shift linkage for smooth operation

Pro Tip: Always flush the engine with fresh water after saltwater use — even a quick 10-minute flush significantly extends component life.
Pro Tip: Use fuel stabilizer in the tank before winter storage, and fog the cylinders to prevent internal corrosion during extended periods of non-use.

Недавно просмотренные продукты

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Example product title

$19.99; $19.99
Unit price: per

Popular Products

Popular Products

Popular Products

Mercury 90 (6 CYL.) (6436123 & Up) Parts & Diagrams

Категории

Refined By Clear all

Бренд

Лошадиная сила

Двигатель

Доступность

Цена

Нужна помощь?

Images

Product

Price

Qty

Options

Mercury 90 (6 CYL.) (6436123 & Up) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Недавно просмотренные продукты

Popular Products

Popular Products

Popular Products

Mercury 90 (6 CYL.) (6436123 & Up) Parts & Diagrams

Категории

Refined By Clear all

Бренд

Лошадиная сила

Двигатель

Доступность

Цена

Нужна помощь?

Images

Product

Price

Qty

Options

Mercury 90 (6 CYL.) (6436123 & Up) Parts & Diagrams

Quick Reference Specifications

Common Issues & Recommended Parts

Parts Diagrams & OEM Part Numbers

100-Hour / Annual Service Checklist

Недавно просмотренные продукты

Shop the look

Choose Options

Recently Viewed

Edit Option

Back In Stock Notification

Choose Options

Popular Products